2012 Dodge Ram 1500 complaints

The component affected on my 2012 dodge ram is the front fuel tank strap frame "T slot" bracket that has corroded with water mix with road salt, making the fuel tank to dangle and possibly causing it to drop and make contact with the ground. I know other ram truck have this recall but unfortunately this recall doesn't show up on my vin. The problem has been confirmed by a dealer but unfortunately they cant not fix it unless the recall shows on my vin or i pay out of pocket.

The contact owns a 2012 Ram 1500. The contact stated while driving 80 MPH, the vehicle lost motive power and stalled without warning. The contact stated he depressed the brake pedal desperately and shifted the vehicle into park and then restarted the vehicle and the vehicle operated normally. The vehicle was taken to the dealer and the fuse box was replaced, but the failure reoccurred. The vehicle was taken to the dealer and the dealer stated that the ignition module needed to be replaced. The manufacturer was not contacted. The failure mileage was 115,000.

I have found on lots of other dodge vehicles made this same year have a recall on the TIPM Totally Integrated Power Module which controls the electrical system in your car. It is the black box that has power board and fuses inside. I found through internet research THAT MANY PEOPLE have said they have the same problem with their 2012 dodge ram Laramies 1500. The truck will not run. Sometimes it clicks on but I read that you CAN NOT DRIVE until it is fixed because that one piece basically controls the entire truck and it could cut off while driving and make you lose all control of vehicle. This particular year make and model SHOULD HAVE BEEN INCLUDED WITH THE OTHER DODGE RECALLS FOR THIS SAME PART. PLEASE I'M BEGGING YOU RECALL THE TIPM SO I CAN GET MY TRUCK FIXED AND BE ABLE TO safely drive it again. I don't have several hundred dollars to replace this part when it should not be defective to begin with. Thanks so much please call me with any questions.

The vehicle is making a loud clicking noise coming from the engine area. . it gets louder when accelerating. It is unknown to me if it could be manifold issues or camshaft issues. It feels unsafe to drive.

Gas tank sagging loosely, strap is not supporting tank.

Abs speed sensor not working causing the abs traction control and 4x4 not to work, also cruise control also won't work, truck spun out due to no abs and was stranded in winter condition not being able to use 4x4

The contact owns a 2012 Ram 1500. The contact was unable to start the vehicle. The contact stated that the check engine warning light was illuminated. The contact was able to restart the vehicle after 10 attempts. The contact took the vehicle to an independent mechanic and was informed the Totally Integrated Power Module (TIPM) needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 125,000.

Complete engine failure caused by lifters sticking due to lack of lubrication which is a well known problem with the hemi engines. It occurred in my case at approximately 140,000 kilometres despite being maintained religiously with all oil changes done at 5000 kilometre intervals using synthetic oil. Only fix possible because of the damage was to purchase a new long block at a cost of approximately $8000.

My 2012 Dodge Ram shuts off or stalls for no apparent reason. Sometimes upon starting, while going down the freeway (at freeway speeds), as well as speeds in between, This has happened with my family in the vehicle and even when we are towing our stock trailer with animals inside. This is very scary for all of us and dangerous for all those on the round around us. While we have not been involved in any accidents, its just a matter of time. There is never any warning when this happens and it not only shuts off it looses power to everything. So times it catches its self and restarts, other times we have to manually restart the engine.

I'm currently having the Recall no.18V160000 problem on my 2012 ram 1500 slt 4.7 but since the vin number on my truck doesn't show this recall, the dealer doesn't want to fix it. My truck currently has the front fuel tank strap frame "T-Slot" bracket broken.

Malfunction of electronic stability control while in 4x4 driving in heavy snow. Almost hit a light pole, could have caused significant harm. Unknown. No. No precursors. Hit a pot hole while on the on ramp unloading the suspension and the truck started to yaw clockwise. Applied throttle to have front end pull truck straight. ESC applied brakes and chopped power inducing a significant yaw rate counterclockwise driving the rear of the truck into the hard snow bank perpendicular to vehicle travel. Another excessive clockwise yaw occurred at this time. NO throttle control and brakes unresponsive. 1. Had the driver been allowed to retain throttle control upon initial yaw this was easily recoverable. 2. Anti-lock brakes, needed to be disabled so the truck could slide across the snow and not into the ditch when the second clockwise yaw started. 3. This caused minor body damage to the vehicle.

I had a recall, R36 - NHTSA Recall #15V-459, completed in 2015 for my 2012 Dodge Ram 1500. However, currently, the same issues associated with that recall is causing my Air Bag warning light to turn on. This is surely a safety issue. By the recommendation of Mopar/Stellantis Customer Care, I had it diagnosed by the dealer and was told I have to pay for the cost to repair. I believe this same issue, Clock Spring malfunction, is the same as the recall and should be fixed and the cost to repair not be incurred by the owner. Expired warranty, completed recall, etc. shouldn't be a factor if the same problem is happening, hence the recall.

The contact owns a 2012 Ram 1500. The contact received notification of NHTSA Campaign Number: 17V821000 (Power Train) and confirmed having the recalled component. The contact made a local dealer aware; however, he was informed the vehicle was unable to be serviced under the recall and advised to contact the manufacturer. The vehicle was not repaired, and the contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware and confirmed the vehicle was unable to be serviced under the recall and the contact was advised to file a complaint with NHTSA. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2012 Ram 1500. The contact stated that the fuel tank strap brackets rusted and detached from the vehicle. Additionally, the fuel tank was also rusted. The contact received notification of NHTSA Campaign Number: 18V160000 (Fuel System Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 170,000. Parts distribution disconnect.

My truck has completly shut off on me while driving several times. The last time my truck shut off I was in 4 wd due to snow and ice and the truck shut down I lost steering and slid sideways. It was scary. I could have been seriously injured or hurt someone else due to a crash. I know the win module is the issue because if I just barely touch the key fob while its in the ignition my truck immediately shuts off. I have talked to the dealership and they said the win module failure is a common problem.

Exhaust manifold failed (warped and broke bolts) for second time since owning my 2012 Ram 1500 causing dangerous exhaust leak that then enters the cabin of the vehicle causing dangerous conditions for the occupants.

Issue is that the exhaust manifold studs/bolts break off in cylinder head(s) on 5.7L Hemi engines causing exhaust leak in engine compartment in which could allow carbon monoxide to be drawn into passenger compartment. I personally replaced all the bolts/ studs along with new gaskets each time. Even once replacing exhaust manifolds only to have this issue continue to happen repeatedly.

Intermittent fault from the TIPM module. When slowing to a stop, or slowing to make a turn, the engine dies without warning resulting in loss of power steering and operability while in traffic. The only indication that the engine has died is the tachometer reads 0 RPM, loss of power steering, and the excelerator becomes inoperable. The radio, headlights, and A/C stay on during this. Coming to a complete stop and putting the truck into park (P) and turning the ignition to OFF and then restarting the truck resolves the problem, but on the highway this is EXTREMELY DANGEROUS. This has been diagnosed as an intermittent fault derived from a faulty TIPM module and involves multiple RAM 1500, 2500, 3500 owners. Various issues of similar nature reported to dealerships and on forums.

Tipm malfunctions and stalls out vehicle. Will not crank back up and truck fries new Tipm within 5 months and stalls out driving down the road.

I just received this truck, 2012 RAM 1500, from my uncle. Worked great for a couple of months but then started having issues with the engine stalling and losing power while driving. Then I would have issues getting it to start again. The last time I was stranded was at a friend's house and wasn't able to get it to start again. His cousin that works on cars initially determined it was a fuel pump issue because he could get it to start by spraying ethanol in the engine but wouldn't stay started. Then another friend of his inquired about the truck and he told him the issue. He knew of the known issue with the TIPM in this year/model truck which was a fuel pump relay issue. He was able to clean some contacts and got it to start again which allowed me to get it home. I did some research and it is widely known of this issue with the TIPM. There are even bypass cables you can get for a work around. I do consider this a safety issue since at any time it will stall while driving down the road including once on a highway.

Starting around 2020 when I moved to the new house and I constantly had to make a slow left turn underneath this underpass. I noticed that it would die every time. And I started noticing that it was a pattern because I have the blinker on the brake pressed and I turn the wheel the left that’s when it would die every time and I’ve had the gas pedal off I wouldn’t be giving any gas. I looked it up in several people have been having this issue since 2009 on all dodge trucks. Yes has put me in the ditch a few times I almost got hit a couple of times the probability and statistics are going to catch up and I can guarantee you I’m certain that somebody has had an accident because of this.

While operating the vehicle at highway speed the vehicle shut off causing total loss of power. This happened on a road with speeds at 55 mph. It also occured while pulling into my driveway at a low speed, and i have had 3 occurences of the vehicle power "surging" at varied speeds. I had the fuel pump replaced, which did not remedy the problem. After hearing my fuel pump running with the vehicle shut off, i did some further research and found that the TIPM (toatally integrated power module) is the culprit and has been found to cause several other electrical system issues. Loss of power in a low speed scenario, such as turning left from one roadway to an intersecting road can cause the vehicle to be stranded in the middle of the road and place the stranded vehicle in the line of incoming traffic posing a serious risk for injury or death from a "T-Bone" motor vehicle crash.

The fuel tank strap frame T -slot bracket corroded and the fuel tank fell upon the ground while traveling on roadway . there is a recall for this but it doesn't look like my vehicle was included .

Failure of fuel pump relay on above listed 2012 Ram 1500 at 69,999 miles. Current repair requires replacement of entire TIPM module (at a cost of $1,000 to 2,000) as this relay is soldered to the circuit board deep inside the module, making it nearly impossible to cost effectively replace this critical $10.00 part. Of note, the TIPM installed in this vehicle has 10 slots (9 relays installed and 1 open slots) for "replaceable" relays under the cover. Of these replaceable relays at least 2 (blower motor and park lamp) are less critical with one empty slot available. Further a safety recall was issued in December of 2014 (Safety Recall P54/14V530 Fuel Pump Relay) for 2011 models of the Dodge Durango and Jeep Grand Cherokee, but no other models despite that the same or very similar designed TIPM's are used in virtually all Chrysler, Dodge, Ram and Jeep vehicles along with many VW models. If this was a SAFETY ISSUE for select 2011 models, why not the other vehicles using the same or similar TIPM's. Further experience has shown that the Chrysler fix tends to have a high failure rate also. Suggestion: Recall all vehicles with TIPM's which have soldered in Relays, for replacement with a re-designed part which allows for all the relays that can be readily replaced. Further consideration in the design of a new part should include the minimization or elimination of multiple points of failure (is a relay really necessary on a circuit?).

The frame rusted at the attachment point for one of the fuel tank support straps. The fuel tank sagged as it was being supported by only one strap.

The contact owns a 2012 Ram 1500. The contact stated that the fuel tank had detached from the vehicle and was left hanging approximately 6 inches from the ground. The contact had taken the vehicle to the dealer who stated that the fuel tank straps needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 67,000.

While driving the Vehicle at 9:30pm on 7/22/22 the vehicle suddenly accelerated on its own at a very fast rate after I sped up to yield over into another lane coming off the highway. There was luckily no vehicles ahead of me and I was on a straight away or else I would’ve hit someone. I pressed the brakes down but they wouldn’t bring the vehicle to a stop. I placed the transmission in neutral and it slowed down but soon as I put it back in drive it accelerated again. I went through this cycle 4 times then finally I gained control of the vehicle again. I have read online the dealer says it’s user error or floor mats. That was not the case at all. My floor mats are stock and have taps keeping them secure. This situation was very dangerous and if it happens again it could cause serious injury to me or someone else.

My 2012 Dodge Ram 1500 has 67,700 miles and about 30 days ago developed a "tick" coming from the engine. After doing a google research, it appears that 2012 Dodge Ram's with the 5.7 HEMI can develop a "tick" ranging from failed manifold bolts to camshaft failure. My Ram has always been very well cared for and is a low mile vehicle for its age. I found no factory recall on this issue, so I will take it into a local Dodge dealer for diagnosis and repair.

I believe there should be a recall by Dodge on their Dodge 1500 Laramie Longhorn with the 5.7 Hemi engines. It's really the Hemi exhaust manifold that is the problem. I have this ticking noise which hundreds if not thousands of others also have. Copied from the Internet ** (Broken or loose exhaust manifold bolts (this is the most common answer). I've had my truck diagnosed and this is what they say is bad. They will not fix it for no charge. The fix is close to and/or over $1,000. Good reason for the to not admit it's their problem. There should definitely be a Class Action Lawsuit against Dodge. This is a very common problem and because hundreds if not thousands of engines have this issue it should be a RECALL issue. I would hope your organization could do something about this. I don't think it's fair that their mechanical problems they caused are my costly problems. I'll pay for wear and tear and things I've done to my car but they should stand up and take responsibility of their manufactures defects. Please help. [XXX] P.s. Not sure of the date this started but it had about 40,000 miles. Now has 69,000. I've been driving it this way for sometime now but would like to get it fixed. Dodge is denying my request to have them pay for it. We hope you have some clout to get this issue resolved not only for me but for hundreds of others. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2012 Ram 1500. The contact stated while driving approximately 15 MPH, there was a fuel strap failure. There were no warning lights. The vehicle was taken to the local dealer who confirmed the failure with the fuel strap. The vehicle was repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number 18V160000 (Fuel System, Gasoline). The approximate failure mileage was 135,000.

Engine ticking heavily and diminishes some when engine warms up. Vehicle dies randomly while driving and loss of power steering and assisted breaking. Almost had an accident while turning a corner and vehicle died.

The contact owns a 2012 Ram 1500. The contact stated that upon opening the rear driver's side sliding door, the rear driver's side window shattered. The vehicle was taken to a glass repair facility where the 3-piece rear driver's side window glass was replaced. The contact stated that the vehicle was repaired; however, the failure reoccurred while his wife was opening rear the driver's side door. The contact stated that some of the broken pieces was on her face. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was unknown.

2012 DODGE RAM. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. THE CONSUMER STATED THE VEHICLE SHUT OFF WHILE BEING DRIVEN. THE CONSUMER STATED WHEN THE FAILURE OCCURS THE STEERING WHEEL LOCKS.

The contact owns a 2012 Dodge Ram 1500. The side step detached from the vehicle's driver side of the vehicle while the contact was attempting to enter the vehicle. The bolts that were attaching the component had completely rusted through causing the failure. As a result, the contact sustained a injured knee during their fall. Medical attention was not sought. The dealer was contacted but had not inspected the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and informed that there was no recall. There was a warranty related repair however the vehicle was not included. The approximate failure mileage was 148,000.

Middle gas tank strap frame bracket has corroded. The tank strap has fallen off and the gas tank almost detached.

The contact owns a 2012 Dodge Ram 1500. The contact stated that the radio was hacked. The safety features became inoperable and the vehicle attempted to crash. The contact called the local dealer but the vehicle was not diagnosed or repaired. The contact stated the failure was related to NHTSA Campaign Number: 15V461000 (Equipment). The manufacturer was notified, but no further assistance was provided. The approximate failure mileage was 125,000.

The contact owns a 2012 Dodge Ram 5500. The contact stated that the service light was illuminated. The contact stated that the vehicle was inoperable. The vehicle was taken to the local dealer but parts were not ordered. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to another local dealer for assistance. The approximate failure mileage was 44,000.

The contact owns a 2012 RAM 1500. The contact stated while the vehicle was stationed at the traffic light and when depressing on the accelerator pedal and the vehicle seized. The contact stated no warning light was illuminated. The contact was able to restart the ignition and drove to his residence, but was able to start the ignition. The vehicle was not drivable. The contact towed the vehicle to a local dealer, where it was diagnosed with needing the fuel pump relay was needing to be removed. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V160000 (Fuel System, Gasoline), however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 116,000.

Wireless ignition module fails to maintain connection with key fob inserted. Looses power on highway if I hit a bump. Dealer will not address the issue. Door locks are also now not functioning. Am assuming it is the trash TIPM in this 2012 ram 1500 chrysler installed. This whole 2012 ram should be recalled totally unsafe vehicle to have my 5 year old and 5 month old in.

What happened to my 2012 1500 Dodge Ram Pickup truck is exactly what is stated in the U04 Ram recall. This makes me wonder why am I not also listed in the recall. While driving to work I felt a big jolt in the car. I thought initially it was something with the brakes but everything seem ok with the brakes and since I was only a block away from work I kept going and park in my assigned parking lot. Only after work did I notice what had happened. The gas tank towards the front of the car had dropped as the strap had detached. I used the tire jack to push the tank back up and then tied rope around the gas tank to hold it in place. I then drove the truck to the local Tire Discounters who said they could fix the Gas tank strap. Only the next day did I learn that they couldn't do that type of repair because where the strap needed to attach on the frame was completely corroded. Thank God the other strap had not come undone too.

I took my vehicle in for an oil drip and the mechanic tells me that I have a strap broken and hanging down on my fuel tank. He tells me there is a recall for it. I called the dealership and they tell me there is a recall for some trucks with the same year, make and model but mine is not one of them. I don't understand why my truck is not covered under this recall when it happened to my truck. Safety recall U04/NHTSA18V-160 Frame bracket.

I went out to start my truck and there was only one headlight working. After replacing the left driver's side bulb multiple times and it still didn't work I had a mechanic look at it and he figured out it was a wiring connector problem.

Both airbag harnesses under the driver and passenger seat had to be replaced because of faulty connections that kept throwing air bag codes on dash display

Exiting the freeway the truck vibrated and shut off going 55 mph, no brakes, no power steering going into a curve. I managed to keep it on the road and had it Towed to nearest dealership where they were able to diagnose the problem immediately and I was told that this is a know problem with this truck. $6000 to fix, contacted Ram customer service and a very rude woman put the dealership on the line and berated them for claiming there was an issue while explaining that it is completely normal for an engine to blow at 130k miles regardless of maintenance and as it’s out of warranty they were not responsible. “Normal” for an engine to blow, absolutely ridiculous and someone could have died. There are now 533 cases of this happening and Ram refuses to address it.

Air BAG LIGHT IS ON

Camshaft lobe warn down from, from faulty rocker arm roller (needle bearing) (there is no to very little compression in cylinder 5), apparently engine is lubricated "by splash oil design" and people smarter then me have diagnosed that it is a design flaw.(having to do with the well and the height of the bores that accept the rocker arms) The engine only had 118,000 miles when the engine light came on, resulted in a severe knocking sound and misfiring. I expected a well taken care of motor with regular oil changes would last 200,000 miles. My choices are to rebuild the motor and or replace, both are costly. Thanks for taking the time to read my complaint. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TIPM is sending intermittent signal to fuel pump relay cause truck to stall at highway speeds.

I was driving on the expressway and my gas tank dropped in the front, causing the front strap to make contact with my drive shaft. The front of the fuel tank was hanging one inch from the cement. I had to pull to the side of the roadway and have someone bring me a "tie down ratchet strap" to hold the tank in place so I could get off the side of the expressway. Upon inspection the strap "T" end appeared to be fine, but the part on the frame that holds it was totally rotted. My Truck had 58,982 miles on it when this happened. My truck is in excellent condition otherwise. * I had received a recall notice years ago for this issue and then I got a letter a few weeks later from FCA telling me to disregard the notice that my vehicle was not affected. I guess they were wrong!

THE TRUCK STALLED OUT ON THE HIGHWAY DOING 60 MILES PER HOUR ALMOST GOT IN SERIOUS ACCIDENT. NO STEERING OR BRAKES. (COULD BE DEADLY). THIS ALSO HAPPENED AGAIN MAKING A RIGHT TURN THRU AN INTERSECTION. WAS TOLD IT IS SOMETHING TO DO WITH FUSE BOX TIPM TOTAL INTEGRATED POWER MODULE

Shifter slips out of gear unexpectedly at times (eg. drive to neutral) while driving and without cause. Unable to place it in park at times as well. We attempted to fix the problem, but a necessary part (gearshift cable) is discontinued and cannot be located anywhere. The truck is not safe and cannot pass a safety inspection and cannot be repaired.