2000 Chevrolet Malibu complaints

ROTORS AND PADS WERE REPLACED AT 7832 MILES. ROTORS RESURFACED AND PADS REPLACED AT 22000 MILES. ROTORS AND PADS AGAIN REPLACED AT 29134 MILES. I WAS TOLD BY BOTH DEALERSHIPS THAT I HAVE HAD MY CAR IN TO THAT THEY WILL HAVE TO JUST KEEP REPLACING THEM UNTIL THEY HAVE THE FIX FOR THE PROBLEM. I FEEL VERY UNSAFE KNOWING THERE IS A DEFECT IN MY BRAKES THAT IS NOT REPAIRABLE. AFTER READING ON THE NHTSA WEBSITE, IT APPEARS THIS DEFECT IS HAPPENING MORE AND MORE OFTEN IN 2000 MALIBUS. I AM GOING TO PURSUE GM TAKING MY CAR BACK.*AK

THE BRAKES ARE BEING REPLACED ALL THE TIME. CHEVY CONTINUES TO SAY ITS JUST NEEDS BRAKE PADS EVERY THREE MONTHS. THE FRONT BRAKES SOUND LIKE THE CAR IN FALLING APART. THERE HAS TO BE A PROBLEM WITH THE COMPLETE BRAKE SYSTEM. *AK

ON FOUR ORGINAL EQUIPMENT FIRESTONE, INFINITY TIRES SIZE P215/60R15 WITH FOURTY THOUSAND MILES TREADS WERE BEGINNING TO CRACK. DEALER HAS BEEN CONTACTED AND HAS REPLACED ALL FOUR OF THE DEFECTIVE TIRES. *AK *TT

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

VEHICLE STALLED WHILE DRIVING 60-70 MPH, THEN AGAIN 3 DAYS LATER. VEHICLE TAKEN TO DEALER BOTH TIMES, COULD NOT FIND CAUSE.

VEHICLE WOULD JUMP WHEN TRYING TO STOP. ROTORS WERE WARPED. CONSUMER HAD TO PUT ON 5 SETS OF ROTORS SINCE JAN 2001. CONTACTED DEALER WHO WANTED CONSUMER TO EXTEND WARRANTY.*AK THE CONSUMER STATED THAT THE FRONT ROTORS ARE WARPED CAUSING BRAKE PULSATION. THE A/C DOES NOT FLOW OUT OF THE CORRECT VENTS DUE TO A/C CONTROL FAILURE, THE A/C CONTROL HEAD ALSO SHORTED OUT. THE DOOR WAS HARD TO OPEN AND CLOSE DUE TO THE LOCK BEING MISALIGNED. ENGINE MAKES A CLUNK NOISE. WHILE DRIVING THE VEHICLE SURGES. LEFT REAR SPEAKER SHORTED OUT. THERE IS A CLICKING NOISE COMING FROM THE FRONT WHEN TURNING, CONSUMER LATER STATED THAT THERE WAS A CHIRPING NOISE COMING FROM THE STEERING COLUMN. *YH

ROTORS GLAZING TWICE WITHIN 21,000 MILES. WAS TOLD THE ROTORS COULD BE REPLACED,BUT EXPECTED IT TO HAPPEN AGAIN DUE TO A KNOWN PROBLEM WITH THE ROTORS.

VIN IS [XXX] MANUFACTURED 05/00. RAIN WATER COLLECTS AND IS RETAINED IN RIGHT TAIL LIGHT ASSEMBLY. ONE LAMP OF FOUR SHORTED AND BLEW. ASSEMBLY IS INADEQUATELY SEALED AND INSULATED AGAINST WATER. COST OF NEW REPLACEMENT TAIL LIGHT ASSEMBLY IS $249.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ALTHOUGH THE DEALER SAYS THAT THE BRAKES ARE DESIGNED TO PRODUCE A SLIGHT CLICKING NOISE WHEN THE PADS BEGIN TO WEAR, NO SUCH NOISE WAS HEARD. WITH ONLY 23,450 MILES ON CAR, THE PADS ON ONE SIDE OF THE ROTOR WORE DOWN CUTTING GROOVES INTO THAT SIDE OF THE ROTOR WHILE PADS ON OTHER SIDE OF SAME ROTOR HAD A WAY TO GO BEFORE BEING WORN DOWN. I UNDERSTAND THIS SAME PROBLEM OCCURRED ON THE CHEVROLET S10 AND FOR WHICH THE S10 WAS RECALLED. DEALER SAID IT IS NOT UNCOMMON FOR ROTORS TO GO BAD SOON AS PADS WEAR OUT ON THE MALIBU. IT IS RIDICULOUS TO HAVE TO PAY FOR ROTORS EACH TIME THE PADS GO BAD, ESPECIALLY AT ONLY 23,000 MILES.*AK

BOUGHT MY CAR NEW OFF SHOW ROOM FLOOR AND HAVE HAD NUMEROUS PROBLEMS SINCE HAD IT IN FOR STARTING PROBLEMS BATTERY PROBLEMS FUEL PROBLEMS WINDOW PROBLEMS DOOR LOCK PROBLEMS ENGINE NOISE ENGINE OIL LEAKS VIBRATION PROBLEMS BRAKE PROBLEMS DYING PROBLEMS POPPING NOISES IN FRONT END STRUTS BOTTOMING OUT ROUGH RIDE AND STEERING PROBLEMS AND SO ON TOO MANY TO LIST ALL HAVE HAD FRONT END REALIGNED STUTS CHECKED AND REPALCED BRAKES CHECKED AND REPLACED WHEEL STUDS REPLACED FUEL PUMP AND FLOAT REPLACED PISTONS REPLACED BATTERY REPLACED REMOTE START SYSTEM REPLACED ALARM SYSTEM REPLACED WINDOW REGULATOR REPLACED FRONT CRANK SEAL REPLACED ALT CHECKED AND TESTED STARTED CHECKED STILL HAVING FUEL PROBLEMS BRAKE PROBLEMS VIBRATION ECT HAD IN THIS LAST WEEK FO 6 DAYS AND WHEN RETURNED STILL HAVING ENGINE NOISE STEERING PROBLEMS RADIO PROBLEMS FUEL PROBLEMS AND FOUND IMPACT MARK ON L/FRONT OF BUMPER ONE OF DEALERS TECH'S HIT SOMETHING AND NOW WANDERS TO LEFT LEFT HEAD LIGHT OUT OF LINE AND PUSHED BACK UNDER FENDER HOOD OUT OF LINE FENDERS BUMPERS DRIVING LIGHTS AND NUMEROUS OTHER PROBLEMS AND DAMAGE POSSIBLE THAT I AM UNABLE TO DETECT AT THIS TIME HAVE CONTACTED CHEVY AND COMPLAINED HAVE TALKED WITH DEALER AND STILL NO RESPONSIBILITY TAKEN AND STATEMENTS OF WE MIGHT HAVE BRUISED IT IT HAS BEEN WRECKED NOW I AMD PAYING GOOD MONEY FOR JUNK AND WANT REFUND OF ALL COSTS TO ME AND THE CAR TAKEN BACK ENGINES SHOULD NOT NEED TO BE OVERHAULED AT 14000 MILES THE CAR IS 2 YAERS OLD AND ACTS LIKE ITS 2

3 MONTHS AFTER I BOUGHT MALIBU IN JULY, 2000 I WAS DRIVING AT 65 MPH WHEN MY CARE LOST ALL POWER. DEALER TOLD ME THAT THERE WAS SOMETHING WRONG WITH THE FUEL INDICATOR WIRING AND WAS FALSELY READING THE AMOUNT OF GAS I HAD WHICH RESULTED IN MY RUNNING OUT OF GAS AT 65MPH. PROBLEM HAS NOT REPEATED ITSELF. AT 21,000 MILES MY SIGNAL INDICATOR LIGHTS FAILED AND MY HAZARD SWITCH HAD TO BE REPLACED. AT 23,000 MILES MY EVAPORATOR VENT VALVE HAD TO BE REPLACE (ENGINE LIGHT REMAINED ON CONSTANTLY). AT 20,000 MILES MY CAR WAS VIBRATING WHENEVER MY BRAKES WERE APPLIED. DEALOR SAID FRONT BRAKES WORN OUT AND ROTORS OUT OF ROUND AND THEY REPLACED THE FRONT BRAKES AND REFACED THE ROTORS. AT 33,000 MILES, CARE AGAIN VITRATED WHENVER BRAKES APPLIED AND DEALER TOLD ME AGAIN THAT IT WAS NOT UNDER WARRANTY AND WAS HAPPENING BECAUSE OF "HOT SPOTS" AND THAT MY ROTORS NEEDED TO BE CUT EVEN THOUGH THEY HAD JUST BEEN FIXED AT 20,000 MILES. WAS NEVER TOLD THAT MANUFACTURER WAS HAVING A PROBLEM WITH MALIBU BRAKES AND WAS TOLD IT WOULD COST APPROXIAMTELY $700.00 TO FIX ROTORS AND IT WAS MY RESPONSIBILITY. MY SEVICE FOR THE BRAKES WAS DONE AT FUTURE CHEVROLET IN OLD BRIDGE, NJ. *AK

CONSUMER STATES THAT THE BRAKES ARE TERRIBLE, THE DEALER STATED THEY COULD DO NO MORE AND THAT THE BRAKING SYSTEM IN THE MALIBU CARS ARE DEFICIENT, CONSUMER IS CONCERNED AND DOES NOT FEEL SAFE DRIVING THE VEHICLE. *SLC

VEHICLE WAS GOING 25MPH ON A STRAIGHT ROAD. THERE WAS NO WARNING AND LEFT FRONT END DROPPED. LEFT TIRE BLEWOUT, AND VEHICLE SKIDDED/ HIT THE CURVE. LOWER BALL JOINT BROKE, CAUSING REAR END TO SPIN AROUND. MANUFACTURER HAD A TSB MENTIONING PROBLEM ,BUT WILL NOT COVER THE PROBLEM WITHIN WARRANTY AGREEMENT.*AK

THE BRAKING SYSTEM ON THE 2000 CHEVROLET MALIBU IS INADEQUATE. MY VEHICLE HAS 31000 MILES ON IT AND DURING BRAKING IT HAS A SHIMMY ON OCCASIONS. THE DEALER STATED THIS WAS DUE TO THE BRAKE PADS BEING WORN AND THE BRAKE ROTORS NEEDED TURNING. I'VE DONE SOME RESEARCH AND THIS AND SOME TIRE PROBLEMS SEEMS TO BE A MAJOR COMPLAINT FROM OTHER MALIBU OWNERS WHO'S PROBLEMS HAVE STARTED SOONER THAN MINE IN MOST CASES IN FACT IN SOME CASES WHILE THE CAR IS STILL UNDER THE 12000 MILE WARRANTY. IT BEING A BRAKE AND TIRE PROBLEM SEEMS TO BE PUTTING SOME LIVES AT STAKE. I MYSELF CONTACTED CHEVROLET ABOUT THIS PROBLEM AND THEY SIMPLY STATED I'M SORRY YOUR HAVING PROBLEMS WITH YOUR CAR. *AK

THE BRAKE SYSTEM WAS NOISY AND WAS SERVICED SIX DIFFERNT TIMES, BUT THE PROBLEM STILL REMAINS. ROTORS AND DRUMS WERE BADLY WARPED CAUSING PULSATION WHEN BRAKES WERE APPLIED. *YH

WITHIN THE FIRST 18000 MILES I HAD TO REPLACE AMY FRONT ROTORS. WHEN I ASKED THE DEALERSHIP IF IT WAS COVERED UNDER WARRANTY, THEY SAID NO. I HAD TO PURCHASE NEW ROTORS AND THEN WITHIN 8,000 MILES THEY STARTED GRINDING AGAIN. WHEN THE ROTORS GO BAD, IT MAKES THE CAR SHIMMY WHEN DRIVING AT SLOW SPEEDS AND WHEN I STOP. I CURRENTLY HAVE MY CAR IN A SHOP OTHER THAN THE DEALERSHIP TO PUT ON THE THIRD SET OF ROTORS AND I ONLY HAVE 32800 MILES ON THE CAR. THE DEALERSHIP TELLS ME THAT I HAVE TO PAY THEM $35 FOR THEM TO LOOK AT MY CAR AND SEE IF THEY CAN FIND A MANUFACTURER'S DEFECT ANYWHERE. I CAN NOT AFFORD TO PAY THEM THAT AMOUNT BECAUSE I AM CONSTANTLY PAYING TO HAVE NEW ROTORS PUT ON. NOT TO MENTION I HAVE TO MISS WORK A LOT FOR VARIOUS TRIPS TO THE DEALERSHIP DUE TO FAULTY BLINKERS, KNOCKING NOISES, LIGHTS SURGING, ETC. WHEN PEOPLE DON'T WORK, THEY DON'T GET PAID!*AK

VEHICLE STALLS AT ANY SPEED/ANY TIME ON A DAILY BASIS. DEALER CANNOT FIND PROBLEM.*AK

HAD ROTORS REPLACED DUE TO EXCESSIVE WEAR. HAD THEM REPLACED AGAIN AT 19,000 MILES. FIRST TIME REPLACED UNDER WARRANTY. REPLACEMENT PARTS WERE THE SAME AS ON VEHICLE. MANUFACTURER KNEW OF PROBLEM , AND HAD A TECHNICAL SERVICE BULLETIN ON ROTORS.*AK WHEN BRAKING AT HIGH SPEED, THE CONSUMER FELT BRAKE PULSATION. BOTH THE BRAKE PADS AND ROTORS WERE REPLACED. *YH

ROTORS ON BRAKES HAVE WARPED 3 TIMES BEFORE 20000 MILES! *AK

BRAKE PADS HAVE BEEN REPLACED 4 TIMES SINCE 14,000 MILES. THE ROTORS VIBRATE AND SHIMMY WHEN APPLYING THE BRAKES. TRYING TO GET THE DEALER TO INVESTIGATE THE PROBLEM IS A HASSLE. THEY SAID THAT BECAUSE I HAVE MY PREVENTATIVE MAINTENANCE DONE BY MY OWN PERSONAL *CERTIFIED* MECHANIC AND NOT AT THE DEALER THAT I HAVE VOIDED MY WARRANTY ON THE ROTORS. THEY WANT TO CHARGE ME $200 + FOR THE REPLACEMENT OF THE ROTORS. I HAVE SPOKEN WITH SEVERAL OTHER MALIBU OWNERS WHO HAVE HAD THIS SAME PROBLEM. IT IS MY OPINION THAT A RECALL SHOULD BE MANDATED AND ENFORCED FOR THIS PARTICULAR PROBLEM WITH THIS VEHICLE. I HAVE NEVER OWNED A CAR THAT I HAD TO REPLACE THE BRAKE PADS EVERY TIME I PULLED INTO A GAS STATION. THANK YOU!

WITHIN THREE MONTHS DEALER HAD TO TURN BOTH FRONT BRAKE ROTORS, AND GAVE NO REASON WHY THIS PROBLEM WAS REOCCURRING. *AK *SLC

WHILE DRIVING, FIRESTONE AFFINITY TIRE BLEWOUT, VEHICLE JUMPED A LANE AND LANDED IN ANOTHER LANE, CONSUMER WAS INJURED IN ACCIDENT, FIRESTONE TIRE SIZE P205/60R15 93T, CLAIM 31-3083-344. *SLC

RIGHT FRONT TIRE BLEWOUT WHILE DRIVING, CONSUMER LOST CONTROL AND HIT FIREPLUG, FIRESTONE AFFINITY, P215/60R15, CLAIM 35-W577-593. *SLC

WHILE DRIVING, TIRE BLEWOUT, STEERING COLUMN LOCKED AND CONSUMER WAS UNABLE TO STEER VEHICLE, CONSUMER STATES A WEEK PRIOR TO THIS, THE FRONT TIRES BEGAN SPINNING BEFORE THE VEHICLE STARTED TO MOVE AND THE PAVEMENT WAS NOT WET, FIRESTONE AFFINITY, P215/60R15, CLAIM 20-5363-226. *SLC

WHILE DRIVING, TIRE EXPERIENCED TREAD SEPARATION, FIRESTONE AFFINITY, P215/60, CLAIM 49-3233-848. *SLC

WHILE DRIVING, FIRESTONE AFFINITY TIRE BLEWOUT, VEHICLE JUMPED A LANE AND LANDED IN ANOTHER LANE, CONSUMER WAS INJURED IN ACCIDENT, FIRESTONE TIRE SIZE P205/60R15 93T, CLAIM 31-3083-344. *SLC

RIGHT FRONT TIRE BLEWOUT WHILE DRIVING, CONSUMER LOST CONTROL AND HIT FIREPLUG, FIRESTONE AFFINITY, P215/60R15, CLAIM 35-W577-593. *SLC

WHILE DRIVING, TIRE BLEWOUT, STEERING COLUMN LOCKED AND CONSUMER WAS UNABLE TO STEER VEHICLE, CONSUMER STATES A WEEK PRIOR TO THIS, THE FRONT TIRES BEGAN SPINNING BEFORE THE VEHICLE STARTED TO MOVE AND THE PAVEMENT WAS NOT WET, FIRESTONE AFFINITY, P215/60R15, CLAIM 20-5363-226. *SLC

WHILE DRIVING, TIRE EXPERIENCED TREAD SEPARATION, FIRESTONE AFFINITY, P215/60, CLAIM 49-3233-848. *SLC

CRACKING BETWEEN TREAD. *AK (TIRESIZE: P21560R15)

WHILE DRIVING AND WITHOUT A COLLISION OCCURRING DRIVER'S AND PASSENGER'S AIR BAGS DEPLOYED, CAUSE UNKNOWN. *AK CONSUMER STATES THE DAYS PREVIOUS TO THE DEPLOYMENT OF THE AIRBAGS, THE ELECTRICAL SYSTEM GAVE SIGNS THAT IT WAS NOT WORKING PROPERLY, THE ALARM WAS GOING OFF FOR NO REASON, CONSUMER WAS INJURED. *SLC

THE CAR HAS A PING IN THE MOTOR AND COOLING SYSTEM OVERHEATS.

WHILE DRIVING, CONSUMER EXPERIENCED DIFFICULTY HANDLING THE VEHICLE, WHEN SHE PULLED OVER SHE SAW THAT THE FIRESTONE AFFINITY TIRES SIDEWALL HAD COME AWAY FROM THE REST OF THE TIRE, FIRESTONE HAS REFUSED TO REPLACE THE OTHER TIRES, REIMBURSE HER FOR THE REPLACEMENT TIRE, OR REIMBURSE HER FOR THE TOWING CHARGE, THE TIRE SIZE IS P215-60R15. (ATTORNEY FOR CLIENT) *SLC

WHILE DRIVING, VEHICLE WAS HESITANT AFTER STOPPING, TRANSMISSION WOULD BEGIN TO SHIFT EVERY 4 SECONDS, DEALER STATED THAT A PIECE OF METAL FROM THE FRONT PUMP OF THE TRANSMISSION HAD COME OFF AND SENT PIECES OF METAL CIRCULATING THROUGH THE ENTIRE TRANSMISSION, CONSUMER WAS TOLD THAT SINCE THE TRANSMISSION WAS SEALED THAT IT WAS NOT ANTICIPATED THAT THE METAL PIECES WOULD AFFECT THE OTHER SYSTEMS OF THE VEHICLE, DEALER MADE REPAIRS AND ONE MILE DOWN THE ROAD TRANSMISSION BEGAN ACTING POORLY AGAIN, CONSUMER TOOK BACK TO DEALER WHO STATED THAT TRANSMISSION WAS STUCK IN SECOND GEAR, DEALER REPLACED TRANSMISSION. OXYGEN SENSOR FAILED. ROTORS WARPED AND WERE CAUSING VIBRATION, DEALER REPLACED PADS AND ROTORS. BATTERY LEAKED ACID INTO ENGINE COMPARTMENT. COOLANT CAP WAS DEFECTIVE AND REPLACED. *SLC

2000, CHEVROLET, MALIBU BROADSIDED ANOTHER VEHICLE AT APPROXIMATELY 25 MPH, AND BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. CONSUMER SUSTAINED KNEE INJURIES AND WAS TAKEN TO HOSPITAL.*AK THE ENTIRE FRONT HOOD WAS KNOCKED TO WINDSHIELD, CONSUMER IS STILL UNDERGOING PYSICAL THERAPY FOR INJURIES. *SLC

THE BRAKES ON THE MALIBU ARE A SAFETY ISSUE AND GMC DOESNT CARE. I HAVE HAD THE ROTORS DONE 5 TIMES SINCE 3000 MILES. MY DEALER HAS HAD MY CAR FOR A TOTAL OF 19 DAYS FOR REPAIRS. THERE ARE NUMEROUS OTHER PROBLEMS WITH THIS CAR ALSO. IAM TIRED OF BEING TOLD I6TS NOT A SAFETY ISSUE, WELL IT IS TO ALL OF WITH CHILDREN AND OTHER LOVED ONES IN THE CAR. LETS STOP THE POLITICS AND PLEASE DO SOMETHING FOR THE CONSUMER.*AK (TIRESIZE: 215)

WHEN APPLYING BRAKES AT 40 MPH VEHICLE SHAKES. DEALER REPLACED FRONT ROTORS AT 3000 MILES. HOWEVER, PROBLEMS PERSISTED, DEALER DID NOT REPLACE ROTORS AGAIN. LAST VISIT TO DEALER CONSUMER WAS ESCORTED OFF THE LOT. DEALER REFUSED TO LOOK AT VEHICLE. *AK CONSUMER ALSO STATES THERE IS A FULE SYSTEMS PROBLEM, THE FUEL WILL SPLASH BACK AT CONSUMER WHEN FILLING UP TANK, AND A LOT OF FUEL SPILLS ON THE GROUND, ALSO THE REAR BRAKES IN WET WEATHER, HOWL WHEN ACCELERATING.*JB

FRONT BRAKE ROTORS ARE WEARING EXCESSIVELY. CONSUMER HAS REPLACED BRAKE ROTORS ON FOUR DIFFERENT OCCASIONS. ALSO, WHEN APPLYING BRAKES TO MAKE A GRADUAL STOP VEHICLE SKIDDED TO A STOP, CAUSING EXTENDED STOPPING DISTANCE. CONSUMER HAS CONTACTED DEALER. MANUFACTURER LINKED THE PROBLEM TO NON-ADJUSTMENTS TO BRAKES. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

CONSUMER STATES FRONT BRAKES AND ROTORS HAVE BEEN REPLACED TWICE, AND MASTER CYLINDER HAS BEEN REPLACED ONE, AND NOT SURE IF PROBLEM HAS BEEN CORRECTED.*JB

KEY WAS IN THE IGNITION IN A ACC POSITION WHEN CONSUMER'S NEPHEW CHANGED GEARS WITHOUT DEPRESSING BRAKE PEDAL, CAUSING VEHICLE TO ROLL DOWN THE HILL. DEALER HAS BEEN CONTACTED FOR THIS PROBLEM, BUT STATED THAT IT WAS NORMAL FOR THOSE TYPES OF VEHICLES. CONSUMER CHECKED OWNERS MANUAL AND FOUND THAT BRAKE PEDAL HAD TO BE DEPRESSED IN ORDER TO CHANGE GEARS. *AK

THE DEALER HAS ATTEMPTED TO FIX THE CONSUMERS BRAKES ON FOUR OCCASIONS WITH NO SUCCESS, THE CONSUMER BELIEVES THAT THE LEMON LAW APPLIES TO THIS VEHICLE. NLM

TICKING SOUND AT STARTUP THAT CHEVROLET WON'T FIX. NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

THE BRAKES HAVE CONTINUALLY FAILED EVERY 3 MONTHS SINCE 3000 MILES. THE CAR IS NOT SAFE FOR MY WIFE AND CHILDREN. THE CAR SHOULD BE RECALLED AND REPURCHASED BY GM. GM TOLD ME MS KAREN ROBERTS THAT THEY ARE AWARE OF THE PROBLEM, BUT ITS NOT A SAFETY ISSUE UNTIL SOMEONE GETS HURT.. ARE THEY CRAZY? THE MALIBU IS AN UNSAFE CAR. EVEN MY SERVICE ADVISOR HARRY HAIGH SAID THE CAR SHOULD BE REPLACED. THE MALIBU IS AN ENGINEERING NIGHTMARE. *AK (TIRESIZE: P215/60/R1)

BRAKES SHIMMIED BADLY. APPARENT BRAKE PROBLEM. DEALER KNEW PROBLEM BEFORE I FINISHED TELLING THEM OF PROBLEM. DEALER REPLACED WARPED BRAKE ROTORS AND BRAKE PADS. RESEARCHED PROBLEM AND DISCOVERED HUNDREDS OF SAME IDENTICAL PROBLEM AND COMPLAINTS. CONCERNED BECAUSE OTHER CONSUMERS ARE HAVING SAME PROBLEM FIXED OVER AND OVER FOR DEFECTIVE DESIGN. I AM CONCERNED ABOUT THE SAFETY ISSUE OF THE BRAKE SYSTEM ON THIS CAR. *AK

I HAVE BEEN HAVING PROBLEMS WITH MY BRAKES ON MY 2000 CHEVROLET MALIBU SINCE I PURCHASED MY VEHICLE. DOUG CHEVROLET KEEPS REPLACING THE PADS AND ROTATION OF BRAKES. ON 7/23/01 MY CAR WILL BE IN THE SERVICE DEPARTMENT FOR THE SAME REPAIRS. I SPOKE TO GM'S CUSTOMER SERVICES DEPT ON/AROUND 7/11/01. I WAS TOLD BY A CUSTOMER SERVICE REP AT GM, DOUG CHEVEROT WILL HAVE TO FIX THE PROBLEM WITH MY CAR. ON 7/16/01 I WAS TOLD BY DOUG CHEVROLET EMPLOYER (S) GM KNOWS THERE IS A PROBLEM WITH BRAKES AND THEY ARE NOT RECALLING CHEVROLET MALIBU'S. I FEEL THAT WITH MY PROBLEMS I'VE BEEN HAVING WITH THE BRAKES ARE JUST MORE THAN THE PADS AND ROTATION OF BRAKES. ONCE MY CAR IS SERVICED I WILL BE FILING A DISPUTE FORM WITH GMC. *AK

IT HAS HAD A TRANSMISSION FAILURE,BRAKE AND ROTOR FAILURE 4 DIFFERENT TIMES,RACK AND PINION FAILURE,CONTROL ARM FAILURE 2 TIMES,IGNITION CONTROL FAILURE AT 1400 MILES. *AK

ENGINE CUT OFF WHILE DRIVING ON FREEWAY 6-8 TIMES. DEALER REPLACED WIRING AND STATED THEY HAVE BEEN HAVING THAT PROBLEM. 2 WEEKS LATER HAPPENED AGAIN. *AK

HARNESS STRAP DETACHES FROM SHIELD RENDERING CAR SEAT UNSAFE.*AK

FRONT ROTORS WARPED, AND WERE REPLACED BY DEALER WITH 20,182 MILES. AGAIN, BRAKES WERE WARPED, DEALER TURNED FRONT ROTORS, AND ADVISED CONSUMER THAT IT WAS SIMPLY A WEAR AND TEAR ITEM. *AK *SLC

TIRES CRACKED INBETWEEN TREAD. *AK (TIRESIZE: P215/60R15)