2005 Chevrolet Silverado 1500 complaints

IGNITION SWITCH IS GETTING HARDER AND HARDER TO GET THE KEY TO TURN. *TR

UPON HAVING MY TRUCK INSPECTED FOR 2014, IT WAS REVEALED TO ME THAT ALL OF THE BRAKE LINES ON THE TRUCK WERE SEVERELY CORRODED AND NEEDED REPLACED. I WAS TOLD THAT THIS IS A "COMMON" PROBLEM ON CHEVY TRUCKS. THE COST OF REPAIRING THE BRAKE LINES HAS BEEN ESTIMATED AT A MUCH HIGHER NUMBER THAN THE $500 THAT GMC QUOTES. ON TOP OF THAT I FAIL TO SEE WHY THEY CAN CREATE STAINLESS STEEL EXHAUST SYSTEMS, BUT APPARENTLY USE CHEAP METAL FOR THEIR HARD BRAKE LINES. I ACTUALLY HAD THE TRUCK UNDERCOATED AT THE CHEVY DEALERSHIP SO THAT I WOULD NOT HAVE TO DEAL WITH THESE TYPE OF ISSUES. I'M NOT SURE WHO UNDERCOATED THE VEHICLE, BUT I WILL NEVER GET IT DONE BY CHEVROLET AGAIN. I HAVE HAD MUCH OLDER VEHICLES (1982) THAT WENT DOUBLE THE AMOUNT OF YEARS BEFORE NEEDING ANY HARD BRAKE REPAIRS. I HAVE READ ABOUT THE INVESTIGATION INTO THESE VEHICLES UP TO THE YEAR 2003, BUT I THINK THAT THE PROBLEM MUST STILL EXIST IN NEWER VEHICLES SUCH AS MINE. *TR

I PURCHASED THIS VEHICLE NEW. A FEW DAYS AFTER USING THE FOUR WHEEL DRIVE I RECEIVED A "SERVICE 4WD" MESSAGE. RETURNED THE VEHICLE TO THE DEALER. DEALER SAID THEY NEEDED TO UPDATE THE FLASH. A FEW WEEKS LATER SAME WARNING. RETURNED IT TO THE DEALER AND THEY PERFORMED THE SAME ACTION. SHORTLY THEREAFTER THE VEHICLE BEGAN TO PERIODICALLY SELF-ENGAGE INTO 4WD LOW WHEN STOPPED (TRAFFIC SIGNAL OR STOP AND GO TRAFFIC). RETURNED THE VEHICLE TO THE DEALERSHIP A TOTAL OF 9 TIMES IN THE FIRST 72,000 MILES (EXTENDED WARRANTY). SHORTLY AFTER THE WARRANTY EXPIRED, THE 4WD BEGAN MALFUNCTIONING AGAIN SELF ENGAGING THEN NOT FUNCTIONING AT ALL. RETURNED TO DEALERSHIP AND THEY SAID IT WOULD COST $125 FOR THEM TO LOOK AT THE VEHICLE BUT SINCE THIS WAS A RECURRING PROBLEM THEY WOULD TAKE CARE OF IT FOR FREE. DEALER UPDATED THE FLASH AGAIN AND SAID THE PROBLEM WAS FIXED. LESS THAN 1 WEEK LATER AT A 2-WAY STOP THE PROBLEM RETURNED. WHEN I WAS STOPPED THE VEHICLE PUT ITSELF INTO 4WD LOW WITHOUT ME KNOWING. AS I ENTERED THE INTERSECTION I REALIZED THE PROBLEM AND PRESSED THE ACCELERATOR TO THE FLOOR TO AVOID GETTING HIT BY CROSS TRAFFIC. I MANAGED TO GET THE VEHICLE OFF THE ROAD; HOWEVER, WHEN I ATTEMPTED TO DISENGAGE THE 4WD I WAS UNABLE. AFTER RETURNING HOME IN 4WD LOW I PARKED THE TRUCK AND DID SOME RESEARCH. TURNS OUT THIS WAS A PRETTY COMMON PROBLEM AND CHEVY STILL DOESN'T HAVE A SOLUTION. WHEN I STARTED THE VEHICLE SO I COULD TAKE IT TO THE DEALERSHIP IT SOMEHOW PUT THE TRANSFERCASE IN NEUTRAL

I STARTED MY TRUCK AND TURNED THE AIR CONDITIONER ON ITS HIGHEST SETTING WHILE I LOADED MY TWO CHILDREN INTO THEIR CAR SEATS. I HAD ONE OF MY CHILDREN IN THEIR CAR SEATS AND WAS PUTTING THE SECOND ONE IN HIS WHEN I SMELLED SMOKE AND QUICKLY REALIZED THERE WAS SMOKE BLOWING OUT OF THE VENTS. I GOT MY BOYS OUT OF THEIR SEATS AND SHUT THE VEHICLE OFF. I OPENED THE DOORS AND SEARCHED FOR SOMETHING TO EXTINGUISH FLAMES. AFTER GRABBING THE GARDEN HOSE AND RETURNING TO THE TRUCK I NOTICED THAT THERE WAS SMOKE COMING FROM UNDER THE DASH BUT I DIDN'T SEE ANY FLAMES. I WAITED TO SEE IT THE SMOKE WAS GETTING WORSE BUT IT WASN'T. I OPENED THE HOOD AND NOTHING WAS SMOKING IN THE ENGINE COMPARTMENT. I FELT AROUND THE CONSOLE AND NOTICED THAT THERE WERE A NUMBER OF AREAS THAT WERE EXTREMELY HOT. A DAY LATER I TRIED TO SEE IF I COULD FIND THE LOCATION OF THE FIRE. I DISCOVERED THAT ANYTIME I HAD THE AIR CONDITIONER ON AND THE BLOWER ON ABOVE LEVEL "3" SOMETHING WOULD BEGIN TO SMOKE. BEFORE THIS PROBLEM WITH THE AIR CONDITIONER OCCURRED ALL OF THE LIGHTS ON MY INSTRUMENT PANEL WOULD PERIODICALLY TURN OFF WHILE I WAS DRIVING. THERE ARE DEFINITELY SOME MAJOR PROBLEMS WITH THE ELECTRICAL WIRING ON THIS VEHICLE. I HATE TO THINK WHAT COULD HAVE HAPPENED IF I DIDN'T CATCH THE PROBLEM IN TIME. *TR

I BOUGHT THE TRUCK NEW IN 2005, IT HAS BEEN A PIECE OF JUNK FROM THE START, I HAVE HAD MULTIPLE PROBLEMS WITH THIS TRUCK, REPLACED BOTH FRONT ROTORS & HUBS, THE DEALERSHIP SAID THIS WAS NORMAL BUT I THINK THAT IT IS JUST NORMAL FOR A JUNKY CHEVROLET, THE MAIN POWER SUPPLY PLUG ON THE HEATER MOTOR MELTED OFF AND WOULD NO LONGER WORK, FRONT SPEAKERS QUITE WORKING, FRONT BRAKE LINES RUSTED AWAY AND THE RESERVOIR WAS DRY AND THE BRAKE LIGHT ON THE DASH NEVER CAME ON FOR A WARNING, HAD TO REPLACE ALL BRAKE LINES ON THE FRONT END OF THE VEHICLE, BRAKES ARE VERY WEAK AND MOST OF THE TIME THE PEDAL IS VERY SOFT AND GOES TO THE FLOOR AND SCARES ME TO DEATH, YOU DON'T THINK THAT THE TRUCK IS GOING TO STOP, THIS BRAKE ISSUE IS A VERY BIG PROBLEM !!!, SEVERAL PEOPLE THAT I KNOW HAVE THE SAME MODEL TRUCK HAVE THE SAVE EXACT ISSUES, I WILL NEVER IN MY LIFE TIME BUY ANOTHER CHEVROLET PRODUCT AS LONG AS I LIVE AND I SPREAD THIS INFO WITH ANYONE WHO MIGHT EVEN THINK OF BUYING A CHEVROLET, DON'T DO IT, THEY ARE JUNK !!!!!!!!!!!! *TR

VEHICLE'S GAUGES WERE NOT ACCURATE. THE SPEEDOMETER WOULD BE WORKING FINE THEN IT WOULD GRADUALLY GO TO 0 WHEN I WAS DRIVING. RPM WOULD BE AT 6 AND THEN GAS GAUGE WOULD QUIT WORKING. CLUSTER HAD TO BE REPLACED. CHEVROLET MANUFACTURER GAVE ME A DISCOUNT OF $75 TO REPLACE. THIS ITEM SHOULD BE CLASSIFIED AS A RECALL AS IT WAS A MATTER TO SAFETY AND THERE WERE OTHER CHEVROLET VEHICLES THAT HAD THE SAME PROBLEM AT DEALERSHIP. *TR

I WENT TO START MY TRUCK IN MORNING TO GET TO WORK AND THIS LOUD TICKING NOISE FROM UNDER THE HOOD, I SHUT ENGINE OFF PANICKING AND OPENED THE HOOD. WENT BACK AND STARTED TRUCK AGAIN AND LOOKED AROUND, I DIDN'T SEE ANYTHING BUT HEARD IT. CHECKED OIL SINCE IT SOUNDED LIKE THE LIFTERS BUT HAD PLENTY OF OIL. STOPPED ON WAY TO WORK AND GOT SOME SLICK50 SUPERCHARGE ENGINE TREATMENT. AT BREAKTIME CHECKED OIL AGAIN AND ADDED THE SLICK50, STARTED ENGINE AND HAD LIFTER NOISE AGAIN BUT QUIETED DOWN WITHIN 30 SECS. AT THE END OF MY WORK DAY STARTED IT UP AND AGAIN LIFTER NOISE BUT QUIETED DOWN AGAIN WITHIN 30 SEC. BROKEN EXHAUST MANIFOLD BOLTS WERE FOUND. *TR

TL* THE CONTACT OWNS 2005 CHEVROLET SILVERADO 1500.THE CONTACT STATED THAT THE GEAR SHIFTER WAS NOT ILLUMINATING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,500 AND THE CURRENT MILEAGE WAS 78,000.

RED CHECK AIRBAG LIGHT IS ON CONSTANTLY. ALL REPAIR SHOPS INDICATE THAT THERE HAVE BEEN MANY MORE, AND THE EXPENSE FOR REPAIR WOULD RUN FROM $450.00 TO $1,000.00. IT SEEMS THAT GM ALREADY KNOWS ABOUT THIS MALFUNCTION, SINCE THERE ARE MANY OTHER REPORTS. SINCE THE LIGHT IS ON, THE AIRBAG WILL NOT WORK IN THE EVENT OF A CRASH. IT WOULD SEEM THAT GM WOULD REPAIR THESE IMMEDIATELY UNLESS THEY WANT ANOTHER IGNITION SWITCH CATASTROPHE. IT SHOULDN'T TAKE SOMEONE DYING AS A RESULT OF THIS MALFUNCTION TO GET GM TO ACT. AS OF NOW, MY AIRBAG WILL NOT INFLATE IN THE EVENT OF A CRASH. *TR

AIR BAG LIGHT JUST CAME ON AN HAD IT SEE A DEALER TOLD ME I HAD BOTH SENSORS IN THE FRONT OF THE TRUCK BAD AND WANTED TO CHARGE ME AROUND $850.00 TO REPLACE THEM I DIDN'T HAVE THAT KIND ON MONEY TO SPEND THEY TOLD ME IT WOULDN'T EFFECT THE RUNNING OF MY TRUCK BUT IF I GET IN A WRECK MY AIR BAGS PROBABLY WILL NOT WORK IS THIS NOT A SAFETY PROBLEM GM SHOULD TAKE CARE OF THEY THOUSANDS OF TRUCKS LIKE MINE WITH THE AIR BAG LIGHT ON AN NOT AIR BAG WANT WORK IF THEY WRECK I CAN ONLY HOPE THAT THEY ARE A RECALL ON THIS BEFORE ANYMORE PEOPLE GET HURT OR KILL THAT COULD BE PREVENTED IF GM WOULD DO WHAT'S RIGHT AND FIX THE PROBLEM. *TR

THE IGNITION LOCK HAS NOT WORKED ON THIS VEHICLE FOR CLOSE TO 5 YEARS. AFTER STARTING THE VEHICLE, THE KEY MAY BE REMOVED AT ANY TIME WHILE THE ENGINE IS RUNNING OR BEING DRIVEN. *JS

ON 7/1/2011, MY 2005 CHEVY SILVERADO LOST BRAKES. THE LOSS OF BRAKES WAS CAUSED BY A LEAK FROM A CORRODED SECTION OF BRAKE LINE. I HAD THAT SECTION OF THE LINE REPLACED AND CONTINUED TO DRIVE. ON 6/12/2012, THE SAME THING HAPPENED TO ANOTHER SECTION OF THE BRAKE LINE. THE CORRODED LINE SPLIT AND BRAKE FLUID WAS GUSHING OUT. LUCKILY, ON BOTH OCCASIONS I WAS ABLE TO STOP MY VEHICLE BEFORE CRASHING INTO SOMEONE OR SOMETHING. WHEN I HAD MY VEHICLE TOWED TO MY MECHANIC, HE SAID THAT THE BRAKE LINES WERE SO CORRODED THAT HE WOULD RECOMMEND REPLACING THE ENTIRE LINE FOR SAFETY. I ALSO HAD AN OPPORTUNITY TO LOOK AT THE LINES AND WAS IN COMPLETE AGREEMENT WITH THE MECHANIC. MY VEHICLE AT THE TIME OF THE FIRST INCIDENT WAS 6 YEARS OLD AND HAD 57,751 MILES ON IT. THE SECOND INCIDENT OCCURRED ABOUT A YEAR LATER AND THE MILEAGE WAS 62,719. *TR

AFTER I BACKED OUT OF MY DRIVEWAY I STARTED DOWN THE STREET AND WHEN I APPLIED THE BRAKES THE BRAKE PEDAL STARTED TO PULSE AND I HAD TO REALLY PUSH HARD TO GET THE TRUCK TO SLOW DOWN. ABOVE 35 MPH THE BRAKES WORKED FINE. THIS IS THE SECOND TIME THIS VEHICLE HAS BEEN FOR THIS SAME TROUBLE. IT HAPPENED AROUND 20,000 MILES AND THE DEALER TOOK CARE OF THE PROBLEM. THE PROBLEM IS THE ABS SENSOR. IT GETS DIRTY AND EITHER HAS TO BE CLEANED OR REPLACED. THIS CAN BE VERY DANGEROUS AT SLOW SPEEDS, UNDER 35 MPH. I WAS TOLD THERE ARE NO RECALLS. IT WAS REPAIRED AT A CHEVROLET DEALER. *TR

CRACKED CYLINDER HEAD AND ENGINE. THIS ALLOWS ANTIFREEZE COOLANT TO MIX IN WITH THE OIL IN THE ENGINE AND GOES THROUGH THE EXHAUST, THIS ALSO GUMS UP THE OIL PARTS IN THE ENGINE AND REQUIRES NEW CYLINDER HEADS TO BE INSTALLED OR ENGINE REPLACED. I JUST RECENTLY WAS MADE AWARE THAT THE GENERAL MOTORS IS AWARE OF THIS PROBLEM WITH THERE ENGINES. AND ALSO WAS MADE AWARE THAT THE GENERAL MOTORS HAS SINCE FIXED THIS PROBLEM AFTER 2007, BECAUSE THIS IS NOT A PROBLEM THAT COULD CAUSE DEATH IT IS NOT LISTED AS A RECALL. THIS PROBLEM IS NOT MADE AWARE TO THE CONSUMER BUT IS PUBLISHED IN TECHNICAL SERVICE BULLETINS. THIS IS KNOWN PROBLEM BY GENERAL MOTORS. IT IS GOING TO COST BETWEEN $2500 TO $5000 TO REPAIR. *TR

VEHICLE HAS SERVICE AIRBAG LIGHT AND MESSAGE ON THE DIC INDICATING A FAULTY AIR BAG SAFETY SYSTEM. UPON FURTHER DIAGNOSTIC IT HAS BEEN DETERMINED THAT THE DRIVER SIDE FRONT AIRBAG IMPACT SENSOR IS FAULTY DISABLING THE AIRBAG SAFETY SYSTEM. THIS PART IS $250 FROM THE DEALER AND AS A SAFETY ITEM IS KNOWN TO BE FAULTY TOO SOON. *TR

WHEN I APPLYING THE BRAKES THE PEDDLE WENT TO THE FLOOR. UPON HAVING IT TOWED TO COVER CHEVROLET WINDBER PA. 15963 I WAS INFORMED THAT THE BRAKE LINES WERE ROTTED AND WOULD NEED REPLACED. *TR

I BOUGHT A 2005 SILVERADO FROM MY MOTHER, AND SHE BOUGHT THE TRUCK OFF OF A USED DEALER LOT PURCHASING FOR 12,500 FOUR YEARS AGO. SINCE THEN THE TRUCK HAS HAD AN AIR BAG SENSOR REPLACED AND IT ONCE AGAIN SHOWING THE AIR BAG NEEDS SERVICED, WHICH CAN BE VERY DANGEROUS TO TRUCK OWNERS IN SITUATIONS OF A CRASH. WAS TOLD THEY GO OUT COMMONLY. THE TRUCK HAS ALSO HAD AN ABS ISSUE SINCE IT WAS PURCHASED ON THE LOT, WE SENT IT BACK TO BE FIXED, AND THE ISSUE WAS NEVER SOLVED, IT HAS BEEN LOOKED AT BY THREE TECHNICIANS. THIS IS ALSO A PUBLIC SAFETY HAZARD IF THE ABS CAUSES THE BRAKES TO FAIL. THE TRUCK ALSO HAS NUMEROUS ELECTRICAL ISSUES, SUCH AS THE GEAR SELECTOR DOES NOT ILLUMINATE, IN WHICH CASE SOMEONE MAY NOT BE ABLE TO DETERMINE WHAT GEAR THEY ARE IN AND CAUSE AN INCIDENT, THE HEADLIGHT, TAIL LIGHT, BRAKE LIGHT, AND MARKER LIGHTS ARE ALWAYS BLOWING BULBS, THE DASH CLUSTER DOESN'T ALWAYS WANT TO ILLUMINATE EITHER, THIS COULD CAUSE A CRASH ESPECIALLY AT DARK WHEN YOU CANNOT SEE THE RPM, SPEEDO, OIL PRESS, TEMP, OR ANY OTHER GAGE PRESENT. *TR

UPON STARTING THE TRUCK, EVERYTHING WAS FINE. I LET IDLE FOR ABOUT 2 TO 3 MINUTES TO WARM UP. AFTER IT WAS WARMED UP, I LOOKED DOWN ONTO THE DASH AND NOTICED THE WARNING TEXT "SERVICE AIR BAG". ALSO THE AIRBAG LIGHT ON THE LEFT SIDE OF THE DASH WAS ILLUMINATED, TO THIS DATE I HAVE YET TO FIX THE ISSUE. AFTER RESEARCH ONLINE, IT SEEMS THAT I AM NOT THE ONLY ONE WITH THIS PROBLEM. THIS DOES NOT AFFECT THE FUNCTION OF THE TRUCK HOWEVER IF I DO GET INTO AN ACCIDENT, THE AIR BAGS WILL NOT DEPLOY. I GUESS I AM WILLING TO TAKE THAT RISK AS A TRIP TO THE DEALER TO FIX THE AIR BAG ISSUE WILL RESULT IN A BILL OF OVER $200. *TR

WITH THE HEATER ON HIGH (SETTING 5), THE FAN STOPPED BLOWING HEAT. I THEN SET THE BLOWER TO SETTING 4, AND THE FAN WORKED FINE. AS SOON AS I THEN PUT THE FAN BACK TO 5, I WOULD HEAR A CLICK BUT THE FAN WOULD NOT WORK AT ALL. I THEN BEGAN TO FIDDLE AROUND WITH THE CONNECTOR THAT IS UNDER THE PASSENGER SIDE DASH WHICH POWERS THE FAN. IF I MOVE THE ONE WIRE AROUND, THE FAN WOULD INTERMITTENTLY WORK WHILE ON SETTING 5. I UNPLUGGED THIS CONNECTOR FROM THE BLOWER MOTOR, NOTICED THAT THE ONE WIRE SEEMS AS IF IT WAS CAUSING A SHORT (THE WIRE WAS SOMEWHAT BLACK FROM OVER CURRENT). I REMOVED THE PIN FROM THE CONNECTOR, RECRIMPED AND SOLDERED IT. WORKED FINE UNTIL A FEW WEEKS AGO WHEN THE FAN ONCE AGAIN BEGAN TO STOP ONLY ON SETTING 5. I AM ASSUMING THAT THE PROBLEM IS ONCE AGAIN THE CONNECTOR THAT GOES TO THE BLOWER MOTOR POWERING THE FAN RESISTOR. I SAW A FEW REPORTS OF THIS ON HERE ABOUT VEHICLE FIRES ALL OF WHICH POINT TO THIS CONNECTION BEING BAD. SO I THOUGHT I WOULD SUBMIT THIS AS WELL DUE TO THE VAST AMOUNT OF ISSUES I HAVE HAD WITH THIS TRUCK. *TR

HAD JUST MADE A LEFT TURN ONTO MY STREET, APPROXIMATE SPEED ABOUT 5 MPH. AFTER THE LEFT TURN WAS MADE, I PROCEEDED ABOUT 200 FEET TO MY DRIVEWAY. UPON PULLING IN, I ATTEMPTED TO STOP AND THE PEDAL WENT TO THE FLOOR. THE BRAKES WERE NOT HIT ABRUPTLY HOWEVER THERE WAS SNOW ON THE GROUND. MOVING AT 10 MPH WHEN COMING TO A STOP, THE TRUCK DID NOT SLIDE BUT EVENTUALLY STOPPED, WITHOUT INCIDENT. AFTER PARKING THE TRUCK, 20 MINUTES LATER I DECIDED TO SEE IF IT WAS STILL THE SAME OR IF THIS WAS JUST A "FLUKE" (NO THE ABS LIGHT DID NOT COME ON WHEN PARKING). SO AS I OPENED THE DRIVERS SIDE DOOR, I LOOKED DOWN AND NOTICED THE SNOW WAS A GOLDEN/BLUISH COLOR. I LOOKED UNDERNEATH THE TRUCK AND SAW BRAKE FLUID DRIPPING SLOWLY ONTO THE GROUND. THE LEAK IS COMING FROM UNDER THE DRIVERS SIDE DOOR, NEAR WHERE THE GROUP OF BRAKE LINES IS LOCATED. I CHECKED OUT POSSIBLE FIXES ONLINE AND NOTICED I AM NOT THE ONLY ONE WITH THIS COMPLAINT. IT WAS SUGGESTED I FILE THIS COMPLAINT, WHICH I AM GLAD I DID SO. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE IS NOT AS LUCKY AS I WAS (PULLING INTO MY DRIVEWAY AT A SLOW SPEED). THANK YOU. *TR

THE HEATER BLOWER WOULD NOT TURN OFF WHICH DRAINED THE BATTERY. NOW BOTH PARTS NEED TO BE REPLACED. ACCORDING TO CHEVROLET, THIS PART WAS A RECALL ITEM IF MADE FROM A CERTAIN MANUFACTURE. APPARENTLY, OUR PART WAS A DIFFERENT MANUFACTURER WHICH IS WHY WE DIDN'T GET THE RECALL NOTICE. SINCE OUR PART FAILED, PERHAPS, IT IS A DESIGN DEFECT OR THE OTHER MANUFACTURERS WERE DELINQUENT DURING THE ASSEMBLY PROCESS AS WELL. PLEASE INVESTIGATE TO SEE IF WE MAY QUALIFY FOR A RECALL ON THIS PART. *TR

BRAKE LINES FAILED DUE TO CORROSION. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING SYSTEM FAILED; THEREFORE, THE CONTACT WAS UNABLE TO KNOW HOW FAST HE WAS DRIVING AND UNABLE TO SEE OR READ ANY OF THE GAUGES. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE DEALER STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000 AND THE CURRENT MILEAGE WAS 147,000.

HIT THE BRAKES, LINE BUSTED....NO BRAKES. LUCKILY NOBODY WAS HURT. VERY DANGEROUS SITUATION. *TR

INSTRUMENT CLUSTER PANEL (SHIFT INDICATOR) STOPPED ILLUMINATING. ALL OTHER ITEMS WORK IN CLUSTER. ITS SO DIM YOU CANT TELL WHICH GEAR YOUR IN. (THERE IS A RECALL BUT WE WERE TOLD WE WERE NOT COVERED). THE ENTIRE CLUSTER MUST BE REPLACED. AND YOU CAN ONLY GET THE PART AT THE DEALER BECAUSE THEY NEED TO THE VIN AND MILEAGE ON THE VEHICLE. 2. ONE OF THE MAIN BRAKE LINES BURST..YESTERDAY 10-16-2013 WHILE MY WIFE WAS DRIVING WITH MY SON. I AM TOLD ALL THE LINES MUST BE REPLACED BECAUSE THEY ARE ALL CORRODED. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A LOUD ABNORMAL POPPING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,517 AND THE CURRENT MILEAGE WAS 61,300.

I WENT TO MOVE THIS TRUCK IN MY DRIVEWAY, WHEN I PUT IT IN REVERSE, THE BRAKE PEDAL WENT TO THE FLOOR, NEARLY HITTING MY CAR WHICH WAS BEHIND ME. I GOT OUT AND OPENED THE HOOD AND NOTICED THAT THE BRAKE FLUID RESERVOIR WAS VERY LOW, AND THAT BRAKE FLUID HAD SQUIRTED ALL OVER THE FRONT OF THE ENGINE AND WAS ALSO LEAKING FROM A SECOND PLACE JUST UNDER THE MASTER CYLINDER ALONG THE FRAME. THE BRAKE LINES WERE WET AND ARE VERY RUSTY, TO THE POINT OF SCALING. NOW, I CAN'T USE MY TRUCK, WHICH I VERY MUCH NEEDED ON 09/14/2013. THIS IS VERY DISGUSTING!

WHILE SLOWING DOWN AT A STOP LIGHT I PRESSED THE BRAKE PEDAL ONLY TO HAVE IT FALL ALL THE WAY TO THE FLOOR. I WAS CRUISING TO A STOP LIGHT WITH CROSSING TRAFFIC AND WAS COMPLETELY TERRIFIED AT THE LOSS OF BRAKING POWER. I HAD THE IDEA TO PUT THE TRUCK INTO NEUTRAL AND JAM THE EMERGENCY BRAKE WHILE HONKING MY HORN. THE TRUCK SLOWLY CAME TO A STOP WELL WITHIN THE INTERSECTION NARROWLY MISSING TRAFFIC. I LOOKED UNDER THE TRUCK AND FOUND BRAKE FLUID LEAKING FROM THE REAR NEAR THE AXLE. A MECHANIC HAS CONFIRMED THIS WAS A BURST BRAKE LINE DUE TO RUST AND THAT HE SEE THIS BRAKE LINE FAIL AT THE SAME SPOT ON CHEVROLET/GMC TRUCKS FREQUENTLY. THIS VEHICLE HAS FREQUENT CAR WASHES WITH UNDERCARRIAGE RINSING YEAR ROUND. *TR

SLOWING DOWN FOR A STOP SIGN AND PEDAL WENT TO THE FLOOR AND WENT THROUGH THE INTERSECTION COULD NOT STOP. THE LEFT REAR BRAKE LINE WENT. *TR

THE REAR BRAKE LINE BURST WHILE DRIVING IN A PARKING LOT RESULTING IN A LOSS OF BRAKING. THE MECHANIC SHOWED ME WHERE IT BROKE AND IT APPEARED TO BE DUE TO CORROSION OF THE LINE. IT ALSO LOOKED LIKE THE FUEL LINE WAS SHOWING SIMILAR CORROSION. *TR

I STARTED SEEING RUST SPOTS AROUND THE BOTTOM THE CAB AND HAD TO PUT IT IN THE SHOP BECAUSE RUST HAD EATEN THROUGH, THE REPAIRMAN SAID IT LOOK AS IF THE AREA HAD NEVER BEEN TREATED FOR CORROSION, THIS VEHICLE SHOULD NOT BE DOING THIS AND HE SAID HE COULD NOT GUARANTEE THAT IT WANT CONTINUE. I FEEL GM SHOULD PAY FOR THE REPAIR AND MAKE SURE IT DOSE NOT HAPPEN AGAIN. *TR

I STEPPED ON THE BRAKES AND THE PEDAL WENT TO THE FLOOR. I STEPPED ON THE MECHANICAL PARKING BRAKE TO STOP. BRAKE FLUID WAS ON THE GROUND.. I PULLED ALL THE WHEELS AND NO BRAKE CYLINDERS OR CALIPERS WERE LEAKING BUT AFTER TRACING THE OIL IT WAS FROM A BUNDLED OF BRAKE LINES UNDER THE DOOR. *TR

TRUCK HAS AN EXHAUST LEAK AT MANIFOLDS. 4 BOLTS HAVE BROKEN OFF OF THE MANIFOLD. MY MECHANIC SAID THIS IS VERY COMMON WITH THIS TRUCK AND COULD COST UP TO AND OVER $1,000.00 TO FIX. CHECK ENGINE LIGHT IS ON SO UNLESS I FIX IT I CAN'T GO TO STATE INSPECTION. ALSO THE BRAKE LINES ARE CORRODED AND ALSO NEED TO BE REPLACED. THESE ARE ALL DEFECTS NOT MAINTENANCE ISSUES. HTTP://WWW.YOUTUBE.COM/WATCH?V=0YG6WLBNZGI IT EXPLAINS THE PROBLEM BETTER. *TR

THE BRAKES FAILED ON MY TRUCK AND I HIT A PARKED DUMP TRAILER. UPON INSPECTION I FOUND THAT THE BRAKE LINES HAD SEVERLY RUSTED AND FAILED. I WAS UNABLE TO STOP SAFELY AND UNABLE TO PUMP THEM UP. THE BRAKE LINE FAILURE OCCURED UNDER THE DRIVERS DOOR. *TR

ALL 5 BRAKE LINES ARE BADLY CORRODED, 2 WERE LEAKING. FILLED THE RESERVOIR, AND DROVE IT TO LOCAL SHOP FOR REPAIR, {ABOUT 2 MILES}, USING WHAT LITTLE BRAKE I HAD, {PEDAL ON THE FLOOR}, AND EMERGENCY BRAKES. COULD HAVE BEEN VERY SERIOUS AND WAS VERY EXPENSIVE TO GET FIXED. TALKED TO LOCAL CHEVY DEALER WHO TOLD ME THEY REPLACE BRAKE LINES ON CUSTOMERS CARS AND TRUCKS ALMOST EVERY DAY. GM WILL NOT DO RECALL BECAUSE PROBLEM IS LOCALIZED TO THE "SALT AREA" OF NORTH EASTERN UNITED STATES. BUT GM DOES STATE THAT VEHICLE SHOULD STOP WITHOUT FLUID. THAT IS NOT TRUE! *TR

I PURCHASED THIS (CURRENTLY 87,000 MILES) TRUCK NEW IN LATE 2004. I HAVE REPLACED THE STEERING GEAR TWICE (AT 20,227 AND 86,033 MILES). THE POWER STEERING PUMP TWICE (AT 32,379 AND 86,033 MILES). AND THE POWER STEERING SHAFT TWICE (AT 31,087 AND 42,169 MILES). WHILE THIS IS ON ITS THIRD POWER STEERING PUMP, EACH OF THE FIRST 2 PUMPS HAD TO BE INSPECTED FOR REPAIRS DUE TO NOISES WHEN IT WAS IN FOR SERVICE. WHILE THE MANUFACTURER ISSUED BULLETINS FOR THESE PARTS AFTER RECEIVING COMPLAINTS FROM CUSTOMERS ABOUT FAILURES, THE MANUFACTURER HAS NOT RECALLED THESE PARTS.

THE SPEEDOMETER IS ERRATIC, DISPLAYING 40, 50, 80 MPH RUNNING, SITTING STILL IN PARK. THEN WILL PEG TO 130 MPH WHEN DRIVEN. LATER, IT WILL EVENTUALLY CORRECT ITSELF AFTER CRANKING 4, 5, 8 TIMES AND WORK PROPERLY TEMPORARILY. THEN REPEAT. THIS IS A COMMON, KNOWN PROBLEM WITH THESE GAUGE CLUSTERS AND CHEVROLET DIV. REFUSES TO FIX AT NO COST BECAUSE THE TRUCK IS OUTSIDE THE TIMEFRAME STATED IN "SPECIAL POLICY # 07187", BUT IT MEETS THE MILEAGE AND VIN CRITERIA. TO THE BEST OF MY KNOWLEDGE, THE TRUCK DID NOT FAIL DURING THE STATED TIMEFRAME. COST OF THE REPAIR IS $560 AND I BELIEVE CHEVROLET SHOULD FIX IT AT NO COST TO THE OWNER. *TR

LUCKILY MY WIFE WAS IN HER PARKING LOT AT WORK. SHE APPLIED THE BRAKES AND THE PEDAL HEADED FOR THE FLOOR. THE LINE TO THE REAR BRAKES RUSTED THROUGH MID POINT BETWEEN THE FRONT AND BACK. THIS IS AN 8 YEAR OLD, WELL MAINTAINED TRUCK! INFERIOR MATERIAL FAILURE? *TR

RUSTED BRAKE LINE LET GO AND HAD TO USE EMERGENCY BRAKE TO STOP TO STOP. PEDAL WENT COMPLETLY TO FLOOR ,TRIED TO PUMP NO BRAKES. REPLACED ALL BRAKE LINES. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE CYLINDER HEADS CRACKED ON THEIR VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE CYLINDER HEADS NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 111,000. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED THAT BOTH THE FUEL GAUGE AND SPEED ODOMETER READINGS FLUCTUATED. THE FAILURE OCCURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

SERVICE AIRBAG LIGHT COMES ON WHEN VEHICLE IS STARTED AND COMES AND GOES THROUGHOUT THE DRIVE. AFTER DISCUSSING WITH FRIENDS FOUND OUT THERE ARE APPROX. 5-10 OTHER VEHICLES OF THE SAME MODEL AND AROUND THE SAME MILEAGE IN MY AREA WITH THE PROBLEM. IF YOU SEARCH THE WEB, THERE ARE A LOT OF TRUCKS WITH THE SAME PROBLEM. NOT AN ISOLATED INCIDENT!!! THE PROBLEM IS EXPENSIVE TO FIX AND SOUNDS LIKE A MONEY MAKER FOR THE DEALERSHIPS!! *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO K1500. THE CONTACT STATED THAT THE STEERING COLUMN EXHIBITED AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO A MECHANIC AND AN INSPECTION WAS PERFORMED. THE FAILURE WAS LOCATED AT THE STEERING INTERMEDIATE SHAFT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 90,000. ..UPDATED 05/10/13 *BF UPDATED 05/24/2013 *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WITH THE HEATER ACTIVATED WHEN HE NOTICED A BURNING ODOR COMING FROM THE CONNECTOR FOR THE HEATER BLOWER. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF AS THE CONTACT INSPECTED THE HEATER BLOWER, WHICH HE DISCOVERED WAS MELTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 88,000.

WHEN COMING TO A STOP AND SUDDENLY WITHOUT WARNING, MY BRAKES BEGAN PULSATING RAPIDLY, EVENTUALLY STOPPING ABOUT 10 FEET BEYOND WHERE I INTENDED TO STOP. FORTUNATELY THERE WERE NO VEHICLES IN FRONT OF ME AN NONE COMING THROUGH THE INTERSECTION. SHORTLY AFTERWARDS, I HAD THE VEHICLES BRAKE SYSTEM EVALUATED ONLY TO FIND OUT THE ROOT CAUSE IS THE ANTI-LOCK BRAKE SENSORS ACTIVATING DUE TO CORROSION AND RUSTING. I WAS INFORMED THAT THIS ISSUE HAS BEEN TYPICAL WITH THESE MODELS OF VEHICLES FOR MANY YEARS. IN READING ONLINE POSTS, I SEEN THIS IS A COMMON AND KNOWN ISSUE, BUT THE DEALER DOES NOT RECOGNIZE IT, THEREFORE A RECALL SHOULD BE ISSUED BECAUSE THIS IS A SERIOUS SAFETY CONCERN WHICH COULD HAVE RESULTED IN BODILY INJURY OR DEATH! *TR

WHILE USING A 12V AIR PUMP PLUGGED INTO THE CIGARETTE LIGHTER OUTLET WITH THE VEHICLE OFF AND NO KEY IN IGNITION, IT SHORTLY STOPPED WORKING. SOON AFTER SMOKE STARTING COMING FROM BEHIND THE DASH TRIM. I QUICKLY DISCONNECTED THE BATTERY AND PULLED OFF THE FRONT TRIM HOUSING THE CIGARETTE LIGHTER TO FIND THE WIRE'S INSULATION MELTED. I THEN LOOKED FOR THE FUSE FOR THAT AND FOUND IT TO BE MELTED AS WELL. THE FUSE WAS RATED AT 15A, AND THE CORRECT FUSE RECOMMEND BY GM. AFTER PULLING THE FUSE, I RECONNECTED THE BATTERY AND HAD NO MORE SMOKE. USING A CONTINUITY TESTER, I CHECKED BOTH WIRES FOR, AND CONFIRMED, SHORT TO GROUND ON BOTH. THE ENTIRE LINE OF WIRES GOING BACK TO THE FUSE BOX MAY BE JUST AS MELTED AND THUS STILL SHORTING TO GROUND. *TR

I HAVE HAD A PROBLEM WITH THE SAFETY AIRBAGS BEING NON OPERATIONAL IN MY TRUCK FOR A WHILE NOW..DEALERSHIP IS WANTING TO CHARGE IN EXCESS OF $300 FOR THE REPAIR. I HAVE BEEN READING ON MULTIPLE FORUMS THAT THIS IS A COMMON PROBLEM WITH THE CHEVROLET SUV/TRUCKS MODEL YEAR 2003-2011. DUE TO THE FRONT IMPACT SENSORS GOING OUT ON THE VEHICLE AND YET CHEVROLET/GM HAS NOT DONE A SAFETY RECALL ON THESE. I WAS TOLD BY A DEALER THAT IF ONE OF THESE SENSORS GOES OUT THAT THE AIRBAG SYSTEM WILL NOT DEPLOY IS IN A CRASH. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, HE NOTICED IN THE REAR VIEW MIRROR THAT THE VEHICLE WAS ON FIRE. HE PULLED OVER AND NOTICED THAT WIRES ON TOP OF THE GAS TANK WERE THE SOURCE OF THE FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE CONTACT HAD PLANS TO HAVE THE VEHICLE TOWED TO A DEALER. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 93,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 45 MPH WITH THE HEATER ACTIVATED, THE CONTACT NOTICED THAT SMOKE EMITTED FROM THE AIR VENTS. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. THE CONTACT INSPECTED UNDER THE DASHBOARD AND OBSERVED THAT THE WIRING HARNESS WAS MELTED. THERE WERE NO FLAMES VISIBLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

WHILE AT A STOP WITH FOOT ON BRAKES, THE PEDAL SUDDENLY DEPRESSED ALL THE WAY TO THE FLOOR. A CHECK REVEALED THAT THE RIGID BRAKE LINE FROM THE EHCU TO THE DRIVERS SIDE FRONT WHEEL HAD FAILED DUE TO CORROSION. *TR