2020 Chevrolet Silverado 1500 complaints

Just hit 65k miles and have had a transmission issue where it shutters back and forth and was quoted 6k to repair it

There was a significant oil leak that was diagnosed during a routine oil change in March of 2025. The dealership that identified the leak attempted to pass it off as something that was out of warranty even though the vehicle had an additional six months and 45,000 miles of warranty (3.0 diesel). The leak was significant enough that loss of oil could cause the engine to fail and result in a crash. Subsequently, another dealership identified the leak and repaired the seal around the lower crankcase. It did not repair the oil leak- there are three additional reports/complaints to file.

This is for the second oil leak that occurred in the 2020 Chevrolet Silverado with the 3.0 diesel engine. It was identified as a leak in the oil pan. The previous repair was for the lower crankcase seal. The service advisor at the dealership stated this is another problem area with the Chevrolet 3.0 diesel engine, and a defect from the manufacturer. He also mentioned it is a common repair they complete on these LM2 engine. It is worth noting, the initial repair didn't last 60 days before another oil leak presented itself. This is the second of four repairs that were done on this vehicle. **No loaner vehicle was given during the repair.**

The second oil leak repair and the first repair for the oil pan failed within one week of the previous repair. This is the third oil leak that occurred in the LM2 engine in the 2020 Silverado. It was identified as an additional leak in the oil pan which had already been repaired the week prior. This is a failure within seven days from the previous repair. I lost 1/2 quart of oil during a 650-mile drive back from vacation. I took pictures of the oil level before leaving and driving home. During our drive, we passed through an area called Yermo where it was 107 degrees at 11am. The two closest Chevrolet dealerships are either 45 minutes or 1.5 hours one-way. I was incredibly frustrated since imagine being stranded in 107-degree weather with your family on the side of the road unable to run AC. It is a serious life, health, and safety issue at this point. I called GM and opened a case expecting them to assist me with the issues with the truck. Fast forward to today, I spoke with Jill at GM, they closed the case without even reaching out to me. This was the third of four oil repairs that have been conducted on my vehicle and the LM2 engine. It isn't a safe engine to have. **No loaner vehicle was given during the repair.**

After three oil leak repairs in my LM2 3.0 diesel engine in my 2020 Chevrolet Silverado RST, you would think that would be enough to repair the manufacturer's defects, but it wasn't. I think the saying is fourth time is the charm? The third repair which was a second oil pan lasted a whopping 48 hours before leaking. This time it ended up being the timing chain cover that was leaking. Again, the service advisor mentioned that these are known to leak too due to a defect from the manufacturer. I even got a call from the service manager, and he said that anything area that could and does leak oil on these LM2 engines has been replaced and/or repaired, so I should be good for the future. I called into GM as per their instructions to update them on the fourth oil leak, and where the repairs were taking place. Fast forward to nearly two months later, and no one from GM attempted to contact me, and Jill stated that the case was closed and wouldn't disclose why. The only thing she could do was open another case. I declined since GM couldn't be bothered to address the issues they know they have in the LM2. The dealership the work was done in, the service advisors, the service techs, and the service manager all discussed in great detail the issues Chevrolet is having with the 3.0 diesel engine. GM knows this and refuses to address this. At this point, my vehicle spent 37 days in 2.5 months at the dealership fixing oil leaks that at any time could have caused engine failure and resulted

When it gets hot it'll lose power at the pedal and it will randomly come back causing the drive train to jerk back and forth throwing full related codes that go away once the truck has cooled off. Took it to a shop and they couldn't get it to throw a code. This will be the third time it has happened. This time it doesn't throw a code

Lose of power at the pedal again not even 15 mins later. Still no code. Just extremely frustrating

Motor suddenly loss power and load knocking noise. After taking it to the dealer they said that number 3 cyl.connecting rod had an issue . This sounds like the same recall for the 2021 to 2024 6.2 engines. They gave me a quote for a new engine ( 20000) that was not available for 4 to 5 weeks if not more. I was on vacation at the time and ended up buying a new truck from them. I was not happy.

Rear window is leaking onto the carpet beneath it creating mold and could allow water to enter the SRS module. Currently i have a tray blocking that water but without that the SRS system could be affected by the water entering the cabin through the rear window.

Rear brake inner pads completely worn while outer pads look brand new at 35,000 miles. This appears to be due to the electronic parking brake not releasing quick enough but this condition almost disables the rear brakes and could cause an accident.

Shop has had the truck over two months and cannot figure out the problem will not go stuck in limp mode.

Defective 8-speed automatic transmission (RPO MQE, 8L45) in my 2020 Chevrolet Silverado 4x2 (VIN: [XXX] , 102,000 miles), purchased used from CarMax Orlando (6375 S Semoran Blvd, Orlando, FL 32822). The vehicle required a $5,950 repair at AAMCO Winter Haven (1350 6th St NW, Winter Haven, FL 33881) due to persistent transmission issues, including shuddering, jerking, or delayed shifting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Lost power steering in the middle of a corner..Almost but me into pole ..No warning..later on warning came on.Truck has 32000 miles on it

The Rear Window leaks when it rains on the truck. I brought it back to the GM Chevy dealer and they applied a sealant. it immediately leaked right after. the truck now smells musty and im assuming there is mold growth. it has been at the dealership for the past two weeks while they try to figure it out

No power steering alert showed up to service power steering. Very dangerous driving and power steering goes out.

Initially, turbo charger issues. Dealer after 2 weeks corrected issues with the turbo charger. We were provided loaner. Dealer took 28 days, the second time, to supposedly remedy Transmission/shifting issues. First we were told it was a valve port body. Then we were told they had to remove the pan, etc., all part of the process. Then the parts were on backorder. Finally, at the 11th hour, they installed a rebuilt transmission. Without a loaner for 2 weeks. Got the truck back and within 24 hours, the truck suddenly lost power steering while driving around curve at aprox.30 to 35 mph., check engine light on, power steering light on, trailer brakes warning light on, etc. Had it towed back to dealer in the morning and told it would be a priority. Called at 5pm. Truck has not been seen. It's not a car. It's a work truck. Seems the dealership is swamped with silverado trucks with similar transmission issues waiting for valve ports. No loaner vehicles to be had the second time after 2 weeks. Not sure what they will tell us tomorrow.

Lifter failure on the 5.3L L84 engine. Due to Dynamic fuel management that come with the trucks.

Having failure with the engine coolant control valve. Have taken my truck to the dealership for overheating and they always come and say that they can’t find an issue. They also informed me that I need to bring it back when my motor blows a head gasket which is complete bull.

There is an issue with the wiring harness that causes vehicle to lose power. Dealership says manufacturer defect because designed with harness cover is too thin and is to close to engine so burns wires. Many other users have complained of this issue and is frequent in this model.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while at a complete stop and depressing the accelerator pedal, the vehicle jerked. The check engine warning light was illuminated. The vehicle was taken to an unknown dealer, where it was diagnosed that the transmission was shifting hard. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. The contact was referred to the NHTSA Hotline to file a vehicle safety complaint. The failure mileage was approximately 40,000.

About 3 months after the 5 year 100000 mi warranty with only 70000 miles on the duramax diesel engine the exhaust brake part of the engine emissions/exhaust split along the weld. Have seen a number of these reported on the internet as well. Sounds like a manufacturing problem. The vehicle's check engine light came on and it's now at the dealership getting a new exhaust brake housing and bracket replaced. If this was in California or the 12 states listed would be covered for 8yrs/100000 miles.

Tranmission rebuild at 70000 miles

Engine seized my truck has been at the Chevorlet Tempe dealership I filed a claim with GM still no response.

I had the lifters and camshaft fail in my truck as a result of the faulty fuel management system GM put in these trucks during these years of manufacturing. I was driving my kids to an appointment when they failed in the middle of the highway, leaving the truck unable to run. I have reported the problem to the dealer as well as reported to GM directly. I have spoken with 3 different garages, all of which have made it a point to tell me this is a common issue in these trucks. Prior to this happening, there were no lights on to warn me of this problem. The repair cost is $12,000 and that is to put the same parts in the failed the first time. I don’t know many consumers that can afford the costs of these repairs when GM knows this is an issue but refuses to do anything about it.

Having transmission issues like other silvardos but not included in recall

Having transmission problems but include in recalls like other silverados

My 2020 Chevrolet Silverado 1500 LT with the 3.0L Duramax diesel engine has experienced three separate failures of the coolant control valve over a span of less than two years. Each failure resulted in the vehicle entering reduced engine power mode, which drastically limits acceleration and the ability to maintain safe driving speeds — particularly dangerous on highways or in heavy traffic. Chronology of Failures: October 2023: First coolant control valve failure. Part was backordered. Repair took ~6 weeks. June 2024: Second failure of the same part. Another 6-week delay in repair due to part availability. June 2025: Third failure of the same part. Vehicle is currently inoperable and unsafe to drive. Each time, the failure triggered a check engine light and immediately placed the truck into reduced power mode. This issue significantly compromises driver safety, especially in high-speed or congested environments, where limited acceleration can increase the risk of collisions. Safety Concerns: Loss of acceleration power at critical times (merging, overtaking, etc.) Unpredictable vehicle behavior Extended unavailability of parts leads to prolonged periods without a functional vehicle Possible underlying design flaw or recurring part defect Given the recurrence, safety risks, and the number of similar complaints I have seen from other owners, I believe this is a widespread and systemic defect that deserves NHTSA investigation. Requested Action: I urge the NHTSA to investigate the

Transmission is sputtering when trying to shift. Mostly at low speeds it's extremely jerky like it doesn't want to go. Had Transmission fluid and filter changed, but it did not help.

Lifter failure and miss fire

I was driving and came to a stop at a red light. When accelerating on green the transmission would not go into gear, stalling my vehicle. Nearly causing the vehicle behind me to rear end me. The vehicle eventually went into gear and started to slowly accelerate with shuttering of the transmission.

2020 Chevy Silverado LTZ 6.2 V8 10 Speed. Started having issues with hesitation/shudder. Dropped off at a Chevrolet dealership for a diagnostic. The dealership pointed to a potential transmission issue. After having the truck for several days, they reported nothing wrong. Said they drove the truck, checked the transmission fluid, and couldn't find any issues. Picked up the truck and took it to a local repair shop. That shop drove it, but could not re-create the issue I was describing. I opted to have the transmission fluid flushed in hopes of fixing the shudder/hesitation I was feeling. After picking up the truck and driving it a couple hundred miles, the issue was still present. I made another appointment at the same local shop. This time, they called me saying the issue I'm feeling is the same problem that's been happening to these engines, the dreaded AFM (Active Fuel Management) system is starting to fail. I was told by the shop it's only a matter of time before the entire engine fails. The only way to fix the issue is to delete the AFM system by removing the old parts within the engine and replacing with new parts that do not use the AFM system. This would cost approximately $6,000 to complete.

Was driving on the interstate on [XXX]. While driving, the truck suddenly slowed down and lost power. The check engine light came on and then after about a minute a message popped up on the dash saying that the truck was in reduced-power mode to prevent engine damage, or something like that. It slowed to roughly 50mph and I had to drive for maybe 5 miles to reach the next exit, narrowly avoiding collision from behind with cars driving upwards of 75. Pulled off the road to the first parking lot, then got towed to the nearest Chevy dealership in Shawnee, Oklahoma. The diagnosis was a blown connecting rod that had occurred while driving on the interstate, resulting in a necessary total engine replacement. The truck was repaired in Shawnee, Oklahoma at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my truck the engine completely shut down. All the dash lights came on initially but then only the check engine light stayed on. My truck never would start back up after that. It was towed to GM dealership who diagnosed catastrophic engine failure.

Odometer Fraud. The contact was attempting to purchase a 2020 Chevrolet Silverado 1500. The contact stated that while attempting to obtain a loan from the bank for the vehicle, it was discovered that there was a mileage discrepancy after obtaining a Carfax report. The vehicle was a private sale. At the time of the initial inquiry on Facebook Marketplace, the vehicle mileage was 63,000. The contact discovered that the mileage was 203,000.

When accelerating the transmission shakes violently under the hood. It shakes so bad that other vehicles can hear it the vibration is intense until you take your foot off the gas and then try to accelerate again it happens a few times then it’ll stop until the next red light. Slowly accelerating makes it worse but doesn’t matter either way.

Was driving on highway and vehicle went into "engine power reduced" and dropped from 60mph down to 35mph and then steadily decelerated down and wouldn't go over 18mph. Per mechanic it is the engine coolant control valve and the part is not available and could be months to a year before the part is available. Online shows this is a widespread issue with GM / Chev vehicles but no recall has been ordered and parts not available anywhere. Completely unacceptable to pay $65000 for a vehicle that is just barely 5 years old and have this kind of issue and manufacturer doing nothing about it.

Lost power steering! Almost impossible to make any turns. The dash has ESC fault and power steering fault. Says drive careful! How can I drive careful if I can't turn the truck? Only 79k miles! GM must recall their bad design and replace it with a design that is proven not to fail!

When a Check engine light is on it's for a low voltage on the charge air coolant sensor, took to the chevy dealer, they replaced a connector to the sensor, at a cost of $600 never got off lot, light returned, they then said I need a new engine wiring harness at a cost of $10.000, the dealership said this is a problem with these trucks and GM knows about it but won't recall them. Now I'm struck with a 5-year-old truck that I can't use, When this light is on, I also receive an Emission system warning, and the truck deregulates and goes in limp mode. as speed is reduced it becomes dangerous to drive in traffic, as GM knows about this, they should recall these trucks and fix the problem, they even say it's because cutting corners on the wiring harness cover causes this problem. as a senior living on a fixed income there's no way my wife or I can get this repaired, so were forced to drive it in limp mode until it dies on us, hopefully not in heavy traffic.

Vehicle started and behaved as expected when leaving my home and for a dozen lights or so between my home and place of the incident. While stopped at a red light, the auto stop function shut the truck down as normal. On re-start when getting green light, after releasing brake pressure, the start up was belabored for two turnovers before starting up. As I pulled off the stop with a green light, the dash lights illuminated and display started rolling through system failures, one of which was the brakes system and ESC. I cautiously proceeded through my turn to a thankfully quiet intersection as the brakes were completely unresponsive. I had ZERO brake function. I was able to slowly come to a rolling stop enough to get the truck in park where I turned it off and back on and the brake function returned. I cautiously drove to the local chevy dealer where I was informed that the battery drain pulls from low voltage when it needs extra power for start up. This is utterly terrifying that it is even possible for the battery to start the truck WITHOUT ANY BRAKE FUNCTION. Had this happened just two lights before or after where I was, it would have been a news headline. I could have easily been headed up and over a bridge leading to a catastrophic event at the bottom where I would have been completely unable to stop my truck by any means other than a collision. I would have preferred a dead battery at a red light. Seems a whole lot safer. I'm now stressed beyond measure at the thought of

I am writing to formally lodge a complaint regarding my Chevy vehicle, which is experiencing significant engine issues. The motor is knocking, and the check engine light has illuminated with trouble codes P0011 and P0016. These codes indicate problems with the camshaft and crankshaft timing on Bank 1 (driver's side in a V6/V8 engine). Specifically, P0011 signifies that the camshaft timing is over-advanced, while P0016 points to a correlation issue between the camshaft and crankshaft positions. These issues are often related to the Variable Valve Timing (VVT) system and may be caused by faulty camshaft or crankshaft sensors, timing chain problems, or solenoid issues. This situation directly correlates with a recent recall affecting similar VIN numbers for 2021-2024 models with similar engines. An independent service has confirmed that my truck requires a new engine, which aligns with the issues addressed in the aforementioned recall. I urge the NHTSA to investigate this matter further and consider extending the recall to include my vehicle, as the problems I am experiencing are consistent with those covered by the recall.

Oil pump went out. Got it repaired. Then, a few days later, while driving on the freeway at 70MPH the engine made a lot of noise then quit in middle of the freeway leaving me vulnerable to being hit. Was able to coast in neutral to the edge of the road. Has 73000 miles on it. Dealer says I need an engine replacement after just spending $5,500 for oil pump replacement. Has been at the dealer over a month and no replacement engine is available.

The engine seized up. Yeah, the truck is at a trusted mechanic and he told me that the engine seized. No warning signs. The truck wouldn't start and the engine light was on.

The lifters failed which caused the camshaft to destroy itself. I am now looking at having to replace my entire motor because of this. This is a similar problem to the current recall going on with the 2021 through 2024 trucks with the same motor. I have 146,000 mi on my truck

The rear brakes of the vehicle are locking up while driving. The truck is a 2020 Chevrolet Silverado 1500 Crew Cab and 2020-2022 Chevrolet Silverado 1500 are listed as included in the recall per the NHTSA Campaign # 24V797000 recall. When searching the VIN number of our vehicle, [XXX] , it states that it is not included in the recall and has no unrepaired recalls. Our vehicle is experiencing the issue as outlined in the recall notice but is not currently included in the recall when it should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had the same transmission torque converter failure shuddering jerking as the class action lawsuit as the 2015-2019 8spd that are covered but 2020 is not..it is a known issue. I had a transmission repair shop replace torque converter and service transmission to repair transmission issue. I did not have any warning or check engine light

Cylinder Four misfire code. PO304 Dealer has discovered lifter failure. Total to replace all lifters on effected side $4300.00 Vehicle is garage kept and serviced per required dealership. All service records have been kept. No other issues with Truck 83K miles.

The contact owned a 2020 Chevrolet Silverado 1500. The contact stated that while stopped at a stop light, he observed smoke emanating from the area of the vehicle between the cab and the bed, prompting him and the other occupants to quickly evacuate. Within moments, the vehicle caught fire and was engulfed in flames. Local emergency services arrived and were able to extinguish the fire. The contact was informed that fire investigators on scene determined that the fire had appeared to originate in the electrical system associated with the seat belt located behind the rear passenger side seat. No warning lights were illuminated. The vehicle was towed to a tow yard and was likely to be deemed a total loss by the contact's insurance provider. A fire report was filed. A police report was filed, and no injuries were reported. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V814000 (Seat Belts); the VIN was included, but the vehicle had already been repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.

This transmission has shifted terribly since day 1. It currently has 114,000 miles. It would slip gears going up an incline. I was told the fluid was too slick. Fluid change at 30k. Started to stumble on downshift again. Fluid / filter change done. Brass, metal in filter/ pan. It will downshift so hard that it feels like you are getting rear ended at a stop light. 1-2 seconds after a complete stop, bam. Been down 9 weeks.

Loss of power in my power steering due to corrosion of a ground strap. Found service bulletin 23-NA-201 issued 12/23 for the exact problem. The dealership stated there was no bulletin or covered under warranty and is being replaced with cost to myself. I had intermittent low speed "jerking" occasionally a few days before up to the incident.

Randomly. The power steering has stopped working. There is a widely reported issue with the power steering in 2020 Silverados and this model now needs to be included