2001 Chevrolet Silverado 1500 complaints

STEEL BRAKE LINE FROM FRONT TO REAR BEFORE REAR SPLITTER RUSTED THROUGH AND CAUSED A MAJOR LEAK WHILE TOWING A TRAILER DOWN A HILL. TRAILER WAS EMPTY AT THE TIME SINCE I HAD JUST EMPTIED IT. FORTUNATELY I COULD DOWN SHIFT INTO 1ST AND RUN THE VEHICLE ONTO THE BERM AND SIDE OF THE ROAD SWERVING TO BLEED OFF SPEED UNTIL I COULD GET TO THE BOTTOM OF THE HILL AND THEN TURN INTO SOFT DIRT TO STOP THE VEHICLE. THERE WAS NO WARNING, AND THE PEDDLE WENT RIGHT TO THE FLOOR, NO BRAKING AT ALL. TRIED TO PUMP BRAKES, BUT WENT RIGHT TO FLOOR IN LESS THAN A SECOND. THE STEEL LINE COMPLETELY SEPARATED. *TR

THERE WAS A RECALL ON AUGUST 29 2005 FOR THIS PROBLEM. RECALL NUMBER 36327 I HAVE THIS PROBLEM WITH MY TRUCK RIGHT NOW HOW SHOULD I HANDLE THIS SITUATION? IT IS THE HYDRAULIC: ABS SENSOR (THE PROBLEM STARTED SLOWLY AND NOW ITS BAD) I JUST FOUND OUT ABOUT THE RECALL. *TR

I WAS DRIVING DOWN A STATE ROAD WHEN I NEEDED TO STOP FOR AN INTERSECTION STOP SIGN; MY BRAKE PEDAL WENT ALMOST TO THE FLOOR. THE BRAKING POWER WAS REDUCED TO SUCH A DEGREE THAT I PASSED THROUGH THE INTERSECTION JUST BEING MISSED BY ANOTHER VEHICLE TRAVELING ON THE OTHER ROADWAY THAT DID NOT HAVE TO STOP. THE BRAKE FLUID RESERVOIR WAS EMPTY IN THE FRONT SECTION AND ONLY SMALL AMOUNT IN THE REAR SECTION. I DROVE THE VEHICLE THE REST OF THE WAY AT 15 MPH BECAUSE THE BRAKING ABILITY WAS SO DIMINISHED IT WOULD NOT STOP FAST ENOUGH AT A HIGHER SPEED. MY FRONT BUMPER GUARD WAS DENTED AND BENT WHEN IT IMPACTED A CAR STOP BOLLARD AT A STOP ON THE WAY HOME. I COULD NOT CALL A WRECKER BECAUSE I HAD NO SIGNAL ON MY CELL PHONE AND I COULD NOT WALK FOR HELP BECAUSE I AM DISABLED AND CAN ONLY WALK VERY SHORT DISTANCES (I HAVE A STATE ISSUED HANDICAP PLACARD). UPON EXAMINATION A RUSTED THROUGH BRAKE LINE WAS FOUND TO BE THE CAUSE. THE OTHER BRAKE LINES ARE IN THE SAME RUSTED CONDITION. I SURE HOPE DOT WILL MAKE GM CORRECT THIS PROBLEM BEFORE SOME CHILDREN ARE HURT OR KILLED. *TR

FUEL GAUGE IS NOT OPERATING ON FULL TANK OF GAS IT STATES EMPTY AND VARIES FROM EMPTY TO FULL AND BACK. *TR ## VIN PASSED ##

WENT TO SEARS TO HAVE THEIR TECHNICIANS REPLACE REAR BRAKE CALIPERS AND THEY REFUSED BECAUSE THEY SAID MY BRAKE LINES WERE SO RUSTED THAT THEY WERE ABOUT TO BREAK IF THEY TRIED TO REPLACE THE CALIPERS. THEY ADVISED ME TO GO TO THE DEALERSHIP MILTON RUBEN HERE IN AUGUSTA GEORGIA OR SOMEONE WHO DEALS WITH REPLACING STEEL BRAKE LINES. AFTER FURTHER INVESTIGATION OF THE STEEL BRAKE LINES THEY ARE COMPLETELY RUSTED THROUGHOUT THE TRUCK FROM FRONT TO BACK. I WILL BE TAKING A PICTURE TOMORROW FOR MY RECORDS.THIS IS A REAL SAFETY CONCERN AND I WILL BE TAKING IT TO A SERVICE SHOP TO BE REPLACED AS SOON AS POSSIBLE. I AM GLAD THAT SEARS POINTED THIS OUT, IT PROBABLY SAVED SOME LIVES. *TR

UPON A ROUTINE GOF (GREASE,OIL & FILTER), THE MECHANIC AT THE TIRES PLUS SHOP AT OKEECHOBEE, FL, INVESTIGATED A LOW BRAKE FLUID ISSUE AND UPON TROUBLESHOOTING, THE BRAKE LINE BURST, LEAVING NO BRAKES. THE MECHANIC CALLED ME OUT TO THE GARAGE BAY AND SHOWED ME THE RUSTED LINE(S) AND SUGGESTED THAT THEY ALL BE REPLACED. I HAD BRAKES UPON ARRIVING FOR THE GOF), SO THIS WAS AN UNPLEASANT "SURPRISE". THE VEHICLE COULD NOT BE DRIVEN, SO I WAS UNABLE TO SHOP FOR A COMPETITIVE JOB ESTIMATE. ALSO, I HAD TO ABANDON THE VEHICLE AND ARRANGE A RIDE, AS THE VEHICLE WOULD REMAIN OVERNIGHT AT THE TIRES PLUS GARAGE. UPON A SUBSEQUENT INTERNET SEARCH, I LEARNED THAT THIS IS A PARTICULAR PROBLEM FOR SILVERADOS AND SUBURBANS VINTAGE 1999-2006, AND WAS ENCOURAGED TO FILE THIS COMPLAINT. I HAVE THE RECEIPT FOR THE WORK WHICH WAS APPROXIMATELY $600. *TR

BRAKE PEDAL WENT TO FLOOR AS I WAS BACKING OUT OF THE DRIVEWAY. UPON INSPECTION DISCOVERED BRAKE LINE WAS RUSTED AND HAD A HOLE. *TR

I HAVE TRIED TO STAY WITH A GM PRODUCT BUT THE TRUCK I RECENTLY PURCHASED HAD THE FOLLOWING PROBLEMS,WHILE TRYING ALSO TO AVOID THE MOST COMMON PROBLEM OF THE GM BAD FRAME,BY THE WAY TOYOTA WARRANTIES THERE FRAMES. THE 1ST MONTH OF OWNERSHIP THE REAR SPRING SHACKLES BROKE THERE ARE 30 YEAR OLD TRUCKS THAT STILL DON'T HAVE THIS PROBLEM,I OWN ONE. NEXT ABOUT ANOTHER 30 DAYS GO BY THE ELECTRIC FUEL PUMP DECIDED TO DIE. THAT SO FAR BRINGS REPAIRS UP TO CLOSE TO 650.00 AFTER 60 DAYS. LAST WK. MY BRAKE LINE FAILED @ ABOUT 50 MPH,NO WARNING LIGHT RIGHT TO THE FLOOR.THIS TRUCK HAD BEEN TAKEN CARE OF . SHOULD I CONTINUE ABOUT THE HOLE IN MY WINDSHIELD FRAME EVERY TIME IT RAINS MY ASH TRAY IS FILLED WITH WATER. BY THE WAY I WAS QUOTED ABOUT 1400.00 FOR ALL THE BRAKE LINE REPAIRS. WTF GM WHO HAS THAT KIND OF MONEY FOR REPAIRS,I DONT. THE PUBLIC SHOULD BE COMPENSATED FOR SUBSTANDARD MATERIAL USE. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE TRYING TO DECELERATE, THE BRAKE PEDAL WAS ABNORMALLY DEPRESSED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS CONFIRMED THAT THE BRAKE LINES WERE SEVERELY RUSTED. THE BRAKE LINES WERE REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 60,000. UPDATED 01/29/13*LJ UPDATED 01/30/20130*JS

WHEN DRIVING TO WORK, WENT TO STOP BRAKE PEDAL WENT TO FLOOR WITH NO WARNING. FOUND OUT BRAKE LINES ROTTED AND LEAKED. COULD NOT BUY HAD TO HAVE BRAKE LINES MADE AND INSTALLED BY MECHANIC. THE MORE PEOPLE I'VE TALK TO CHEVY SHOULD BE RESPONSIBLE FOR THE BRAKE LINES. I ALMOST HIT ANOTHER CAR . WENT INTO DITCH TO AVOID THE CAR. THE TRUCK IS KEPT VERY CLEAN AND NEVER TAKEN OFF ROAD. PURCHASED THE TRUCK BRAND NEW. *TR

DRIVING DOWN HILL LIGHT TURNED YELLOW, WENT TO APPLY BRAKES PEDDLE HELD FOR A SECOND THEN WENT TO THE FLOOR. LUCKILY NO ONE WAS WAITING TO COME THROUGH INTERSECTION, UPON INSPECTION FOUND BRAKE LINES HAD RUSTED THROUGH. COMPLETE BRAKE FAILURE. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THERE WAS A CLUNKING NOISE IN THE STEERING WHEEL WHEN MAKING ANY TURNS. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 192,000.

BROUGHT A 2001 CHEVY SILVERADO 1500 IN FOR A SLOW LEAK IN THE FRONT DRIVERS SIDE TIRE. UPON MECHANIC TACKING TIRE OFF THE VEHICLE THE INSPECTION REVEALED THE INSIDE SIDE WALL SEAM IS SEPARATING AND ACTUALLY HAS A GAPS MEASURING 3/16' WIDE BY A FEW INCHES LONG ALL ALONG THE SEAM. UPON FURTHER INSPECTION THE REAR TIRE ON THE DRIVERS SIDE ALSO REVEALS THE SAME SIDE WALL SEPARATION TEARS IN THE SEAM. THIS IS A GOODYEAR WRANGLER SR-A , P245-75-16. WITH A MANUFACTURERS DATE OF 2009. *TR

THIS IS THE 4TH TIME I HAVE BLOWN A LINE ON THIS VEHICLE. THE FIRST 3 WERE WITHIN THE LAST 2 YEARS. FIRST, PULLED UP TO A LIGHT AT 25 MPH AND MANAGED TO STOP AFTER I RAN THE LIGHT. NO TRAFFIC, NO CRASH, AND I AM NOT SURE OF THE MILEAGE. SECOND, PARKING TRUCK AT HOME, BLEW A LINE. LESS THAN 5 MPH, NO DAMAGE, AGAIN, NOT SURE OF MILEAGE. THIRD, PULLING TRUCK INTO A GARAGE TO REPLACE A U-JOINT, BLEW A LINE. LESS THAN 5 MPH, NO DAMAGE, NOT SURE OF MILEAGE. I HAD ALL OF THE REMAINING LINES REPLACED AT THIS TIME. FOURTH, YESTERDAY (OCTOBER 23, 2010) DRIVING IN A CONSTRUCTION ZONE ON THE HIGHWAY, 40-45 MPH, CAME UP ON SLOWER TRAFFIC, BLEW A LINE, REAR-ENDED THE SMALL TRUCK IN FRONT OF ME AND SHOVED HIM DOWN THE ROAD. BOTH VEHICLES DAMAGED, MINE SUSTAINED SIGNIFICANTLY MORE DAMAGE. I PURCHASED THIS TRUCK FEBRUARY 1, 2007 WITH 60,119 MILES ON IT. I GENERALLY DRIVE MY VEHICLES MANY YEARS. I HAVE NEVER HAD THIS MANY BRAKE LINE ISSUES. MY FORD TRUCK WITH 135,000 NEVER HAD A LINE BLOW, 1995 THUNDERBIRD WITH 125,000 ONE LINE BLEW, 1991 T-BIRD, 214,000 MILES NEVER BLEW A LINE, I COULD GO ON, BUT NONE OF THE OTHERS HAVE BLOWN LINES EITHER. *TR

ALL THE STEEL BRAKE LINES ARE RUSTED TO THE POINT OF FAILURE. EVERYTHING ELSE ON THE TRUCK IS RELATIVELY RUST FREE, BUT THE STEEL BRAKES LINES ARE ROTTED OUT AND I DON'T HAVE SAFE BRAKES TO STOP ANYMORE. BRAKE PEDAL GOES TO FLOOR WHEN A LINE IS RUPTURED AND CAN'T STOP. NONE OF MY OTHER VEHICLES THAT ARE DRIVEN IN SIMILAR CONDITIONS SHOW THIS MUCH CORROSION ON THE BRAKE LINES AS THIS TRUCK DOES. THERE IS NO CORROSION PROTECTION ON THESE BRAKE LINES AT ALL.. I HAVE A BAD BACK AND IT WOULD BE VERY DIFFICULT TO REPLACE THE LINES MYSELF, AND I CAN'T AFFORD TO PAY A SHOP TO DO IT RIGHT NOW, SO I'M PRETTY MUCH PARKING IT FOR NOW.. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE TRAVELING AT AN UNKNOWN SPEED, THE FUEL GAUGE SHOWED AN ERRONEOUS READING OF EMPTY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL SENSING UNIT HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS NOT AVAILABLE AND THE CURRENT MILEAGE WAS 109,496. UPDATED 11/14/12*LJ UPDATED 11/19/2012 *JS

FUEL GAUGE GOES TO FULL,BACK TO EMPTY. LOW FUEL LIGHT COMES ON. THIS GOES ON ALL THE TIME YOU DRIVING THE VEHICLE. *TR

WHILE DEPRESSING THE BRAKES TO GO FROM PARK TO REVERSE, THE BRAKE PEDAL SUDDENLY SANK TO THE FLOOR. AFTER TOWING THE VEHICLE TO A GM DEALERSHIP, I LEARNED THAT IT WAS A BRAKE LINE FAILURE WHICH WAS DUE TO A RUPTURE IN THE CORRODED STEEL BRAKE LINES. I WAS TOLD THAT THIS WAS A COMMON PROBLEM WITH THIS MODEL YEAR TRUCK. THE RUPTURED LINE WAS REPLACED WITH A NON-CORROSIVE COPPER/NICKEL LINE. FORTUNATELY I WAS PARKED AT THE TIME OF THIS FAILURE OR THIS COULD HAVE EASILY CAUSED A SEVERE ACCIDENT. I QUESTION WHY GM WOULD USE CORROSIVE STEEL FOR A LIFE-SAFETY COMPONENT OF THE VEHICLE AND HAS NOT ADDRESSED THIS ISSUE EITHER THROUGH RECALL OR SAFETY BULLETIN. *TR

I WAS STOPPED AT THE MAILBOX REACHING OUT FOR THE MAIL WHEN THE BRAKE PEDDLE WENT TO THE FLOOR AND THE TRUCK ROLLED FORWARD ABOUT A FOOT. I WAS ABLE TO SLOWLY GET UP THE DRIVEWAY AND FOUND THE BRAKE LINES HAD RUSTED THROUGH. HAD TO REPLACE ALL THE LINES. *TR

METAL BRAKE LINE FAILURE DUE TO CORROSION WITH MASSIVE LOSS OF FLUID. EXPERIENCED LOSS OF BRAKES AT LOW SPEED, AND USED THE EMERGENCY BRAKE TO STOP. HAD LINE REPLACED. IN AUGUST 2012 I EXPERIENCE A SECOND FAILURE, AGAIN DUE TO METAL BRAKE LINE CORROSION BUT ON DIFFERENT LINE, AGAIN WITH MASSIVE LOSS OF FLUID AND LOSS OF BRAKES, LUCKILY AT LOW SPEED AGAIN. IF THIS HAD HAPPENED AT HIGH SPEED OR WITH A LESS EXPERIENCED DRIVER, IT COULD HAVE RESULTED IN SERIOUS PROPERTY DAMAGE AND INJURY OR FATALITY. THIS TRUCK IS LOCATED IN VA AND OTHER THAN THE BRAKE LINES HAS LITTLE UNDERSIDE CORROSION. I AM HAVING TO REPLACE ALL THE BRAKE LINES AT HIGH COST TO ENSURE SAFETY. THESE BRAKE LINE FAILURES ARE NOTED ALL OVER THE INTERNET ON LATE 90'S TO EARLY 2000'S CHEVY TRUCKS- THEY SEEM TO BE VERY COMMON. I HAVE VEHICLES THAT ARE DECADES OLD AND HAVE THEIR ORIGINAL BRAKE LINES. I SUSPECT DEFECTIVE BRAKE LINE MATERIALS ON THE TRUCK. *TR

I TOOK MY TRUCK FROM HOME IN CT INTO NYC FOR A FOLLOW UP DOCTOR APPT. AND THE LINES BLEW OUT ON THE WAY IN AND WE STILL HAD TO GET BACK TO CT WITH BRAKE FAILURE; HAD TO STOP 3X FOR BRAKE FLUID, NOT FUN LUCKY I MADE IT HOME ALIVE. I CANNOT BELIEVE GM HAS NOT RECALLED THIS PROBLEM. GM SHOULD MAKE THIS A PRIORITY AND PUT LIVES AHEAD OF PROFITS. I HAD BRAKE REPLACEMENT EXPENSES OF OVER $1300.00. I HAVE OWNED MORE THAN 8 TRUCKS (ABOUT 5 GM TRUCKS AND 3 CHEVY SUVS FROM 1980 TO NOW WITH MY CURRENT 2001 SILVERADO. WITH THE EXCEPTION OF THIS VEHICLE (SILVERADO), NEVER HAD A PROBLEM THE LINES RUSTING OUT. *TR

COMPLETE BRAKE FAILURE DUE TO RUPTURED LINE CAUSED BY EXCESSIVE CORROSION. AFTER APPLYING BRAKES AND RECEIVING SOME RESISTANCE, BRAKE PEDAL WENT COMPLETELY TO FLOOR. VERY MINIMAL BRAKING WAS AVAILABLE BY RAPIDLY PUMPING THE BRAKES AND LIBERAL USE OF THE PARKING BRAKE...I WAS ABLE TO FINALLY GET THE VEHICLE STOPPED AFTER TRAVELING ABOUT 2 BLOCKS. I WAS THANKFUL NO TRAFFIC OR PEDESTRIANS AS THE POSSIBILITY OF SERIOUS INJURY/DEATH AND PROPERTY DAMAGE WOULD HAVE BEEN EXTREMELY HIGH. AFTER SAFELY STOPPING THE VEHICLE I DISCOVERED ONE OF THE BRAKE LINES WHICH RUN ALONG THE LEFT FRAME RAIL IN A GROUP OF 4 LINES, HAD RUPTURED. ALL FOUR BRAKE LINES HAD SIGNIFICANT CORROSION...I THOUGHT BRAKE LINES WERE STAINLESS STEEL... I ALSO NOTICED MILD CORROSION ON THE ADJACENT FUEL LINE, WHICH APPEARED TO BE ALUMINUM. IT'S A GOOD THING I RECENTLY GOT MY PARKING BRAKE REBUILT...THE MIDDLE CABLE BROKE (ALSO FROM CORROSION AND IN ABOUT THE SAME AREA AS THE BRAKE LINE FAILURE) AND DURING REPAIRS THEY ENDED UP HAVING TO REPLACE THE BACKING PLATE AND ENTIRE EMERGENCY BRAKE ASSY, ALSO DUE TO CORROSION. I DO NOT HAVE A BOAT, NOR WOULD I CONSIDER MY VEHICLE TO HAVE BEEN EXPOSED TO EXCESSIVE SALT FROM ROADWAYS. *TR

REAR STEEL BRAKELINE FAILURE CAUSED BY RUST-THROUGH, CAUSING COMPLETE LOSS OF BRAKEFLUID. LEAK WAS AT BEND OVER FRAME BRACKET AND FITTING FOR FLEXIBLE RUBBER HOSE FOR REAR AXLE BRAKE . DID UNDER VEHICLE INSPECTION OF BRAKELINES ON VEHICLE, ALL BRAKELINES FRONT AND REAR NEED REPLACEMENT BECAUSE OF SEVERE RUST AND CORROSION. LINES BETWEEN MASTER CYLINDER AND ABS BRAKE CONTROLLER AND LINES TO ALL SERVICE BRAKES NEED REPLACEMENT. LOSS OF REAR BRAKES CAUSED REAR BRAKES TO FAIL. REMAINING FRONT BRAKES SYSTEM WOULD HAVE BEEN USELESS IF LOSS WAS AT HIGH SPEED. *TR

THE BRAKES FAILED IN TRAFFIC APPROACHING A STOP LIGHT. A SEVERE COLLISION WAS NARROWLY AVOIDED. THE MECHANIC DETERMINED THAT A BRAKE LINE BETWEEN THE ABS CONTROLLER AND THE MASTER CYLINDER HAD RUSTED THROUGH CAUSING A SUDDEN RUPTURE AND BRAKE FAILURE. IN ADDITION, ALL BRAKE LINES WERE FOUND TO BE SEVERELY RUSTED FROM END TO END. *TR

LUCKY I WAS SITTING AT A WENDY'S PICKUP WINDOW WHEN I FELT A POP AND MY BRAKE PEDAL WENT TO THE FLOOR. CHECKED AND FOUND THAT 2 OF MY BRAKE LINES HAD PIN HOLES LEAKING BRAKE FLUID. ALL BRAKE LINES ARE RUSTED ALONG WITH GAS LINE (FROM MASTER CYL TO ABS BLOCK AND BACK) IT IS SITTING AT A CHEVY DEALER IN VA BEACH BECAUSE THEY SAID COST OVER 3000 TO FIX OR TOTAL IT, GLAD IT HAPPENED WHEN I WAS REALLY DRIVING LIKE ON THE WAY HOME TO PA AFTER VAC. *TR

I LIVE IN A SECTION OF TOWN WHERE THERE ARE NUMEROUS, STEEP HILLS. ON THE WAY HOME, I BEGAN BRAKING TO KEEP BELOW THE 35MPH SPEED LIMIT, AND THE BRAKES WENT WAY FURTHER DOWN THAN NORMAL, BUT THE TRUCK SLOWED DOWN. SINCE I WAS VERY CLOSE TO HOME, I KEPT GOING ON MY WAY VERY SLOWLY. I DOWNSHIFTED ALL THE WAY DOWN TO FIRST GEAR THE NEXT TIME I NEEDED TO BRAKE (AT MY HOUSE), THIS TIME THE BRAKE WENT ALL THE WAY TO THE FLOOR AND FINALLY STOPPED WHEN I WAS STANDING ON THE BRAKE PEDAL WITH BOTH FEET. UPON LOOKING UNDER THE REAR OF THE CAR, I DISCOVERED THE RUSTY BRAKE LINE THAT HAD RUPTURED, AND SEVERAL OTHER BRAKE LINES AND FUEL LINES THAT WERE VERY RUSTY AS WELL. TRUCK REMAINS PARKED FOR NOW, TO REPLACE THE BROKEN LINE, (THE ONE THAT RUNS FROM THE ABS/PROPORTIONER TO THE REAR BRAKES) AND THE OTHER RUSTY BRAKE LINES AS WELL AS THE RUSTY FUEL LINES. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT WAS TRAVELING 45 MPH WHEN THE BRAKES FAILED TO WORK WHEN THE DEPRESSED. THE CONTACT DISCOVERED THAT THE BRAKE LINES HAD RUPTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 141,600 UPDATED 08/16/12*LJ THE CONSUMER STATED THERE WERE NO WARNING LIGHTS ON BFORE, DURING OR AFTER THE BRAKE LIGHTS. UPDATED 08/21/12

BRAKE PEDAL VIBRATES AND BUZZES. BRAKES DO NOT ENGAGE. VEHICLE WAS RECALLED AND REPAIRED FOR THIS BEFORE, AND NOW IT IS DOING IT AGAIN, SEVERAL YEARS LATER. *TR

MAKING A LEFT HAND TURN AFTER A STOP LITE PUT MY FOOT ON MY BRAKE PEDAL AND IT WENT TO THE FLOOR, ALMOST HIT CAR IN FRONT OF ME, STOPPED AND SAW MY REAR DRIVER SIDE LINE LEAKING. *TR

ABOUT A WEEK BEFORE THE STEERING GOT HARD STEERING THE INSTRUMENTAL LITES CAME ON WHEN I WAS DRIVING, THEN WENT OFF THREE DIFFERENT TIMES, THEN I WAS BACKING UP AND TURNING FAIRLY SHARP TO THE RIGHT WHEN THE MOTOR DIED. I STARTED THE ENGINE BACK UP AND MY STEERING WAS HARD TO STEER. ALSO EVERY TIME I TURNED TO THE RIGHT THE TIRE SOUND LIKE THE TIRE RUB ON SOMETHING BUT I NEVER SEEN ANY RUB MARKS ANY WHERE. I DO THINK THAT IF I WAS DRIVING DOWN THE STREET THIS COULD HAVE BEEN A VERY SERIOUS SITUATION. I HAVE CHECKED AND SEEN WHERE ALOT OF 2001 CHEVY SUBURBANS HAS HAD THIS PROBLEM AND I BELIEVE THIS IS SOMETHING THAT CHEVY SHOULD DEFINETLY RECALL AND CHECK NO MATTER HOW MANY MILES. *TT

STARTED TRUCK, WENT TO PUT IN GEAR AND BRAKE PEDAL WENT CLEAR TO FLOOR. LOOKED UNDER TRUCK AND HAD A PUDDLE OF BRAKE FLUID APPROXIMATELY UNDER THE FRONT OF THE DRIVER'S DOOR. UPON INSPECTION, THE LINE THAT WENT FROM THE ABS MODULE UP TO THE RIGHT FRONT BRAKE HAD RUPTURED (SMALL PIN HOLE). ALL THE BRAKE LINES ON THE TRUCK ARE ABOUT RUSTED THROUGH. THIS RUPTURE LEFT ME WITH NO BRAKES ON THE TRUCK. LUCKILY IT HAPPENED IN A PARKING LOT WHILE PUTTING IN GEAR INSTEAD OF WHILE TRYING TO BRAKE ON THE ROADS. *TR

I WAS PULLING INTO PARKING SPACE AND THERE WAS NO BRAKES ALSO HAPPENED WHEN I WAS PULLING OUT OF PARKING LOT OF STORE .I TOOK TO GM DEALER AND WAS TOLD THAT BOTH HUB BEARINGS WERE LOOSE AND THAT IS WHAT CAUSED ME TO LOSE ALL MY BRAKES. I HIT A CONCRETE HANDICAP SIGN WAS LUCKY NOT ANOTHER CAR IN FRONT OF ME. WHY WOULD GM MAKE A TRUCK THAT WOULD LOSE ITS BRAKES IF A BEARING WAS LOOSE I AM AFRAID TO DRIVE TRUCK THAT THE SAME THING MIGHT HAPPEN AGAIN AND MAYBE THE NEXT TIME I WON'T BE SO LUCKY. THERE WAS NO SIGN OF ANYTHING WRONG WITH THE EXCEPTION OF 4 DAYS EARLIER MY ABS LIGHT FLICKERED ON THEN OFF 1 TIME. REMAINED OFF AFTER THAT. *TR

MY 16 YR OLD SON DROVE THRU AN INTERSECTION WITH NO BRAKES. JUST AVOIDING AN ACCIDENT. I KNOW 4 OTHER PEOPLE THAT OWN THE SAME KIND OF VEHICAL WITH THE EXACT SAME PROBLEM. I WILL BE CONTACTING THEM SO THEY CAN ALSO FILL THIS COMPLAINT OUT. DO PEOPLE HAVE TO DIE TO GET THIS MESS FIXED UP ?????????? *TR

BRAKES WERE STAYING APPLIED AFTER BRAKING. SMELL OF BURNING BRAKES. BRAKES AND ROTORS WORN DOWN AND BRAKING DISTANCE WAS AFFECTED. BRAKE HOSES WERE FAILING AND HAD TO BE REPLACED ALONG WITH ROTORS AND BRAKE PADS. EMERGENCY BRAKE WAS WORN DOWN ALSO. REAR BRAKES AND ROTORS HAD BEEN REPLACED 7 MONTHS EARLIER. *TR

THE 1ST INCIDENT THIS YEAR HAPPENED IN MARCH 2012. WHILE TRAVELING DOWN A HILL AT 25 MPH I PRESSED ON THE BRAKE PEDAL AND IT WENT TO THE FLOOR. I HAD TO USE THE EMERGENCY BRAKE TO BRING THE TRUCK TO A STOP ON THE LEVEL AT THE BOTTOM OF THE HILL. THANK GOD THERE WAS NOT ANY ONE CROSSING THE STREET OR ANOTHER CAR IN FRONT OF ME. THE MECHANIC SAID THE LEFT REAR BRAKE LINE HAD RUPTURED FROM THE METAL LINE BEING CORRODED. COST $300.00 + TOWING. COST TO REPLACE ALL LINES IS OVER A $1,000.00. CANNOT AFFORD NEW TRUCK OR THAT TYPE OF EXPENDITURE AT THIS TIME. THE 2ND INCIDENT HAPPENED TODAY, MAY 2012. WHILE TRAVELING ON A LEVEL HIGHWAY AT 35 MPH A CAR PULLED OUT IN FRONT OF ME FROM A GAS STATION AND I HAD TO HIT THE BRAKES HARD. I FELT A PULSE IN THE BRAKE PEDAL AND IT WENT TO THE FLOOR. TO AVOID HITTING THE CAR I WENT UP OVER A VERY HIGH CURB, OVER A WALKWAY AND THROUGH A PARKING LOT. I JAMMED ON THE EMERGENCY BRAKE TO BRING IT TO A STOP. LOOKED UNDER THE TRUCK AND THE FRAME IS COVERED WITH BRAKE FLUID UNDER THE DRIVERS SEAT. ANOTHER GUY STOPPED TO SEE IF I WAS O.K.. I HAD HIM PRESS ON THE BRAKE PEDAL AND LOOKED UNDER THE TRUCK. YOU COULD SEE THE FLUID SQUIRTING OUT OF 2 CORRODED, RUPTURED BRAKE LINES. HAD THE TRUCK TOWED. I HAVE HAD PROBLEMS WITH METAL CORROSION ON THIS TRUCK SINCE DAY ONE. THE REAR BUMPER HAD EXTENSIVE RUST IN 3 YEARS. WENT TO DEALER, GOT THE RUN AROUND. I REPLACED ALL FOUR BRAKE ROTORS WITH LESS THAN 35,000 AND THE PADS WERE MAINTAINED DURING THIS TIME. WENT TO DE

THE BRAKES WENT OUT - NOT TOTALLY OUT I BUT HAD TO PUSH THE BREAKS ALL THE WAY TO THE FLOOR TO GET THE CAR TO SLOWLY STOP. I HAD VERY LITTLE STOPPING POWER. SHORTLY THEREAFTER (3- 4 MINUTES LATER ) THE INSTRUMENT BREAK WARNING LIGHT CAME ON. HAD I BEEN GOING ANY FASTER I WOULD HAVE SURELY BEEN IN A SERIOUS ACCIDENT. THE CAR WAS TOWED TO A CHEVROLET DEALER. THEY DISCOVERED A LEAKING BREAK LINE. THEY INDICATED THAT IT WAS A RESULT OF EXCESSSIVE RUST IN THE BREAK LINE. THE WARNING LIGHT SHOULD HAVE COME ON MUCH SOONER AND THE BREAK LINE SHOULD NOT HAVE RUSTED THROUGH. $3,000 LATER, IT WAS FIXED. *JS

I WAS DRIVING DOWN THE HWY AND MY BRAKES WENT COMPLETELY OUT. NO WARNING LIGHT THAT IS A LIE AND SO IS THE STATEMENT ABOUT IT SLOWLY COMING TO A STOP. LUCKILY I WAS GOING UP A HILL SO IT CAME TO A STOP THEN STARTED ROLLING BACKWARDS INTO ON COMING TRAFFIC AND I HAD TO GO OFF THE ROAD AND HIT A POLE AND BROKE MY TAILGATE OFF CAUSE THE TAILGATE PINS WERE RUSTED TO AND I LIVE IN ALABAMA. NO SALT ANYWHERE. THANKS CHEVY, NOW I CAN'T EVEN FIX THE TRUCK BECAUSE ITS GOING TO COST ME 1,000 DOLLARS. *TR

MY WIFE WAS ON AN ERRAND AND WHEN SHE GOT INTO THE TRUCK TO COME HOME THE BRAKE PEDDLE WAS SOFT AND WENT TO THE FLOOR BEFORE SHE WAS ABLE TO STOP. SHE WAS SCARED AND TESTED THE BRAKES AND FOUND THERE WAS SOME SO CAME HOME SLOWLY WITH A PLAN IN HER MIND TO HIT SOMETHING OTHER THAN ANOTHER CAR IN THE CASE THE BRAKES FAILED COMPLETELY. HAD THIS HAPPENED ON THE ROAD THERE MAY HAVE BEEN A CRASH. *TR

BRAKE LINE CORRODED AT ABS UNIT ALONG FRAME. *JS

THIS TRUCK HAS SEVERAL EXHAUST HEADER BOLTS THAT ARE BREAKING OFF. THIS IS A MAJOR DEFECT AND SHOULD BE A RECALL TO REPLACE THE EXHAUST HEADER BOLTS THEY SHOULD NOT BE BREAKING OFF AND THEY ARE CAUSING EMISSION ERRORS AND NEEDING MAJOR REPAIRS. *JS

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO K 1500. THE CONTACT WAS DRIVING 5 MPH WHEN THE BRAKE LINE FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 81,220.

I BELIEVE MY VEHICLE HAS SUFFERED SAME EXACT PROBLEMS OUTLINED IN NHTSA ACTION NUMBER: PE05020 AND RECALL CAMPAIGN NUMBER: 05V379000. WHEN TRYING TO STOP IN PARKING LOT OR PARKING GARAGE THE ABS WOULD ACTIVATE AT VERY LOW SPEEDS AND MY VEHICLE WOULD NOT STOP. I WOULD RUN INTO CEMENT WHILE CHOCKS OR BLOCKS THAT ARE DESIGNED TO STOP A CAR IN PARKING LOTS. THIS HAS HAPPENED 5-10 TIMES IN MY VEHICLE. IT HAS NOT HAPPENED IN THE PAST YEAR BUT I BELIEVE THIS IS BECAUSE THE ABS HAS BEEN DEACTIVATED BY VEHICLE. LAST MONTH I HAD TO SLAM ON BRAKES AND THEY LOCKED UP AND MY TRUCK SKIDDED OUT OF CONTROL, HAD TO RELEASE BRAKES TO REGAIN CONTROL. LUCKILY NO ACCIDENTS YET. *TR

MY DRIVERS SIDE HUB WENT OUT ABOUT 120,000 MILES. REPLACED IT, WENT OUT LESS THAN OVER YEAR LATER, THEN AGAIN LESS THAN 6 MONTHS LATER . TAILGATE LATCH BROKE BEFORE THEN, ABOUT ONE YEAR LATER, FUEL PUMP WENT OUT. FRONT RUNNING LIGHTS ALWAYS SEEM TO HAVE A LIGHT OUT. 2009 RACK AND PINION WENT OUT, REPLACED IT, THEN ONE YEAR LATER WENT OUT AGAIN.U JOINT WENT OUT ABOUT SAME TIME. AND IGNITION STUCK AND COULDN'T TAKE OUT OF GEAR OR TURN OFF. FUEL LINE UNCLIPPED AND DUMPED ALL MY GAS,2010 TRANSMISSION WENT OUT. NOW MY PASSENGER SIDE HUB ASSEMBLY HAS GONE OUT FOR FIRST TIME WITH ABS LIGHT ON AND WHEEL CLANKING AND SEPARATING. RACK AND PINION BLOWN ALSO. REPAIRS NOT CHEAP, AND ALWAYS HAPPENS AT FINANCIALLY BAD TIME. SO NOW IT SITS IN DRIVEWAY BROKE DOWN AND I'M TRYING TO FIND A HUB FOR CHEAP SO I CAN GET AROUND AGAIN TO WORK ETC. SEEMS LIKE EVERYTIME I FIX SOMETHING ANOTHER PART GOES OUT. NEVER HEARD ABOUT ANY RECALL PROBLEMS TILL NOW, AND WOULD LIKE TO KNOW ABOUT ANY OPTIONS OF GETTING REPAIR. ITS COSTING ME WEEKS OF OFF TIME FROM WORK. AND BILLS PILING UP, RENT PAST DUE, NO MONEY TO REPAIR, AND AFFECTING MY COULD'VE LIFE. ANY HELP APPRECIATED. I LIKE CHEVY, BUY JUST FEEL LIKE MINE SEEMS TO HAVE ALLOT OF PROBLEMS THAT HAS BEEN DESCRIBED IN YOUR PAGE I READ. IN FACT HAD EVERY PROBLEM LISTED PLUS .PLEASE HELP IF YOU CAN. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS GM IS NOT STANDING BEHIND THIS ISSUE. THIS IS CAUSING CO RELEASE, HIGH HEAT IN THE ENGINE COMPARTMENT, NOISE, AND AN EXPENSE THAT I SHOULD NOT PAY FOR. SOME STATES ARE NOT ACCEPTING THESE VEHICLES NOW FOR NOT MEETING THE EMISSION STANDARDS PLEASE LOOK IN TO THIS. IT IS A SAFETY HAZARD. *TR

WHILE IN MOTION, A COMPONENT IN THE DIFFERENTIAL FAILED, CREATING AN INTERFERENCE CONDITION LOCKING UP MY REAR END. LUCKILY I WAS NOT TRAVELING AT HIGHWAY SPEEDS, AND WAS JUST AROUND TOWN, TRAVELING AT ABOUT 30 MPH. THERE WAS NO WARNING OF PARTS FAILING. THERE WAS AMPLE GEAR OIL IN THE REAR END, AND MAINTENANCE WAS NOT A FACTOR AS I DID A GEAR OIL CHANGE THIS PAST SUMMER. I SELDOM USE THIS VEHICLE TO TOW AND IT HAS NEVER SEEN A PLOW OR OVERLY ROUGH DRIVING CONDITIONS. *KB

FUEL GAUGE GOES EMPTYTO FULL CONSTANTLY. DEALER SAYS IT WILL COST 8 TO 900.00 DOLLARS TO FIX. IF I AM MISKAKEN THIS PART OF FUEL PUMP ASSY. *TR

I PURCHASED MY VEHICLE IN MARCH OF 2011 AND SINCE HAVE NOTICED A SIGNIFICANT AMOUNT OF RUST ON ALL THE BRAKE LINES GOING AND COMING FROM THE ABS MODULE UNDER THE DRIVER'S SIDE FRAME RAIL. I HAVE READ MANY CASES OF OWNERS THAT HAVE HAD THEIR LINES BURST IN AS LITTLE AS 2 YEARS AFTER PURCHASE FROM THE DEALERSHIP. I AM VERY CONCERNED ABOUT THE SAFETY OF OPERATION OF MY TRUCK WITH THE BRAKE LINES CORRODED TO THE EXTENT THAT THEY ARE AND HOPE THAT GENERAL MOTORS WILL DO THE RIGHT THING AND FIX THIS SAFETY HAZARD. THERE IS ALSO A SIGNIFICANT AMOUNT OF RUST ON THE ENTIRE UNDERSIDE OF THE VEHICLE (FRAME RAILS, BOLT LOCATIONS, WELD LOCATIONS, UNDERSIDE OF BUMPERS, ECT). *TR

RUSTING FUEL LINE CAUSED A SIGNIFICANT FUEL LEAK IN THE REAR OF THE VEHICLE NEAR THE FUEL TANK, WHILE REPAIRING THAT LINE I OBSERVED SEVERAL OTHER RUSTING LINES IN THAT AREA BRAKE, AND MORE FUEL LINES. *TR

MY BRAKE LINES ARE CORRODED AND THIS IS A KNOWN ISSUE. I FEAR THIS IS A SAFETY ISSUE AND SHOULD BE RECALLED BY GM. *TR

WHILE PULLING INTO MY PARKING AREA AND BRAKING, THE BREAK PEDAL WENT TO THE FLOOR. A HISSING SOUND WAS HEARD WHILE THE PEDAL WAS BEING PUSHED. UPON INSPECTION A BREAK IN THE BRAKELINE UNDER THE DRIVER'S SIDE CAB WAS IDENTIFIED AT THE HANGER. BASED UPON VISUAL INSPECTION THEIR APPEARS TO BE CORROSION AROUND THE BREAK IN THE LINE. *TR