2003 BMW 325i complaints

POOR CONNECTION AT REAR LAMP CONNECTOR. BMW. MODEL E46. ( NHTSA ITEM NUMBER - 10020856 ). *TR

TL*THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT NOTICED A CRACK IN THE FUEL TANK THAT CAUSED GASOLINE TO LEAK OUT. EACH TIME THE GASOLINE TANK IS FILLED, HE SMELLS FUMES. RECENTLY, AFTER FILLING THE VEHICLE WITH GASOLINE, THE CONTACT PARKED HIS VEHICLE AND OBSERVED APPROXIMATELY A QUARTER TANK OF FUEL ON THE GROUND. HE TOOK THE VEHICLE TO HIS MECHANIC AND WAS INFORMED ABOUT THE CRACK IN THE FUEL TANK. THE BMW MANUFACTURER ADVISED HIM TO TAKE THE VEHICLE TO THE DEALER TO DETERMINE IF THE FUEL TANK WAS CRACKED. ONCE THIS HAS BEEN DETERMINED, THE CONTACT MAY BE ELIGIBLE FOR REIMBURSEMENT OR BMW WILL REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 68,172. UPDATED 8/18/09 *CN THE DEALER DETERMINED THE GAS TANK WAS NOT CRACKED, BUT THE LEAK WAS CAUSED BY A SEAL THAT WAS INSTALLED INCORRECTLY AT THE FUEL PUMP. UPDATED 08/21/09.*JB

FAILURE OF LEFT REAR TAIL LIGHT ASSEMBLY. CONNECTOR ON WIRING ASSEMBLY HAS MELTED. ONE OF THE PINS ON LIGHT BULB ASSEMBLY HAS DISINTEGRATED RENDERING ALL LIGHTS INOPERABLE. CONTACTED LOCAL BMW DEALERSHIP AND WAS TOLD THIS IS A COMMON PROBLEM WITH THIS MODEL. *TR

RIGHT REAR LIGHTING SYSTEM, TO INCLUDE TURN SIGNAL AND BRAKE LIGHT, ON MY 2003 BMW 325I WORKS INTERMITTENTLY. BMW ACKNOWLEDGED DEFECT IN SYSTEM IN SI B 63 03 06, DATED FEBRUARY 2007 BUT TO DATE HAS REFUSED TO INITIATE A RECALL TO FIX THIS SAFETY DEFECT. *TR

I WENT TO START MY VEHICLE IN THE MORNING AND IT STARTED AND THEN TURNED BACK OFF ON ITS OWN. THIS HAPPENED ABOUT 3 TIMES,BEFORE IT STAYED ON. I THEN DROVE THE VEHICLE ABOUT 40 MILES AND THE TRANSMISSIONS STARTED TO THUMP. THE VEHICLE ONLY HAS 100K MILES. I KEPT UP ON ALL ITS MAINTENANCE. I TOOK THE VEHICLE TO THE DEALERSHIP AND THE TRANSMISSION LIGHT AND CHECK ENGINE LIGHT BOTH CAME ON. I WAS INFORMED IT WOULD COST 6,500 TO REPAIR MY TRANSMISSION. *TR

MY DASHBOARD PANEL SHOWED A WARNING LIGHT INDICATING THAT THE TAIL LIGHT WAS HAVING AN ISSUE. I WAS TOLD BY A SERVICE CENTER THAT THE TAIL LIGHT ASSEMBLY MAY GET HOT ENOUGH TO MELT THE PLASTIC IN THE HOUSING AND IT WILL HAVE TO BE REPLACED. UPON INSPECTION I FOUND THAT THE WIRE HARNESS HAD MELTED AND THE POWER SUPPLY WIRE FOR ONE OF THE LIGHTS HAD MELTED THE PLASTIC AND THE WIRE HAD COME FREE. ONCE FREE, IT ARCED TO THE CONNECTOR PIN ON THE BULB HOLDER ASSEMBLY AND DEGRADED THAT PIN UNTIL THE CONNECTION WAS LOST. ALL PLASTIC PIECES IN CONTACT WITH THE PARTS ARE MELTED AND BURNED. I CONTACTED THE BMW SERVICE CENTER AND WAS TOLD THAT THIS IS NOT A RECALL ISSUE AND I WAS RESPONSIBLE FOR REPLACING THESE PARTS. PICTURES ARE AVAILABLE OF THE PARTS. *TR

BRAKE LIGHT MALFUNCTION DUE TO CORROSION OF WIRES WITHIN THE HOUSING OF THE BRAKE LIGHT. BMW CORPORATE IS AWARE OF THE PROBLEM, BUT HAS YET TO RECALL IT. *TR

MY COUSIN WAS ON HIS WAY TO GET ON INTERSTATE.....ALL OF SUDDEN HIS 2003 BMW 325I STEERING WHEEL LOCKED AS HE TRIED TO LEAVE FROM A PARKING LOT...HE HAD TO BRAKE HARD AND GLAD THERE WAS NOTHING ON HIS WAY...I M JUST GLAD THAT THIS DIDN'T HAPPEN WHILE HE WAS IN INTERSTATE.....THIS ALL HAPPEN AROUND 6PM-7PM...SO HE CALLED BMW AND HAD TOWED TO LOCAL DEALER...THEY CALLED US BACK ON 3RD DAY AND TOLD US OUR POWER STEERING PUMP WENT BAD AND WE WILL HAVE TO REPLACE IT....AND THEY WANT ME PAY FOR THIS AND PRICE TAG IS ABOUT $1200....PLEASE CHECK ON THIS ISSUE AND SEE IF THIS CAN BE MAJOR RECALL....I M SURE THIS MUST HAVE HAPPEN IN PAST OR MAY HAPPEN TO CARS THAT ARE ON OUR INTERSTATE WHICH MAY CARRY LITTLE CHILDREN'S OR YOUNG KIDS LIKE MY COUSIN.... *TR

TEMPERATURE SENSOR IS LOCATED IN FRONT RIGHT WHEEL WELL WITHOUT PROTECTION FROM ROAD -- I HAVE HAD TO REPLACE IT THREE TIMES IN THREE YEARS. *TR

TL*THE CONTACT OWNS A 2003 BMW 325I. WHILE DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT HAD TO USE GREATER FORCE TO TURN THE STEERING WHEEL. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE POWER STEERING PUMP. CURRENTLY, THE VEHICLE IS INOPERABLE AND HAS NOT BEEN REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 40,400.

2003 BMW 325I. WHILE DRIVING OUR BMW, THE POWER STEERING FAILED WITHOUT WARNING. THERE WERE NOT VISIBLE LEAKS, VIBRATIONS, OR UNUSUAL NOISES FROM THE SYSTEM. WHEN THE PUMP WAS REMOVED AND DISASSEMBLED, THERE APPEARED TO BE A CATASTROPHIC FAILURE OF THE IMPELLER BLADE/BLADES INSIDE THE PUMP. SHARDS OF METAL FROM THE IMPELLER BLADE(S) ALSO WENT INTO THE POWER STEERING RACK. HAD THIS HAPPENED IN A DIFFERENT SITUATION IT COULD HAVE RESULTED IN LOSS OF VEHICLE CONTROL AND PERHAPS A MAJOR ACCIDENT. WE STILL HAVE THE OLD PUMP. *TR

TL*THE CONTACT OWNS A 2003 BMW 325I. WHILE THE VEHICLE WAS DECELERATING TO STOP, IT SUDDENLY SURGED FORWARD. THE FAILURE CAUSED THE CONTACT TO STRIKE THE FRONT END OF ANOTHER VEHICLE IN A PARKING LOT. THE VEHICLE WAS TOWED TO A SERVICE SHOP AND HAS NOT YET BEEN DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS 32,000. UPDATED 07/07/08. *LJ UPDATED *JB

THE TAIL LIGHT ASSEMBLY KEEPS FAILING. AND I LOOSE THE TAIL LIGHTS. THE FIRST TIME THIS HAPPENED WAS IN 2005 ON THE RIGHT HAND SIDE AND NOW IT HAPPENED ON THE LEFT HAND SIDE. *TR

I HAVE A FORMERLY PRISTINE BMW 325I 2003 WITH 70KMI THAT HAD A SUDDEN, CATASTROPHIC TRANSMISSION FAILURE FOR UNIDENTIFIABLE REASONS WHILE BEING DRIVEN NEAR SACRAMENTO. THE CAR WAS TOWED TO A BMW DEALER IN SACRAMENTO WHO CLAIMED THEY HAD "NEVER SEEN ANYTHING LIKE IT", YET CONSUMERAFFAIRS.COM HAS OVER 20 PAGES OF COMPLAINTS ABOUT THIS SPECIFIC PROBLEM. UNFORTUNATELY, THOUGH WE WERE ABLE TO LOCATE A USED TRANSMISSION, THE DEALER REFUSED TO INSTALL ANYTHING OTHER THAN A BRAND NEW UNIT AT THE COST OF $6,000. CLEARLY THERE IS SOMETHING DEFECTIVE IN THESE TRANSMISSIONS. IT APPEARS THAT BMW OF NORTH AMERICAN HAS REFUSED TO ACCEPT ANY RESPONSIBILITY. *TR

TL*THE CONTACT OWNS A 2003 BMW 325I. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER. THE VEHICLE BEGAN TO DECELERATE TO AN UNKNOWN SPEED. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE FAILURE ONLY OCCURRED WHEN THE VEHICLE WAS WARM. THE DEALER STATED THAT THE WIRES FOR THE ACCELERATOR PEDAL MALFUNCTIONED AND THE PEDAL AND ASSOCIATED COMPONENTS NEEDED TO BE REPLACED. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 71,500 AND CURRENT MILEAGE WAS 72,000. UPDATED 03-04-08 *BF UPDATED 03/04/08 *TR

FOUR TIMES SINCE I BUY A 2003 BMW 325I , I HAVE TO GET THE AUTO TO GUARANTEE SERVICE FOR REPLACEMENT OF THE STRUCT FRONT BUSHING, NOW , AFTER REPLACE THEM AT 32,000 MILES ABOUT FOUR MONTH AGO, MY CAR AT 37,000 MILES REQUEST A NEW BUSHINGS. THEY SAID ME THAT BMW WAS NO LONGER REPLACE THEM BY GUARANTEE BECAUSE OF THE ROAD CONDITIONS IN PUERTO RICO. WHEN I BUY THE CAR I PAID FOR A GUARANTEE AND I THINK THAT IS IMPOSSIBLE THAT A CAR LIKE THIS , THE ULTIMATE DRIVE MACHINE REQUIRE EVERY FOUR MONTH TO REPLACE THAT PARTS. THEY SHOULD INSTALL A GOOD REINFORCED GENUINE PARTS AND NOT A REMANUFACTURED. I ALWAYS TRY TO AVOID THE HOLES, BUT I ASK WHEN IT'S RAINING IT START A RED LIGHT THAT INDICATED " PLEASE AVOID THIS HOLE" . *TR THE DEALER STATED REPLACED LENS AND COVER DISC FOR BOTH HEADLIGHTS, NOISES COMING FROM BOTH REAR SHOCK ABSORBERS, REPLACING ALTERNATOR DRIVE BELT TENSIONER, TENSIONER AND PULLEYS, AND REMOVING AND INSTALLING LEFT OR RIGHT RUBBER STRIP. UPDATED 10/24/07 *TR

TL*THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT HEARD A NOISE COMING FROM THE FRONT PASSENGER SIDE WINDOW. SHE TOOK THE VEHICLE TO THE DEALER AND IT WAS REPAIRED. HOWEVER, THE DRIVER SIDE WINDOW IS NOW MAKING THE SAME NOISE. THE DEALER STATED THAT THIS IS A COMMON FAILURE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 47,800 AND FAILURE MILEAGE WAS 45,000.

TL*THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE WIRING HARNESS FOR BOTH TAIL LIGHTS HAVE SHORTENED OUT AND MELTED. SHE IS CONCERNED THAT THIS FAILURE COULD CAUSE HER VEHICLE TO CATCH FIRE. THE DEALER STATED THAT THIS IS A COMMON FAILURE AMONG THE 2001-2003 MODELS. THE CURRENT AND FAILURE MILEAGES WERE 57,200.

WHILE DRIVING, THE AIR BAGS ON THE DRIVER SIDE DEPLOYED; ABOVE THE WINDOW AND ABOVE THE ARM REST. I DID NOT GO OVER ANY BUMPS OR HOLES. THERE WAS NOT AN ACCIDENT OR IMPACT NOR ANY HISTORY OF. NO WARNING LIGHTS CAME ON INDICATING A PROBLEM WITH THE CAR. THE AIRBAGS SPONTANEOUSLY DEPLOYED WHILE DRIVING! MY LEFT ELBOW, LEFT ARM, AND LEFT EAR WERE INJURED. I PANICKED AND CROSSED OVER TO THE MEDIAN ON MY LEFT WITHOUT LOOKING FOR ONCOMING TRAFFIC; ALSO, THE AIRBAGS WERE OBSTRUCTING MY VIEW. THE ENGINE WAS TURNED OFF, I GOT OUT OF MY CAR, AND RAN DOWN THE ACCESS ROAD ALONGSIDE THE HIGHWAY THINKING MY CAR WAS GOING TO EXPLODE. I CALLED ROAD SIDE ASSISTANCE. THE TOWING COMPANY TOOK 1 HOUR AND 45 MINUTES. THE MAN WAS VERY RUDE AND UNWILLING TO TOW THE CAR. MY FRIEND AND I FOLLOWED THE TOW TRUCK TO THE BMW DEALERSHIP. THE TOWER REFUSED TO LET ME TAKE PICTURES OF MY CAR. I WAS ABLE TO TAKE PICTURES OF THE CAR THE NEXT DAY UNDER THE SUPERVISION OF A SERVICE ADVISOR. THE DEALERSHIP TOLD ME THAT "THE AIR BAGS WERE NOT ON MY WARRANTY" AND "I WOULD HAVE TO GO THROUGH MY INSURANCE TO REPAIR THE CAR". WHEN I ASKED FOR A COURTESY CAR IN THE MEANTIME, THEY STATED "YOUR WARRANTY COVERS RENTAL CARS BUT WE DO NOT GIVE OUT CARS FOR THIS PROBLEM. YOU WILL HAVE TO GO THROUGH YOUR INSURANCE." I GOT A RENTAL CAR THROUGH MY INSURANCE. THE ADJUSTER WAS SENT TO INSPECT MY CAR. HE AND BMW TOLD ME THAT THERE WAS "SIGNIFICANT DAMAGE" ON THE LEFT UNDERSIDE OF THE CAR THAT CAUSED A PART OF THE CAR TO COME "LOOSE

LTR FM (MA) CONCERNED ABOUT THE STALLING TENDENCES IN MODEL YEARS 2001-2004 BMW 325I AND 323I PASSENGER CARS. *TS THE STALLING PROBLEM WAS ELEMINATED BY INSTALLING AN UPDATE RELEASED ABOUT JULY 2004 BY BMW AG HEADQUARTERS IN MUNICH. AN INDEPENDENT REPAIR FACILITY DOWNLOADED THE UPDATE FROM THE BMW-SIEMENS WEBSITE IN THE U.K. AND INSTALLED IT IN THE CONSUMER'S BMW. SINCE THE SOFTWARE HAS BEEN UPDATED THE VEHICLE HAS ONLY STALLED TWICE SINCE UPDATED, ONCE WHEN IN THE WRONG GEAR, AND ONCE WHEN THE EMERGENCY BRAKE WAS SET. *NM

MY WIFE WAS IN A SERIOUS ACCIDENT ON 07/07/06. HER 2003 325I BMW WAS HIT ON THE DRIVERS SIDE BY A SUV THAT JUMPED OVER THE MEDIAN, TOTALING THE CAR. WE CONTACTED BMW OF NORTH AMERICA AND REPORTED THAT NONE OF THE AIR-BAGS DEPLOYED. WE ARE VERY CONCERNED. WE ALSO TO THIS DATE HAVE NOT RECEIVED ANY INFORMATION FROM BMW. *NM

2003 BMW 325I STALLS FREQUENTLY BECAUSE OF INSTABILITY. *KB THE VEHICLE STALLED ABOUT SEVEN TIMES AFTER BEING DRIVEN OFF THE LOT ON THE DATE IF PURCHASE. FROM DEC 2003 TO JUNE 2005 THE VEHICLE HAD ONLY BEEN DRIVE 11,000 BECAUSE THE DEALER WAS UNABLE TO ALLEVIATE THE STALLING CONDITION. THE DEALER BELIEVED THE STALLING WAS DUE TO DRIVER ERROR. THE CONSUMER BELIEVES THE STALLING IS DUE TO INSTABILITY AND THAT THIS PROBLEM COULD BE EASY FIXED BY UPDATING SOFTWARE. AN INDEPENDENT REPAIR FACILITY DOWNLOADED THE UPDATE FROM THE BMW-SIEMENS WEBSITE IN THE U.K. AND INSTALLED IT. SINCE THE SOFTWARE HAS BEEN UPDATED THE VEHICLE HAS ONLY STALLED TWICE SINCE UPDATED, ONCE WHEN IN THE WRONG GEAR, AND ONCE WHEN THE EMERGENCY BRAKE WAS SET. *NM

I WAS DRIVING THROUGH AN INTERSECTION AT APPROXIMATELY 15 MPH WHEN I WAS STRUCK IN THE DRIVER AND PASSENGER DOORS BY A VEHICLE WHO WAS RUNNING A RED LIGHT. THE OTHER DRIVER DID NOT SEE ME AND STRUCK ME AT FULL SPEED, PROBABLY AROUND 45 MPH. MY VEHICLE WAS HIT SO HARD THAT IT SPUN AROUND AND SLID ABOUT HALF A BLOCK. NONE OF THE AIRBAGS, INCLUDING THE SIDE IMPACT AIRBAGS, DEPLOYED, AND THE ENGINE DID NOT SHUT OFF. THE CAR WAS DEEMED A TOTAL LOSS BY MY INSURANCE COMPANY. *JB

THE ENGINE HAS BEEN STALLING INTERMITTENTLY WHILE DRIVING SINCE 11/2004, AND HAS HAD 6 DOCUMENTED SERVICES. AFTER LAST SERVICE ON 11/18/05, IT STALLED AGAIN ON 12/01/05 WHEN DRIVING ON FREEWAY. I HAD NOT DRIVEN IT SINCE THEN AND HAD IT TOWED AND RETURNED TO THE DEALER ON 12/10/05. *JB

DT: THE CONTACT OWNS BMW AND WHILE DRIVING DOWN THE HIGHWAY BOTH DRIVER SIDE AIR BAGS DEPLOY AND THERE WAS NOT AN ACCIDENT. THE TWO AIR BAGS THAT DEPLOYED WAS ONE OF THE SIDE ABOVE THE WINDOW AND THE ONE AT THE ARM REST. HE CONTACTED BMW AND THEY WANT HIM TO SIGN A STATEMENT PRETTY MUCH TELLING HIM TO KEEP HIS MOUTH SHUT AND NOT TO REPORT THE DEPLOYMENT OR HIS INJURIES TO ANYONE. IF HE SIGNS THE STATEMENT THEY TOLD HIM THEY WOULD GIVE HIM A REPLACEMENT CAR. THE DEPLOYMENT OF THE AIR BAG CAUSED INJURY TO THE DRIVER OF THE VEHICLE AND HE SAYS THIS IS A SAFETY PROBLEM THAT HE WANTED TO REPORT. *NM

I'VE HAD THIS CAR FOR ONLY 2 YEARS AND THE IGNITION COILS HAVE BEEN REPLACED THREE TIMES NOW. THE EVENTS INCLUDE THE "SERVICE ENGINE SOON" LIGHT COMING ON AND THE CAR VIBRATING AND IDLING ROUGH. THE CAR EVENTUALLY STALLS AND CANNOT BE DRIVEN AND MUST BE TOWED. BMW IS AWARE OF THIS PROBLEM WITH THE IGNITION COILS BECAUSE THEY HAVE AN INTERNAL SERVICE BULLETIN ON THE PROBLEM. EVEN AFTER REPLACING ALL 6 COILS THE SECOND TIME, THE PROBLEM HAS HAPPENED AGAIN FOR THE THIRD TIME. THERE IS A DEFINITE DESIGN ISSUE WITH THIS CAR THAT BMW HAS REFUSED TO ADDRESS.*AK

I PURCHASED A 2003 BMW 325I LAST YEAR . FROM SAN DIEGO BMW AND I HAD 3 OR MORE TIRE BLOW OUT EVER SINCE , AND IS ALL FROM THE SAME SIDE OF THE CAR (LEFT REAR) . I GOT BRAND NEW TIRES , ROTATION ALIGNMENT , ANYTHING I CAN THINK OF. FROM THE SAME DEALER I PURCHASED MY CAR FROM . MY LAST TIRE BLOW OUT WAS ON NOV. 20,2004 FROM THE TIRE I HAD REPAIR ON AT THE DEALER SERVICE DEPT.)AND IT HAPPENED TWO DAYS AFTER I HAD MY CAR SERVICE, AND TIRE REPAIR . (I CALL THE SERVICE DEPT. ALL THEY CAN TELL ME WAS TO GET NEW TIRES. ) *JB

CONSUMER'S VEHICLE WAS REAR ENDED. UPON IMPACT,IT HIT THE VEHICLE IN FRONT, AND AIR BAGS DID NOT DEPLOY, BUT THERE WAS A FOUL ODOR INSIDE THE VEHICLE.*AK

DEFECTIVE 5-SPEED TRANSMISSION AT 17,000 MILES. *JB

2003 BMW 325I 4 DOOR OWNED BY ME FOR 3 1/2 MONTHS DESTROYED IN FIRE. BMW HAD SENT LETTER TO ME REGARDING MANUFACTURING PROBLEM & TO BRING INTO DEALERSHIP FOR CORRECTION. PRIOR TO PROBLEM, I DID HAVE HAVE SLOW STARTING/CRANKING PROBLEMS. CAR BROUGHT INTO DEALERSHIP ON 2/21/04. ON 2/23/04, DRIVING FIRE STARTED IN RIGHT REAR AREA OF MY TRUNK, NEAR BATTERY. CAR TOTALLED BY INSURANCE COMPANY.*AK

BMW 325I PURCHASED NEW IN APRIL 2003. AFTER A COUPLE OF WEEKS I STARTED TO EXPERIENCE PROBLEMS. MY CAR WOULD JERK VERY HARD WHEN APPROACHING TO A STOP. MY CAR STARTED TO STALL OUT WHILE DRIVING OR SOMETIMES IT DID NOT EVEN START. IN JUNE 2003 A LITTLE OVER A MONTH AFTER I INITIALLY PURCHASE IT, I TOOK IT TO THE DEALER. THEY COULD NOT DUPLICATE THE SAME PROBLEM AND IT DID NOT REGISTER ANY FAULTS IN THE COMPUTER. A MONTH LATER TOOK IT BACK FOR THE SAME PROBLEM AND THEY COULD NOT DUPLICATE PROBLEM. ANOTHER MONTH PASSD TOOK IT BACK FOR THE SAME PROBLEM AND THIS TIME THEY WERE ABLE TO FIND OUT WHAT CAUSED THE JERKING PROBLEM. BMW TECH SAID THAT THEY NEEDED TO UPGRADE THE COMPUTER SOFTWARE WHICH THEY DID AND THE JERKING STOPPED. BUT THE MOST IMPORTANT PROBLEM THAT HAS NOT BEEN FIXED IS MY CAR STALLING. SINCE PURCHASED DATE MY CAR HAS BEEN IN THE SHOP SEVERAL TIMES NOW AND MY CAR CONTINUES TO DIE OUT ON ME. SOMETIMES THE CAR WOULD NOT EVEN START, I HAD TO TOW IT BACK TO THE DEALER ONCE. SUMMARIZE CURRENT PROBLEMS: RANDOMLY DOES NOT WANT TO START AND SOMETIMES MY DOORS DOES NOT UNLOCK WHEN USING THE KEY REMOTE. *AK

PROBLEMS WITH TRANSMISSION ON 2003 BMW 325I.*MR WHILE DRIVING THE VEHICLE'S TRANSMISSION LAGGED FOLLOWED BY SURGING WHEN SHIFTING FROM PARK, NEUTRAL, REVERSE THEN DRIVE WHEN THE ENGINE WAS COLD. INITIALLY THE DEALER INDICATED THAT THE TRANSMISSION NEEDED TO BE REPLACED, BUT THREE MONTHS LATER IT WAS DETERMINED THAT THE TRANSMISSION NEEDED TO BE REPROGRAMMED. THE DEALER HAS NOT CONTACTED THE CONSUMER IN ALMOST 2 WEEKS TO PERFORM THIS SERVICE. *NM

VEHICLE THRUSTS FORWARD DESPITE THE BRAKE PEDAL BEING DEPRESSED. *MR CONSUMER HAD TO PRESS BOTH FEET TO KEEP VEHICLE FROM JUMPING INTO THE INTERSECTION. ALSO, CONSUMER HAD TO SHIFT GEAR FROM DRIVE TO NEUTRAL. *LA

VEHICLE'S TRANSMISSION IS NOT ENGAGING WHEN STARTING FROM A STATIONARY POSITION. *MR THE ENGINE WOULD REV UP TO 3-4000, BUT THE VEHICLE WOULD CREEP, LURCH FORWARD AND SPEED UP NORMALLY. THIS WOULD USUALLY OCCUR WHEN THE VEHICLE SAT OVERNIGHT. THE PROBLEM ALSO OCCURRED WHEN BACKING UP. *SC *JB

WHILE DRIVING 60 MPH VEHICLE STALLED. DEALERSHIP COULD NOT DUPLICATE THE PROBLEM. *AK

INTERMITTENT SEVERE ENGINE MISS. ENGINE HESITATION/FAILURE TO ACCELERATE. ENGINE SURGES AND HAS VERY ROUGH IDLE. TRANSMISSION FAILURE TO UP SHIFT (MAXIMUM SPEED IS APPROXIMATELY 50 MPH). SERVICE ENGINE SOON LIGHT ILLUMINATES, BUT NOT ALWAYS (INTERMITTENT). WITH LESS THAN 9,000 MILES THIS CAR HAS BEEN TOWED IN THREE TIMES FOR THIS AND OTHER FAILURES WHICH HAVE LEFT THE CAR UNDRIVEABLE. BMW DEALERSHIP SERVICE PERSONNEL HAVE REPLACED MANY PARTS, WITHOUT SUCCESS, AS FAR AS WE KNOW (MORE LATER). THESE ENGINE EVENTS CAN OCCUR SPONTANEOUSLY, AND ARE NOT ALWAYS INDICATED BY A "SERVICE ENGINE SOON" LIGHT ILLUMINATION. THE MOST DANGEROUS SITUATIONS ARE WHEN IT OCCURS AS ONE COMES TO A STOP BEFORE ENTERING HIGH SPEED TRAFFIC OR WHEN MAKING A LEFT TURN. BECAUSE THE PROBLEM CAN OCCUR SPONTANEOUSLY, IF THE ENGINE WERE TO STALL OR BEGIN TO RUN ON LESS THAN ITS FULL COMPLEMENT OF CYLINDERS, IT COULD LEAVE ONE EXPOSED TO ONCOMING TRAFFIC WITH NO WAY TO ACCELERATE. VERY DANGEROUS. INTERNET SEACHING AFTER THE LATEST "REPAIR" ATTEMPT HAS EXPOSED A "SECRET" BMW BULLETIN REGARDING BREMI IGNITION COILS. (APPARENTLY, THIS IS THE SAME COIL BRAND USED IN THE VW/AUDI CARS WITH SIMILAR PROBLEMS TWO YEARS AGO.) ALL SIX IGNITION COILS, SPARK PLUGS, AND A HOST OF OTHER PARTS HAVE BEEN REPLACED THUS FAR. UNKNOWN IF THESE ATTEMPTS WERE SUCCESSFUL AS THIS CAR IS NO LONGER BEING DRIVEN--IT'S FATE AWAITS A POSSIBLE LAW SUIT AGAINST BMW. I STRONGLY URGE THE NHTSA TO RECALL EVERY BMW WITH THESE COILS, IN ADDITION

WINDSHIELD WIPERS "AUTO" POSITION CAUSES WIPERS TO FAIL TO SUDDENLY FAIL TO OPERATE DURING RAIN CONDITIONS. ALSO, CAN CAUSE DISTRACTING SWEEPS OF THE WIPERS WITH NO RAIN OR WATER, ANYWHERE NEAR THE CAR OR WINDSHIELD SENSOR. ODDLY, DEALERSHIP TECHNICIANS WERE UNABLE TO REPAIR; SERVICE WRITERS REFUSED TO WRITE IT UP AS "NORMAL" OPERATION. BMW FIELD SERVICE ENGINEER NOTED THE WINDSHIELD SENSOR (WHICH ALSO CONTAINS CONTROLS FOR AUTOMATIC LIGHTS) WAS MASSIVELY DELAMINATED FROM THE WINDSHIELD, THUS REQUIRING THE REPLACEMENT OF THE ENTIRE WINDSHIELD FOR THIS SMALL PART. ISSUES: 1. NORMAL "ERRATIC" OPERATION OF WIPERS (AND AUTOMATIC HEADLIGHTS) IS ACCEPTABLE TO BMW SERVICE WRITERS. 2. WIPERS ARE A CRITICAL SAFETY FUNCTION, YET WITH BMW'S SYSTEM THEY CAN APPARENTLY OPERATE ERRATICALLY DUE TO A BAD SENSOR "BOND" WITH THE WINDSHIELD. 3. THE COST OF A REPLACEMENT WINDSHIELD IS HIGH--OUT OF WARRANTY MANY DRIVERS MAY NOT BOTHER TO ADDRESS THIS ISSUE GIVEN THE MASSIVE COST (AND ABSURDITY) OF REPLACING AN OTHERWISE PERFECT WINDSHIELD. THIS COULD LEAD TO AN ACCIDENT IF THE DRIVER WERE TO BE IN THE "AUTO" WIPER FUNCTION WITH A FAILED SYSTEM. PLEASE FEEL FREE TO CONTACT ME IF YOU WOULD LIKE ADDITIONAL INFORMATION. MARK PETERS [email protected]

ENGINE STALLED IN TRAFFIC; HAD TO COAST TO SIDE OF THE ROAD. WOULD NOT RE-START, DESPITE STRONG CRANKING. COMPUTER READ "38 MILES TO EMPTY" AND GAUGE READ APPROXIMATELY 1/4 TO 1/8 TANK OF FUEL REMAINING. CAR WAS TOWED IN AND SEVERAL FAULTS WERE FOUND: 240, 243. DEALER TECH (VISTA BMW, FL) STATED IN SERVICE RECEIPT: FUEL SENDING UNITS. CHECKED FUEL PRESSURE . . . PRESSURE WAS 3.5 BAR. CHECKED RETURN FUEL PRESSURE AT FUEL TANK . . . PRESSURE WAS 1.0 BAR. REMOVED BOTH FUEL SENDING UNITS & PERFORMED RESISTANCE SWEEP OF BOTH RESISTANCE CARS . . . BOTH LEFT & RIGHT SENDING UNITS HAD AN OPEN. REPLACED LEFT & RIGHT FUEL SENDING UNITS. PARTS REPLACED: FUEL SENSOR, SUCTION UNIT. SAFETY CONSIDERATION: SUDDEN ENGINE STOPAGE CAN BE EXTREMELY DANGEROUS, YET THIS IS NOT AN ISOLATED EVENT. INTERNET WEB SITES RELATE OTHER BMW'S WITH SIMILAR PROBLEMS. ESPECIALLY TROUBLESOME IS THE COMPLETE LACK OF WARNING. PLEASE FEEL FREE TO CONTACT ME IF YOU WOULD LIKE ADDITIONAL INFORMATION. MARK PETERS BEDFORD, TX [email protected]

WHEN PULLING OUT THE DIP STICK AFTER VEHICLE WAS SITTING FOR A WHILE CONSUMER WAS UNABLE TO READ THE DIP STICK. OIL SPREAD IN VARIOUS PLACES ON THE DIP STICK. DEALER WAS CONTACTED. *AK

I HAVE A BMW 325I WHICH I PURCHASED BRAND NEW IN NOV. '02. IN MARCH '03, WHILE DRIVING ON THE NJTPK AT 60-65MPH IN THE LEFT LANE, THE CAR SUDDENLY LOST ITS ACCELERATION. THE CLOCKS ALSO WENT OFF AND THEN RESET ITSELF TO 12:00. BEING THAT I WAS DRIVING IN THE LEFT LANE OF THE NJ TURNPIKE, I CONSIDER MYSELF VERY LUCKY THAT I WAS ABLE TO CROSS FOUR LANES OF TRAFFIC AND COME TO THE RIGHT SHOULDER (THERE WAS NO LEFT SHOULDER). I WAITED FOR A WHILE, RESTARTED THE CAR, RESET THE CLOCK AND HIT THE ROAD AGAIN. SHORTLY AFTER THAT THE ELECTRICAL SYSTEM IN THE CAR STARTING ACTING UP... AT ONE OCCASION, I WAS NOT ABLE TO UNLOCK THE CAR USING THE REMOTE. AT ANOTHER, THE WINDOWS WOULD NOT ROLL UP UPON PULLING ON THE KNOB. THE LIGHT BELOW THE REAR VIEW MIRROR WOULD NOT COME ON. MOST OF THESE PROBLEMS WOULD GO AWAY AFTER I WOULD SHUT DOWN THE CAR AND RESTART IT. I TOOK THE CAR INTO PRINCETON BMW WHERE I HAD PURCHASED IT. THEY HAD NEVER HEARD OF THIS ISSUE BEFORE. THEY KEPT THE CAR FOR A FULL DAY AND DID EXTENSIVE TESTING ON IT. AT THE END OF THE DAY THEY WERE NOT ABLE TO FIND ANYTHING WRONG WITH THE CAR. FOR THE NEXT FEW MONTHS I DID NOT HAVE ANY PROBLEMS WITH THE ACCELERATION ALTHOUGH THE LIGHT BEHIND THE REAR VIEW MIRROR STILL DOES NOT WORK FINE. IF I TURN THE RIGHT LIGHT ON, NOTHING HAPPENS FOR ABOUT 5-10 MINUTES. THEN ALL OF A SUDDEN THE LIGHT COMES ON. WELL, THIS PAST WEAKENED (MARCH 14TH '04) I HAD AN ANOTHER EXPERIENCE, ON RT. 1, WHERE THE CAR TOTALLY LOST ITS ACCELERATION AGAIN. I AM

REAR PASSENGER SIDE TIRE RIPPED COMPLETELY APART WHILE TRAVELING 20-25 MPH. *PH *MR

WHEN DRIVING AT AN UNDETERMINED SPEED TRUNK WOULD OPEN WITHOUT WARNING. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT VEHICLE HAD AN ELECTRICAL PROBLEM. *AK

2003 BOUGHT BRAND NEW. AUTOMATIC TRANSMISSION DOES NOT ENGAGE IN THE MORNINGS. AFTER PARKING CAR IN GARAGE OVERNIGHT, THE CAR IS PUT WENT INTO REVERSE AND BACKED OUT WITHOUT STEPPING ON THE GAS (DRIVEWAY IS SLOPED). AFTER SHIFTING INTO DRIVE, THE CAR LAGS ANYWHERE FROM 3 TO 10 SECONDS BEFORE THERE IS ANY POWER TO DRIVE. THIS IS SPECIALLY DANGEROUS WHEN THERE IS TRAFFIC.*AK

I PURCHASED A NEW 2003 BMW 325 IN JULY, 2003 FROM PERFORMANCE BMW IN CHAPEL HILL, NC. THE IGNITION COIL HAD TO BE REPLACED TODAY ON THE #2 CYLINDER. THE VEHICLE CURRENTLY HAS 8,000 MILES ON IT. I WAS TOLD BY MEL, THE SERVICE TECH AT PERFORMANCE BMW IN CHAPEL HILL, NC, THAT BMW HAS HAD PROBLEMS WITH THE IGNITION COILS ON THE 2003 AND 2004 MODELS AND THAT BECAUSE OF THESE PROBLEMS BMW HAS SWITCHED VENDORS FOR THESE IGNITION COILS AND NO LONGER USES THE VENDOR THAT SUPPLIED THE PARTS FOR MY CAR. SINCE THERE A 6 IGNITION COILS IN MY CAR, THAT MEANS THAT AT ANY POINT IN TIME ANY ONE OF THE OTHER 5 IGNITION COILS COULD FAIL AND LEAVE ME STRANDED AS HAPPENED TODAY. I ASKED THE DEALER TO REPLACE ALL THE IGNITON COILS IN MY CAR THAT WERE SUPPLIED BY THIS VENDOR SEEING AS I AM A FEMALE WHO TRAVELS FREQUENCTLY FOR BUSINESS THROUGH RURAL AREAS WHERE IT WOULD BE EASY FOR ME TO BE STRANDED. THE DEALER REFUSED SAYING THAT THE OTHER COILS HAVE NOT YET FAILED SO THEY CANNOT REPLACE THEM. IT APPEARS TO ME THAT THIS IS A KNOWN QUALITY AND SAFETY ISSUE WITH THIS PRODUCT, FOR WHICH BMW IS UNWILLING TO STAND BEHIND IT'S PRODUCT.*AK

LEFT/REAR AND RIGHT FRONT TIRES HAD DEVELOPED A LARGE "BUBBLE" IN THE SIDEWALL. THE TIRES HAD LESS THAN 2000 MILES AT TIME OF FAILURE. BRIDGESTONE TURANZA, ER30 225/45ZR17, DOT NO. K9701ER3OU2, ORIGINAL TIRES. *AK *JB

AUTOMATIC TRANSMISSION ON 2003 325I JERKS WHEN DOWNSHIFTS WHILE BRAKING. A LAUD THUD CAN BE HEARD ON LOWER SPEEDS.

1. TRANSMISSION: AFTER TRANSMISSION REPAIR, CONSTANT HARD DOWNSHIFTING OF AUTOMATIC TRANSMISSION WHEN COMING TO A STOP IN D AND S D MODES. VEHICLE JERKS FORWARD WHEN DECELERATING BETWEEN SPEEDS OF 42 TO 35 MPH (USUALLY WHEN DRIVEN BEFORE WITH SPEEDS IN EXCESS OF 50 MILES AN HOUR). ALSO, AFTER TRANSMISSION REPAIR, CONSTANT LOUD THUMPING NOISE WHEN COMING TO A STOP 2. ENGINE:INTERMITTENT LOUD ENGINE REVVING AND IMMEDIATE TORQUE LOSS OCCURRING WHEN TAKING OFF FROM A STOP.INTERMITTENT DELAYED ENGINE START OF UP TO 3 SECONDS AFTER TURNING KEY IN IGNITION .INTERMITTENT PRM IDLE FLUCTUATION RESULTING IN VEHICLE SHUDDERING 3. BRAKES:LOUD BREAK SQUEAKING WHEN COMING TO A STOP 4. FUEL TANK / FUEL PUMP:AFTER DEFECTIVE FUEL TANK/PUMP REPLACEMENT, RECURRENCE OF LOUD WHINING NOISE ( CONFIRMED WITH BMW OF NORTH AMERICA) 5. CD PLAYER: INTERMITTENT BUILT-IN BUSINESS CD PLAYER SKIPPING 6.STEERING WHEEL: STEERING WHEEL CREAKING WHEN TURNING.*AK

THE COMPUTER FIRST FAILED ON MY 2003 BMW 325I ON JUNE 15, 2003, (THREE WEEKS AFTER I PICKED IT UP FROM THE DEALERSHIP, BMW OF MANHATTAN), CAUSING ME TO LOSE ACCELERATION WITHOUT WARNING. I WAS TRAVELLING AT 60-65 MILES PER HOUR IN THE FAR LEFT LANE OF THE GARDEN STATE PARKWAY. I WAS BARELY ABLE TO MANUEVER THE CAR TO THE SHOULDER OF THE ROAD AND I WAS LUCKY THAT THERE HAPPENED TO BE A VERY SMALL SHOULDER ON THE LEFT SIDE OF THE ROAD, AS I WOULD HAVE NEVER BEEN ABLE TO MAKE IT TO THE SHOULDER ON THE RIGHT HAND SIDE OF THE ROAD AND TRAFFIC WAS VERY HEAVY. THIS SUDDEN LOSS OF ACCELERATION COULD HAVE EASILY CAUSED A FATAL ACCIDENT; PARTICULARLY, BECAUSE THE CARS BEHIND ME HAD NO WAY TO DETECT THAT MY CAR WAS ONLY COASTING. THE NJ STATE TROOPERS HAD TO SHUT DOWN NORTHBOUND TRAFFIC IN ALL 4 LANES OF THE GARDEN STATE PARKWAY IN ORDER TO REMOVE MY CAR FROM THE PARKWAY. THE CAR WAS TOWED TO THE DEALERSHIP.THE DEALERSHIP WAS UNABLE TO SUCCESSFULLY REPROGRAM THE COMPUTER, SO THEY SENT IT TO MONTVALE, NJ TO BE REPROGRAMMED. THE DEALERSHIP RETURNED THE CAR TO ME ON JUNE 20, 2003. ON JUNE 25, 2003, THE COMPUTER FAILED AGAIN, CAUSING THE CAR TO LOSE ACCELERATION WITHOUT WARNING. THIS TIME, I WAS EXITING A PARKING GARAGE AND ANOTHER CAR NEARLY SLAMMED INTO ME ON THE EXIT RAMP. WHEN I RESTARTED THE CAR, I WAS ABLE TO REACH THE TOP OF THE RAMP AND PULL TO THE SIDE OF THE ROAD, (NOT AN EASY TASK DURING RUSH HOUR IN MIDTOWN MANHATTAN!), BUT THE CAR LURCHED REPEATEDLY AND WAS UNABLE TO GO MORE TH

THE VEHICLE DOWN SHIFTED VERY HARD WHEN THE BRAKES WERE APPLIED, THE VEHICLE JERKED AND JUMPED FORWARD WHEN DECELERATING.*JB