Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 1996 record →
WAS DRIVING VEHICLE AND HAD TO JAM ON BRAKES WHEN ANOTHER VEHICLE CUT IN FRONT. ABS SYSTEM LOCKED UP. PRIOR TO LOCKING UP, HAD 3 SETS OF BRAKES, AND 2 SETS OF ROTORS REPLACED. THIRD TIME HEARD GRINDING NOISES ON RIGHT FRONT WHEEL. SOUNDED LIKE METAL TO METAL. DRIVER SIDE ROTORS WERE SHOT DUE TO BRAKES LOCKING UP. AT DEALERSHIP, NOTHING WAS FOUND WRONG.*AK
PRIOR TO RECALL THE CONSUMER FOUND A BULGE ON THE BACK LEFT TIRE AND REPLACED WITH MICHELINS, CONSUMER REQUESTED REIMBURDSEMENT FOR THE REPLACEMENT TIRES BUT WAS DENIED BECAUSE THE TIRES WERE REPLACED PRIOR TO AUG 9, 2000(FIRESTONE WILDRNESS AT TIRE P235/75R15 ).
LEFT REAR TIRE BLEW OUT CAUSING THE VEHICLE TO SPIN OUT OF CONTROL, AND VEHICLE ALSO FLIPPED OVER SEVERAL TIMES, THE LEFT REAR TIRE EXPERIENCED TREAD SEPARATION, DRIVER SUFFERED MINOR INJURIES. (UNIROYAL LAREDO TIRES P235/75R15 M+S)(OHIO TRAFFIC CRASH REPORT) *YH
SUPPORT FRAME THAT HOLDS CAR TOGETHER ON FRONT OF VEHICLE WAS SEVERELY CRACKED. CONSUMER TOOK VEHICLE TO DEALER, AND THEY WERE NOT GOING TO DO ANYTHING. CONSUMER FELT THAT THE ENTIRE FRONT END OF VEHICLE COULD FALL OFF. THEN, CAR WOULD FLIP OVER, AND PASSENGER COULD BE INJURED OR KILLED. VEHICLE WAS ROLLING DEATH TRAP. FRAME SHOULD NEVER BREAK, IT COULD BE BENT, BUT NOT BROKEN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
CONSUMER REPLACED FIRESTONE TIRES, P235/75R15, PRIOR TO RECEIVING RECALL 00T005, CONSUMER STATES TIRE TREAD WAS WEARING ON THE INSIDE OF THE TIRES, FIRESTONE STATES THAT SINCE TIRES WERE REPLACED PRIOR TO RECALL THEY ARE NOT WILLING TO GIVE ANY REIMBURSEMENT. *SLC
TIRE TOTALLY BROKE DOWN LIKE NEVER BEFORE SEEN; INSPECTED BY GOODYEAR; SAID NORMAL BLOWOUT OF UNDER INFLATED TIRE. INSPECTED BY CERTIFIED MECHANIC. STATED SUCH NEVER BEFORE SEEN AND SHOWDED WHY UNDERINFLATION COULD NOT BE THE CAUSE. STILL HAVE TIRE IN MY POSESSION.*AK (TIRESIZE: P235/75R15) (TIRESIZE: P235/75R15)
THE CONSUMER REQUESTED REIMBURSEMENT FOR THE DEFECTIVE SPARE TIRE, THE CONSUMER ONLY RECIEVED REIMBURSEMENT FOR THE TIRE MOUNTING, THE CONSUMER IS STILL AWAITING REIMBURSEMENT FOR THE REPLACED TIRE (FIRESTONE ATX II).
WHILE DRIVING UNDER NORMAL OPERATING CONDITIONS ENGINE SURGED AND WOULD NOT DECELERATE. CONSUMER PUT VEHICLE IN NEUTRAL, AND WAS ABLE TO STOP VEHICLE. DEALERSHIP HAS EXAMINED VEHICLE, AND HAS INFORMED CONSUMER THAT THIS VEHICLE WAS NOT INCLUDED IN RECALL 97V074000 DUE TO VIN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
PRIOR TO RECALL, CONSUMER EXPERIENCED THREE TREAD SEPARATIONS AND ONE BLOW OUT, IN WHICH ONE OF THE TREAD SEPARATIONS WAS A REPLACEMENT, HOWEVER CONSUMER WAS DENIED REIMBURSEMENT DUE TO THE OCCURENCES HAPPENING BEFORE RECALL WAS ISSUED, CONSUMER WAS INFORMED BY A FIRESTONE DEALER THAT ONLY THE TIRES BEING REPLACED IN THE YEAR 2000 WOULD BE REIMBURSED. FIRESTONE TIRES ATX/P235/7R15.*JB
I HAD THIS SAME PROBLEM WITH MYH 1994 EXPLORER. WHEN THE TEMPERATURE IS OVER 85 DEGREES OUTSIDE AND THE AIR CONDITIONER IS ON, WE GET AN EXTREMELY STRONG ODOR OF RAW GASOLINE INSIDE THE CAR. IT MAKES US NAUCEOUS. THIS HAPPENS ESPECIALLY WITH IN-TOWN STOP AND GO DRIVING. *AK
CONSUMER STATES IGNITION SWITCH HAS FAILED ON NUMEROUS OCCASIONS.*JB
CONSUMER IS UNABLE TO UNLOCK TAILGATE BECAUSE RIGHT SIDE LATCH WILL STICK. PLEASE PROVIDE FURTHER INFORMATION.*AK
CONSUMER NOTICED A SMALL RING AND SEPARATION ON ALL FOUR OF THE FIRESTONE ATX TIRES, A MICHELIN DEALER ALSO NOTICED THIS AND CONSUMER REPLACED ALL FOUR TIRES, CONSUMER RECEIVED LETTERS FROM FIRESTONE AND FORD REGARDING THE RECALLED TIRES, HOWEVER CONSUMER WAS DENIED ANY REIMBURSEMENT FROM BOTH PLACES. *SLC
I HAVE TRIED TO RECEIVE REIMBURSEMENT FROM FORD AND FIRESTONE EVER SINCE AUGUST 2000 FOR FOUR FAILED FIRESTONE WILDERNESS ATX'S. FROM THE BEGINNING WE HAD PROBLEMS WITH THESE TIRES ON MY FORD EXPLORER. WHEN WE TRAVELED AT 60MPH, THE VEHICLE WOULD SHAKE VIOLENTLY. WE TOOK THE VEHICLE TO THE FORD AND FIRESTONE DEALERS WHO TOLD US THEY COULD FIND NOTHING WRONG. SO FOR THE NEXT 2 1/2 YEARS, WE DID NOT DARE DRIVE ABOVE 60MPH. WHILE THESE TIRES WERE ON THE EXPLORER, I MADE SURE TO HAVE THEM ROTATED AND PROPERLY INFLATED PER THE DIRECTIONS ON THE TIRES. ABOUT TWO YEARS LATER, WE NOTICED EXTREME WEAR ON THE OUTER PERIMETERS OF ALL FOUR TIRES, AS WAS NOTICED BY THE PLACE WHERE WE GOT THE TIRES ROTATED, AS WELL AS STRANGERS AT GAS STATIONS. I TOOK IT AGAIN TO FIRESTONE AND DEMANDED REPLACEMENT. I WAS TOLD THAT THERE WAS NO MILEAGE WARRANTY, AND BECAUSE THEY WERE SO WORN OUT (STEEL BELTS VISIBLE) ON THE PERIMETER (BUT NOT THE MIDDLE TREAD AREA) THERE WAS NO WEAR CREDIT. I WAS TOLD THAT ALL I COULD DO WAS PURCHASE NEW TIRES AT MY COST. NOT WANTING TO PUT MY FAMILY'S LIFE IN JEOPARDY, IN EARLY 1999, I REPLACED ALL FOUR TIRES AT MY COST ($367.29) WITH MICHELINS. SINCE THEN, NOT ONLY IS THE CAR RUNNING SMOOTHLY ABOVE 60MPH, WITH 20,000 MILES ON THEM, THEY STILL HAVE PLENTY OF TREAD FOR ANOTHER 20-30,000 MILES. WHEN THE RECALL WAS ANNOUNCED IN AUGUST 2000, I REJOICED BECAUSE I KNEW SOMETHING WAS INHERENTLY WRONG WITH THE TIRES, AND BECAUSE I THOUGHT (MISTAKINGLY) I WOULD BE REIMBURSED. BUT..
THE CRANKSHAFT SPLIT DIRECTLY IN HALF.
NOISE COMING FROM FRONT SUSPENSION(CREEKING & POPING),VEHICLE STEERING IS ERATIC, TENDS TO OVERSTEER. LOCAL FORD DEALER PERFORMED SWAY BAR RECALL ON 02/12/01. WHERE CAN I GET MORE INFO. ON THIS PROBLEM. CAN I GET HELP FROM FORD? WHAT. *AK
POWER DOOR LOCKS ARE NOT WORKING, THEREFORE THE DOORS DO NOT OPEN FROM THE INSIDE. THIS COULD BE EXTREMELY DANGEROUS IF TRAPPED INSIDE. SHOULDN'T THEY ALWAYS OPEN MANUALLY? ISN'T THERE A LAW PROVIDING SAFETY FOR DOOR LOCKS?
FUEL PUMP WAS BEING REPLACED. TOWNSEND FORD PERFORMED THE JOB. TECH BROKE CHEAP PLASTIC CLIP REQUIRING FUEL FILLER NECK TO BE REPLACED. IT'S DEFECTIVE. WILL NOT SEAL. GAS VAPOR LEAK. CHECK ENGINE STAYS ON. FORD HAS PROBLEM WITH SUPPLIER. NONE IN COUNTRY TOLD TO ME ABOUT A COUPLE MONTHS AGO. STILL NONE NOW. GAS VAPOR LEAK IS HEALTH HAZARD AND UNSAFE IN MY OPINION. THEY KEEP BLOWING ME OFF ON RESOLUTION. CAN YOU HELP? -THANKS-*AK
THE VEHICLES OVERDRIVE FAILED RESULTING IN TRANSMISSION FAILURE, THE MANUFACTURER HAS BEEN CONTACTED. NLM
THE VEHICLE SHUT OFF COMPLETELY WHILE THE CONSUMER WERE DRIVING ON HIGHWAY, THE DEALER FOUND OUT THAT THE CRANKSHAFT HAD SPLIT IN HALF, CONSUMER WANTS THE MANUFACTURER TO PAY PART OF THE COST OF REPAIR. *YH
THE FORD EXPLORER WAS HIT ON THE FREEWAY IN THE FRONT RIGHT SECTION WHICH PUSHED THE CAR LEFT THE CAR WAS THEN BROADSIDED BY ANOTHER CAR AND THE FRONT DRIVER SIDED DOOR FLEW OPEN IT WAS FORTUNATE THAT MY SON HAD ON HIS SEATBELT SO HE WOULD NOT BE THROWN FORM THE CAR, BUT WITH THE DOOR FLYING OPEN HIS ARM, LEG OR HEAD COULD HAVE BEEN SEVERILY DAMAGED IF IT HAD BEEN IN THE WAY WHEN THE DOOR FLOEW BACK TO CLOSE. THE AIR BAGS DID NOT DEPLOY EITHER, IT SEEMS THAT THEY WOULD HAVE SINCE THE BOTH HITS WERE AT SPEEDS OF APPROX. 55 MPH. *AK
THE RIGHT FRONT AND RIGHT REAR TIRES EXPERIENCED TREAD SEPARATION PRIOR TO THE RECALL BECOMING PUBLIC, THE CONSUMER REPLACED ALL FOUR TIRES AND IS REQUESTING REIMBURSEMENT, THE MANUFACTURER DENIED REIMBURSEMENT BECAUSE THE REPLACEMENT TIRES WERE PURCHASED PRIOR TO JANUARY 1, 2000. NLM
THE DEALER IS BEEN INFORMING THAT THEY ARE WORKING ON FUEL GUAGE PROBLEM FOR ALMOST 1 YEAR AND REPLACED THE ASSEMBLY IN THE FUEL TANK AND CONTACTED FORD SEVERAL TIMES. I ALSO CONTACTED THEM AND SPOKE TO SHAWN @ 1-800-392-3673 EXTN: 3066. HE TOLD ME FORD WILL CONTACT ME, BUT, FAILED TO CONTACT. ABS PROBLEM CAME RECENTLY. DEALER REAPLACED A PART, BUT, DID NOT RESOLVE THE PROBLEM. AS PER THE DEALER THE FORD MOTORS ARE AWARE OF THE FUEL GUAGE PROBLEM FROM THE BEGINING BUT, FAILED TO COME UP WITH A RECOMMENDATION.
AFTER PURCHASING VEHICLE, CONSUMER BEGAN TO EXPERIENCE A VIBRATION IN THE VEHICLE, TIRES WERE REBALANCED AND ROTATED, BUT THE VIBRATION STILL EXISTED, CONSUMER DECIDED TO REPLACE THE FIRESTONE P235/75RX15 TIRES WITH GOODYEAR TIRES AND THE VIBRATION IMMEDIATELY STOPPED, EVEN THOUGH PROBLEM OCCURRED PRIOR TO RECALL, CONSUMER IS REQUESTING SOME TYPE OF COMPENSATION FOR HIS EXPENSE AND TIME OF RESOLVING THE VIBRATION.*JB
CONSUMER WAS TRAVELING 65MPH ON HIGHWAY AND ACCELERATED INTO ANOTHER LANE. ACCELERATOR PEDAL WAS STUCK ALL THE WAY TO THE BOTTOM OF FLOOR. THERE WAS A LOUD STREAKING NOISE, AND BOTH FEET WERE ON THE BRAKE. SHE WAS ABLE TO PULL OVER TO THE SHOULDERS, AND VEHICLE HAD TO BE TOWED.*AK
ON THE FREEWAY CAR STOPPED RUNNING. CRANK SPLIT IN TWO. SERVICE REP COULDN'T BELIEVE IT. *AK
THE TRANSMISSION FAILED WHILE DRIVING. NLM
I HAVE HAD FOUR TIRE SEPARATIONS ON THIS SAME EXPLORER. TWO WERE ON THE ATXII 235/75R15 - BOTH VDHL FROM DECANTUR, IL PLANT. THE COMPANY (AFTER MUCH HASSLE) REPLACED THEM WITH THE FIREHAWK R45 ALSO VD DOT NUMBERS INDICATING THEY ARE FROM THE SAME PLANT. BOTH BLOWOUTS CAUSED OVER $1000 WORTH OF DAMAGE TO MY VECHICLE. THIS LAST TIME, I HAD TO PAY $350 FOR NEW TIRES. I SUSPECTED SOMETHING WAS WRONG WITH THE ATX LONG BEFORE THE RECALL (AUG. 3, 1997 WAS THE FIRST BLOWOUT, JUNE 9, 1998 WAS THE SECOND). NOW I SUSPECT SOMETHING MUST EITHER BE WRONG WITH THE FIREHAWKR45, OR THE FORD SUSPENSION SYSTEM. PLEASE DO NOT HESITATE TO CALL OR WRITE IF YOU HAVE ANY FURTHER QUESTIONS.*AK (DOT NUMBER: VDHKFMA457 TIRESIZE: LTP235/75)
DRIVER'S SIDE REAR SEAT BELT LOCKED UP, AND WOULD NOT RELEASE FROM LOCKING MECHANISM . SEAT BELT HAD TO BE CUT TO RELEASE CHILD FROM THE SEAT. PLEASE GIVE ANY FURTHER DETAILS.*AK
CABLE HOLDING SPARE UP AGAINST VEHICLE WAS ABOUT TO BREAK. WIRING WAS WEARING OUT. CONTACT DEALER, AND DEALER STATED IT WAS WEAR AND TEAR OF VEHICLE.*AK
O/D LIGHT FLASHES AFTER 15 MIN. OF RUNNING VEHICLE. TRANSMISSION THEN SHIFTS HARD UP AND DOWN. FORD SERVICE SAYS THEY CANNOT FIND ANYTHING WRONG.*AK
THE ACCELERATOR STUCK ,CAUSING THE VEHICLE TO ACCELERATE UNCONTROLLABLY. *AK
THE 1990 EXPLORER HAD TIRE RECALL 00T-005 RESULTING IN REPLACEMENT OF ALL FOUR TIRES, THE 1996 EXPLORER EXPERIENCED TIRE SEPARATION PRIOR TO RECALL, AND WAS REPLACED BY THE CONSUMER. THE CONSUMER BELIEVES THAT THE 1996 EXPLORER TIRES SHOULD BE REPLACED PER RECALL ALSO. THE CONSUMER IS SEEKING REIMBURSMENT FROM THE MANUFACTURER OF THE TIRES . *YH
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE DRIVING AT GA400, NOTICED THAT VEHICLE CAN NOT BE SLOWED DOWN AFTER APPLYING BRAKE PEDALS SEVERAL TIMES. NOTICE THAT THE RPM IS INCREASING. FEARING THAT SINCE THERE IS NOT WAY TO SLOWING DOWN THE CAR,I SHIFTED TO THE GEAR TO NEUTRAL AND EXIT AT HOLCOMB BRIDGE EXIT. SINCE THE SPEED IS STILL AT 70MPH, THE CAR HIT THE ENBANKMENT, WENT DOWN THE GRASSY AREA AND (FFG IS WHAT I CAN REMEMBER HAPPENED)AND HIT A WATER RUN-OFF/DITCH, DID A SPIN AND CAME UP AND STOP AT THE GRASSY AREA. I WAS ABLE TO TURN OFF OF THE ENGINE WHEN I CAME BACK TO SENSES AND RAN TO THE CLOSEST GAS STATION (CHEVRON) TO CALL AAA. THE TOW TRUCK OPERATOR NOTICED THAT WHEN HE RESTARTED THE ENGINE, IT WAS ROARING AT 5000RPM. TOWED IT TO FORD DEALER/SERVICE AT MANSELL ROAD, WAS TOLD 2-DAYS LATER THAT THEY HAVE INSPECT LINKAGE FOR BINDING AND TROTTLE BODY FOR BINDING, BUT DID NOT FIND ANY PROBLEM, AND SINCE THEY CAN NOT REPRODUCE THE SITUATION, THERE IS NOTHING THEY CAN DO BUT TO BRING IT BACK WHEN IT HAPPENED AGAIN??? I FEARED FOR THE NEXT TIME THAT IT HAPPENED, LIFES WOULD BE AFFECTED.*AK
CONSUMER HAD TAKEN VEHICLE TO DEALER REGARDING TRANSMISSION PROBLEMS ON SEVEN OCCASIONS, WHEN SHIFTED INTO REVERSE, VEHICLE WILL HESITATE AND THEN POP INTO REVERSE AFTER 15-20 SECONDS, VEHICLE WILL NOT ALWAYS GO IN REVERSE, DEALER STATED THAT TRANSMISSION WAS GOING, BUT NOT TO DO ANYTHING UNTIL ALL GEARS WERE AFFECTED. *ET
WHEN DRIVING AT 35 MPH AND PULLING FROM A PARKING SPACE STEERING WHEEL JAMMED AND MADE A POPPING SOUND. ALSO, IN ORDER TO MOVE STEERING WHEEL CONSUMER HAD TO JERK AND APPLY FORCE TO STEERING WHEEL TO MOVE IT. CONSUMER HAS YET TO CONTACT THE DEALER. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
WHEN THE CONSUMER REPLACED THE LEFT REAR BRAKE ROTOR HE NOTICED THAT THE LINING HAD COME LOOSE FROM THE METAL OF THE REAR PARKING BRAKE SHOE AND IT WAS LESS THAN HALF WORN, ALL FOUR SHOE LININGS WERE CRAZED BUT WERE NOT BROKEN.
AIRBAG LIGHT HAS COME ON, NOT TAKEN TO DEALER YET.*AK
THIS VEHICLE WAS PROFESSIONALLY SERVICED AND MAINTAINED. AT 74,000 MILES THE TRANSMISSION BEGAN SLIPPING. WHEN FORD TESTED THE VEHICLE THEY TOLD ME IT BROKE DOWN AN THAT THE STARTER, FLYWHEEL, TORQUE CONVERTER AND ENTIRE TRANSMISSION HAD TO BE REPLACED. THEY SAID THEY HAVE NEVER SEEN THIS BEFORE. THE MORE I TALK ABOUT THIS, THE MORE I HEAR ABOUT FORD EXPLORER TRANSMISSION PROBLEMS.*AK
THE CONSUMER BEGAN TO HEAR NOISE IN THE FRONT END IF THE VEHICLE AT 9K MILES, THE CONSUMER HAD THE FRONT END CHECKED AND THE TIRES ROTATED, AT 22K MILES THE NOISE DEVELOPED AGAIN AND ONE TIRE BLEWOUT WHILE DRIVING, THE VEHICLE WAS DRIVEN FOR ANOTHER 10K MILES WHEN THE NOISE STARTED AGAIN AND UPON INSPECTED IT WAS NOTED THAT THE TREAD WAS SEPARATING, THE CONSUMER IS REQUESTING REIMBURSEMENT FOR THE TIRES (FIRESTONE P 235 AT). NLM
FRONT DUNLOP RADIAL ROVER TIRES , SIZE: LT235/75R15, DOT: DAHK ON 1996, FORD, EXPLORER WOULD MAKE A CLICKING NOISE , AS IF A ROCK WAS IN TREAD OF TIRE. CLICKING NOISE TURNED INTO A THUMPING NOISE, AND CONSUMER REPLACED FRONT TIRES. SERVICE CENTER INFORMED CONSUMER THAT NOISE WAS DUE TO IMPROPER ROTATION/MAINTENANCE OF TIRES. *AK TIRES EXPERIENCED CUPPING. *SLC
LEFT FRONT TIRE SEPARATION CONTRIBUTED TO ROLLOVER ACCIDENT ON MARCH 10, 2001. TIRES WERE NOT ON RECALL BUT THEY WERE UNDER INVESTIGATION, AND BY THE ACCOUNT OF THE EMERGENCY PERSONEL, AT THE SITE,THE TOW COMPANY, AND BODY SHOP, AHVE ALL SAID THE SEPARATED FRONT TIRE CONTRIBUTED TO THE ROLLOVER. WHAT IS MY OPTIONS AT THIS POINT?*AK (TIRESIZE: 255/70R/15)( DOT NUMBER: TIRE SIZE: 255/70R/15 )
DURING A SPIN OUT AT HIGHWAY SPEED OF APPROXIMATELY 50 MPH IN RAINY CONDITIONS, A 1998 FORD EXPLORER IMPACTED A CONCRETE DIVIDER ON THE RIGHT FRONT FENDER, FOLLOWED BY THE RIGHT REAR QUARTER PANEL. THE VEHICLE CAME TO A STOP AND TIPPED OVER ONTO THE LEFT SIDE OF THE VEHICLE. BOTH AIRBAGS FAILED TO DEPLOY. NO MAINTENANCE HAS EVER BEEN DONE ON THE AIRBAG SYSTEM, NOR HAS THERE BEEN A RECALL.*AK
WHILE DRIVING, CONSUMER NOTICED VEHICLE WAS RIDING ROUGH BUT WAS ABLE TO CONTROL VEHICLE, HOWEVER IN SEPTEMBER 1998 WHILE DRIVING THE VEHICLE WAS RIDING ROUGH AND CONSUMER WAS HAVING TROUBLE CONTROLLING THE STEERING, ONCE CONSUMER RETURNED HOME SHE GOT OUT OF THE VEHICLE AND NOTICED THAT THE THREAD OF THE REAR TIRE HAD STARTED TO PEEL OFF, CONSUMER EVENTUALLY REPLACED ALL FIVE TIRES, CONSUMER RECEIVED THE RECALL INFORMATION FROM FIRESTONE AND SENT IT BACK, ONLY TO RECEIVE A DENIAL LETTER STATING THAT THE REPLACEMENT TIRES WERE PURCHASED PRIOR TO RECALL NOTIFICATION.(FIRESTONE ATX P235/75R15 SERIAL # VDHLATN368.*JB
INSIDE HANDLES ON LEFT AND RIGHT REAR DOORS ARE BROKEN. DOORS CANNOT BE OPENED FROM INSIDE. DEALER HAS BEEN NOTIFIED.*AK
LUGS: NUTS IS WEARING OFF FROM WHEEL WHICH COULD EVENTUALLY CAUSE WHEEL TO COMPLETLEY SEPARATE FROM VEHICLE. *AK *JB
TIRES WERE ORIGINAL EQUIPMENT ON A 1996, FORD, EXPLORER, TIRE SIZE P255/70R16, DOT NUMBER NOT AVAILABLE, TIRES HAD 80 THOUSAND MILES ON THEM. CONSUMER NOTICED THAT REAR PASSENGER AND FRONT DERIVER'S SIDE TIRES WOULD NOT STAY INFLATED. ALSO, REAR TIRE WAS SHOWING SIGNS OF TREAD SEPARATION . CONSUMER HAS REPLACED ALL FOUR TIRES. PLEASE.*AK *JB
VEHICLE STALLS WHEN WEATHER IS HOT. RPM GOES BELOW 500 AND WILL STALL. DEALER SAYS THEY DO NOT KNOW WHAT IS WRONG, HOWEVER ON NUMEROUS INTERNET SITES HAVE FOUND INFORMATION RELATING TO A FAULTY IGNITION DEVICE. THIS HAS BEEN A PROBLEM FOR OVER A YEAR, DEALER SAID HAD TO BRING VEHICLE IN WHEN PROBLEM WAS OCCURRING. VEHICLE IS CURRENTLY IN SERVICE DEPARTMENT. STILL NO ANSWER AND CANNOT FIND OUT IF THE RECALL IS BEING ENFORCED.*AK
DRIVER'S SIDE EMERGENCY BRAKE LINE IS TOO LONG , ABOUT 6-8 INCHES LONGER, AND IT RUBS AGAINST AND WEARS INTO LEFT REAR TIRE, ALMOST INTO SIDEWALL. THIS COULD CAUSE AN UNEXCEPTED BLOWOUT WITHOUT WARNING, AND COULD RESULT IN A CRASH. IT WAS RUBBING SO BADLY AGAINST TIRE THAT IT HAS BEGUN TO WEAR OFF NAME OFF TIRE.PLEASE PROVIDE FURTHER INFORMATION. *AK CONSUMER STATES CABLE APPEARS TO BE TO LONG AND THE PLASTIC CLIP THAT IS SUPPOSE TO HOLD THECABLE AWAY FROM THE TIRE CAN SLIP DOWN AND ALLOW THE SITUATION TO OCCUR, THE TIRE HAD WORN THROUGH THE VINYL PROTECTIVE COATING OF THE CABLE IT ALSO WORE THROUGH THE VINYL CABLE COATING AND HAD BEGUN TO WEAR AWAY THE INSIDE SIDEWALL OF THE LEFT REAR TIRE. *JB
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 1996 Ford Explorer → · Every Explorer year → · How the figures are calculated →