Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 2002 record →
TL* THE CONTACT OWNS A 2002 BMW 325XI. WHILE DRIVING APPROXIMATELY 45 MPH, A LOUD CLANKING NOISE EMITTED FROM THE REAR END OF THE VEHICLE. THE CONTACT CONTINUED DRIVING AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DETECTED THAT BOTH REAR COIL SPRINGS WERE FRACTURED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
ABOUT 3 MONTHS AGO NOTED MY TAIL/TURN SIGNAL LIGHT OUT INDICATOR ON DASH, BUT ALL BULBS WERE GOOD. PROBLEM INTERMITTENT AT FIRST, BUT THEN BECAME CONSTANT ON LEFT LIGHT INDICATOR. WENT ON BMW INTERNET FORUM AND FOUND THIS IS A COMMON PROBLEM TO 3-SERIES ASCRIBED TO GROUND NOT GOOD ENOUGH, BURING PIN/PORT ON CONNECTOR. INDEED THIS IS WHAT HAPPENED ON THE LEFT SIDE OF THE TAIL LIGHT HOUSING/CONNECTOR. I SPLICED ANOTHER GROUND WIRE TO THE ORIGINAL AND CONNECTED TO THE HOUSING AS DESCRIBED IN THE ONLINE FORUM AND SEEMS TO WORK FOR NOW, BUT I FEEL NOT HAVING AN OPERABLE TURN SIGNAL ON THE REAR OF THE CAR COULD BE DANGEROUS. *TR
I HAVE A 2003 BMW 325XI BUT THERE ISN'T A 2003 YEAR TO ENTER FOR SOME REASON. BOTH TAIL LIGHTS AND BOTH HEADLIGHTS HAVE GONE OUT MULTIPLE TIMES. HAZARD LIGHT AND MAIN LOCK NEXT TO HAZARD LIGHT BUTTON HAVE GONE OUT COMPLETELY, DASH WARNING LIGHT HAVE ALSO GONE OUT BUT HAVE SINCE BEEN FIXED WITH FUSES. *TR
THE TAIL LIGHTS ELECTRIC CONNECTOR MODULE IS DYSFUNCTIONAL. IT IS BURNED OUT ON THE PASSENGER SIDE. AS A RESULT, BRAKE LIGHTS AND TURN INDICATOR LIGHTS ARE NOT FUNCTIONAL. THIS FAILURE HAS PREVIOUSLY HAPPENED ON THE DRIVER SIDE TAIL LIGHTS AS WELL. THE CAUSE WAS SIMILAR. THE GROUND CABLE AND ELECTRIC CONNECTOR WERE BURNED OUT. *TR
FORMAL PETITION FOR AN INVESTIGATION OF A SAFETY-RELATED DESIGN DEFECT: BMW 325XI 2002 DEFECTIVE TAIL LIGHT. TAIL LIGHT CONNECTIONS BURN OUT DUE TO LACK OF PROPER WIRING. BMW HAS NOW ISSUED A CORRECTION FOR THIS BUT WILL NOT COVER THE COST OF REPAIRS. *TR
I HAVE CONTACTED BMW 3 TIMES ABOUT NHTSA ID#02V088000 AND THEY WILL NOT CONTACT ME. I WANT TO KNOW IF MY VEHICLE SHOULD HAVE BEEN RECALLED. *TR
NEVER CONTACTED BY BMW ABOUT BMW 325XI RECALL #02V088000. ALSO, BOTH FRONT AXLES HAVE GONE OUT AT 77,000 MILES. *TR
2002 BMW 325 XI HAVING NEW WATER PUMP AND FAN CLUTCH REPLACED AND OIL CHANGE (4/27/09). AFTER 15 MINUTES DRIVE ON I-90 (4/28/09) THE CAR SUDDENLY STOP ON THE MIDDLE OF I-90 NEAR EXIT 11A. NEAR COLLISION WITH A BIG TRUCK THAT CAUSE TRAFFIC STOP. MANAGE TO GET INTO THE MASPIKE TOLL PLAZA, THE ENGINE DAMAGE AND OVERHEATED. CAR TOWED BACK TO DEALER, THEY HAVE THE OLD PUMP, NEW PUMP, FAN CLUTCHES (OLD AND NEW). THE CAR NEARLY GOT HIT BY A TRUCK THAT MAY CAUSE FATAL. THE ENGINE THAT HAVE THE PARTS REPLACE TO PREVENT THE ENGINE OVERHEAT OVERHEATED. NO REPAIR WAS PERFORMED. THE ENGINE FAILURE. *TR
2002 BMW 325 XI THE WARNING LIGHT FOR A BULB-OUT OR THE FAST BLINK FOR THE TURN SIGNALS COMES ON INTERMITTENTLY. TOOK TO DEALERSHIP AND IT'S A KNOWN ISSUE WITH THE GROUNDING OF THE TAIL LIGHTS. THE WIRING HARNESS MELTS. MANUFACTURER REFUSES TO FIX OUTSIDE WARRANTY. CHARGE TO REPAIR - $450. BMW SERVICE BULLETIN: SI B 63 03 06 PARTS NEEDED: 12 52 7 519 956 8-PIN CONNECTOR HOUSING 12 52 0 007 171 BLADE CONTACT SLK 2.8 WITH A WIRE LENGTH OF 500 MM, 1.0 MM 12 52 1 433 217 BLADE CONTACT SLK 2.8 WITHOUT WIRE FOR A CABLE CROSS SECTION OF 1.5 MM 61 13 8 353 747 CRIMP CONNECTOR 1.0 MM 61 13 1 379 833 SHRINK SLEEVE 61 13 1 393 718 COMB-TYPE CONNECTOR (HOUSING) 3-PIN 61 13 1 387 150 COMB-TYPE CONNECTOR (CONTACT STRIP) 61 13 1 387 144 FLAT CONTACT FOR COMB-TYPE CONNECTORS 07 11 9 975 531 FLAT PLUG-IN SLEEVE 4.8-2.5 SOURCE LOCALLY BROWN WIRE, 1.5 MM, LENGTH APPROXIMATELY 120 MM. *TR
BMW 2002 325XI AT LOW TEMPERATURES LIKE 5 OR 6 F. THE CRANKCASE VENT VALVE FROZE AND THE HIGH PRESSURE BUILT UP CAUSED THE VALVE TO BLOW AND COUPLE OF GASKETS BURNT. OIL SPILLED OVER TO THE EXHAUST CAUSING SMOKE COMING OUT OF THE ENGINE COMPARTMENT. IF DRIVEN COUPLE OF MORE MILES THE CAR WOULD HAVE BEEN ON FIRE. THE CAR JUST HAS 67000 MILES WHICH IS FAIRLY LOW MILES AND NEW CAR. ALL THE MECHANICS I TALKED TO QUICKLY RECOGNIZED THE PROBLEM AND ASKED ME NOT TO DRIVE AT ALL. THEY SAID IT CAN CATCH FIRE IF DRIVEN LITTLE MORE. ITS A COMMON PROBLEM THAT MOST OF THE MECHANICS RECOGNIZE AND FREQUENCY IS HIGH BUT IN COLD STATES NOT IN WARMER STATES. *TR
THIS IS FOR A POTENTIAL FIRE HAZARD OR POSSIBLE REAR END ACCIDENT DUE TO A KNOWN FAILURE IN THE TERMINAL BLOCK ON THE TAIL LIGHTS. *TR
DT*: THE CONTACT STATED VEHICLES TIRES BLEW OUT ON SEVERAL OCCASIONS. DURING ONE OF THE INCIDENCES, THE VEHICLE HIT A POTHOLE ON THE HIGHWAY TRAVELING AT 65 MPH BEFORE THE TIRE BLEW OUT. ON ANOTHER OCCASION, THE VEHICLE WAS TRAVELING 35 MPH IN RESIDENTIAL AREA WHEN A POTHOLE CAUSED ANOTHER BLOWOUT. THE TIRES HAVE BEEN REPLACED MORE THAN NINE TIMES BY AN INDEPENDENT TIRE COMPANY WHO DETERMINED PROBLEMS WERE WITH THE SIDEWALLS. THE CONTACT EXPRESSED THAT THE TIRES ARE DEFECTIVE. THE DEALERS AND MANUFACTURER WERE CONTACTED BUT OFFERED NO RESOLUTION. UPDATED 7/18/2006 - *NM
(1) PARKED AT A LIGHT. (2) LIGHT CHANGED, I ACCELERATED, THE ENGINE LOST POWER, VARIOUS DASH WARNING LIGHTS CAME ON, I NURSED THE CAR THROUGH THE INTERSECTION, AND PULLED OVER. TURNED THE CAR OFF, RESTARTED, DASH WARNING LIGHTS CAME ON AGAIN. AFTER TALKING WITH THE SERVICE DEPARTMENT I REACHED THE CONCLUSION THAT THE CAR WAS DRIVEABLE. WARNING LIGHTS STAYED ON BUT ENGINE POWER WAS BACK AND I WAS ABLE TO GET THE CAR HOME. (3) DEALER RESEARCHED THE PROBLEM AND FOUND A SERVICE BULLETIN WHICH EXPLAINED THE ENGINE FAILURE AS AN ELECTRICAL FAULT INVOLVING "DEFECTIVE CRIMPING" IN THE THROTTLE MOTOR, RESISTENCE FLUCTUATION DUE TO PIN CONTAMINATION, OR "FAULTY CRIMPING OR DEFECTIVE FEMALE PINS" ON A CONNECTOR. WIRING HARNESS AND THROTTLE MOTOR WERE REPLACED.*AK
PROBLEMS WITH VEHICLE'S TIRE EQUIPMENT.*MR THE CONSUMER HAS REPLACED FOUR TIRES BECAUSE OF BLOWOUTS INCURRED WHEN HITTING POTHOLES. (GOODYEAR EAGLE RS-A, HIGH PERFORMANCE TIRES). *NM
WHILE DRIVING 50 MPH DRIVER RAN OVER PIECES OF DEBRIS ON THE HIGHWAY AND BOTH FRONTAL AIR BAGS WENT OFF INADVERTENTLY. DRIVER SUSTAINED HEAD AND BACK INJURIES , AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. VEHICLE WAS TOWED TO THE DEALER. *AK
VEHICLE HAD 2 GOODYEAR TIRES, WHERE THE SIDEWALL HAD BLOWN OUT WHILE DRIVING AT A MODERATE SPEED. OLD TIRES WERE THROWN OUT, THEREFORE THE D.O.T. # FOR THE TIRES WERE UNAVAILABLE. PROVIDE FURTHER DETAILS. *PH
THE SEAT BELT LATCH TRIGGERED THE AIR BAG DEFAULT AND THE AIR BAG HAD BECOME INOPERATIVE. THE SERVICE CHECK FAILED TO CORRECT THE PROBLEM. EVEN THOUGH THE SYSTEM WAS CLEARED, DEFAULT/INOPERATIVE AIR BAG OCCURRED WITH THE NEXT SEAT BELT LATCH. (MODEL 325XI) *JB *SCC *JB
DRIVING ON INTERSTATE-95 IN NEW YORK I FELT A VIBRATION START IN THE BACK OF THE CAR WHICH GREW VERY QUICKLY. I PULLED OVER TO FIND THE RIGHT REAR TIRE FLAT. I FOUND THE TIRE HAD A SLIT IN THE SIDE WALL HALF WAY AROUND THE TIRE WITH A GAP BETWEEN THE TREAD AND THE BODY CORE OF THE TIRE. IT APPEARS THAT THE TREAD STARTED TO SEPARATE FORM THE TIRE. I CHECK THE TIRE PRESSURES REGULARLY AND KEEP THEM AT THE MANUFACTURES RECOMMENDED PRESSURES. *JB
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 2002 BMW 325Xi → · Every 325Xi year → · How the figures are calculated →