2006 Ford Expedition complaints

WAS DRIVING ON FREEWAY AT ABOUT 60 VEHICLE WENT INTO ENGINE FAILURE MODE VEHICLE CUT OFF COMPLETED I HAD TO HURRY PUT THE TRUCK IN PARK TURN ON MY HAZARDS AND KEEP RESTARTING THE TRUCK UNTIL I GOT IT RESTARTED WHEN IT RESTARTED THE AIR DIDN'T WORK ANY MORE I HAVE NO COLD AIR BUT THE HEAT WORKS AND THE TRUCK ONLY HAS 27000 MILES ON IT AS OF TODAY FORD WOULD NOT FIX IT I HAVE FULL BUMPER TO BUMPER WARRANTY AT THE TIME AND STILL HAVE EXTENDED WARRANTY UP TO 75000 MILES THE VEHICLES SHUTS OFF LIKE ONCE A MONTH AND IT JUST DID IT THIS MORNING I DON'T KNOW HOW TO SOLVE THIS PROBLEM FORD DID NOT HONOR MY CONTRACT I COULD HAVE BEEN KILLED ON A FREEWAY IN TRAFFIC HERE A BEEP AND CAR GO INTO FAILURE MODE SOMEONE COULD HAVE RAN INTO THE BACK OF ME BY NOT KNOWING WHAT WAS GOING ON ANY THING WHAT IF I WAS GOING UP A HILL AND MY ENGINE GOES INTO FAILURE MODE I NEED HELP SOLVING THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THE VEHICLE STALLS WITHOUT WARNING. THE VEHICLE WILL THEN START WITHOUT ANY PROBLEMS. THIS FAILURE HAS OCCURRED RANDOMLY OVER THE FOUR YEARS THE CONTACT HAS OWNED THE VEHICLE. THE VEHICLE WAS INSPECTED BY THE DEALER A WEEK AGO AND NOTHING WAS FOUND TO BE WRONG WITH THE VEHICLE. THE VIN WAS REJECTED FROM THE SYSTEM. THE FAILURE MILEAGE WAS 25000 AND THE CURRENT MILEAGE 74000.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 70 MPH ALL OF THE INTERIOR AND EXTERIOR LIGHTS BEGAN TO DIM. THE RADIO SHUT OFF AND THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED HOME WHERE SHE REPLACED THE ALTERNATOR. APPROXIMATELY 5 MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE STARTER WAS REPLACED. APPROXIMATELY 1 MONTH LATER THE FAILURE BEGAN TO INTERMITTENTLY RECUR. DURING ONE OF THE FAILURES THE CHECK ENGINE LIGHT ALSO BEGAN TO ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THE FAILURE WAS DUE TO THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING 45 MILES AN HOUR DOWN A MAJOR HIGHWAY WHEN MY ENGINE IN MY 2006 FOR EXPEDITION JUST SHUT DOWN WITHOUT WARNING AND WENT INTO "FAIL -SAFE MODE". THANK GOD I WAS ABLE TO CROSS 3 LANES OF TRAFFIC WITHOUT INCIDENT TO GET TO THE SHOULDER. I SHUT OFF MY CAR AS THE MANUAL TOLD ME TOO. AFTER 20 MINS I WAS ABLE TO RESTART THE CAR. I DROVE TO THE NEAREST DEALERSHIP SO THEY COULD LOOK INTO THE ISSUE. IT WAS DIAGNOSED AS NEEDING A REPLACEMENT THROTTLE BODY. WHEN I ASKED "WHAT HAPPENED? WHY DID THIS HAPPEN?", I WAS TOLD "IT JUST HAPPENS," AND "THERE IS NOTHING PREVENTATIVE THAT CAN BE DONE.". CONVENIENTLY THIS PART WAS NOT COVERED BY MY 100,000 MILE POWERTRAIN WARRANTY THAT FORD IS SO PROUD OF ON ITS USED VEHICLES. THIS REPAIR COST ME $609. THE NEXT DAY I DID SOME RESEARCH AND FOUND NUMEROUS COMPLAINTS ON THE EXACT SAME ISSUE FOR THE SAME MAKE AND MODEL (2006 FORD EXPEDITION) ON THE FOLLOWING WEBSITE: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2006/FORD/EXPEDITION/ENGINE+AND+ENGINE+COOLING+SYSTEM . I CALLED THE SERVICE MANAGER TO DISCUSS AND HE AGREED HE HAS BEEN SEEING ALOT OF THESE THROTTLE BODY REPLACEMENTS AND ENGINE SHUTDOWNS ON THIS MODEL AND AGREES A RECALL NEEDS TO BE DONE BEFORE SOMEONE GETS SERIOUSLY HURT. I AM JUST THANKFUL MY 3 KIDS WERE NOT IN THE CAR WITH ME AND PRAY THIS DOESN'T HAPPEN AGAIN. THE SERVICE MANAGER GAVE ME THIS WEB ADDRESS TO MAKE AN OFFICIAL COMPLAINT, HOPING A RECALL WOULD TAKE PLACE. *TR

WITH NO WARNING, MY 2006 FORD EXPEDITION WILL LOSE ALL POWER WHILE DRIVING. THE LIGHT ON THE CONTROL PANEL COMES ON SAYING "ENGINE FAIL SAFE MODE." AFTER COASTING TO THE SIDE OF THE ROAD, I RESTART THE CAR AND ALL IS FINE. I HAVE TAKEN IT TO TWO MECHANICS AND THEY SAY THERE IS NOTHING WRONG WITH THE CAR. IT HAS HAPPENED TWICE SO FAR. *TR

MY FAMILY (ME, WIFE AND TWO CHILDREN) WERE ON OUR WAY HOME FROM A RESTAURANT. WE NORMALLY TAKE THE HIGHWAY BUT DECIDED TO TAKE THE SIDE ROAD HOME AND THANK GOD. DRIVING 45 MPH THE "ENGINE FAIL SAFE MODE" CAME ON AND IT COMPLETELY SHUT OFF. I PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. AFTER A FEW MINUTES, I RESTARTED THE VEHICLE AND IT STARTED FINE AND NO WARNING SIGNS.THIS IS THE FIRST TIME IT OCCURRED BUT I DO NOT WANT THIS TO HAPPEN AGAIN. THE VEHICLE IS INSIDE THE GARAGE AND I'M CALLING THE DEALERSHIP TOMORROW TO MAKE AN APPOINTMENT. THIS IS A FAMILY CAR AND WE ARE ALWAYS ON THE HIGHWAY. THIS IS A FATAL FAIL THAT NEEDS TO BE CORRECTED. THIS FAILURE OCCURRED AT 61,408 MILES. I CHECKED THE FORD WEBSITE AND THERE IS NO RECALL. HOWEVER, THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET FOR THE SAME ISSUE. I'M AFRAID FOR MY WIFE AND CHILDREN WHILE THEY ARE OPERATING THIS VEHICLE. *TR

BOLTS ON FRONT PASSENGER AND DRIVER SIDE SEATBELT RESTRAINT ANCHORS TO HE SIDE WALL LOOSENED ALMOST COMPLETELY OFF. THIS POSES A SERIOUS SAFETY CONCERN. THE FORD DEALERSHIP HAS NEVER NOTICED OR CORRECTED THE PROBLEM IN THE FOUR YEARS WE HAVE OWNED THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING UNDER 20 MPH WHEN HE APPLIED THE BRAKES. THERE WAS AN INCREASE IN ENGINE RPMS AND THE VEHICLE ABNORMALLY ACCELERATED. THE BRAKE PEDAL WAS APPLIED WITH FORCE AND THE VEHICLE CONTINUED TO ACCELERATE. WHEN THE GEAR SELECTOR WAS SHIFTED INTO THE NEUTRAL POSITION, THE VEHICLE CAME TO A COMPLETE STOP. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATIONS. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING AT 5 MPH, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT WOULD LIGHTLY TAP ON THE ACCELERATOR PEDAL IN ORDER TO GET IT TO ENGAGE. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED. THE DEALER ADVISED THAT ONE OF THE COIL PACKS WAS DEFECTIVE AND IT WS REPLACED. THE FAILURE RECURRED. THE CONTACT STATED ONLY ONE COIL PACK WAS REPLACED BY THE DEALER BUT THERE WERE TWO ADDITIONAL COIL PACKS THAT NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 135,000.

I HAVE A 2006 FORD EXPEDITION AND MY WIFE ALMOST LOST CONTROL AND HIT A CAR WHEN THE BRAKES WENT TO THE FLOOR. THE VEHICLE HAS HAD "SPONGY BRAKES" SINCE I BOUGHT IT AND HAD IT TO THE DEALER TWICE. THERE IS A TSB TO REPLACE THE FRONT CALIPER/ROTOR AND PADS AND FORD DID THIS BUT IT STILL FEELS SPONGY AND IS NOW LEAKING FLUID. THIS HAS BEEN AN ISSUE ON MANY EXPEDITIONS AND SHOULD HAVE BEEN A RECALL RATHER THAN A TSB. THIS IS AN INCREDIBLY DANGEROUS SITUATION WHEN THE BRAKES FAIL. I KNOW I HAVE HAD INSTANCES WHERE I LITERALLY NEED TO STAND ON THE BRAKES TO GET THE VEHICLE TO STOP. *TR

TL* CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING AT 50 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT IT STALLED A SECOND TIME WITHIN SECONDS. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT WAS ABLE TO LOCATE NUMEROUS COMPLAINTS REGARDING THE THROTTLE CONTROL AND BELIEVED IT TO BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 80,000.

MY WIFE, THREE KIDS AND MYSELF WERE IN OUR 2006 FORD EXPEDITION LIMITED COMING DOWN A MOUNTAIN PASS IN LAKE TAHOE WHEN ALL OF A SUDDEN THE ENGINE STOPPED! A CODE ON THE DASH READ "FAIL SAFE ENGINE MODE". THE STEERING WHEEL LOCKED AND THERE WAS NO POWER, NO ACCELERATION. I WAS LUCKY TO PULL TO THE SIDE OF THE ROAD. THE FOLLOWING DAY, I TOOK THE TRUCK TO THE CARSON CITY, NV FORD DEALER AND PAID FOR A DIAGNOSTIC. NOTES FROM DEALER: ROAD TEST COULD NOT VERIFY. PERFORMED EEC SELF TEST, HAS CODE P0104. PERFORMED WIGGLE TEST AND PINPOINT TESTS. PERFORMED RECORDER-MONITOR TEST ALL THE PIDS LOOKED GOOD. REMOVED THE MAF SENSOR. HAS DEBRIS ON THE MAF SENSOR WIRES. RECOMMEND A NEW MAF SENSOR." I PUT IN A NEW MAF SENSOR AND AIR FILTER. IN DRIVING LESS THAN 3 MILES AFTER THIS WAS DONE, THE TRUCK DID THE SAME THING. THE "FAIL SAFE ENGINE MODE" CAME ON, LOSS OF POWER AND ACCELERATION. I HAD TO TURN THE TRUCK OFF COMPLETELY, REMOVE KEY AND RESTART. THEN THE TRUCK DID NOT HOLD THE IDLE AND DIED. AFTER A SECOND TIME, THE TRUCK RESTARTED. I AM STILL DRIVING WITH THE CHECK ENGINE LIGHT OFF AND HAVE ANOTHER APPOINTMENT WITH THE FORD DEALER TOMORROW MORNING (6-24-10) TO SEE WHAT IS GOING ON. WE ARE SUPPOSED TO LEAVE TOMORROW AND DRIVE 1100 MILES TO RETURN TO DENVER. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FUEL INJECTORS WERE STUCK OPEN AND FLOODED THE ENGINE. THE DEALER ALSO STATED THAT BOTH CATALYTIC CONVERTERS WERE RUINED AND NEEDED TO BE REPLACED, AND THE ENGINE WAS POSSIBLY DAMAGED. THE CONTACT STATED THAT THERE WAS A RECALL RELATED TO THE FAILURE FOR PREVIOUS MODEL YEARS AND WARRANTIES WERE EXTENDED AS A RESULT. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD NOT EXTEND THE WARRANTY ON THE VEHICLE. THE CONTACT FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 65,000. UPDATED 11/19/10. *LJ UPDATED 10/27/10. *LJ THE CONSUMER STATED A NEW ENGINE WAS PUT IN THE VEHICLE. HOWEVER, HE CONTINUED TO EXPERIENCE PROBLEMS. THE DEALER STATED THE #6 CYLINDER HAD COMPRESSED CAUSING THE PISTON TO STOP A HALF INCH FROM THE TOP WHICH CAUSED THE VEHICLE TO SHUT DOWN. UPDATED 11/24/10

ON 2 SEPARATE OCCASIONS (BOTH AROUND 40,000 MILES), THE CAR JUST SHUT ITSELF OFF, WITHOUT WARNING, WHILE DRIVING DOWN THE ROAD AT ABOUT 40 MPH. POWER STEERING AND POWER BRAKING BOTH FAILED. I WAS JUST ABLE TO COAST ACROSS SEVERAL BUSY LANES OF TRAFFIC TO GET TO THE SIDE OF THE ROAD. THIS COULD BE EXTREMELY DANGEROUS, PARTICULARLY IF I WAS ON A FREEWAY OR INTERSTATE. THE DEALER'S DIAGNOSIS WAS THAT THE THROTTLE HAD GOTTEN STUCK WIDE OPEN, AND THAT THE CAR HAD TO GO INTO FAILSAFE MODE TO PREVENT IT FROM ACCELERATING OUT OF CONTROL. WHAT IF THE FAILSAFE MODE FAILS? I'VE READ NUMEROUS OTHER COMPLAINTS OF THE SAME THING HAPPENING ON OTHER 2006 FORD EXPEDITIONS. THERE IS CLEARLY A DEFECTIVE PART HERE, AND IT IS CLEARLY A SAFETY ISSUE. *TR

2006 FORD EXPEDITION SHUTS DOWN WHILE DRIVING ENGINE GOES INTO FAIL SAFE MODE WHICH IS LIKE NEUTRAL WITH LIMITED STEERING CAPABILITIES AND NO GAS PEDAL USE. BOUGHT VEHICLE IN DEC 09. THIS VEHICLE HAS DONE THIS APPROX 7 TIMES. HAS HAPPENED WHILE ON SURFACE STREETS AS WELL AS THE FREEWAY. VERY DANGEROUS. AT DEALER FOR THIRD TIME AND THEY ARE GIVING A THIRD REASON FOR IT HAPPENING. CHECKED INTERNET AND IT IS FULL OF COMPLAINTS OF EXACTLY SAME PROBLEM WITH NO RESOLUTION FROM ANY MECHANICS BUT SEVERAL DIFFERENT REASONS THEY WERE GIVEN. A DEFINITE SAFETY ISSUE! ON THE PHONE WITH FORD CUSTOMER SERVICE TODAY ABOUT THE ISSUE. THEY WILL GET BACK TO ME TOMORROW. NO RECALLS ON THIS, APPARENTLY UNTIL SOMEONE GETS HURT. THIS IS ANOTHER TOYOTA ISSUE WAITING TO HAPPEN. I AM A STATE TROOPER AND YOU CAN BELIEVE I FEEL THIS IS SERIOUS AND NEEDS TO BE ADDRESSED. SOMEONE COULD BE SERIOUSLY HURT OR KILLED ESPECIALLY ON THE FREEWAY WHEN THIS HAPPENS. *TR

ENGINE SAFE FAIL MODE CAME ON WHILE DRIVING MY 2006 FORD EXPEDITION WHICH ALSO LEAD TO THE VEHICLE SHUTTING DOWN IN THE MIDDLE OF THE HIGHWAY. THE NEXT READING THAT WAS CONNECTED TO THIS WARNING WAS...ENGINE OFF...LOW FUEL OIL PRESSURE. I CHECKED UNDER THE HOOD OF THE VEHICLE TO SEE IF THERE WAS ANY OIL LEAKS OR IF THE READING WAS REALLY LOW AND ALL SEEN FINE. THIS IS A VERY SCARY INCIDENT BECAUSE THE VEHICLE JUST SHUTS DOWN IN THE MIDDLE OF TRASH WHICH COULD CAUSE AN ACCIDENT MAYBE FATAL. *TR

MY FAMILY, WHICH I HAVE FIVE CHILDREN IN THE TRUCK. ON 10FWY ON MOTHERS DAY EXPEDITION LOST POWER IN SECOND LANE 65MPH FLOWING W/ TRAFFIC. WE MANAGED TO GET IN EMERGENCY LANE. HAD NO IDEA WHAT WAS HAPPENING! AMBER LIGHT APPEARS (WRENCH)?? CLUELESS. PUT TRUCK IN "PARK" TURNED OFF TRUCK WAITED 5 MINUTES. TRUCK STARTED?? DROVE HOME AS TRUCK IS NOT UNSAFE. PARKED TRUCK FOR 3-DAYS NOW TRUCK WILL NOT TURN ON. DEALER WILL LOOK AT TRUCK FOR CHARGE OF COURSE. *TR

DRIVING TO WORK VIA FREEWAY, HAD JUST REACHED THE BOTTOM OF A FREEWAY OFF-RAMP, AT A STOPLIGHT. LIGHT TURNED GREEN, HAD JUST STARTED TO GO AND THE "FAIL SAFE ENGINE MODE" LIGHT ON MY 2006 FORD EXPEDITION CAME ON THE DASHBOARD, WITHIN 5 SECONDS THE CAR TURNED OFF ON ITS OWN, LIKE TAKING THE KEY OUT OF THE IGNITION. HAD IT TOWED TO A FORD DEALERSHIP, THEY RAN DIAGNOSTICS, SAID THE THROTTLE BODY ASSEMBLY NEEDED REPLACING. I LOOKED ON THE INTERNET, GOOGLING "FAIL SAFE ENGINE MODE" AND "FORD" AND FOUND THIS TO BE A COMMON PROBLEM. ASKED WHY IT'S NOT A RECALL ITEM OR HAS A TECHNICAL BULLETIN WITH SO MANY CASES OF IT, PLUS IT'S VERY DANGEROUS. MANY IN THEIR INTERNET POSTINGS SAID THE PROBLEM COMES BACK. DEALERSHIP SAID TO CONTACT FORD CORPORATE, OPENED A CUDL CASE FOR ME TO REQUEST REIMBURSEMENT. WROTE A LETTER TO FORD CORPORATE, INCLUDED INTERNET LINKS TO ALL THE POSTINGS OF OTHER PEOPLE HAVING THE SAME PROBLEM, ASKED FOR $480.35 REIMBURSEMENT, ALSO ASKED WHAT THEY ARE DOING ABOUT THIS DANGEROUS SITUATION WITH THE THROTTLE BODY ASSEMBLY. FORD CORPORATE SEND ME A LETTER BACK, SIMPLY SAID I'M PAST WARRANTY AND UNABLE TO PROVIDE REIMBURSEMENT. THEY DID NOT REPLY REGARDING MY QUESTION ABOUT WHAT'S BEING DONE ABOUT THIS DANGEROUS PROBLEM. *TR

I HAVE A 2006 FORD EXPEDITION EDDIE BAUER UNDER 5 YEARS OLD THAT THE TAILGATE IS SEVERELY BLISTERED ALL OVER, PAINT HAS EVEN POPPED OFF OF IT. THERE IS ALSO SOME ON THE HOOD. THE LOCAL FORD DEALERSHIP ADMITTED THAT FORD HAD A PROBLEM WITH THE BLISTERING PAINT AND TOLD ME HOW BAD MY VEHICLE WAS. THEY TOOK PICTURES AND SENT TO FORD. FORD REP DENIED IT AND I WAS TOLD THAT EVEN IF HOLES APPEARED AS A RESULT NOW THEY WOULD DO NOTHING FOR ME BECAUSE THEY HAD ALREADY DENIED AND ONLY LOOK AT A CLAIM FOR ONE THING ONE TIME. I PURSUED FURTHER BY CALLING CUSTOMER SERVICE AND EMAILING THEM AS WELL. THE CUSTOMER SERVICE REP ALSO ADMITTED THERE WAS A PROBLEM WITH PAINT BLISTER BUT COULD DO NOTHING FOR ME BECAUSE IT HAD ALREADY BEEN DENIED. I HAVE OWNED FORDS ALL OF MY LIFE AND EVEN WORKED FOR A LINCOLN MERCURY DEALERSHIP FOR SEVERAL YEARS. I AM CONTINUING TO PURSUE THIS AS FAR AS I CAN AND ASK FOR ANY HELP THAT CAN BE OFFERED IN THIS MATTER. *TR

2006 FORD EXPEDITION (LAW ENFORCEMENT PACKAGE) WITH STEEL WHEELS AND APPROX. 120,000 MILES; WHEEL SEPARATION (CRACKED ALONG WELD). PRIOR TO THE FAILURE, THIS VEHICLE WAS USED DAILY FOR ROUTINE LAW ENFORCEMENT PATROL DUTIES. WE HAVE HAD THIS ISSUE ON SEVERAL 2006 EXPEDITIONS. UPON LEARNING OF THE POTENTIAL FOR THE WHEEL FAILURE, WE HAVE IMPLEMENTED PROCEDURES TO INSPECT THE WHEELS FOR CRACKS AND OTHER DAMAGE REGULARLY. IN ALL CASES, THERE HAVE BEEN NO OBVIOUS WARNING SIGNS BEFORE FAILURE. THIS PROBLEM WAS DISCOVERED WHEN THE OFFICER NOTICED A FLAT TIRE PRIOR TO STARTING HIS SHIFT FOR THE DAY. UPON FINDING THE CRACKED WHEEL A NEW REPLACEMENT WHEEL WAS INSTALLED ON THE VEHICLE. *TR

2006 FORD EXPEDITION FAILSAFE MODE COMES ON. IT HAS HAPPENED 4 TIMES IN 4 MONTHS. HAVE LOSS OF STEERING AND ENGINE HAS NO POWER. VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING IN A PARKING LOT AT ABOUT 15MPH, THE VEHICLE JUST SHUT OFF. A LIGHT ON THE INSTRUMENT PANEL INDICATED THAT THE VEHICLE WAS IN " ENGINE FAIL SAFE MODE". THE CONTACT PUT HER HAZARD LIGHTS ON, PUT THE VEHICLE IN PARK AND TURNED THE ENGINE OFF. SHE RESTARTED THE VEHICLE AND IT OPERATED NORMALLY. THE CONTACT STATED THAT THIS HAS HAPPENED ABOUT 6-7 TIMES. SHE REPORTED THE FAILURE TO THE MANUFACTURER AND THEY STATED THAT THEY NEVER HEARD OF ANYTHING LIKE THIS. THE DRIVER DOES NOT FEEL HER VEHICLE IS SAFE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE IS 52,691.

SPARKS PLUGS BLEW OUT RIGHT AT 60,000 MILES ON 2006 FORD EXPEDITION ON OUR WAY FROM MARYLAND TO LOUISIANA. STARTED GETTING PROBLEMS IN NORTH CAROLINA. AFTER SPENDING 2000.00 FOR HOTEL, RENTAL CAR AND POSSIBLE FIX BY FIRESTONE..IT STILL WAS NOT WORKING. BROUGHT TO FORD DEALERSHIP AND SAID IT WAS SPARK PLUGS THAT BLEW AND A COMMON THING FOR F150S AND IT WOULD COST OVER 7,000.00 TO FIX IT AND RECOMMENDED TRADING IT IN. SO WE DID CAUSE WE HAD NO CHOICE WITH THE TRUCK BEING IN NC. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE FAIL SAFE MODE WAS ACTIVATED AND MADE IT IMPOSSIBLE TO CONTINUE DRIVING AFTER THE VEHICLE WAS STOPPED. THE VEHICLE WOULD NOT ACCELERATE OR TURN IN ANY DIRECTION. IF THE VEHICLE WAS TURNED OFF AND RESTARTED THE VEHICLE WOULD FUNCTION PROPERLY. THE VEHICLE MALFUNCTIONED WHENEVER THE VEHICLE WAS PULLING OFF FROM A STOP. THE VEHICLE HAD 38,000 AT THE TIME OF THE FAILURE AND THE CURRENT MILEAGE WAS 38,500 CURRENT MILES.

REAR DOOR PAINT BLISTERS. *TR

ENGINE SHUTS OFF WHILE RUNNING. LAST TIME ON THE FREEWAY. MY MECHANIC SAYS THE SYSTEMS READS OK ON COMPUTER DIAGNOSTIC, BUT THE FAIL-SAFE SYSTEM DEFINITELY SHUT THE ENGINE DOWN DUE TO A POSSIBLE GLITCH IN THE SYSTEM. DEALERS "SEE" GOOD READINGS FOR THROTTLE SYSTEM AND WILL NOT REPLACE A "GOOD" PART. WHEN THIS HAPPENS, CAR HAS NO POWER WITH NO WARNING. IT HAS HAPPENED TWICE AND WE DON'T KNOW WHEN IT WILL HAPPEN AGAIN. *TR

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 88,607 MILES. AFTER REPORT 10307412, WE COMPLETED A FLEET WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS. THIS IS THE 4TH INCIDENT OF THIS NATURE TO OCCUR WITHIN 2 YEARS. THE OTHER 3 TIMES THE FAILURE OCCURRED ON OTHER FORD EXPEDITIONS. REPORTS WERE FILED HERE. SEE COMPLAINT 10286279, 10307412. BASED ON PRIOR 3 FAILURES, A UNIT-08 FOREST WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS IS UNDERWAY. I CURRENTLY HAVE TWO RIMS WITH TYPICAL RIM FAILURE AT THE BEAD FACE WELD FROM TWO DIFFERENT VEHICLES. PLEASE ADVISE IF PHOTO DOCUMENTATION IS REQUIRED. AFTER INSPECTION BY FORD TECHNICIAN, ALL 4 WHEELS WERE REPLACED. RECOMMEND FORD INITIATE A RECALL ON STEEL WHEEL FOR CRACK INSPECTION ASSOCIATED WITH 2003 AND NEWER FORD VEHICLES WITH STEEL WHEELS. *TR

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 71,000 MILES, THIS IS THE 3RD INCIDENT OF THIS NATURE TO OCCUR WITH 2 YEARS. THE OTHER 2 TIMES THE FAILURE OCCURRED ON ANOTHER FORD EXPEDITION. UNKNOWN IF REPORTS WERE FILED HERE. SEE COMPLAINT 10286279. BASED ON PRIOR 2 FAILURES, A REGION WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS IS UNDERWAY. IF A PHOTO IS NEEDED, I HAVE THAT AS WELL

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION WHICH WAS PURCHASED BRAND NEW. WHILE STEPPING ON THE ACCELERATOR PEDAL AT ANY SPEED INCLUDING APPROXIMATELY 25 MPH, THE PEDAL BECAME STUCK IN THE OPEN THROTTLE POSITION. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE WAS ALSO REPORTED TO THE MANUFACTURER. THERE WERE NO RECALLS. NO REPAIRS WERE MADE TO DATE. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 45,000.

I HAVE A 2006 FORD EXPEDITION WITH APPROX. 42,000 MILES. THE INCIDENT THAT OCCURRED WITH THIS VEHICLE, WHICH IS DANGEROUS, IS WHEN THE VEHICLE'S ENGINE FAILSAFE MODE ENGAGES. I WAS ACCELERATING FROM A STOP ON A TWO LANE ROAD WHEN THE ENGINE FAILSAFE MODE ENGAGED. WHEN THIS OCCURRED, I LOST THROTTLE CONTROL, ALMOST CAUSING ANOTHER VEHICLE TO STRIKE THE REAR OF MY VEHICLE. THE SECOND INCIDENT WAS ON DEC. 28, 2009. I WAS MAKING A LEFT TURN ONTO A SIDESTREET WHEN THE ENGINE FAILSAFE MODE OCCURRED AGAIN CAUSING ME TO LOSE CONTROL OF THE ACCELERATOR. I WAS ALMOST HIT BROADSIDE WHEN THIS INCIDENT OCCURRED. THE ONLY WAY TO REGAIN THROTTLE CONTROL IS TO TURN THE VEHICLE OFF AND RESTART THE VEHICLE. BY TURNING OFF THE VEHICLE IT ALSO RESETS THE ENGINE FAILSAFE MODE. UPON CHECKING THE ENGINE FAILSAFE MODE ON THE INTERNET, IT APPEARS TO BE A COMMON PROBLEM. SOMEONE SHOULD MAKE FORD FIX THIS PROBLEM BEFORE SOMEONE GETS SERIOUS INJURED OR KILLED. *TR

FORD EXPEDITION STEEL WHEEL RIM FAILURE. *TR

THREE SEPARATE TIMES THE CAR SHUT OFF IN DIFFERENT TYPES OF "ENGINE FAILSAFE MODE" WITHIN THE PAST 7WEEKS. ENGINE FAILSAFE MODE CAUSES THE VEHICLE TO LOSE ALL POWER. LAST TIME THIS HAPPENED ON THE HIGHWAY AT 60 MPH WITH TWO SMALL CHILDREN IN THE VEHICLE. OTHER TWO TIMES IT OCCURRED WHEN SLOWING DOWN TO TURN. THERE IS GREAT POTENTIAL FOR THIS TO LEAD TO A VERY DANGEROUS SITUATION. OWNER'S MANUAL POINTS TO CRUISE CONTROL OR THROTTLE SYSTEM STUCK ALTHOUGH THE CRUISE CONTROL WAS NOT IN USE. EACH TIME VEHICLE RESTARTED WITH NO ISSUES. DEALER REPORTED IT WAS AN ISSUE WITH THE THROTTLE BODY AND POSSIBLY THE THROTTLE GETTING STUCK WIDE OPEN . NO EXPLANATION OR INVESTIGATION WAS DONE TO DETERMINE SPECIFIC ISSUES WITH THE THROTTLE BODY, EXCEPT IT JUST NEEDED TO BE REPLACED. REPAIR AT THIS PARTICULAR DEALER RUNS $800. NO DIAGNOSTICS WERE DONE ON THE THROTTLE POSITION SENSOR. ALTHOUGH COMPLETELY UNRELATED, THE DEALER OFFERED HALF OFF THE $600 60K TUNE-UP IF I REPLACED THE THROTTLE BODY. RESEARCH INDICATES THIS HAS HAPPENED TO A LOT OF 05/06 EXPEDITION VEHICLES WITH APPROX. 50-65K MILES, SIMILAR TO MY VEHICLE. I HAVE YET TO REPAIR THE VEHICLE, PART IS STILL ON IT. *TR

DRIVING VEHICLE AND CAR SHUT OFF. A WRENCH SYMBOL APPEARED. AFTER 2 ATTEMPTS, I WAS ABLE TO GET THE VEHICLE RESTARTED. TOOK CAR TO GARAGE FOR SERVICE AND WAS INFORMED THAT THE COMPUTER CODE WHICH CAME BACK WAS THE "CRUISE CONTROL CIRCUITRY" AND I WOULD NEED TO TAKE THE VEHICLE TO A FORD DEALERSHIP FOR SERVICE DUE TO THE NATURE OF THE REPAIR. *TR

THIS COMPLAINT IS IN REFERENCE TO OUR 2006 FORD EXPEDITION. THIS FAILURE AT THIS TIME SEEMS TO BE OCCURRING DURING NORMAL VEHICLE OPERATION, AT RANDOM INTERVALS. THE FAILURE IS BEING REPORTED BY THE OBD TO BE "THROTTLE BODY STUCK WIDE OPEN" WHICH RESULTS IN THE VEHICLE ENTERING FAILSAFE MODE, WHICH APPEARS TO RESTRICT THE RPM'S OF THE ENGINE. UPON ENTERING FAILSAFE MODE THE VEHICLE TENDS TO STALL AND SUBSEQUENTLY WILL NOT START FOR A SHORT PERIOD OF TIME FOLLOWING THE FAILURE. THIS FAILURE OCCURS WEEKLY AT VARIOUS TIMES OF THE DAY. AT THIS TIME THE CONCERN IS THAT IF THERE IS ANY FAILURE ON THE PART OF THE "FAILSAFE" MODE, THE VEHICLE WILL BE UNRESPONSIVE TO THE OPERATORS THROTTLE CONTROL AND IF THE THROTTLE BODY IS IN FACT STUCK WIDE OPEN THE VEHICLE WILL PROCEED TO INCREASE SPEED WITHOUT REGARD TO THE OPERATORS CONTROLS, RENDERING THE VEHICLE OUT OF CONTROL. AFTER SPEAKING WITH THE SERVICE DEPARTMENT AT OUR LOCAL FORD DEALERSHIP THE RECOMMENDED COURSE OF ACTION IS TO REPLACE THE THROTTLE BODY AS THIS IS A "COMMON OCCURRENCE". SEARCHES OF THIS ISSUE ONLINE RESULT IN MANY 2006 EXPEDITION OWNERS REPORTING THIS ISSUE FOR VEHICLES WITH MILEAGES RANGING FROM 50,000-55,000. THE FORD SERVICE DEPARTMENT STATED THAT THERE WAS A SERVICE BULLETIN ON THIS ISSUE BUT THAT IT DID NOT APPLY TO OUR VIN. SEARCHING THE ODI SERVICE BULLETIN DATABASE YIELDED NO RESULTS REGARDING THIS ISSUE. *TR

I HAVE A 2006 FORD EXPEDITION WITH 50,000 MILES ON IT. MY WIFE DRIVES THIS CAR WITH OUR CHILDREN. ABOUT 7 OR 8 TIMES NOW THE CHECK ENGINE OR (WRENCH LIGHT) COMES ON GOING DOWN THE ROAD AND SHUTS THE CAR OFF COMPLETELY. I HAVE LOOKED ONLINE AND HAVE SEEN THAT THOUSANDS OF PEOPLE ARE HAVING THE SAME THING HAPPEN TO THEM. FROM WHAT I READ IT HAS SOMETHING TO DO WITH THE ELECTRONIC THROTTLE CONTROL. I KNOW YOU PROBABLY GET COMPLAINTS ALL THE TIME BUT THIS IS VERY SERIOUS. EVERY POST ON THE WEB SAYS THAT FORD HAS NO RECALL AND THAT THE DEALERSHIPS ARE DOING NOTHING TO FIX THIS PROBLEM BUT PUTTING A NEW PART ON AND CHARGING FOR IT. THIS IS ABSOLUTELY RIDICULOUS. THERE IS OBVIOUSLY A PROBLEM. PLEASE HELP ME AND OTHERS TO FIX THIS PROBLEM BEFORE SOMEONE GETS HURT. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE PAINT ON THE TAIL GATE AND FRONT HOOD HAD BEGUN TO CRACK AND BUBBLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE TECHNICIAN CONCLUDED THAT NONE OF THE PAINT CAN BE SERVICED UNTIL CORROSION WAS EXHIBITED. THE CURRENT AND FAILURE MILEAGES WERE 82000.

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 90,200 MILES, THIS IS THE 4TH INCIDENT OF THIS NATURE TO OCCUR. THE OTHER 3 TIMES THE FAILURE OCCURRED ON ANOTHER FORD EXPEDITION AND REPORTS WERE FILED HERE WITH THE NHTSA. *TR

OUR 2006 FORD EXPEDITION ONLY HAD 35,490 MILES, AND WOULD START UP WITH A RATTLE. THE AIR WAS OK, BUT IT STOPPED WORKING OVER THE WEEKEND AND THE START UP RATTLE IN THE MORNING WENT AWAY. WE TOOK IT TO FORD, AS WE HAD 19 DAYS LEFT ON THE MANUFACTURE WARRANTY, AND IT NEEDED A NEW COMPRESSOR ASSEMBLY AND MANIFOLD AND TUBE ASSEMBLY, SUCTION AND DISCHARGE. NOW OUR AIR IS JUST LIKE NEW, NO START UP RATTLE. I SEARCHED THE INTERNET AND SEEMS MANY PEOPLE WITH THIS RATTLE, HAVE BEEN TOLD IT'S JUST SOMETHING THAT THE FORD EXPEDITION DOES. WE NOTICED DIE IN THE DISCHARGE THAT CAME FROM THE COMPRESSOR WHEN IT FAILED, LIKE SOMEONE HAD LOOKED AT THIS BEFORE AND JUST PATCHED IT. WE BOUGHT IT FROM CARMAX JAN 2009. I THINK A RECALL NEEDS TO TAKE PLACE FOR ALL 2006 FORD EXPEDITION OWNERS CAN GET THEIR AC COMPRESSOR AND MANIFOLD AND TUBE REPLACED. *TR

MY CAR STALLED AT AN INTERSECTION LIGHT. IT WAS DRIVING POORLY-MAKING LOUD NOISES AND STICKING AS I PRESSED THE GAS PEDAL AS IF THE TRANSMISSION WAS GOING OUT. WE WERE TOLD IT WAS COVERED UNDER THE POWERTRAIN WARRANTY AND WE TOOK IT IN TO FORD. THEY TOLD US IT WAS THE TIMING CHAIN BUT BECAUSE THERE WAS EVIDENCE OF SLUDGE, THE WARRANTY CLAIM WAS DENIED BY FORD. THEY CLAIM WE DID NOT MAINTAIN OUR VEHICLE. WE BELIEVE IT IS A DEFECT IN THE SYSTEM. WE HAVE MAINTAINED THE OIL ON A REGULAR BASIS AND HAVE HAD OTHER MAJOR REPAIRS WITH THIS CAR. IT HAS HAD A NEW TRANSMISSION AT 35,000 AS WELL AS A NEW SUSPENSION SYSTEM AND ELECTRICAL FAILURE WITH THE STEREO/DVD SYSTEM. THERE HAS NEVER BEEN ANY PRIOR EVIDENCE OF SLUDGE. AN ACCIDENT COULD HAVE OCCURRED WHEN THE CAR STALLED. *TR

DEFECTIVE PAINT. *TR

LOW DRIVER SIDE TIRE INDICATOR SOUNDED A FEW HOURS PRIOR TO ACCIDENT WHERE VEHICLE FLIPPED OVER 4 TIMES 70-80 FEET END OVER END BOUNCED OFF A TELEPHONE POLE THEN LANDED IN THE OPPOSITE LANE BACK WARDS. THE LOW TIRE INDICATOR HAD GONE OFF TWICE TO WHICH THE TIRE WAS TAKEN TO THE STATION TO BE REFILLED UP TO AIR PRESSURE AS RECOMMENDED BY THE SERVICE MANUAL. DRIVING SPEED WAS CLOSE TO 50 MPH ON A SLIGHTLY RURAL ROAD WITH NOT MANY TURNS MOSTLY STRAIGHTAWAYS. JUST COMING OUT OF A SMALL RIGHT TURN THE TIRE MUST HAVE LOST AIR JERKED THE STEERING CAUSING THE VEHICLE TO ROLL OVER END OVER END CARTWHEELING AND LANDING IN 4 SPOTS ACCORDING TO TIRE MARKS ON THE ROAD ITSELF EACH DOUBLE LINED MARK WAS ON THE CENTER LINE OF THE ROAD ABOUT 70-80 FEET APART BEFORE HITTING THE POLE AND BOUNCING THE VEHICLE INTO THE OPPOSITE LANE FACING THE OTHER DIRECTION. WHERE UPON AIDE OF OTHERS IT COULD NOT BE RESTARTED AND THE DRIVERS SIDE TIRE WAS COMPLETELY UNUSABLE. THE VEHICLE BROKE OUT 3 WINDOWS AND THE WINDSHIELD IS WASTED, CAN BE STARTED BUT GRINDS WHEN PUT IN GEAR, CAN NOT BE DRIVEN EVEN AFTER TIRE REPLACEMENT. *TR

ENGINE FAILURE OF 2006 FORD EXPEDITION. DEALERSHIP EXPLAINED THE ENGINE HAD A BENT INJECTOR ROD . ADVISED NEW ENGINE WAS NECESSARY. COST ESTIMATE $4000-$7000. *TR

PAINTED METAL TRIM AT THE BOTTOM OF SIDE WINDOWS IS RUSTING AND THE PAINT IS PEELING. IF PAINTED CORRECTLY AT THE FACTORY NO WAY THIS WOULD BE HAPPENING. I HAVE ALSO NOTICED THIS SAME PRBLEM ON MANY OTHER EXPEDITIONS, YET FORD SAYS NOT THERE PROBLEM. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 20 MPH, THE VEHICLE STALLED. THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND READ, "ENGINE FAIL SAFE MODE." AFTER SEVERAL ATTEMPTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE DEALER REPLACED THE THROTTLE BODY ASSEMBLY. AFTER THE REPAIR, THE CONTACT BEGAN SMELLING A BURNING OIL ODOR IN THE VEHICLE. THE SMELL BECAME STRONGER AND THEN TURNED INTO A GASEOUS ODOR, WHICH WAS ALSO ENTERING THROUGH THE INTERIOR VENTS. THE CONTACT INSPECTED THE VEHICLE, BUT COULD NOT LOCATE ANY GAS LEAK. THE ODOR BECAME SO OVERPOWERING THAT ONE OF THE OCCUPANTS HAD A NOSE BLEED AND SEVERAL OTHER OCCUPANTS SUFFERED HEADACHES AND STOMACH ACHES. THE DEALER STATED THAT THE OIL LEVEL WAS TOO HIGH AND CAUSED THE FUEL ODOR. THE ODOR IS STILL PRESENT. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 66,000.

I HAVE A 2006 FORD EXPEDITION THAT HAS BUBBLING AND PEELING PAINT ON THE HOOD AND BACK HATCH. *TR

2006 FORD EXPEDITION, HAS STOPPED SEVERAL TIMES WHILE IN ROUTE SOMEWHERE. JUST STOPS AT ONCE AND SAFE MODE FAILURE LIGHT COMES ON. POWER STEERING FAILS, AS WELL AS ENGINE STOPPING. HAVE HAD REBUILT TRANSMISSION, REPLACE THE THROTTLE, AND SEVERAL OTHER THINGS INCLUDING I BELIEVE AIR PUMP. NONE OF THIS CHEAP. BUT BIGGEST CONCERN IS THE SAFETY OF THE VEHICLE. HAVE BEEN VERY BLESSED THAT NO ONE HAS BEEN BEHIND ME WHEN THIS HAS HAPPENED OR ON THE HIGHWAY. THIS IS VERY SCARY AND FORD NEEDS TO RECALL AND FIGURE OUT WHAT IS CAUSING THIS TO OCCUR. *TR

MY 2006 EXPEDITION HAD A SPARK PLUG BLOWOUT. I UNDERSTAND THIS IS A FREQUENT PROBLEM AND IS A DESIGN DEFECT VERSUS A MAINTENANCE ISSUE. I DID BUY THE EXTENDED WARRANTY AND HAVE BEEN TOLD IT IS NOT COVERED. *TR

A WHEEL SEPARATED ON A 2006 FORD EXPEDITION. WE REPLACED THE WHEEL AND I HAVE THE ORIGINAL THAT FAILED. *TR

ENGINE SHUTS OFF WHILE DRIVING DOWN THE STREET. ENGINE FAIL-SAFE LIGHT IS DISPLAYED. WAS BARELY ABLE TO STEER THE VEHICLE TO A SAFE AREA. RESTARTED ENGINE, EVERYTHING CAME BACK UP AGAIN. *TR

MY TRUCK WENT INTO FAIL SAFE MODE WHILE ON THE HIGHWAY. THIS CAUSED THE TRUCK TO STOP SUDDENLY WITH NO USE OF GAS PEDAL BUT THE ENGINE WAS STILL RUNNING. THIS ALMOST CAUSED AN ACCIDENT. I WAS ABLE TO DRIFT OVER AND SHUT THE ENGINE OFF AND RESTART IT AND IT RAN FINE THE REST OF THE DAY. NOW I AM AFRAID TO DRIVE IT. *TR