2001 Ford Expedition complaints

DT: THE CRUISE CONTROL WENT OUT, THE MEMBRANE BROKE. THE BRAKE FLUID FILLED THE SERVO OF THE CRUISE CONTROL. IT WAS FROM THE BROKEN MEMBRANE ON THE CRUISE CONTROL SWITCH. DEACTIVATION SWITCH WAS LEAKING, CRUISE CONTROL SERVO WAS FULL OF FLUID. THAT WAS THE STATEMENT FROM THE INVOICE. THE CONSUMER NOTICED THE CRUISE CONTROL STOPPED WORKING, LAST WEEK. THE FORD WAS CALLED, AND THEY TOLD CONSUMER TO CHECK THE DEACTIVATION SWITCH. AT THAT POINT, THE CONSUMER NOTICED THE DEACTIVATION SWITCH WAS FULL OF FLUID. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THE PART WAS ON BACK ORDER. THE DEACTIVATION SWITCH WAS CHANGED, AND THE CRUISE CONTROL WILL NOT WORK UNTIL THE SERVO WAS INSTALLED. THE VEHICLE WAS 2001 FORD EXPEDITION. IT WAS COSTING THE CONSUMER $516 TO FIX THIS $21 PART.*AK

FUSE BOX AND MODULE ALL KINDS OF ELECTRIAL PROBLEMS ALSO CAR WILL START ON ITS OWN THE CAR WILL JUMP INTO REVERSE

THE FRONT PASSENGER SEAT-BELT BUCKLE BECOMES UNLATCHED ON AN INTERMITTANT BASIS. BELT BUCKLE WILL INSERT AND SNAP MOST OF HTE TIME, BUT THERE HAVE BEEN SEVERAL INSTANCES WHEN THE BUCKLE SNAPPED AS IF IT WAS LATCHED, BUT COME UNLATCHED WHEN A FORCE WAS APPLIED TO THE BUCKLE (AS WHEN LEANING FORWARD).

BEGINNING ABOUT 8-12 MONTH'S AGO, THE RIGHT REAR CHILD SAFETY LOCK FREQUENTLY SWITCHES FROM THE "UNLOCKED" POSITION TO THE "LOCKED" POSITION, APPROXIMATELY EVERY 3RD-TO-4TH TIME THE RIGHT REAR DOOR IS SHUT. THIS MALFUNTION OF A SAFETY FEATURE CREATES SITUATIONS WHERE THE PASSENGER IS LOCKED WITHIN THE CAR AND CANNOT LET THEMSELVES OUT UNLESS THE DOOR IS OPENNED FROM THE OUTSIDE.

MY 2001 FORD EXPEDITION'S (65300 MILES) CABLE WHICH MOUNTS THE SPARE TIRE UNDER THE VEHICLE HAS FRAYED AND THE TIRE HAS FALLEN OFF. I CALLED MY LOCAL DEALERSHIP, WHICH JUST WORKED ON THE CAR, AND THEY SAID, "YA, WE'VE SEEN THAT HAPPEN A FEW TIMES... THE CABLE RUSTS OUT, AND THE TIRE FALLS OFF." I HAVE NEVER BOTTOMED OUT THE CAR, WE HAVE BEEN THE SOLE OWNERS, AND IT WAS JUST IN TO FORD FOR REPAIRS, AND A "SAFETY INSPECTION" SO IT MUST HAVE HAPPENED RECENTLY. I HAVE NO IDEA WHEN OR WHERE THIS COULD HAVE HAPPENED. I MUST HAVE BEEN DRIVING, BECAUSE OTHERWISE I WOULD HAVE BACKED OVER IT, HAD I BEEN PARKED. I MAY HAVE BEEN GOING 65 MPH DOWN THE HIGHWAY WITH MY THREE CHILDREN IN THE CAR! AND GOD HELP ANYONE BEHIND ME! THIS SEEMS TO ME TO BE AN EXTREMELY DANGEROUS DEFECT, I CAN ONLY HOPE MY CAR WAS NOT THE CAUSE OF AN ACCIDENT TO ANOTHER. NOW I AM FORCED TO ENDURE YET ANOTHER COSTLY REPAIR TO A CAR, WHICH FOR ITS LIMITED 65,000 MILES HAS ALREADY HAD ITS SHARE. TWO MONTHS AGO I WAS TOLD THAT I WAS LUCKY THAT I BROUGHT IT IN FOR REPAIRS TO AN ENGINE PROBLEM, BECAUSE ITS BALL JOINTS WERE SO BAD THAT THE FRONT WHEELS WERE GOING TO FALL OFF! THIS IS NOT THE KIND OF THING THAT A MOTHER, WHO USES THIS VEHICLE TO TRANSPORT HER THREE SMALL CHILDREN AROUND IN, WANTS TO HEAR! AND NOW, THE SPARE TIRE HAS FALLEN OFF! IT WILL REQUIRE THE REPLACEMENT OF THE MOUNTING MECHANISM, AS WELL AS THE TIRE AND WHEEL, ASSUREABLY, NOT TO BE CHEAP! THANK YOU FOR YOUR TIME AND CONSIDERATION. RESPECTFULLY, KIM WY

THIS EXPEDITION STARTS UP WITH NO KEY WIPERS START AND STOP DOOR LOKES OPEN AND CLOSE 4 WHEEL DRIVE ENGAGES AND DISENGAGES IN PARK OR NEUTRAL THE CAR TRIES TO START AGAIN WHEN IT IS ALREADY RUNNING . THE CAR WAS PARKED WHILE I WENT INTO THE STORE MY WIFE WAS IN THE CAR IT JUMPED INTO REVERSE SHE JUMPED OUT OF THE CAR THE DOOR HIT HER NOCKED HER DOWN AND ALMOST RAN HER OVER THIS CAN BE REPEATED THE FUSE BOX AND MODULE WERE REPLACED AT A COST OF ABOUT $1,000.00 ALSO I HAD TO REPLACE THE FRONT WINDSHIELD AS IT WAS LEAKING THEY SAID THE CAR WAS OUT OF WARRENTY THE CAR HAS NEVER BEEN IN A ACCIDENT .

DT: CONTACT STATES THE WINDSHIELD IS LEAKING, CAUSING THE COMPUTER IN THE FUSE PANEL TO SHORT OUT. THE STEREO, WINDSHIELD WIPERS, AND THE AIR CONDITIONER COME ON WHEN THE VEHICLE WAS NOT IN USE. WINDSHIELD WAS REPLACED. WARRANTY EXPIRED , AND ELECTRONIC PANEL HAD NOT BEEN REPLACED. FORD MANUFACTURER HAS BEEN CONTACTED.*AK

2001 FORD EXPEDITION (EDDIE BAUER) HAS HAD REPEATED WATER LEAKS IN FRONT WINDSHIELD. I'VE HAD THE WINDOW REPLACED ONCE AND REPAIRED 2 MORE TIMES, SO FAR IN THE PAST 2 YEARS. IT CAUSED MY AUTOMATIC HEAD-LIGHT CONTROL SWITCH TO FAIL. ALSO MY REAR-WINSHIELD WIPERS FAILED ONCE, BUT I'M NOT SURE IF IT WAS RELATED TO A WINDSHIELD LEAK.

I HAD COMPLETE FAILURE OF ELECTRICAL SYSTEMS DUE TO WATER LEAK AROUND FRONT WINDSHIELD AND/OR MOON ROOF

NO FAILURE AT THIS TIME, HOWEVER WE ARE CONCERNED ABOUT THE SAFETY OF THE VEHICLE GIVEN THE SERIOUS NATURE OF THE FIRE HAZARD (CRUISE CONTROL).

PURCHASED A 2001 FORD EXPEDITION FROM MAROONE FORD IN MARGATE ON 11/05/2004. THE TIRES THAT CAME WITH THIS VEHICLE WERE THE CONTITRAC AW ID # 02T012000. ON 04/02/05 WHILE TRAVELING ON I-95 AT THE SPEED OF 55 MPH MY LEFT REAR TIRE BLEW OUT. I WAS ABLE TO GET THE TRUCK UNDER CONTROL WITHOUT HITTING ANY OTHER CARS AND I WAS NOT INJURED. I HAD THAT TIRED REPLACED THE SAME DAY AND THOUGHT IT MUST HAVE BEEN SOMETHING ON I-95 THAT CAUSED THE TIRE TO BLOW OUT. ON 05/21/05 WHILE TRAVELING EAST ON COMMERCIAL BLVD IN FORT LAUDERDALE FLORIDA AT A SPEAD OF 30 MHP THE RIGHT REAR TIRE BLEW OUT, I DROVE THE TRUCK INTO TIRE KINGDOM AND HAD THAT TIRE REPLACED AS WELL. THIS MORNING WHILE PARKING AT WORK I NOTICED THREAD SEPARATION LUMPS HAD DEVELOPED ON THE TWO REMAINING TIRES, AT THIS POINT I REALIZED SOMETHING HAD TO BE WRONG WITH THE TIRES, AND THROUGH THE INTERNET I FOUND OUT THERE WAS A RECALL ON THESE TIRES. I CONTATED THE DEALERSHIP WHO SOLD ME THE TRUCK INMEDIATELY AND WAS TOLD THEY COULD NOT DO ANYTHING TO CORRECT THE PROBLEMP BECAUSE TO THEIR KNOWLEDGE THERE IS NO RECALL IN EFFECT FOR THESE TIRES AND THAT THE MANUFACTURER WOULD HAVE TO BE THE ONE TO REPLACE THEM, BUT THAT IF I COULD NOT WAIT TO THEN TAKE THE TRUCK TO THE NEAREST TIRE KINGDOM TO HAVE THE TIRES REPLACED AND THAT THEY WOULD PRO RATE THE COST OF THE TIRES. I HAD BOTH TIRES REPLACED THIS AFTERNOON, AGAIN AT MY OWN EXPENSE. IN THE PAST TWO MONTHS I HAVE REPLACED ALL FOUR TIRES ON THIS VEHICLE, AND THE DEALERSHIP HAS NOT BEE

VEHICLE CAUGHT FIRE WHILE PARKED, COMPLETELY ENGULFED IN FLAMES

DT: THERE ARE RECALLS THAT SHOULD BE INVESTIGATED CAR IS A 2001, BUT THEY WILL NOT RECOGNIZE CAR AS A RECALL BECAUSE THEY RECALLED THE 2000 MODELS AND NOT THE 2001. THIS CAR WAS DELIVERED IN 2001, AND THEY USED 2000 PARTS, ALTHOUGH IT IS A 2001 MODEL. THEY CHANGED THE TRANSMISSION DESIGN. *AK

THE VEHICLE COMPLETELY BURNED DUE TO A FIRE THAT ORIGINATED FROM THE FUSE OF THE MASTER CRUISE CONTROL MODULATOR AREA OF MASTER BRAKE CYLINDER. *JB THIS MAKE/MODEL IS UNDER INVESTIGATION BY CPSC FOR A MNUFACTIRER DEFECT OF THE CRUISE CONTROL SYSTEM. *SC *JB

TIRE BLEW OUT WHILE TRAVELING CAUSING VEHICLE TO FISHTAIL FROM SIDE TO SIDE, NO CRASH

VEHICLE PARKED FOR APPROX. 22 HOURS, CC QUIT WORKING 1 WEEK PRIOR, ONE DAY BEFORE VEHICLE FIRE WOULD NOT GET OUT OF PARK

2001 FORD EXPEDITION CAUGHT ON FIRE IN THE STEERING WHEEL AREA UNDERNEATH THE HOOD. *MR THE VEHICLE WAS PARKED THE DAY BEFORE THE INCIDENT OCCURRED. AROUND 9 AM THE CONSUMER VIEWED SMOKE COMING FORM THE VEHICLE. THE VEHICLE WAS TOTALED. *SC *JB

VEHICLE PARKED IN GARAGE AND STARTED ON FIRE. CRUISE CONTROL QUIT WORKING PRIOR TO FIRE. VEHICLE SEVERELY DESTROYED AND FUSES OBLITERATED. CRUISE CONTROL DEACTIVATION SWITCH COMPONENETS RECOVERED AND XRAYED. INTERNAL CONTACTS ARCED AND SPLATTERED. ALSO ARCING ON WIRING HARNESS ADJACENT TO VACUUM BOOSTER.

THIS IS THE SECOND SPARK PLUG IN LESS THAN 4 MONTHS THAT HAS BLOWN OUT OF THE CYLINDER HEAD OUT OF OUR 2001FORD EXPEDITION. PLEASE INVESTIGATE THIS PROBLEM AS IT IS OCCURRING TO MANY PEOPLE. IT IS DEFINITELY A FLAW IN DESIGN AND IS COSTING PEOPLE TOO MUCH MONEY TO CONTINUE TO FIX. FORD HAS BEEN NO HELP. AS THE LAST TIME, WHILE DRIVING THE SPARK PLUG JUST BLOWS THROUGH THE CYLINDER HEAD ON A VEHICLE THAT HAS BEEN IMPECCABLY MAINTAINED.*AK

DRIVING ABOUT 40 MILES PER HOUR IN MY 2001 FORD EXPEDITION W/ TRITON V8 5.4L WHEN I HEARD A LOUD POP. VEHICLE WAS VERY LOUD AFTERWARDS BUT STILL DRIVEABLE. HAD TO STAY UNDER 15 MPH TO TURN AROUND AND DRIVE IT THE ONE MILE I HAD ALREADY DRIVEN TO RETURN HOME. GREATER THAN 15 MPH PRODUCED SOUNDS SIMILIAR TO THE SOUND OF AN EXTREMELY LOUD LAWNMOWER. PROBLEM: BLEW A SPARK PLUG. DON'T KNOW WHICH ONE YET BUT FROM WHAT I AM READING ON THE INTERNET, THE REPAIR WILL BE SURE TO DRAIN MY WALLET. AM HAVING IT TOWED TO THE DEALER TONIGHT TO FIND OUT THE DAMAGE TO MY ENGINE AND MY PURSE.*AK

SURGE GAS/ODI NO.10108106- 010,ODI895445,ODI897959,ODI8009292,ODI8012749,ODI10037108,ODI10041253.ODI10066799,ODI10080504, I HAVE A LOT MORE OFF YOUR SITE, SURGE IS GOING TO HURT SOMEONE PLEASE, THIS DOES WARRENT A SAFETY ON THIS. PLEASE RESPOND, MY GARBAGE CAN COULD HAVE BEEN A CHILD IN CROSSWALK.*AK

VEHICLE WAS PARKED FOR OVER 38 HOURS. AT 2:30 AM ON MONDAY APRIL 4, 2005 OWNER WAS AWAKENED BY A NEIGHBOR INFORMING HER THAT VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS ALSO NOTIFIED. LATER, THE OWNER CONTACTED THE MANUFACTURER, AND WAS INFORMED THAT THIS VEHICLE NOT INCLUDED IN THE RECALL FOR THE SPEED CONTROL CRUISE CONTROL DEACTIVATION SWITCH DUE TO VIN. *AK

ELECTRONIC SHORTAGES IS CAUSING MALFUNCTIONS IN THE IGNITION SWITCH, WIPERS, RUNNING LIGHTS AND RADIO. THESE MALFUNCTIONS SEEM TO WORSEN WHEN IT RAINS. THE VEHICLE STARTS BY ITS SELF WHILE UNATTENDED. WHEN DRIVING IF THE WIPERS DONT WORK, I HAVE TO SHIFT THE TRANSMISSION TO NEUTRL FOR THEM TO OPERATE AND THE SAME FOR THE RADIO. I HAVE SPENT SEVERAL HUNDRED DOLLARS TO HAVE THIS PROBLEM LOOKED AT AND THE FORD DEALERSHIP STATED THAT THEY HAVE HAD SEVERAL VEHICLES COME IN WITH THE SAME PROBLEM, BUT I WOULD HAVE TO PAY AROUND $1000.00 MORE DOLLARS TO CHANGE OUT THE FUSE BOX AND STILL THIS MAY NOT THE CURE THE PROBLEM. THE TECHNITION STATED THAT WATER WAS GETTING IN BEHIND THE FUSE BOX SOME HOW. HE TOLD ME TO SILICONE THE COW DOWN TO THE WINDSHEILD TO REFLECT THE WATER, SO I DID AND IT DID NOT WORK. EVERY MORNING MY PREGANENT WIFE AS TO USE A BATTERY JUMPER BOX TO JUST START THE VEHICLE BECAUSE THE ELECTRONICS ON THE VEHICLE STAYS ON ALL THE TIME AS IF THE KEY WAS INSERTERED AND TURNED TO AUXILLARY. THE VEHICLE ATTEMPTS TO START DURING THE NIGHT BY ITS SELF. IT DOES NOT START, THE STARTER JUST TURNS OVER AS IF IT IS TRYING TO START UNTIL THE BATTERY GOES DEAD. I AM SCARED THAT THE VEHICLE IS GOING TO CATCH FIRE OR EVEN BLOW UP IN FRONT OF MY RESIDENCE. DEALERSHIP SAID THAT THEY COULD NOT FIX THE PROBLEM UNTIL ENOUGH PEOPLE CAME IN ASKING FOR THE SAME HELP. I HOPE THERE IS SOMETHING THAT CAN BE DONE ABOUT THIS 36,000.00 VEHICLE. I HAVE CARRIED THE VEHICLE TO SEVERAL OTHER MECHANICS

WHILE DRIVING AT HIGHWAY SPEED THE ACCELERATOR PEDAL STUCK, CAUSING A VEHICLE ROLL OVER WHEN T CONSUMER DEPRESSED THE BRAKES. CONSUMER/PASSENGER SUSTAINED INJURIES. VEHICLE WAS TOTALED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. THE CAUSE WAS NOT DETERMINED.*AK

WHILE PARKED IN THE GARAGE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT STATED SOURCE OF THE FIRE WAS CRUISE CONTROL SWITCH. AS A RESULT, THE VEHICLE WAS CONSIDERED A TOTAL LOSS. *AK

TIRE ROTATION/BALANCE/ALLIGNMENT DONE 1/18/05. ON 3/3/05 HAD SUDDEN VIBRATION ON INTERSTATE 75. FOUND AREA ON THE REAR PASS. SIDE TIRE APRROX 6-8 INCHES LONG & 3/4 WIDTH OF THE TIRE WITH TREAD SEPARATION. THESE WERE THE ORIGINAL GRABBERS (ON MY 2001 EXPEDITION) LOT 1377, WHICH WAS NOT PART OF THE RECALL SEVERAL YRS AGO. TIRE DEALER SAID OTHER REAR TIRE WAS ALSO SHOWING SIGNS OF TREAD SEPARATION AS WELL. TIRE HAD 49,000 MILES ON THEM WITH PLENTY OF TREAD. *AK

OWNER DROVE THE VEHICLE FOR APPROXIMATELY 51/2 HOURS, AND THEN IT SAT FOR 1 1/2 HOURS. WHEN DRIVING OFF THE FERRY AT APPROXIMATELY 15 MPH ENGINE EJECTED THE SPARK PLUG FROM THE SEVENTH CYLINDER . OWNER CONTACTED THE DEALER, AND HAD THE VEHICLE TOWED. OWNER WAS WAITING FOR THE RESULTS OF THE DEFECT. *AK

I HAVE A 1997 FORD EXPEDITION, I WAS DRIVING HOME THROUGH THE COUNTRY, WHEN GOING INTO A CURVE, I HEARD A POP COME FROM THE FRONT OF THE TRUCK. TRUCK WENT INTO A HARD LEAN , BUT I WAS ABLE TO KEEP UNDER CONTROL. FROM PREVIOUS OWNERSHIP OF A FORD EXPLORER, I KNEW WHAT HAPPENED. UPON INSPECTION SWAY BAR LINKS HAD BROKEN. *JB...UPDATED 02/11/15 *BF

CONSUMER'S VEHICLE WAS A PART OF THE RECALL FOR FORD EXPEDITION FIRES. HOWEVER, HE WAS TOLD THAT HE WOULD HAVE TO WAIT FOR SOMETIME BEFORE THE REPAIRS COULD BE DONE. CONSUMER FEELS AS THOUGHT THIS IS NOT UNACCEPTABLE. *AK

AFTER TRAVELING APPROXIMATELY 10 MILES WE PARKED OUR 2001 EXPEDITION IN THE CAR PORT AND WENT TO BED. APPROXIMATELY ONE HOUR WE WOKE UP WITH OUR HOUSE ON FIRE AT THE WEST END WHERE THE CAR PORT IS LOCATED. INVESTIGATORS AND FIRE INSPECTORS DETERMINED THE FIRE ORIGINATED FROM THE EXPEDITION BUT DUE TO THE EXTENT OF DAMAGE COULD NOT DETERMINE THE EXACT LOCATION THE FIRE STARTED OTHER THAN IN THE ENGINE COMPARTMENT. THE FIRE RESULTED IN A TOTAL LOSS OF THE VEHICLE, HOUSE, BELONGINGS, AND SEVERE BURN TO ONE FAMILY MEMBERS ARM AND EXTENSIVE DAMAGE TO ANOTHER VEHICLE PARKED CLOSE BY. THE FORD PART NUMBER FOR RECENTLY RECALLED CRUISE CONTROL SWITCHES IS THE SAME AS THE ONE ON MY EXPEDITION AND WAS CHANGED FOR THE 2002 MODELS.*AK

MY WIFE WAS DRIVING OUR 2001 EXPEDITION HOME FROM WORK WHICH IS ABOUT 35 MILES AWAY WHEN THE #2 SPARK PLUG "BLEW" OUT OF THE CYLINDER HEAD OF THE ENGINE CAUSING IT TO MISFIRE BADLY. SHE HAD TO PULL OFF THE SIDE OF THE ROAD IN SOMEONES YARD. LUCKILY THE PERSON THERE LET HER USE A PHONE TO CALL ME. I CALLED INTO WORK, WENT AND PICKED HER UP AND WE WENT TO THE NEAREST FORD DEALERSHIP IN SPRINGFIELD, TN. WE HAD TO SUV TOWED TO THE DEALERSHIP, THEY INSPECTED IT AND FOUND THE SPARK PLUG HAD "BLOWN" OUT OF THE CYLINDER HEAD. FORD WOULD NOT COVER ANY PART OF THE COST BECAUSE MY VEHICLE HAD 49K MILES ON IT AND I HAD CHANGED THE SPARK PLUGS ABOUT 15K MILES AGO BECAUSE THE #1 CYLINDER FACTORY SPARK PLUG "FOWLED UP". ANYWAY IT COST ME FIVE DAYS WITHOUT A VEHICLE AND $2953 TO REPLACE THE HEAD. I AM AN ENGINEER AND FEEL THAT THIS IS A DESIGN ISSUE WITH THE VEHICLE. THERE HAVE BEEN TO MANY OTHER CASES JUST LIKE MINE FOR IT TO BE AN "ISOLATED" INCIDENT. THIS MAY SEEM LIKE JUST A PROPERTY DAMAGE ISSUE BUT IF STRANDED IN THE MIDDLE OF NOWHERE OR EVEN ON A BUSY STREET OR INTERSTATE IT HAS THE POTENTIAL TO BE LIFE THREATING. THANK YOU FOR YOUR TIME. SW. *JB

WHILE VEHICLE WAS PARKED A FIRE STARTED UNDER THE HOOD. VEHICLE WAS TOTALED. DEALERSHIP WAS AWARE OF THE PROBLEM, BUT DID NOT RESOLVE IT. *AK

I OWN A 2001 FORD EXPEDITION, I WAS PARKED IN FRONT OF MY PARENTS HOME FOR APPROX. 2 1/2 HOURS, WHEN MY FIANCE WALKED OUTSIDE AN SAW THAT MY CAR WAS ON FIRE. THE FIRE STARTED ON THE DRIVER SIDE ENGINE COMPARTMENT. I HAVE REPORTED THE INCIDENT TO MY INSURANCE CARRIER. BUT I HEARD OF THE RECALLS THAT HAVE BEEN REPORTED ON THE FORD SUV'S. THE ENGINE WAS COMPLETELY DESTROYED. I FEEL THIS IS RELATED TO THE CRUISE CONTROL UNIT, AFTER EXAMINATION AFTER THE FIRE WAS EXTINGUISHED. THE FIRE DEPARTMENT REPORTED TO THE SCENE, AND REPORT WAS FILED. *JB

I HAVE OWNED THIS VEHICLE FOR ONLY 3 MONTHS AND BOUGHT IT FROM A DEALER WITH LOW MILES. TWICE NOW IN THAT THREE MONTHS I HAVE BEEN COMPLETLY STOPPED WITH FOOT ON BRAKE AND THE VEHICLE LURCHED FORWARD AS IF IT HAD BEEN HIT FROM BEHIND. TODAY IN HEAVY FREEWAY TRAFFIC IT DID THE SAME. ALMOST HITTING THE CAR IN FRONT OF ME. I HAVE CALLED FORD AND TALKED TO THE DEALERSHIP AND THEY SAY THEY HAVE NEVER HEARD OF THIS. I JUST HAD IT IN AND IT PASSED WITH FLYING COLORS. I DID COUNT 19 COMPLAINTS ON YOUR SITE WITH THE SAME ISSUE. DOES SOMEONE HAVE TO DIE FIRST?*AK

MY 2001 FORD EXPEDITION XLT LURCHES FORWARD WHEN I AM STOPPED IN TRAFFIC OR AT A LIGHT. I HAVE TAKEN IT IN TO THE DEALERSHIP SEVERAL TIMES TO HAVE THE PROBLEM FIXED. THEY CANNOT FIND A REASON WHY MY CAR DOES THIS. THE SERVICE MANAGER EVEN DROVE THE CAR AROUND FOR A FEW DAYS AND COULD NOT FIGURE IT OUT. THEY TRIED RE-SETTING THE COMPUTER BUT THAT DID NOT WORK. THIS IS A BIG PROBLEM. IT EVEN HAPPENED WHEN MY MOTHER WAS GETTING OUT OF THE CAR.*AK

RECALL CAMPAIGN FOR FORD CRUISE CONTROL DEACTIVATION. *BF THE CONSUMER WANED TO KNOW IF THE 2001 FORD EXPEDITION VEHICLES WOULD BE RECALLED, BECAUSE HE KNEW AT LEAST 2 HAD CAUGHT ON FIRE. THE CONSUMER DID NOT STATE THAT ONE OF THE VEHICLES WAS HIS. *JB RECALL305V017000

THE VEHICLE WAS PARKED INSIDE OF THE GARAGE WITHOUT WARNING THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT WAS CALLED OUT TO EXTINGUISHED THE FIRE. TWO PEOPLE SUSTAINED INJURIES AND WENT TO THE EMERGENCY ROOM ON ITS OWN. THE VEHICLE WAS TOWED AND TOTALED OUT BY THE INSURANCE COMPANY. PLEASE PROVIDE ADDITIONAL INFORMATION.

MY FORD EXPEDITION WAS REAR ENDED BY A LARGE GARBAGE TRUCK. MY AIR BAG DID NOT DEPLOY AT THAT HIT. MY TRUCK WENT INTO A SPIN AND HIT ANOTHER VEHICLE WITH THE FRONT AND DRIVER SIDE AND AGAIN THE AIRBAG DID NOT DEPLOY. I SUSTAINED BROKEN RIBS, BLACK EYE, BRUISED JAW, AND BRUISED TAILBONE. WHY DIDN'T MY AIRBAG GO OFF TO ALLEVIATE THE INJURIES TO ME? *NM

ELECTRICAL COMPONENTS FAIL WHEN THE CAR IS PUT IN DRIVE, INCLUDING RADIO, REAR WIPER, FOG LAMPS, COMPASS, OUTSIDE TEMPERATURE, POWER WINDOWS, AND DASH WARNING LIGHTS. DEALER REPORTS WINDSHIELD LEAKING, CAUSING COMPONENT FAILURES AND REPAIRS NOT COVERED UNDER WARRANTY. *NM

WINDSHIELD WIPERS STOPPED WORKING WHILE DRIVING IN THE RAIN. FORD DEALER AND FORD "CUSTOMER ASSISTANCE" 800-392-FORD REFUSED TO REPAIR PROBLEM OF WATER IN DRIVER COMPARTMENT FUSE BOX CAUSED BY LEAKING ORIGINAL WINDSHIELD, RESULTING IN SHORTING OUT OF THE WINDSHIELD WIPERS AND OTHER DASH EQUIPMENT WHILE DRIVING, WITH NO WARNING. FORD DEALER SERVICE DEPT MGR SAID: "KNOWN PROBLEM WITH FORD EXPEDITIONS AND F150 TRUCKS".*AK

WHILE PLACING THE KEY INSIDE OF THE IGNITION VEHICLE WOULD TURN OFF. BUT CONSUMER COULD TURN THE IGNITION SWITCH MANUALLY WITHOUT THE KEY INSIDE. VEHICLE WOULD TURN ON, AND THE WINDOWS WOULD ROLL UP. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK THERE WERE TIMES WHEN THE CONSUMER WAS UNABLE TO GET THE KEY OUT OF THE IGNITION, AND THERE WERE TIMES WHEN HE DID GET THE KEY OUT, THE RADIO CONTINUED TO PLAY. *JB

WHILE DRIVING MY 2001 FORD EXPEDITION AT 50 MPH I HEARD A POP AND THIS WAS FOLLOWED BY ERRATIC HANDLING AND POOR IDLE. AN INSPECTION LATER REVEALED A SPARK PLUG WHICH EJECTED OUT OF THE CYLINDER HEAD AND STRIPPED THE THREADS WITH IT. THE COST TO REPAIR THE HEAD WAS $600.00. INITIALLY I WAS TOLD I WOULD NEED A $2700 HEAD REPLACEMENT. THE DEALER ADVISED ME THAT THERE STILL CAN BE NO GUARANTEE THAT THE REPAIRED PLUG WON'T COME OUT OR ANY OF THE OTHER PLUGS. RESEARCH OF THIS PROBLEM SHOWS MANY EXPEDITION AND F-150 OWNERS WITH THE SAME PROBLEM.*AK

WINDSHIELD WIPERS FAILED TO WORK WHEN SUV IN DRIVE;WHEN LIGHTS ON;4X4, WIPER AND ABS INDICATOR ON DASH FLASHING ON AND OFF. RADIO SHUTTING OFF WHEN VEHICLE PUT IN DRIVE. PW NOT WORKING WHEN VEHICLE IN DRIVE. 11/20/04 WAS FIRST OCCURRENCE. HAPPENED APPROX. 8 TIMES BETWEEN THEN AND 12/23/2004. *NM

ON 12-21-04 WHILE DRIVING OUR '01 FORD EXPEDITION HOME FROM WORK, THERE WAS A LOUD POP, FOLLOWED BY RATTLING AND THE ENGINE CUT OFF. MY HUSBAND FOUND THAT A SPARK PLUG HAD EXPLODED OUT OF THE CYLINDER HEAD. WE TOOK THE TRUCK TO A FORD DEALER AND HE STATED THAT THE SPARK PLUG EXPLODED OUT PF THE HEAD STRIPPING THE GROVES IN THE CYLINDER HEAD. THE DEALER SUGGESTED THAT WE REPLACE THE CYCLINDER HEAD AT A COST OF $2700. THIS TRUCK IS PROPERLY MAINTAINED AND ONLY HAS APPROXIMATELY 68,000 MILES ON IT.

THERE IS A LEAK THROUGH THE WINDSHIELD, ENABLING WATER TO RUN DOWN THROUGH THE ELECTRONIC MODULE. THIS IS CAUSING THE DASHBOARD LIGHTS TO TURN ON INTERMITTENTLY, AND CAUSING THE VEHICLE TO SHUT OFF. DEALER WILL REPAIR FOR THE SECOND TIME AT CONSUMER'S EXPENSE.*AK

ON JANUARY 11, 2004 CONSUMER'S VEHICLE EXPLODED WHILE BEING PARKED IN THE GARAGE. THIS EXPLOSION DAMAGED ABOUT 80% OF HOUSE PROPERTY. WHEN THIS WAS INVESTIGATED IT WAS DETERMINED THAT THIS WAS DUE TO A DEFAULT IN ELECTRICAL SYSTEM WIRING. CONSUMER HAD VEHICLE SERVICED TWICE PRIOR TO THIS INCIDENT.*AK

2001 FORD EXPEDITION FUEL SYSTEM INDICATOR PROBLEM. WITH VEHICLE TANK CAPACITY AT 1/4 FULL AND WHEN PARKED ON AN INCLINE (ENGINE DOWN) VEHICLE HAS REPETITIVE IGNITION PROBLEMS DUE TO INSUFFICIENT FUEL PICK UP. SERVICE TECHNICIANS FROM FORD DEALERSHIP INDICATE THEY ARE AWARE OF SUCH, BUT CAN ONLY RECOMMEND "ALWAYS KEEPING TANK AT >1/2 FULL AND THEY WILL NOT/CAN NOT REPAIR DEFICIENCY". THIS PRACTICE ISN'T ALWAYS PRACTICAL. FURTHER RESEARCH FROM YOUR WEBSITE INDICATES THIS IS A WIDE SPREAD PROBLEM ACCORDING TO NHTSA ITEM #10010731. ISN'T THIS ENOUGH FOR A RECALL CAMPAIGN?*AK

MY FORD EXPEDITION SURGES WHEN I AM IDLE AT A TRAFFIC LIGHT OR JUST STOPPED. IT IS SO SEVERE THAT I SOMETIMES FEELS LIKE I HAVE BEEN REAR ENDED BY ANOTHER CAR. NOTHING BAD HAS HAPPENED YET BUT I AM AFRAID I MAY HIT A PEDESTRIAN AT AN INTERSECTION I AM STOPPED AT OR I MAY RUN INTO ANOTHER CAR. *JB

FORD EXPEDITION 2001 CAUGHT ON FIRE WHILE PARKED, REF.,ODI NUMBER 10115928. *BF THE FIRE WAS POSSIBLY DUE TO A FAULTY CRUISE CONTROL DEACTIVATION SWITCH. *JB

A SPARK PLUG BLEW OUT OF SOCKET #3 CAUSING THE VEHICLE TO RUN ON 7 CYLINDERS. PROVIDE FURTHER DETAILS. *JB