2005 Chevrolet Silverado 1500 complaints

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, SHE WOULD HEAR A LOUD ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY ADVISED HER THAT THE DRIVER'S SIDE HUB FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHEN DRIVING AT LOW SPEEDS AND COMPLETING TURNS, THE STEERING WHEEL WOULD SEIZE AND THE CONTACT WAS UNABLE TO MANEUVER THE STEERING WHEEL. THERE WAS ALSO A LOUD GRINDING NOISE WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THE POWER STEERING BOX FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT THE VEHICLE HAD NO EXISTING RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000. THE CURRENT MILEAGE WAS APPROXIMATELY 100,000.

THE BRAKE LINES ,FUEL LINES AND THE FRAME CROSSMEMBERS ARE ALL SEVERELY RUSTED. IT JUST IS A MATTER OF TIME BEFORE I LOOSE MY BRAKES, GO UP IN FLAMES OR DROP MY GAS TANK ONTO THE HIGHWAY. THE BODY ON THIS TRUCK IS NOT TOO BAD. IT HAS 92,000 MILES ON IT, AND IT IS CLEANED QUITE OFTEN. THE UNDERCARRIAGE IS RUSTED VERY BADLY. I EXPECTED MORE FROM SOMETHING THAT COSTS SO MUCH. CANT AFFORD A NEW ONE AND IF I COULD IT WOULDN'T BE A GM. HAVE ALWAYS OWNED GM IN THE PAST. *TR

AIR BAG LIGHT HAS COME ON DUE TO A FAULTY IMPACT SENSOR, A PART WHICH WILL COST APPROXIMATELY $200 TO REPLACE. EVEN THOUGH I WOULD CONSIDER THIS A MAJOR SAFETY ISSUE, I CANNOT AFFORD REPAIRS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING, HE HEARD A NOISE UNDER THE DASH BOARD AND THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE CENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT HE NEEDED TO TAKE THE VEHICLE IN TO GET IT REPAIRED AT HIS EXPENSE. THE FAILURE MILEAGE WAS 42,500.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE GEAR SHIFTER INDICATOR LIGHT FAILED AND THE CONTACT DID NOT KNOW IF THE GEAR SHIFTED TO DRIVE. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V055000 (POWER TRAIN: MANUAL TRANSMISSION: SHIFT PATTERN INDICATOR) THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 97,000 AND CURRENT MILEAGE WAS 108,000. UPDATED 11/30/12 *CN

SEVERELY RUSTED BRAKE LINES THROUGHOUT. LINE RUPTURED WHILE VEHICLE WAS TRAVELING AT APPROXIMATELY 30 MPH ON A RESIDENTIAL STREET. NO INJURIES OR DAMAGE BUT FOR A VEHICLE OF THIS AGE TO LOOK LIKE IT DOES UNDERNEATH IS DESPICABLE. I'VE LIVED IN NEW ENGLAND ALL OF MY LIFE AND HAVE OWNED AND WORKED ON SEVERAL OLDER VEHICLES THAN MY CURRENT TRUCK AND HAVE NEVER SEEN CORROSION THIS BAD UNDERNEATH. REPLACING ALL LINES WITH STAINLESS STEEL IMMEDIATELY. HOW THIS DIDN'T HAPPEN SOONER IS DIFFICULT TO BELIEVE. *TR

BRAKE LINES RUSTED AND BURST FRONT AND REAR, PRESSED THE PEDAL TO SHIFT FROM PARK TO DRIVE PEDAL WENT ALL THE WAY TO FLOOR, LUCKILY WAS SETTING IN PARKING LOT. *TR

TOOK TRUCK IN FOR CHECK UP SAID STEERING WORN AND LEAKING BOTH LEFT AND RIGHT WAS REPLACED WITH CHEVY PARTS AT CHEVY DEALER IT IS NOW 8-22-12 NOW TOOK IT IN TO HAVE IT CHECK BEFORE VACATION AND THEIR SAYING THE STEERING BOX LEAKING MILEAGE NOW IS 37,778 I DON'T UNDERSTAND THE TROUBLE WITH THIS PART IT IS ALSO VERY EXPENSIVE. *TR

VEHICLE SPEED WOULD NOT INCREASE. MOTOR WOULD REV UP BUT VEHICLE WOULDN'T GO ANY FASTER. TRANSMISSION OVERHAULED AT A COST OF 1400.00. *TR

THE SERVICE AIRBAG LIGHT CAME ON,AND I HAD IT CHECKED,WAS TOLD THE FRONT SENSOR WAS BAD. CALLED THE CHEVY DEALER AND WAS TOLD THEY ONLY HAVE TO BE REPLACED IF IN A CRASH. I'VE HAD WIRING PROBLEMS AND A RECALL ON THE BLOWER WIRING. I THINK CHEVROLET SHOULD HAVE TO CHECK INTO THE PROBLEM,BECAUSE ON THE INTERNET THERE ARE A NUMBER OF OWNERS WITH THE SAME AIRBAG PROBLEM. SOUNDS LIKE A SAFETY ISSUE TO ME. CHEVROLET SAID FOR A PRICE THEY WILL CHECK IT. THEY MAKE IT SOUND LIKE IT'S THE OWNER'S FAULT, AND THE MORE MONEY THEY CAN GET THE BETTER. SOUNDS LIKE THEIR MOTTO IS (MONEY BEFORE SAFETY) SOMETHING NEEDS TO BE DONE TO HELP THE CONSUMERS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SPARE TIRE WOULD NOT DETACH FORM THE TIRE WELL AFTER NUMEROUS ATTEMPTS. THE TIRE WHEEL WAS LOCATED UNDER THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. ...UPDATED 05/08/13 *BF THE CUSTOMER STATED 2 REPUTABLE CHEVY SERVICERS ATTEMPTED TO RELEASE THE SECONDARY LATCH HOLDING UP THE SPARE AND WERE UNSUCCESSFUL. THE PROCESS TOOK 2 DAYS TO FREE THE TIRE. UPDATED 05/15/2013 *JS

I WAS DRIVING WHEN THE BRAKE PEDAL WENT SOFT. I CONTINUED AND THE SERVICE BRAKES WARNING LIGHT CAME ON. AS I WAS LESS THAN 1 MILE FROM HOME I CONTINUED CAREFULLY. WHEN I GOT HOME I FOUND THE BRAKE RESERVOIR ALMOST EMPTY. I DISCOVERED THE BRAKE HARD LINE TO THE REAR BRAKES WAS CORRODED. THIS IS THE LINE THAT RUNS ABOVE THE GAS TANK. IT WAS CORRODED THERE AND LEAKING FLUID. LUCKY I WASN'T KILLED OR STRANDED FAR FROM HOME ! *JS

THE SPEEDOMETER WILL READ 110MPH WHEN I'M JUST DOING APPROXIMATELY 34-40. *TT

THERE IS A BAD SEAL WHERE THE RIGHT FRONT AXLE CONNECTS TO THE SHAFT FROM THE TRANSFER CASE. THIS IS A COMMON PART THAT HAPPENS TO LARGE NUMBER OF VEHICLES.

DRIVING DOWN THE ROAD AND THE CAB FILLED UP WITH SMOKE. IT SMELLED LIKE BURNING RUBBER. I HAD TO EVACUATE MY YOUNGEST SON AND FOUND THAT THE WIRES ON THE BLOWER/RESISTOR WHERE ON FIRE. THERE SEEMS TO BE A KNOWN ISSUE WITH THIS AND I AM SURPRISED THAT NOBODY HAD BEEN KILLED SO FAR. LOOKS LIKE THE RECALL WAS DONE IN CANADA? HTTP://WWW.ARFC.ORG/COMPLAINTS/2005/CHEVROLET/SILVERADO/ELECTRICAL_SYSTEM/PROBLEM.ASPX. *TR

WHILE BRAKING ON ALL PAVEMENT CONDITIONS, AS VEHICLE SLOWS, BRAKES GO INTO ABS MODE AND VEHICLE SURGES FORWARD, REQUIRING ADDITIONAL PEDAL FORCE TO STOP. OCCURS AT 5 MPH OR LESS EVEN ON DRY PAVEMENT. OCCURS WITH ALL PEDAL PRESSURES. *TR

THE FRONT END INTERMITTENTLY BEGINS TO "SHIMMY" AT ABOUT 50MPH. I HAVE REPLACED TIRES, INNER AND OUTER TIE RODS, AND BRAKES CALIPERS BUT THE PROBLEMS HAVE NOT RESOLVED. THE VEHICLE HAS ALWAYS HAD PROBLEMS WITH A "CLUNKING" FROM THE STEERING COLUMN. SEVERAL OWNERS REPORT THE SAME PROBLEM. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS VERY COMMON PROBLEM. HEATING UP ENGINE COMPARTMENT, RELEASES CARBON MONOXIDE,MESSES UP THE O2 SENSOR AND CATALYTIC CONVERTER. CANNOT PASS EMISSION STANDARDS IF NEED BE.THIS IS IN GM TRUCKS 1999-2008. PLEASE CHECK THIS OUT FOR SAFETY PURPOSES. VERY EXPENSIVE TO REPAIR AND GM IS NOT STANDING BEHIND THE ISSUE. TOO MANY TRUCKS THIS WAY TO BE CO-INCIDENTAL. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF IN TO THE HEAD THIS IS CAUSING EXHAUST LEAKS IN THE ENGINE COMPARTMENT, NOISE, CARBON MONOXIDE IN THE ENGINE AND CAB AREAS, ADDED HEAT IN THE ENGINE COMPARTMENT, AND WILL NOT MEET THE EMISSION STANDARDS OF SOME STATES. VERY EXPENSIVE TO REPAIR AND GM IS NOT STANDING BEHIND THIS ISSUE IN THE TRUCK WITH V-8 ENGINES YEARS 1999-2008. ALMOST ALL HAVE THIS ISSUE. SAFETY HAZARD. PLEASE LOOK AT THIS. ALSO, CAUSING PROBLEMS WITH THE CATALYTIC CONVERTER AND O2 SENSOR. MAKE THEM STEP UP TO THE PLATE. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS CAUSING AN EXHAUST LEAK, NOISE, CARBON MONOXIDE, ADDED HEAT IN THE ENGINE COMPARTMENT, AND WILL NOT MEET EMISSION STANDARDS. VERY EXPENSIVE TO REPAIR. GM NOT STANDING BEHIND THIS ISSUE TRUCKS 1999-2008 MODELS ALL HAVE THIS ISSUE. SAFETY HAZARD. PLEASE LOOK AT THIS. THIS IS UNACCEPTABLE. ALSO, CAUSING PROBLEMS WITH THE CATALYTIC CONVERTER AND O2 SENSOR. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS VERY COMMON PROBLEM. GM NOT STANDING BEHIND IT. HEATS UP THE ENGINE COMPARTMENT AND RELEASES CARBON MONOXIDE INTO THE DRIVER. POTENTIALLY A SAFETY HAZARD. IT ALSO AFFECTS THE O2 SENSOR AND THE CATALYTIC CONVERTER. SOME STATES YOU CANNOT PASS EMISSIONS BECAUSE OF THIS TRAGEDY. PLEASE CHECK ALL VEHICLES FROM 1999-2008 FOR THIS SAFETY ISSUE. *TR

NOTICED MY BRAKE LINES COMING OUT OF THE BRAKE MASTER CYLINDER ARE RUSTING ! THESE LINES ARE NOT NEAR THE ROAD [ CHEMICALS/ ROAD SALTS ] BUT ARE IN THE ENGINE COMPARTMENT. MY TRUCK IS LOCATED AND DRIVEN IN SOUTHERN CALIFORNIA IN A WARM LOCATION [ NOT IN THE MOUNTAINS AND WINTER COLD]. I WILL HAVE TO CHECK THE REST OF THE LINES AND DO SOMETHING BEFORE THEY RUST THRU AND CAUSE AN ACCIDENT. THIS IS A SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SPEEDOMETER WOULD READ INACCURATELY WHILE THE VEHICLE WAS SHUT OFF AND WHILE DRIVING ON THE HIGHWAY. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATELY FAILURE AND CURRENT MILEAGES WERE 57,000.

I WAS OPERATING THE VEHICLE ON THE INTERSTATE. THE SPEEDOMETER SHOWED 70 MPH; HOWEVER, EVERYONE WAS PASSING ME. I PULLED OVER TO INVESTIGATE BUT THE SPEEDOMETER WOULD NOT GO LOWER THAN 30 AT A COMPLETE STOP. IT DID GO BACK TO 0 WITHIN A FEW A DAYS; HOWEVER, IT IS AGAIN SHOWING 20 MPH AT A DEAD STOP. DEALERS/MECHANICS HAVE GIVEN ME THREE DIFFERENT STORIES AS TO HOW TO FIX THE PROBLEM. PER A LOT OF OTHER SIMILAR REPORTS, THIS APPEARS TO BE A DEFECT WITH THE VEHICLE AND SHOULD NOT BE AT MY EXPENSE. IT IS A SEVERE SAFETY FACTOR. I'VE ALWAYS BEEN A CHEVY SILVERADO MAN BUT I'M FEELING DISAPPOINTED IN GM BY NOT BACKING THEIR PRODUCT LIKE THEY USED TO DO. *TR

2005 CHEVY SILVERADO 1500. BOUGHT BRAND NEW AT THE END OF MARCH 2005. SPEEDOMETER READS INCORRECTLY. SOMETIMES READS 120, SOMETIMES READS 90, ETC.ETC.ETC. MY TRUCK HAS JUST OVER 72,000 MILES ON IT AND IS LESS THAN 7 YEARS OLD, BUT MISSES THE VIN RECALL BY 9570. THIS SPEEDOMETER PROBLEM SEEMS TO BE A POPULAR COMPLAINT FROM WHAT I SEE ON THE INTERNET. SHOULDN'T THIS RECALL BE EXTENDED TO HIGHER VIN NUMBERS WITH THE SAME EXACT PROBLEM??? *TR

I WAS APPROACHING A STOP SIGN WHEN I APPLIED THE BRAKE THE PEDAL WENT ALMOST TO THE FLOOR. I PUSHED MY EMERGENCY BRAKE PEDAL TO HELP ME STOP.`I WAS GOING ABOUT 30 TO 40 MILES PER HOUR. THERE SHOULD BE A RECALL. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE ANTI-LOCK BRAKING SYSTEM ENGAGED WITHOUT WARNINGS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFERED ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 64,000 AND THE CURRENT MILEAGE WAS 65,000.

WHEN ROLLING FORWARD TO A STOP, THE ABS ACTIVATES, PEDAL FALLS, AND TRUCK ROLLS PAST STOP SIGN. AT FIRST IT WAS RANDOM, NOW IT HAPPENS ALL THE TIME WHEN STOPPING. I WON'T LET MY WIFE OR DAUGHTER DRIVE IT. *TR

MY 2005 CREW CAB 4X4 CHEVY SILVERADO AIR BAG LIGHT HAS COME ON AT 75000 MILES. FROM MY SHORT ONE HOUR ONLINE RESEARCH THERE ARE NUMEROUS GM SUVS AND TRUCKS FROM 2003 - 2011 WITH THIS SAME ISSUE. MOST GM CERTIFIED REPAIR FACULTIES ARE NOT ABLE TO CORRECT THIS ***MAJOR SAFETY ISSUE*** WITHOUT SIGNIFICANT COST TO THEIR AUTO OWNERS (AVERAGE COST $400-$3000). COMMON MALFUNCTIONING PART - IMPACT SENSOR 15103522 (AVERAGE COST OF PART $100; AVERAGE ANALYSIS COST $200; AVERAGE LABOR COST $87 A HOUR). I DID CALL GM CUSTOMER SERVICE DEPARTMENT WITH NO RESOLVE. CASE NUMBER 71-999598205. I SHOULD NOT HAVE TO PAY ADDITIONAL COST FOR A COMMON MANUFACTURE SAFETY ISSUE THAT WILL RESULT IN A CAUSE OF DEATH OR SERIOUS INJURY. PLEASE USE OUR TAX DOLLARS WISELY IN HAVING GM REPAIR THIS ISSUE AT NO COST TO THE OWNERS. (WHO WE, INCLUDING YOU, ARE THE TAXPAYERS THAT BAILED OUT GM...WHY??? THOUGHT THAT IS WHAT CHAPTER 13 BANKRUPTCY IS FOR?) SINCERELY *TR

BATTERY WENT DEAD AND I EXCHANGE WITH A NEW ONE. THE AIR CONDITIONER IS BLOWING HOT AIR. THE AIR CONDITIONER AND ALL THE ELECTRICAL WAS WORKING FINE WHEN THE PICKUP WAS LAST DRIVEN WHICH WAS ABOUT 3 WEEKS AGO. I HAVE BEEN TOLD THAT PARTS AND LABOR WILL BE IN THE $500.00. *TT

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT SUDDENLY LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CEMENT BARRIER. THE CONTACT SUFFERED A BROKEN JAW AND THE FRONT END OF THE VEHICLE WAS SEVERELY DAMAGED. THE VEHICLE WAS TOWED FROM THE SCENE AND A POLICE REPORT WAS FILED. IN ADDITION, THE AIRBAGS FAILED TO DEPLOY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE.

MY TRUCK AS DUAL AC CONTROLS, WHILE DRIVING THE DRIVER SIDE AIR BLOWS HOT AIR WHILE AIR CONDITIONER IS ON. IF YOU TURN THE TRUCK OFF AND THEN BACK ON IT FIXES THE PROBLEM FOR SOMETIME 2MIN AND SOMETIMES 30 MIN. I KNOW MULTIPLE PEOPLE THAT HAVE THE SAME PROBLEM AS ME, I HAVE SEEN HUNDREDS OF PEOPLE ON FORUMS THAT HAVE THE SAME PROBLEM WITH THE SAME TRUCK AND OTHERS SUCH AS THE TAHOE, AVALANCHE, SUBURBAN OF SAME YEAR AND DIFFERENT YEARS. SOME FORUMS THAT I HAVE READ STATED THAT THE TRUCK COULD CATCH FIRE, I AM VERY CONCERNED ABOUT THE SITUATION, MOST PEOPLE SAY THAT THE PARTS TO FIX THE PROBLEM ARE AROUND $500 - $700, BUT THIS IS OCCURRING IN HUNDREDS IF NOT THOUSANDS OF GM VEHICLES. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 9 MPH, THE ABS ACTIVATED AND OVERRODE THE BRAKES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO RAN A DIAGNOSTIC TEST BUT NO FAILURE CODES GENERATED FOR THE BRAKES. THE DEALER THEN LUBRICATED AND CLEANED THE BRAKES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 62,000.

DEFECTIVE CD PLAYERS. WILL NOT EJECT CD AND THIS IS A PROBLEM FOR ALMOST ALL CD PLAYERS IN THE 03-06 MODELS. I PERSONALLY KNOW 4 PEOPLE WITH THIS PROBLEM, AND THERE ARE THOUSANDS OF REPORTS IN FORUMS ON THE INTERNET. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THE PARKING BRAKE CABLE WAS WEARING A HOLE INTO THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO NORMAL WEAR AND TEAR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 69,000. UPDATED 10/27/11*BF UPDATED 3/30/12 *CN

NOTICED ELECTRICAL BURNING ODOR WHILE ON LONG TRIP ON INTERSTATE. OCCASIONALLY OPERATED THE AIR CONDITIONING, WITH BLOWER ON HIGH. ONE WEEK LATER, BLOWER MOTOR FAILED TO OPERATE ON HIGHEST (5) SETTING. PULLED 7 PIN CONNECTOR FROM BLOWER RESISTOR, FOUND RED WIRE AND CONNECTOR FOR HIGH SPEED, BURNED/MELTED.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH APPROACHING A STOP SIGN, THE ENGINE WARNING INDICATOR ILLUMINATED AND THE TRANSMISSION BEGAN TO SLIP GEARS. THE WARNING LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TUNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY DETECTED THE FOUR WHEEL DRIVE ENCODER MOTOR FAILED FOR THE SECOND TIME. THE PART HAD BEEN REPLACED LESS THAN TWO YEARS AGO. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

ABS ENGAGES WHEN ROLLING TO A STOP SIGN AT VERY LOW SPEEDS. THE BRAKE PEDAL GETS SOFT AND YOU ROLL PAST WHERE YOU THINK YOU WOULD HAVE STOPPED. THE ABS LIGHT DOES NOT COME ON WHEN THIS HAPPENS. I DISABLED THE ABS BY PULLING THE FUSE AND THE PROBLEM DOES NOT OCCUR. I THINK IT IS A ABS SENSOR ISSUE AS THERE ARE NO LEAKS OR LOSS OF BRAKE FLUID AND EVERTYTHING ELSE LOOKS FINE. *TT

STRANGE SMELL IN A/C UNIT WHEN TURNED ON. FAN BLOWER WASN'T BLOWING HIGH ENOUGH, THEN EVENTUALLY STOPPED WORKING. TOOK VEHICLE TO MECHANIC. STATED THE FAN AND RESISTER HAD BURNED UP. THERE WAS A RECALL ON MANUAL A/C BUT NOT ON AUTO. THE SAME PROBLEM HAPPENED IN MY AUTO A/C AS HAPPENED IN MANUAL A/C WHY IS MY VEHICLE NOT COVERED UNDER THE RECALL WHEN IT IS THE SAME PROBLEM. *TT

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE HEATER FAN RESISTOR MELTED. THE DEALER DIAGNOSED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS 100,000. THE CURRENT MILEAGE WAS 105,000. UPDATED 09/28/11*LJ THE CONSUMER STATED THERE WAS NO FIRE, BUT THE INSULATION HAD MELTED OFF OF THE WIRING GOING INTO THE RESISTOR ON THE HVAC FAN. UPDATED 12/30/11

ABS LOW SPEED ACTIVATION. AS I WAS STOPPING AROUND 5 MPH ABS WOULD START TO ACTIVATE CAUSING THE TRUCK TO NOT STOP CORRECTLY. THIS WOULD HAPPEN MOST OF THE TIME WHEN STOPPING. TOOK TRUCK TO DEVOE CHEVY DEALER ,ALEXANDRIA INDIANA, FOR REPAIR. BOTH FRONT ABS HUB SENSORS NEEDED REPLACED AND HUBS CLEANED AT COST OF $359.10 TRUCK HAS ONLY 55900 MILES. *KB

SUDDEN LOSS OF ALL BRAKES AFTER PRESSING ON BRAKE PEDAL HARD, ABLE TO USE PARKING BREAK ONLY TO STOP. FOUND BURST/LEAKING BRAKE HYDRAULIC LINE UNDERNEATH VEHICLE IN VICINITY OF DRIVERS DOOR. LINE WAS HEAVILY CORRODED. *TR

THE AUTOMATIC 4 WHEEL DRIVE SHIFTS FROM 2 WHEEL HIGH TO 4 WHEEL LOW WHILE DRIVING. I HAVE REPLACED ENCODER ONCE AND NOW DOES IT AGAIN. THIS NOT UNCOMMON IN CHEVY P/U'S. WAS TOLD BY SERVICE WRITER THIS HAPPENED TO A TRUCK WHILE IT WAS GOING DOWN ROAD AT 70MPH AND IT DESTROYED POWER TRAIN. THE PERSON WAS LUCKY THAT THEY HAD THEIR SEAT BELTS ON. PROBLEM # 2 IS SOMETIMES THE SPEEDOMETER WORKS AND SOMETIMES IT DOES NOT ANOTHER COMMON DEFECT. WHEN I WORKED FOR A PLUMBING COMPANY THEY HAD THIS SOME OF THEIR TRUCKS. I ALSO TALKED TO A FORMER GM MECHANIC AND HE SAID THAT THESE PROBLEMS WERE COMMON WITH CHEVY TRUCKS. THERE ARE RECALLS FOR HUB CAPS AND LIGHTS BUT NOT FOR SOMETHING AS SERIOUS AS THESE 2 DEFECTS. HOW LONG BEFORE SOMEONE IS INJURED OR DIES BEFORE THIS IS CORRECTED? *TR

I WAS DRIVING DOWN THE ROAD IN MY 2005 CHEVY SILVERADO WITH THE AC ON AND THE CAB OF THE TRUCK STARTED TO FILL UP SMOKE. THE WIRES TO THE BLOWER MOTOR METED AND STARTED TO BURN. *TR

BLOWER MOTOR SPEED CONTROLLER RESISTOR AND RELAY WIRING MELTED SMELL OF SMOKE AND ELECTRICAL ARCING DAMAGED WIRING AND CONNECTORS CAUSING DANGER TO OCCUPANTS FROM POSSIBLE FIRE. BLOWER RUNS WITH KEY OFF AND FUSE PULLED OUT. BATTERY DEAD, STANDING DRIVER. ECONOMIC HAM FROM COST TO REPAIR BY RIPOFF GM DEALER REFUSED TO COVER UNDER THE SPECIAL OFFER WARRANTY. *TR

I OWN A 2005 CHEVROLET SILVERADO 1500. I SMELLED BURNED PLASTIC AND MY FAN STOPPED WORKING ON #4 AND #5 SETTINGS. I REMOVED THE RESISTOR AND SAW THE CONNECTIONS HAD OVERHEATED AND MELTED. *TR

2005 CHEVROLET SILVERADO. CONSUMER STATES TRANSMISSION FAILED. *TGW THE DEALER REPLACED THE INPUT CLUTCHES IN THE TRANSMISSION. *JB

DEFECTIVE ENCODER MOTOR. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SERVICE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO REPLACED THE AIR BAG SENSOR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 30,000. UPDATED 06/01/11*LJ

2005 CHEVY SILVERADO 1500 INSTRUMENT PANEL ACTING UP, SPEEDOMETER IN PARTICULAR DOES NOT WORK ANYMORE. BUT SEEING TACH AND OIL PRESSURE GAGE ACTING UP ALSO. I HAVE 134,000 MILES ON IT BUT THE SPEEDOMETER HAS BEEN ACTING UP AROUND 80,000 AND RECENTLY JUST QUIT. I HAVE READ THAT GM IS WILLING TO FIX BUT HAS TO BE UNDER CERTAIN REQUIREMENTS. THEY KNOW THEY HAVE A PROBLEM THEY SHOULD FIX ALL UNDER A RECALL WHICH I HAVE NOT SEEN. *TR