2005 Chevrolet Silverado complaints

I OWN BOTH A CHEVY SILVERADO AND SUBURBAN 2005. BOTH VEHICLES WILL RANDOMLY START BLOWING HOT AIR OUT THE DRIVER'S SIDE. I KNOW AT LEAST 5 OTHER PEOPLE THAT HAVE 2005 CHEVYS AND THEIR VEHICLE DOES THE SAME THING. I TRIED WORKING WITH THE DEALER AND CHEVY AND BOTH ACT LIKE THEY NEVER HEARD OF THE PROBLEM. CHEVY REFUSES TO ACKNOWLEDGE THAT THIS IS A DEFECTED ISSUE ON THEIR PART AND WANT OVER $1000.00 TO FIX THE ISSUE. IS THERE ANYWAY YOU CAN GET GOVERNMENT MOTORS TO ISSUE A RECALL? *TR

I WAS DRIVING THE VEHICLE AT NORMAL SPEEDS AND I HAVE HAD THIS VEHICLE FOR ABOUT 6 MONTHS AND NEVER HAVE HAD A PROBLEM WITH IT. ALL THE SUDDEN I GET A MESSAGE THAT SAYS "SERVICE AIR BAG". I TOOK THE TRUCK TO THE DEALER AND THEY DIAGNOSED IT AND THEY SAID THAT THE TRUCK NEEDS A NEW FRONT DRIVERS SIDE IMPACT SENSOR THAT WENT BAD. THIS TRUCK HAS NEVER BEEN IN AN ACCIDENT AND THE AIRBAGS HAVE NEVER BEEN DEPLOYED. THEY TOLD ME THAT IF THIS REPAIR DOES NOT GET DONE, IF I HAVE AN ACCIDENT THE AIRBAGS WOULDN'T DEPLOY. *TR

STARTED TRUCK PLACED FOOT ON BRAKE AND PEDAL WENT TO FLOOR. BRAKE FLUID LEAKED ALL OVER THE GROUND. HAD VEHICLE TOWED TO REPAIR SHOP. BRAKE LINE WERE TOTALLY RUSTED THROUGH. I DRIVE THE VEHICLE APPROXIMATELY ONCE A WEEK. IT ONLY HAS APPROXIMATELY 9700 MILES ON IT. I AM THE ONLY OWNER. THE UNDER CARRIAGE IS ALSO RUSTED. LUCKILY IT HAPPEN IN MY DRIVEWAY RATHER THAN ON THE ROAD. CAN PROVIDE A RECEIPT FOR ALL NEW BRAKELINES INSTALLED IF NEEDED. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE REAR BRAKE LINES NEAR THE FUEL TAKE WERE COMPLETELY COVERED WITH RUST CAUSING THE VEHICLE TO LOSE ALL OF THE BRAKE FLUID. THE CONTACT WAS DRIVING 60 MPH AT THE TIME OF THE FAILURE. THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN THE PEDAL WAS ENGAGED. THE CONTACT HAD TO SHIFT THE VEHICLE INTO A LOWER GEAR AND USE THE EMERGENCY BRAKE IN ORDER TO DRIVE THE VEHICLE TO THE DEALER. THE DEALER CONFIRMED THE BRAKE LINES RUSTED THROUGH IN THE REAR. THE FAILURE AND CURRENT MILEAGE WAS 82,000.

COLD AIR BLOWING INSTEAD OF HOT AIR AND COULD NOT DEFROST WINDSHIELD. HAD TO PULL OFF ROAD AND SCRAPE INSIDE OF WINDSHIELD. THIS HAS OCCURRED SEVERAL TIMES OVER THE YEARS WHERE HOT AIR IS COMING FROM PASSENGER SIDE AND COLD AIR COMING FROM DRIVERS SIDE. VERY DANGEROUS IF YOU CANNOT SEE THROUGH THE WINDSHIELD AS WINDOWS FOG OR FREEZE UP. *TR

SERVICE AIR BAG LIGHT WAS ACTIVATED WITHOUT ANY REASON. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE BACKLIGHT AND THE GAUGE LIGHTS ON THE INSTRUMENT PANEL HAD BECOME ABNORMALLY DARK. THE CONTACT WAS UNABLE TO SEE ANY OF THE GAUGES ON THE INSTRUMENT PANEL, INCLUDING THE TACHOMETER AND SPEEDOMETER, WHICH ALSO FAILED INTERMITTENTLY. THE BATTERY WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO DEALER FOR INSPECTION OR REPAIR. THE VIN WAS UNAVAILABLE.THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. THE CURRENT MILEAGE WAS 113,000.

THIS TRUCK HAS EXPERIENCED TWO FUSE BLOCK FAILURES SINCE NEW. THE SYMPTOM, IN BOTH CASES, WAS THE TRUCK WOULD NOT START. BOTH REPAIRS WERE ACCOMPLISHED AT BROWN AND BROWN CHEVROLET IN MESA ARIZONA. THE FIRST REPAIR OCCURRED IN 2008 AND THE SECOND REPAIR OCCURRED IN 2012. WHEN REIMBURSEMENT WAS REQUESTED FOR THE SECOND FAILURE, THE BROWN AND BROWN SERVICE PERSON AND THE GM CUSTOMER CARE PERSON BOTH DENIED WARRANTY COVERAGE BECAUSE THERE ARE THIRD-PARTY DEVICES INSTALLED IN THE VEHICLE. THERE IS AN ALARM SYSTEM AND A KENWOOD STEREO, WITH A GM MODULE, INSTALLED THAT WERE DEEMED THIRD-PARTY. THERE IS ALSO A CB RADIO BUT IT WAS NOT CITED. ALL VEHICLE EQUIPMENT IS POWERED THROUGH FUSES ON THE FUSE BLOCK. NONE OF THE FUSES WERE FOUND TO BE BLOWN BY BROWN AND BROWN, INCLUDING THE ONES POWERING THE THIRD-PARTY EQUIPMENT. THE FUSE BLOCK?S INTENT IS TO DISTRIBUTE POWER TO SUCH DEVICES AND PROTECT THE WIRING WITH ITS INSTALLED FUSES. PROPERLY CONNECTED EQUIPMENT MAY BLOW A FUSE BUT CANNOT STRESS THE FUSE BLOCK TO FAILURE. I REQUESTED THE ?BAD? FUSE BLOCK IN BOTH CASES AND HAVE DISASSEMBLED THE SECOND ONE. I FOUND LOOSE POWER PINS AND NO EVIDENCE OF BURNING OR ARCING. THE DESIGN PERMITS THE POWER PINS TO LOOSEN OVER TIME, CAUSING INTERMITTENT CONNECTIONS. THIS INTERMITTENT CONNECTION WAS VERIFIED BY BROWN AND BROWN; THEY SAID THAT SIMPLY LEANING ON THE FUSE BLOCK WOULD CAUSE THE ENGINE TO STOP. THIS IS NOT AN EFFECT OF THIRD PARTY EQUIPMENT BUT IS A DESIGN DEFECT OF THE FUSE BLOCK. *TR

PARKED TRUCK AT OUTSIDE STALL AND WENT INDOORS. AFTER ABOUT 20 MINUTES I HEARD NOISES AND WENT OUTSIDE. FOUND THE WHOLE TRUCK WAS ENGULFED IN FLAMES. BY THE TIME THE FIRE DEPARTMENT ARRIVED 6 MINUTES LATER THE FIRE SPREAD TO TWO ADDITIONAL VEHICLES. THE HEAT MELTED AND CONSUMED EVERYTHING EXCEPT THE FRAME. THE FIRE INVESTIGATOR SUSPECTS THE FIRE INITIATED DUE TO ELECTRICAL FAILURE AND GENERATED FROM EITHER THE DRIVER SIDE DASH BOARD OR LEFT SIDE OF ENGINE. THE DAMAGE WAS TOO DESTRUCTIVE TO PINPOINT EXACT CAUSE. *TR

THE INSTRUMENT CLUSTER WENT OUT AND RESET MY ENGINE HOURS, ODOMETER IS ERROR, AND WON'T CHANGE ANYTHING.I TOOK IT TO THE DEALER AND THEY SAID ABOUT $600 TO FIX.THERE IS ALOT OF PROBLEMS WITH THESE AND THEY SHOULD BE FIXED FOR FREE. *JS

BRAKE PEDAL WENT TO THE FLOOR WITHOUT STOPPING THE VEHICLE. FOUND THE LINES ON THE DRIVER SIDE BELOW THE DOOR ON TOP OF THE RAIL WERE CORRODED AND HAD BURST. *JS

FAILURE OF BRAKING SYSTEM DUE TO RUSTED BRAKE LINES, ALL LINES NEED REPLACEMENT. UPON ATTEMPTING TO STOP THE VEHICLE THE BRAKE PEDAL WENT TO THE FLOOR, UPON EXITING THE SYSTEM WAS LEAKING BRAKE FLUID DIRECTLY UNDER THE DRIVER COMPARTMENT. *JS

I WAS DRIVING 75 MPH WITH MY CRUISE CONTROL ON, AND THE SPEEDOMETER DROPPED TO 35 MPH. SHORTLY AFTER, ABOUT 10 MILES, THE AIR BAG LIGHT CAME ON. THE SPEEDOMETER RESET AFTER TURNING OFF THE IGNITION SWITCH AND WORKED PROPERLY. THIS HAPPENED AGAIN TWO MORE TIMES, AND THE SPEEDOMETER FAILED COMPLETELY. THE AIR BAG LIGHT REMAINED ON AND IS STILL ON AT 123,000 MILES. DIAGNOSTIC CHECK SHOWED NUMBER 1 AIR BAG SENSOR FAULT. REPLACED SENSOR. AIR BAG LIGHT STILL ON. I SENT THE SPEEDOMETER HEAD TO A PRIVATE MECHANIC IN MINNESOTA, AND IT NOW WORKS FINE. *JB

SPEEDOMETER STARTED STICKING AT 60MPH AND THEN IF THE TRUCK WAS RESTARTED IT WOULD GO BACK TO 0 AND START WORKING AGAIN AND THEN WOULD STICK AGAIN LATER. WELL NOW IT'S JUST STUCK AT 0 AND DOESN'T MOVE AT ALL. ALL THE OTHER GAUGES WORK PROPERLY THOUGH. *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT WAS DRIVING 55 MPH WHEN THE FRAME BED OF THE VEHICLE DROPPED. THE CONTACT THEN PULLED OVER AND NOTICED THAT THE SPRING SHACKLES TO THE FRAME WERE FRACTURED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THAT THERE WAS CORROSION ON THE FRAME AND OFFERED NO ASSISTANCE IN REPAIRING THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 104,000 AND THE CURRENT MILEAGE WAS 108,617.

2005 CHEVY SILVERADO CK1500. CONSUMER WRITES IN REGARDS TO DISABLING THE SWITCH FOR THE DRIVERS' AIRBAG OR IF SHE CAN OBTAIN A WAIVER SO THAT THE DEALERSHIP CAN DISABLE THE DRIVER'S AIRBAG *TGW THE CONSUMER STATED SHE HAS TO HAVE THE SEAT UP ALL THE WAY, IN ORDER TO REACH THE PEDALS; PARTICULARLY THE CLUTCH. THE CONSUMER STATED THERE IS NO WAY SHE CAN BACK FURTHER THAN THE RECOMMENDED 10 INCHES FROM THE STEERING WHEEL, DUE TO HER HEIGHT. *JB

EXHAUST MANIFOLD BOLTS BREAKING LEAVING STUDS IN THE HEADS, HEATING UP ENGINE COMPARTMENTS, RELEASES CARBON MONOXIDE, AFFECTS O2 SENSOR AND CATALYTIC CONVERTER. WILL NOT PASS EMISSIONS IN SOME STATES. GM NOT STANDING BEHIND THIS 1999-2008 ISSUE. IT IS A SAFETY ISSUE AND IS EXPENSIVE TO FIX. GM MECHANICS DENYING ANY SUCH ISSUES. PLEASE CHECK- IN TO THIS. OUR WHOLE FLEET AND OUR PERSONAL TRUCKS AFFECTED BY THIS. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS HEATING UP ENGINE COMPARTMENT, RELEASES CARBON MONOXIDE, AFFECTS O2 SENSOR AND CATALYTIC CONVERTER, WILL NOT PASS EMISSIONS IN SOME STATES. GM NOT STANDING BEHIND THIS 1999-2008 ISSUE. IT IS A SAFETY ISSUE AND IS VERY EXPENSIVE FOR US TO FIX. GM MECHANICS SAY THEY HAVE NOT HEARD OF THIS ISSUE. PLEASE CHECK IN TO THIS. *TR

THIS IS THE SECOND TIME IT HAS HAPPEND, MY EXHAUST MANIFOLD BOLT BREAKS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE PARKED, THE CONTACT NOTICED THAT THE GEAR INDICATOR WAS EXTREMELY DIM AND WAS DIFFICULT TO SEE WHICH GEAR THE VEHICLE WAS IN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS WHERE THE MECHANIC ADVISED THE CONTACT THAT THE INSTRUMENT CLUSTER WOULD HAVE TO BE REPROGRAMMED.THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V055000 (POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR) BUT WAS ADVISED BY THE MANUFACTURER WAS THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

IN JUNE, 2011, I BEGAN NOTICING MY ANTIFREEZE LEVELS WERE DROPPING SLIGHTLY. THERE WERE NO NOTICEABLE LEAKS OF ANTIFREEZE ANYWHERE. I ATTRIBUTED IT TO EVAPORATION & ADDED COOLANT. OVER TIME THE TRUCK STARTED USING MORE & MORE ANTIFREEZE. A FRIEND OF MINE NOTICED A PUFF OF WHITE SMOKE COMING FROM THE TAILPIPE. AT THE TIME I DIDN'T REALLY THINK ANYTHING OF IT. LAST WEEK WHILE DRIVING HOME FROM WORK AFTER FINISHING UP A "B" TRICK JOB (11PM), I NOTICED A KNOCKING SOUND COMING FROM THE ENGINE. IT SMOOTHED OUT AFTER A FEW MILES OF DRIVING IT. THE NEXT DAY IT HAPPENED AGAIN ( I WORK 26 MILES FROM HOME) AGAIN IT SMOOTHED OUT & I WAS JUST GRATEFUL I GOT HOME SAFELY THAT NIGHT. BY THIS TIME I KNEW THERE WERE SOME SERIOUS ISSUES & DECIDED NOT TO DRIVE IT AGAIN. I BEGAN RESEARCHING THE ISSUE ON LINE & FOUND OTHERS THAT WERE EXPERIENCING IDENTICAL SYMPTOMS. TURNS OUT THE PROBLEM LIES WITH THE CYLINDER HEADS IN THE ENGINE MANUFACTURED FOR GM BY CASTECH. ACCORDING TO OTHER PEOPLE & BY GMS OWN ADMISSION, A FAULTY, WEAK MATERIAL WAS USED TO BUILD THE CYLINDER HEADS. OVER TIME THE MATERIAL WEARS AWAY CAUSING POROUS CRACKS & THE ANTIFREEZE SEEPS INTO THE OIL SYSTEM POLLUTING IT, CAUSING SIGNIFICANT DAMAGE TO THE ENGINE. (BY THIS TIME MOST EXTENDED WARRANTIES ARE UP). THE ANTIFREEZE MIXES WITH THE OIL & IS EMITTED OUT OF THE TAILPIPE AS EXHAUST. THIS IS WHY NO TRACES OF ANTIFREEZE WERE FOUND & THE REASON FOR THE WHITE PUFF OF SMOKE. GM ISSUED A BULLETIN #06-06-01-019B IN JUNE 2007 INFORMING REPA

THE PROBLEM ADDRESSED IN YOUR NHTSA ACTION NUMBER: PE05020 FOR EARLIER MODEL YEARS OF THE SAME TRUCK ARE OCCURRING IN MY 2005 TRUCK. THIS HAS LED TO NEAR REAR-END COLLISIONS. THE BRAKES GO INTO AN "ANTI-LOCK" CONDITION AT SLOW SPEEDS WHILE BRAKING, NO MATTER WHAT THE WEATHER OR ROAD CONDITIONS ARE. YOU SHOULD EXTEND THE MODEL YEARS COVERED IN YOUR EARLIER RECALL TO INCLUDE ALL THRU 2005 MODELS AND PERHAPS BEYOND OR ISSUE A NEW RECALL BASED ON THIS AND SIMILAR COMPLAINTS FROM CONSUMERS. OBVIOUSLY GM DID NOT FIX THE PROBLEM IN FOLLOW ON VERSIONS OF THE SILVERADO. *KB

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE SPARE TIRE CABLE FRACTURED CAUSING THE SPARE TIRE TO DETACH FROM THE VEHICLE. THE STRANDS WHERE THE CABLE FRACTURED WERE UNEVEN AND CONTAINED RUST. THE CONTACT WAS UNAWARE UNSURE WHAT THE APPROXIMATE SPEED WAS WHEN THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 01/13/12*LJ

SPEEDOMETER STOPPED FUNCTIONING. IT DISPLAYS I'M DRIVING @ 120 MPH AND GETS STUCK THERE, WHEN I'M ONLY GOING APPROXIMATELY 30-40 MPH. THIS IS RIDICULOUS THAT THERE IS NO RECALL ON THIS MALFUNCTION AS I SEE THERE ARE PLENTY OF COMPLIANTS WITH SAME ISSUE. HOW CAN I DRIVE SAFELY WITHOUT KNOWING THE SPEED LIMIT I'M GOING. *TR

HEATER BLOWER CONNECTOR FIRE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT ABNORMALLY DEPRESSED THE BRAKE PEDAL INTO THE FLOORBOARD. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME WHERE IT WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE MECHANIC ADVISED THAT THERE WAS EXCESSIVE RUST ON THE FRAME AND THE REAR BRAKE LINE WAS FRACTURED. THE REAR BRAKE LINE WAS REPLACED. THE MECHANIC INFORMED THE CONTACT THAT THE OTHER FRONT BRAKE LINES WERE ALSO RUSTED AND COULD POSSIBLY FRACTURE IF NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING OVER A BUMP IN THE ROAD AND TURNING THE STEERING WHEEL THE VEHICLE MADE A LOUD CLANKING SOUND. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 67,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE WIRING FOR THE AIR BAG SENSOR UNDER THE PASSENGER SEAT WAS FAILING. THE VIN WAS AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THE WIRING HARNESS CONNECTED TO THE BLOWER MOTOR BECAME HOT AND BEGAN TO MELT. A PRIVATE MECHANIC REPAIRED THE RESISTOR IN OCTOBER 2008; HOWEVER, THE FAILURE OCCURRED AGAIN. IN JANUARY 2011, THE CONTACT HAD THE WIRING HARNESS AND THE RESISTOR QA REPLACED BY A PRIVATE MECHANIC SINCE HE SMELLED A BURNING ODOR AND HAD TO DISCONNECT THE WIRING HARNESS IN ORDER TO PROTECT IT FROM MELTING. THE DEALER NOR MANUFACTURER WERE NOTIFIED. THE CURRENT MILEAGE WAS 119,000. THE APPROXIMATE FAILURE WAS 80,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING ALONG WHEN THE CAB FILLED WITH SMOKE AND A BURNING PLASTIC SMELL. I SAW SMOKE COME FROM UNDER THE PASSENGER SIDE DASHBOARD. THE BLOWER MOTOR RESISTOR HARNESS HAD CAUGHT FIRE. I WAS ABLE TO PUT IT OUT WITH DAMAGE TO ONLY THE HARNESS AND RESISTOR. IT WAS REPLACED UNDER THE EXTENDED WARRANTY I HAD PURCHASED FROM GM. FAST FORWARD TO MAY 9, 2010 AND 50,000 MILES LATER, THE SAME THING HAPPENED AND GM CORPORATE TOLD ME THERE WAS NOTHING THEY COULD DO EVEN THOUGH THIS SAME MODEL VEHICLE HAS BEEN RECALLED IN CANADA FOR THE SAME PROBLEM. I WAS QUOTED $300.00 FOR THE REPAIR. ON MAY 10.2010, MY DEALER CALLED AND SAID HE RECEIVED AN E-MAIL FROM GM STATING THAT GM WAS IN THE PROCESS OF OFFERING A 10 YEAR 150,000 MILE WARRANTY ON THE BLOWER MOTOR AND HARNESS REPAIR. HAVE NOT RECEIVED ANY NOTICE FROM GM YET BUT DEALER SAID THEY WOULD FIX IT NO CHARGE.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A LOCAL SHOP WHERE THEY INFORMED THAT THE ELECTRONIC CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT UNDER WARRANTY. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 36,946 AND THE CURRENT MILEAGE WAS 37,826.

THE PROBLEM IS THE FAN ON GM TRUCKS BURNS OUT. WE WERE TOLD BY THE SERVICE DEPT THAT THE WIRES WERE BURNED UP AND THAT THIS REQUIRED MORE PARTS AND SERVICE. NEEDED RESISTOR, CONNECTOR AND BLOWER TO REPAIR. THIS IS A POTENTIAL FIRE HAZARD WHICH IS NOT BEING ADDRESSED BY GM. APPARENTLY THIS IS AN ISSUE THAT MANY VEHICLE OWNERS HAVE EXPERIENCED BUT SINCE NO ONE HAS BEEN KILLED I GUESS THERE IS NOT REASON TO MANDATE A RECALL. WE WERE TOLD BY THE SERVICE DEPT. THAT MANY VEHICLES ARE BEING BROUGHT IN FOR SERVICE BECAUSE OF THIS PROBLEM. THIS SHOULD BE LOOKED INTO. OUR VEHICLE HAS 38,000 MILES. WE HAVE A FRIEND WHO LIVES IN NJ THAT HAD THE SAME PROBLEM WITHIN A YEAR OF PURCHASING HIS NEW TRUCK. *TR

NOTICED VEHICLE VIBRATION AT SLOW SPEED AND PERSISTENT BUT NOT AS SEVERE AT HIGHWAY SPEEDS. NOT BEING A MECHANIC I THOUGHT IT FELT LIKE A TIRE OUT OF ROUND OR TIRE OUT OF BALANCE. TOOK IT TO A FIRESTONE SHOP TO INSPECT AND CORRECT PROBLEM. MECHANIC FOUND THAT THE RIGHT FRONT BEARING WAS FALLING APART AND NEEDED TO BE REPLACED. THE TIRES WERE READY TO BE REPLACED THEY HAD 60,000 MILES ON THEM WITH A LITTLE CUPPING BUT FAIRLY EVEN WEAR. WITHOUT STOPPING TO CHECK THE TIRES THE BEARING MOST LIKELY WOULD HAVE FAILED AT HIGHWAY SPEEDS, WHICH PROBABLY WOULD HAVE PREVENTED ME FROM FILING THIS REPORT. *TR

I ALSO HAVE A 2005 SILVERADO AN THE SPEEDOMETER IS STUCK AT 120 IT HAS GONE DOWN AS FAR AS 60 BUT WHEN YOU DRIVE IT PEGS OUT AND REMAINS THERE. THERE WERE NO WARNINGS JUST HAPPENED AROUND 82,000 NOW AT 86,000 AND 6,000 MILES OUT OF WARRANTY. I FEEL THAT THIS IS A SAFETY HAZARD BECAUSE I DON'T KNOW MY SPEED BUT I AM LUCKY ENOUGH TO HAVE BEEN GIVEN A GPS TO DO THAT. I LOOKED AT GM WEBSITE BUT THEY SAY I AM OVER MILEAGE FOR REPAIR AND I DON'T HAVE THE MONEY FOR THE REPAIRS MYSELF AN FEEL THIS SHOULD BE REMEDIED BY THE MANUFACTURER SINCE IT IS A WELL KNOW PROBLEM OF THEIRS AND THIS DEFECTIVE EQUIPMENT. *TR

SPEEDOMETER NOT SHOWING CORRECT SPEED. *TR

FUEL EVAP SYSTEM MALFUNCTIONING NOT ALLOWING FUEL SYSTEM TO VENT THUS MAKING IT ALMOST IMPOSSIBLE TO REFUEL THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE GEAR INDICATOR LIGHTS FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS OR DIAGNOSIS. THE CONTACT STATED THERE WAS A RECALL (NHTSA CAMPAIGN ID NUMBER: 05V055000-POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR)BUT THE MANUFACTURER INFORMED THE CONTACT THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THE VEHICLE WAS ABNORMALLY LOSING COOLANT EVERY THREE WEEKS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE MECHANIC WAS UNABLE TO DETERMINE THE SOURCE OF THE LEAK. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED IN REGARDS TO THE FAILURE. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF THE VEHICLE OVERHEATING AS HE LOCATED NUMEROUS COMPLAINTS ONLINE REGARDING THE FAILURE IN HIS YEAR, MAKE AND MODEL BUT NO RECALLS. THE FAILURE MILEAGE WAS 80,000.

ANTI- LOCK BRAKES ARE ACTIVATING ON DRY PAVEMENT AT SLOW SPEEDS. THIS HAPPENS 95% OF ALL STOPPINGS. WHEN YOU THINK YOU WILL STOP IN 10-15 FEET, IT MIGHT TAKE TWICE THE DISTANCE AS EXPECTED. *TR

I HAVE A 2005 CHEV SILVERADO TRUCK WHERE THE ABS SYSTEM COMES ON AT 15KMS OR LESS. THIS HAPPENS ON MATTER THE ROAD CONDITION, ITS STARTED ABOUT 2 MONTHS AGO. NOW IT COMES ON ALL THE TIME, EVERYTIME I STOP. WHAT HAPPENS IS THAT THE ABS COMES ON WHEN BELOW 15KMS, SCARELY WHNE YOUR NOT EXSPECTING IT. I REASEACHED THIS AS TO WHY OR IF THERES ANY RECALLS. I FOUND OUT THE 1999-2002 CHEV SILVERADO'S HAD RECALLS ON THESE VEHILCES FOR THIS PROBLEM. PROBLEM IS THAT IT STATED THAT IT'S CAUSED FROM CORRISION IN THE HUB, GIVING A WRONG SIGNAL TO THE ABS SYSTEM. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE VEHICLE WAS EQUIPPED WITH GENERAL TIRES, LINE SIZE P245/70R17. THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE WENT FLAT. HE PURCHASED PENNZOIL FIX A FLAT S455, 16 OZ TO REPAIR THE TIRE. THE CONTACT WAS ATTEMPTING TO FIX THE FLAT WHEN THE HOSE DISCONNECTED FROM THE CAN. THE CONTACT STATED THAT THE PLASTIC RING WAS FRACTURED AND THE CHEMICALS FROM THE CAN RELEASED INTO HIS FACE. THE CONTACT SUSTAINED INJURIES TO HIS LUNGS, BOTH EYES AND BURNS TO THE FACE. THE CONTACT STATED THAT THE BOTTLE WAS NOT LABELED IN REGARDS TO WEARING GOGGLES OR PROTECTION WHEN USING THE PRODUCT. HE REFERENCED NHTSA CAMPAIGN ID NUMBER: 99E007000 (TIRES) BUT HAD NOT CONTACTED THE MANUFACTURER IN REGARDS TO THE RECALL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 54,000.

AIR BLOWS COLD ON DRIVER SIDE AND EXTREMELY HOT ON DRIVERS SIDE WITH DUAL CONTROLS BOTH SET TO COOL. SEEMS TO BE A VERY COMMON PROBLEM ACCORDING TO MANY PEOPLE ON THE FOLLOWING WEBSITE AND UNABLE TO BE FIXED BY DEALERS. HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/CHEVROLET-SILVERADO_1500_PICKUP/DUAL_AC_BLOWS_COLD_AIR_ON_PASSENGER_BUT_HOT_ON_DRIVER. *TR

I HAVE A 2005 CHEVROLET SILVERADO. I KEPT SMELLING AN ODOR OF SOMETHING BURNING BUT COULD NOT FIND WHERE IT WAS COMING FROM UNTIL RECENTLY WHEN MY FAN MOTOR STOPPED WORKING. I HAD BEEN HAVING PROBLEMS WITH THE SWITCH NOT WORKING IN ALL POSITIONS. I CALLED THE DEALERSHIP TO INQUIRE ABOUT THE PRICE AND AVAILABILITY OF THE SWITCH. THE PARTS DEPT. INFORMED ME THAT IT WAS MOST LIKELY THE FAN RESISTOR OR THE PLUG BECAUSE THEY HAVE HAD SEVERAL THAT NEEDED REPLACED. WHEN I LOOKED UNDER THE DASH I FOUND WHAT HAD BEEN CAUSING THE SMELL. THE RESISTOR SHOWED SIGNS OF BEING OVERHEATED AND THE WIRE HARNESS WAS BURNT FOR APPROXIMATELY 6 INCHES. THIS IS A FIRE HAZARD AND IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS EITHER INJURED OR KILLED DUE TO THIS DEFECTIVE RESISTOR/PLUG. *TR

LETTER FROM SENATOR ON BEHALF OF CONSTITUENT RE PROBLEMS WITH 2005 CHEVY SILVERADO. DOT/I#2010-1208. *KB THE CONSUMER STATED HIS VEHICLE HAS SEVERE CORROSION ON THE FRAME. WITHIN TWO YEAS, THE ENTIRE UNDERCARRIAGE HAD CORRODED, WHICH CAUSED THE BRAKES AND POWER STEERING TO FAIL CATASTROPHICALLY. THE CONSUMER SUED ALLEGING BREACH OF WARRANTY. THE CASE WAS HEARD, HOWEVER GM EXPERTS TESTIFIED THAT THE CORROSION WAS CAUSED BY SEA AIR AND THEY WERE NOT UNDER ANY OBLIGATION TO COVER CORROSION CAUSED BY THE ENVIRONMENT. THEY ALSO TESTIFIED THAT THE CORROSION WAS PRIMARILY COSMETIC AND THAT THE VEHICLE WAS IN GOOD DRIVING CONDITION. THE CONSUMER STATED TWO DAYS LATER, AS HE ATTEMPTED TO DRIVE THE VEHICLE TO A REPAIR SHOP, THE BRAKE LINES RUPTURED AND THE DRIVE SHAFT SHEARED IN HALF, NEARLY CAUSING A MAJOR ACCIDENT. *JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ON, THE DRIVERS SIDE VENT WAS RELEASING HOT AIR WHILE THE PASSENGER SIDE VENT CONTINUED TO RELEASE COLD AIR. THE CONTACT SHUT THE VEHICLE OFF AND AFTER RESTARTING IT THE AIR CONDITIONER BEGAN TO FUNCTION PROPERLY. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE CONTACT STATED THAT OVER TIME THE FAILURE BECAME PROGRESSIVELY WORSE. THE FAILURE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THERE WAS A TECHNICAL SERVICE BULLETIN RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 71,000. THE VIN WAS UNAVAILABLE.

SPEEDOMETER INOPERATIVE. EVERYTIME THE VEHICLE IS DRIVEN I HAVE NO WAY OF TELLING HOW FAST I AM TRAVELING. *TR

AT AROUND 37,000 MILES THE SPEEDOMETER STARTED STICKING AND AROUND 45,000 MILES IT COMPLETELY WENT OUT AND HAS BEEN STUCK AT 120 MPH EVER SINCE. I TOOK IT TO THE CHEVY DEALERSHIP AND THEY TOLD ME IT WOULD COST AROUND 800.00 DOLLARS TO FIX. I CALLED AND COMPLAINED TO GM CUSTOMER SERVICE, AT WHICH TIME THEY DID NOTHING BUT TOLD ME TO TAKE IT IN AND GET IT REPAIR AT MY EXPENSE. I HAVEN'T HAD THE MONEY TO HAVE IT REPAIRED SO FAR SO I HAVE BEEN DRIVING WITHOUT IT. I THINK CHEVY SHOULD RECALL THE INSTRUMENT CLUSTERS AND FIX THE PROBLEM AT THEIR OWN EXPENSE. *TR

SPEEDOMETER FAILS TO REGISTER ACTUAL SPEED OF DRIVING -- WILL SHOW 120 WHEN DRIVING 70, 90 MPH WHEN DRIVING 30MPH, 15 MPH WHEN STOPPED AT A LIGHT. MAKES HIGHWAY DRIVING HAZARDOUS BECAUSE I AM PRONE TO DRIVING SLOWER THAN TRAFFIC. ALSO CONCERNS ABOUT ACCURACY OF THE ODOMETER BECAUSE OF THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHEN DRIVING THE VEHICLE THE CONTACT NOTICED THAT THE SPEEDOMETER WOULD DISPLAY A SPEED OF 120 MPH WHEN THE CONTACT WAS ACTUALLY TRAVELING AT A SPEED OF 45 MPH. THE DEALERSHIP WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE VEHICLE WAS NOT REPAIRED AT THE TIME OF COMPLAINT. THE FAILURE AND CURRENT MILEAGES WERE 90000. UPDATED 07/19/10 *BF UPDATED 07/21/10.*JB

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO DIESEL ENGINE . WHILE DRIVING AT SPEEDS AS LOW AS 50 MPH, THE VEHICLE SPEEDOMOTER WOULD INDICATE THE VEHICLE WAS TRAVELING AT SPEEDS OF 120 MPH AND WOULD STICK AT THIS MILEAGE. THE VEHICLE WAS TAKEN TO THE DEALER, HOWEVER NO REPAIRS WERE MADE TO THE VEHICLE. THE CONTACT WAS NOT PRESENT AT THE TIME THE VEHICLE WAS TAKEN TO THE DEALER AND WAS UNSURE AS TO WHAT WAS ADVISED IN REFERENCE TO THE VEHICLE. THE FAILURE PERSISTED. THE FAILURE AND CURRENT MILEAGES WERE 96,000. UPDATED 06/02/10. *LJ THE CONSUMER WAS INFORMED THE PROBLEM WAS CAUSED BY A WIRING CLUSTER IN THE DASH. UPDATED 06/28/10*JB