2020 Ford Ecosport complaints

Driving down the road and Low Oil Pressure Light comes on car loses all power had to coast to try to get off the road got to a stop. The ford app shows power train malfunction ended up having it towed to a Ford dealership

Vehicle had oil change prior to oil change date/miles, drove vehicle less than 2 miles away from Oil shop. low oil pressure light turned on. Was unable to drive it back home. Was taken to ford dealership and was notified I need a new engine due to "metal shavings found in engine"

I have a 2020 Ford EcoSport that was 3 years old and had 84000 miles on it. As I was driving down the highway I lost all oil pressure and the engine seized up. As I was 47 miles away from home I became stuck in the side of the road upon taking it to a local mechanic they reported the oil pump chain has failed and the entire engine will need to be rebuilt. The car had had all usual repairs and maintenance and regular oil changes

My 2020 Ecosport with 25k needed the rear differential replaced because the clutch coupling locked causing a grinding noise in the rear. The car was unsafe to drive and the rear axle assembly needed replacement.

Was driving my vehicle 2020 Ford EcoSport, engine blew due to oil pump being internally belt driven and submersed in oil. It caused the belt to decay and plug my uptake which brings oil to the top of the engine. Paid for a tow to the nearest dealership after my vehicle failed driving 75 on an interstate down a mountain to Phoenix AZ. Lights went off and a low oil pressure light came on and the vehicle and in to limp mode and would not accelerate. It took the dealer a month to figure out and resolve my issue but over 2 months to get my car repaired and back to me. Ford accepted some responsibility and assisted in laying 60% of a $7,000 bill. This happened 2/8/2023. Got my car back end of April 2023 and within in the first month check engine light returned. Brought it to a dealer in Flagstaff AZ and discovered a sensor had gone bad (cam shaft sensor) and I paid over $209 for that to be completed and the previous dealer reinstalled my subframe incorrectly when they replaced the engine. Fast forward to yesterday 10/10/23 and I’m in my car with my new engine with less than 10,000 miles on it. I try to accelerate to highway speeds and check engine light comes on with a “see manual message” and it goes in to limp mode with no way to accelerate. I safely drove it 2 miles to the nearest Ford dealer in Lake Havasu AZ and was informed that my engine was blown once again due to a failed oil pump. I still owe on this car and it’s cost me so much money in repairs and rental cars and I’m go

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the check engine and low oil pressure warning lights illuminated. The vehicle was taken to the dealer. The vehicle was diagnosed with an engine failure. The engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.

Going 55 mph down a local 2 lane road, I received a low oil pressure warning followed by loud knocking of the engine. I had to stop the car and have it towed home. Car has 76,000 miles on it and the oil level is perfect. Dealership blames oil pump failure, resulting in a new engine. Seems to be a reoccurring issue with the EcoSports

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed and going downhill, she briefly felt the vehicle jerk. The vehicle returned to normal functionality, but the failure had since become a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 26,000.

Engine blown while driving on freeway with child. No prior error lights on dash. Mechanic stated due to internal failure of oil belt, which frayed and exploded into engine. Car received all regular required maintenance & was inspected at oil change 60 days ago with no issues reported. Have diagnostic stating manufacturing failure.

Low oil pressure light came on within minutes before total engine failure. This happened almost 1 month ago and is currently at an independent service contractor being repaired, requiring total engine replacement.

Loss of engine oil pressure at highway speed causing engine and turbo failure. Vehicle is being repaired at dealer under warranty but it has been months and I’ve had no assistance with a vehicle replacement

I was driving the vehicle to work and after about 15 minutes of driving it, the low oil pressure light came on and started to lose speed. I was on a highway and had cars behind me and wasn't sure what to do. I attempted to speed up so I could pull over at a gas station, but I was not able to go above 20 mph. I had to quickly pull over to the side of the road. After a few minutes, I attempted to get back on the road to reach a gas station near by, but was not able to get above 15-20 mph. I put my flashers on and attempted to make it to the gas station and finally made it and called a tow truck. I had to call in to work that day. The car was towed to our home and I called our local Ford dealer to make an appt to check it out. I was not able to get a service appt for 3 months! I had tobhave the vehicle towed to the dealership and they told me the oil pump was bad and I would need to have the engine replaced and it would cost me $6,000. It's ridiculous to have a car for 3 years and 64,000 and have to replace the engine!!! This conveniently happened right after the warranty ran up. I had just had the turbocharger replaced and the vacuum pump a couple minutes prior to the low oil pressure issue! No reason this should happen on a 3 year old car that has had the maintenance kept up on it.

On 9/23, the vehicle was traveling on !-94 in SE Michigan when it suddenly lost power. The vehicle had to be towed to a service center. The mechanic stated that the oil pump had failed, causing the engine to completely fail. The car was 3 years old, with 67.000 miles. Oil changes had been performed every 5K miles since the car was purchased. Because we did not purchase the ESP, we are now looking at $8K-$10K to get this fixed - we have no idea what to do. it needs a new engine.

While driving it’s dropping rpm’s. It feels like it’s going in and out of gear while driving and even does it in cruse. While switching gears on take off it jerks each gear like it’s struggling. Rpm’s jump 500/1000 all the time even at idol.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving approximately 50 MPH, the oil pressure warning light had illuminated, and the vehicle lost motive power. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 62,000.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently decelerated while the accelerator pedal was depressed, and the vehicle lost motive power. The oil pressure warning light and the service warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number and informed that the warranty coverage had been exceeded due to the mileage. The failure mileage was approximately 65,000.

On December 30, 2022 I was driving my EcoSport when the "low oil pressure" light first came on followed by the "check engine" light. I immediately pulled to the side of the road and called the dealership where my vehicle was just serviced for The Works the week before and spoke to the service advisor. I asked what the problem could be since it was just serviced and he said it sounds like the engine. I had to have my car towed (thank goodness for AAA) to the dealership. The warranty on the powertrain/engine was up at 60K miles and I was at 72,000. I paid out of pocket almost $6300 for the new engine. I have NEVER had to pay for any engine in all the years I have owned and driven any make/model of car. I am very disappointed with how FORD handled this problem.

On July 27, 2023 as I was accelerating to enter a busy interstate, my vehicle warning light came on for low oil pressure and went into a limp mode only allowing the vehicle to drive 45MPH. There were no warnings other than this light and message appearing on dash as the vehicle lost power. The 18 wheeler approaching behind my vehicle was able to get in a different lane and not hit me and I pulled onto shoulder until I could exit. I had approximately 87,000 miles on the odometer. I contacted the local dealership to have the vehicle towed for an inspection. When the vehicle was brought in for inspection, the technician seemed to know the precise problem from just the description of events. After they inspected the car, they confirmed that the vehicle’s engine experienced an oil pump failure that would require a new engine. The vehicle has been at dealership since that day awaiting the back ordered engine to arrive so it can be installed. Today is September 25, 2023 and I still have not heard of an estimated date for the back ordered engine from Ford to arrive. The repair is estimated to be $8,300 since it was out of warranty. I have already given a $4,000 deposit to the service department so they could order the engine parts, although the engine isn’t even accessible. I have since rented a car totaling $1050 and just went and purchased a second vehicle so I wouldn’t have to waste more money renting a vehicle.

Almost a year ago while driving the car it would just cut off. I took it to Ford and they stated I needed a new valve. I got the car repaired it was about 450$. Months later the car begin to do the same thing again and it cut off on me while turning onto a street. That time it would not restart and I got it towed. After getting it fixed again like 2 months later the car started to knock after I got my oil change. Took it to a mechanic and they said the oil wasn’t coming all the way up. I took the car to Ford and they said I would need a new engine because at some point my fuel pump started going out without me knowing. Ford expects me to pay 7000$ for a new engine on a 2020 car that I’m still paying a car note on.

Was driving down highway at 65 MPH, low oil pressure message popped up on the dash and car slowed down. Got pulled over and shut car off. Checked oil and there was oil.

The contact owns a 2020 Ford EcoSport. The contact stated that while the vehicle was idling, the vehicle stalled with the check engine warning light illuminated. On another occasion, while driving at an undisclosed speed, the RPM fell, and the vehicle stalled. The contact was able to restart the vehicle. The contact stated that occasionally, several attempts were needed to start the vehicle. The contact stated that the instrument panel displayed a message that the emissions control system had detected a restricted fuel vapor tube. The contact took the vehicle to the dealer who replaced the engine however, the failure persisted. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 66,000.

Oil pump failure causing power loss and damage to engine and transmission, causing both to need to be replaced.

I was driving on the highway on July 18, 2023 and had engine failure. The car made a thump as if engine collapsed and there was fire under the car - 2020 Ford Ecosport. The car was towed to Ford dealer (Waynesville NC) and was declared a total loss by Geico Insurance and Ford Mechanic Dept. The manager said these cars have a problem with oil pump failure and the result is engine failure. Car was towed to junkyard and next day Geico changed their mind from their responsibility of total loss. Geico said it's all over the internet the oil pump failure issue with this vehicle, and that is it the responsiblity of Ford to fix or total vehicle. At this time no one is taking responsiblity to pay off lease nor to fix the problem. Car is sitting in front yard without being able to move as it has a hole in engine with damages from incident and whatever Ford mechanics did and junkyard.

The contact owns a 2020 Ford Ecosport. The contact stated while driving 60 MPH, there was an abnormal sound coming from the vehicle and the oil pressure warning light illuminated. The contact pulled over on the side of the road and had the vehicle towed to the dealer. The dealer diagnosed the vehicle and stated that the oil pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 71,964.

While driving on July 31, 2023 the low oil pressure lamp appeared, loud knocking sound and loss of power occurred. I immediately pulled over, parked, and had car towed to Colma Ford, Colma, CA. The next day they left a vm saying they'll get back to me throughout the week. It probably needs an engine. This was without diagnostics. I then towed it to a reputable shop who also said it needs an engine but they don't want to do the repairs due to this engine having so many problems and the parts not being readily available. Next I towed it to James Ford, Half Moon Bay, CA where they performed diagnostics and confirmed it needs an engine. The engines, however, are on backorder with no estimation of availability. The car remains there at this time. I've had to rent a car the entire time. I bought the car in March 2023 as certified preowned with 58978 miles from Enterprise Car Sales, Redwood City, CA with a 1yr/12000 mile warranty. When breakdown occurred I had 68498 miles so it is under warranty, repairs approved, but parts not available.

For the 2nd time in about 8-10 months, while braking and having nearly come to a stop, on a slight incline, the car had a sudden acceleration. Driver repeatedly stomped on the brake as the car tried to leap forward. Extremely dangerous. No warning lights. I know the dealer won’t do anything because they won’t be able to reproduce it. Conditions were mild, slight sprinkle. I bought the car from a dealer with 5000 mile on it. Wonder whether original owner experienced a similar problem.

Oil pump failure at 90,000 miles, haven’t even had the car for two years. Since oil pumped failed the dealership says the motor is needing to be replaced. Cost is over $6,500.

The engine started knocking while my wife was driving to school . She pulled over I drove to meet her and sent her on to school in my car . I had the car towed to Stivers Ford in Birmingham . They ultimately had to replace the engine due to I think oil pump sudden failure . The date I put as date car failed is approximate .

The contact owns a 2020 Ford EcoSport. The contact stated while driving 55 MPH, the oil pressure warning light illuminated. The contact stated that there was an abnormally loud sound coming from the engine compartment. The vehicle was turned into a parking lot where the vehicle stalled. The vehicle was restarted, and oil was added to the engine. The vehicle was towed to a dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 88,000.

Vehicle has a knocking sound from.engine went to Ford Service Ctr.on 7/22/2023. [XXX] Was informed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car is incessantly jumping/jerking when switch gears. The symptom is so bad it is comparable to hitting a speed bump without slowing down. Sometimes it jumps forward and seems as though you can't stop it. It happens when backing out of the driveway, putting the car in drive from reverse, putting the car in drive from park, putting the car in reverse from park, accelerating after stopping at a stop sign or a light, and more. Dealership the vehicle was purchased from has tried to fix the problem approximately 5 times. Car was at the dealership from July '22 to October '22 and problem still was not fixed. Another Ford certified dealer tried to fix it with no success.

I purchased the 2020 Ford Ecosport in July 2022 from bulter Ford in milledgville ga I have been having problems with the car barely pulling up a hill when driving and I can feel the car jerking while driving feeling like it's going to cut off in the road I have been to the bulter shop 5 times and nothing is working it is still doing the same thing they say they can't find anything wrong I have not had a good ride out of the 8 month I have had the car I need help

The contact owns a 2020 Ford Ecosport. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while accelerating. The vehicle was taken to the dealer, where the MAP (Manifold Absolute Pressure) sensor was cleaned and the air filter was replaced; however, the failure recurred. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 21,550.

While driving my 2020 Ford Ecosport it spontaneously caught fire and exploded on Sunday, May 29th. •I purchased my 2020 Ford Ecosport from Ford or Helfman Ford in Stafford Texas on Monday, May 25th, 2020. I immediately had problems with the vehicle and have taken the vehicle in multiple times for overheating issues and the check engine light coming on. •May 25th, 2020 – overheating and coolant light came on. Vehicle taken to Planet Ford in Dallas May 28, 2020. Vehicle repaired and picked up from Planet Ford on May 29th, 2020. •May 30th, 2020 - check engine light came back on. Vehicle taken back to Planet Ford in Dallas June 2, 2020 and I picked it up. Vehicle repaired and picked and I picked June 5, 2020. •April 2nd, 2021, I took it the vehicle to Helfman Ford for routine maintenance and the continuous check engine light problem. I received the car back the same day with paperwork stating that they could not re-create the problem. •August 4th 2021, I took it back to Helfman Ford, vehicle was running very rough and was extremely loud. On 10/06/2020 the vehicle was returned after extensive repairs were done to exhaust and engine under warranty (see repair invoice). •My check engine light and coolant light continued to come on sporadically producing the same error messages in the Ford app for my car. •On May 7, 2022 My check engine light come back on and I received an error message that I had never seen prior but as soon as I stopped the message went away •On May 17, 2022 I took

Oil pump belt broke at 72000 miles

Was leaving work and suddenly the oil pressure light came on and the engine started making a terrible noise. I pulled over and had the car towed to the Ford dealership. The dealership inspected it and said that the oil pump belt "shredded" and the sudden loss of oil pressure, along with the debris from the oil pump belt, completely ruined both the motor and the turbo requiring full replacement of both at a cost of $6500. Car was purchased new less than 2 1/2 years before but Ford will not pay for the repairs.

My wife was in an accident and the right hand side airbags failed to deploy and she was hit around 30mph and i know a airbag will deploy at that speed

The contact owns a 2020 Ford Ecosport. The contact stated the air bag warning light was illuminated. The contact called the local dealer who informed the contact that the vehicle needed to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the warranty had expired, and referred her to the NHTSA Hotline. The failure mileage was approximately 90,000.

Car was leaking coolant, overheated, now has a head gasket problem.

My husband was driving home from work when he heard a boom. He had thought he hit something but didn’t feel or see anything. A few minutes later he saw smoke coming from the engine and thought maybe a hose had come off or something so he pulled into a parking lot. When he lifted the hood the car was on fire.

The Brake system emits a squeaking, moan/groan sound when backing up. The vehicle is available for inspection upon request. The concern was that any sound not usual to the operation of the vehicle is a warning of a potential problem. No warning lights appeared. This problem was inspected, confirmed/diagnosed at a Ford dealer in Huntington, WV. The problem was supposed to be remedied with the replacement of the rear braking system(pads, rotors. and slides). The vehicle had 19,736 miles on it but the dealer said it was not a warranty item and charged $600.00 for the repair. The problem was not corrected. The manufacturer was contacted. A Ford representative contacted the dealer and was convinced by the dealer that nothing could be done to remedy this condition. Hence it still poses a threat to the safety of the vehicle. I researched the issue via the internet and found a considerable number of postings relating the same problem from other 2018-2020 Ford Ecosport owners. The results of their efforts mirrored mine. A video of the problem (post repair) is available but not able to download in this format.

Driving on the interstate the low oil pressure light came on no check engine lights or anything . The oil pump is belt driven aka wet belt and the rubber teeth come off stopping up the oil pump and causing it not to work properly . With the rubber pieces going into the motor the rubber melts causing issues with the pistons and engine block. The Ford dealership recommends not replacing just the oil pump because of all the other issues the rubber belt causes because it melts inside the engine . So I am left with no choice but to replace the engine at a cost of 5,000.00. Why there hasn't been a recall is questionable . I am in the process of getting said motor replaced but does that mean every 2 years it will have same issues ?

Hill start failure

I rear ended a car got a concussion because my airbags did not deploy

Suspension will start going up and down not safe while driving

205/50/17 Tires were cut with knife

The contact owns a 2020 Ford Ecosport. The contact stated that while stopped and attempting to make a left turn, another vehicle ran a red light and T-boned his vehicle. Due to the impact, his vehicle slammed into a guardrail on a bridge, nearly knocking the vehicle over the bridge. The contact stated that all curtain side airbags were deployed; however, his driver and passenger side airbags did not deploy. The contact stated that he was trapped in the vehicle and had to wait for authorities to assist him out of the vehicle. The contact was rushed to the hospital but decided to leave after a long wait in the emergency room. The contact stated that he did have soreness to his right shoulder and right arm. A police report was filed (210066310). The whereabouts of the other driver were unknown. The vehicle was towed to an independent body shop where it remained in their possession after the contact was given an estimate for repair. Upon investigation, the contact linked his failure to NHTSA Campaign Number: 20V791000(Air Bags). The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 20,310.

The contact owns a 2020 Ford Ecosport. The contact stated that while the gear shifter was in park, the contact exited the vehicle to retrieve an item and without warning, the vehicle started rolling backwards. The contact ran and entered the vehicle and slammed on the brake pedal to stop the vehicle. The vehicle was not diagnosed nor repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 17,904.

Car was parked in the driveway and back windshield shattered out of no where. We were outside when we heard the explosion as it happened.

FOR SOME REASON SCREEN ON MY ENTERTAINMENT CENTER ON ECOSPORT GOES BLACK. SO FAR I HAD TWO SOFTWARE UPDATES AND ONE SCREEN REPLACEMENT BUT THE PROBLEM STILL APPEARS. I AM SO PISSED OFF WITH THIS THAT MY DEALER IS NOT ABLE TO FIX THIS PROBLEM. FOR SOME REASON SCREEN ON MY ENTERTAINMENT CENTER ON ECOSPORT GOES BLACK. SO FAR I HAVE HAD TWO SOFTWARE UPDATES AND ONE SCREEN REPLACEMENT BUT THE PROBLEM STILL APPEARS. I AM SO PISSED OFF WITH THIS THAT MY DEALER IS NOT ABLE TO FIX THIS PROBLEM ALWAYS THIS PROBLEM APPEARS WHEN I TURN THE GEAR FROM PARKING TO DRIVE OR DRIVE TO PARKING OBVIOUSLY WHEN I SWITCHED THE GEARS, NEVER WHEN I DRIVING SO FAR ON 1/7/21, 1/20/21, 2/12/21, 4/15/21