2021 Ford Bronco Sport complaints

I bought a 2021 Bronco Sport Brand new and ever since the car has been a problem. The rear axle wasn’t getting enough lubricants so it was grinding and I didn’t know what it was at the time but I took it to a Ford dealership and was told after spending 200$ on diagnostic testing that absolutely nothing was wrong with the vehicle. The vehicle kept doing the same thing grinding noises so I took it in again and got the same results now mind you this is way before my power train was up. The car felt so unstable and unsafe it got to the point where I had to just leave it at the dealership until Ford could help me with some financial assistance. While at the dealership Ford told the mechanic to check the transmission and upon checking the transmission the mechanic found a problem. The total of repairs came up to over 10k for a vehicle that doesn’t even have 65k miles on it. I was sold a brand new lemon. This was my first new car purchase and it has literally been the worst experience in my life. The brakes were recalled the fuel injection system now the battery which I’ve already spent 500$ on a new one last year has guess what? Been recalled as of 1/17/2025. So after thousands of dollars in rental car and Uber rides which I have yet to be reimbursed for my vehicle is still at the Ford dealership has been there for over 3 months out of 10k in repairs Ford offered to pay only 4,100. What a rip off buying this junk was. I really thought Ford would do the right thing and take care of

The contact owns a 2021 Ford Bronco Sport. The contact stated while stopped at a traffic light, the vehicle lost electrical power and stalled. The contact stated that several unknown warning lights illuminated before the screen went black. The vehicle was towed to the dealer, where it was diagnosed and determined that the battery had failed. The contact was informed that the battery did not support the function of the vehicle and needed to be replaced. The battery was replaced. The contact stated that on another occasion, while driving at undisclosed speeds, the heating system failed. The contact stated that the passenger’s side vents were not blowing hot air. The vehicle was taken to the dealer, where it was diagnosed that the water pump and gaskets had failed and needed to be replaced. The vehicle was repaired. The failure mileage was approximately 43,000.

August 2024 had multiple instances where the Bronco Sport would stall out while driving, had to maneuver to the side of the road, turn the vehicle completely off, and try multiple times to restart the vehicle. Jack Demmer Ford sent a technician to our house to flash the Powertrain Control Module and Body Control Module. We saw the Part 573 Safety Recall Report 24V-267, where these modules were undercharging the battery, causing the stalling of the vehicle. The vehicle stalled out two more times after the update and has continued to run thereafter. On [XXX], Bronco Sport was struck from behind on the driver's side rear tire, car came to rest against the back axle. There was damage to the axle, rear quarter panel, tail light, and aligned rear tailgate. The vehicle battery was disconnected 12-15 times during the work, we would get messages on the app that "Remote features disabled to preserve battery" as they worked on the vehicle. The vehicle was finally ready on [XXX], for pickup. Drove the car approximately 22 miles and parked in the garage. The following morning we went to start the Bronco and there was a loud bang when we pushed the start button, and all electrical features were dead. We had to vacate the vehicle, all the power features were dead, unload, and take another vehicle for travel. When we returned on [XXX], I popped open the hood and discovered battery damage. Battery acid leaked out into a 5-foot puddle on the garage floor, power steering reservoir drained also.

Battery failed exactly as described in Ford recall 25S02 NHTSA# 25V019. On 11/1/24 drove vehicle 125 miles home on a return trip and parked car in garage. Morning of 11/2/24, vehicle would not start, battery is dead. Tried to charge battery with external charger, would not take a charge. Called dealer, scheduled appointment for 11/4/24. Morning of 11/4/24, started vehicle with a jump box, took vehicle to dealer. Vehicle would not start when shut off at Dealer. Lucky have made it there, I had shut off the auto restart vie dash button, if I had not shut it off, I would have been stranded at my first traffic stop. Dealer determined it was a failed battery, replaced it at a cost of $510 as vehicle was 2 weeks out of warranty. I reluctantly paid the $510. I was lucky that the vehicle did not start running on that (11/1/25) 125 mile drive, the battery was almost dead at the end of the trip, and of course, it would have stalled when battery got too low. There were in-dash warning messages about low battery near the end of the trip. Ford and the dealership won't reimburse me for the $510. They state that they have to test the battery under the recall, even though that original battery was disposed of by the dealership. Dealership wants to test the 2 month old replacement battery under the recall before they can do anything about a refund. That makes no sense, the replacement almost certainly will test ok.

The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. All recall for 1.5L and I am sure the badlands have the same parks and is not included in the recall. less than 60,00o mile with a check engine light on. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere. Please add recall to cover Badland if they contain same parks as 1.5L!!!! Also the windshield wiper pump did not work. I can not clean the windshield wen needing to see out of it. i have to pull over and clean at local gas station.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the Auto START/STOP technology failed to start the vehicle while depressing the accelerator. The contact had to connect a portable charger to be able to restart the vehicle and continue driving. The failure recurred and the engine failed to restart. The vehicle was towed to a certified mechanic who diagnosed and determined that the battery was drained and needed to be replaced. The vehicle was repaired. The dealer was not contacted. The manufacturer was made aware of the failure and informed the contact that the part for the recall repair would be available approximately in April 2025. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 59,340. VIN tool confirms parts not available.

In August of 2024, my vehicle shut down after sitting at a red light. The vehicle would not turn back on nor could I put it in neutral to move it out of the way of traffic. It was explained to me that the battery was bad and had to be replaced when I took it in for service the next day. A recall was placed on my vehicle yesterday related to battery issues and I suspect my prior battery had the same issue as referenced in the recall. My car at the time was under 40,000 miles.

This has been an ongoing issue since I purchased the vehicle in July 2024. It has become so bad that the vehicle is nearly un-driveable. FORD states it is a non-issue, non safety related and there is no know fix at this time. FORD has been buying vehicles back due to this "secret recall" but after numerous calls and visits to both dealers and the Ford customer care line, nothing is being done. And while FORD might state it is an "inconvenience", when driving on the highway and a cylinder just randomly shuts down, the vehicle loses power and backfires and vibrates it is a safety concern. I have been EXTREMELY patience and professional in all my dealings with FORD on this matter, yet they refuse to offer me any help or come to a resolution in my case.

Complained numerous times about a clunk noise art parking lot speeds Finally on my Ford dealer 7/10/24 they diagnosed TSB 24-2185 and had me pay $433.53 to replace Vent Hose not covered under my powertrain warranty My mileage was 48986 on that date If part was labeled as RDU Vent hose why not covered under power train warranty? The day I was there, they has another Bronco in with this same issue they told me The service department told they wouldn't be surprised if thus became a recall. I don't see any recall to this day for this issue Ford knows about

Rear brakes are noisy, they make a grinding noise. Ever since we got the vehicle . Screens turn black while driving , can control infotainment system Water gets into the vehicle when it rains or when getting car washed

The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells like fuel is burning and fumes enter into the cabin. When you push start after fueling it struggles to turn car on to drive. There is full accessory power but no power to drive the car even when giving it gas. It requires multiple attempts at starting the vehicle and it will tremble and shake once it starts running and stutters as if about to shut off even when you start driving it. Today it powered down again while driving and we avoided and accident but it is becoming dangerous to drive the vehicle due to its unpredictable shutting down.

Tranmission failed at 137k miles. Inspection revealed the tranmission was beyond repair and would have to be replaced. Last maintenance was tranmission fluid change at 95k miles by Ford dealer.

The vehicle has been in the shop since day one with many many problems! The TURBO failed under warranty so they replaced it without doing proper procedures. A few months later the turbo failed again out of warranty but this time cracked the head causing damages I can not afford!! The vehicle is sitting at the dealership not fixed!! I want out of this lemon!!! I tried getting them to buy it back when I took it to the shop three different times due to break issues they could not fix but a Ford representative told me it "had too many miles" I work out of this vehicle and have not been able to work now for three months!! Note...after the first TURBO was replaced I told the dealership the vehicle was loosing antifreeze but all they did was pressure check the radiator. A few months later engine failure due to turbo failure!!

The contact owns a 2021 Ford Bronco Sport. The contact stated while his son was driving 55 MPH, several unknown warning lights illuminated. The steering wheel then seized. The vehicle was towed to the dealer and the battery was replaced. The technician inspected the alternator and stated that the alternator could not be replaced since it was fully charged. The contact stated that during the second failure, the emergency brake was applied independently. The vehicle was towed to a Walmart Service Center waiting to be towed by Ford's road side assistance. The manufacturer was not notified of the failure. The approximate failure mileage was 55,000.

The battery that came with the vehicle lasted less than 2 years. It was replaced after one day the car just wouldn’t hold any charge. I have the pep boys receipt and record to prove the battery would no longer hold any charge.

Battery is healthy, but car wouldn’t start. Car was just inspected and passed with flying colors. The car has stalled three times while driving, and a fourth time, it wouldn’t start. It gave the red battery warning on the dashboard when it wouldn’t start. Waited a few minutes and tried a couple times and it finally started. Drove it home nearby and don’t plan on driving it until problem is eradicated. The battery works sometimes and then doesn’t other times. There’s no warning, just stalls out of nowhere every once in a while.

Breaks squeal while in reverse.

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. The contact received notification of NHTSA Campaign Numbers: 22V859000 (Fuel System, Gasoline) and 24V267000 (Electrical System, Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.

The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was taken to a vehicle inspection station, and the contact was informed that the test could not be performed due to a faulty sensor. The contact was informed by a mechanic at the inspection station that the vehicle might be under recall. The local dealer was notified of the failure, and the contact was informed that the vehicle was not included in the recall. The contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,000.

My daughter was operating the vehicle when it unexpectedly lost power and came to a stop without warning. The instrument panel began flashing, and she was unable to restart the vehicle to move it out of traffic. A jump-start was required to get the vehicle operational. It has been taken to Koons Ford Annapolis for evaluation. Vehicle mileage is aprox. 27,000

The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehicle while driving. This has caused the vehicle's owner and her children to get sick and forced them to drive the vehicle with the windows down at all times even in cold weather. Ford's dealers have confirmed the problem several times, but either could not or refused to fix it. A summary of the vehicle's service history is included below: 35,662 miles Customer states inside of vehicle smells like exhaust. 37,431 miles Inside of vehicle smells like exhaust. 39,856 miles inside of vehicle smells like exhaust. confirmed customers concern found cat warped at mating surface to turbo replacement required. 46,832 miles Fumes getting inside the Cab, seems to be blowing in from vents. Misdiagnosed as blower motor electrical smell and missed broken catalyst. 47,300 miles Customer had car towed into shop stating car was shaking and smelled flumes inside the car. Verified concern that exhaust smell was present in car and loud noise was coming from e

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle started losing motive power. A message advising a power train failure was displayed. The driver was able to exit the highway at 15 MPH. The vehicle was driven to a nearby dealer, where the computer was rebooted; however, the failure recurred several times while driving. The vehicle was taken back to the dealer several times, and the transmission was rebuilt. The contact stated that the failure had been recurring while driving. The contact stated while her husband was driving 70-80 MPH, the vehicle lost electrical power and stalled. The check engine and the power train warning lights were illuminated. The driver was able to pull to the side of the road. The vehicle was able to restart but failed to exceed 15 MPH. The driver continued driving on the shoulder of the roadway. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and informed the contact that the repair could not be covered due to the mileage on the vehicle. The failure mileage was approximately 1,310.

Torque converter failure at 100,000 miles. Car hesitates when it accelerates creating delay when going from stop to start.

The contact owns a 2021 Ford Bronco Sport. The contact stated while the vehicle was parked, the windshield washer fluid was leaking out of the front camera. The windshield fluid warning light was illuminated. The failure occurred on several occasions. The vehicle was towed to a dealer to be diagnosed; however, the dealer informed the contact that a cause for the failure was not found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown. The VIN was not available.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at undisclosed speeds and while in reverse, the instrument panel occasionally flickered. The battery failure warning light illuminated intermittently. In addition, the contact stated that while attempting to start the vehicle, the engine failed to turn over. AAA was contacted and arrived on the scene to replace the battery. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.

Bought 12-1-23 got recall 24V-267 fix and then the vehicle started to die at red lights if the autostart/stop wasn't turned off. On 12/9/24 apparently the turbo went out. Unsure how only 95,345 miles. The driver window get stuck down anytime at a drive thru. Will have to turn off vehicle completely and restart for it to roll back up.

On two occasions vehicle has turned off while in drive. Have taken to dealership without a resolution. After vehicle is off for several minutes (unable to turn anything on including hazards) vehicle starts up and computer resets without any warnings. Unable to put the vehicle in neutral to move off the road while occurring.

Since performing a manufacturer update to the Sync technology system, my touch screen has not functioned properly, including the back up camera. The screen goes black or freezes on the rear view camera even when in drive and moving forward. Each time this happens, the system has to be rebooted.

The contact owns a 2021 Ford Bronco. The contact stated that while driving at 80 MPH, a warning message displayed reading "Service charging system soon", after which the infotainment system intermittently functioned properly. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the alternator harness. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA campaign 24V267000 (Electrical System, Power Train); the VIN was included and the vehicle had already been repaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 36,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while her daughter was starting the vehicle, there was a loud sound before the vehicle lost power. The vehicle was taken to the dealer where it was diagnosed and determined that the battery needed to be replaced. The battery was replaced, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 45,500.

[XXX]. about 3 months ago my wife started to smell what she referred to as raw gas odor in the cabin of car. took it to dealership, nothing found. then again complaint of odor in cabin. nothing found. then again smell in cabin. nothing found. I drove the car 40, mils. on errons. had a after oil smell like a oil breather was disconnected. dealership nothing found. wife it smells bad in cabin of car. my truck went in for service, I took the bronco to work, had to have the windows rolled down. on the way home it was real bad. called Ford Moter company. was told to take to another dealer. called our dealer asked for the owner. not around asked for number 2 he was told him we were done. he said he would find the problem. he did the catalytic converter had a crack somewhere. I had to drive with the window down. I am a professional truck driver with over 3 million miles. what if this happened to a mom with kids in the dead of winter. the bronco will be picked up tomorrow after several complaints and several months. I have a case # from the motor company [XXX] . the last may be an [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Bronco Sport. The contact stated that while her son was at a stopped at a traffic light, the vehicle shut off without warning, and started to roll backwards. The contact's son applied the parking brake and later restarted the vehicle. The contact stated that upon restarting the vehicle, several warning lights illuminated. The vehicle was taken to the dealer and the contact was informed that the battery was drained. The vehicle was repaired under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN); however, the contact expressed concern that the same failure might return. The contact also stated that while driving at various speeds, an audible warning chime was coming from the vehicle with the temperature gauge was hot(H). The vehicle was taken to an independent mechanic where coolant was added; however, the failure returned. The vehicle was later taken to a dealer where the water pump was replaced. The contact stated that the failure recurred twice. The manufacturer was notified of the failure and the contact was given a case number. The vehicle was not repaired. The failure mileage was approximately 57,000.

As I was driving the vehicle it lost all power. Nothing on it worked, including the locks and windows. It turns out that the warning system that my battery was low wasn’t functioning and my battery was down to 5%. If I had gotten notice I could have replaced the battery prior to the car literally bricking as I was driving it on a busy city street.

While in reverse when you press on the breaks they squeal.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while his wife was driving at an undisclosed speed, the engine seized. The contact's wife attempted to restart the vehicle; however, the vehicle failed to start as intended. In addition, the contact stated that the failure occurred on a busy freeway. The contact stated that a Police Officer assisted the contact's wife due to the failure. The vehicle was towed to a business parking lot and was then towed to the dealer and was diagnosed with battery failure. The vehicle was repaired. The contact stated that the battery control module and the power control module were previously recalibrated under NHTSA Campaign Number: 24V267000 (Electrical System, Power Train). The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

My 2021 Bronco Sport suddenly died on [XXX]. The parking brake engaged unexpectedly, locking all four brakes and resulting in a significant skid mark. An error message flashed: “Park Not Available. Apply Park Brake Before Exiting,” and the park gear light blinked. I turned off the engine again, but the car was dead when I tried to restart it. After getting a jump start, the car turned on. However, the parking brake engaged again shortly after. I was able to drive it off the road. My wife, a research librarian, found that many others have reported issues related to “Sudden Death Syndrome." See below. [XXX] [XXX] ). The car was towed from PA, where we were visiting, to Stanford Ford, where we purchased it on [XXX]. On 11/13, the dealership told us there was a short circuit in the wiring connected to the solenoid and estimated $900.00 for labor. At noon on 11/15, the technician was test-driving the car. By 4:17 PM, I was told it was ready. 5 min. later, they told me it wasn't ready due to another issue. At 11:15am on 11/18, we were informed the issue was a short circuit in the transmission, costing $13,000. How is that possible? The car is only three years old! We've faced many recalls with this car, the last just this past August, but the most dangerous issue is the unexpected engagement of the parking brakes, causing chaotic behavior. Given the number of similar incidents, it's hard to believe there hasn't been a recall. We could have been injured or even killed if we had been

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when the parts would become available. The contact stated while the vehicle was parked and attempting to start the vehicle, the vehicle failed to start. The contact stated that there was smoke coming from the engine compartment. The Fire Department was called, and the engine temperature was checked inside and outside the vehicle and it was determined that the engine had overheated. The vehicle was towed to the dealer to be diagnosed and it was determined that the water pump was leaking, the alternator had overheated, and the battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 32,468.

REAR DIFFERENTIAL- CAR IS SHUDDERING WHILE TURNING- SAFETY ISSUE

My vehicle was emitting fumes into my vehicle and making a strange noise. When I took it to the dealership they tested the emissions/catalytic converter and fuel injectors. Which all showed no issues. When investigating further, they found that the weld on the catalytic converter had broke and was causing an unstable catalytic converter. Service manager reported to me that he felt this was definitely a manufactured defect and said if I hit a bear that shouldn’t have been an issue. No bear was hit and there was NO incident at all. Just driving to and from work.

The contact owns a 2021 Ford Bronco Sport. The contact stated that upon attempting to start the vehicle, the vehicle failed to start and was jumpstarted. The message "Battery Saver Mode" was displayed on the infotainment system screen. Additionally, the contact stated that failure had caused the engine auto Start-Stop system to become inoperable, causing the engine to not restart automatically while attempting to resume driving from a complete stop. The contact stated that she had deactivated the engine auto Start-Stop system. The contact stated that upon accelerating from a complete stop, the vehicle hesitated to respond. The vehicle was taken to Advance Auto, where the battery was tested, and the contact was informed that the battery was in good condition and did not need to be replaced. The vehicle was taken to the dealer, where the battery replacement was recommended; however, the dealer informed the contact that there was no guarantee that the battery replacement would correct the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 49,000.

The contact owns a 2021 Ford Bronco Sport. The contact had received notification of the NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); and the vehicle was taken to the dealer to be repaired. The contact stated that 4 months later, while stopped and idling at a stop light, the vehicle lost power. The contact was unable to use any of the features or systems within the vehicle. The vehicle was towed to the dealer who diagnosed and determined that the battery had failed and needed to be replaced. The battery was replaced. The manufacturer was made aware of the failure and opened a case. The failure mileage was 25,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the shaking to cease before the vehicle was taken to the local dealer to be diagnosed. The contact was informed that the transmission needed to be replaced, and the engine needed some undisclosed repairs. The vehicle was not repaired. The contact believed that the failure was related to NHTSA Campaign Number: 22V859000 (FUEL SYSTEM, GASOLINE) for which the VIN was included; however, the recall repair had not yet been performed. The manufacturer was notified of the failure. The approximate failure mileage was 108,000.

My ford bronco stalled when I was slowing down at a traffic light. The entire car shutdown. The steering wheel locked up and the car could not be put into neutral. After about 15 minutes the car was able to turn on again. The stalling out at an intersection put me in danger by putting me in a situation where I was stuck in active traffic without the ability to move my car to a safe area off of the main road. There were no warning lights or messages prior to the car completely shutting off at the traffic light.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing during morning startup and depressing the brake pedal, the vehicle made an abnormal loud moaning sound. The contact stated that the abnormal loud sound increased over time. There were no warning lights illuminated. The vehicle was taken to the local dealer several times, where the failure was acknowledged, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened, but no additional assistance was provided. The failure mileage was approximately 2,000.

Brakes Made loud squeaks noise when in reverse. Have taken into dealer multiple times and not fixed. They say an issue with Bronco Sports but my vin does not show on recall. Worried about brake failures or issues that could arise. They replaced front rotors and deglazed pads. Spent 462.19 and problem never fixed.

The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere, not only does this not help with emissions control into the atmosphere, but it decreases fuel efficiency and increases gasoline smell into the vehicles cabin.

The contact owns a 2021 Ford Bronco Sport. The contact stated while reversing at an undisclosed speed, the contact heard an abnormal sound coming from the axle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 31,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while in reverse with the brake pedal depressed, there was an abnormal sound coming from the brakes. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that the failure was a manufacturing defect; however, no remedy was available to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 37,800.

The contact owns a 2021 Ford Bronco. The contact stated that while driving approximately 70 MPH, there was an abnormal vibrating sound coming from the moon roof. The contact stated that the moon roof started to bend inward and required to be held up manually. The contact then closed the moonroof. The contact contacted an independent mechanic and was informed that it was a known failure. The mechanic referred the contact to the dealer. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 40,000.

The contact's husband owns a 2021 Ford Bronco Sport. The contact stated while reversing, the vehicle made an abnormal bumping and squealing sound. The vehicle was taken to the dealer, where the contact was informed that the squealing sound was caused by the brake pad material, and the bumping sound was caused by the brake calipers and rotor material. The dealer informed the contact the failure was a manufacturing defect. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.