Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 1995 record →
CONSUMER STATES WHILE TRAVELING AT 65 MPH, VEHICLE SUDDENLY STARTED TO SLOW DOWN. CONSUMER STATEED HAD TO PULL CAR OVER. CONSUMER FEELS LUCKY THAT VEHICLE WAS NOT ON A HIGHWAY. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB
CONSUMER STATED THE ABS BRAKES FAILED TO ENGAGE AND THE WHEELS LOCKED UP WHILE MAKING A SUDDEN STOP, DEALER HAS BEEN UNABLE TO REMEDY PROBLEM. NLM
DRIVER WAS TRAVELING AT 45 MPH WHEN VEHICLE WENT FROM THIRD GEAR TO FIRST GEAR WITHOUT WARNING. VEHICLE SUDDENLY SLOWED DOWN, ALMOST CAUSING A REAR END COLLISION BY ANOTHER DRIVER. PLEASE PROVIDE ANY FURTHER INFOMATION.*AK
WHILE DRIVING VEHICLE JERKS AND BACKFIRES. WHEN DRIVING OFF FROM A STOP VEHICLE HAS NO POWER. TOOK TO DEALER, AND DEALER INDICATED IT WAS A LEAK IN HEAD GASKET.*AK
*YH
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
THE CONSUMER HAD RECEIVED SAFETY RECALL ON LOWER LATERAL ARM BALL JOINTS, BUT THE DEALER DELAYED FIXING THE VEHICLE BECAUSE, PARTS WERE NOT AVAILABLE AND THE ORDERED PARTS WERE NOT RECEIVED ON TIME. *YH
THE VEHICLE WAS TAKEN IN FOR CURRENT RECALL ON BALL JOINT BOOT ON 3/16/01. DEALER REPORTED PART WAS ON NATIONAL BACK ORDER AND COULD TAKE UP TO ONE YEAR TO GET PART. I DONT FEEL THE RECALL LETTER READS INDICATES THE URGENCY NOR THE SERIOUSNESS OF NOT GETTING THE VEHICLE REPAIRED IMMEDIATELY. AS OF 3/16/01 THE LEFT BALL JOINT HAD NO PROBLEM WITH BOOT WHEN INSPECTED ALTHOUGH THE RIGHT BOOT HAD CRACKED. THE LEFT BALL JOINT WAS THE ONE THAT SEPARATED CAUSING THE ACCIDENT. THE RECALL IS FOR INSPECTION OF BOOT AND REPLACEMENT IF NEEDED. I AM GLAD I WASN'T DOING 65 MPH WITH MY FAMILY IN THE VEHICLE. MAYBE CHRYSLER SHOULD RETHINK THERE MOTIVE FOR INSPECTION AND REPLACEMENT AS NECESSARY AND REPLACE THE ALL BEFORE SOMEONE LOSES THEIR LIFE.
PRIOR TO RECALL, WHILE MAKING A TURN, THE LOWER ARM BROKE, CAUSING THE PASSENGER SIDE OF THE CAR TO FALL TO THE GROUND, CONSUMER IS REQUESTING REIMBURSEMENT FOR THE REPAIRS DUE TO THE OCCURENCE HAPPENING PRIOR.*YD
CONSUMER RECEIVED A RECALL 00V421002/ MANUFACTURER'S RECALL967 THAT DEALER DENIED COMMPLETING. RECALL STATED BRIEFLY IF BALL JOINTS DIDN'T NEED TO BE REPLACED, THEN THEY WOULD E CLEANED AND ADDED A SPECIAL SEALANT TO PREVENT INTRUSION OR MOISTURE. DEALER DENIED CARRYING OUT SECOND PART OF RECALL. *AK
THE CRANKSHAFT THRUST BEARING BECOMES SEVERLY WORN DUE TO A *KNOWN* DESIGN FLAW IN THE OILING SYSTEM (MANUFACTURER IS AWARE OF THE DESIGN FLAW AS EVIDENCED BY THE TSB'S SENT TO ITS DEALERS REGARDING THE ISSUE). THIS WEAR EVENTUALLY CAUSES EXCESSIVE LATERAL PLAY IN THE CRANKSHAFT WHICH DAMAGES THE CRANKSHAFT POSITION SENSOR MOUNTED EXTERNALLY TO THE ENGINE BLOCK (THIS FAILURE HAS BEEN KNOWN TO OCCUR AS EARLY AS 10,000 MILES ON THE ODOMETER OR AS LATE AS 100,000 MILES). THIS WILL, WITHOUT WARNING, KILL THE ENGINE. ON AN EXPRESSWAY DOING 70MPH, IT'S A DIFFICULT AND DANGEROUS TASK TO NEGOTIATE 4 LANES OF TRAFFIC DOING HALF THE POSTED SPEED LIMIT IN A CAR COASTING ON ITS OWN DEAD WEIGHT WITH NO POWER-ASSISTED BRAKES OR STEERING (I'VE HEARD OF MORE THAN ONE INSTANCE WHERE THE FAILURE CAUSED AN ENGINE FIRE). THIS PROBLEM ONLY AFFECTS THE *TURBO* ENGINE DESIGNATED "MITSUBISHI 4G63 2.0L TURBO" IN THE EAGLE TALON AND MITSUBISHI ECLIPSE MANUFACTURED DURING AND AFTER THE 1995 MODEL YEAR. I KNOW OF 3 OTHER TURBO TALON/ECLIPSE OWNERS IN THE OKLAHOMA CITY AREA ALONE THAT HAVE HAD THEIR CAR JUST *DIE* WHILE DRIVING. SOME HAVE HAD THE PROBLEM "FIXED" UNDER WARRANTY ONLY TO HAVE THE PROBLEM RETURN AFTER THE WARRENTY HAD EXPIRED. THE FAILURE RATE IS PRETTY MUCH 100% AND *WILL* HAPPEN TO *EVERY* 4G63 EQUIPPED TALON AND ECLIPSE MADE DURING AND AFTER THE 1995 MODEL YEAR EVENTUALLY. UNFORTUNATLY, THE NUMBER OF TALON'S AND ECLIPSE'S ORIGINALLY EQUIPPED WITH THE OPTIONAL TURBO ENGINE IS A TENTH THE N
DURING ROUTINE OIL CHANGE MECHANIC FOUND A OIL LEAK ON HEAD GASKET. VEHICLE NOT REPAIRED AT THIS TIME.*AK
MISMATCHED SIZES BETWEEN CRANKSHAFT AND BALL BEARINGS, ENABLING THE CRANKSHAFT TO MOVE. THE MOVING CRANKSHAFT DESTROYED THE CRANK SHAFT SENSOR, AND THERE IS SIGNIFICANT WEAR IN THE BALL BEARINGS. ALL THREE INDEPENDENT DEALERS I CONTACTED REGARDING THIS PROBLEM DEEM IT BEYOND NORMAL WEAR--A DEFECTIVE PART. FURTHER RESEARCH AT THE DSM CAR CLUB (HTTP://WWW.DSM.ORG) REVEALED THAT THIS IS A COMMON PROBLEM IN TALON/ECLIPSES, MODEL YEARS 1995-1998. THIS IS A SAFETY CONCERN BECAUSE THE CAR ENGINE WILL STOP WITH NO WARNING, LEAVING THE DRIVER WITHOUT ASSISTED STEERING. I CONTACTED CHRYSLER, BUT THEY DISAVOW ANY RESPONSIBILITY.*AK
SOMETIMES THE HORN WILL BLOW AND AT OTHER TIMES IT WILL NOT BLOW.*AK
AFTER TAKING THE CAR TO A MECHANIC AND RESEARCHING THE PROBLEM ON THE INTERNET IT HAS BECOME EVIDENT THAT I HAVE WHAT IS NICKNAMED OR CALLED "CRANKWALK". THIS IS AN ISSUE THAT RESULTS FROM THE CRANKSHAFT OR THRUST BEARINGS ALLOWING THE CRANKSHAFT TO MOVE FREELY. THIS MOVEMENT ALLOWS THE CRANKSHAFT TO MOVE, WHICH WEARS A GROVE INTO THE ENGINE BLOCK AND OR ALLOWS THE CRANKSHAFT TO HIT THE CRANK-ANGLE SENSOR AND BREAK IT, BOTH OF WHICH RESULTING IN A TOTAL LOSS OF THE ENGINE BLOCK. I AM EXTREMELY DISAPPOINTED THAT MITSUBISHI AND CHRYSLER HAVE NOT COME FORWARD WITH THIS MANUFACTURING FLAW. MITSUBISHI HAS SAID THAT THIS IS A COMMON PROBLEM BUT HAS NOT MADE ANY REPARATIONS TO THE OWNERS OF THESE VEHICLES. I AM BEING TOLD THAT THERE IS A CLASS ACTION LAWSUIT BEING PUT TOGETHER AS A TYPE THIS, BUT I AM HOPING THAT THE MANUFACTURER WILL MAKE THINGS RIGHT WITH ME AND REPLACE MY ENGINE BLOCK AT THEIR COST. THANK YOU FOR THE SPACE WITH WHICH I AM EXPRESSING MY DISPLEASURE. THE RESULT OF THIS AND MY DISCUSSION WITH THE MANUFACTURER DIRECTLY, WILL DECIDE IF I OR ANYONE ELSE IN MY FAMILY WILL EVER PURCHASE A CHRYSLER OR MISTUBISHI PRODUCT EVER AGAIN.
FUMES WERE ENTERING INTO PASSENGER'S COMPARTMENT. A RECALL HAS BEEN ISSUED ON VEHICLE'S MAKE AND MODEL. HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN.*AK
COMPUTER CONTROL MODULE WAS CAUSING VEHICLE TO STALL. ALSO CAUSED FUEL PUMP TO SHORT OUT. *AK THE CONSUMER SAYS THE VEHICLE HAD SEVERAL RECALLS AND STILL EXPERIENCING THE COMPUTER FAILURE. *YH
I WAS DRIVING VERY SLOWELY OVER RR TRACKS.WHEN ALL OFASODDEN MY BALL JOINT IN THE DRIVERS SIDE SNAPPED OUT OFF THE CONTROL ARM. *AK (TIRESIZE: 205/70/R16)( DOT NUMBER: TIRE SIZE: 205/70/R16 )
THE CYLINDER HEAD GASKET WAS LEAKING ON TO THE MANIFOLD AND COULD HAVE CAUSED A FIRE IF NOT TAKEN CARE OF. ESTIMATE AT THE DEALER WAS FOR APPROX. $1,000. MECHANIC AT A LOCAL GARAGE SAID HE HAS REPLACED MANY ON THIS MOTOR FOR CHRYSLER AND MITSUBISHI. APPARENTLY CHRYSLER ALSO HAS REDESIGNED THE GASKET 3 TIMES IN ORDER TO CORRECT THE DEFECT. I BELIEVE THIS SHOULD BE A RECALL BECAUSE OF THE DANGER OF FIRE AND THE ORIGINAL DESIGN DEFECT.*AK
WHILE DRIVING ABOUT 5 MPH LEFT FRONT BALL JOINT BROKE. *AK
CONSUMER WAS INVOLVED IN CRASH DUE TO BROKEN LOWER BALL JOINT. PRIOR TO INCIDENT,CONSUMER TOOK VEHICLE TO FERRERO EAGLE, DEALER IN LOVELAND CO,TELE#970-667-4433 FOR RECALL 99V066003 ON OCT 23,2000. DEALER CLAIMED IT PASSED INSPECTION, AND DID NOT DO REPLACEMENT.*AK
TRANSMISSION WENT OUT DUE TO FROZEN TRANSFER CASE . *AK
EITHER THE SEALS WENT BAD, OR THE TRANSFER CASE WENT BAD, EITHER WAY, THAT CAUSED A LOSS IN LUBRICATION, WHICH TOOK OUT MY ENTIRE TRANSMISSION. I HAD TO REBUILD THE WHOLE THING, ALL OF WHICH ENDED UP COSTING ME $2673.00!!*AK
WHILE DRIVING FRONT END VIBRATES AND SHAKES. TOOK VEHICLE AUTOMOBILE SHOP, AND WAS NOTIFIED THET BALL JOINTS WERE NOT SAFE AND WILL BREAK SOON. *AK
WHEN CLUTCH IS DEPRESSED, IT'S MUCH SOFTER THAN ORIGINAL AND METAL-SCRATCHING NOISE COMES FROM PULLEY SIDE OF ENGINE. SOMETIMES CLUTCH STAYS DEPRESSED AFTER LIFTING LEFT FOOT. SOMETIMES ENGINE STALLS IN STOP WHEN CLUTCH IS DEPRESSED. THE ISSUE IS WHEN CLUTCH IS DEPRESSED, IT PUTS A FORCE ON THE THE FLYWHEEL WHICH MOVES THE CRANKSHAFT, HENCE CRANK-END PLAY OR CRANKWALK.*AK
RELATING TO THE ENGINE:MAINBEARING PROBLEM, THIS IS THE THIRD CAR OF THIS TYPE I HAVE OWNED (ALL VINS AND RECIEPTS AVAILABLE) THAT THIS HAS HAPPENED TO. IT IS REFERREDD TO BY MANY AS "CRANKWALK". THE OIL PRESSURE TEST SHOW A NORMAL PRESSURE, YET THE #4 BEARING HAS BEEN DEPRIVED OF OIL AND SEEMS TO GRIND THE BEARING DOWN SLOWLY UNTIL THERE IS SO MUCH EXCESSIVE CLEARENCE THAT THE PISTON STARTS HITTING THE CYLINDER HEAD AND DESTROYS THE ENTIRE ENGINE ASSEMBLYL. I HAVE READ ONLINE POSTS AT HTTP://WWW.DSM.ORG FROM HUNDREDS, IF NOT THOUSANDS, OF OWNERS OF THIS SAME CAR AND ITS TWIN - THE MITSUBISHI ECLIPSE GSX/GS-T - ABOUT THIS SAME PROBLEM AND WONDER WHY IF THERE IS SO MANY REPORTS OF THIS HAPPENING, WHY HAVE THEY NOT BEEN RECALLED. *AK
ENGINE BEARINGS WERE NOT RECIEVING OIL. ENGINE WAS INSPECTED AND FOUND TO BE FREE FROM BLOCKAGE AND DEBRIS. OIL PUMP WAS WORKING AS SPECIFIED. NO CAUSE COULD BE FOUND AS TO WHY BEARINGS WERE NOT RECIEVING OIL. BEARINGS WERE FOUND TO HAVE EXCESSIVE CLEARENCE THAT RESULTEDD IN THE PISTON BEENING ABLE TO PHYSICALLY HIT THE CYLINDER HEAD LEAVING EXTENSIVE DAMAGE TO THE CYLINDER HEAD, REQUIRING THE ENTIRE ENGINE TO BE REPLACED. WHEN I CONTACTED DAIMLERCHRYSLER AND MY DEALER, I WAS TOLD THAT THIS WAS NOT A COMMON OCCURANCE SO THERE WAS NO RECALL ON IT. HOWEVER, I HAVE DISCOVERED ON WEBSITES SUCH AS WWW.DSM.ORG THAT THIS IS A COMMON OCCURANCE WITH THIS PARTICULAR MODEL.*AK
ENGINE BEARINGS WERE NOT RECIEVING OIL. ENGINE WAS REBUILT WITH NEW OEM CRANKSHAFT, BEARINGS, PISTONS, RODS, AND CYLINDER HEAD. NOT EVEN A MONTH LATER THE SAME EXACT PROBLEM HAPPENS AGAIN. ENGINE WAS INSPECTED AND FOUND TO BE FREE FROM BLOCKAGE AND DEBRIS. OIL PUMP WAS WORKING AS SPECIFIED. NO CAUSE COULD BE FOUND AS TO WHY BEARINGS WERE NOT RECIEVING OIL. BEARINGS WERE FOUND TO HAVE EXCESSIVE CLEARENCE THAT RESULTEDD IN THE PISTON BEENING ABLE TO PHYSICALLY HIT THE CYLINDER HEAD LEAVING EXTENSIVE DAMAGE TO THE CYLINDER HEAD, REQUIRING THE ENTIRE ENGINE TO BE REPLACED. WHEN I CONTACTED DAIMLERCHRYSLER AND MY DEALER, I WAS TOLD THAT THIS WAS NOT A COMMON OCCURANCE SO THERE WAS NO RECALL ON IT. HOWEVER, I HAVE DISCOVERED ON WEBSITES SUCH AS WWW.DSM.ORG THAT THIS IS A COMMON OCCURANCE WITH THIS PARTICULAR MODEL.
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
CONSUMER RECEIVED RECALL REGARDING THE OIL GASKET, DEALER CHANGED THE GASKET AND A MONTH LATER VEHICLE OVERHEATED, DEALER REPLACED THE THERMOSTAT AND CONSUMER PAID FOR REPAIRS. *SLC
VEHICLE WONT GO INTO GEAR, IT DROPS OUT IN FIRST AND SECON. CONSUMER HAS TO TAKE OFF IN 3RD GEAR IN ORDER TO GO. *AK
CONSUMER TOOK AUTOMOBILE TO DEARLER FOR RECALL REPAIRS, AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH VEHICLE. NO RECALL WAS CHECKED OR REPAIRED. LATER ON, SUSPENSION FAILED, AND HAD AN ACCIDENT AT APPROXIMATELY 65 MPH. NO INJURIES. *AK
HAD TO REPLACE ENGINE TURBO-CHARGER TWICE, HEADGASKET ONCE AND ENGINE BLEWOUT. *AK
I'VE HEARD THAT THERE WERE RECALLS ON MY CAR AND THESE ARE THE MAJOR PROBLEMS WRONG WITH IT. THIS IS THE ONLY WAY I KNOW OF TO FIND RECALLS. THANKYOU FOR YOUR HELP. NO SAFETY DEFECT LISTED. *AK
THIS CAR HAS MANY FAILING PARTS, MINOR & MAJOR, WE DON'T THINK ITS NORMAL. THE ELECTRICAL PROBLEMS HAVE BEEN ONGOING SINCE SHORTLY AFTER AUTO WAS PURCHASED BY USE (12/99). OUR OUT-OF-POCKET EXPENSES THUS FAR APPROX. $2300.00. THIS CAR SEEMS TO BE A BIG LEMON! ANY INFORMATION WOULD BE MOST WELCOME. THANK YOU.*AK
CONSUMER WAS DRIVING AT 10 MPH AND SLID INTO BACK OF VEHICLE DUE SNOW CONDITIONS. DUAL AIRBAGS DID NOT DEPLOYING, CAUSING DAMAGE TO RIGHT FRONT END , TOTALLY CRUMPLED. PLEASE PROVIDE FURTHER INFORMATION.*AK
RECEIVED RECALL NOTICE 99V066003, TOOK VEHICLE TO DEALER WHO SAID PART WAS OKAY. 13 MONTHS LATER, AXLE BROKE DUE TO LEFT BALL JOINT PROBLEM. 1 WEEK LATER RIGHT BALL JOINT BROKE, DEALER CHARGED FOR BOTH REPAIRS. *AK
LOWER CONTROL ARM NUT CAME OFF, CAUSING DRIVER'S SIDE TIRE TO COME OFF, AND THE FRONT END OF THE VEHICLE TO DROP. PLEASE GIVE ANY FURTHER DETAILS.*AK
ABS SYSTEM FAILED, CAUSING EXTENDED STOPPING DISTANCE. DEALER CAN'T FIX VEHICLE UNTIL MANUFACTURER GIVES APPROVAL. RECALL 94V199001 ON ABS WAS ISSUED BUT IT DIDN'T APPLY TO THIS VEHICLE . ALSO REPAIRED WATER PUMP. *AK
"CRANK WALK". *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
FUEL TANK INLET HOSE LEAKED, WHEN FUEL TANK WAS FULL, GAS WOULD LEAK ON THE GARAGE FLOOR
THE BATTERY ONLY LAST 1 YEAR. THE COMPUTER GETS WET INSIDE SOMEHOW AND SHORTS OUT, THIS IS VERY COMMON ON THESE CARS. I HAVE SPOKEN TO A FEW OTHERS AND THEY HAVE THE SAME PROBLEM. THERE IS A SEAL OR SOMETHING THAT IS NOT I PLACE.
WHILE DRIVING WOULD SMELL STRONG FUEL ODOR. THEN, WHEN STOPPING FOUND OUT THAT FUEL HAD BEEN LEAKING UNTIL EMPTYING HALF OF FUEL TANK. TOOK VEHICLE TO DEALER, AND TECHNICIAN SAID THATTHE CAUSE WAS A RUBBER FUEL LINE THAT BUSTED. *AK
HE WAS TRAVELING ABOUT 25MPH ON A STREET, CAME TO A SUDDEN STOP, AND DRIVER'S SIDE WHEEL FELL OFF. THERE WAS NO PRIOR WARNING. *AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
THE DEFECTIVE BALL JOINT BOOTS FAILED PRIOR TO RECALL NOTICE 99V-066 CAUSING THE CONSUMER TO LOOSE CONTROL OF THE VEHICLE ON THREE OCCASIONS. NLM
I AM WRITING THIS TO YOU BECAUSE MY FRIEND RECENTLY HAD A PROBLEM WITH HIS ECLIPSE KNOWN AS "CRANK WALK" EVER SINCE THE 2ND GENERATION (95-99) TURBO ECLIPSE AND TALONS CAME OUT THEY HAVE BEEN WITH FAULTY CRANKSHAFTS. THE CRANKS EVENTUALLY WERE OUT THE THRUST WASHER AND SHIFT TO THE POINT THAT IT DESTOYS THE CRANK ANGLE SENSOR, SHUTTING OFF THE MOTOR. MITSUBISHI IS AWARE OF THE PROBLEM. ITS THEIR FAULT. THE VEHICLES ARE BAD FROM THE FACTORY BUT YET MY FRIEND HAS BEEN DENIED A WARRANTY CLAIM BECAUSE HE MADE A FEW UNREALTED PERFORMANCE MODIFICATIONS. PLEASE, I URGE YOU TO FORCE MITSUBISHI TO RECALL THE CARS WITH THESE BAD CRANKS BEFORE SOMEONE MOTOR SHUTS OFF AND AN ACCIDENT IS CAUSED. YOU KNOW HOW BAD MITZ IS WITH RECALLS AS WITH THE LEAKY TRANSFER CASE. PLEASE CHECK THIS WEBSITE. HTTP://WWW.ROADRACEENGINEERING.COM/WALKINGCRANKSHAFT.HTM FOR OTHER PEOPLES EXPEREIENCES WITH CRANKWALK FAILURES. ALTHOUGH I HAVE A 92 AWD TALON MYSELF (WITH A LEAKING TRANSFER CASE) I HAVE WITNESS THREE OF MY FRIENDS SUFFER CRANKWALK FAILURES. OF THEM ONLY ONE WAS ABLE TO GET HIS DEALER TO COVER THEM. PLEASE INVESTIGATE THIS BEFORE SOMEONE'S CAR SHUTS OFF WHILE THEY ARE DRIVING AND AN ACCIDENT IS CAUSED. ALL THREE OF MY FRIENDS ESCAPED INJURY BUT WHO KNOW WHEN SOMEONE ELSE WONT BE SO LUCKY. THANK YOU. *AK
STEERING WILL LOCK UP WITH NO APPARENT REASON. I HAVE TALKED TO MANY MECHANICS, NOBODY HAS AN ANSWER PLEASE HELP. *AK
CLOCK SPRING IN AIRBAG ASSEMBLY FAILED, CAUSING AIRBAG TO EJECT AT ANY ANY TIME. *AK
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 1995 Eagle Talon → · Every Talon year → · How the figures are calculated →