2006 Ford Explorer complaints

HAVING PROBLEMS WITH FLUID OVERFLOWING TO THE OVERFLOW TANK, OVERHEATING AND CYLINDER MISFIRE READINGS. *TR

I HAVE HAD TO CHANGE THE RADIATOR THREE TIMES AND GETTING READY TO DO IT AGAIN THE SECOND TIME THE TRUCK RAN HOT AND RUINED THE MOTOR. I THEN PUT ANOTHER MOTOR AND NEW RADIATOR AND IT HAS NOT BEEN 40000 MILES AND WITH NO WARNING AT ALL IT DONE IT AGAIN WITH ALL OF THE COMPLAINTS THAT HAS BEEN POSTED ONLINE THIS SHOULD HAVE BEEN ADDRESSED TO EVERY ONE THAT HAS THIS PROBLEM. *TR

WAS DRIVING WHEN TILT GATE GLASS AJAR WARNING CAME ON, AT THE SAME TIME HEARD A WHISTLING NOISE. UPON STOPPING NOTICED THE LIFT GATE WAS AJAR WITH AND AWAY FROM THE HATCH BY SEVERAL INCHES. TIED TO CLOSE IT AND IT DID NOT CLOSE PROPERLY UPON INSPECTION THE HINGE WAS BROKE THAT HOLDS THE GLASS TO THE VEHICLE. MANAGED TO GET THE GLASS SOMEWHAT BACK IN PLACE AND DROVE GINGERLY HOME ALL WHILE THE LIFT GATE AJAR LIGHT WAS ON. THERE IS A LOT OF WHITE RESIDUE PACKED IN PART OF THE HINGE NOT KNOWN IF IT IS ROAD SALT OR NOT AND THE HINGE HAS A CRACK WHERE IT SEPARATED. MY CONCERN IS THE FAILURE IS RELATED TO SALT AND FREEZING AND THAWING, AND IF THAT IS THE CASE HOW LONG BEFORE THE OTHER ONE FAILS... ALSO IF DRIVING AT HIGHWAY SPEEDS WITH WINDOWS OPENED COULD IT HAVE CAUSED THE GLASS TO SHATTER SCARING THE DRIVER OF OTHER TRAFFIC CAUSING AN ACCIDENT. I HAVE CONTACTED FORD ABOUT IT IN CASE THEY WANTED TO SEE IT AND GOT THE NORMAL BASIC REPLY CAR IS OUT OF WARRANTY AND BASICALLY WE DON'T' CARE AT THIS TIME. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY DECELERATE TO 40 MPH WITHOUT WARNING. LATER, THE TRANSMISSION WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO STATED THEY WOULD ASSIST HIM AT A LATER DATE. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 104,000. THE VIN WAS NOT AVAILABLE.

THE VEHICLE HAS HARSH UPSHIFTS WHEN ACCELERATING FROM 1ST TO 4TH GEAR, CREATING MOMENTARY LOSS OF CONTROL. THE VEHICLE WILL STALL, THEN JERK FORWARD A FEW INCHES UNANNOUNCED, WHICH HAS THE POTENTIAL OF CAUSING A WRECK OR HITTING A PEDESTRIAN. THE SAME WILL OCCUR WHEN SHIFTING FROM DRIVE TO REVERSE, AND VICE-VERSA. ALSO, SOMETIMES THE RPM WILL INCREASE DRASTICALLY ON ITS OWN WITHOUT AN INCREASE IN SPEED. I'M AFRAID THIS WILL CAUSE AN ACCIDENT IF THE SPEED DECIDES TO INCREASE. *TR

THE AIR BAG MALFUNCTION LIGHT AND WRENCH LIGHT BOTH LITE UP ON THE DASH. THE CAR APPEARED TO BE RUNNING STRANGE, SHIFTING HARD. AFTER TURNING OFF THE VEHICLE, IT WOULD NOT RESTART FOR APPROX 20 MINUTES. IT WOULD RUN FINE FOR A DAY OR SO THEN THE LIGHTS WOULD COME ON AGAIN. TOOK THE CAR TO THE FORD DEALERSHIP, THEY DROVE IT FOR APPROX 23 MILES AND THE LIGHTS WOULDN'T COME ON. THE BATTERY TESTED LOW SO THEY REPLACED THE BATTERY. WHEN TEST DRIVING AFTER THE BATTERY REPLACEMENT THE WRENCH LIGHT AND AIRBAG LIGHT FINALLY CAME ON. THEY TURNED OFF THE VEHICLE AND IT WOULDN'T START. AFTER WAITING 15 MINUTES TO AN HOUR IT WOULD START BUT THE LIGHTS WOULD COME ON AGAIN AND ONCE AGAIN AFTER TURNING IT OFF IT WOULDN'T RESTART. THEY CHARGED ME AN ADDITIONAL $759 TO FIX THE INSTRUMENT CLUSTER (AFTER AROUND $300 FOR THE BATTERY AND DIAGNOSTIC TESTING). VERY FRUSTRATING - MY 2006 ONLY HAS 47K MILES AND IS RARELY DRIVEN. *TR

2006 FORD EXPLORER XLT W/4.0 L HAD A COOLANT LEAK AND NEEDED A NEW RADIATOR. MILEAGE WAS 40,005. RADIATOR WAS REPLACED ON 11/16/2009. TWO YEARS LATER (1/1/12) THE RADIATOR IS AGAIN LEAKING AND NEEDS TO BE REPLACED. CURRENT MILEAGE IS 54,435. *TR

RADIATOR FAILURE. THE RADIATOR FAILED CAUSING THE ENTIRE ENGINE TO OVERHEAT. SEE ODI NUMBER 10439878. REPLACED ENTIRE ENGINE AND RADIATOR IN THIS VEHICLE WHICH ONLY HAS 68,000 MILES ON IT. (COSTING OVER $6000). PLEASE ISSUE A RECALL. *TR

THIS 2006 EXPLORER EDDIE BAUER CAR STARTED MAKING ROARING SOUND WHEN TRYING TO ACCELERATE. TRIED BACKING OFF THE ACCELERATOR AS MUCH AS POSSIBLE. THERMOSTAT GAUGE TEMPERATURE WENT TO HOT AND DISPLAYED RED AND A/C STARTED BLOWING COLD AIR. THERMOSTAT THEN WENT FROM HOT TO COLD MULTIPLE TIMES. CHECKED COOLANT LEVELS AND THEY WERE FINE. THE ENGINE AND CAR FINALLY SHUT DOWN COMPLETELY AND THE CAR THEN OVERHEATED. COOLANT BLEW OUT AT THE HOSE AT THE THERMOSTAT. TOWED THE CAR TO A NATIONWIDE REPAIR SHOP WHERE THEY REPLACED THERMOSTAT AND PRESSURE TESTED COOLING SYSTEM BUT CAR WILL NO LONGER IDLE AND ENGINE NOW HAS MAJOR PROBLEMS. TOWED THE CAR TO THE FORD DEALERSHIP AND THEY ARE NOW SAYING IT MAY HAVE A BLOWN HEAD GASKET ($2200 OR MORE) AND OR ENGINE NEEDS TO BE REPLACED ($5600). THEY ARE GOING TO CHECK WITH FORD TO SEE IF THEY CAN PROVIDE ASSISTANCE. THIS VEHICLE HAS 68,000 MILES ON IT (LESS THAN 15,000/YEAR) AND SHOULD NOT NEED A NEW THERMOSTAT AND ENGINE. THERE APPEARS TO BE A MAJOR PROBLEM WITH THIS YEAR/MAKE WITH RADIATORS/THERMOSTAT ISSUES. PLEASE ISSUE A RECALL. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE ACCELERATING FROM A TRAFFIC STOP, A LOUD NOISE WAS HEARD FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE LUG NUTS HAD SHEARED, CAUSING THE WHEEL TO DETACH FROM THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT THEN REALIZED THAT THE VEHICLE HAD OVERHEATED AS IT PROCEEDED TO STALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THE RADIATOR AND THERMOSTAT FAILED. THE VEHICLE WAS REPAIRED BUT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AGAIN AFTER TWO WEEKS. THE VEHICLES WAS TAKEN BACK TO THE INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE HEAD GASKET WAS BLOWN AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 84,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHIFT OUT OF PARK. THE CONTACT RECEIVED AN UNKNOWN SAFETY RECALL LETTER FROM THE MANUFACTURER REGARDING THE SHIFT LEVER CIRCUIT BOARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE SHIFT LEVER CIRCUIT BOARD REPLACED BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE VEHICLE WAS TAKEN BACK TO THE DEALER A MONTH LATER BUT THE DEALER DID NOT FIND A PROBLEM WITH THE SHIFTER. THE DEALER SUGGESTED TO THE CONTACT TO APPLY THE EMERGENCY BRAKE BEFORE SHIFTING THE VEHICLE OUT OF PARK. THE CONTACT CALLED THE MANUFACTURER REGARDING THE SHIFTER AND THE MANUFACTURER STATED THAT IT WAS UP TO THE DEALER WHETHER THE VEHICLE WOULD BE REPAIRED UNDER THE RECALL A SECOND TIME. THE FAILURE MILEAGE WAS 86,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE TEMPERATURE GAUGE STARTED TO INCREASE AND THE TEMPERATURE WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE RADIATOR WAS LEAKING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 36,000.

RADIATOR FAIL CAUSED CAT DEATH. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID AND RADIATOR COOLANT. AND AS A RESULT, THE RADIATOR FAILED. A PRIVATE MECHANIC MADE THREE ATTEMPTS TO REPAIR THE FAILURE BY REPLACING THE RADIATOR BUT TO NO AVAIL. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. THE CURRENT MILEAGE WAS 78,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 43,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR CONTINUED TO LEAK. THE LEAKING WAS CAUSED BY THE PLASTIC MATERIAL SEPARATING FROM THE ALUMINUM, WHICH WAS CAUSING THE VEHICLE TO OVERHEAT. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER ALSO ADVISED THAT THE THERMOSTAT NEEDED TO BE REPLACED AS WELL DUE TO THE RADIATOR FAILURE. THE FAILURE MILEAGE WAS 67,000. THE CONSUMER COULD NOT AFFORD TO FIX THE PROBLEM. SHE ALSO STATED THE WERE PLENTY OF WEBSITES DEVOTED TO THE EXACT RADIATOR AND THERMOSTAT PROBLEM. UPDATED 11/21/11...UPDATED 11/25/11 *BF UPDATED 11/30/11

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHEN THE VEHICLE GEAR WAS PLACED INTO REVERSE THE GEAR ENGAGED WITH FORCE, AND THE VEHICLE ALSO LOST POWER. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT A DIAGNOSED WAS NOT PERFORMED. THE DEALER DID NOT REPLACE ANY PARTS. THE VEHICLE WAS NOT REPAIRED. THE VIN INFORMATION WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHEN THE GEAR WAS PLACED IN REVERSE IT ENGAGED WITH FORCE, AND THE VEHICLE STALLED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT A DIAGNOSTIC TEST WAS NOT PERFORMED. THE VEHICLE WAS NOT REPAIRED NOR DID THE DEALER REPLACE ANY PARTS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 THE CURRENT MILEAGE WAS NOT AVAILABLE.

WHILE DRIVING THE VEHICLE, THE SMELL OF ANTIFREEZE STARTED COMING INTO THE CAR. MY FIANCE' CHECKED THE RADIATOR AND OVERFLOW BOTTLE AND FOUND OUT IT WAS GAS MIXED WITH THE ANTIFREEZE. MY CAR'S MILEAGE IS 80100. I DO NOT BELIEVE THE CAR SHOULD HAVE THIS ISSUE AT ONLY 5 YEARS. THIS PROBLEM/COMPLAINT SHOULD BE INVESTIGATED AND DAMAGES SHOULD BE COVERED BY THE DEALERSHIP OR MANUFACTURER. *TR

WE PURCHASED OUR 2006 EXPLORER USED WITH 61,000 IN SUMMER 2009. THE DEALERSHIP DID A COMPLETE INSPECTION AND REPLACED EVERYTHING WE FOUND AS DEFECTIVE OR AS A RECALLED ITEM. THE COOLANT SYSTEM WASN'T ONE OF THESE ISSUES. DROVE VEHICLE ALL SUMMER AND INTO THE FALL WITHOUT ISSUE. BY LATE FALL OF 2009 VEHICLE HAD ANTI-FREEZE LEAK, JUST AFTER THE FIRST FROST IN NE. LOCAL AUTO SERVICE PROVIDOR REPLACED RADIATOR TWICE IN ONE MONTH WITH NAPA PARTS WITHOUT REMEDY AND THEN EVENTUALLY THEY HAD TO REPLACE WITH AN AUTHORIZED FORD RADIATOR TO GET IT NOT TO FAIL. ALSO REPLACED THE WATER PUMP, ALL HOSES, PULLIES, AND FLUID TO MAKE SURE THERE WERE NO OTHER ISSUES. STILL LEAKED BUT MINOR AND FINALLY WAS CORRECTED IN SPRING OF 2010. BY LATE FALL 2010, AGAIN AFTER THE FIRST FROST THE VEHICLE WAS LEAKING ANTI-FREEZE AGAIN. TOOK IT TO FORD DEALERSHIP THIS TIME WHERE THEY WENT THROUGH THE ENTIRE COOLING SYSTEM AND REPLACED THE THERMOSTAT AND UPPER INTAKE HOUSING THEY SAID WAS LEAKING. THEY ALSO FLUSHED THE ENTIRE SYSTEM AGAIN AND ADDED WHAT THEY DEEMED WAS THE CORRECT ANTIFREEZE FOR THE VEHICLE ASSURING THAT THIS WOULD STOP THE PROBLEM. VEHICLE STILL LEAKED AND WE HAD TO PERIODICALLY TIGHTEN THE HOSE CLAMPS BUT BY SPRING OF 2011 THE LEAK AGAIN STOPPED. JUST BROUGHT VEHICLE BACK TO FORD DEALERSHIP FALL 2011, AGAIN AFTER THE FIRST FROST. WAS TOLD THE NOW 2 YEAR OLD FORD RADIATOR WAS FAILING AT THE JOINTS BETWEEN ALUMINUM AND PLASTIC. THIS WAS THE SAME FAILURE AS ORIGINALLY NOTED IN FALL OF 2009. THE

ENGINE STALLS. WHENEVER IT FEELS LIKE IT, HOT OR COLD, SLOWING DOWN TO STOP, TURNING LEFT OR RIGHT, ON THE STREET ROADS AND FREEWAYS. STARTS AND GO AGAIN AFTER 5/10 MINUTES BUT THIS IS RIDICULOUS. I PAID SO MUCH MONEY AND TIME FOR DIAGNOSTIC AND PARTS ALREADY AND YESTERDAY WAS THE WORST. MY 2006 FORD EXPLORER STALLED IN THE MIDDLE OF THE FREEWAY. DATE: NOV 1, 2011, TIME:1550, AND MY WIFE WAS DRIVING, WHEN SHE'S NOT HAPPY, NOBODY'S HAPPY....SHE ALMOST GOT RAN OVER AS SHE OPEN HER DOOR, SHE COULD NOT GO ANYWHERE BUT WAIT FOR TIME TO EITHER COOL OFF OR RESET ON THE ENGINE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR FAILED. THE RADIATOR WAS REPLACED TWO YEARS PRIOR TO THE MOST RECENT FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THEY COULD REPLACE THE RADIATOR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 39,000 AND THE CURRENT MILEAGE WAS 63,000.

MY 2006 FORD EXPLORER HAS 44,000 MILES ON IT AND NEEDS A NEW RADIATOR,AFTER CHECKING COMPLAINTS ONLINE FOR THE SAME PROBLEM, I HAVE FOUND MANY COMPLAINTS ABOUT THIS ISSUE.I BELIEVE FORD NEEDS TO RECALL THIS VEHICLE FOR THE RADIATOR ISSUE. THE LEAK FROM THE RADIATOR CAN SEEP INTO THE GROUND AND INTO THE UNDERGROUND WATER SYSTEM,NOT TO MENTION ANY ANIMALS THAT WOULD DRINK FROM THE PUDDLES LEFT BEHIND FROM THIS VERY TOXIC ANTI-FREEZE. THE REPLACEMENT OF THIS ITEM COST ALMOST $1200 AT A FORD DEALER,THESE TRUCKS ARE ONLY 5 YEARS OLD AND I KNOW PEOPLE WHO HAVE REPLACED 3 OR MORE RADIATORS SINCE THEY PURCHASED THEIR EXPLORERS. IT SEEMS TO BE A BIGGER PROBLEM FOR THE 2006 MODEL WHEN FORD CHANGED THE RADIATOR TO PLASTIC. I WONDER HOW MANY ACCIDENTS WHERE CAUSED WHEN THE RADIATOR FAILED AND SEIZED THE ENGINES WHILE PEOPLE WHERE DRIVING? *TR

WHILE BEING PARKED ON AN INCLINED HILL, MY EXPLORER WOULD NOT GET INTO GEAR. HAD TO CALL AAA TO TOW TO TRANSMISSION SPECIALIST WHO ADJUSTED THE GEAR BUT STATED YOU MIGHT HAVE MORE TRANSMISSION PROBLEMS. SINCE THEN MY CAR HAS HAD PROBLEMS WHERE THE GEARS HAVE BEEN GRINDING AS I'M DRIVING. I'M AFRAID I MIGHT HAVE MORE SERIOUS PROBLEMS IN THE FUTURE SINCE I'VE BEEN READING REPORTS FROM FORD OWNERS THAT THIS IS BECOMING A MAJOR PROBLEM WITH FORD VEHICLES. *TT

TL* THE CONTACT OWNS A 2006 FORD EXPLORER XLT. THE CONTACT WAS DRIVING 60 MPH WHEN THE ENGINE STALLED. THE CONTACT NOTICED A LEAK COMING FROM THE RADIATOR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY CONFIRMED THAT THERE WAS A HOLE IN THE RADIATOR .THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 71,000 AND THE CURRENT MILEAGE WAS 82,000.

THE RADIATOR WAS LEAKING ON MY EXPLORER AND FORD REFUSED TO FIX IT, EVENTHOUGH IT WAS STILL UNDER WARRANTY. I SEE THAT THERE ARE MANY COMPLAINTS ON THE 2006 FORD EXPLORER FOR THE RADIATOR LEAKING. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 45 MPH, THE TEMPERATURE GAUGE DISPLAYED A READING INFORMING HER THAT THE ENGINE WAS OVER HEATING. THE CONTACT ALSO STATED THAT WATER WAS LEAKING FROM THE ENGINE. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND STATED THAT THE RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED APPROXIMATELY EIGHT MONTHS LATER. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE TEMPERATURE GAUGE WOULD INDICATE THAT THE ENGINE WAS OVERHEATING. THE CONTACT ALSO NOTICED THERE WAS FLUID LEAKING FROM THE RADIATOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO INFORMED THE CONTACT THAT THE RADIATOR WAS CRACKED AND THE THERMOSTAT HOUSING FAILED. THE CONTACT WAS ALSO INFORMED THAT THIS WAS A COMMON FAILURE THAT REQUIRED THE RADIATOR BE REPLACED WITH A NEWLY DESIGNED VERSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

AT RANDOM TIMES AND NOT OFTEN, WHEN I PUT THE SUV IN PARK, AND TURN OFF THE TRUCK AND REMOVE MY FOOT FROM THE BRAKE, THE TRUCK WILL CONTINUE TO ROLL. IT IS AS THOUGH THE SUV IS IN NEUTRAL, PUT IT IS IN PARK. THE SUV WILL ROLL UNTIL SOMETHING STOPS IT LIKE A CURB OR APPLYING THE BRAKE. TO FIX THE PROBLEM, I HAVE TO PLACE THE SHIFT GEAR TO FROM PARK TO ANOTHER GEAR AND BACK TO PARK. AT THAT TIME, THE TRUCK WILL CATCH. OVER THE PAST YEAR OR SO, IT HAS OCCURRED 6 OR 7 TIMES. I TOOK THE TRUCK IN FOR SERVICE AND THEY CHECKED THE TRANSMISSION AND GEAR BOX AND FOUND NO ISSUE. THE PROBLEM OCCURRED AGAIN LAST WEEK. SINCE THE DEALER CANNOT SEE THE PROBLEM, THEY SAY THERE IS NO PROBLEM. HOWEVER, IT IS A MATTER OF TIME OF WHEN IT OCCURS AND I AM NOT AWARE OF IT NOT LOCKING AND IT ROLLS WHEN THERE IS NOBODY TO STOP IT OR A CURB. THERE IS NO PATTERN SINCE IT HAS OCCURRED AT WORK, GROCERY STORE, HOME, ETC. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THE AUTOMATIC TRANSMISSION BEGAN SLIPPING IN 2006 WHEN THE VEHICLE WAS PURCHASED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THERE WAS NO FAILURE WITH THE TRANSMISSION AND IT WOULD NOT FAIL; HOWEVER, OVER TIME IT BECAME PROGRESSIVELY WORSE. THE MANUFACTURER WAS NOTIFIED BUT STATED THERE WERE NO RECALLS AND TO CONTACT NHTSA IN ORDER TO FILE A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 7,000 AND THE CURRENT MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THE RADIATOR WAS REPLACED FOUR TIMES. THE RADIATOR BEGAN TO LEAK AND CAUSED THE VEHICLE TO RUN HOT. THE CONTACT STATED THAT THE RADIATOR WAS REPLACED EVERY 25,000 MILES. ALL OF THE RADIATORS WERE BEEN REPLACED BY AN AUTHORIZED DEALER, BUT THE DEALER STATED THERE WAS NO CAUSE FOR THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 105,000.

THIS VEHICLE CONSTANTLY OVERHEATS. I HAVE TO ADD COOLANT EVERY FEW DAYS. IT FIRST STARTED DURING A DAY TRIP. PRIOR TO LEAVING I HAD MY OIL CHANGED AND ALL MY FLUIDS WERE FILLED. AFTER LEAVING THE HIGHWAY THE CAR COMPLETELY SHUT OFF. I HAD TO GO TO A GAS STATION AND ADD MORE COOLANT IT WAS ONLY A THREE HOUR TRIP AND IT WAS COMPLETELY DRY. SHORTLY AFTER THE TRANSMISSION BECAME SHIFTING HARD. IT JERKS AND SEEMS TO MISS GEARS. AT THE TIME IT ONLY HAD 40,000 MILES. NOW I HAVE TO BE EXTREMELY CAREFUL WITH THE TRANSMISSION AND MUST KEEP COOLANT IN MY VEHICLE. I HAVE 4 SMALL CHILDREN AND I AM AFRAID THIS VEHICLE IS A FIRE DANGER BECAUSE OF THE RADIATOR. I AM FINANCING THIS VEHICLE AND DON'T HAVE THE MONEY TO GET A NEW ONE. THIS VEHICLE TODAY HAS 54,000 MILES AND IF BUILT CORRECTLY I SHOULD BE ABLE TO GET 100,000 WITHOUT ANY MAJOR REPAIRS. FORD SHOULD BE RESPONSIBLE AND RECALL THESE VEHICLES AND SHOW THEY STAND BY THEIR PRODUCTS. THEIR SAYING SHOULD BE FORD FLIMSY NOT FORD TOUGH! *TR

NO EVENTS LEADING UP TO FAILURE. REGULAR VEHICLE USAGE. AFTER 4 OR 5 YEARS, THE TRANSMISSION BEGAN CLUNKING AND HESITATING TO SHIFT. WHEN SHIFTING INTO REVERSE OR DRIVE, THE TRANSMISSION JOLTS VIOLENTLY. THE CHECK ENGINE LIGHT IS ON. THE FAILURE HAS NOT YET BEEN CORRECTED BUT I AM COMPLAINING NOW BECAUSE SO MANY SIMILAR REPORTS HAVE ALSO BEEN FILED ACROSS THE INTERNET. *TT

I HAVE A 2006 FORD EXPLORER AND I HAD TO REPLACE TRANSMISSION AND REAR BEFORE VEHICLE REACHED 70, 000 MILES. I WAS TOLD BY THE MECHANIC THAT THEY COULD NOT REPLACE TRANSMISSION OIL AND DIFFERENTIAL UNTIL 100,000 MILES. FORD SHOULD GUARANTEE THE TRANSMISSION AND REAR END UP TO 100,000 MILES, IT'S NT FAIR TO THE CONSUMER. *TR

WHILE DRIVING 2006 FORD EXPLORER SHUTS DOWN SEVERAL TIME AT DIFFERENT OCCASION SOMETIMES A LITTLE WRENCH APPEARS AND GAS PEDAL BECOMES UNRESPONSIVE AND CRUISE CONTROL CAN NOT BE ENGAGE AND VEHICLE IDLE VERY ROUGH WHEN COME TO A STOP. VEHICLE HAS LOSS ACCELERATION WHILE RUNNING ON 6 LANES HIGHWAY AND REQUIRE TO BE PULL ALONG THE SIDE TO TURN OFF AND RESTART AGAIN, WHEN VEHICLE SHUTS DOWN IT DOES NOT ALWAYS RESTART RIGHT AWAY. WHEN I BRING IT FOR DIAGNOSTIC FORD DEALERS ARE UNABLE TO DO ANYTHING BECAUSE THE SYMPTOMS CAN NOT BE DUPLICATED AND NO FAULT ARE STORE. IT HAPPEN AGAIN SUNDAY AUGUST 21 2011 WHILE I WAS DRIVEN FROM NJ TO NY ON I-80 AND THIS TIME CHECK ENGINE LIGHT CAME ON AND TOOK IT TO AUTO-ZONE AND THEY READ CODES P2104 AND P2111. BY THE TIME I WENT TO THE DEALER AND TURN OFF THE VEHICLE CHECK ENGINE LIGHT WAS GONE THE COULD NOT DO ANYTHING. *TR

THE WRENCH, THE ABS, AND THE ANTI-SWAY ICONS STARTED COMING ON INTERMITTENTLY ON MY 2006 EXPLORER. THEY WOULD RESET IMMEDIATELY USING THE RESET BUTTON. THE DEALER REPLACED A WHEEL-SPEED SENSOR AND STATED THAT THE SENSOR WAS DAMAGED WHEN THE "TONE" WHEEL CRACKED. DEALER ALSO STATED THAT UNLESS THE TONE WHEEL WAS REPLACED, THE ABS WAS NOT OPERATIONAL. SEEMS LIKE THIS IS A MAJOR SAFETY CONCERN; IF YOU THINK YOU HAVE ABS, BUT DON'T THE DRIVER IS SET UP FOR THE BIG FALL! FORD IS AWARE OF THIS CRACKING PROBLEM: WHY NO RECALL? *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR AND WATER PUMP WERE REPLACED BECAUSE THE VEHICLE WAS OVER HEATING BUT THE REPAIR DID NOT CORRECT THE FAILURE. THE CONTACT CONSULTED WITH HIS PERSONAL MECHANIC AND WAS ADVISED THAT THE HEAD GASKET WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 90,000.

2006 FORD EXPLORER XLT SPORT UTILITY 4X4 4.6L AUTOMATIC TRANSMISSION. THE TRANSMISSION SLIPS OR HESITATES GOING INTO GEAR. AT STOPS IT HAS A TENDENCY TO SLAM DOWN SHIFT HARD. THE TRANSMISSION SLIPS SO MUCH BETWEEN GEARS IT AFFECTS THE MILEAGE SO I GET REALLY BAD GAS MILEAGE LESS THEN THE 13 LOW END OF THE 13/18 MPG SUGGESTED. IT WILL TAKE ABOUT $2,000.00 TO GET ANOTHER TRANSMISSION. I STILL OWE $8,000.00 ON THIS CAR. I AM JUST ABOUT READY TO SAY COME GET IT. *KB

THE ISSUE BEING, DIGITAL ODOMETER FAILURE,AND FORD UNABLE TO PROVIDE REPLACEMENT INSTRUMENT CLUSTER COMPONENT. NOW WE ARE CONTRIBUTING TO THE POLUTION OF THE ENVIRONMENT AS I AM UNABLE TO MONITOR MY ENGINE PERFORMANCE, HAVE NO IDEA WHEN TO CHANGE OIL, CONTRIBUTING TO PREMATURE ENGINE FAILURE, AND UNABLE TO HAVE MY VEHICLE INSPECTED, RENDERING MY VEHICLE INOPERABLE

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL AND THE TEMPERATURE GAUGE BEGAN TO FLUCTUATE TO VERY HOT. THE CONTACT DROVE TO THE SIDE OF THE ROAD WITH CAUTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE RADIATOR WAS REPLACED. THE MOST RECENT IDENTICAL FAILURE RECURRED AND THE RADIATOR WAS REPLACED FOR THE SECOND TIME. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.

THE TRUCK MAKE A HORRIBLE TICKING NOISE WHEN YOU START IT UP. IT WILL DO THIS UNTIL THE OIL GETS THRU THE MOTOR. FORD STATES THAT IT IS THE NATURE OF THE MOTOR FOR NORMAL WEAR AND TEAR. IT IS EMBARRASSING TO SAY THE LEAST, AS IT SOUNDS LIKE A TICKING TIME BOMB THAT IS WAITING TO GO OFF. AFTER THE TRUCK HAS BEEN RUNNING FOR A FEW MINUTES THAN THE NOISE GOES AWAY, SEEMS THAT IF I SPENT THIS MUCH MONEY ON A VEHICLE, IT WOULDN'T SOUND LIKE AN OLD CLUNKER. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT FLUID WAS LEAKING FROM THE VEHICLE. WHEN INSPECTED, HE DISCOVERED THAT THE TRANSMISSION PAN WAS CORRODED AND WAS CAUSING THE LEAK. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE PAN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED ALONG WITH ADDITIONAL PARTS. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 60,000.

RADIATOR FAILURE CAUSING LEAK WHICH COULD RESULT IN ENGINE OVERHEAT AND POSSIBLY FIRE.. *TR

I OWN A 2006 FORD EXPLORER WITH 64000 MILES. YESTERDAY WITHOUT ANY WARNING THE TRANSMISSION WENT OUT WHILE IN HEAVY TRAFFIC, I HAD THE VEHICLE TOWED TO A DEALER WHERE THEY SAY THE TRANSMISSION WOULD NEED REPLACED. I CHECKED ONLINE AND FOUND THIS TO BE A VERY COMMON PROBLEM WITH THIS YEAR AND MAKE. AND EVERYONE HAD EXACT SYMPTOMS. FORD ACTS LIKE THIS ISN'T COMMON AND PLAYS DUMB TO THE FACT. I STILL OWE $15000 ON A VEHICLE AND CANNOT AFFORD $3000 TO REPAIR. SOMEONE PLEASE LOOK INTO THIS ISSUE AND STOP FORD FROM TAKING ADVANTAGE OF CITIZENS. THANK YOU *TR

ABS BRAKE LIGHT AND INTERMITTENT LOCKING UP BRAKES WITH STABILITY CONTROL ALMOST CAUSING ACCIDENT AS YOU LOSE CONTROL WHILE DRIVING. *TR

2006 FORD EXPLORER-BAD RADIATOR LEAK. STARTED LEAKING WITH ONLY 28,000 MILES ON IT. CALLED DEALERSHIP AND THEY STATED IT WOULD COST $ 1100.00 TO FIX. THEY ALSO TRIED SELLING ME AN EXTENDED WARRANTY. *TR

2006 FORD EXPLORER WITH 69,000 MILES. TRANSMISSION FAILURE. MAKES A LOUD NOISE AS ENGINE IS WORKING BUT TRANSMISSION ISN'T WORKING PROPERLY. HAVE BEEN TOLD TO EITHER SELL IT OR TRY TO PUT IN A NEW TRANSMISSION. ALSO, CONTROL BOX ON DASH PANEL WENT OUT AT 30,000 MILES. $700 TO REPAIR. TRANSMISSION COULD BE UPWARDS OF $4,000 TO REPAIR

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT HER VEHICLE STALLED WHILE SHE WAS DRIVING 50 MPH. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THERE WAS NO FAILURE. NEITHER THE DEALERSHIP OR MANUFACTURER WERE CONTACTED. THE FAILURE MILEAGE WAS 5,000 AND THE CURRENTLY MILEAGE WAS 35,000.

I OWN A 2006 FORD EXPLORER. THE VEHICLE EXPERIENCE A FAILURE ON THE FUEL FILL SYSTEM IN 2008. I WAS NOT ABLE TO PUT MORE THAN A GALLON OF GAS IN AT A TIME, WAIT FOR AWHILE, ADD ANOTHER GALLON, ETC AS THE FUEL FILL WOULD ACT AS THOUGH THE TANK WAS FULL. TOOK TO A DEALER AND HAD IT REPLACED BASED ON TSB#07253. EXPERIENCED THE SAME FAILURE AGAIN NOW IN 2011 AND BROUGHT IT BACK TO THE DEALER AND WAS TOLD SINCE IT WAS MORE THAN 12 MONTHS SINCE THE ORIGINAL REPLACEMENT I HAD TO PAY THE DEDUCTIBLE AGAIN TO HAVE THE WORK DONE. *TR

I HAVE A 2006 FORD EXPLORER THAT IS JERKING WHEN I PUT IT INTO REVERSE AND ALSO HAS JUMPED OUT OF GEAR A COUPLE OF TIMES, THANK GOODNESS I WAS SITTING IN IT AND NO ONE GOT HURT. TAKING IT IN AGAIN TO THE SHOP TOMORROW HOPE THEY CAN FIND A PROBLEM. IF ANYTHING IS DONE I WILL KEEP THE OLD PART. *TR