2022 Ford Bronco Sport complaints

Passenger knee airbag did not deploy Drivers Steering column came off at base which is why there was no airbag deployed. Front driver and passenger sun visors came completely off and exposed wires and metal rods.

Vehicle with 900 miles on it began smoking and caught fire under the hood for no apparent reason. Vehicle was in new condition. Vehicle likely a total loss (see photos). Driver was lucky to escape

I have had this vehicle approximately 6 months, in that time I have noticed that not only is there a lot of brake dust and the brakes make a loud noise when reversing. The sound is like metal rubbing together and I have only noticed it when backing up. I've taken it to the dealership twice, both times I was told it's the new braking system Ford has and it's "normal".

In the last three weeks the check engine light has come on twice and stayed on after I started the vehicle. The first time it came on I had about 7800 miles on the vehicle. I called the dealership to see if I could get a service appointment (of course it was a Friday afternoon), the earliest appointment was the next Wednesday. I was told as long as the light was not flashing, I could drive the vehicle. I was also told to check the gas cap/door (there is no gas cap!) because there could be an air in the fuel line. As it turned out the light went off the next day. When I took the car in for service, I was told they did the "smoke" test, and everything checked out ok. Three week later the check engine light has come on again. It is a steady light, not flashing, taking it back to the dealership.

Driving and Engine won’t accelerate. Almost like it is just coasting while I was merging on the freeway. It almost caused an accident. It has happened on multiple occasions. Ford service said when it is hot that just happens. It’s unsafe. The car has 600miles on it.

Started my car and started down the driveway and all types of warnings with of about my engine overheating. Checked the antifreeze and there was none. Applied antifreeze and it drained into the engine. I had this vehicle for 2 months and it has been at the dealership since April 28,2022. was told there was a crack in the engine.

Brand new vehicle with about 3500 miles on it. Delivered 04/29/2022. On three separate occasions between 07/29/2022 - 07/31/2022, the vehicle started jerking/losing acceleration while driving and the engine began to sputter. Upon slowing down and during idle, the engine would continue sputtering to low RPM and eventually stall. This happened while driving on the road, almost resulting in an accident in a roundabout during one of the instances. The error I received via the Ford Pass app is: The Engine Control System is unable to control the fuel system pressure as expected. This is clearly a defective product, and so far Ford and Ford and Ford dealerships have offered me little options for repair often stating that it could be more than a month to fix with no options for a loaner vehicle. This is unacceptable. I have video proof of one of the incidents I am willing to share, but I cannot upload it to this form.

There is a repeating clicking noise (click, click, click…) every time I turn the steering wheel. It only occurs when it’s above 90 degrees Fahrenheit outside. Any problem related to the steering, or turning of the vehicle is a safety concern in my opinion. Ford forces the owner to make a service appointment to get the problem inspected (I could not just drive to a dealership). The earliest I could schedule an appointment at one of the three nearest dealerships to me is a week from the day I’m writing this complaint. So I guess I can either keep driving the vehicle in the unsafe condition, or get a rental on my own dime. There are no warning lights or trouble codes related to the issue, and the vehicle only has 3,500 miles on it. I’ve owned it for two months 🤦‍♂️.

The driver was on M53 near Armada around 5pm today, July 25, 2022. The owner was driving down the road another vehicle pulled up next to her and told her the vehicle was on fire. The driver was able to exit the vehicle and took the photo (unable to upload photo). Owner called 911 and fire department was able to extinguish the fire.

The current acceleration pedal on this model is made out of hard plastic. While driving your foot slips off the pedal because there is no rubber on the pedal for a better contact. To counter this slippage you have to move the seat closer to the dash. This then becomes a safety issue because you are now too close to the dash to quickly move your foot to the brake pedal when necessary. There is no after market product offered by Ford to correct this matter. This needs to be addressed quickly so Ford can correct this. I don't know how this could not be noticed by the design managers and test team at Ford.

The wrench icon which refers to the Powertrain system keeps coming on. I received a message from the Ford pass system that there was (Fault) in the Powertrain system. That power was reduced. Further it said to see a dealer right away. All of the Ford Dealers in my area are all booked up.

Received a Powertrain malfunction/reduced power warning at 190 miles. Noticed large oil leak on garage floor which turned out was leaking from TPU due to faulty cap. Car has been at dealer for 8 days to replace fluid and cap and no explanation provided for powertrain warning.

The contact owns a 2022 Ford Bronco Sport. The contact stated while the vehicle was parked in a parking space on the park position, the vehicle unintendedly accelerated and reversed, striking her mother on the knee. The contact was able to get in the vehicle and depress the brake pedal. An appointment was scheduled for a diagnostic test. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 5,135.

Car had 3000 miles on it, started rough idling randomly then the check engine light came on and was flashing. Drove straight to the Ford Dealership in Elko, Nevada and barely made it the 5 miles as the car wanted to die, had gas pedal all the way to the floor and was barely going 30 mph. Dealer has had vehicle for over a week and said a core and plug and deactivator solenoid had to be replaced.

The manual park release cable is defective and was a recalled issue on the 2021s (SSM 50274). I am experiencing the same rattle noise on my 2022 and have contacted ford multiple times about the issue and the most they are willing to help with at this point is cover 50% of the costs of fixing it. They state that there is no recall on 2022s and only on 2021s. This is a safety issue on a car with less than 1500 miles and has had this issue since around the 400 mile mark. I used a bronco sport forum to find a contact from someone within Ford who looked up my vin and told me my bronco sport has the same part that has been found to be defective on 2021s — my car was built in November 2021 and soon after ford changed the part number that they are putting in the car so that they aren’t using a defective part. I have also found on forums that there are many people experiencing this issue and are similarly being told that there is no recall on 2022s so we are basically out of luck.

Brakes make a grinding sound at low speed. When in reverse, brakes make a humming sound. This was the same issue that caused a recall of previous models, however my vehicle is not covered by the recall. Took the vehicle to the dealer and they said “we know there is a noise but the brakes are working properly.” The noise is not normal.

Engine makes intermittent metal crunching and scraping sounds at low speeds and when braking in stop an go traffic. And sometimes the sound would be heard the all the time when keeping the car between 25 to 30 mph.

Vehicle's pre-collision assist wasn't working. After taking it to the dealer for repair they stated "VEHICLE ABLE TO DETECT LARGER VEHICLES BUT NOT CARS. DROVE SIMILAR EQUIPPED VEHICLES, WITH THE SAME RESULTS. NO PROBLEM FOUND AT THIS TIME." Ford describes the pre-collision assist as "This feature scans the road ahead and can alert you to potential collisions with vehicles or pedestrians detected in your path." This safety feature is supposed to work with pedestrians and vehicles, not "larger vehicles but not cars" "

Car failed to go into drive several times while in traffic. Was bought with zero miles and started making strange grinding and knocking noises immediately. When I reported it I was told I couldn’t get it checked for a month and that it was safe to drive until appointment. I was soon stuck in the middle of busy intersections because car would not drive after I give it gas and it acted like it was in neutral. This happened every time I stopped until I made it safely home it was very scary because I could have caused an accident not being able to go when needed and was almost stranded in traffic. There were never any warning lights. After having it towed to the dealership I am now being told it could be transmission problems, but it doesn’t seem there is much knowledge on this particular vehicles mechanics or electrical system. Ford has not been honest or in contact with me about situation. Should not be happening at under 1000 miles and after more research seems is a common issue they knew about that they did not fix before selling to me. It has been at the dealership for 3 weeks with little communication or explanation.

Engine makes intermittent metal crunching and scraping sounds at low speeds.