2007 BMW 335i complaints

FIRST NOTICED A BURNING SMELL -- THOUGHT IT MAY BE PLASTIC OR RUBBER. PULLED OFF OF THE HIGHWAY NEAR TAMPA TO A LOCAL GAS STATION. LOOKED UNDER THE HOOD, NOTICED NOTHING. THEN NOTICED SMOKE COMING FROM THE SPACE WHERE THE REAR WINDOW ROLLS UP, ON THE DRIVERS SIDE. SMELLED LIKE BURNING RUBBER OR PLASTIC. CALLED BMW ASSIST, WAS TOLD TO GET A TOW TO THE NEAREST DEALER. AFTER ABOUT AN HOUR, CALLED TO BMW TO TALK WITH A SERVICE TECHNICIAN -- DESCRIBED THE PROBLEM TO THE TECHNICIAN AND ASKED IF I COULD DRIVE THE CAR TO THE DEALERSHIP. SERVICE ADVISOR INDICATED THAT GIVEN THE SMOKE, WOULD ADVISE AGAINST DRIVING THE CAR. CAR TOWED TO DEALERSHIP AND INSPECTED BY DEALER THE FOLLOWING MORNING. DEALER ADVISED THAT THE "DASH REFLECTED MESSAGE OF PINCH PROTECTION MALFUNCTION. JBE MODULE CAUSED FAILURE OF BOTH REAR WINDOW MOTORS, INTERROGATE FAULT MEMORY. FOUND FAULTS IN JBE, A6D9, A6DA, A6D8, A6DB. COMPLETED TEST PLAN FOR THESE FAULTS. PER TEST PLAN REPLACE JBE. SWAPPED IN JBE FROM KNOWN GOOD VEHICLE." ESSENTIALLY, THE DEALER REPLACED THE EXISTING SOFTWARE IN THE CAR WITH THE SOFTWARE FROM A CAR KNOWN TO HAVE GOOD SOFTWARE. DEALER FOUND BOTH WINDOW MOTORS "BURNED" AND REPLACED BOTH WINDOW ROLL-UP MOTORS. DEALER COMPLETED VEHICLE PROGRAMMING INCLUDING "CAS". COMPLETE CAR ENCODING. *TR

THIS IS A SECOND COMPLAINT OF THE SAME EXACT PROBLEM THAT I HAD PREVIOUSLY IN APRIL 2008. THE ODI ID NUMBER IS: 10227507. ON THE EVENING OF JAN. 2ND, 2010, THE REPLACEMENT FUEL PUMP FAILED WHILE I WAS DRIVING THE CAR AS I WAS MAKING AN APPROACH TO THE ONRAMP ONTO THE FREEWAY. THE CAR SHUDDERED, RATTLED, AND LOSS POWER AND EVENTUALLY DIED. I HAD TO TOW THE CAR TO A STORAGE OVERNIGHT AND WAITED UNTIL JAN. 4TH, A MONDAY, TO TOW THE CAR AGAIN TO A NEARBY BMW SERVICE CENTER. THEY EVENTUALLY REPLACED THE FUEL PUMP, WHICH IS A 3RD FUEL PUMP, INCLUDING THE ORIGINAL THAT CAME WITH THE CAR. IT WAS VERY FRUSTRATING THAT I WAS STRANDED 140 MILES AWAY FROM HOME, AND HAD NO TRANSPORTATION FOR 48 HOURS UNTIL THE PROBLEM HAD BEEN RESOLVED THEREAFTER. *TR

MY VEHICLE HAS AN ISSUE WHERE APPARENTLY A FUSE BLOWS AND THE DOOR LOCKS CAN NOT BE ACTIVATED BY THE FOB, INTERIOR HANDLES (EXCEPT THE DRIVER DOOR), OR THE INTERIOR DOOR LOCKING SWITCH. [PLEASE NOTE THAT I DO NOT HAVE ANY CHILD SAFETY LOCKS ACTIVATED ON THE REAR DOORS.] THE ONLY WAY YOU CAN OPEN THE DRIVER DOOR IS THROUGH THE VALET KEY. THIS HAS OCCURRED TO ME TWICE AND IS NOW APPARENTLY A SERVICE BULLETIN WITH BMW. I AM WRITING TO YOU BECAUSE I FEEL IT IS A DESIGN HAZARD IF THE ELECTRICAL SYSTEM WERE TO FAIL IN AN ACCIDENT, THEN THIS BECOMES AN EXTREME HAZARD IF FIRE OR ANY OTHER ISSUE WERE INVOLVED. I WOULD HAVE THOUGHT THAT THERE WAS REQUIRED AN ALTERNATIVE MEANS OF UNLOCKING THE DOORS OTHER THAN ELECTRICALLY (HENCE THE DOOR PULL KNOBS WHICH IN MY CAR ARE EVEN WITH THE TRIM AND UNABLE TO GRASP). *TR

THE HIGH PRESSURE FUEL PUMP IN MY BMW 335I. THE CONSEQUENCES, WHILE WELL DOCUMENTED, FOR ME LACK OF ACCELERATION AND UNABLE TO GO PAST 45MPH. THIS OCCURRED ON A MAJOR FREEWAY WHERE THE SPEED LIMIT IS 60MPH ACROSS THE LAKE WASHINGTON BRIDGE. THE PART REPLACED WAS THE HIGH PRESSURE FUEL PUMP BY BMW. WHAT LEAD UP TO THE FAILURE? SIMPLY ACCELERATING TO FREEWAY SPEEDS CAUSED THE ONBOARD COMPUTER TO NOTIFY ME THERE WAS AN ENGINE MALFUNCTION. IT THEN REDUCED MY SPEED TO APPROXIMATELY 45MPH. *TR

DOOR LOCK MALFUNCTIONING. ALL 4 DOORS ON MY 2007 BMW 335I WON'T OPEN USING THE KEY REMOTE NOR THE CENTRAL LOCK SYSTEM. EVEN WHEN TRYING TO OPEN THE DOOR MANUALLY, I WAS NOT ABLE TO OPEN ANY OF THE 4 DOORS. MY FAMILY HAD TO CLIMB OUT FROM THE WINDOW. I SEE A LOT OF COMPLAINTS FROM DIFFERENT FORUMS. HOW DO YOU EXPECT A PASSENGER TO GET OUT THE CAR DURING EMERGENCY SITUATION? ONE OF THE PASSENGERS WAS A HANDICAP. NOT BEING ABLE TO OPEN ALL DOORS IT CAN BE A LIFE THREATENING. PLANNING TO TAKE THE CAR TO THE DEALER NEXT WEEK. *TR

CONSTANT FAILURE IN MY 2007 BMW 335I SEDAN. RANDOM LOSS OF POWER WHEN DRIVING ON THE ROAD. LIGHTS DO NOT LIGHT UP THE PATH OF DRIVING VERY WELL. I HAVE TAKEN MY VEHICLE IN AT LEAST 6-7 TIMES FOR THESE ISSUES AND IT HAS NOT BEEN FIXED. THIS IS A KNOWN ISSUE WITH THIS MODEL. I DO NOT KNOW WHAT ELSE TO DO. I WOULD HOPE BMW WOULD RECALL SUCH A DEFECT. PER BMW RECOMMENDATION I HAD THE ENGINE DECARBONIZED AS THEY SAID THIS WOULD MAKE THE VEHICLE RUN TO SPEC. THE FUEL PUMP WAS RECENTLY REPLACED AS IT WAS FAULTY AND A NEW SPARK PLUG PUT IN PLACE. THE CAR NOW RUNS ROUGH AND THE ENGINE IS LOUD. EVERYTIME I TAKE IT TO BMW THEY SAY ITS RUNNING FINE. I WILL BRING MY VEHICLE IN ONCE AGAIN TOMORROW TO HAVE THEM TAKE A LOOK AT IT. *TR

NOTICED A LONG CRANK (ABOUT 5 SECONDS LONG) WHEN I STARTED MY VEHICLE (2007 BMW 335I SEDAN) IN THE MORNING. THE VEHICLE DID START THOUGH. I WAS COMING HOME FROM BREAKFAST WHEN THE "ENGINE MALFUNCTION" LIGHT CAME ON AND DRAMATICALLY REDUCED POWER. AT THE TIME I WAS TURNING LEFT AT A SIGNALED INTERSECTION. I WAS NOT ABLE TO ACCELERATE THROUGH THE TURN AND COULD HAVE BEEN STRUCK BY DRIVERS TURNING LEFT BEHIND ME. AFTER A SECOND OR TWO, THE CAR WAS ABLE TO ACCELERATE, BUT IN A REDUCED POWER STATE. LATER, IT WAS DETERMINED THE HIGH PRESSURE FUEL PUMP FAILED. THIS WAS THE SECOND HIGH PRESSURE FUEL PUMP REPLACEMENT ON THIS VEHICLE WITHIN A 6 MONTH OR ABOUT A 8000 MILE SPAN. IF I WAS ON THE FREEWAY OR OTHER HIGH SPEED ROAD, AND THIS REDUCED POWER STATE APPEARED DUE TO THE FUEL PUMP - I WOULD POSE A SERIOUS HAZARD TO OTHERS ON THE ROAD, AND PUT MY SAFETY IN JEOPARDY. *TR

WHEN I TRIED TO MAKE A SHARP U TURN ON A HILLSIDE STREET, THE CAR SUDDENLY ACCELERATED, AND STOPPED WITH ITS BELLY STUCK ON THE CURB AND THE REAR WHEELS IN THE AIR AFTER HITTING THE GUARD RAIL ACROSS THE STREET. IT WAS SO SUDDEN, AND THE CAR JUMPED ABOUT 12 FEET INSTANTLY, AND HIT THE RAIL. SINCE THE STREET IS SLOPING DOWN, I NEVER ACCELERATE WHEN I COME DOWN THE HILL. THIS MODEL HAS A TURBO PROBLEM, AND THE WARRANTY IS EXTENDED ON THE TURBO PART UP TO 10 YEARS. THIS CAR HAD A SEVERAL STARTING PROBLEMS BEFORE, AND DISPLAYED THE "CHECK ENGINE" LIGHT. THEN IT IS RESET BY ITSELF. WHEN THE DEALER WAS ASKED, THEY DENIED THE POSSIBILITY OF ANY MALFUNCTION OF THE CAR. THIS SUDDEN ACCELERATION LOOKS LIKE A DEADLY FAILURE. IF IT HAPPENS IN A BUSY INTERSECTION, IT MIGHT HAVE RESULTED IN FATAL CRASHES OR DEATHS OF PEDESTRIANS. *TR

SUBSTANTIAL POWER LOSS, MANY EPISODES (5 AT LEAST), BMW DOES NOT SEEM TO BE ABLE TO CORRECT. HIGH PRESSURE FUEL PUMP AND INJECTORS REPLACED TWICE. PROBLEM STILL EXISTS THIS HAS HAPPENED AT 70MPH, CAR BOGGED TO 20MPH. BARLEY GOT OFF FREEWAY LAST TWO TIMES . *TR

CENTRAL LOCKING FAILURE CAUSING ONLY THE DRIVERS SIDE DOOR TO BE OPERABLE. THE PASSENGER AND REAR DOORS CANNOT BE OPENED FROM THE INSIDE OR OUTSIDE. IN THE EVENT OF FIRE PASSENGERS COULD NOT LET THEMSELVES OUT OR EMERGENCY PERSONNEL WOULD NOT BE ABLE TO OPEN THE 3 DOORS FROM THE OUTSIDE. *TR

BMW 335I MASTER BRAKE AND ABS SYSTEM FAILURE WITHOUT PARTS AVAILABLE IN USA, CANADA, NOR EUROPE TO EFFECT REPAIR. BMW WILL NOT EXPLAIN THE ABSENCE OF PARTS TO SOLVE THE PROBLEM. VEHICLE CANNOT BE CURRENTLY SERVICED WITH NO ESTIMATE FOR PART AVAILABILITY. SUSPECT AN EXTENSIVE PROBLEM HAS NOT YET SURFACED. *TR

TIRE CUPPING ON 3 SERIES BMWS. CAUSE UNKNOWN. DEALER STATES ITS A TIRE ISSUE. IF ONE LOOKS ON ANY OF THE CAR FORUMS ONLINE, YOU QUICKLY CAN DETERMINE THERE IS A HUGE ISSUE WITH TIRE CUPPING ON THESE VEHICLES. I OWN A 2007 335I BMW. I'M HAVING TO REPLACE THE TIRES @ 19K MILES. *TR

THE FUEL PUMP/ INJECTOR PROBLEM IN BMW335I TWIN TURBO CHARGED ENGINES. THE CAR SUDDENLY GETS INTO A LIMP MODE(DROP POWER AND ENGINE MALFUNCTION LIGHTS ON) WHEN DRIVING ON FREEWAYS/RAMPS ETC. FUEL PUMP REPLACED. THE PROBLEM OCCURS AGAIN IN 2 MONTHS. FUEL INJECTORS REPLACED. DON'T KNOW IF THIS WILL OCCUR AGAIN. *TR

I WAS DRIVING MY CAR FROM FLORIDA TO NEW MEXICO AS PART OF A MILITARY CHANGE OF STATION. I WAS ON MY SECOND DAY OF THE TRIP, FROM FORT WORTH, TX TO PORTALS, NM, WHEN I EXPERIENCED SIGNIFICANT LOSS OF POWER 5 TIMES IN A 200 MILE DISTANCE (NO WARNING, NO WARNING LIGHTS ON THE DASH). TWICE, THE CAR TURNED ITSELF OFF SUDDENLY, DISABLING THE POWER STEERING, WITH NO WARNING AT ALL. ONCE WAS AT HIGH SPEED ON THE INTERSTATE; THE OTHER WAS IN THE MIDDLE OF A SMALL TOWN. THANKFULLY IT DID NOT CAUSE AN ACCIDENT EITHER TIME. THIS IS THE FIRST TIME I HAVE EVER EXPERIENCED THIS PROBLEM AND IT HAS HAPPENED TWICE IN ONE DAY. BMW OF NORTH AMERICA HAS BEEN CONTACTED REGARDING THESE INCIDENTS. IT IS A 90 MINUTE DRIVE ON VERY DESOLATE ROADS TO THE NEAREST DEALERSHIP IN LUBBOCK, TX, SO I HAVE REQUESTED THAT THE CAR BE TAKEN TO THE DEALERSHIP FOR SERVICE AS IT IS UNSAFE FOR ME TO DRIVE IN THIS CONDITION. I AM AWAITING A RESOLUTION TO MY PROBLEM FROM BMW OF NORTH AMERICA. *TR

CAN NOT UNLOCK DOORS USING THE KEY FOB! ONLY DRIVER DOOR CAN BE OPENED MANUALLY USING THE KEY INSIDE THE KEY FOB! NO OTHER DOORS COULD BE OPENED EVEN MANUALLY USING THE INTERIOR DOOR HANDLES! (THIS IS A DESIGN FLAW THAT NEEDS TO BE CORRECTED OTHERWISE IT CAN CAUSE SERIOUS ISSUES IF PROBLEM OCCURS IN AN ACCIDENT THAT COULD MAKE EXITING THE VEHICLE VERY DIFFICULT TO IMPOSSIBLE ). *TR

HIGH PRESSURE FUEL PUMP FAILED ON MY CAR TWICE 1ST INSTANCE - 3000 MILES ON CAR - 2 MONTHS OLD - OCTOBERISH OF 07 - SYMPTOMS WERE LONG CRANKING - TAKING 5-10 SECONDS TO START - OCCASIONALLY 20-30 SECONDS. (COMPLAINT WAS NEVER FILED - DEALER REPLACED UNDER WARRANTY) 2ND INSTANCE - JUST A FEW WEEKS AGO - NO WARNING - DRIVING AWAY FROM MY HOUSE, PULLING INTO A BUSY STREET, SUDDENLY ALMOST NO POWER, AND ALMOST STALLED, AND WOULD HAVE IF I DIDN'T GET THE CLUTCH IN AND FOOT ON THE GAS AS QUICK AS I DID. CAR WENT INTO LIMP MODE AND WAS BARELY DRIVABLE. HAD TO ABUSE THE CLUTCH JUST TO GET IT TO MOVE WITHOUT STALLING, FELT LIKE IT HAD MAYBE 50 HORSEPOWER IF I WAS LUCKY. NO EXAGGERATION. - WOULD OCCASIONALLY STALL AT IDLE AT THIS POINT. BARELY LIMPED A FEW BLOCKS HOME. (THIS FUEL PUMP WAS THE 2ND IN THE CAR, HAD ABOUT 25,000 MILES ON IT AND ABOUT 1.5 YEARS). *TR

2007 335I COUPE - CAR EXPERIENCES A SUDDEN LOSS OF POWER WHILE DRIVING AT NORMAL SPEEDS. CAR OMITS MALFUNCTION WARNING LIGHTS ON THE DASHBOARD. THIS CAR HAS HAD THIS HAPPEN NOW AT LEAST 3 TIMES. THE PREVIOUS TWO TIMES BMW DEALER FOUND FAULTY FUEL PUMPS AND REPLACED. NOW, BMW DEALER CLAIMS THE CAR NEEDS NEW CAM SHAFTS IN THE CAR, MEANWHILE ENGINE HAS BEEN TAKEN OUT OF THE VEHICLE COMPLETELY TO ATTEMPT THE REPAIR. IT SEEMS LIKE BMW DOES NOT WANT TO ACKNOWLEDGE THAT THE CAR HAS MAJOR ISSUES.*TR

FACSIMILE FROM SENATOR BOB CORKER ON BEHALF OF CONSTITUENT RE PROBLEMS WITH HIS 2007 335I TRANSMISSION BMW. *NJ IN DEC 2007, PART OF THE MANUAL TRANSMISSION WAS REPLACED. THE PART KNOWN AS THE FRICTION PAD. THE CONSUMER STATED THERE WERE MULTIPLE REPORTS OF THE TRANSMISSION FAILING AND SMOKE WISPING OUT FROM UNDER THE HOOD. THE CONSUMER STATED HE INHALED THAT MATERIAL IN ITS SMOKE FORM, NOT ITS DUST FORM. HE WAS ALSO TOLD, THE SLAVE MASTER CYLINDER'S FLUID ALSO PRODUCED ADDITIONAL SMOKE. THE CONSUMER STATED HE COMPLAINED OF AN OVERPOWERING INTENSE BURNING RUBBER SMELL AS THE FIRST EXPOSURE. THE CONSUMER WAS ALSO TOLD, THE SEEPING FLUID WAS A POSSIBLE CAUSE OF THE PROBLEM. *JB

SIDEWALL BULGE ON TIRE. UNKNOWN CAUSE. *TR

PURCHASED A BMW 335I COUPE FROM BMW OF MANHATTAN AND IT HAS BROKEN DOWN HALF A DOZEN TIMES AND SPENT OVER 30 CONSECUTIVE DAYS AT THE SERVICE DEPT. WHEN IT BROKE DOWN THE FIRST TIME DUE TO FAULTY FUEL PUMP THAT I WAS TOLD IS ON BACK ORDER THEN BROKE DOWN FEW MORE TIMES DUE TO SIMILAR PROBLEMS INCLUDING RECENTLY CAR DYING ON ME DUE TO FUEL INJECTOR MALFUNCTION. 23K MILES ON THE CAR. *TR

I PURCHASED A NEW 2007 BMW 335I FROM BMW OF HONOLULU IN JAN 2007. 4 MONTHS LATER THE CAR STALLED WITH MY WIFE AND SON IN THE MIDDLE OF TRAFFIC. CAR WAS TOWED IN TO BMW AND REMAINED THERE FOR OVER A MONTH. BMW COULD NOT GIVE ME A STATUS AS TO WHAT WAS GOING ON, NOR DID THEY TRY TO CONTACT ME. EVENTUALLY, I WAS TOLD IT WAS THE FUEL PUMP, WHICH I WOULD THINK WOULD BE A RECALL ITEM. THEY KNEW OF THE PROBLEM BUT DID NOT INFORM THEIR CUSTOMERS UNTIL CARS WERE TOWED IN TO THE DEALERSHIP. MY CAR IS IN THE SHOP NOW FOR SOME OTHER ISSUE. IT HAS BEEN TOWED IN 3 TIMES AND DRIVEN IN FOR OTHER REPAIRS 7 OTHER TIMES IN 2 YEARS. THIS HAS COST ME TO MISS WORK AND MOST OF ALL AN INCONVENIENCE TO MY FAMILY. USUALLY THERE IS NO LOANER AVAILABLE, SO YOU HAVE TO WAIT FOR A SHUTTLE WHICH DRIVES ALL OVER THE ISLAND DROPPING OFF EVERYONE ELSE WHO IS THERE HAVING THEIR 335I WORKED ON. I HAVE COMPLAINED WITH BMW OF NORTH AMERICA AND THEY FINALLY AGREED TO PAY A MONTHS CAR PAYMENT AND INSURANCE. I HAVE RECENTLY SUBMITTED ANOTHER ONLINE COMPLAINT WHICH I HAVE RECEIVED NO RESPONSE. SPOKE WITH BMW OF HONOLULU MANAGEMENT AND THEY ARE SUPPOSEDLY IN THE PROCESS OF BUYING BACK THE CAR AND TRYING TO PUT ME IN ANOTHER 335I. DON'T KNOW IF I WANT TO DO THAT. WHAT KILLS ME IS THEIR RELUCTANCE TO KEEP ME INFORMED OF ANYTHING. THEY TELL ME, I WILL GET THIS INFORMATION TO YOU ON A CERTAIN DAY AND I DON'T HEAR FROM THEM FOR DAYS AT A TIME. THE ONLINE BLOGS ARE AMAZING. THEIR COMMENTS SOUND EXACTLY LIKE MINE. I JUST RET

DOOR LOCKS PERMANENTLY LOCKED FROM INSIDE OF CAR WHILE I WAS I STOPPED AT A MALL PARKING SPOT WITH WIFE AND 9 MONTH OLD SON. I COULD NOT UNLATCH THE DOORS BY USING THE DOOR UNLOCK BUTTON AND THROUGH THE KEY UNLOCK BUTTON. (SECOND TIME THIS HAS HAPPENED SINCE MY OWNERSHIP BEGAN AT 14400 MILES AND THIRD IN CARS TOTAL HISTORY ACCORDING TO THE OWNERSHIP RECORD). CAR IS STILL UNDER WARRANTY UNTIL DECEMBER 24 2011. JUST HAD THIS PROBLEM FIXED ON 1/8/2009 AT PERILLO BMW IN CHICAGO IL.I HAD TO ROLL DOWN MY WINDOW, CLIMB OUT, AND THEN TAKE THE KEY OUT OF THE KEY FOB AND UNLOCK THE DRIVER DOOR. I HAD TO HAVE MY WIFE CLIMB IN BACK TO GET SON OUT OF SEAT AND PASS HIM FORWARD TO THE FRONT SEAT SO I COULD GET HIM OUT THROUGH THE DRIVERS DOOR. SHE CLIMBED BACK INTO FRONT AND GOT OUT DRIVERS DOOR. THIS TOOK APPROXIMATELY 4-5 MINUTES. IF THERE WAS AN ACCIDENT OR A CAR FIRE, THERE IS NOW WAY I COULD HAVE GOTTEN MY FAMILY OUT IN A HURRY. THIS PROBLEM HAS BEEN REPORTED ON NUMEROUS BMW CAR CLUB SITES AND THERE IS REALLY NO QUICK FIX BUT TO REPLACE DOOR LOCK ACTUATOR OR FUSES. EVEN WHEN THESE PARTS ARE REPLACED, THE PROBLEM HAPPENS TIME AND TIME AGAIN. THIS IS VERY DANGEROUS. *TR

CAR LOSES POWER AND SHAKES. CHECK ENGINE LIGHT COMES ON. CAR DIES AND MUST BE TOWED. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME 6 MONTHS AGO THE FUEL PUMP WAS REPLACED. *TR

LONG CRANKS TO START, SHAKING NOW WHILE STARTING, ENGINE SERVICE SOON LIGHT APPEARING. *TR

BMW 335I HAD A FUEL INJECTOR PROBLEM AND WITHIN 2 WEEKS I HAVE A MICROFILTER PROBLEM. IN 3 WEEKS, MY CAR HAS BEEN IN THE SHOP TWICE. *TR

AFTER PUTTING THE CAR IN REVERSE AND MOVING TO REVERSE INTO A PARKING SPACE THERE IS A "CLUNK" LIKE HEAVY LUGGAGE THAT FALLS IN THE BACK OF THE CAR / OR THAT YOU HAVE BANGED INTO AN OBSTRUCTION IN THE ROAD. (NOTICEABLY GETTING WORSE). TOOK IT TO THE DEALER FOR INVESTIGATION AND RESOLUTION. 1) THEY DECIDED IT WAS THE REAR DIFF AND REPLACED IT. TOOK IT ON A TEST DRIVE AND FOUND THE PROBLEM STILL EXISTED - SO THEY PUT THE ORIGINAL DIFF BACK IN THE CAR. THEN THEY DECIDED AFTER REF TO THE CHIEF TECHNICIAN AND CHECKING IN GERMANY - IT WAS THE DRIVE SHAFT. THEY SAID THERE WAS NO DANGER, SO THEY ORDERED THE REPLACEMENT DRIVE SHAFT 2) THEY INSTALLED THE NEW DRIVE SHAFT THREE WEEKS LATER. THE PROBLEM REMAINED. THEY DECIDED IT WAS A NORMAL CONDITION AND SAID THEY TEST DROVE CARS OF SIMILAR AGE/ MILEAGE AND SAID THE NOISE WAS ACCEPTABLE. I DISAGREED. 3) MADE ARRANGEMENTS FOR THE NATIONAL TECHNICIAN TO ASSESS (OCT 15, 2008) - HE SAID THE SAME OUTCOME. NORMAL CONDITION, ACCEPTABLE NOISE LEVEL FOR AGE / MILEAGE OF THE CAR. I DISAGREED. 4)I CALLED BMW CUSTOMER SERVICE. THEY SAID AFTER GETTING A REPORT AND FEEDBACK FROM THE DEALER (OCT 20, 2008) THAT A FURTHER OPINION IN ANOTHER DEALERSHIP WOULD NOT CHANGE THE STATUS OF THE ANALYSIS FROM BMW AS THE NATIONAL TECHNICIAN HAD ASSESSED THE FINAL OUTCOME. THE NOISE IS NOTICEABLY GETTING WORSE OVER TIME. I HAVE THE CAR > 12M BUT < 18M AND THE MILLEAGE IS 17,500 TODAY. *TR

BRAKE PEDAL HARD AFTER CAR SITS 708 MILES. INCIDENT DATE: 11/02/07 DEFECTIVE VACUUM PIPE REPLACED. BRAKE PEDAL HARD AFTER CAR SITS 1899 MILES. INCIDENT DATE: 12/18/07 DEFECTIVE PRESSURE HOSE REPLACED. BRAKE PEDAL HARD WHILE STOPPING. TEMPORARY LOSS OF POWER ASSISTED BRAKES. BRAKE PEDAL HARD AFTER CAR SITS. 2630 MILES. INCIDENT DATE: 12/31/07. BRAKE SERVO, BRAKE BOOSTER, VACUUM PUMP, AND 2 VACUUM PIPES REPLACED. BRAKE PEDAL HARD WHILE STOPPING. TEMPORARY LOSS OF POWER ASSISTED BRAKES. BRAKE PEDAL HARD AFTER CAR SITS. 7300 MILES. INCIDENT DATE: 09/20/2008. CAR IS IN THE SHOP FOR REPAIRS. *TR

MY 2007 BMW 335 SEDAN WAS RECENTLY UPDATED WITH A NEW ECU SOFTWARE UPDATE (REFERRED TO AS PROGMAN 29.2) AND SINCE THEN THE RESPONSE HAS BECOME UNPREDICTABLE. PARTICULARLY THE CAR HAD NO TURBO LAG EARLIER AND AFTER THE UPDATE THE TURBO LAG HAS BECOME VERY PERCEPTIBLE. THIS HAS MADE HIGHWAY PASSING UNSAFE BECAUSE THE CAR DOES NOT BEHAVE CONSISTENTLY AND SOMETIMES WILL HESITATE FOR A FEW SECONDS AND THEN SURGE VERY QUICKLY AND AT OTHER TIMES DRIVE NORMALLY. THE UNPREDICTABILITY AND TURBO LAG MAKES HIGHWAY PASSING QUITE UNSAFE ESPECIALLY AT HIGHWAY SPEEDS AND GIVEN THE AMOUNT OF TORQUE IN THE CAR (SURGES ARE TOUGH TO ANTICIPATE). BMW DOES NOT ACKNOWLEDGE THE PROBLEM AND WILL NOT EVEN DO ANY TESTS ON THE CAR. THEY HAVE BEEN SENDING ME IN CIRCLES BETWEEN THEIR NA OFFICE AND LOCAL DEALER. *TR

FUEL PUMP FAILED A SECOND TIME. MY ORIGINAL COMPLAINT # IS 10227599. EXACT SAME SYMPTOMS. *TR

TL*THE CONTACT LEASED A 2007 BMW 335I. THE CONTACT STATED THAT THE DOORS WOULD NOT OPEN FROM THE PASSENGER COMPARTMENT NOR THE EXTERIOR OF THE VEHICLE. HE WAS FINALLY ABLE TO OPEN THE DRIVER'S SIDE DOOR MANUALLY WITH THE PHYSICAL KEY. NONE OF THE OTHER DOORS ON THE VEHICLE WOULD UNLOCK OR OPEN, INCLUDING THE GAS TANK COVER THAT WAS POWERED BY A KEYLESS LOCK SENSOR. THE DEALER STATED THAT A FUSE BLEW AND CAUSED ALL THE LOCKS TO FAIL ON THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 18,000. UPDATED 10/14/08. *LJ UPDATED 10/16/08. *JB

NHTSA ACTION NUMBER : PE08032 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE / MODELS : MODEL/BUILD YEARS: BMW / 335I 2007 MANUFACTURER : BMW OF NORTH AMERICA, LLC COMPONENT : FUEL SYSTEM, GASOLINE FUEL SYSTEM, GASOLINEELIVERY FUEL SYSTEM, GASOLINEELIVERY:FUEL PUMP DATE INVESTIGATION OPENED : APRIL 28, 2008 DATE INVESTIGATION CLOSED : OPEN SUMMARY: THE 2007 BMW 335I VEHICLES ARE EQUIPPED WITH A HIGH PRECISION FUEL INJECTION SYSTEM DESIGNED TO ALLOW PRECISE METERING OF THE FUEL MIXTURE AND HIGHER ENGINE COMPRESSION TO INCREASE ENGINE AND FUEL EFFICIENCY. THE SYSTEM INCLUDES A STANDARD IN-TANK FUEL PUMP TO DELIVER FUEL TO THE ENGINE AND A HIGH-PRESSURE FUEL PUMP DRIVEN BY THE OIL PUMP CHAIN DRIVE ASSEMBLY, WHICH CAN ACHIEVE A MAXIMUM PROGRAMMED FUEL PRESSURE OF 200 BAR. ODI HAS RECEIVED THREE OWNER COMPLAINTS OF STALLING INCIDENTS IN THE SUBJECT VEHICLES DUE TO FAILURE OF THE HIGH-PRESSURE FUEL PUMP. ADDITIONALLY, ODI HAS RECEIVED EIGHT COMPLAINTS ALLEGING INCIDENTS OF VEHICLES UNEXPECTEDLY GOING INTO A LIMP MODE BECAUSE OF HIGH-PRESSURE FUEL PUMP FAILURES. A PRELIMINARY INVESTIGATION HAS BEEN OPENED TO ASSESS THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT. *TR

CAR STARTED PERFECTLY FOR FIRST 10000 MI. STARTS WERE SHORT AND SMOOTH. CAR UNDRIVEN FOR 7DAYS BEFORE INCIDENT. DRIVING ON FREEWAY AFTER AN UNUSUAL LONG HARD START. LOST ENGINE POWER ALL OF A SUDDEN. CAR SYSTEM SAYS: ENGINE MALFUNCTION ENGINE POWER REDUCED. THE SAME THING HAPPENED ON THE NEXT FEW STARTS-REDUCED POWER AFTER A SHORT TIME DRIVING. IT THEN FAILED ON EVERY START UNTIL I HAD MY APPOINTMENT (18 DAYS) US MODEL 2007 335XI BUILD DATE MAY 2007 TOOK IT TO BMW GALLERY IN CALGARY. IT IS THE HIGH PRESSURE FUEL PUMP AND IT IS ON INDEFINITE BACKORDER FROM GERMANY. THEY CANNOT FIX IT UNTIL BMW RELEASES A NEW VERSION. THERE IS NO ETA FOR THIS PART. THEY TELL ME IT IS OK TO DRIVE. I FEEL IT IS UNSAFE. FROM MY INVESTIGATION, THIS IS A COMMON PROBLEM THAT MERITS A COMPLAINT. *TR

STARTED MY CAR IN THE MORNING IN ABOUT 400 FEET AFTER CHANGING TO 2ND GEAR AND THE CLUTCH FULLY ENGAGED DROVE 20 FEET AND THE CAR BUCKED. NO ENGINE FAULT LIGHTS LIT. DROVE TO WORK. AT LUNCH TIME STARTED THE CAR AND THE ENGINE LIGHT WAS LIT ANYTHING ABOUT 1/4 THROTTLE THE CAR WOULD BOG DOWN AND SLOW DOWN. MAXIMUM SPEED WAS AROUND 45MPH WITH VERY LITTLE ACCELERATION. UPON RESTART THE CAR WAS RUNNING WITHOUT THE ENGINE LIGHT AND PERFORMANCE RETURNED. I'M CONCERNED THIS COULD HAPPEN AT ANY MOMENT SUCH AS MERGING ONTO THE HIGHWAY. THIS IS A MAJOR SAFETY CONCERN WHEN I HAVE MY FAMILY IN THE CAR. CONTACTED THE DEALER AND THEY INSPECTED THE CAR THE NEXT DAY. THEY FOUND THE HPFP TO BE FAULTY AND REPLACED IT. *TR

MY PREVIOUS CAR WAS A 2007 BMW 335I COUPE. AFTER A COUPLE OF MONTHS OF OWNING THE CAR, THE CAR WAS DIAGNOSED WITH A FAULTY FUEL PUMP. SUBSEQUENTLY, I PURCHASED A 2008 335I CONVERTIBLE. AFTER DRIVING THE CAR FOR A COUPLE OF THOUSAND MILES, THE CAR STARTED SHOWING SIGNS OF A FAULTY FUEL PUMP (LONG CRANK TIMES). YESTERDAY, THE ENGINE MALFUNCTION LIGHT CAME ON AND THE ISSUE WAS DETERMINED TO BE THAT OF THE FAULTY FUEL PUMP. AT THIS POINT, THE CAR WENT INTO LIMP MODE WITH REDUCED POWER. ADDITIONALLY, THERE WAS SHAKING AND THE CAR WAS MISFIRING AND RUNNING VERY ROUGH. THIS IS CLEARLY A HUGE DEFECT WITH THE 335I ENGINES. IT IS A SAFETY HAZARD SHOULD THE FUEL PUMP BREAK WHILE THE CAR IS ON A HIGHWAY, OR IN A DESERTED LOCATION WITH NO ACCESS TO A REPAIR SHOP. I WOULD APPRECIATE IF THIS ISSUE IS GIVEN THE SERIOUSNESS THAT IT DESERVES. *TR

TL*THE CONTACT OWNS A 2007 BMW 335I. WHEN THE CLUTCH HEATS UP THE MATERIAL BURNS INSIDE THE CLUTCH PLATE, EMITS SMOKE AND CAUSED THE CONTACT TO HAVE BREATHING PROBLEMS. THE CLUTCH DISC WAS REPLACED; HOWEVER, THE SAME SMELL AND TOXIC FUMES HAVE CAUSED THE CONTACT TO HAVE PERMANENT LUNG PROBLEMS. THE FAILURE WAS REPAIRED AT 3,100 MILES AND RECURRED IN JULY 2008. THE CONTACTS IMMEDIATE CONCERN WAS WITH THE FUMES THAT ARE INHALED. THE CURRENT MILEAGE WAS 6,000 AND THE FAILURE MILEAGE WAS 3,100. UPDATED 10/03/08 *BF UPDATED 10/07/08.*JB

2008 BMW 335I. JAN BUILD PICKED UP AT THE BMW WELT IN FEB OF 08. @9,500 MILES. HIGH PRESSURE FUEL PUMP FAILURE. CAR EXPERIENCED A SUDDEN LOSS OF POWER WHILE I WAS DRIVING ON A SECONDARY ROAD. THANKFULLY I WAS ABOUT TO MAKE A TURN AND THE CAR BEHIND ME WAS A REASONABLE DISTANCE AWAY. ALSO SERVICE ENGINE SOON LIGHT HAS COME ON. CAR HAS A VERY ROUGH IDLE AND IS BARELY DRIVABLE ON PUBLIC ROADS. *TR

ROUGH IDLE WITH FLUCTUATING RPM, LONG CRANK BEFORE ENGINE TURNS OVER ON IGNITION. AT FIRST IT WAS ONCE A MONTH OCCURRENCE, SOON IT TURNED INTO ONCE A WEEK AND BECAME ALMOST A SURE-THING. TOOK IT TO A BMW DEAL WHO REPLACED A FUEL PUMP. NOW LONG CRANK AND FLUCTUATING RPM AT IDLE IS MOSTLY GONE BUT RARELY HAPPENS AGAIN. ALSO, SIDEWALL OF FRONT PASSENGER SIDE RUN-FLAT TIRE (RFT) HAS A BUBBLE EVEN THOUGH THE TIRE HASN'T EXPERIENCE ANY SHOCK (FROM POTHOLES, ETC). *TR

I HAVE HAD TWO FUEL PUMPS REPLACED FOR MY BMW 335I AND IT IS VERY ANNOYING. THE EVENTS LEADING UP TO THE FAILURE WERE VERY LONG CRANKS WHEN I STARTED THE CAR AND ONE TIME MY CAR EVEN ALMOST BROKE DOWN AND WOULDN'T START ON ME... BMW REPLACED BOTH THE FUEL PUMPS THAT WENT DEAD AND FOR ONE OF THEM I HAD TO WAIT THREE WEEKS TO GET IT... =/ VERY MAD!! *TR

2008 BMW 335I (E93) HIGH PRESSURE FUEL PUMP FAILURE RESULTING IN LONG STARTS AND SOMETIMES REDUCED POWER OR ENGINE STALLING WHILE DRIVING. BMW REPLACE HPFP (HIGH PRESSURE FUEL PUMP) WITH REBUILT UNIT AT 2,200 MILES. *TR

MY 8 MONTH OLD BMW 335 FAILS ON ME WHILE DRIVING IN THE FREEWAY WITH MY 7 YEAR OLD SON AT 1130PM. ENGINE MALFUNCTION. TOWED IT TO THE DEALER -IT WAS THE FUEL PUMP. THEY APPARENTLY REPLACED IT ..THE NEXT DAY I GOT IT BACK LATE AFTERNOON. DRIVING IT BACK HOME AFTER 60 MILES. IT DID IT AGAIN. APPARENTLY IM NOT THE ONLY ONE WHO' S HAVING PROBLEM..THIS IS A VERY SERIOUS ..IT JUST STOP IN THE MIDDLE OF THE ROAD WITH A VEHICLE THAT'S ONLY 8 MONTH OLD....HOPE YOU WILL ADDRESS THIS. *TR

MULTIPLE INCIDENTS WITH "ENGINE MALFUNCTION. REDUCED POWER" AKA LIMP MODE. ON MY 2007 BMW 335I SEDAN. BMW REPLACED FUEL PUMP ONCE, BUT NOW SEEMS LIKE THE PROBLEM IS REPEATING ITSELF. *TR

I DRIVE A BMW 335I AND THE FUEL PUMP FAILED. INDICATIONS WERE LONG CRANK TIMES, ENGINE STALLING WHILE DRIVING, AND SHUTTERING WHILE DRIVING. I KNOW OF MANY OTHER BMW'S WITH THE TWIN TURBO ENGINE THAT HAVE/HAD THIS PROBLEM. BMW NEEDS TO COMPLETELY REDESIGN THE FUEL PUMP SO SERIOUS INCIDENTS DO NOT OCCUR WHILE DRIVING. *TR

INITIALLY, CAR WAS SLOW TO START AFTER PRESSING START BUTTON. IMMEDIATELY EXPERIENCED NOTICEABLE DECREASE IN POWER. CAR WAS NOT RESPONSIVE AT ALL WHENEVER I ATTEMPTED TO ACCELERATE. EXHAUST NOTE BEGAN TO SOUND LIKE THERE WAS A HOLE IN THE MUFFLER. AFTER 1 OR 2 DAYS, A YELLOW SERVICE ENGINE LIGHT APPEARED IN DASHBOARD DISPLAY. AFTERWARDS CAR FELT LIKE IT WOULD STALL OUT UNLESS I DEPRESSED PEDAL TO KEEP RPMS UP. THE CAR WAS TOWED TO THE DEALERSHIP WHERE I WAS TOLD WHEN I PICKED UP THE CAR THAT THE PROBLEM WAS DUE TO A COMPUTER PROGRAM FAILURE. ON MY WAY HOME AFTER 10 MINUTES OF DRIVING I RETURNED THE CAR TO THE DEALERSHIP AND TOLD THE SERVICE ADVISOR THAT MY CAR WAS NOT FIXED AND THAT I WAS EXPERIENCING THE SAME CAR SUBSTANDARD PERFORMANCE. AFTER A COUPLE OF DAYS I WAS CALLED AND TOLD THE PROBLEM WAS THE HIGH PRESSURE FUEL PUMP. THE CAR IS TILL AT THE DEALERSHIP AS THE PART HAS NOT ARRIVED AT THE DEALERSHIP YET. *TR

DROVE CAR NORMALLY - NO EXTRAORDINARY EVENT LEADING UP TO ISSUE. CAR THREW ENGINE ERROR AND RAN UNDER FORCED 'LIMP' MODE. TOOK TO DEALER - THEY HAD TO REPLACE THE HIGH PRESSURE FUEL PUMP. *TR

FUEL PUMP COMPLETELY FAILED; CAR UNDRIVABLE, WOULD START AND THEN STALL 5-10 SECONDS LATER. INITIAL STALL OCCURRED PULLING OUT OF A DRIVEWAY ONTO A HIGHWAY. BMW TOWED THE CAR TO CLOSEST DEALERSHIP & DIAGNOSED AS HIGH-PRESSURE FUEL PUMP FAILURE. PUMP REPLACED, CAR OUT OF SERVICE FOR ~5 DAYS DURING REPAIR. OCCURRED WITH ~18K MILES ON VEHICLE. MULTIPLE ONLINE REPORTS OF OTHER 335I VEHICLES WITH IDENTICAL PROBLEMS - THIS REQUIRES A SAFETY RECALL. *TR

HIGH PRESSURE FUEL PUMP FAILURE. *TR

HIGH PRESSURE FUEL PUMP HAS BEEN REPLACED TWICE ON THE VEHICLE. *TR

2007 BMW 335I COUPE : FAULTY HIGH PRESSURE FUEL PUMP THEY CHANGED MY FUEL PUMP TO REMANUFACTURED FUEL PUMP. THEY SHOULD CHANGE THIS TO NEW ONE. *TR

MY CARS HIGH PRESSURE FUEL PUMP HAS FAILED (2 SEPARATE TIMES) IN HIGH SPEED TRAFFIC, ALMOST CAUSING ACCIDENTS. CAR IS A BMW 335I 2007. *TR

I HAVE A 4 OEM BRIDGESTONE POTENZA RUN FLAT TIRES (RFT) I CURRENTLY HAVE MY REAR PASSENGER TIRE BUBBLING ON THE OUTSIDE WALL. I HAVE NO RIM DAMAGE AND HAVE ONLY 8K MILES ON MY VEHICLE. I CONTACTED THE DEALERSHIP AND WAS TOLD THEY DO NOT COVER THIS TYPE OF DEFECT. NUMEROUS REPORTS OF THE SAME PROBLEM CAN BE FOUND ONLINE HERE: HTTP://WWW.E90POST.COM/FORUMS/SEARCH.PHP?SEARCHED=4573680 I CONTACTED THE DEALER AND WAS TOLD THIS WAS NOT COVERED UNDER ANY WARRANTY UNLESS TIRE WARRANTY WAS PURCHASED. *TR