2011 Ford Explorer complaints

I PURCHASED A "CERTIFIED" USED 2011 EXPLORER BASE WITH 3500 MILES IN MARCH 2014 FROM FORD DEALER. AIR BAG LIGHT ILLUMINATED IN MAY AND STAYED ON STEADY...DEALER REPLACED MASTER MODULE (UNDER WARRANTY) AFTER A WEEK OF WORKING ON THE VEHICLE. AT THE TIME, THEY TOLD ME WHEN THE LIGHT WAS ON, IT INDICATED THE AIR BAGS WOULD NOT DEPLOY IN A CRASH AND THEY WOULD NOT LET ME HAVE THE VEHICLE BACK WHILE THEY WAITED FOR THE PART, A CLEAR INDICATION OF HOW SERIOUS THEY CONSIDERED THE PROBLEM. LIGHT HAS COME BACK ON THREE MORE TIMES SINCE (EVERY 6-8 WEEKS). EACH TIME SINCE, DEALER HAS "GREASED" ELECTRICAL CONNECTIONS WHICH CAUSES THE LIGHT TO GO OFF ONLY TEMPORARILY. WHEN THE LIGHT COMES BACK ON, WE ARE USUALLY DRIVING ON THE HIGHWAY AND NOT PROTECTED BY THIS CRITICAL SAFETY SYSTEM. ASIDE FROM THE EXTREMELY UNSAFE CONDITION THIS POSES TO MY FAMILY, IT IS BECOMING MORE AND MORE DIFFICULT TO BRING THE CAR BACK TO THE DEALER EVERY SEVERAL WEEKS TO HAVE THEM ONLY TEMPORARILY FIX THE ISSUE. BASED ON OTHER SIMILAR COMPLAINTS, I EXPECT THIS WILL CONTINUE FOR ME UNTIL THE WARRANTY EXPIRES AND I CAN'T AFFORD TO FIX THE PROBLEM ANY LONGER. I APPROACHED THE DEALER'S GENERAL MANAGER AND MY REGIONAL FORD REP ABOUT BUYING THE VEHICLE BACK BUT THEY BOTH TOLD ME THEY WOULD ONLY GIVE ME WHAT THE VEHICLE WAS WORTH (WHICH WOULD PUT ME IN A LARGE FINANCIAL HOLE)... *JS

WHEN PARKED IN A PARKING GARAGE I STARTED OUT AND OF MY SPOT AND DOWN A RAMP TOWARD THE PAY STATION/BOOTH OF THE GARAGE TO EXIT. THE POWER STEERING ASSIST FAULT CAME ON, I IMMEDIATELY LOST POWER STEERING AND WAS HEADED DIRECTLY TOWARD THE PAY BOOTH/ATTENDANT UNTIL I WAS ABLE TO BRAKE AND MUSCLE THE STEERING AWAY FROM THE IMPENDING CRASH. THIS POWER STEERING ISSUE HAS STARTED TO OCCUR BRIEFLY OVER THE LAST FEW 6 MONTHS AND EITHER RESOLVES ITSELF OR IF I STOP, SHUT OFF, THEN RESTART IT SEEMS TO RESET. THE ELECTRONIC POWER STEERING SEEMS TO BE AT FAULT. I CAN ONLY IMAGINE LOSING THIS AT HIGHWAY SPEEDS AND THE DANGER IT POSES TO DRIVERS. *JS

AFTER BRINGING MY CAR IN ON 9/15/14 TO ADDRESS THE FORD EXPLORER 2011 RECALL, SHEEHY FORD IN SPRINGFIELD, VA DECLARED MY PARTS OK AND REPROGRAMMED MY PSCM (I HAD NEVER HAD A SINGLE ISSUE WITH MY POWER STEERING)...I SUBSEQUENTLY DROVE TO KENTUCKY (FROM BURKE, VA) AND SEVERAL OTHER PLACES...EVENTUALLY DRIVING TO MY PARENT'S HOUSE IN VIENNA, VA (ABOUT 30+ MINUTES AWAY) FOR THANKSGIVING DAY (12/27/14), JUST 3 MONTHS LATER. SEVERAL STREETS FROM ARRIVAL I RECEIVED A MESSAGE THAT MY POWER STEERING WAS FAILING. THE CAR BECAME VERY DIFFICULT TO DRIVE, BUT I WAS ABLE TO PARK THE CAR IN FRONT OF THEIR HOUSE. AFTER RESEARCH ON THE INTERNET, I HOPED TO BE ABLE TO START THE CAR AND FIND THE PROBLEM FIXED, BUT UNFORTUNATELY WAS NOT ABLE TO STEER THE CAR AT ALL. I HAD TO HAVE THE CAR TOWED THE NEXT DAY TO A DEALER (I DID NOT CHOOSE THE SAME DEALER WHO HAD DONE THE RECALL). THEY REPLACED THE POWER STEERING PARTS SEVERAL DAYS LATER, BUT THE PARTS WERE NOT COVERED UNDER THE RECALL BECAUSE THE CODE THEY RECEIVED WAS DIFFERENT. THIS HAPPENED 3 MONTHS AFTER THEY DECLARED MY PARTS OK! I ONLY HAD TO PAY $100 FOR THE FIX BECAUSE OF MY EXTENDED WARRANTY, BUT AM ILL ABOUT WHAT MIGHT HAVE HAPPENED IF I HAD BEEN ON MY WAY TO OR FROM KENTUCKY WHEN THE POWER STEERING FAILURE HAPPENED SO I FEEL OBLIGATED TO REPORT MY ISSUE TO YOU. I UNDERSTAND FROM PRESS RELEASES I'VE SEEN THAT YOU CONSIDER THIS ISSUE CLOSED. I DO NOT BELIEVE THAT TO BE THE CASE... *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SHOOK AND TRACTION CONTROL WARNING LIGHT ILLUMINATED. IN ADDITION, THE STEERING WHEEL SEIZED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE STEERING CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

WE WERE DRIVING THE VEHICLE AT APPROXIMATELY 35 MPH WHEN WARNING LIGHT CAME ON STATING THERE WAS ISSUE WITH POWER STEERING, I BELIEVE IT SAID POWER STEERING SERVICE WAS REQUIRED. WHEN WE STOPPED AT NEXT INTERSECTION, IT WAS EVIDENT POWER STEERING ASSISTANCE WAS REDUCED. AFTER PULLING OVER AND SHUTTING OFF VEHICLE, THEN RESTARTING, THERE WAS NO POWER STEERING ASSISTANCE, ONLY MANUAL. WHEN TRAVELING AT LOW SPEED, TURNING WAS VIRTUALLY IMPOSSIBLE. IMMEDIATELY AFTER STOPPING, BECAUSE WHEELS COULD NOT BE STEERED, VEHICLE WENT STRAIGHT, BLOCKING A CROSS PATH IN A COMMERCIAL LOT, WITH CROSS TRAFFIC NEARLY CAUSING COLLISION, ALTHOUGH NO COLLISION OCCURRED, THERE WAS CLEAR DANGER. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED, THE TECHNICIAN DISCOVERED THAT THE ELECTRICAL PUMP FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE ACCELERATED INDEPENDENTLY, CAUSING THE CONTACT TO CRASH INTO A GARAGE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. NO REPAIRS WERE MADE TO THE VEHICLE. THE CONTACT ALSO STATED THAT WHILE ACCELERATING, THE ENGINE RPMS WOULD INCREASE RAPIDLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE WAS 23,500.

2011 FORD EXPLORER LIMITED: I WAS DRIVING MY FAMILY BACK FROM A VACATION AND HAD BEEN TRAVELING AT AN APPROXIMATE SPEED OF 65 MPH ON THE HWY. I TURNED INTO A PARKING LOT FOR A RESTROOM BREAK FOR THE KIDS WHEN THE RACK & PINION BAR BROKE COMPLETELY NEAR THE DRIVER SIDE FRONT WHEEL. I NOTICED THE CHIMES, SOME LOUD POPS AND HARDER THAN NORMAL STEERING PRIOR TO THE PART BREAKING. VEHICLE WAS UNABLE TO BE STEERED. IT IS NOT A EVERY DAY DRIVEN VEHICLE. VEHICLE HAS 42,608 MILES ON IT. LUCKILY WE WEREN'T TRAVELING AT 65 MPH WHEN THE PART FAILED. *TR

REFERENCING PREVIOUS COMPLAINT FOR SAME ISSUE SEE TCN JEN28-49151 TRAVELING TO DINNER AT 7:00PM AGAIN POWERTRAIN WARNING LIGHT CAME ON, ENGINE RAN ROUGH AND SPEED DROPPED TO APPROX. 1 MPH. PULLED OFF SIDE OF ROAD, TURNED OFF CAR. RESTARTED AND CONTINUED ON MY WAY. SAME THING OCCURRED AGAIN THIS MORNING 11/14/14 AT APPROX. 7:15 AM ON WAY TO WORK. THIS TIME THANKFULLY I WAS NOT ON THE CAUSEWAY WHERE TRAFFIC MOVES AT APP 50 - 60 MPH AS I WAS THE FIRST TIME THIS OCCURRED. WHEN THIS HAPPENED TWICE IN OCTOBER I TOOK MY CAR TO THE DEALERSHIP BOTH TIMES AND THEY COULD FIND NOTHING WRONG. THIS CONTINUES TO HAPPEN AND I AM AFRAID THAT ONE DAY MY CAR WILL MALFUNCTION LIKE THIS ON A BUSY ROAD AT A HIGHER SPEED. I WAS LUCKY THE FIRST TIME ON THE CAUSEWAY THAT I MADE IT UP THE BRIDGE TO COAST DOWN ON TO THE GRASS WITHOUT CAUSING AN ACCIDENT. *TR

ON CRUISE CONTROL AT 75MPH HEADING EAST ON I-44 TOWARDS TULSA, OK. POWER STEERING SERVICE WARNING, ADVANCE TRAK WARNING, TERRAIN MANAGEMENT WARNING BECOME ACTIVE. POWER STEERING ADVANCE TRAK AND TERRAIN MANAGEMENT NO LONGER ACTIVE. *TR

WHEN FILLING THE GAS TANK THE GAS NOZZLE WOULD SHUT OFF. EVEN WHEN I WAS VERY SLOWLY PUMPING IN GAS , THE PUMP WOULD SHUT OFF VERY MUCH LIKE A TANK INDICATING IT WAS FULL WHICH I KNOW WAS NOT THE CASE. THEN GAS WOULD DRIP/STREAM (NUMEROUS DRIPS AND STREAMS)) UNDER THE VEHICLE CREATING A BASKETBALL SIZE GAS SPOT. UPON SERVICE AT THE DEALER I WAS TOLD THE TANK VENT TUBE WAS BLOCKED BY COBWEBS. DRIVING FOR OVER 50 YEARS , I HAVE NEVER HEARD OF SUCH A THING. *TR

I WAS DRIVING MY 2011 FORD EXPLORER ON THE CAUSEWAY- HEAVY TRAFFIC MOVING AT ABOUT 50 - 55 MPH. APPROACHING FIRST BRIDGE INCLINE, SPEED DROPPED TO APPROX 1 MPH CREEPING ALONG, ACCELERATOR PRESSED TO FLOORBOARD. ORANGE WRENCH ICON APPEARED ON INSTRUMENT PANEL. PUT ON HAZARDS TO NOTIFY TRAFFIC. CARS PULLING AROUND TRYING TO AVOID HITTING MY VEHICLE. NOT ENOUGH ROOM ON EMERGENCY LANE OF BRIDGE TO PULL COMPLETELY OUT OF TRAFFIC LANE - MADE IT TO TOP OF BRIDGE - COASTED DOWN HALF WAY IN EMERGENCY LANE AND LEFT LANE UNTIL REACHED BOTTOM OF BRIDGE AND COULD PULL OVER TO GRASSY SIDE OF ROAD. TURNED VEHICLE OFF. WAITED, THEN RESTARTED VEHICLE. DROVE DIRECTLY TO FORD DEALER WHO HOOKED IT UP TO COMPUTER AND FOUND NOTHING WRONG. THEY TEST DROVE IT, THEN CALLED TO SAY THEY COULD FIND NOTHING. I ASKED THEM TO SERVICE THE CAR AS IT WAS TIME. THEY KEPT THE CAR OVER THE WEEKEND TO SERVICE IT ON MONDAY 10/27/14 AND TESTED THE SYSTEM ONE MORE TIME- STILL FOUND NOTHING WRONG. I PICKED THE CAR UP 10/27/14 AND LEFT DEALERSHIP AT ABOUT 1230 AND BY ABOUT 1245 THE SAME THING HAPPENED AGAIN- NO ACCELERATION - JUST ABOUT 1 MILE AN HOUR AND VEHICLE RUNNING SLIGHTLY ROUGH- WRENCH APPEARED AGAIN. I PULLED OVER IN TO A PARKING LOT, TURNED THE ENGINE OFF; RESTARTED AND DROVE BACK TO THE DEALERSHIP. THIS TIME THEY RAN A DIFFERENT COMPUTER CHECK AND GOT A CODE THAT SUGGESTED BRAKES AND ACCELERATOR DEPRESSED AT SAME TIME. NO, I DO NOT TRY TO BRAKE AND ACCELERATE AT THE SAME TIME. THE SERVICE DEPARTMENT DROVE M

DRIVING AT HIGHWAY SPEED, ALL STEERING WAS LOST WITH FAMILY IN VEHICLE. NO PROBLEMS HAD OCCURRED WITH THE VEHICLE STEERING UNTIL A FLASH UPDATE HAD BEEN COMPLETED BY DEALER FOR THE RECAL NOTICE. AS OTHERS THIS OCCURRED OVER A WEEKEND AND WE WERE NOT HOME FELT WE COULD NOT DRIVE EVEN AFTER SHUTTING DOWN, RE STARTING AND ERROR CLEARED. RENTED A VEHICLE OURSELVES UNTIL MONDAY WHEN THE DEALER PROVIDED A RENTAL. AFTER BEING IN THE SHOP FOR A WEEK WAS NOTIFIED THAT FORD WOULD DO NOTHING ABOUT THE ISSUE AS THEY ASSUME NO LIABILITY AFTER THE FLASH WAS COMPLETED! OUR DEALER STEPPED UP AND PAID FOR EVERYTHING. THEY SHOULD NOT HAVE TO DO THIS AND AS AN INSURANCE PROFESSIONAL VIEW THIS AS A MAJOR LIABILITY AND IF THIS IS NOT CORRECT ASAP SOMEONE OR MANY WILL BE KILLED! WHY IS THIS SO,HARD TO ENFORCE BASED ON THE NUMBER OF CLAIMS FOR THIS FAILURE? EVEN NOW WITH WHAT MIGHT BE THE CORRECT REPAIRS AND BASED ON OTHERS WHO HAVE DONE THE SAME WHAT ASSURANCE DO ANY OF US HAVE? *TR

THE POWER STEERING FAILED WHILE I WAS DRIVING SOUTH ON I-75. THE RECALL FOR THE MODULE (REPROGRAMMING) HAD ALREADY BEEN PERFORMED LESS THAN 2 MONTHS BEFORE. NOW, AFTER HAVING THE CAR IN THE SHOP FOR A WEEK AND 2 DAYS, FORD HAS AGREED TO PAY ALL BUT $700 OF THE REPAIR. THE REPROGRAMMING OBVIOUSLY WAS NOT AN EFFECTIVE SOLUTION SINCE THE POWER STEERING FAILED A SHORT TIME AFTER THAT WAS DONE. THE CAR IS NOT SAFE TO DRIVE. THE STEERING WENT OUT WITHOUT NOTICE AS I WAS TRAVELING 70 MPH ON AN INTERSTATE HIGHWAY. I WAS EVENTUALLY ABLE TO MUSCLE IT OVER TO THE RIGHT LANE AND GET TO AN EXIT WITHOUT GETTING INTO A CRASH, BUT THAT WAS PURE LUCK. THE TRAFFIC WAS VERY HEAVY AND I DIDN'T WANT TO MAKE ANY HASTY MOVES BECAUSE I WASN'T SURE WHAT WAS GOING ON. IT WAS A VERY SCARY SITUATION. FORD HAS ADMITTED THAT THIS IS A PROBLEM, NOW THEY NEED TO FIX IT. *TR

I HAVE A 2011 FORD EXPLORER XLT. THE THROTTLE BODY HAS RECENTLY GONE BAD AND IS STAYING STUCK IN THE OPEN POSITION. THE DEALERSHIP SAYS IT HAS TO BE REPLACED. IT IS AN OBVIOUS SAFETY HAZARD FOR IT TO GET STUCK WHEN GOING AT A HIGH RATE OF SPEED OR EVEN A SLOWER RATE FOR THAT MATTER. THE THROTTLE BODIES WERE A BIG ISSUE FOR THE FORD ESCAPES IN THE PAST SO FORD EXTENDED THE WARRANTY FOR THEM, UNFORTUNATELY IT DOESN'T APPLY TO THE EXPLORER ALTHOUGH IT THE EXACT SAME PROBLEM. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING IN INCLEMENT WEATHER AT AN UNKNOWN SPEED, WATER LEAKED DOWN THE REAR DRIVER AND REAR PASSENGER SEAT BELTS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 22,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHEN THE FUEL TANK WAS FILLED TO CAPACITY, THE FUEL GAUGE INDICATED ONLY A HALF OF A TANK. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AFTER THE FUEL TANK WAS FULL. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER FOR REPAIRS UNDER RECALL NHTSA CAMPAIGN 14V286000(STEERING). THE VEHICLE WAS REPAIRED BUT THE PROBLEM HAS RECURRED. THE VEHICLE WAS TAKEN BACK TO DEALER WHO EXPLAINED THAT THE VEHICLE WAS NO LONGER ELIGIBLE FOR THE RECALL REPAIRS SINCE IT HAD BEEN REPAIRED ONCE BEFORE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. AFTER PARKING THE VEHICLE, THE SHIFT TO PARK WARNING INDICATOR ILLUMINATED. THE DEALER STATED THAT THE SHIFT TO PARK SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.

WHILE DRIVING TO WORK, MY VEHICLE EXPERIENCE AN ISSUE WITH THROTTLE RESPONSE. A WRENCH WARNING LIGHT APPEARED AND THE CHECK ENGINE LIGHT CAME ON. AT THAT POINT, THE VEHICLE BEGAN SHUDDERING AND THE INTERNAL SYSTEMS SLOWED THE VEHICLE TO APPROXIMATELY 5MPH. AFTER STOPPING ON THE SHOULDER OF THE INTERSTATE, I SHUT THE CAR OFF, PULLED THE KEY, REINSERTED THE KEY AND RESTARTED THE VEHICLE. IT STARTED UP NORMALLY, BUT IMMEDIATELY EXHIBITED THE SAME SYMPTOMS. I CHECKED THE OWNER'S MANUAL AND FOUND THAT THE WRENCH WARNING LIGHT INDICATES A "POWERTRAIN FAULT". I CONTACTED FORD ROADSIDE ASSISTANCE AND GOT THE VEHICLE TOWED TO THE NEAREST DEALERSHIP, THINKING THAT A WARNING LIGHT INDICATING A "POWERTRAIN FAULT" WOULD BE COVERED UNDER MY POWERTRAIN WARRANTY. THE DEALERSHIP DIAGNOSED THE PROBLEM AS AN ISSUE WITH THE THROTTLE BODY OF THE VEHICLE, THAT THE THROTTLE BODY IS NOT COVERED UNDER THE POWERTRAIN WARRANTY, AND CHARGED ME OVER $700 TO FIX THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING SEIZED AND EXCESSIVE FORCE WAS REQUIRED TO TURN THE STEERING WHEEL. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING GEARS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14E001000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000...UPDATED 10/07/14 *BF THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 10/10/14

I WAS DRIVING DOWN THE STREET AT AROUND 20 MPH WHEN THERE WERE CARS THAT SUDDENLY STOPPED. WHEN I WAS BRAKING I FELT AS IF THE STEERING WAS ALLOWING ME TO TURN AND IT HAPPENED SO FAST I FELT AS IF I LOST BRAKING POWER. THEN I HIT THE CAR IN FRONT OF ME HARD. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE POWER STEERING AND COMPUTER FAILED. IN ADDITION, THE ENGINE, ABS, TRACTION CONTROL, AIR BAG, AND SECURITY SENSORS ILLUMINATED. THE DEALER ADVISED THE CONTACT TO RESET THE MASTER CONTROLS. THE VEHICLE ALSO EXHIBITED COMPUTER FAILURE. THE FIRMWARE WAS UPDATED MULTIPLE TIMES, HOWEVER THE FAILURE RECURRED MONTHS LATER AND INCLUDED VARIOUS ELECTRICAL SHORTS. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAITED FOR MONTHS TO DETERMINE IF THE DEALER WAS ABLE TO PROVIDE A REMEDY TO THE FIRMWARE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V286000 (STEERING) AND 14E001000 (STEERING). THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

THE VEHICLE WHEN SHIFTED INTO PARK WOULD NOT SHUT OFF, WITH THE VEHICLE NOT SEEING THE SHIFTER IN PARK. ON INSPECTION IN SEPTEMBER 2014, IT WAS DETERMINED THAT THE SHIFT LEVER WAS FAILING, WHICH CAN CAUSE THE VEHICLE TO SLIP OUT OF PARK AND MOVE UNEXPECTEDLY. FORD INDICATED THERE WAS NOT A RECALL ON THIS AT THIS TIME AND WOULD NOT COVER ANY REPAIR WORK FOR THIS SERIOUS SAFETY ISSUE. *TR

MY VEHICLE WAS PARKED IN THE DRIVEWAY, WHERE IT HAD BEEN SINCE THE PREVIOUS DAY. I OPENED THE FRONT DRIVERS SIDE DOOR AND GOT INTO THE CAR. I PUT THE KEYS INTO THE IGNITION SWITCH AND STARTED THE VEHICLE. AT THIS POINT I CLOSED THE DRIVERS SIDE DOOR. AT THIS MOMENT I HEARD A LOUD "POP" SOUND. I LOOKED INTO THE REAR VIEW MIRROR AND SAW A LARGE HOLE IN THE GLASS OF THE UPPER CENTER PORTION OF THE REAR WINDOW. UPON FURTHER INSPECTION THE REMAINING GLASS WAS SHATTERED AND SPIDER WEBBED. THERE WAS GLASS ON THE GROUND OUTSIDE THE VEHICLE AS WELL AS IN THE REAR COMPARTMENT OF THE CAR. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING) BECAUSE THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

STEERING STOP MOVING IN THE MIDDLE OF DRIVING ON THE EXPRESS WAY. HAD TO TURN THE VEHICLE OFF AND THEN RESTART FOR IT TO CONTINUE MOVING. THIS HAPPEN A VIEW TIMES BUT NEVER ON THE EXPRESS WAY. *TR

THIS IS A MAJOR SAFETY CONCERN. WHILE DRIVING AN INDICATION OF A MALFUNCTION IN THE AWD SYSTEM SHOWS ON THE DASHBOARD & SYNC COMPUTER. THE ENGINE LOSES COMPLETE POWER AND YOU MUST PULL OVER AND RESTART THE VEHICLE TO RESET THE ON-BOARD COMPUTER. THIS LOSS OF POWER HAPPENS ON THE HIGHWAY AND IS AT GREAT RISK OF CAUSING SERIOUS ISSUES TO OTHER TRAFFIC. NOT TO MENTION WHEN I HAVE MY CHILD IN THE VEHICLE. I HAVE TAKEN IT TO ROSNER FORD DEALERSHIP IN KING GEORGE VA (THEY COULDN'T FIND A ISSUE 4 FOUR TIMES NOW). IT HAPPENS WITH FREQUENT AND UNREGULAR INTERVALS. I HAVE REPEATEDLY WENT BACK TO THE DEALERSHIP TO FIX. THE FORD MOTOR COMPANY (THROUGH MY EXPERIENCE WITH THE SERVICE DEPT) SEEMS AS IF THEY DON'T CARE EVEN WHEN I EXPRESSED THE SAFETY CONCERN. I BELIEVE THE COMPUTER PROBLEM IS A BIGGER THING THAN REALIZED. HOPEFULLY THIS WILL HELP IN GETTING ADD TO THE COMPLAINT LIST SO FORD WILL FIX THE PROBLEMS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LEFT REAR BRAKE CALIPER FAILED CAUSING VEHICLE TO BECOME UNSTABLE FOR BRIEF SECOND WHEN THE CALIPER GRABBED THE ROTOR WHILE TRAVELING AT HIGHWAY SPEEDS. YOU COULD FEEL THIS IN THE STEERING AND WOULD HAVE TO CORRECT AT EACH DIP OR BUMP IN THE HIGHWAY. BRAKE PAD WORN TO FAILURE POINT BEFORE IDENTIFYING THE PROBLEM. *TR

POWER STEERING STILL FAILING EVEN AFTER RECALL "FIX". MY FORD EXPLORER 2011 ALREADY HAD THE POWER STEERING RECALL (SAFETY RECALL NOTICE 14S06/NHTSA RECALL 14-V-286) FIX COMPLETED AT DEALERSHIP ON 8/7/14, BUT THE POWER STEERING IS STILL FAILING! THIS IS VERY SERIOUS IF THE RECALL "FIX" IS NOT WORKING. PLEASE REQUIRE FORD TO IMMEDIATELY IMPLEMENT THE PROPER FIX AND IMMEDIATELY NOTIFY ALL OWNERS WHO HAVE ALREADY TAKEN THEIR EXPLORERS IN PER THE RECALL AND HAVE THIS ISSUE FIXED IMMEDIATELY. FORD KNOWS ABOUT THIS ISSUE AND COULD BE PUTTING PEOPLE'S LIVES AT RISK. *TR

2011 FORD EXPLORER WAS JUST RETURNED TWO WEEKS AGO FOR NATIONAL RECALL ON ELECTRONIC POWER STEERING CONTROL MODULE FAILURE. ON AUGUST 21ST AT 9:30 AM MY WIFE WAS APPROACHING A RED LIGHT. SHE APPLIED THE BRAKES AND FELT AN IMMEDIATE POWER LOSS ISSUE WITH THE BREAKS. SHE IMPACTED THE VEHICLE IN FRONT OF HER AROUND 15 MPH. AIR BAGS WERE NOT DEPLOYED AT TIME OF ACCIDENT. SHE DID NOTICED THE TERRAIN MANAGEMENT FAILURE LIGHT WAS ILLUMINATED AT TIME OF IMPACT. MY WIFE DID NOT FEEL THE ANTI LOCK BRAKES ENGAGE, NOR WERE THERE ANY SKID MARKS VISIBLE ON THE ROAD. MINOR FRONT END DAMAGE IS EVIDENT AND RADIATOR WAS LEAKING FLUID. INSURANCE COMPANY HAS BEEN NOTIFIED ABOUT RECENT RECALL. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD VEER TO THE RIGHT WITHOUT THE CONTACT MOVING THE STEERING WHEEL. THE DEALER STATED THAT THE RACK AND PINION STEERING MECHANISM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE PART NOT BEING AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 25 MPH, THE SPEEDOMETER AND TURN SIGNALS FAILED TO OPERATE. THE DEALER REPLACED THE COMPUTER AND THE TURN SIGNAL CLUSTER. IN ADDITION, THE BRAKE CALIPERS AND ROTORS FAILED DUE TO INSUFFICIENT LUBRICATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 19,000.

DRIVING DOWN THE ROAD AND REAR WINDOW EXPLODED. *JS

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD JERK VIOLENTLY. IN ADDITION, THE VEHICLE WOULD DECELERATE ON ITS OWN AND FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE DEALER RE-INSTALLED THE SOFTWARE, TRANSMISSION SENSOR, AND SHIFT CONTROL CABLE, BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,652.

MY DAUGHTER AND I WERE DRIVING ABOUT 55 MPH ON A HIGHWAY, AND ALL OF A SUDDEN THE TRUCK LOST POWER. ALL OF A SUDDEN AN ORANGE WRENCH SYMBOL APPEARED ON MY INSTRUMENT PANEL, BUT I HAD NO IDEA WHAT IT MEANT. VERY SCARED, I PUT ON MY HAZARD LIGHTS AND HAD TO MOVE TO THE RIGHT IN 3 LANES OF TRAFFIC!! I WAS SO TERRIFIED A CAR OR TRUCK WAS GOING TO SMASH INTO THE BACK OF OUR VEHICLE. THE TRUCK WAS ONLY ABLE TO GO ABOUT 5 MPH EVEN THOUGH I WAS PUSHING THE GAS PEDAL AS FAR DOWN AS POSSIBLE. WHEN WE FINALLY WERE ABLE TO PULL OVER, I TURNED OFF THE TRUCK. I THEN LOOKED THROUGH THE FORD MANUAL TO TRY AND IDENTIFY THE ORANGE WRENCH SYMBOL, WHICH WAS LIT UP IN MY INSTRUMENT PANEL. IT INDICATED THAT THE VEHICLE HAD A POWER TRAIN MALFUNCTION. AFTER WAITING 15 MINUTES I THEN STARTED THE TRUCK UP, WITH SUCCESS. THE TRUCK SEEMED TO BE WORKING AGAIN AND ODDLY ENOUGH THE ORANGE WARNING SYMBOL HAD DISAPPEARED. THERE WERE NO WARNING SYMBOLS AT ALL ANYMORE. I DROVE IT IMMEDIATELY TO OUR FORD DEALERSHIP. I HAD TO GET A RENTAL BECAUSE THEY WERE SO BUSY AND TOLD ME THEY WOULDN'T BE ABLE TO LOOK AT IT UNTIL THURSDAY. THIS AFTERNOON (24 HRS. LATER) FORD CALLED AND TOLD ME WE NEEDED A NEW THROTTLE BODY PART ($650). THIS TRUCK IS ONLY 3 YEARS OLD!! WE COULD HAVE BEEN SERIOUSLY INJURED. I THANK GOD WE WEREN'T AS THIS IS A VERY ACTIVE HIGHWAY. *TR

AS I WAS MERGING ON TO THE HIGHWAY, I ACCELERATED TO REACH THE SAME SPEED OF THE TRAFFIC. THE ENGINE REVVED OVER 3500 RPM. MY AIR CONDITIONER WAS ON AND SET TO RECIRCULATE THE AIR. SHORTLY AFTER MERGING ONTO THE HIGHWAY, I SMELLED EXHAUST FUMES IN THE CABIN OF MY CAR. *TR

DRIVING DOWN THE INTERSTATE AT 70MPH, WARNING COMES ON THE CONSOLE "AWD IS OFF" AND THE ENGINE IS DOWN TO IDLE SPEED (~800 RPM). PRESSING THE ACCELERATOR RESULTS IN NO SPEED INCREASE, FORCING ME TO MOVE ACROSS 4 LANES OF TRAFFIC TO THE EMERGENCY LANE WITH ONLY THE BRAKES WORKING (NO CONTROL OVER MY SPEED, OTHERWISE). PULLED OVER, STOPPED THE ENGINE, LOOKED AROUND AND COULD SEE NO EXTERNALLY VISIBLE PROBLEMS (FLUID LEAKS, ETC.). START THE CAR AND THERE ARE NO WARNINGS, SO I CONTINUE DOWN THE ROAD, BUT THIS TIME STAY IN THE RIGHT LANE AND KEEP THE SPEED TO AROUND 60. LESS THAN 1 MILE DOWN THE ROAD, THE EXACT SAME THING HAPPENS. AT THIS POINT WE CALL FORD TO GET US A TOW. THIS WAS A VERY DANGEROUS EVENT TO HAPPEN, ESPECIALLY WHEN I HAD THE EXPLORER FULL WITH MY FAMILY! TODAY THE SERVICING DEALER CALLED AND SAID IT IS A PROBLEM WITH THE THROTTLE BODY. BEING THAT THIS IS THE 2ND TIME OUR 2011 EXPLORER HAS LEFT US STRANDED ON THE SIDE OF THE ROAD, IT WAS TIME TO GO SEARCHING FOR OTHERS WITH THIS SAME THROTTLE BODY PROBLEM. TURNS OUT THERE IS A CUSTOMER SATISFACTION NOTICE ALREADY BEING DONE BY FORD FOR SEVERAL OTHER 2011 VEHICLES, BUT THE EXPLORER HAS BEEN EXCLUDED. OUR SYMPTOMS AND PART FAILURE ARE EXACTLY THE SAME AS THESE OTHER MODELS, SOME EVEN FROM THE SAME ASSEMBLY PLANT. I THINK FORD NEEDS TO EXTEND THE 13N03 PROGRAM TO INCLUDED THE EXPLORERS. THANK YOU. *JS

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE FROM THE ROOF RACK. THE VEHICLE WAS NOT TAKEN INTO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 85,000.

I WAS MAKING A RIGHT HAND TURN GOING DOWN A HILL ONTO A STREET WHEN THE SENSORS WENT OFF AND THE POWER STEERING STOPPED WORKING. THE CAR REGISTERED TWO WARNINGS. I STOPPED THE CAR IN THE MIDDLE OF THE STREET. I WAS MANUALLY ABLE TO GET IT TO A PARKING LOT BUT IT WAS EXTREMELY DIFFICULT. I DROVE VERY SLOWLY. WHEN I GOT TO THE PARKING LOT, I TURNED THE CAR OFF AND RESTARTED IT. THE WARNINGS DISAPPEARED AND THE CAR FUNCTIONED NORMALLY. I PROCEEDED TO CALL THE DEALERSHIP WHERE I GOT THE CAR FROM TO EXPLAIN THE SITUATION. I SUBSEQUENTLY CALLED THE DEALERSHIP THE FOLLOWING DAY TO VOICE MY CONCERNS AND MAKE AN APPOINTMENT. THE BEST THEY COULD DO WAS A WEEK FROM TODAY. THIS IS A CERTIFIED, PRE-OWNED VEHICLE THAT I PURCHASED LESS THAN A YEAR AGO. *TR

WHEN MERGING INTO LANE AND PASSING A CAR ABOUT 3500 RPM EXHAUST GAS ENTERS PASSENGERS CABIN AND EVERYONE INSIDE WILL COMPLAIN OF VERY STRONG ODOR, BREATHING PROBLEM AND HEADACHE. HAD THIS PROBLEM SINCE CAR WAS NEW AND DEALING WITH UNCOMFORTABLE SMELL WITH THE REST OF THE FAMILY. WIFE HAD NUMEROUS TIMES HAVING PROBLEM CONCENTRATING DRIVING BECAUSE THE EXHAUST FUMES OR ODOR IS CAUSING HER TO HAVE HEADACHES AND ALMOST PASSING OUT ON LONG TRIPS. IT IS A HAZARDOUS/DANGEROUS ISSUE. IF FORD CAN HAVE A FIX ON THIS AND IT HAS TO BE SOON. I THINK IT IS THOUSAND OR HUNDRED OF THOUSAND OF FORD VEHICLES OUT THERE THAT HAS THIS PROBLEM. PLS. DON'T WAIT FOR SOMETHING LIKE GM DID. *TR

ON JUNE 16TH, 2014, I WAS TRAVELING 40 MPH WITH MY 3 YEAR OLD AND 18 MONTH OLD IN THE CAR AND I LOST ALL POWER STEERING AND ENDED UP IN A DITCH. THERE WAS NO WAY TO CONTROL IT OR EVEN TURN THE WHEEL. IT HAPPENED AGAIN ON JUNE 19TH, 2014 HOWEVER, MY HUSBAND WAS DRIVING AND WAS ABLE TO GET THE CAR OFF THE ROAD. *TR

POWER ASSISTED STEERING GOES OFF WITH NO WARNING. FIRST HAPPENED BACK IN 2012, PULLED OFF ROAD, RESTARTED CAR EVERYTHING WORKED FINE. PROBLEM OCCURRING MORE FREQUENTLY OVER PAST 6-8 MONTHS. (3 OR 4 TIMES) DEALER SAYS UNAWARE OF ANY GENERAL PROBLEMS WITH THE STEERING AM SCHEDULED TO TAKE TO DEALER FOR FURTHER ANALYSIS. NOT COVERED BY ANY RECALL BUT PROBLEM WIDELY REPORTED ON THE WEB. *TR

DURING TRAFFIC IN HOT WEATHER ON HIGHWAY THERE IS SQUEALING SOUND COMING FROM FRONT DRIVERS SIDE OF VEHICLE AND SMOKE COMING FROM REAR DRIVER TIRE AFTER EXITING HIGHWAY TO CHECK THE NOISE. AFTER EXITING HIGHWAY I FELT ALL 4 METAL WHEELS AND DRIVER'S SIDE REAR WAS EXTREMELY HOT AND OTHER WHEELS WERE WARM TO THE TOUCH. I HAD THE EXACT SAME CONDITIONS ON PASSENGER REAR BRAKES LAST SUMMER AT ~50,000 MILES, AND THE DEALERSHIP REPLACED REAR PASSENGER CALIPER IMMEDIATELY. THIS TIME THEY CLAIM ARE NOT ABLE TO REPRODUCE THE SEIZING OF CALIPER AFTER 3 MILE TEST DRIVE AND CALIPERS APPEARED TO BE IN WORKING CONDITION. I ARGUED THAT THE PROBLEM MAY OCCUR DURING LONG DISTANCE HIGHWAY TRAVEL AND MAY NOT HAPPEN ON SHORT TEST DRIVE. DEALERSHIP ARGUED THAT IT IS FORD POLICY NOT TO PERFORM WARRANTY REPAIRS/REPLACEMENT WORK WHEN THEY ARE UNABLE TO REPRODUCE PROBLEMS DESCRIBED BY CUSTOMER. I AM VERY UPSET THAT I HAVE TO WORRY ABOUT MY CAR STARTING ON FIRE EVERY TIME I DRIVE ON HIGHWAY. 2011 FORD EXPLORER XLT 3.5L V6 TIVCT. NORTHWEST CHICAGO IL. *TR

UPON MEDIUM TO HEAVY ACCELERATION, SUCH AS ACCELERATING ONTO A FREEWAY, THE VEHICLE CABIN IS FILLED WITH EXHAUST FUMES FROM THE ENGINE. THIS INJURES THE RESPIRATORY SYSTEM OF THE PASSENGERS. THEY ARE WORKING ON A FIX (AFTER MY FAMILY HAS BEEN BREATHING POLLUTED AIR FOR ALMOST TWO AND A HALF YEARS). FORD HAS FINALLY ADMITTED THAT THERE IS A PROBLEM, AND SEND ME A LETTER THAT SAID. [XXX] FORD CUSTOMER SERVICE DIVISION MARCH 7, 2014 [XXX] [XXX] SUBJECT: CUSTOMER CONCERN - EXHAUST ODOR ON 2011-2014 EXPLORER, EDGE OR MKX WE THANK YOU FOR TAKING THE TIME TO DISCUSS THE CONCERN OF EXHAUST ODOR IN YOUR VEHICLE. TO ADDRESS YOUR CONCERN ABOUT EXHAUST ODOR, WE HAVE PERFORMED SEVERAL INSPECTIONS AND SEALING ACTIONS WHERE APPLICABLE ON YOUR VEHICLE TO HELP MINIMIZE THE AMOUNT OF ODOR COMING INTO THE PASSENGER COMPARTMENT. WITH THESE CHANGES YOU MAY STILL EXPERIENCE ODOR UNDER CERTAIN DRIVING CONDITIONS SUCH AS, WHEN PERFORMING WIDE OPEN THROTTLE (WOT) ACCELERATIONS WITH THE CLIMATE CONTROL SYSTEM IN RECIRCULATION MODE. FORD MOTOR COMPANY ENGINEERS HAVE EVALUATED THE AIR ENTERING THE CABIN DURING WORST CASE DRIVING CONDITIONS (SEVERAL WOT ACCELERATIONS WITH THE CLIMATE SYSTEM IN RECIRCULATION MODE). TEST RESULTS INDICATE CABIN AIR QUALITY LEVELS ARE WELL WITHIN THE AMBIENT AIR QUALITY STANDARDS ESTABLISHED BY VARIOUS GLOBAL ENVIRONMENTAL PROTECTION AGENCIES SUCH AS THE U.S. EPA, OSHA, THE KINGDOM OF SAUDI ARABIA PRESIDENCY OF METEOROLOGY & ENVIRONMENT AND THE GOVERNMENT OF DUBAI ENVIRONMEN

AT APPROX 1430 ON JUNE 2ND ON HIGHWAY ON RAMP ACCELERATING HAD THE SERVICE ADVANCETRAC WARNING LIGHT AND CHIME COME ON AND THE TRACTION CONTROL OFF LIGHT AND CHIME COME ON AND LOST ALL POWER STEERING CONTROL OF VEHICLE. I IMMEDIATELY PUT ON MY EMERGENCY FLASHER AND LET OFF THE ACCELERATOR AND FORCED MY EXPLORER TO THE SHOULDER. ONCE ON THE SHOULDER OF THE HIGHWAY I CLEARED THE FAULTS, I WISH I WOULD HAVE TAKEN CELL PHOTO OF FAULT, AND TURNED VEHICLE OFF AND THEN RESTARTED VEHICLE WITH NO ISSUES. I DID NOT HAVE ANY OTHER ISSUES FOR THE REST OF THE DRIVE APPROX 25 TO 30 MIN. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE THROUGH THE REAR PASSENGER SEAT BELT AREA. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 56,000.

WHILE DRIVING ON THE INTERSTATE AT ABOUT 70 MPH, AN ELECTRICAL LIGHT CAME UP ON THE DASH AND I IMMEDIATELY LOST POWER STEERING. MY FAMILY WAS IN THE CAR AND IT WAS EXTREMELY FRIGHTENING. I WAS ABLE TO MUSCLE THE CAR OVER TO THE RIGHT LANE AT WHICH POINT, POWER STEERING WAS RESTORED. THE ISSUE HAPPENED AGAIN AROUND 20 MINUTES LATER AND THEN RECTIFIED ITSELF AFTER A MINUTE OR SO. I DROVE THE CAR TO THE DEALER AND SPOKE WITH THEM ABOUT WHAT HAPPENED. THEY KEPT THE CAR FOR A WEEK AND COULD NOT "REPLICATE THE ISSUE". THIS WAS THE FIRST WEEK OF APRIL. I AM NOW LEARNING THAT FORD WAS AWARE OF THIS PROBLEM BACK IN JANUARY AND HAS ISSUED A RECALL. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHEN BACKING OUT OF THE DRIVEWAY THE POWER STEERING FAILED. AS A RESULT, THE POWER STEERING ASSIST FAULT AND SERVICE STEERING ADVANCE TRACT LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,417 AND THE CURRENT MILEAGE WAS 87,437. PM UPDATED 9/4/14*CN

I WAS DRIVING ON A FOUR LANE HIGHWAY WHEN A SIGNAL CAME ON DASH " STEERING ASSIST FAILURE" AND I COULD NOT STEER THE VEHICLE. WAS JUST COMING OFF HIGHWAY AND WAS ABLE TO CONTINUE TO RAMP AND HAD TO PULL OFF ON MEDIAN IN MIDDLE OF BUSY EXIT RAMP. STOPPED AND THEN RESTARTED CAR WHICH TEMPORARILY FIXED PROBLEM NOW DEALERSHIP IS TELLING ME THE STEERING COLUMN MODULE NEEDS REPLACED - WILL COST ME $600 !!!!!:( VERY DISAPPOINTED IN FORD AS THERE ARE MANY REPORTS OF THIS HAPPENING TO OTHERS ! *TR