1992 Dodge Daytona

Defect. THE WELDING ATTACHMENTS OF THE FRONT FRAME RAILS TO THE FLOOR PAN SHEET METAL MAY NOT BE PROPERLY WELDED.

Risk. THE IMPROPERLY WELDED AREAS COULD CAUSE BODY PANELFLEXING AND SHEET METAL CRACKING, POSSIBLY RESULTING IN STRUCTURAL DAMAGE,COMPROMISING THE VEHICLE IMPACT PROTECTION CAPABILITY. THIS COULD INCREASE THELIKELIHOOD OF INJURY TO OCCUPANTS IF THE VEHICLE IS INVOLVED IN A COLLISIONACCIDENT.

Remedy. SECURE THE FLOOR PAN TO THE FRONT FRAME RAILS BY BOLTING BOTH FRAME RAILS TO THE FLOOR PAN.

Defect. THE ZINC PLATING OPERATION PERFORMED ON THE UPPER STEERING COLUMN SHAFT COUPLING BOLT CAUSED HYDROGEN EMBRITTLEMENT AND BREAKAGE OF THE BOLT.

Risk. FRACTURES OF THE UPPER STEERING COLUMN SHAFT COUPLINGBOLT RESULT IN A LACK OF COUPLING LOAD ON THE SHAFT AND LOSS OF STEERINGCONTROL.

Remedy. REPLACE THE ZINC PLATED BOLT WITH A PHOSPHATE PLATED BOLT.

I HAD JUST PULLED THE FRONT DRIVERS SEAT BACK FORWARD TO PERMIT MY 10 YEAR OLD SON TO GET IN THE BACK SEAT. I PUT THE SEAT BACK IN THE REAR POSITION, GOT IN AND SAT DOWN. THE SEAT COLLAPSED BACKWARD ONTO MY SON. HE WAS NOT INJURED BUT BADLY FRIGHTENED.. I HAVE A BAD LOWER BACK PROBLEM AND HAD MY REARWARD FALL NOT BEEN CUSHIONED BY MY SON"S BODY I PROBABLY WOULD HAVE HAD A BACK INJURY. I TRAVEL AN INTERSTATE TO GO HOME FROM MY FATHER'S HOUSE IN ALBUQUERQUE AND I SHUDDER TO THINK WHAT WOULD HAVE HAPPENED 5 MINUTES LATER. THE OUTBOARD SEAT BOLT HAD SHEARED OFF. THE CAR , OF COURSE, WAS UNDRIVEABLE IN THAT CONDITION. MY FATHER WAS ABLE TO FIND A SUBSTITUTE BOLT, INSTALLED IT AND I WAS ABLE TO GO HOME. I INTEND TO GO TO THE DEALER AND GET AN ORIGINAL BOLT. THE SCREW HOLDING THE SEAT TRIM/SEAT RELEASE COVER ALSO SHEARED AND I CANNOT PUT IT BACK TOGETHER SO I CAN PROPERLY USE MY SEAT RELEASE HANDLE. I HAVE THE SHEARED BOLT PIECES. *NM

I WAS ACCELERATING FROM A TRAFFIC LIGHT AND THE BACK OF THE DRIVERS SEAT FELL INTO THE BACK SEAT. LUCKILY I HAD SOME DIET PEPSI ON THE FLOOR AND ON THE BACK SEAT BECAUSE IT WAS THE ONLY THING THAT STOPPED ME FROM FALLING ALL THE WAY BACK AND POSSIBLY LOSING CONTROL OF THE VEHICLE. ONE OF THE TWO BOLTS HOLDING THE SEAT BACK TO THE RECLINER PIECE FAILED. I ORDERED A REPLACEMENT BOLT FROM DODGE. I HAVE THE OLD BOLT. *NM

CONSUMER EXPERIENCED PROBLEMS WITH THE 1992 DODGE DAYTONA SHAKING WHILE DRIVING ON THE HIGHWAY. CONSUMER ALSO IS REQUESTING A REIMBURSEMENT FOR REPAIRS DONE TO THE FRAME RAIL TO THE FLOOR PAN WELDS.*MR *NM

IT WAS LIMITED PRODUCTION ENGINE THAT HAS A PROBLEM OF EATING TIMING BELTS, CRACKING CYLINDER HEADS, AND A/C FAILURE. WHEN THE TIMING BELT BREAKS, THE ENGINE IMMEDIATELY DIES AND THERE IS A LOSS OF ALL POWER ASSIST INCLUDING STEERING. ANOTHER ONE OF THESE VEHICLES I OWN WENT THROUGH 5 CYLINDER HEADS AND 7 TIMING BELTS IN 83K MILES, BECAUSE OF THE SMALL NUMBER OF THIS SPECIAL ENGINE PRODUCED, THERE PROBABLY HAVEN'T BEEN MANY COMPLAINTS, BUT IF THE SERVICE RECORDS WERE PULLED FROM DAIMLER CHRYSLER FOR ALL THE CARS WITH ENGINE VIN CODE "A" THE 2.2L 16V LOTUS DOHC TURBO III, 90% WILL HAVE HAD AT LEST ONE OF THESE PROBLEMS REPAIRED UNDER WARRANTY AND PROBABLY MANY MORE THAT WHICH CONTINUED TO OCCUR AFTER THE FACTORY WARRANTY EXPIRED. AN OWNERS CLUB ON THE INTERNET AT HTTP://TOPICA.COM/LIST/RT_MAILING_LIST HAS OVER 300 PEOPLE, SOME WITH MULTIPLE CARS LIKE MYSELF AND WOULD BE A GOOD SOURCE TO HELP DOCUMENT THESE PROBLEMS. *JB **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****762546

IN SEPTEMBER 2001,THE BOLT BETWEEN THE TRANSMISSION AND THE MOTOR WAS FOUND TO BE MISSING WHICH CAUSED THE ENGINE TO JUMP, AND TEARING THE TRANSMISSION LINE . TRANSMISSION FLUID SPRAYED ALL OVER ENGINE. POSSIBLE CAUSE OF ENGINE FIRE? FIRE STARTED NEAR BATTERY ON WIRES POSSIBLY SHORTING THEM OUT. WHOLE CAR WAS LOST, DESTROYED BY FIRE. *AK

PIN ON THE HINGES OF THE DOORS ARE TOO HEAVY & ARE WEIGHING THE VEHICLE DOWN. DOORS ARE PUTTING BIG DENT IN THE FENDER. THEY'VE BEEN REPAIRED TWICE. DEALER IS TRYING TO IGNORE THE PROBLEM.*AK

WHILE VEHICLE WAS BEING DRIVEN THE HOOD FLEW UP IN THE AIR, CAUSING THE HINGES TO SNAP. WHEN THE HINGES SNAPPED, THE HOOD HIT AND CRACKED THE WINDSHIELD. WHEN THE DRIVER ATTEMPTED TO BRING THE HOOD BACK DOWN, THE HOOD INJURED THE DRIVER IN THE PROCESS. THE HOOD HINGES AND WINDSHIELD HAVE BEEN REPLACED. *AK

DURING COLD WEATHER REAR LIFTGATE HYDRAULICS WILL NOT SUPPORT GATE. *AK

ANTI-LOCK BRAKES LOCKED UP, RESULTING IN BRAKE FAILURE. *AK

PAINT STARTED TO BLISTER AND PEEL OFF THE BODY OF VEHICLE. *AK

HATCH SUPPORT FAILED.

DRIVING VEHICLE AT 45MPH, LOST CONTROL OF VEHICLE, IMPACT 12:00 POSITION DRIVER SIDE AIRBAG DID NOT DEPLOY. *AK

WHEN REAR SEAT WAS OCCUPIED, TIRES WOULD RUB FENDERS. TT

EMERGENCY PARKING BRAKE WOULD RELEASE ON IT'S OWN. TT

WHILE DRIVING AT 65 MPH WHEN HOOD FLEW UP AND SMASHED INTO THE WINDSHIELD AND CAUSED AN ACCIDENT. TT

THE PASSENGER SIDE DOOR TRIM GETS HOT, CAN'T OPEN THE DOOR . *AK

TIMING BELT BROKE ON THREE DIFFERENT OCCASION. TT