2003 BMW 325i complaints

TAIL LIGHTS CONTINUE TO FAIL ON THIS MODEL. CALLED THE MANUFACTURER, BMW, AND THEY SAID THAT EVENTHOUGH A RECALL EXISTS FOR 2003 BMW 325I MODELS FOR TAIL LIGHT FAILURE (ID NO. 11V4380000), MY VIN NUMBER DID NOT CORRESPOND TO PRODUCTION RUN FAILURES UNDER RECALL. *TR

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE REAR TAIL LIGHT FAILED. THE CONTACT EXAMINED THE VEHICLE AND FOUND THAT THE REAR TAIL LIGHT WIRES WERE BURNED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TURN SIGNAL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 161,000.

THE OIL FILTER HOUSING GASKET FAILS ON BMW CARS. IT IS A MESH GASKET BETWEEN THE ENGINE AND THE BLOCK WHERE THE OIL ENTERS/EXITS THE FILTER. THE REPAIR IS ABOUT $600 AND FAILS FREQUENTLY ON THESE CARS. IT CAUSES OIL TO LEAK ONTO THE BLOCK AND GIVES A STRONG BURNING OIL SMELL. OIL CAN ACCUMULATE ON TOP OF THE ENGINE DEPENDING ON THE SEVERITY OF THE LEAK. OIL BLOWS AND COVERS THE OIL FILTER HOUSING AND THE INSIDE OF THE HOOD WITH A SPRAY OF STICKY OIL. *TR

ENGINE VAPOR SEPARATOR, HOSES, DIPSTICK, AND VANOS LINE REPLACEMENT. THIS PART SEPARATES THE WATER VAPOR FROM THE OIL TO REMOVE CONDENSATION SO IT DOESN'T CIRCULATE INSIDE THE ENGINE. THE CAR WAS UNSAFE TO DRIVE WITH A FAULTY VAPOR SEPARATOR AND CAN CAUSE ENGINE VAPOR LOCK IF IT FAILS. THE REPAIR WAS ABOUT $1,400. *TR

XENON HEADLIGHT REFLECTORS ARE MELTING/BURNING CAUSING A SIGNIFICANT REDUCTION IN LIGHT OUTPUT. VERY SIMPLE PROBLEM FOR WHICH THERE IS NO FIX OTHER THAN TO PURCHASE NEW HEADLIGHT ASSEMBLES FOR $2,000. SEEMS TO AFFECT ALL XENON HEADLIGHTS PRODUCED BY ZWK FOR THE 2002-2004 3 SERIES BMW. *KB

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT WAS DRIVING 20 MPH WHEN THE TURN SIGNAL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE TURN SIGNAL WIRING AND THE BRAKE LIGHTS BURNED OUT. THE MANUFACTURER WAS CONTACTED WHERE THEY ADVISED THAT THE VEHICLE QUALIFIED FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS), BUT THE CONNECTOR WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 110,000.

DOORS WILL NOT OPEN BECAUSE DOOR LOCKS WILL NOT UNLOCK. KEY FOB BUTTON WILL NOT UNLOCK ANY DOORS 90% OF THE TIME. MOST OF THE TIME I CAN ONLY GET IN CAR ON DRIVERS SIDE WITH MANUAL OPERATION OF DRIVER'S SIDE DOOR LOCK (STICKING KEY IN LOCK AND TURNING). ONCE IN CAR, 90% OF TIME I STILL CANNOT UNLOCK ANY OTHER DOORS, EVEN BY PULLING ON DOOR HANDLE (WHICH WOULD ORDINARILY UNLOCK THE DOOR). THE INTERIOR BUTTON TO UNLOCK THE DOORS WILL NOT WORK. ON FRIDAY, 12/9/11, I COULD NOT EVEN GET OUT OF THE DRIVER'S SIDE DOOR WHEN I ARRIVED AT MY DESTINATION. (CAR IS SET TO AUTOMATICALLY ENGAGE ALL LOCKS ONCE I START DRIVING) I HAD TO ROLL WINDOW DOWN AND REACH OUT AND UNLOCK DOOR WITH KEY. WHEN MY SON AND DAUGHTER DRIVE WITH ME, THEY HAVE TO GET IN AND OUT OF CAR EITHER BY CRAWLING ACROSS DRIVER'S SEAT OR GO THROUGH A WINDOW OPENING. MY WIFE CANNOT RIDE IN THIS CAR NOW BECAUSE SHE MAY NOT BE ABLE TO GET OUT. DUE TO THIS DEFECT, PASSENGERS ARE TRAPPED IN CAR. ALSO, ENTRY INTO VEHICLE IS DELAYED (BECAUSE FOB WILL NOT UNLOCK DOORS) WHICH ALSO POSES SAFETY RISKS WHEN PARKED AT NIGHT IN DOWNTOWN PARKING GARAGES. THERE ARE FIVE OTHER COMPLAINTS ON NHTSA WEBSITE ON THIS EXACT SAME ISSUE. RECALL SHOULD BE INITIATED. *TR

MY 2003 BMW 325I WILL NOT UNLOCK. I CANT GET INTO THE CAR. I HAVE TRIED THE KEY AND THE FOB AND THE DOORS WILL NOT UNLOCK. I HAD TO BREAK THE WINDOW TO GET INTO THE CAR ONLY TO FIND OUT THE DOORS STILL WILL NOT UNLOCK. THIS IS A SAFETY ISSUE YOU CANT UNLOCK THE DOORS FROM THE INSIDE OR THE OUTSIDE. THIS IS EXTREMELY CONCERNING AND A TRUE SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2003 BMW 325I. WHILE MAKING A RIGHT TURN AT APPROXIMATELY 5 MPH, THE TURN SIGNAL LIGHTS FAILED TO ILLUMINATE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TURN SIGNAL) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 78,600.

RIGHT TAILLAMP FAILURE AND LEFT TAILLAMP INTERMITTENT OPERATION. ELECTRICAL SYSTEM REPAIR: RIGHT REAR TAILLAMP CONNECTOR AND BULB CARRIER CORRODED. DEALER REPLACED PIGTAIL HARNESS AND BULB CARRIER WITH UPDATED DESIGN: SOCKET HOUSING, TERMINAL, CONTACT, CABLE CONNECTOR, HOSE, INSULATION HOUSING, FLAT CONTACT, CABLE SOCKET AND BULB SOCKET. *TR

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH AND WHEN THE BRAKE PEDAL WAS ENGAGED, THE DRIVER SIDE TAIL LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY CAUSING THE REAR DRIVER SIDE TAIL LIGHT TO BECOME INOPERABLE. THERE WAS A RECALL RELATED TO THE SIMILAR DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS). THE VIN WAS NOT INCLUDED IN THE RECALL AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT BOTH REAR TAIL LIGHTS FAILED. THE CONTACT WAS ADVISED OF A RECALL UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS) BY HIS MECHANIC. THE MANUFACTURER WAS CONTACTED BUT ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE VEHICLE WAS 90,000 AND THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE EXTERIOR TAIL LIGHTS BURNED THROUGH THE HOUSING HARNESS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,250.

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE TAIL LIGHTS FAILED INTERMITTENTLY AND WOULD SHUT OFF WHILE DRIVING WITHOUT WARNING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT WAS ADVISED BY THE DEALER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 73,346 AND THE APPROXIMATE FAILURE MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE.

THE REAR STOPLIGHTS, TAILLIGHTS, AND TURN SIGNALS HAVE FAILED ON MULTIPLE OCCASIONS. *TR

XENON LIGHTS WENT OUT SHORTLY AFTER THE 50,000 MARK. SHORTLY AFTER CAR KEPT GOING INTO FAIL SAFE MODE, KEPT GETTING LOW VOLTAGE READINGS ON DIAGNOSTICS. ONE BMW DEALERS KEPT TELLING ME I NEEDED TO REBUILD TRANSMISSION. ALL THEY WOULD DO IS PLUG THE CAR INTO THE COMPUTER AND SEE THE TRANNY READING ON THE SCANNER. THE REASON THERE WAS A TRANNY READING WAS BECAUSE THE CAR WAS IN FAIL SAFE MODE. I EVENTUALLY HAD THE TRANNY REBUILT AND I STILL HAD THE SAME ISSUE. I WOULD CYCLE THE IGNITION AND RESTART THE CAR AND CAR WOULD DRIVE FINE. IT KEEPS GOING INTO FAIL SAFE MODE EVERYTIME I START THE CAR. ITS HARDER TO GET IT OUT OF FAIL SAFE MODE IN THE WINTER WITH COLDER STARTS. *TT

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT AN ABNORMAL GRINDING WHEN THE BRAKES WERE DEPRESSED. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED THAT THE BRAKES AND THE ROTORS FAILED. THE BRAKE SENSOR LIGHT NEVER ILLUMINATED TO WARN THE DRIVER THAT THE PADS NEEDED TO BE REPLACED AND THE DEALER WAS UNSURE AS TO WHY THE WARNING LIGHT NEVER ILLUMINATED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 84,000.

MY 2003 BMW 325I SEDAN WAS T-BONED ON DRIVERS SIDE DOORS, AND SENT ACROSS THE INTERSECTION AND SMASHED INTO UTILITY POLE ON REAR PASSENGER SIDE WITH ENOUGH FORCE TO BEND THE FRAME. NO SIDE OR CURTAIN AIR BAGS DEPLOYED. OTHER DRIVER RAN A RED LIGHT AT ABOUT 40 MPH AND NEVER HIT THE BRAKES. MY HEAD SLAMMED TO THE TOP OF THE DRIVER'S DOOR WHERE AN AIR BAG SHOULD HAVE BEEN, CAUSING SWELLING AND NUMBNESS TO THIS DAY. THE DOOR SLAMMED INTO MY ENTIRE LEFT SIDE WHERE THE AIR BAG IN THE DOOR SHOULD HAVE BEEN. I WAS WEARING A SEAT BELT. THE CAR IS TOTALED. BMW IS SENDING AN ENGINEER TO EXAMINE THE CAR IN A FEW DAYS. *TR

THE DOORS WILL NOT UNLOCK IN MY 2003 325I 4 DOOR SEDAN. APPARENTLY, A MODULE GOES BAD AND COULD TRAP PEOPLE IN THE CAR WITH NO WAY TO GET OUT. *KB

GROUND WIRE ON REAR LIGHT WIRING HARNESS HAS BURNT THROUGH DAMAGING PLUG AND SOCKET. POTENTIAL FOR FIRE. UPDATED 09/07/11 *BF *TR

MY CURRENT VEHICLE IS A 2003 BMW 325I WITH BI-XENON HEADLIGHTS MANUFACTURED BY ZKW. OVER THE LAST YEAR OR TWO, THE LIGHT OUTPUT FROM THE XENON HEADLIGHTS HAD DROPPED TO THE POINT WHERE I GET ALMOST NO NOTICEABLE ILLUMINATION OF THE ROAD AT NIGHT (IN AVERAGE CITY LEVELS OF STREET ILLUMINATION). I TURNED TO USING MY FOGLAMPS TO BE ABLE TO SEE ANYTHING. AFTER RESEARCHING THIS PROBLEM ON ONLINE FORUMS, I EXAMINED THE HEADLIGHTS MYSELF AND FOUND THAT THE UPPER PORTION OF THE PROJECTOR BOWLS SEEM BURNED. THEY ARE MADE OF PLASTIC AND PAINTED WITH REFLECTIVE PAINT, BUT THE UPPER ~40% OF THE BOWL IS NOW BROWNED AND NONREFLECTIVE. APPARENTLY THIS IS DUE TO AN INABILITY OF THE PAINT TO WITHSTAND THE HIGH TEMPERATURES GENERATED BY THE XENON BULBS. ALSO, THIS SEEMS TO BE COMMON TO MANY/ALL ZKW BRAND HEADLIGHTS UTILIZED IN 2003-2004 MODEL YEARS OF 3 SERIES (E46) BMW VEHICLES, ACCORDING TO POSTINGS ON THE BMW-OWNER FORUMS. FOR NOW, I HAVE TRIED TO REMEDY THIS BY LINING THE BURNT PORTION OF THE BOWL WITH ALUMINUM FOIL AND CAN NOW NOTICE SOME ILLUMINATION OF THE ROAD AT NIGHT. THIS FURTHER ARGUES THAT THE BURNING/LOSS OF REFLECTIVE COATING IS WHAT CAUSES THE LOSS OF LIGHT OUTPUT. *TR

BRAKE LIGHTS AND TURN SIGNALS RANDOMLY NOT WORKING. 2003 BMW 325I. REPLACED LIGHT BULBS AND NOTICED BURNT WIRES AND LIGHT SOCKETS. RESEARCHED REPAIR AND FOUND NUMEROUS OTHER OWNERS OF SAME YEAR AND MAKE VEHICLE WITH SAME ISSUE. *TR

I BOUGHT MY 2003 BMW 325I NEW. SHORTLY AFTER THE SALE I NOTICED THE FRONT DRIVERS XENON LIGHT WOULD GO OUT. THE ONLY WAY TO GET THE LIGHT BACK ON, IS TO TURN OFF THE CAR AND RESTART THE ENGINE. THIS WORKS ABOUT 80 PERCENT OF THE TIME. ANOTHER ISSUE I HAVE BEEN EXPERIENCING IS A FALSE INDICATION THAT MY TAILLIGHTS ARE OUT. THIS IS VERY SPORRATIC AND ANNOYING. A THIRD ISSUE I AM EXPERIENCING IS VERY DANGEROUS RELATING TO MY DRIVERS SEATBELT. THE SEATBELT MAY SEAM LOCKED, BUT IF YOU PULL WITH A BIT OF FORCE, THE SEATBELT WILL COME OUT OF THE LOCKED POSITION.

WENT TO GO INTO REVERSE AFTER COMING HOME FROM A SHOPPING SPREE AND THE CAR SIMPLY WOULD NOT REVERSE. AFTER A FEW DAYS IT FINALLY WENT INTO REVERSE. ENGINE LIGHT STAYS ON AND THERE ARE TRANSMISSION CODES ON THE INDICATOR FROM THIS. CAN'T AFFORD TO FIX THIS PROBLEM BUT THERE ARE SEVERAL REPORTS ON THE 325 I BMW. *TR

CAR RAN PERFECTLY, THEN I TURNED OFF, THEN I RESTARTED 5 SECONDS LATER TO REPOSITION IN GARAGE. ENGINE THEN REVVING FROM 800 TO 1200 RPM RHYTHMICALLY, APPROX ONCE PER SECOND, EML LIGHT ON, BRAKE LIGHT ON, SERVICE ENGINE LIGHT ON, VERY HARD TO STOP CAR, HAD ANYONE BEEN CLOSE I WOULD HAVE HIT THEM. ENGINE REVVING CONTINUED FOR 2 DAYS, THEN WENT AWAY ON OWN. I THEN TOOK OFF AIRBOX TO INSPECT MAF, FILTER. CODES ON 3RD DAY: P1632 THROTTLE, PENDING: P0102, IATS. THERE HAVE BEEN OTHER INCIDENTS OVER THE YEARS OF RESTARTING ENGINE TO HAVE EXTREMELY ROUGH IDLE, ALSO CLEARED ON ITS OWN, BUT NEVER SURGING LIKE THIS. *TR

GOT A WARNING FROM POLICE ABOUT DRIVERS SIDE BRAKE LIGHT BEING OUT. TOOK IT TO REPAIR SHOP TO BE REPAIRED. BULB REPLACED. IN LESS THAN 12 HOURS THE LIGHTS WERE OUT AGAIN. TOOK IT BACK TO REPAIR SHOP THEY PULLED THE LIGHT PANEL OUT LIGHTS CAME ON. I DROVE OFF AND THE INSIDE WARNING LIGHT CAME ON AGAIN. I WAS TOLD BY THE REPAIR SHOP THAT IF THE LIGHT WENT OUT AGAIN IT WAS AN ELECTRICAL PROBLEM AND THE PANEL WOULD HAVE TO BE REPLACED. *TR

2003 BMW 325I REAR TAIL LIGHTS SPONTANEOUSLY AND REPEATEDLY QUIT WORKING. LIGHT BULBS REPLACED AND WORK WELL. IT APPEARS TO BE A WIRING ISSUE. *TR

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT WINDOW REGULATORS WOULD CONTINUOUSLY FAIL. THE FIRST FAILURE OCCURRED ON THE REAR PASSENGER WINDOW, THEN THE FRONT PASSENGER WINDOW AND MOST RECENTLY, THE REAR DRIVER SIDE WINDOW. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN RECALL CAMPAIGN NUMBER: 03V160000 (VISIBILITY:POWER WINDOW DEVICES AND CONTROLS).THE CONTACT STATED THAT BECAUSE HE WAS EXPERIENCING THE EXACT SAME FAILURE, HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 43,000.

MY 2003 325I BMW HAS A DEFECT IN THE TRANSMISSION WHICH CAUSED IT TO, WITHOUT WARNING, LOSE ITS ABILITY TO GO INTO REVERSE. I WAS RETURNING TO PHILADELPHIA FROM NYC SEVERAL DAYS AGO. I PULLED OVER FOR GAS. WHEN I PUT THE CAR INTO REVERSE, THE TRANSMISSION ACTED LIKE IT IS IN NEUTRAL. THE ENGINE WOULD REV BUT WAS NOT ENGAGED. THE CAR HAS ONLY 70K MILES ON IT. THE PROBLEM IS WIDESPREAD IN OWNERS OF EARLY 2000 BMWS AND RESULTS FROM A REVERSE DRUM THAT IS POORLY MANUFACTURED AND NOT SUFFICIENTLY THICK AROUND THE EDGES. APPARENTLY, BMW CORRECTED THE MANUFACTURING PROBLEM IN 2003. IT NEVER SHARED INFO ABOUT THE ISSUE WITH PROSPECTIVE OWNERS, IN EFFECT SELLING CARS UNDER FALSE PRETENSE. PLEASE VISIT WWW.NOREVERSE.ORG AND YOU WILL SEE HUNDREDS OF COMPLAINTS ABOUT THIS ISSUE. IT IS A SAFETY ISSUE BECAUSE THE DRIVER MAY BE IN A DANGEROUS POSITION AND NEED TO REVERSE FOR GET OUT OF HARM'S WAY. BMW SHOULD HAVE RECALLED ALL OF THESE DEFECTIVE TRANSMISSIONS. I CANNOT AFFORD TO REPAIR THE CAR AND SO IT IS SIMPLY SITTING ON MY STREET. *TR

REAR SPRINGS ON 2003 BMW 325X1 BOTH BROKEN--YET SHOCKS FULLY OPERATIONAL. MECHANIC AT LOCAL BMW DEALERSHIP SAID THIS A DEFECT IN MANUFACTURING(CAR HAS 47,000 MILES) BMW REFUSES TO ACKNOWLEDGE OR REPAIR DEFECT. *TR

I HAVE EXPERIENCED SEVERAL TIMES WHEN OUR TURN SIGNAL LIGHT FAILS TO WORK AND THE INDICATOR LIGHT OF FAILURE IS SHOWN ON THE DASHBOARD. THE LIGHT WILL WORK THEN STOP WORKING IN SHORT PERIODS OF TIME. I HAVE REPLACED BULBS ON NUMEROUS OCCASIONS WITH SOME SUCCESS WHILE OTHER TIMES NOTHING HELPS. THERE APPEARS TO BE SOME TYPE OF ELECTRONIC PROBLEM WITH THE SIGNAL LIGHTS, ESPECIALLY IN THE REAR OF THE VEHICLE. *TR

THE TAIL-LIGHTS OF MY BMW 325I HAVE PERIODICALLY SHORTED OUT EVER SINCE I PURCHASED THE CAR. THE WARNING LIGHT ON THE DASHBOARD INDICATES THAT THE LIGHT IS NOT FUNCTIONING CORRECTLY, AND IS NOT CORRECTED BY REPLACING THE BULB. BEFORE MY WARRANTY EXPIRED BMW REPLACED THE REAR TAIL LAMP MODULE WHICH CORRECTED THE PROBLEM, BUT ALREADY THE REPLACEMENT MODULE HAS SHORTED OUT AGAIN. CURRENTLY BOTH TAIL-LIGHTS ARE SHORTING OUT. *TR

THE DRIVERS SIDE DOOR WOULD NOT OPEN EITHER WITH THE KEYLESS REMOTE OR BY PULLING ON THE DOOR HANDLE INSIDE THE CAR (THE WINDOWS WERE DOWN SO I COULD REACH INSIDE) I HAD TO OPEN THE PASSENGER DOOR AND CLIMB ACROSS THE SEAT TO GET INTO THE DRIVER'S SEAT. THE BUTTON BETWEEN THE SEATS TO UNLOCK ALL OF THE DOORS ALSO FAILED TO OPEN ANY OF THE LOCKS. THE HAZARD LIGHT SWITCH BESIDE IT STILL WORKED, SO I KNOW THE PROBLEM ISN'T DUE TO THAT FAULTY SWITCH. THIS DOOR LOCKS RETURNED TO NORMAL AFTER DRIVING THE CAR ABOUT 30 MINUTES AND IT HASN'T YET RETURNED IN THE FIVE DAYS SINCE. *TR

OUR 2003 BMW 325I HAS HAD REPEATED STALLING EVENTS OCCURRING AT INCREASING FREQUENCY. WHILE IDLING AT STOP LIGHTS OR AT HIGHWAY SPEED WARNING LIGHTS ON THE DASHBOARD (EML, HAZARD AND BRAKE) LIGHT AND THE ENGINE LOSES POWER, AND RPM'S DROP. AFTER THE FIRST OCCURRENCE, THE BMW WAS TAKEN TO ADVANTAGE MIDTOWN BMW IN HOUSTON, TX FOR DIAGNOSIS/REPAIR. BMW REPLACED THE THROTTLE CONTROLLER WHICH THEY SAID WAS DEFECTIVE. 1-2 MONTHS LATER THE PROBLEM BEGAN OCCURRING AGAIN WITH INCREASING FREQUENCY. THE CAR STALLED AT A TRAFFIC LIGHT WITH THE SAME WARNING LIGHTS/SYMPTOMS. THE CAR WAS RETURNED TO ADVANTAGE BMW AND LEFT FOR SEVERAL DAYS. INITIALLY THE SERVICE STAFF AT ADVANTAGE BMW TOLD US THAT THE COMPUTER HAD FAILED AND NEEDED TO BE REPLACED AND WAS UNDER WARRANTY. HOWEVER, AFTER DISCUSSIONS WITH THE BMW CORPORATE OFFICE, ADVANTAGE BMW DID NOT REPLACE THE COMPUTER INSTEAD STATING THE THAT THE PROBLEM MAY BE DUE TO LOW VOLTAGE IN THE SYSTEM. I ASKED THEM WHAT WOULD CAUSE THIS SINCE I DID NOT WANT TO DRIVE THE CAR WHEN IT INTERMITTENTLY COULD STALL. ADVANTAGE KEPT THE CAR A FEW MORE DAYS AND THEN RETURNED IT TO US WITH THE EXPLANATION THAT THE LOW VOLTAGE WAS DUE TO INSUFFICIENT CHARGE ON THE BATTERY. I WAS ADVISED TO PURCHASE A FLOAT CHARGER. SINCE THEN THE CAR HAS BEEN KEPT FULLY CHARGED VIA A CTEK FLOAT CHARGER. HOWEVER LAST WEEKEND THE ENGINE STALLED REPEATEDLY WHILE MY FAMILY AND I WERE DRIVING ON INTERSTATE 10 AT FREEWAY SPEEDS. THIS FORCED ME TO PULL TO THE SHOULDER OF THE HIGHWAY

THE ZKW BRAND OF HIGH INTENSITY DISCHARGE (HID) HEADLIGHTS EQUIPPED IN THE 2003-2004 E46 MODEL 3 SERIES BMW SEDAN HAVE A PLASTIC REFLECTOR BOWL IN THE PROJECTOR THAT HAS THE TENDENCY TO HAVE THE CHROME REFLECTIVE PLATING BURNT OFF RENDERING THE HEADLIGHTS ALL BUT USELESS. THIS MAKES IT DANGEROUS TO DRIVE AT NIGHT BECAUSE YOU CAN BARELY SEE THE ROAD. THE ONLY REMEDY TO THIS IS TO REPLACE THE ENTIRE HEADLIGHT ASSEMBLIES FOR $1200 PER SIDE, WHICH IS UNACCEPTABLE FOR NON WEAR ITEM TO OCCUR WHEN THE VEHICLE IS BETWEEN 5 TO 7 YEARS OLD, AVERAGING 50K TO 90K MILES. *TR

2003 BMW 325I 4-DOOR SEDAN. DRIVER'S SIDE DOOR LOCK WILL NOT UNLOCK. HAPPENS ALL THE TIME. STARTED ABOUT A YEAR AGO. I HAVE GONE ONLINE AND FOUND MANY OTHER PEOPLE HAVE SAME PROBLEM. SEEMS TO ME TO BE A SAFETY ISSUE. IF I CAN'T GET OUT OF THE CAR. *TR

I PURCHASED MY BMW 325I IN AUGUST OF 2006. SINCE THAT PURCHASE I HAVE ONLY DRIVEN IT APPROXIMATELY 9-12 MONTHS COLLECTIVELY. THE CAR WAS PURCHASED WITH 37500 MILES AND NOW HAS 70,000 MILES. THE PROBLEM APPEARS TO BE THE ELECTRICAL SYSTEM WHICH CAUSES THE LIGHTS TO TURN OFF AND ON WHEN THEY FEEL LIKE IT. THIS CAR HAS BEEN SITTING IN MY DRIVEWAY FOR THE PAST 9 MONTHS BECAUSE IT IS UNSAFE TO DRIVE AND WILL NOT PASS INSPECTION. I HAVE HAD IT TO NUMEROUS BMW DEALERSHIPS, THEY CAN NOT FIND THE PROBLEM. ALL THE ISSUES SEEM TO BE ELECTRICAL IN NATURE AND ARE VERY HARD TO ACCURATELY DIAGNOSE. THE BOTTOM LINE IS I AM CHARGED THOUSANDS OF DOLLARS TO REPAIR THE CAR BUT CAR IS STILL NOT SAFE. THE REAR LIGHTS HAVE BURNED OUT AND THE RIGHT FRONT LIGHT GOES ON AND OFF AT WILL. THE LAST INCIDENT OCCURRED IN DEC 2009 WHEN THE CAR LIT UP LIKE A CHRISTMAS TREE (THE ONLY TIME ALL OF THE LIGHTS WORKED.) HOWEVER, WHEN YOU TURN THE CAR ON, THE LIGHTS WENT OFF AGAIN. THE CAR HAD TO BE TOWED TO THE SHOP WHERE IT REMAINED UNTIL JANUARY 2010. I WAS CHARGED $2700 AND STILL CAN'T GET THIS BEAST INSPECTED. THIS HAS GONE BEYOND THE POINT OF LUDICROUS. I AM COMPLETELY DISGUSTED WITH THE "ULTIMATE DRIVING MACHINE". IN ESSENCE I AM PAYING 650 DOLLARS A MONTH FOR NOTHING. THE LAST MECHANIC THAT LOOKED AT THE CAR RECOMMENDED THAT WE SHOULD REPLACE THE FRONT LIGHTING SYSTEM BECAUSE THE CURRENT SYSTEM THAT IS FAULTY IS NOT MEANT TO BE REPLACED, SO REPLACEMENT PARTS ARE VERY EXPENSIVE. IN THEORY THE LIGHTS SHOULD L

WE OWN A BMW 325I SERIES 2003 SEDAN. WHILE MY DAUGHTER STARTED THE CAR SHE NOTED THE LEFT HEADLIGHT WENT OUT ON THE DRIVER'S SIDE OF THE CAR. SHE WAS ONLY AROUND 4 BLOCKS AWAY SO PROCEEDED TO DRIVE HOME AND DURING THE DRIVE SHE EXPERIENCED HER BRAKES GRABBING AND STEERING DIFFICULTIES. ALL THE DASHBOARD INDICATOR LIGHTS CAME ON. WE TOOK THE CAR THAT NIGHT TO BMW TO DROP OFF FOR EVALUATION. THE SERVICE MANAGER STATED THAT THE XENON HEADLIGHT FAILED AND TOOK AT THE STEERING SYSTEM PANEL AND HAD TO BE ALL REWIRED. HE SAID THEY HAD NEVER SEEN THIS HAPPEN BEFORE. I AM CONCERNED THIS IS A SAFETY CONCERN IN THE WIRING OF THE XENON HEADLIGHT TO EFFECT A STEERING PANEL WHEN THE HEADLIGHT GOES OUT. THE EFFECT ON THE STEERING PANEL IS IMMEDIATE AND GIVES NO TIME TO REPLACE THE HEADLIGHT WITHOUT FURTHER DAMAGE TO THE CAR. THE COST TO REPAIR WAS 1800.00. THIS IS VERY CONCERNING. 2 MONTHS LATER THE BLINKER HEADLIGHT NEXT TO THE XENON HEADLIGHT FELL COMPLETELY OUT OF THE CAR HELD BY A WIRE WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY. IT SEEMS LIKE THERE IS AN ISSUE WITH THE BMW 325I SERIES HEADLIGHTS THAT TO ME IS A GREAT SAFETY CONCERN FOR THOSE DRIVING. I WOULD APPRECIATE YOUR FOLLOW UP TO THE MAKE AND MODEL. I WOULD BE GLAD TO PROVIDE MY NAME FOR YOU TO OBTAIN COPIES OF THE SERVICE RECORDS ON THESE EVENTS FROM OUR BMW DEALERSHIP. THANK YOU. *TR

FAULTY PIN CONNECTORS IN REAR BRAKELIGHT ASSEMBLIES, CAUSING PREMATURE FAILURE OF BRAKE LIGHTING HARNESS, VERY DANGEROUS. *TR

3/26/2010 - OLNEY, MD - 2003 325XI RIGHT AND LEFT REAR LIGHT ASSEMBLY SYSTEM FAILING AT TIMES, (TURN SIGNAL AND BRAKE LIGHT WORKS INTERMITTENLY). BMW ACKNOWLEDGED "GROUND" PROBLEM IN ASSEMLY IN TBS:630306, FEBRUARY 1 2007 LOCAL DEALER IN SILVER SPRING MD, TISHER BMW CORRECT THE PROBLEM ONLY ON THE RIGHT SIDE AND COMPLETELY IGNORE MULTIPPLE OFFICE VISIT FOR THE SAME ISSUE ON BOTH SIDES AND REFUSE TO CORRECT PROBLEM ON THE LEFT ASSEMBLY. AT THE SAME TIME BMW CORPORATE OFFICE CUSTOMER SUPORT REFUSED TO OFFER OUT OF WARRANTY FREE REPAIR OR TO INITIATE RECALL ON PREVIOSLY ACKNOWLEDGED "GROUND" PROBLEM. I BELIVE THIS ISSUE IS THE SAFTY HAZARD BECAUSE THE "GROUND" RED WIRE IS BURNING IN THE CONNECTOR OF TAIL LIGHT ASSEMBLY. ALSO PEOPLE AND OTHER DRIVERS CAN'T SEE WHEN YOU "BRAKING"

I HAVE ENCOUNTERED THE FOLLOWING PROBLEMS MANY TIMES SINCE PURCHASING THE CAR. THE PROBLEMS STARTED AT MILEAGE OF ABOUT 2000. THE STEERING LOST FUNCTION AT LOW SPEED WHEN MAKING TURN (CAN'T MAKE TURN). THE ENGINE ALSO DIED AT VERY LOW SPEED. WE HAVE TO RESTART THE ENGINE EVERY TIME SUCH PROBLEMS HAPPENS. I REPORTED TO LOCAL DEALERS AND THEY WERE UNABLE TO IDENTIFY THE UNDERLYING PROBLEMS. *TR

THE RIGHT FRONT HEADLIGHT WILL GO OFF SPORADICALLY AND RIGHT REAR TAIL LIGHT GOES OFF. THE DEALER COULD NOT CORRECT THE HEADLIGHT PROBLEM. THE TAIL LIGHT PROBLEM BEGAN WHILE CAR WAS IN WARRANTY. NOW TO CORRECT TAILLIGHT PROBLEM THERE IS UPDATE KIT WHICH THEY WANT ME TO PAY. SINCE TAILLIGHT PROBLEM BEGAN IN WARRANTY BMW SHOULD COVER COST. *TR

GM5 LOCKING MODULE FOR 2003 BMW E46. ALL FOUR LOCK WOULD NOT UNLOCK OR LOCK ON THE REMOTE OR SWITCH INSIDE THE CAR. I HAD TO EITHER WAIT IN THE HEAT OR COLD OUTSIDE WHILE WAITING FOR THE LOCKING SYSTEM TO RESPOND. IF THERE ARE CHILDREN IN THE CAR AND YOU CANNOT GET TO IN TIME BECAUSE OF THE LOCK/UNLOCK ISSUE, IT CAN BE FATAL FOR OTHERS. *TR

OWN A BMW 3251, REAR END STARTED MAKING POPPING NOISE WHEN PUT IN REVERSE AND WHEN TURNING CURVES. WHEN ON INTERSTATE REAR END LOCKED UP WHILE DRIVING CAUSING MY CAR TO SKID THROUGH ALL LANES OF TRAFFIC. AFTER HAVING CAR INSPECTED THE REAR END HAD BROKE, WE REPLACED THE REAR END. ALSO HAVING TROUBLE WITH HEAD LIGHTS STAYING ON AND BLINKERS. RIGHT REAR TAIL LIGHT OVER HEATED AND BURNT ITEMS IN TRUNK. RADIATOR HAS BROKE AND DRIVERSIDE WINDOW REGULATOR AND CLUTCH FAN. *TR

1-AIR BAG WARNING LIGHT WOULD NOT TURN OFF AFTER START UP. TOOK VEHICLE TO LOCAL BMW DEALER. WAS INFORMED THAT I NEEDED TO FIX THIS PROBLEM SO AIR BAG WOULD DEPLOY PROPERLY ON PASSENGER SEAT . WAS TOLD THIS IS A 'COMMON' PROBLEM ON E46 MODELS! VERY COSTLY TO REPAIR..NOT TO MENTION THAT THE PARTS THAT NEEDED REPLACEMENT ARE WELL STOCKED AT ALL BMW DEALERS THAT I CALLED..VERY RARELY HAS ANYONE SAT ON PASSENGER SEAT..THE DEFECT IN THE SEAT SENSOR IS DISCUSSED IN INTERNET WEB SITES AS FAR BACK TO THE E39 SERIES MODELS AS WELL AS THE E90 SERIES MODELS. 2- RADIATOR EXPANSION TANK FAILS TOO OFTEN ON THIS SERIES MODEL. I DEVELOPED A ANTI-FREEZE LEAK ON A RETURN VACATION TRIP. NO WARNING WAS GIVEN.. PARKED CAR IN GARAGE IN THE EVENING, NOTICED A FAIR AMOUNT OF ANTI-FREEZE ON GROUND. AGAIN, WAS TOLD THIS IS COMMON ON THIS SERIES E46 MODEL.. SINCE WHEN IS EQUIPMENT FAILURE A STANDARD FOR THE SAFE OPERATION OF ANY MOTOR VEHICLE? THE PARTS THAT FAIL IN THIS VEHICLE CAN CAUSE GREAT INJURY TO ITS OCCUPANTS ESPECIALLY THE PASSENGER IN THE CASE OF AIR BAG DEPLOYMENT. IN THE CASE OF THE RADIATOR EXPANSION TANK,FOR THIS PART TO FAIL WITHOUT WARNING CAN BE CATASTROPHIC TO THE ENGINE, WHICH WILL CAUSE SEVERE DAMAGE. IF ENGINE IS NOT OPERATIONAL, ONE CAN LOSE POWER STEERING OR BRAKE CAPABILITY, OR BOTH. *TR

BMW 325I REAR BLINKERS SHORTED OUT CAUSING ELECTRICAL WIRES TO BURN. WHILE DRIVING MY BMW A WARNING LIGHT ON MY CONSOLE TURNED ON INDICATING THE LEFT REAR BRAKE/BLINKER LIGHT(S) WENT OUT WHILE AT THE SAME TIME I SMELLED WIRING BURNING. I STOPPED THE CAR AND ALL MY LIGHTS SEEMED OK, SO I PRESUMED IT WAS A FAULTY SENSOR. A SHORT WHILE LATER WHILE DRIVING DOWN THE FREEWAY I PULLED INTO THE LEFT LANE AND REALLY PISSED THE DRIVER OFF BEHIND ME AND NEARLY CAUSED AN ACCIDENT. AT THIS MOMENT I NOTICED MY LEFT BLINKER WAS MAKING A FAST NOISE AS THOUGH THE LEFT BLINKER BULB(S) WAS OUT. I PULLED OVER A SECOND TIME TO CHECK MY BLINKERS, FEARING I WOULD CAUSE AN ACCIDENT, AND ALL MY FLASHERS, BRAKE LIGHTS AND BLINKERS WERE WORKING FINE. THE WARNING LIGHTS ON THE CONSOLE WENT ON AND OFF INTERMITTENTLY. I PURCHASED A NEW BULB HOPING THIS WOULD SOLVE THE PROBLEM, BUT EVERYTHING SEEMED OK AND FUNCTIONAL. WHEN I RETURNED FROM MY TRIP, I WAS TOLD BY TWO EUROPEAN AUTO SHOPS AND THE SERVICE MANAGER OF A BMW DEALERSHIP THAT BMW IS AWARE OF A GROUND PROBLEM WITH THE REAR LIGHT CLUSTER. WHEN I UNSNAPPED THE PLASTIC CONNECTION FROM THE REAR LIGHT CLUSTER, THE METAL PRONGS AND PLASTIC WERE MELTED AWAY. THE HEAT APPARENTLY WAS SO HOT, THE SOLID METAL PRONGS 1/4" LONG COMPLETELY MELTED INCLUDING THE PLASTIC CASING. A BMW DEALERSHIP EMPLOYEE TOLD ME THAT THIS ISSUE IS COMMON WHEN DRIVING IN THE CITY WHEN ONE IS USING THE BRAKES AND BLINKERS INCESSANTLY, PARTICULARLY IN HEAVY TRAFFIC. "THE GROUNDING WIRE

2003 BMW 325I 4-DOOR SEDAN - PROBLEM: ELECTRIC DOOR LOCKS WILL NOT ALWAYS UNLOCK WITH KEY FOB. PERSISTENT WITH COLDER AMBIENT TEMPERATURES (LESS THAN 65 DEGREES F). I CAN UNLOCK DRIVERS DOOR WITH KEY, BUT NO OTHER DOORS UNLOCK. ISSUE: THE DOOR LOCKS DOUBLE-LOCK MEANING WHEN DOORS ARE LOCKED, THEY CAN'T BE OPENED FROM OUTSIDE OR INSIDE (BY PULLING ON HANDLE). THE ONLY DOOR THAT UNLOCKS WITH INTERIOR HANDLE PULL IS DRIVERS DOOR. IF VEHICLE IS IN AN ACCIDENT MY PASSENGERS WILL NOT BE ABLE TO UNLOCK THEIR DOORS TO EXIT VEHICLE! THEY ARE BASICALLY LOCKED INSIDE. THIS IS A BIG SAFETY ISSUE, ESPECIALLY IF THERE IS A DANGER OF FIRE OR SOME OTHER EVENT THAT NECESSITATES QUICKLY EXITING THE CAR. MY RESEARCH: I'VE BASICALLY NARROWED IT TO THE GM5 MODULE THAT CONTROLS THE DOOR LOCKING AND UNLOCKING. THIS MODULE CONTROLS SOME OTHER VEHICLE FUNCTIONS AS WELL. THE DOOR LOCKING FUNCTION WORKS GREAT, BUT UNLOCKING IS SPORADIC WITH AMBIENT TEMPERATURE FLUCTUATIONS. OPINION: THERE SHOULD BE AN INVESTIGATION OPENED ON THIS ISSUE. READING SEVERAL BMW USER FORUMS THIS APPEARS TO BE A COMMON PROBLEM ACROSS MANY VEHICLE YEARS. THE DOUBLE-LOCKING DOOR LOCKS ARE A NICE ANTI-THEFT FEATURE, BUT ARE DANGEROUS IF THE SYSTEM MALFUNCTIONS. BMW MUST ACKNOWLEDGE A DEFECT IS PRESENT IN THE GM5 MODULE AND TAKE APPROPRIATE ACTION. *TR

MULTIPLE BLINKER AND BRAKE LIGHTS PERIODICALLY MALFUNCTION ON MY 2003 BMW 325I. I UNDERSTAND FROM TALKING WITH SEVERAL OTHER BMW OWNERS THAT THIS IS A COMMON OCCURRENCE DUE TO FAULTY DESIGN INVOLVING THE GROUNDING OF THE LIGHT FIXTURES. FURTHERMORE, I FEEL THIS IS A SAFETY ISSUE THAT BMW SHOULD PAY TO HAVE REPAIRED. *TR

TL* THE CONTACT OWNS A 2003 BMW 325XI. THE TAIL LIGHTS STOPPED FUNCTIONING WITHOUT ANY PRIOR WARNINGS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE ENTIRE REAR LIGHTING SYSTEM NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 54000.

REAR LIGHTING SYSTEM, TO INCLUDE TURN SIGNAL AND BRAKE LIGHT, ON MY 2003 BMW 325I WORKS INTERMITTENTLY. BMW ACKNOWLEDGED DEFECT IN SYSTEM IN SI B 63 03 06, DATED FEBRUARY 2007 BUT TO DATE HAS REFUSED TO INITIATE A RECALL TO FIX THIS SAFETY DEFECT. THE NATURE OF THE DEFECT CAUSES THE LAMP HOUSING TERMINALS TO BURN AND BURNS THE SURROUNDING PLASTIC HOUSING. THIS CAN BE A FIRE HAZARD PARTICULARLY OF THERE IS FLAMMABLE MATERIAL IN THE TRUNK. OBVIOUSLY THE BRAKE LIGHTS WORKING INTERMITTENTLY IS AN OBVIOUS HAZARD. THE REPAIR COSTS APPROX $600 FOR BOTH SIDES. *TR