1997 Dodge Dakota

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEEL TO NOT BE SEATED FULLY AGAINST THE HUB FLANGE FACE DURING MOUNTING.

Risk. IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.

Remedy. SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.

Defect. CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy. AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.

Risk. A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.

Remedy. K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.

Defect. CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Risk. LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy. AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.

Risk. WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.

Remedy. DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE REAR AXLE VENT HOSE AND THE BRAKE HOSE.

Risk. A PUNCTURE IN THE REAR BRAKE HOSE WILL RESULT IN A LOSS OF BRAKING FORCE AT THE REAR WHEELS.

Remedy. DEALERS WILL INSPECT THE REAR BRAKE HOSE FOR EVIDENCE OF WEAR. WORN BRAKE HOSES WILL BE REPLACED. THE REAR VENT HOSE WILL BE SHORTENED BY 3 INCHES AND A CLIP WILL BE INSTALLED TO ASSURE CLEARANCE BETWEEN THE AXLE VENT LINE AND BRAKE HOSE IS MAINTAINED.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS BUILT WITH 2.5L ENGINES. SOME VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE POWER STEERING HOSE.

Risk. A PUNCTURE OF THE LEFT FRONT BRAKE TUBE CAN RESULT IN A LOSS OF BRAKING FORCE AT THE FRONT WHEELS, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL INSPECT THE BRAKE TUBE AND POWER STEERING HOSE FOR WEAR. IF WEAR IS EVIDENT, THE BRAKE TUBE AND/OR POWER STEERING HOSE WILL BE REPLACED. A POWER STEERING STANDOFF BRACKET WILL BE INSTALLED ON ALL VEHICLES TO ENSURE THAT ADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND POWER STEERING HOSE IS MAINTAINED.

Defect. VEHICLE DESCRIPTION: PICKUP TRUCKS WITH A 131 INCH WHEELBASE. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH INADEQUATE CLEARANCE BETWEEN THE FUEL LINE AND THE CAB UNDERBODY.

Risk. THIS CONTACT CAN RESULT IN WEAR, AND AFTER EXTENDED CONTACT, COULD CAUSE A PERFORATION IN THE FUEL LINE, RESULTING IN LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy. DEALERS WILL INSPECT THE VEHICLES FOR PROPER CLEARANCE. FUEL LINES THAT EXHIBIT INADEQUATE CLEARANCE WILL BE REPLACED WITH A REDESIGNED FUEL LINE THAT WILL ASSURE PROPER CLEARANCE.

Defect. THE ELECTRICAL CIRCUIT DESIGN ALLOWS THE POTENTIAL FOR AN INADVERTENT AIR BAG DEPLOYMENT UPON VEHICLE IGNITION SHUT DOWN.

Risk. UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.

Remedy. DEALERS WILL REPLACE THE AIR BAG ELECTRONIC CONTROL MODULE WITH A NEWLY DESIGNED MODULE.

Daimlerchrysler corporation (dcc) is recalling the target population of approximately 600,000 my 2000 through 2003 durango and dakota vehicles with four-wheel drive to replace the front suspension upper ball joints with redesigned parts that do not have the joint integrity concerns and have substantially improved joint retention capacity (NHTSA recall no. 04v-596).though dcc does not admit to a safety-defect in the subject components, odi believes that the facts in this investigation show otherwise.because of the low rates of separation incidents in the remaining subject vehicles, a …

ILLUMINATED MIL AS THE RESULT OF A DIAGNOSTIC TROUBLE CODE (DTC) P0420 - CATALYST EFFICIENCY, OR MAY HAVE FAILED A CALIFORNIA SMOG OR STATE I/M TEST BUT WITHOUT AN ILLUMINATED MIL, OR A RATTLING SOUND FROM THE UNDERSIDE OF THE VEHICLE. CATALYTIC CONVERTER EXTENDED WARRANTY TO REPLACE THE CATALYTIC CONVERTER. *TT

SUBJECT REGARDING UPPER CONTROL ARM BUSHING SERVICE. *TT

SOME CUSTOMERS MAY COMMENT ABOUT A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT

THIS BULLETIN MENTIONS THAT THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT

EXPERIENCING A SQUEAK NOISE COMING FROM REAR LEAF SPRING. *TT

EXPERIENCING SQUEAKING OR CREAKING FROM FRONT WHEEL AREA AT LOW SPEEDS. *TT

SUBJECT ON THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT

BRAKE LINE CRODDED, LOSS OF BRAKES IN MOTION IN DRIVEWAY

HEADLIGHTS KEEP FAILING. HAVE CHANGED HEADLIGHT SWITCH SEVERAL TIMES, BUT FAILS AGAIN. TRANSMISSION WON'T SHIFT INTO OVERDRIVE. CRUISE CONTROL IS DIFFICULT TO ACTIVATE. SOMETIMES TRANSMISSION WON'T SHIFT FROM 2ND TO 3RD GEAR

TL* THE CONTACT OWNED A 1997 DODGE DAKOTA. WHILE DRIVING 50 MPH, THE VEHICLE BEGAN TO OVERHEAT WITHOUT WARNING. THE CONTACT PULLED OVER AND OPENED THE HOOD OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.

TOOK VEHICLE TO DODGE DEALER (BRYDEN MOTORS BELOIT) FOR INSPECTION OF FUEL LINE AND BRAKES (FUEL LINE IS NOT RIGHT AND REAR BRAKE LINE IS LEAKING AFFECTING BRAKING) FUEL LINE PART WAS ORDERED NUT BRAKES WERE NOT INSPECTED AND IGNORED. I AM SUPPOSED TO RETURN WEDNESDAY AFTERNOON TO HAVE ORDERED FUEL LINE PART(S) INSTALLED.

3 DAYS AFTER WE BOUGHT THIS VEHICLE THE FUEL SYSTEM WENT DOWN. REPLACED THE FUEL PUMP AND STILL WANTS TO STALL AND ACT LIKE ITS CLOGGED IN THE FUEL LINES. ITS BEEN FLUSHED. WHEN DRIVING IT BOGS DOWN AND CHUGS. IT WANTS TO DIE AND SHUT OFF WHILE YOUR DRIVING THE TRUCK. THE BRAKES ONLY WORK HALF THE TIME. MOST OF THE TIME I CAN'T EVEN STOP UNTIL I'M HALFWAY THROUGH THE INTERSECTION. REPLACED ALL THE SENSORS AND STILL DOESN'T WANT TO START AND STAY RUNNING. FUEL PUMP KICKS ON, BUT HAS TO RUN EXTRA HARD TO TRY AND KEEP THE ENGINE RUNNING. *TR

TL* THE CONTACT OWNS A 1997 DODGE DAKOTA. THE CONTACT STATED THAT THERE WAS A FUEL ODOR EMITTING OUTSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V199000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 121,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 1997 DODGE DAKOTA. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO NHTSA RECALL NUMBER 00V199000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THEY HAD NO KNOWLEDGE OF RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 1997 DODGE DAKOTA. THE CONTACT STATED THAT THE DRIVER FRONT SEAT WAS UNSTABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 125,000 AND THE CURRENT MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.

LOCKED VEHICLE IN FOUR WHEEL DRIVE HIGH, STARTED GOING THROUGH FLAT PASTURE, EITHER BRAKES LOCKED UP OR FRONT PUMKIN TURNED UP AND LOCKED FRONT WHEELS UP, LOST CONTROL AND ROLLED ONTO DRIVER SIDE. *TR

BRAKE LINES RUSTED THROUGH. BURST WHILE DRIVING ON EXPRESSWAY. REPLACED ALL BRAKE LINES. *JS

REPLACED RUSTED RADIATOR. *JS

REPLACE RUSTED RADIATOR. *JS

PREMATURE WEAR AND FAILURE OF UPPER AND LOWER BALL JOINTS. TRUCK WAS MAKING POPPING NOISES WHEN YOU TURNED THE WHEEL OR WENT OVER BUMPS. TOOK TO LOCAL MECHANIC; MECHANIC STATED THAT THE BALL JOINTS WERE SCARY BAD. MECHANIC ALSO STATED THAT IF I HAD NOT BROUGHT THE VEHICLE IN THE FRONT WHEELS COULD HAVE BROKEN OFF CAUSING THE VEHICLE TO WRECK. *JS

CAR LOST POWER AND LOCKED UP WHILE DRIVING. CHECK ENGINE LIGHT CAME ON. SCANNER SHOWED CODE P0740; TORQUE CONVERTER PROBLEM. HAD TO OVERHAUL TRANSMISSION AND REPLACE THE TORQUE CONVERTER. *JS

TL* THE CONTACT OWNS A 1997 DODGE DAKOTA. THE CONTACT WAS DRIVING 30 MPH WHEN THE HEATER BLOWER MALFUNCTIONED. THE CONTACT WAS UNABLE TO HEAT THE VEHICLE INTERIOR OR UTILIZE THE DEFROSTER. THE VEHICLE WAS TAKEN IN FOR REPAIRS WHERE THE HEATER BLOWER, MOTOR AND BLOWER FAN WERE REPLACED. THE TECHNICIAN ALSO ADDED MORE ANTI-FREEZE TO THE VEHICLE BUT NONE OF THE REPAIRS REMEDIED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 96,400. UPDATED 3/1/11 *CN UPDATED 07/01/11

TL*THE CONTACT OWNS A 1997 DODGE DAKOTA. UPON STARTING THE VEHICLE, THE CONTACT NOTICED A STRONG FUEL ODOR. THE CONTACT SHUT THE VEHICLE OFF AND DISCOVERED FUEL LEAKING UNDER THE VEHICLE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 120,000. UPDATED 02/03/11*LJ UPDATED 03/17/11

DUE TO POOR CHOICE OF MATERIALS (I ASSUME) THE FRONT HUB AND SPINDLE ASSEMBLY WEARS. LEAVING FRONT BRAKE SLIDER PINS UNATTACHED TO CALIPER MOUNTING PLATE. WHEN THIS HAPPENS, THE FRONT CALIPER WOBBLES IN IT'S PLACE, POSSIBLY EJECTING THE SLIDEPINS BECAUSE THEY "WOBBLE" IN THE KNUCKLE HOLES DESIGNED TO RETAIN THEM. THIS CAUSES EXCESS WEAR ON THE FRONT HUB ASSEMBLY, INCREASED WEAR IN BRAKES, AND STRESS ON THE HUB BEARINGS. HAVING READ THE "ALLDATA" DATA BASE, THERE IS A REDESIGNED KNUCKLE WITH IMPROVED SLIDE PIN SUPPORTS. THERE ALSO IS A REPAIR KIT INVOLVING THE USAGE OF "HELI-COIL" INSERTS TO SECURE BRAKE PAD CARRIER TO SPINDLE ASSEMBLY. (SLIDE PINS) I FEEL TOTALLY UNSAFE WITH THIS ARRANGEMENT. I PREFER TO HAVE THE RE-DESIGNED SPINDLE ASSEMBLIES INSTALLED FOR FREE BY DEALER WITH UP-DATED PART NUMBERS. THE DEALER WANTS $1000 PER SIDE FOR THE REDESIGNED UNITS. I THINK THIS IS ABSURD. THIS IS A SAFETY HAZARD AND COULD CAUSE LOSS OF LIFE DUE TO LOSS OF CONTROL. THE ONLY THING HOLDING THE BRAKE ASSEMBLIES IN PLACE IS THE WHEEL, ITSELF!! *TR

TL*THE CONTACT OWNS A 1997 DODGE DAKOTA. THE VEHICLE HAS CONTINENTAL TIRES. WHILE DRIVING 65 MPH, THE TREAD FROM ONE OF THE TIRES BEGAN TO STRIKE THE DOOR AND FRONT FENDER OF THE VEHICLE BEFORE COMPLETELY SEPARATING FROM THE TIRE. THE REMAINDER OF THE TIRES REMAINED INFLATED. THE CONTACT DID NOT DRIVE OR ANY POTHOLES OR OTHER ROAD HAZARDS TO CAUSE THE FAILURE. HE TOOK THE TIRE BACK TO THE STORE FROM WHERE IT WAS PURCHASED AND WAS INFORMED THAT IT WAS DEFECTIVE. THE TIRE WAS REPLACED FOR FREE. THE TIRE SIZE, TIRE LINE, AND REMAINING TREAD DEPTH WERE UNKNOWN. THE FAILURE MILEAGE WAS 90,408. UPDATED 03/17/09. *LJ THE CONSUMER BELIEVED THE TIRE WAS DEFECTIVE. UPDATED 03/17/09. *JB

THE BALL JOINTS ON MY 97 DODGE DAKOTA ARE WORN OUT. APPARENTLY THIS IS A VERY COMMON PROBLEM AND SUPPOSEDLY THERE IS A RECALL IN EFFECT FOR NEWER DAKOTAS AS THOUGH THE PROBLEM DIDN'T START UNTIL AFTER 1997. THIS IS A FAULTY PART FROM THE MANUFACTURING PROCESS AND ITS REPAIR (AMONGST THE MANY OTHER MANUFACTURING FAULT REPAIRS ON THIS VEHICLE) IS RUINING ME FINANCIALLY IN THIS ECONOMY. I SHOULD NOT BE HELD FINANCIALLY RESPONSIBLE FOR A CAR MAKERS INEPT MANUFACTURING. *TR

THE FRONT BRAKE CALIPER BOLTS TO THE STEERING KNUCKLE ON A 1997 DODGE DAKOTA, 4WD. DUE TO THE NATURE OF THE DESIGN, THE THREADS THAT HOLD THE BRAKE CALIPER MOUNTING STUDS CAN STRIP OUT, THEREBY LEAVING THE CALIPER TO FLOAT ON THE KNUCKLE. UNDER PROLONGED USE, THESE STUDS CAN BACK OUT, LETTING THE CALIPER FALL OFF, WHICH COULD LEAD TO A CRASH. ON MY PARTICULAR VEHICLE, THIS HAS HAPPENED FOR THE THIRD TIME NOW, ONCE ON THE DRIVER'S SIDE AND TWICE ON THE PASSENGER SIDE. THE THREADS STRIP OUT, AND THE MOUNTING BOSS SECTION IS SO SMALL THAT A LARGER THREAD CANNOT BE RETAPPED WITHOUT DANGER OF BREAKING THE HOLE OUT. AUTO PARTS SUPPLIERS SELL SLIGHTLY OVERSIZE, SELF TAPPING STUDS, BUT THESE DO NOT LAST LONG. THE STEERING KNUCKLE IS A VERY PRICEY PART (ON THE ORDER OF $600 JUST FOR THE PART) AND CONTINUING REPLACEMENT IS COST PROHIBITIVE. MY VEHICLE IS APPARENTLY NOT THE ONLY ONE WITH THIS PROBLEM, AS A SEARCH OF SALVAGE YARDS REVEALED NUMEROUS STRIPPED OUT THREADS ON VEHICLES WHERE THE STEERING KNUCKLE WAS ACTUALLY AVAILABLE. *TR

MY BALL JOINTS AND TIE RODS WERE GOING BAD AT 54,000 MILES. DODGE WOULD NOT DO ANYTHING ABOUT THE PROBLEM. ALSO, MY TRANSMISSION STARTED TO GO BAD AT 74,000 MILES. 2ND GEAR WENT OUT, THEN IT WENT COMPLETELY OUT AT 91,000 MILES. OBVIOUSLY DODGE WASN'T GOING TO DO ANYTHING ABOUT IT. I WONT BUY ANOTHER DODGE AGAIN. *TR

TRANSMISSION FAILURE AT 50,000 MILES. TRANSMISSION BEGAN TO BOG DOWN WHILE DRIVING ABOUT 40 MPH. AFTER ABOUT 5 MINUTES IT WOULD ONLY GO ABOUT 5 MPH WHILE REVING ABOUT 3500 RPM. PAID FOR TOW TO DODGE DEALER IN HAMPTON VA FOR ANALYSIS AND REPAIR. TOW OPERATOR REMARKED ALMOST ALL DODGE DAKOTAS TOWED FOR TRANNY WORK ENDED UP COSTING $2300-$2900 FOR A REPLACEMENT. I WAS LUCKY AND ONLY HAD TO REPLACE ALL PRESSURE REGULATING VALVES FOR ABOUT $670 (FUNNY HOW THEY ALL WENT BAD AT THE SAME TIME BUT I WOULD NOT ARGUE THE POINT SINCE THE PARTS WERE CHEAP COMPARED TO DOING IT OVER IN A FEW MONTHS). DEALER INDICATED THIS WAS A YEARS OLD PROBLEM WHICH WAS COMMON TO REPLACE THESE TRANSMISSIONS AND THAT MY $600 REPAIR WAS NOT GUARANTEED TO PREVENT TOTAL FAILURE. DODGE HAS NOT AGREED TO ANY RECALL TO FIX BUT SHOULD DO THIS. THEREFORE, I WILL NEVER OWN ANOTHER DODGE OR CHRYSLER OF ANY SORT. UPPER AND LOWER BALL JOINTS ALSO FAILED AT UNDER 50,000 MILES AND NO REPAIR RECALL ON THIS LONG STANDING PROBLEM AS WELL. SUBJECT ON ANOTHER COMPLAINT. *TR

BALL JOINT FAILURES: TRUCK FAILED STATE INSPECTION DUE TO DEFECTIVE UPPER AND LOWER BALL JOINTS OR BALL JOINT AND LOWER CONTROL ARM. ANOTHER BALL JOINT HAD BEEN REPLACED THE PREVIOUS YEAR. ALL DEFECTS OCCURRED AT ABOUT 50,000 MILES. THIS IS COMMON PROBLEM WITH DODGE DAKOTA AND CHRYSLER WILL NOT PAY FOR REPAIRS. PROBLEM IS WELL DOCUMENTED ON DOZENS OF INTERNET SITES, BLOGS, ETC AND ALL MECHANICS AND STATE INSPECTORS ALL NOD KNOWINGLY ABOUT THE DODGE PICKUP. THIS IS SAFETY ISSUE AND FAILURE OF BALL JOINTS IS NOT A PROBLEM IN ALMOST ANY CAR EXCEPT CHRYSLER PRODUCTS. HOW DO THEY GET AWAY WITH THIS SAFETY ISSUE WHICH CAN CAUSE LOSS OF CONTROL AND CRASHES AND AT UNDER 50,000 MILES. IT IS TIME NHTSA FORCES DODGE TO RECALL AND REIMBURSE ALL COSTS TO THOSE ALREADY HAVING PAID FOR SUCH REPAIRS. THIS SHOULD BE APPLICABLE FOR ANY YEAR VEHICLE UP TO AT LEAST 100,000. I HAVE OWNED OVER A DOZEN VEHICLES AND MOST DRIVEN OVER 100,000 AND ONE AT 145,000 AND ONE 200,000 AND HAVE NEVER REPLACE BUT ONE BALL JOINT ON A 1970 CUTLASS. ONLY ONE HIGH MILEAGE VEHICLE WITH CV JOINTS BUT MAYBE NO BALL JOINTS HAD TO HAVE A CV JOINT REPLACED. THIS DOES NOT SPEAK WELL OF CHRYSLER/DODGE. *TR

BALL JOINT FAILURE.........HAD TO REPLACE UPPER AND LOWER BALL JOINTS IN MARCH 2005, AND NOW IN DECEMBER 2007, I AM HAVING TO REPLACE UPPER BALL JOINTS AGAIN. BALL JOINTS IN 1997 DODGE DAKOTA ARE A DEFECTIVE DESIGN, AND WEAR OUT TOO QUICKLY. *TR

DURING 200, SQUEAK IN FRONT END BECAME LOUDER AND LOUDER. HAD TO HAVE UPPER AND LOWER BALL JOINTS REPLACED ON THE LEFT AND RIGHT. TRUCK HAD 95,000 MILES. 2 YEARS LATE SAME PROBLEM WITH SQUEAK IN FRONT END BECAME LOUDER AND LOUDER. NEEDED TO HAVE THE BALL JOINTS REPLACED AGAIN. ONLY ABOUT 10,000 MILES ON TRUCK THIS TIME. *AK

TL*THE CONTACT OWNS A 1997 DODGE DAKOTA. THE CONTACT STATED THAT THE VEHICLE SHIFTS OUT OF GEAR WHEN THE 4 WHEEL DRIVE FEATURE IS ACTIVATED. THE FAILURE BEGAN SINCE THE TIME THE VEHICLE WAS PURCHASED. HE CALLED THE DEALER, BUT BECAME ILL AND WAS UNABLE TO RETURN THE VEHICLE FOR REPAIR BEFORE THE THIRTY DAY WARRANTY EXPIRED. THE VEHICLE RECEIVED A NEW STATE INSPECTION IN SPITE OF THE BRAKE AND BALL JOINT ISSUES. THE CONTACT STATED THAT THE 4 WHEEL DRIVE FEATURE DISENGAGES WHILE DRIVING AND THE UPPER AND LOWER BALL JOINTS WERE COMPLETELY WORN, MAKING THE VEHICLE DIFFICULT TO STEER. THE WHEEL HUB WAS REPLACED AND THERE WAS NO BRAKE LINING ON THE REAR AXLE. THE BRAKE CABLES WERE REPLACED AS WELL. THE VIN, ENGINE SIZE, AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE IS 116,000 AND FAILURE MILEAGE WAS 108,000.

TL* - THE CONTACT OWNS A 1997 DODGE DAKOTA. WHILE LEAVING HIS DRIVEWAY AT 5 MPH IN AN ATTEMPT TO ENGAGE THE BRAKES, THE PEDAL WENT TO THE FLOOR AND THE VEHICLE DID NOT STOP. THE CONTACT USED THE EMERGENCY BRAKE TO SLOW THE VEHICLE DOWN. THE CONTACT OBSERVED BRAKE FLUID ON THE ENGINE AND UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE SHOP MECHANIC STATED THE DRIVER SIDE BRAKE LINE RUSTED WHICH CAUSED THE FAILURE. THE REPAIR ORDER STATED THAT ALL THE BRAKE LINES WERE RUSTY AND ANY ONE OF THEM COULD HAVE FAILED. *AK UPDATED 2/13/2007 - *NM

TL* - THE CONTACT' OWNS 1997 DODGE DAKOTA. THE CONTACT COMPLAINED THAT BRAKE WARNING LIGHT TURNED ON. THE CONTACT TOOK THE VEHICLE TO TWO DIFFERENT BRAKE REPAIR FACILITIES, AND BOTH STATED THAT THE BRAKE WARNING LIGHT STAYED ON DUE TO THE SENSOR, WHICH MEANT THAT THE ABS WERE TURNED OFF. THE SENSOR WAS LOCATED ON THE MASTER CYLINDER. THE CONTACT STATED THAT THE REPAIR FACILITIES DIDN'T KNOW WHY THE SENSOR WAS FAILING. WHEN THEY INSPECTED THE BRAKES THEY COULDN'T FIND ANYTHING WRONG WITH THE VEHICLE. ALSO, THE CONTACT STATED THAT WHILE APPLYING THE BRAKES IN WET CONDITIONS THE VEHICLE HAD A DIFFICULTY STOPPING, CAUSING IT TO SLIDE.*AK

CATALYTIC CONVERTER INSPECTION. THERE IS A RECALL OUT FOR 1996 JEEP CHEROKEE WITH A 4.0 LITER ENGINE AND 1997 DODGE DAKOTA WITH A 2.5 LITER ENGINE. I HAVE A 1997 DODGE DAKOTA WITH A 3.9 ENGINE AND HAS THE SAME PROBLEMS THAT ARE IN THE 2 MODELS DESCRIBED ABOVE. THE CHECK ENGINE LIGHT WILL NOT COME ON AND THE CATALYTIC CONVERTER RATTLES. *NM

I OWN A 1997 DODGE DAKOTA SLT. THE ENGINE IS A 5.2 V8 WITH ONLY 45,000 MILES MY COMPLAINT STARTED AROUND 40,000 MILES. I AM GETTING A SEVERE SPARK KNOCK AND A TREMENDOUS OIL CONSUMPTION 2.5 QUARTS EVERY TWO HUNDRED MILES. THEY INSTALLED FAULTY ENGINE INTAKE MANIFOLD PLENUM PAN GASKETS. THROUGH MY EXTENSIVE RESEARCH THERE HAVE BEEN COUNTLESS COMPLAINTS ON THIS. I WAS DRIVING DOWN THE HIGHWAY AND MY CHECK ENGINE LIGHT CAME ON AND CHECKED MY GAUGES I HAD A COMPLETE LOSS OF OIL PRESSURE. LUCKILY NO ONE WAS BEHIND ME BECAUSE MY ENGINE STALLED!!! THE DODGE DEALER TOLD ME THIS IS VERY COMMON, SO WHY ARE THEY NOT TAKING RESPONSIBILITY? *NM

DT*: THE CONTACT STATED UPON STARTING THE VEHICLE, THE BRAKE PEDAL WENT THREE QUARTERS OF WAY TO THE FLOOR. THE VEHICLE WAS THEN DRIVEN DOWN THE DRIVEWAY AND FLUID WAS ON THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE IT WAS DETERMINED THE BRAKE LINES THAT GO TO THE REAR OF THE VEHICLE CORRODED. THE VEHICLE IS LOCATED IN A SALT BELT STATE. THE MECHANIC INSTALLED NEW PIPING.

DT*: THE CONTACT STATED THAT THERE WAS A FUEL LEAKAGE IN THE VEHICLE WHICH STARTED IN THE BEGINNING OF JUNE 2006. THERE WAS RECALL #00V199000 REGARDING FUEL LEAKAGE HOWEVER THE DEALER AND MANUFACTURER DETERMINED THE VIN OF THE VEHICLE WAS NOT INCLUDED IN THE RECALL.

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH A KNOCKING AND PINGING SOUND WAS HEARD COMING FROM THE ENGINE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE ENGINE NEEDED REPLACED DUE TO OIL SLUDGE. THE VEHICLE WAS PROPERLY MAINTAINED. THE MANUFACTURER HAS BEEN ALERTED. UPDATED 6/12/2006 -*NM

I BOUGHT A 1997 DODGE DAKOTA PICK/UP THAT HAD 52,303 MILES SHOWING ON THE SPEEDOMETER, THE DEALER SAID AND SHOWED ME A "SAFETY CHECK" SEAL ON THE WINDSHIELD AND TOLD ME THEY SAFETY CHECK ALL THEIR USED CARS AND TRUCKS, AFTER FINALLY PUTTING 1,000 MILES ON THE TRUCK I NOTICED IT WAS GETTING HARDER AND HARDER TO STEER AND CONTROL, I ALSO STARTED HEARING A LOUD NOISE IN THE FRONT END WHEN TURNING. I FINALLY TOOK THE TRUCK TO A GARAGE AND ASKED TO CHECK THE FRONT END, THE DEALER HAD SUPPOSEDLY ALIGNED THE FRONT END AT THE TIME OF PURCHASE. TO MY SURPRISE AND THE MECHANICS, WHEN HE JACKED UP THE VEHICLE AND WENT TO CHECK THE BALL JOINTS, THE LEFT FRONT WHEEL STARTED TO FALL OFF, THE BALL JOINT WAS SO WORN OUT. THIS VEHICLE HAS 53,324 MILES ON IT AT PRESENT, THESE ARE ACTUAL MILES, THERE IS ONLY 3 TITLES BEEN ISSUED FOR THIS VEHICLE, THE ORIGINAL BUYER (NEW), THE DEALER AND MY SELF. APPARENTLY THE DEALER KNEW THE FRONT END BALL JOINTS WERE WORN OUT, A TRUE SAFETY CHECK AND THE SUPPOSEDLY FRONT END ALIGNMENT THEY CLAIM THEY DID WOULD HAVE SHOWN THAT. ALSO THE SAFETY CHECK THEY CLAIM THEY DO, SHOULD HAVE SHOWN THE BALL JOINTS WERE WORN OUT. IF WE HAD BEEN DRIVING ON THE INTERSTATE AND THE LEFT FRONT WHEEL FELL OFF, I DREAD THINKING HOW MANY CARS WOULD HAVE BEEN INVOLVED IN THE WRECK. THE COST OF REPLACING ALL 4 BALL JOINTS COST ME $237.00, I AM POSITIVE A DEALER WOULD HAVE PAID LESS TO REPAIR THE VEHICLE PRIOR TO GUARANTEEING THAT IT WAS A SAFE VEHICLE. IN HAVING THE VEHICLE REPAIRED

OUR 1997 DODGE DAKOTA TRUCK'S ENGINE FAILED THIS PAST FEBRUARY DUE TO THE LACK OF OIL PRESSURE. WE THEN HAD TO HAVE THE TRUCK TOWED TO THE MECHANIC. OUR MECHANIC TOLD US WE NEEDED TO GET A NEW ENGINE PUT IN SINCE OUR ENGINE WAS FULL OF SLUDGE AND HE SAID IT WAS DUE TO THE LACK OF CHANGING OUR OIL. MY WIFE AND I KNEW THIS WAS NOT THE CASE AT ALL SINCE WE ALWAYS HAD THE OIL CHANGED EVERY 3,000 MILES AND WE COULD NOT FIGURE OUT HOW THIS COULD HAVE HAPPENED. AFTER PAYING $5,000 FOR A NEW ENGINE, WE WERE OUTRAGED AND DID OUR OWN RESEARCH ONLINE ABOUT THE CHRYSLER ENGINES AND FOUND THAT THIS IS ACTUALLY A HUGE PROBLEM WITH THE CHRYSLER ENGINES EVERYWHERE. THE ONLY THING WE'VE NOTICED IN OUR RESEARCH IS THAT THE COMPLAINTS ARE STEMMING FROM THE SMALLER 2.7 LITER ENGINES, BUT WE HAVE A 3.9 LITER ENGINE WITH THE SAME EXACT PROBLEM. THERE IS CLEARLY A DEFECT WITH THE CHRYSLER ENGINES REGARDLESS OF THE SIZE OF THE ENGINE. CHRYSLER SHOULD HAVE TO PAY FOR THIS SINCE THEY ARE THE ONES THAT ARE PUTTING OUT THE DEFECTIVE ENGINES THAT ARE CAUSING ALL OF THE SLUDGE TO BUILD UP IN THEIR ENGINES!! *NM

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS HAVING AN OIL CHANGE PERFORMED BY THE DEALER, THE SERVICE DEPARTMENT DETERMINED THE UPPER BALL JOINTS NEEDED TO BE REPLACED. THE UPPER BALL JOINTS WERE REPLACED AND LUBRICATED. THERE IS A NHTSA RECALL, # 04V596000, REGARDING THE UPPER BALL JOINTS. THE VIN WAS NOT INCLUDED IN THE RECALL. UPDATED 6/1/2006 - *NM

DT*: THE CONTACT STATED WHILE DRIVING THE CONTACT SMELLED GASOLINE. THE CONTACT NOTICED THERE WAS GAS COMING FROM THE TOP OF THE PLASTIC FUEL TANK. THERE WAS A CRACK LOCATED AT THE RIGHT REAR TOP CORNER OF THE TANK. THE DEALERSHIP HAS BEEN INFORMED.

I CANNOT REST PROPERLY AGAINST THE SEAT BACK IT WILL RECLINE ON ITS OWN. REACHING INTO POCKET AT DRIVE-THRU RESTAURANTS APPLYING MODERATE PRESSURE AGAINST SEAT BACK IT FALLS ALL THE WAY BACK. IF I ACCELERATE SWIFTLY THE SEAT BACK WILL DROP FROM BEHIND ME. IN EVENT OF ACCIDENT I'M SURE I WILL HAVE NO SUPPORT TO PREVENT WHIPLASH.*JB

DT*: THE CONTACT STATED WHILE TRAVELING 60 MPH, THE STEERING BECAME HARD TO CONTROL. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP WHERE IT WAS DETERMINED THE LOWER AND UPPER BALL JOINTS NEEDED TO BE REPLACED. THERE IS A NHTSA RECALL, # 04V596000, REGARDING THE UPPER BALL JOINTS. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

MY HUSBAND AND I WERE IN A WRECK 01/02/06 WITH HIS 97 DODGE DAKOTA SLT CLUB CAB, WE HIT 2 DEER AT 50-55 MPH HEAD ON. OUR AIRBAGS DID NOT DEPLOY. WE NOTIFIED CHRYSLER ABOUT THIS MATTER. THEY SENT OUT A SPECIAL INVESTIGATOR TO GO OVER THE TRUCK TO SEE WHY THEY DID NOT DEPLOY, WE WERE ADVISED BY MY HUSBANDS INSURANCE COMPANY TO BE PRESENT AT THE TIME OF INSPECTION, WE TOLD THIS TO CHRYSLERS SPECIAL INVESTIGATOR. MY HUSBAND WENT TO THE DEALERSHIP THE TRUCK WAS TO BE TAKEN TO THE SI DIDN'T SHOW UP MY HUSBAND CAME HOME, I CALLED THE BODY SHOP THAT HAD THE TRUCK AND THEY INFORMED ME THAT THE SI HAD COME AND LOOKED AT THE TRUCK THERE AND THEN WAS WANTING IT TAKEN TO A LOCAL DEALERSHIP. I TOLD THE BODY SHOP NOT TO ALLOW THE TRUCK TO BE MOVED WITHOUT US PRESENT, THEY WENT AHEAD AND DID IT ANYWAY. ALONG WITH CONTACT OVER THE AIRBAGS WITH CHRYSLER I WAS MADE AWARE OF 1 RECALL, THAT WE HAD NOT BEEN NOTIFIED OF. NOW IN MY RESEARCH I HAVE FOUND 5 RECALLS THAT WE WERE NOT NOTIFIED OF. I WAS INJURED IN THE ACCIDENT BECAUSE OF THE AIRBAGS NOT DEPLOYING, I AM STILL HAVING PROBLEMS. WE HAVE NO VEHICLE AT ALL, CHRYSLER IS DRAGGING THEIR FEET ABOUT DOING ANYTHING AS FAR AS TELLING US ANY DETAILS OF THE INVESTIGATION. WE ARE THINKING ABOUT POSSIBLY REPAIRING THE TRUCK, THIS WILL TAKE MONEY THAT WE DO NOT HAVE TO FIX, THE TRUCK HAD LIABILITY ONLY INSURANCE. WE LIVE ON A FIXED INCOME, MY HUSBAND IS DISABLED, I AM CURRENTLY NOT WORKING AND IF I WERE I WOULD HAVE BEEN FIRED FOR NOT BEING ABLE TO GET TO

TWO DRIVER SIDE EXHAUST MANIFOLD BOLTS BROKE OFF. THESE TWO BOLTS WHERE HOLDING ON THE HEAT SHIELD. THE HEAT SHIELD DROP DOWN AND WEDGED IT SELF BETWEEN THE ENGINE AND STEERING SHAFT. THE STEERING SHAFT IS NOW SCORED. THE ONLY REASON I FOUND THIS WAS THAT I KNOW WHAT AN EXHAUST LEAK SOUNDS LIKE AND WENT SEARCHING. IF I DIDN'T I WOULD HAVE NEVER FOUND IT UNTIL MY STEERING SHAFT SEPARATED. *JB

DT: THE CONTACT STATES THERE NHTSA RECALL CAMPAIGN 04V596000 CONCERNING UPPER BALL JOINTS. THE CONSUMER IS EXPERIENCED THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE MODEL YEAR OF VEHICLE. THE CONTACT HAS NOT REPAIRED THE VEHICLE. *AK UPDATED 12/27/05. *JB

SUSPENSION, UPPER AND LOWER BALL JOINTS REPLACED AND SHOCKS REPLACED - 60K MILES. RECALL ON 2000 AND UP BUT PROBLEM WITH 97 AND UP. *NM

DT: THE CONTACT STATED DEALER REPLACED BOTH THE UPPER AND LOWER FRONT CONTROL ARM BALL JOINTS IN 2003. UPON INSPECTION THIS YEAR IT WAS DISCOVERED THE BALL JOINTS NEEDED TO BE REPLACED AGAIN. THE VEHICLE HAD ONLY ACCUMULATED 16,500 MILES SINCE THEY WERE LAST REPLACED. THE FIRST REPLACEMENT WAS COMPLETED UNDER WARRANTY. THE CURRENT REPLACEMENT OF THE BALL JOINT WILL BE DONE AT THE CONTACT'S EXPENSE. HE FELT THEY WERE DEFECTIVE BASED ON THE LIMITED MILEAGE.*AK

AFTER READING ABOUT BALL JOINT FAILURE ON DAKOTAS AND DURANGO'S I CHECKED MY 1997 DAKOTA WITH 43000 MILES AND FOUND ALL UPPER AND LOWER BALL JOINT SEALS TORN OPEN AND NO GREASE IN THE IN THE BALL JOINT SOCKET. THERE IS NO SIGN OF ANY GREASE EVER IN OR AROUND THE BALL JOINTS. THE JOINTS ARE STARTING TO RATTLE. *JB

I NOTICED ANOTHER COMPLAINT DATED 3/1/2004 AS THE FAIL DATE AND AN INTERNAL USE DATE OF 7/6/2005 OF THIS SAME PROBLEM. THE PAINT ON THE ROOF OF THE CAB STARED PEELING OFF AND PAINT ON VARIOUS OTHER AREAS OF THE TRUCK. THE BUMPER WAS THE FIRST TO GO. I WOULD SAY THIS STARTED ABOUT AFTER THE TRUCK WAS 4-5 YEARS OLD. I ONCE HAD THIS HAPPEN ON A TWO YEAR OLD NISSAN TRUCK AND NISSAN REPAINTED THE ENTIRE TRUCK AN SAID IT WAS DEFECTIVELY PAINTED. *NM

OCT. '04 BROUGHT TRUCK IN FOR A WHEEL ALIGNMENT AND WAS TOLD THE CONTROL ARM AND UPPER AND LOWER BALL JOINTS NEED REPLACING AT A COST OF $1,000. FOR SAFETY I HAD THE FRONT END FIXED. YOU HAVE ORDERED RECALLS FOR SIMILAR FAILURES IN THE 2000-03 DAKOTAS. THE 1997'S HAVE THE SAME PROBLEM. *NM

THE UPPER BALL JOINTS ON MY 1997 DODGE DAKOTA FAILED WITH ONLY 28,000 MILES ON THEM. I REPLACED THEM MYSELF WITH MOOG GREASABLE BALL JOINTS. I STILL HAVE THE OLD PARTS. *NM

PAINT BEGAN BUBBLING ABOUT A YEAR AGO ON THE ROOF OF THE CAB. SINCE THEN EVERY SINGLE PANEL ON THE VEHICLE(HOOD, ROOF, FRONT 1/4 PANELS, DOORS, CAB BODY, AND REAR FENDERS) ALL HAVE AT LEAST ONE SPOT WHERE PAINT HAS BUBBLED AND PEELED. SOME SPOTS AS BIG AS A FOOT IN DIAMETER AND GROWING. THIS IS NOT RANDOM. I MEAN EVERY BODY PART HAS PAINT JUST "LETTING GO". THIS IS AN OBVIOUS CASE OF POOR PAINTING PROCEDURES AND IS SEEN IN MANY OTHER MAKES AND MODELS FROM DODGE IN THIS SAME TIME FRAME.

BEGAN SMELLING FUEL WHILE AT IDLE OR IMMEDIATELY AFTER SHUTTING ENGINE OFF. IF VEHICLE WAS LEFT SHUT OFF FOR 30 MINUTES OR SO THE SMELL WOULD SUBSIDE AND CEASE. VEHICLE THEN BEGAN TAKING SEVERAL SECONDS OF CRANKING TO START WHICH ADDED TO THE CASE THAT FUEL WAS ESCAPING FROM THE PRESSURIZED FUEL LINE WHILE SITTING. I OBSERVED FLUID LEAKING FROM UNDER TRUCK ON DRIVER SIDE OF VEHICLE IN THE CAB REGION AND UPON CLOSER INSPECTION FOUND THE METAL FUEL LINE SHOWED EVIDENCE OF RUBBING AGAINST UNDER SIDE OF CAB BODY AND WAS SPRAYING FUEL TOWARD CENTER OF TRUCK AND HAD THE UNDER SIDE OF TRUCK CAB WET IN ABOUT A 2 FOOT SQUARE. FUEL LINE SHOWS NO EVIDENCE OF BEING IMPACTED AND IS STILL HELD IN ROUTING AND SECURING CLAMPS UNDERNEATH VEHICLE. THIS APPEARS TO BE THE ORIGINAL ROUTING OF FUEL LINES.