2005 Chevrolet Silverado complaints

ATTEMPTED TO STOP AT STOP SIGN AND BAKE LINE BETWEEN MASTER CYLINDER AND PROP VALVE RUPTURED INSTANTLY DRAINING BRAKE FLUID RESULTING IN NO BRAKING. STOPPED VEHICLE WITH PARKING BRAKE. UPON INSPECTION, DETERMINED THAT BRAKE LINE HAD RUSTED OUT AS A RESULT OF BEING MOUNTED ON TOP OF FRAME RAIL WHERE DIRT, SALT AND MOISTURE COLLECT FROM FRONT WHEEL SPRAY. *TR

WHILE DOING AN OIL CHANGE ON MY 2005 PU I NOTICED ENOUGH BUILDUP OF RUST ON THE BRAKE LINES THAT I STOPPED DRIVING THE TRUCK. I HAVE HAD PU TRUCKS (FORD) SINCE 1972 AND NEVER HAD AN ISSUE WITH BRAKE LINES ALTHOUGH I HAD THE TRUCKS FOR 10 YRS. THIS IS A SERIOUS ISSUE OF NEGLIGENCE OF GM. I AM 75 AND NEVER HAD THIS ISSUE ALTHOUGH I HAD CARS AND TRUCKS (AND MOTORCYCLES) SINCE I WAS 16. I BELIEVE THIS IS MORE SERIOUS THAN IGNITION SWITCH. THANK YOU *JS

APPROACHING A TRAFFIC LIGHT AT THE BOTTOM OF A STEEP GRADED HIGHWAY, I NOTICED THE BRAKE PEDAL FELT SPUNGEY AND NEAR THE BOTTOM THE BRAKE PEDAL WENT CLEAR TO THE FLOOR BOARD. I WAS FORCED TO LEAVE THE HIGHWAY TO PREVENT A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME RESULTING IN NO REAL DAMAGE TO THE VEHICLE ITSELF. IT COULD HAVE BEEN MUCH WORSE. THE BRAKE LINES (4 OF THEM) HAVE RUSTED OUT SO MUCH THAT THEY COULD NOT CONTAIN PRESSURE OF THE FLUID WHEN APPLYING THE BRAKE AND BURSTED. MY MECHANIC TELLS ME THIS WILL BE IN EXCESS OF $600.00 TO REPAIR DO TO THE CAB HAVING TO BE UNBOLTED AND LIFTED FROM THE CHASSIS TO ACCESS THE LINES FOR REPLACING. HE ALSO TELLS ME THAT MANY GM MODELS, NEW AND OLD HAVE THIS PROBLEM WITH RUSTING BRAKE LINES. GM IS AWARE OF THESE PROBLEMS. WHY HAS THIS NOT BEEN ADDRESSED? WHY HAVE THESE MODELS NOT BEEN RECALLED? SUBARU RECENTLY RECALLED OVER 660,000 VEHICLES FOR THE SAME PROBLEM; #DOINGTHERIGHTTHING. I AM NOT AT ALL HAPPY ABOUT THIS. *JS

THE BRAKE LINES AND FUEL LINES RUSTY TO THE POINT THAT THEY ARE LEAKING NEED TO BE REPLACED.THE BLEND MOTOR FOR HVAC ISN'T WORKING RIGHT. *JS

4 WHEEL DRIVE AUTOMATIC SHIFT TO TAKE THE 4 WHEEL DRIVE IN AND OUT MESSED UP HAD TO CHANGE THE SERVO OUT.THE OTHER ISSUE IS THE BEARING HUB FOR THE FRONT WHEEL HUBS 4 WHEEL DRIVE HAS A DEFECT I HAVE HAD THESE HUBS CHANGED OUT 3 TIMES AT A VERY COSTLY PRICE. *JS

WHILE DOING AN OIL CHANGE ON MY 2005 PU SILVERADO I NOTICED LARGE RUST BUILD UP ON THE BRAKE LINES' THIS IS NOT THROUGH NEGLECT ON MY PART, BUT IS SUFFICIENT ENOUGH TO CAUSE SERIOUS CONCERN. MY SON IN LAW WITH CHEVY 2002 HAD A SIMILAR PROBLEM WHEN HIS BRAKES FAILED ON A HILL WHICH CAUSED ME TO CHECK MINE.THIS IS EXTREMELY DANGEROUS AND GM SHOULD BEAR THE RECALL EXPENSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING DOWN HIGHWAY ROAD WHEN SEVERAL DEER RAN IN FRONT OF VEHICLE. SLAMMED ON BRAKES AND THE PEDAL, AFTER A FEW SECONDS, WENT TO THE FLOOR. NOTICED BIG PUDDLE OF FLUID THE NEXT DAY UNDER CAB OF TRUCK. STARTED TRUCK AND HAD NO BRAKES AT ALL. HAD THE TRUCK INSPECTED BY LOCAL REPAIR SHOP AND WAS INFORMED THAT ALL OF THE BRAKE LINES WERE RUSTY BEYOND THE POINT OF REPAIR. HAD TO HAVE A WHOLE NEW BRAKE LINE KIT INSTALLED. *TR

THE TRUCK HAS 110K MILES ON THE DURAMAX / ALLISON DRIVE TRAIN. THE DIESEL FUEL INJECTION PUMP FAILED UNEXPECTEDLY AND WITHOUT WARNING. THIS POWERTRAIN COMBINATION SHOULD BE CAPABLE OF 500K MILES WITHOUT PROBLEMS LIKE THIS. THIS PUMP SHOULD NOT FAIL AFTER NORMAL USE IN ONLY 110K MILES. NOTHING BUT EXCUSES AND OTHER NOT POSSIBLE REASONS FOR THE POOR ENGINEERING AND MANUFACTURING EXHIBITED IN THEIR PRODUCT. THEY SAID THE METHANOL WATER INJECTION SYSTEM CAUSED THE FUEL INJECTION PUMP TO FAIL. METHANOL (NON CAUSTIC FLUID) IS INJECTED AIR SIDE OF THE ENGINE AND DOES NOT MIX WITH THE INJECTED FUEL UNTIL THE ENGINE CYLINDER. THE FUEL INJECTION PUMP SUPPLIES FUEL TO THE INDIVIDUAL INJECTORS THAT THEN IN TURN SUPPLIES THE HIGH PRESSURE FUEL TO THE CYLINDERS. IF THIS CONDITION WAS TO HAPPEN ON THE ROAD PULLING A TRAILER / HEAVY LOAD IN HILLS OR OTHER CONFINED ROADWAYS PEOPLE COULD BE INJURED OR KILLED BY THE SUDDEN LOSS OF POWER AND CONTROL. GM BUSINESS PRACTICES ARE GOING TO CONTINUE TO KILL AND HURT PEOPLE. *TR

BRAKE PEDAL PUSH TO THE FLOOR, OIL COMING OUT ONTO THE GROUND, BRAKE LINES RUSTED OUT IN MANY PLACES UNDER THE HOOD. *JS

HAD TO ADD COOLANT OVER A TIME.....NO EVIDENCE OF A LEAK ON MY DRIVEWAY OR ANY OTHER PLACE. STARTED TRUCK ONE MORNING AND HEARD CLICKING NOISE COMING FROM ENGINE. I OBSERVED WATER COMING FROM THE MUFFLER. TOOK VEHICLE TO DEALER ON APRIL 22, 2014. ( MILEAGE 84241) DEALER FOUND BLOWN HEAD GASKET AND SEALS, ONE CRACKED HEAD AND WATER IN OIL. REPAIRS DONE: COMPLETE VALVE JOB (REPLACE HEAD GASKET, SEALS & OTHER ASSOCIATED PARTS), REPLACE BROKEN BOLTS, REPLACE COOLANT HOSES, RADIATOR & HEATER HOSES AND THERMOSTAT ETC.. WAS NOT ADVISED BY SERVICE CONSULTANT OF ANY RECALLS OR BULLETINS FOR 2005 SILVERADO. THIS IS LOW MILEAGE FOR THIS KIND OF ENGINE PROBLEM. REPAIR COST: $3683.92 MARTIN CHEVROLET *** TORRANCE, CALIF. *TR

I WAS DRIVING HOME FROM WORK WHICH IS 1.5 MILES, WHEN I HEARD A THUMPING SOUND, AND IT SEEMED AS IF MY REAR WHEELS WERE NOT TURNING. I HAD A FRIEND TOW IT TO THE DEALER COX CHEVROLET IN BRADENTON, FL, AND THEY TOLD ME, THAT THE REAR END (SPIDER GEARS, AND BEARINGS) WERE NEEDING REPLACING BUT ARE NOT PART OF THE POWER TRAIN SO IT WAS NOT COVERED UNDER WARRANTY, AND IT WOULD COST ME $2600. I HAD HIM TOW IT AGAIN TO A LOCAL TRANSMISSION SHOP AND THEY TOLD ME IT WAS COMMON IN THAT YEAR OF CHEVY TRUCKS. I ALSO NEEDED BOTH CLUTCHES REPLACED IN EACH REAR WHEEL, COST WAS WELL UNDER THE DEALERS CHARGE. THE OWNER OF THE TRANSMISSION SHOP INFORMED ME THAT HE HAS REPLACED A COUPLE 100 OF THESE AND THERE SHOULD BE A RECALL ON THEM. I COULD HAVE BEEN IN AN ACCIDENT WHEN THE WHEELS LOCKED. *TR

WAS DRIVING DOWN ROAD LOOKED DOWN AT MY SPEEDOMETER AND IT WAS PEGGED OUT OVER 120 MPH I WAS ONLY GOING ABOUT 15MPH SO I STOPPED AND TURNED OFF TRUCK AND SPEEDOMETER WENT DOWN TO 60 NOT 0 AS IT SHOULD I TURNED IT BACK ON AND TOOK OFF IT DID SAME THING ALL WAY OVER 120 MPH SO WHEN I GOT WHERE I WAS HEADING AND TURNED TRUCK OFF AGAIN SAME THING JUST DROPPED TO 60 SO I KEPT TURNING KEY ON AND OFF AND IT WOULD DROP ABOUT 5MPH EACH TIME UNTIL IT GOT TO 0 WENT TO DEALER HE SAID LOT OF PROBLEMS WITH THIS MODEL TRUCK I WOULD NEED A NEW DASH AND IT WOULD COST ME $1200 I THINK GM SHOULD FIX THESE TRUCK IT THE LAW TO HAVE A WORKING SPEEDOMETER ON YOUR TRUCK THANK YOU. *TR

REAR BRAKE LINE APPEARED RUSTY AND SCALY, THEN WHEN HIT MY BRAKES, THE PEDAL WENT TO THE FLOOR. I USED EMERGENCY BRAKE. I REPLACED REAR BRAKE LINE. ALL OTHER LINES APPEARED RUSTY AND SCALY. NOW, MY FRONT LEFT BRAKE LINE IS BEGINNING TO WEEP; IT'S MOIST AND IT GLISTENS WITH OIL. I WILL HAVE TO REPLACE IT SOON. ALL THE OTHER LINES IN THE TRUCK APPEAR TO BE THE SAME, RUSTY AND SCALY. I WILL NO DOUBT HAVE TO CONTINUE TO REPLACE EACH LINE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE ROTORS NEEDED TO BE REPLACED ON A REGULAR BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS NOT ABLE TO DIAGNOSE THE MULTIPLE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1000.

WAS ON HIGHWAY WHEN HEARD A NOISE AND PULLED OVER TO SEE A DOUGHNUT FOR A TIRE AND RUBBER PIECES TIED AROUND TAILPIPE,_E-BRAKE AND OTHER PARTS UNDERNEATH. DAMAGED REAR PANEL THE MILEAGE AT THE TIME WAS 30100MILES COULD'VE CAUSED A BAD ACCIDENT. ALSO BROKE A CLUSTER LOST ALL METERS ON DASH. *TR

THE LOW COOLANT LIGHT WENT ON. THE ONLY WAY TO FILL THE SYSTEM IS TO OPEN THE RESERVOIR CAP. UNFORTUNATELY BECAUSE THE ENGINE HAD A HEAD GASKET FAILURE THE COOLING SYSTEM WOULD NOT DEPRESSURIZE, EVEN WHEN COLD. IT SEEMS TO ME THAT THERE SHOULD BE A PRESSURE CAP THAT WHEN THE ENGINE OVERHEATS IT ALLOWS THE COOLING SYSTEM TO DEPRESSURIZE. THIS CLOSED SYSTEM IS VERY DANGEROUS ESPECIALLY WHEN SOMEONE WHO IS USED TO FILLING THE OVERFLOW TANK WHEN THE COOLANT IS LOW. BECAUSE THE LACK OF AN OVER FLOW TANK ANYONE THAT OPENS THE PLASTIC RESERVOIR COULD BECAME BURNED. *TR

2005 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEM AND REQUESTS VEHICLE RECALL INFORMATION. *SMD THE CONSUMER STATED THE PUSH BUTTON 4-WHEEL DRIVE BUTTON HAS NEVER WORKED PROPERLY. *JB

INSTRUMENT CLUSTER FAILURE. ODOMETER MILEAGE WIPED CLEAN. DISPLAY READS "ODOMETER ERROR". *TR

BRAKE LINES RUSTED OUT. TRUCK FAILED TO STOP WITHIN A SAFE DISTANCE ON THE HIGHWAY. BRAKE LINE GAVE OUT ON THE HIGHWAY NO WARNING AT ALL. JUST A SOFT, NON FUNCTIONING PEDAL. LUCKILY I WAS ABLE TO PULL THE TRUCK OVER TO THE SIDE OF THE ROAD NO ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT WAS ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC THAT DETERMINED A SENSOR INSIDE THE FRONT BUMPER WAS THE CAUSE OF THE DEFECT. THE CONTACT ALSO REPORTED THAT THE DRIVER'S SIDE REAR BRAKE LINE WAS RUSTED AND RUPTURED, WHICH CAUSED THE REAR BRAKES TO BECOME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS ADVISED THAT THE PARTS WERE ON A NATIONAL BACK ORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 102,000. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AND DEPRESSING THE BRAKES, THE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000.

THIS IS PROBLEM(S) THAT HAS BEEN INTERMITTENT FOR A COUPLE A YEARS SHORTLY AFTER I PURCHASED THE VEHICLE BUT DID NOT MENTION ANYTHING BECAUSE IT WAS SO INTERMITTENT....FIRST THE ILLUMINATION LEVEL SEEMED TO DIM EVERY ONCE IN A WHILE FOR MANY AREAS SUCH AS THE GEAR (PRND), THE SPEEDOMETER, THE TEMP CONTROL LEVELS. NEXT THE SPEEDOMETER DID NOT REFLECT CORRECT SPEED SOMETIMES EVEN WHEN YOU WERE PARKED. THESE SYMPTOMS WERE INITIALLY INTERMITTENT BUT NOW ARE MORE PREDOMINANT. NOW THIS AT TIMES IS A REAL PROBLEM AND EVEN A SAFETY ISSUE. *TR

APPROACHING A 4 WAY TRAFFIC SIGNALED INTERSECTION WHEN SIGNAL STARTED TO CHANGE TO YELLOW. DECIDED TO NOT PROCEED THROUGH INTERSECTION SO APPLIED BRAKE PEDAL TO STOP. PEDAL WENT DIRECTLY TO FLOOR, BRAKE DASHBOARD LIGHT ILLUMINATED. VEHICLE WOULD NOT STOP AND PROCEEDED THROUGH INTERSECTION, WHILE VEHICLES TO MY RIGHT PROCEEDED TO MOVE. I HAD NO BRAKES AT ALL. I MANEUVERED VEHICLE ONTO A PARALLEL ACCESS ROAD AND VEHICLE EVENTUALLY ROLLED TO A STOP. UPON INSPECTION IT WAS OBVIOUS THAT THERE WAS A FAILURE OF THE BRAKING SYSTEM, AS HYDRAULIC FLUID WAS ON THE ROAD IN THE VICINITY OF THE RIGHT FRONT OF THE VEHICLE...ONLY... I WAS ALWAYS AWARE THAT I HAD SOME BRAKING CAPACITY WHEN I HAD A BRAKE FAILURE. FOLLOWING 8 DAYS AT A GM DEALERSHIP AND A BILL FOR $2,000, THE BRAKE LINES WERE REPLACED FOLLOWING THE DIAGNOSIS "RUSTED/CORRODED BRAKE LINES". A COMPLAINT TO GM HAS FALLEN ON DEAF EARS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE GEAR POSITION INDICATOR LIGHTING FAILED TO ILLUMINATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

I WAS DRIVING MY TRUCK INTO MY DRIVEWAY WHEN I PUT MY FOOT ON BRAKE PEDAL IT WENT TO FLOOR , NO WARNING. WHEN I LOOKED UNDER VEHICLE BRAKE LINE WAS LEAKING, VERY RUSTED. *TR

REAR STEEL BRAKE LINE CORRODED AND BLEW OUT CAUSING BRAKE FAILURE. THIS HAS HAPPENED TO FOUR PEOPLE I KNOW. ONE OF THOSE PEOPLE HAD A BAD ACCIDENT. ALL VEHICLES WERE CHEVY SILVERADOS. *TR

ON OUR 2005 CHEVY SILVERADO 2500 HD THE ABS SYSTEM HAS BEEN KICKING IN WHEN COMING TO A STOP AND YOU ALMOST HIT THE CAR IN FRONT OF YOU. I HAVE READ A LOT OF ISSUES WITH THIS AND I HAVE NOT SEEN A RECALL FOR THIS YEAR OF THE CHEVY TRUCK. THE RECALL ONLY STOPS AT 2002 TRUCKS. HOW MANY PEOPLE HAVE TO BE INJURED OR KILLED BEFORE YOU GUYS DECIDE TO RECALL THIS YEAR OF THE CHEVY TRUCK???? *TR

THE FIRST INCIDENT OCCURRED IN AUGUST 2013. WHEN BACKING UP (AT APPROXIMATELY 5 MPH), I STEPPED ON THE BRAKES AND THE BRAKES FAILED. THE BRAKE LINE WAS REPLACED OVER THE RIGHT SIDE OF THE REAR END HOUSING. ON OCTOBER 3, 2013, ANOTHER BRAKE LINE FAILED CAUSING THE BRAKE PEDAL TO GO TO THE FLOOR OF THE TRUCK. THIS TIME THE BRAKE LINE IS ON THE LEFT SIDE OF THE FRAME UNDER THE DRIVER'S COMPARTMENT. *TR

THE BRAKES WENT OUT BACKING IN TO A DRIVEWAY AND ALL THE FLUID LEAKED ON TO THE DRIVEWAY AND STREET. THIS COULD OF BEEN VERY SERIOUS IF IT HAPPENED ON THE HIGHWAY COMING HOME FROM PICKING UP FURNITURE. ALL THE BRAKE LINES WERE RUSTED AND HAD TO BE REPLACED?????? COSTLY FOR US? *TR

I WENT TO SLOW TO MAKE TURN AND BRAKES WENT TO THE FLOOR SUDDENLY SO I USED EMERGENCY BRAKE TO STOP. I BELIEVE ALL LINES WILL NEED TO BE REPLACED AS OTHER LOOK AS RUSTY. RUST HAS BEEN AN ISSUE FOR LAST 2 YEARS WITH ROTORS NEEDING REPLACE THEN BEARINGS IN FRONT RUSTED AND ANTI-LOCK BRAKE LIGHT WOULD COME ON AND PEDAL WOULD SURGE. THIS IS THE WORSE CHEVY TRUCK I EVER BOUGHT AS EVEN SEEING RUST ALREADY IN LOWER PANELS AND ENTIRE FRAME. LOOKS BAD FOR ONLY 53,474 MILES. *TR

DRIVING BACK TO WORK FROM LUNCH ON BUSY 4 LANE HIGHWAY, BRAKE PEDAL WENT TO FLOOR. NARROWLY AVOIDED A COLLISION AT A RED LIGHT. PUT FLASHERS ON, LOWERED THE GEAR SELECTOR, AND USED COMBO OF MINIMAL BRAKE PEDAL AND E BRAKE TO MAKE IT BACK TO THE PARKING LOT AT WORK. UPON INSPECTION, LARGE PUDDLE OF BRAKE FLUID ON DRIVER SIDE NEAR GAS TANK. LARGE LEAK IN HIGHLY CORRODED BRAKE LINE. ALL BRAKE LINES IN SIMILAR CONDITION AND ARE CURRENTLY BEING REPLACED IN THE SHOP. TRANSMISSION LINES AND FUEL LINE ARE IN SIMILAR HIGHLY CORRODED CONDITION. *TR

WHILE DRIVING, LOUD BANG. LOOKED UNDER TRUCK, DRIVER'S SIDE REAR LEAF SPRING SHACKLE HAD ROTTED OFF AND THE LEAF SPRING BUSTED THROUGH THE BED OF THE TRUCK. 2 WEEKS LATER, A BANGING ON THE UNDER SIDE OF BED. LOOK UNDERNEATH AND THE DRIVER'S SIDE REAR SHOCK MOUNT HAS RUSTED OFF THE FRAME. NOT EVEN SURE THERE IS ENOUGH METAL LEFT TO WELD OR PUT ON A NEW MOUNT! THE REAR CROSS MEMBER THAT HOLDS THE SPARE TIRE IS NON-EXISTENT. IT HAS RUSTED AWAY. THE BODY OF THE TRUCK IS IN GREAT SHAPE. IT IS JUST THE FRAME AREA AND MOUNTS THAT ATTACH TO IT. I HAVE OWNED THIS TRUCK SINCE IT WAS NEW, IT HAS NEVER BEEN OFF ROAD AND HAS BEEN KEPT IN EXCELLENT RUNNING CONDITION. THIS SEEMS TO BE AN ONGOING PROBLEM WITH GM. I HAVE SEEN MANY COMPLAINTS AND HOPES THAT THE NHTSA TAKES NOTICE AND ACTION. *TR

MY AIR BAG SENSOR MALFUNCTIONED. THIS IS A PART THAT SHOULD BE GUARANTEED BY GENERAL MOTORS. INSTEAD I PAID OVER $500 DOLLARS TO HAVE IT REPAIRED AT A DEALERSHIP. 64K MILES / 8 YEARS AND THE AIR BAG SENSOR NEEDS TO BE REPLACED? I SEARCHED ONLINE AND NOTICED MANY OTHERS ARE HAVING THIS PROBLEM. GM GOT A GOVERNMENT BAILOUT AND SHOULD BE REQUIRED TO PAY FOR THIS REPAIR. *TR

BRAKE PEDAL WENT TO FLOOR. BRAKE LINE ABOVE GAS TANK RUPTURED. *TR

SERVICE AIRBAG LIGHT ON. *TR

I HAD A SOFT BRAKE PEDAL ON MY 2005 SILVERADO. I THOUGHT I HAD A BAD MASTER CYLINDER. I WORK AT AN AUDI DEALERSHIP AND I WAS BRINGING THE VEHICLE TO WORK TO CHECK IT OUT. AS I APPROACHED THE DRIVEWAY TO WORK, THE BRAKE PEDAL WENT TO THE FLOOR. I USED THE EMERGENCY BRAKE TO SLOW DOWN AND PULL INTO,THE DRIVEWAY. WE INSPECTED THE VEHICLE AT WORK AND FOUND THAT A STEEL BRAKE LINE UNDER THE DRIVERS SIDE THAT RUNS ALONG THE FRAME RAIL HAD A HOLE IN IT DUE TO RUST. I FIND THIS COMPLETELY UNACCEPTABLE THAT A STEEL BRAKE LINE RUST THROUGH. CHEVROLET USED A POOR MATERIAL ON THEIR BRAKE LINES. I HAVE BEEN IN THE AUTOMOTIVE BUSINESS FOR 31 YEARS IN CONNECTICUT ( YES, SALT IS USED ON THE ROADS ) AND HAVE WORKED FOR FORD, VOLVO, HUMMER AND AUDI. I HAVE NEVER SEEN A BRAKE LINE RUST THROUGH. CHEVROLET NEEDS TO FIX THIS ISSUE AT THEIR EXPENSE AND NOT THE CONSUMERS. THE DEALERSHIP WANTS $1500.00 TO REPAIR USING THE SAME BRAKE LINES. I HAVE PURCHASED STAINLESS STEEL LINES AND WILL PERFORM THE REPAIRS AT MY SHOP . *TR

UPON STARTING THE TRUCK FOR THE FIRST TIME ON 6-11-2013 THE "SERVICE AIR BAG" LIGHT CAME ON AND HAS STAYED ON. THERE IS NO REASON FOR THE FAILURE OTHER THAN POOR CRAFTSMANSHIP. *TR

I PURCHASED A 2005 CHEVY SILVERADO IN LATE 2010 FROM A CHEVY DEALER (TOM CLARK CHEVROLET IN MCKEESPORT, PA). APPROXIMATELY JUNE 7, 2013, MY SPEEDOMETER WENT CRAZY STICKING ON 0, 100, OR 120 ... REGARDLESS OF MY SPEED. I CONTACTED THE DEALER MONDAY JUNE 10, 2013 AND WAS TOLD TO BRING IT IN FOR THEM TO LOOK AT IT. I TOOK MY VEHICLE IN TO TOM CLARK AT 7:55 A.M. ON TUESDAY JUNE 11, 2013 AND RECEIVED A PHONE CALL FROM THEM AT APPROXIMATELY 8:45 A. TELLING ME THAT THE ISSUE IS THE CLUSTER AND HE AGREED THAT THIS ISSUE IS THE EXACT ISSUE THAT WAS RAISED IN THE GM LAWSUIT BUT STILL TOLD ME THAT THEY WOULD NOT FIX THE PROBLEM. (I ONLY BECAME AWARE OF THE GM LAWSUIT OVER THE WEEKEND OF JUNE 7, 2013, WHILE SEARCHING THE INTERNET TO TRY AND FIND OUT WHAT COULD BE WRONG WITH MY VEHICLE). HE THEN INFORMED ME THAT THEY WOULDN'T FIX IT BECAUSE THE WARRANTY/RECALL EXPIRED LAST YEAR (2012), SO HE DOES ACKNOWLEDGE THAT A PROBLEM EXISTS AND HAS EXISTED. I PURCHASED THIS VEHICLE AFTER ALL THE ISSUES WITH THEM SURFACED AND A LAWSUIT HAD ACTUALLY TAKEN PLACE AND THEY SOLD ME THIS TRUCK, KNOWING THERE WAS A PROBLEM AND DIDN'T INFORM ME OF THE PROBLEM. NOW THEY ARE TELLING ME THAT IT WILL COST $550.00 TO FIX IT. MY VEHICLE HAS 49,809 MILES ON IT, IT'S A THIRD VEHICLE THAT'S HARDLY EVER USED AND THERE IS NO EXCUSE FOR THE DISHONEST PRACTICES OF TOM CLARK WHERE THIS MATTER IS CONCERNED. THEY SOLD ME A VEHICLE WITH A DEFECTIVE PART, WHILE A LAWSUIT WAS EITHER PENDING OR HAD BEEN RESOLVED, AND STILL FAIL

BRAKE LINE BURST DUE TO CORROSION CAUSING LOSS OF REAR BRAKES. I HAVE SINCE HAD THREE MORE BRAKE LINES (COMPLETELY DIFFERENT LINES) START TO LEAK DUE TO CORROSION CAUSING LOSS OF REAR BRAKES AGAIN AND THEN FRONT BRAKES. THE BRAKE LINES ARE SEVERELY CORRODED WHICH IS UNUSUAL ON A VEHICLE WITH LOW MILEAGE AND LESS THAN 10 YEARS OLD. *TR

UPON STARTING TRUCK IN MORNING, "SERVICE AIR BAG" MESSAGE CAME ON. TOOK TO DEALER WHO SAID THE L FRONT IMPACT SENSOR FAILED AND NEEDS TO BE REPLACED $400+. COST SEEMS EXCESSIVE AND THE SAFETY SYSTEM FAILURE, IF THAT IS WHAT IT REALLY IS, SHOULD NOT BE MY RESPONSIBILITY. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, HE DEPRESSED THE BRAKE PEDAL BUT THE BRAKES WERE HESITANT TO RESPOND. THE CONTACT INSPECTED THE VEHICLE AND NOTICED CORROSION AND BRAKE FLUID LEAKING FROM THE BRAKE LINES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

COMING HOME AFTER A NIGHT OF BOWLING WITH A TRUCK FULL OF KIDS. I COULD FEEL AND HEAR A GRINDING NOISE COMING FROM THE FRONT END. I THOUGHT IT WAS MY BRAKES UNTIL I GOT BACK INTO TOWN. WHEN I HIT THE BRAKES AND MOVED THE STEERING WHEEL BACK AND FORTH I COULD I KNEW IT WASN'T MY BRAKES. I TOOK THE FRONT TIRE OFF THE NEXT DAY AND I COULD WIGGLE THE WHEEL HUB BACK AND FORTH. VERY DANGEROUS. I FEEL LUCKY THAT NOBODY GOT HURT. THE ROAD I TRAVELED HOME WAS HWY 32 AND IT HAS ALOT OF CURVES. THIS SHOULD BE ADDRESSED. EVERY CHEVY THAT HAS THIS PROBLEM SHOULD BE NOTIFIED. IM A BACK YARD MECHANIC. I KNEW SOMETHING WAS WRONG. WHAT HAPPENS WITH THE SINGLE MOTHER WHO KNOWS NOTHING ABOUT THIS STUFF. SHE'S GOING TO BE LUCKY IF SHE DOESN'T GET IN AN ACCIDENT OR WORSE YET. KILLED! *TR

I WAS DRIVING AND APPLIED THE BRAKES FOR A STOPLIGHT WHEN I FELT A SUDDEN LACK OF RESISTANCE IN THE PETAL. NO WARNING LIGHTS WERE ACTIVATED AT ALL. I PULLED OVER AND PUMPED THE BRAKES A FEW TIMES AND NO PRESSURE WAS REGAINED. I GOT OUT OF THE TRUCK AND NOTICED A PUDDLE OF BRAKE FLUID TOWARDS THE REAR. UPON FURTHER INSPECTION ALL OD THE BRAKE LINES WERE RUSTED BADLY AND ONE HAD RUPTURED. NO WARNING LIGHTS EVER CAME ON DURING THE WHOLE ORDEAL. THE TRUCK IS UNDER 8 YEARS OLD AND ALL OF THE BRAKE LINES NEED TO BE REPLACED. LUCKILY I WAS NOT IN TRAFFIC OR TRAVELING FASTER WHEN THIS OCCURRED. I HAVE NEVER SEEN MORE RUST ON A NEWER VEHICLE IN MY LIFE. OBVIOUSLY THE RUST IS BEYOND COSMETIC AND HAS PROVEN TO BE A HAZARD. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE THE BRAKE PEDAL DEPRESSED HE NOTICED THAT THE BRAKE PEDAL FELL TO THE FLOOR BOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE FRONT BRAKE LINES WERE CORRODED AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 9 MPH, THE CONTACT ATTEMPTED TO DECELERATE BUT STOPPING POWER GREATLY DECREASED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND WAS INFORMED THAT THE TWO FRONT ABS SENSORS HAD BECOME CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 15,669 AND THE CURRENT MILEAGE WAS 65,500. THE CONSUMER STATED THE SERVICE DID NOT COME OUT UNTIL AFTER THE VEHICLE WAS OUT OF WARRANTY, THEREFORE; THE DEALER AND MANUFACTURER REFUSED ASSISTANCE. STOPPING DISTANCE WAS INCREASED BY AT LEAST 2 VEHICLE LENGTHS. *JS

FUEL EVAP SYSTEM MALFUNCTIONING NOT ALLOWING FUEL SYSTEM TO VENT THUS MAKING IT ALMOST IMPOSSIBLE TO REFUEL THE VEHICLE. THIS ALSO RESULTS IN A CHECK ENGINE LIGHT TO OCCUR. THE DEALERSHIP FOUND A BULLETIN ON THIS PROBLEM: DTC P0446 (RESTRICTED/BLOCKED EVAP VENT PATH) SET, CHECK ENGINE LIGHT ON (REPLACE EVAPORATIVE EMISSION (EVAP) VENT VALVE SOLENOID ASSEMBLY AND ADD/RELOCATE FILTER BOX USING SERVICE KIT). THIS SEEMS TO BE A COMMON AND RECURRING ISSUE AND THE REPAIR IS TO NOT ONLY REPLACE THE PART, BUT CHANGE THE EXISTING DESIGN OF THE SYSTEM. WHY IS THIS NOT A RECALL WHERE THE MANUFACTURER FIXES THE PROBLEM SINCE IT IS OBVIOUSLY AN ENGINEERING PROBLEM? I HAVE READ MANY BLOGS THAT INCLUDE ALMOST NEW VEHICLES WITH THIS SAME PROBLEM. *TR

I WAS DRIVING SOUTH ON I-95 ON THE NEW JERSEY TURNPIKE AND SLOWED DUE TO TRAFFIC AND BRAKES WENT TO THE FLOOR. I PUMPED THEM SEVERAL TIMES AND PUT ON THE EMERGENCY BRAKE AND LUCKILY STOPPED BEFORE HITTING ANYONE. I HAD MY WHOLE FAMILY IN THE CAR, WIFE, 4 KIDS AS WE WERE HEADING TO MARYLAND FROM CONNECTICUT TO VISIT FAMILY FOR CHRISTMAS. I PULLED OVER AND WAS ABLE TO STOP AGAIN BUT THE BRAKES NEVER FELT QUITE RIGHT AGAIN. I HAD WARNING LIST COME ON SEVERAL TIMES AND HAD TO KEEP ADDING BRAKE FLUID. WHEN I INSPECTED THE LEAK IT WAS UNDER THE DRIVERS DOOR RIGHT WHERE THE LINES SIT IN THEIR PLASTIC HANGER. I ALSO NOTICED ALL THE OTHER LINES WERE SHOT AS WELL (AS IN RUSTED). THIS IS MY FAMILY CAR AS I USE IT FOR WORK AND EVERY TIME WE GO OUT AS A FAMILY AS WELL AS DRIVE KIDS TO SCHOOL ETC..... I AM AMAZED AT THE CORROSION LEVEL AND AM CURRENTLY ATTEMPTING TO REPLACE THE LINE THAT IS LEAKING, BUT JUST A SMALL PORTION OF IT. AFTER READING THE COMPLAINTS ASSOCIATED WITH THIS VEHICLE AND BRAKE LINE CORROSION, I HOPE YOU DO SOMETHING! AS THANK GOODNESS I AM A CAREFUL AND CONSCIENTIOUS DRIVER BECAUSE IF I WAS GOING ANY FASTER (FASTER THAN 35 MPH ON A 65 MPH HIGHWAY) I WOULD HAVE CAUSED A CRASH. SUFFICE TO SAY WE HAD TO USE RELATIVES CARS TO TRAVEL AND THEN CAREFULLY PLAN THE TRIP HOME WITH LOTS OF BRAKE FLUID AND CONSTANT STOPPING TO AVOID HOLIDAY SEASON TRAFFIC. NOT A GOOD SCENARIO! *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED A CLUNKING NOISE FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC ADVISED THAT THE INTERMEDIATE STEERING SHAFT WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR) THAT THE CONTACT BELIEVED WAS RELATED TO THE FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.

WHILE DRIVING NORMALLY I NOTICED MY SPEEDOMETER GIVING ERRONEOUS READINGS AS HIGH AS 120 MPH, AND UPON STOPPING, THE SPEEDOMETER STAYED AT THE 35 MPH. POSITION. AFTER A FEW DAYS, IT RETURNED TO NORMAL. OCCASIONALLY, THE SPEEDOMETER DOES NOT WORK FOR DAYS AT A TIME. I FEEL IT IS DANGEROUS DRIVING WITH A SPEEDOMETER WHICH IS NOT RELIABLE. GM HAS REFUSED TO FIX THE PROBLEM AND TOLD ME I AM FULLY RESPONSIBLE FOR ALL PARTS AND LABOR COSTS BECAUSE MY VEHICLE IS OUT OF WARRANTY. NOW, THE VOLT-METER ALSO DOES NOT WORK AND THE NEEDLE POINTS DOWN AT A "6 O CLOCK" POSITION WHICH IS OFF THE CHART. THIS HAS BEEN BROKEN FOR SEVERAL WEEKS NOW. *TR