2020 Ford Escape complaints

After dealing with the loud popping of my door for one day, now my window will not roll down and when i open and close my door there is no tension at all. making me believe that the entire inside of my door panel fell apart. it’s scary because i’m worried i may not be able to open or close my door soon, or that it will stop latching.

The contact owns a 2020 Ford Escape. The contact stated that while driving at 70 MPH, the driver's side door partially opened, and upon attempting to secure the door, the contact heard an abnormal popping sound emanating from the door hinge. The following day, the contact stated that upon entering the vehicle, he found that the driver's side door was unable to latch closed and required an excessive amount of force to securely close the door. As a result, the door hinge detached from the vehicle. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure but provided no assistance. The failure mileage was 80,000.

The contact owns a 2020 Ford Escape. The contact stated that while the vehicle was in reverse, the vehicle made a howling noise coming from the rear end of the vehicle. The vehicle was also emitting a clicking noise when the brake pedal was depressed to shift out of park(P). The failure was intermittent. The contact's spouse, an independent mechanic, stated that it seemed as though there might have been a failure with the parking brake. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the howling noise while the vehicle was shifted into reverse due to not being able to duplicate the sound. The dealer stated that the clicking noise while depressing the brake pedal was diagnosed as a parking brake failure. The vehicle had not been repaired due to not being covered under recall or warranty. The manufacturer was made aware of the failure where it was confirmed that the repairs were not covered by a recall or warranty. The failure mileage was unknown.

Drivers door started popping very loud spoke to ford about it they said to report the safety issue on the welds breaking in the door

The driver’s side front door made a creaking/popping sound when opened due to an issue with the welding. This same issue also prevents the window from being rolled down.

The door pops when opening and closing. sometimes gets stuck while opening or closing. looks like the door panel is coming undone from the door. arm break check.

Drivers side door was creaking and now the window will not go down. Reading other complaints seems like a weld issue on the door catch. I do not want this to open while I am driving. I have 41k miles so my basic warranty is not in play. Please let me know if there are other warranties that will cover this.

The driver's seat has something protruding (seat heater?) into your tailbone which causes pain and discomfort. The constant adjusting to get comfortable (grabbing the steering wheel to pull myself forward) and slower reaction due to pain and numbness is a hazard waiting to happen. I have not addressed this with my local dealership as they had my car for 7 weeks and only fixed the recall issue (window switch) and none of the other 5 issues I took it in for.

A message appears that reads" Falla en system. de control de cinturones de sguridad traseros. Require servicio"

The door welds broke and the driver door sounds like it is going to fall off. It affects how the door opens and closes. Also the evap system has caused my car to die out and have issues due to it being messed up. Ford did nothing when I told them just said it was because I needed to buy the most expensive gas. So I did so and it didn’t make a difference.

The driver side door arm is broken

I opened door and it made a loud pop and I took it to a dealership and was told it was a Ford issue and the door needed to be replaced but that their wasn’t a recall so I’m just stuck with a door that is very hard and loud to open.

I have a bad weld on the driver's side door of my 2020 Titanium Escape and I am told this is a known issue. The window in the door doesn't work anymore and my door is basically falling off and from what I have read this can happen at any time even while driving. They say the door can fly open even while driving because of the bad weld. I have spoken with Ford and they will only pay a fraction of the bill. This requires a fix of a new door. They are expecting me to pay over $1300 for the repair and they will pay $980. To fix on my own is $3300. Why is there no recall. Do I have to get injured or die to be taken seriously??

The driver door starting making a loud popping sound. I found out the check arm/hinge broke. Now the door has 3 holes in it, the window will not roll up or down, and the popping sound is still present.

My driver’s door started making a loud noise. Then it popped real loud and now it has no spring. It will not stay open for me to get out of the car. You have to hold it open. The window will only go down about an inch.

Problems with the driver side door. Purchased car brand new. Currently has 25k miles (roughly). My 3-36k mile warranty ended 10/23. My door is making creaking snapping popping noises and the window Won't go down. I'm concerned the door won't open or worse snap and fall off while driving. I feel I have to hold the door while driving which is not safe. . I have to drive this car for work, I work in the field and need the car to go from location to location throughout the day. . I took it to the dealer garage. The conversation went along the lines, the door arm welds are bad and the garage mentioned they had 5 cars recently with the same problem. They said it was covered and then the door would have to be replaced. They (service dept) sent it over to the body shop stating it was too long of a job for service dept to do. I waited 2 weeks and went down to check on status. The body shop said it wasn't covered and it would be $2400 to replace the door. Contacted Ford about the letter that's supposedly to come out to owners with this problem 2020 escape and they know nothing about it. I reached out to another dealer in the area and they are very aware of problem with the escape door but they know nothing about Fords customer satisfaction program regarding the door. Very concerned the car door is unsafe.

Drivers side door inner shell became unwelded. Ford released a TSB technical service bulletin about it, but refuses to call it a recall. Out of pocket $1500

Weld came undone. Driver door does not work properly. Window does not roll down

- The check arm attachment point in the door assembly on the driver's side door. The spot welds holding the attachment to the door have broken. It is available for inspection at request. - It's a safety issue because the door no longer is able to catch itself presenting the possibility of the door being "ripped" from our hand if the wind would catch it potentially causing harm. Also, it's unknown whether the door will eventually be unable to latch presenting an even bigger problem if the door would open while traveling. - The local dealership is fully aware of the issue at hand reassuring me that this is indeed an issue. There is even a Technical Service Bulletin (TSB) - SSM 50150 issued displaying the issue at hand. - The "fix" the dealership collision center has told me is a complete door replacement with a cost of $3,000 or more.

Left front door check came unwelded from inside door panel causing door to not open and close properly. Left window would not work. Holes in door frame where hinges pulled out.

The vehicle without warning lost power as I was driving in the middle of a road way. The engine stayed running but only revs. No check engine lights or messages. Thankfully I was headed down hill and was able to coast through the intersection that was turning yellow and had just turned red as I coasted through. I coasted and pulled over to a side street and proceeded to put vehicle in park and shut it off. I then tried to start and put it back into drive. Nothing. I shut it off again waited 10 minutes then started and it started driving. Then lost all ability to give power to the wheels. Vehicle was taken to the dealership where they said it had metal in the transmission fluid. The vehicle was scheduled to have a fluid exchange for the transmission the next day. They couldn't get it out of park either then it did slam into drive for them. They said it needed a new transmission. For the cost of $7,500 it now has a new transmission from ford. The only warning I finally got was through the Ford pass app after the vehicle has finally been at the dealership for a couple days. That is when it indicated a power train fault and problem with transmission.

The weld that holds the control arm for the front driver side door has broken.

The driver front door check arm spot welds are breaking, making the door hard to open and close. The vehicle only has 56,000 miles.

Opening/closing driver door is very difficult must do slowly. Window does not go down. I can see three holes where the spot weld holding the hinge is gone.

* Spot Weld Joints failed on driver side door. The welds have failed. * Cannot open drivers side door due to to spot weld failure. * Dealer has seen the issue and said the only option is a new door. *Dealer has notified Ford Motor Company. I have a 5 year 100,000 mile bumper to bumper warranty that I purchased from Ford Motor Company. Ford told the dealer it is not a part failure so not covered under my warranty and the cost should fall back to the customer. *No. I was getting into my car to leave work on 2/15/2024 and when I opened the door I heard the loud popping/cracking sound.

On February 23,2024 the driver door started making very loud scraping and popping noises with physical resistance to opening or closing. The drivers power window started working very slowly like it was being dragged on, and then wouldn't go back up. Pushing on exposed window edge got it finally to go up and close. Over the next several days the noise and resistance has gotten worse. Found out NTSB has opened an investigation into this issue, and Ford has a service memo SSM 50150 as the cause is faulty spot welds on interior door anchors which can lead to door failure and unexpected opening. SO far Ford has not offered any help to repair this issue. I have filed a claim without result yet.

So there is multiple issues with my vehicle. First: I had the recall issue with the fuel injector "fixed" as the dealer stated. Now CO2 is leaking into my cabin when the car is parked and/ or when the remote start is activated. You can not breathe. I bought this car because I have 2 boys in car seats still. It is a serious hazard for anyone that breathes it in, especially kids. Second: after pumping gas it chugs. Like it will try to crank up but can't. I have had this car for less than a year. After the dealership "fixed" the fuel injector this issue started. When it finally starts the car smells strongly of gas. Third: there was a recall on a hose that had to do with the A/c system. It leaked onto wires and caused a shortage in my whole electrical system which in turn caused the vehicle to shut down on me while I was driving on the interstate. Fourth: The blind spot warning goes crazy when you are driving down a road with no one beside you. Fifth: The lane keeping assistant has completely stopped working. I have reset the system and it still will not work. Sixth: the radio, bluetooth, sound system does not work because of the water that leaked onto the wires from the A/C pipe that was recalled. Now my biggest issue is that the dealership that I purchased the vehicle from tried to charge me to have the recalls fixed. I had to take it to another dealership and afterwards was informed that, that specific dealership will claim to replace the recalls but not actually do the work

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door made an abnormal popping sound while driving. The vehicle was taken to the dealer, who diagnosed that the driver's side door check arm attachment point had failed. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure but offered no assistance. The contact was later referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was 45,000.

The passenger door hinge made a large noise and was unable to close without extreme force. It was a safety issue as the car function and hinge mechanism failed. The dealer turned me away as they do not "weld" and referred me to a body shop. Yes, my independent auto service stated that the Door Stay and Mounting Bracket three small welds broke off. They were unable to re attach door properly as they do not weld. They noted the drivers side door is also starting to loosen. This is another safety concern.

The contact owns a 2020 Ford Escape. The contact stated that while opening the front driver's side door, the door made an abnormally loud popping sound. Additionally, the door failed to open completely, and the window failed to roll down completely. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The vehicle was not diagnosed or repaired. The failure mileage was 40,000.

When opening driverside door, hinge broke making it difficult to close door securely. Had to have the hinge replaced.

The driver side door began making a terrible noise upon opening and closing. It would not close. The door eventually closed and the door weld for the hinge failed. The door does not operate properly and now the driver side window does not go down because the door hinge components are broken off inside the door and blocking the window from going down at all. Ford was contacted multiple times about the manufacturer failure and there is still NO Recall on the 2020 Escape AWD. They advised to wait for a letter from Ford allowing the fix. Ford has no information for when they will send letters to customers or dealers to fix the failed manufacturer weld component on the drivers side door.

My driver door began clicking and popping and I was unable to open my door to exit the vehicle . My driver window would not roll down. The following day the metal door arm had popped loose. And where the hinge was welded to the door. 3 holes were found and the metal hinge in the door started moving freely. I am a home care nurse and depend on my vehicle. It feels like the door is going to fall off. This scares me, because I am not sure if I will be unable to open my door or window to exit in case of an emergency. I am also fearful the door will fall off. I called ford and was told no recalls were reregistering for my vin number. I was told my warranty ran out and any repair will have to be paid fully by me. Ford refuses to put customer safety first in this situation. Please advise. Thank you.

The door check bracket is broke to where my door makes a terrible noise and I hear this is affecting over 300,000 Ford escapes

The contact owns a 2020 Ford Escape. The contact stated that upon entering the vehicle, he heard an abnormal sound coming from the door hinge. The vehicle was taken to the dealer, who diagnosed a failure with the door check arm attachment point. The vehicle was not repaired. The manufacturer was not notified of the failure. After investigating the failure, the contact related the failure to NHTSA Action Number: PE23013 (Structure), but the vehicle was not included. The failure mileage was 15,000.

The driver door welds have broken. The door has been investigated by Courtesy Ford, Hattiesburg, MS. They stated the door would have to be replaced at a cost of $2600. No warning lamps were indicated. Also, the breaks squeal when in reverse.

Drivers side door started to make a loud popping sound and the window stopped rolling down. Every time the drivers side door opens it flings wide open because there’s nothing to keep it in place. Took the car to the dealership it was purchased at and was told that the ford escape has that issue with a faulty weld on the check arm causing it to break completely off with no way to repair it.

Drivers door spot welds that hold the reinforcing angle for the door check have broken loose allowing the door check angle to move inside of door, this makes it difficult to close the door all the way because the angle is hitting something inside of the door. Looking online this appears to be a common problem, Ford issued a service bulletin for this issue, (SSM 50150), we called the local Ford dealership and was told that since the vehicle is out of warranty there is nothing they can do. Vehicle has about 14,000 miles on it but is about 8 months out of warranty, it was used very little for the first 2 years due to Covid 19 pandemic shutting down the University that is the owner. The passenger door spot welds are also beginning to break loose.

The contact owns a 2020 Ford Escape. The contact stated that while opening the front driver's side door, there was an abnormal cracking sound heard. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was determined that the driver’s side front door was cracked or had a fractured spot weld at the check arm attachment in the door assembly. The dealer informed the contact that the door needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and informed the contact there was no coverage under a recall or warranty for the repair. The contact stated that the failure was related to NHTSA ID Number: 10234590, Manufacturer Communication Number: SSM 51553 (Structure). The failure mileage was approximately 33,000.

The contact owns a 2020 Ford Escape. The contact stated that while entering the vehicle, the front driver's side door made an abnormal popping sound. The vehicle was taken to the dealer, who diagnosed the vehicle and determined that the driver's side door check arm attachment point had failed. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 51,000.

The door just started to make a bad noise and the window will not go down now. The weld mounts on the door have come undone!

Last week, I heard a popping noise when opening my driver side front door of my 2020 Ford Escape. I had the issue diagnosed by my local Ford dealership as broken spot welds on my door. Since then, the issue has progressed and my door no longer closes properly. It is a safety issue because my door is not closing properly and continuing to get worse. I do not feel comfortable driving until it is fixed. I was referred to a body shop by my local dealership for the issue and will have it repaired this week. The body shop confirmed the broken spot welds on my driver side front door.

The driver door popped open at 70 MPH on the interstate. Pulled over and the door was jammed open about 12 inches. We could not get the door to close or get the window to go down. We had to get out the passenger side. We finally forced the door closed with two of us pushing on it. Now it won't open all the way and the window is stuck about 6 inches from closing. Extremely dangerous situation. The vehicle has 56.000 miles and we purchased it new. Now my wife refuses to ride in it. We are both [XXX] . It's unbelievable that the Ford Motor Company has not addressed this! My dealer is stating the repair could cost us as much as $2000 out of pocket, The NHTSA is our only hope.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Approximately a week ago we noticed a popping sound in our driver side door. You can see where the rivets have popped free from the sheet metal. This car is over its 3 year warranty by about one week. Yet, the dealer and Ford motor company do not want to do anything to replace our door. This is an issue that ford acknowledged as a problem on this specific car. But, no TSB or recall has been issued yet. Hopefully by leaving this message, the NHTSA will look into this concern. I don't need my wife driving this car with a door that is not safe. Thank you!

The drivers side door hinge has failed. It has come loose.

Hinge on driver's door broke. Door pops every time it opens. Window will not roll all the way down.

The spot welds holding the door check on driver side have failed. The door does not open or close properly now we have had the vehicle for 3 months. The vehicle has 22000 miles on the Odometer.

Spot welds on drivers side front door attaching the check arm has broken loose causing a loud popping sounds and causing difficulty opening and closing the door. Ford is aware of the problem and refuses to fix it, even though they have been made aware of the issue by Ford through service bulletin numbers SSM 51553 and SSM 50150.

Hello and thanks, for giving this your attention. 2 days ago, I heard a popping noise when I opened my drivers side door. There is now an issue opening and closing the door. The window also, will now not roll down. Upon, looking closer at the door frame, 3 factory tack welds have completely come loose.

The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door made an abnormal sound while opening. Additionally, the door failed to open for more than 5-inches due to the door check arm bracket being fractured. Additionally, the contact stated that the window failed to go down. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to Ford Campaign Number: 23B56. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 63,134.