1999 Volvo V70 complaints

THE THROTTLE ON OUR 1999 VOLVO V70 HAS FAILED. THE PROBLEM WAS NOTICED BY UNUSUAL THROTTLE BEHAVIOR ON THE FREEWAY AT 60 - 70 MILES PER HOUR. AFTER THIS BEHAVIOR HAD OCCURRED SEVERAL TIMES OVER A PERIOD OF MONTHS, THE ETS LIGHT CAME ON INDICATING A THROTTLE PROBLEM. THE PROBLEM CAUSED AN UNUSUAL FEELING TO DRIVING THE CAR AS IF THERE WERE SOME RESISTANCE OR IMPEDIMENT TO THE ENGINE RUNNING PROPERLY. THE ETS WARNING LIGHT CAME ON THE DATE BELOW LISTED AS "INCIDENT DATE," BUT THE PROBLEM WAS OCCURRING OVER A FEW MONTH PERIOD BEFORE THAT DATE. THE ETS LIGHT DID NOT STAY ON, BUT THERE IS CLEARLY A PROBLEM WITH THE THROTTLE. I TOOK THE CAR TO THE DEALER, LEE VOLVO IN WELLESLEY, MA AND WAS TOLD THE THROTTLE NEEDED TO BE REPLACED. THIS IS WORRISOME, BECAUSE THE MANUAL SAYS TO TURN THE CAR OFF AND BACK ON WHEN THE ETS LIGHT COMES ON, BUT THE ETS LIGHT WILL NOT CONSISTENTLY INDICATE A PROBLEM, WHEN THE THROTTLE IS DEFECTIVE AS OURS IS. WE OWN A 2000 VOLVO S70, WHICH I UNDERSTAND MAY HAVE THE SAME THROTTLE, AND THAT YOU ARE CONSIDERING A RECALL FOR VOLVO THROTTLES. IT IS EXPENSIVE TO REPLACE THE THROTTLE $1,000+, AND DANGEROUS AS IT IS A PROBLEM WHICH MAY ARISE AT 70 MILES AN HOUR WITH NO WARNING. *NM

1999 VOLVO V70 ENGINE STARTS AND THEN STOPS SUDDENLY. SOMETIMES WILL HAVE TO RESTART ENGINE 3 OR 4 TIMES BEFORE IT CONTINUES TO RUN. DEALER HAS BEEN UNABLE TO FIND AND/OR REPAIR THIS PROBLEM. *JB

1999 VOLVO V70 ETM (ELECTRONIC THROTTLE MODULE) FAILURE - MY WIFE AND 3 YEAR OLD DAUGHTER WERE DRIVING THE CAR ON A MAJOR FOUR LANE AVENUE, IN HEAVY TRAFFIC, WHEN THE ETM FAILED. THE CAR STARTED IDLING ROUGH. WHEN SHE CAME TO A STOP LIGHT, SHE HAD TO PRESS THE BRAKE EXTREMELY HARD TO PREVENT THE CAR FROM LUNGING INTO THE VEHICLE IN FRONT OF HER. WHEN SHE ACCELERATED TO PROCEED, THE CAR WOULD ONLY GO A MAXIMUM OF 30 MPH, EVEN WITH THE ACCELERATOR PRESSED TO THE FLOOR. LUCKILY, THE CROWN VOLVO DEALERSHIP (GREENSBORO, NC) WAS ON THE SAME STRETCH OF AVENUE. SHE MANAGED TO GET TO THE DEALERSHIP AND GET IT REPAIRED. WE WERE DEVASTATED WHEN THEY TOLD US THE REPAIR WOULD COST $934.00. WE WERE ABLE TO GET THAT REDUCED TO $836.24, BECAUSE WE JUST HAPPEN TO HAVE A $100 DISCOUNT COUPON IN THE GLOVE COMPARTMENT. WE HAD JUST HAD A 60,000 MILE SERVICE PERFORMED ON THE CAR A COUPLE MONTHS AGO. THE ACTUAL MILEAGE WHEN THE ETM FAILED WAS 64,284. THE REPAIR INCLUDED REPLACING THE FAULTY ETM, A GASKET, AND A ETM PROGRAM RELOAD. *JB

DT: WHILE DRIVING VEHICLE LOST POWER AND DIED ON THE HIGHWAY. CALLER SAID THE ELECTRIC THROTTLE SYSTEM WARNING LIGHT CAME ON WHEN THE VEHICLE LOST POWER. HE WAS ABLE TO GET THE VEHICLE RESTARTED BUT IT WOULD NOT IDLE RIGHT AND COULD NOT BE DRIVEN. VEHICLE WAS TOWED TO DEALER WHO DETERMINED THAT THE ELECTRIC THROTTLE NEEDE TO BE REPLACED. MANUFACTURER SAID SOMETIMES THESE THINGS FAILED. *AK *NM

DT: WHILE DRIVING ON 09/10/2005 THE VEHICLE HESITATED/LOST POWER AND DIED. ALSO ETS LIGHT APPEARED. IN ADDITION, BRAKES WERE NOT HOLDING. THIS STARTED IN 2002. *AK

SIRS - I FILE THIS COMPLIANT TO ADD TO THOSE ALREADY FILED BY OTHERS THAT DOCUMENT MALFUNCTIONING ELECTRONIC THROTTLE MODULES IN 1999 TO 2001 VOLVO 60/70/80-SERIES VEHICLES. MY 1999 V70 T5 CURRENTLY EXHIBITS THE CONDITIONS INDICATIVE OF ETM MALFUNCTION (E.G., ROUGH STARTING, UNEVEN ACCELERATION, AND INTERMITTENT SURGING WHEN DRIVING AT STEADY STATE HIGHWAY SPEEDS). THE ETS DASH PANEL LIGHT IS ILLUMINATED. ONLY ONCE HAS THE CAR COMPLETELY STALLED (AND IT OCCURRED IN THE VOLVO OF IRVINE, CA PARKING LOT AS I WAS DEPARTING). THE CAR JUST TURNED 90K MILES. IT HAS NOT LEFT ME STRANDED ON A HIGHWAY BUT I'M VERY CONCERNED THAT IT WILL STALL AND GO INTO "20-MPH LIMP HOME" MODE AND MAKE ME A TARGET. *NM

1999 VOLVO V70 W/61,000. ELECTRONIC THROTTLE MODULE FAILURE (ETS AND CHECK ENGINE LIGHTS: ROUGH IDLE ON START (SURGING);SLOW SPEED ONLY. DEALER SERVICE MGR. INDICATED THEY REPLACE MANY, BUT NOT AT SUCH LOW MILEAGE. NO INDICATION THAT FAILURE WAS IMMINENT EXCEPT SLIGHT, OCCASIONAL HESITATION AFTER STARTUP. TRIP LENGTH OF 3 MILES. SUBSEQUENT STARTUP AND COMMUTE TO DEALER UNEVENTFUL EXCEPT CHECK ENGINE LIGHT WAS LIT. *NM

I'VE HAD NUMEROUS ELECTRONIC PROBLEMS WITH MY VOLVO V70 SINCE I BOUGHT IT IN 1998. THE VEHICLE HAS BEEN BROUGHT BACK TO THE VOLVO REPAIR DEALER FOR MANY REPAIRS (I HAVE ORGANIZED DOCUMENTS OF ALL THE REPAIR ORDERS) CLEARLY IDENTIFIED AS "LOST OF POWER" WHILE DRIVING. MOSTLY ON SMALL ROADS AND ONLY ONCE ON AN INTERSTATE. ORIGINALLY STARTED UNDER WARRANTY, I WAS TOLD THAT THE SAME PROBLEM WAS NOT COVERED OUTSIDE OF WARRANTY WHEN I SPOKE WITH THE PRESIDENT OF VOLVO NORTH AMERICA'S SECRETARY. I HAVE HAD MANY PARTS REPLACED TRYING TO CORRECT THE SITUATION INCLUDING TWO ELECTRONIC THROTTLE CONTROL UNITS (TOTALING THREE IF YOU INCLUDE THE ONE THAT CAME WITH THE CAR). "LOSS OF POWER", "STALLING AT TRAFFIC LIGHTS", "HESITATION WHEN PRESSING ON ACCELERATOR", AN OTHER COMMENTS ARE ALL DOCUMENTED IN THE VOLVO REPAIR SHOP REPAIR ORDERS. THE PROBLEMS CONTINUED UNTIL THROUGHOUT MY OWNERSHIP OF THE CAR. I FINALLY GAVE UP AND SOLD IT JUNE 05. THE REPAIRS THAT VOLVO DID TO MY V70 WOULD WORK FOR A WHILE AND THEN THE LIGHTS WOULD SOON COME BACK ON. I'D PUT UP WITH IT FOR A WHILE UNTIL THE CAR STARTED TO BECOME TO DANGEROUS TO DRIVE (HESITATION) AND THEN I'D BRING IT IN FOR REPAIR. VOLVO TRIED DIFFERENT SOLUTIONS AND TOLD ME THAT THE COMPUTER CODES INDICATED DIFFERENT REPAIRS, BUT TO ME IT WAS ALWAYS THE SAME SYMPTOMS. I WOULD BE GLAD TO SHARE THE ENTIRE BOOK OF REPAIR ORDERS OVER THE 7 YEARS (AND 167,000 MILES) THAT I OWNED THE CAR. AGAIN THEY WERE ALWAYS DONE AT A CERTIFIED VOLVO DEALERSHIP. *J

DT: THE CONTACT STATED BASICALLY THE WARNING LIGHT WAS COMING ON IN THE LATTER PART OF 2003. IT HAPPENED SEVERAL TIMES. HE TOOK THE VEHICLE TO THE DEALER, AND THE DEALER TOLD HIM THAT HE COULD HAVE IT CLEANED, BUT THE WARNING LIGHT COULD STILL COME ON. HE WOULD EVENTUALLY HAVE TO REPLACED THE ELECTRONIC THROTTLE MODULE (ETM). THE CONTACT HAD IT REPLACED IN 2-04, AND JUST FOUND OUT ABOUT THE PROBLEM WITH THE VALVES. HE CALLED THE DEALER STATING HE WOULD LIKE HIS MONEY BACK FROM VOLVO. BECAUSE THE CAR WAS NOT UNDER WARRANTY AT THE TIME HE HAD THE ETM REPLACED, AND BECAUSE THE MILEAGE WAS 64,495, THEY COULD NOT REIMBURSE HIM. THE CALLER WAS NOT THE ORIGINAL OWNER. *AK

CARS STALLS WITHOUT WARNING AT VARYING SPEEDS. SOMETIMES I JUST LOSE ACCELERATION WITHOUT WARNING- HAS CAUSED TWO NEAR CAUSES. I HAVE WRITTEN IN THE DATE OF MY LAST INCIDENT -BUT IT HAS OCCURRED INTERMITTENTLY FOR THE PAST YEAR. *NM

FAILURE OF ELECTRONIC THROTTLE SYSTEM OCCURRED. NO INJURIES DUE TO IMMEDIATE DISCONTINUED USE AFTER WARNING LIGHT ILLUMINATED. AFTER LIGHT ILLUMINATED, I DROVE THE CAR STRAIGHT HOME FROM WORK, PARKED IT AND AM CURRENTLY RESEARCHING WHERE I WILL TAKE IT TO GET REPAIRED. I HAVE RECENTLY READ NUMEROUS ARTICLES ON THIS PROBLEM THAT OTHERS ARE HAVING AS WELL, AND WANTED TO NOTE THIS INCIDENT AS WELL.

1) 1999 VOLVO V70. ETS LIGHT APPEARED ON DASHBOARD. 2) THROTTLE BODY ASSEMBLY DEFECTIVE 3) PARTS REPLACED WITH NEW. *JB

I OWN A 1999 VOLVO V70 AWD WAGON WITH 55,000 MILES. WE WERE TRAVELING ON THE HIGHWAY AT ABOUT 70 MPH AND THE CAR STARTED TO SURGE. THE ETS LIGHT CAME ON. WE WERE ABLE TO DRIVE HOME, BUT THE CAR WAS RUNNING ROUGHLY. I CONTACTED THE DEALER AND MADE AN APPOINTMENT TO BRING IT IN. I WAS TOLD THAT THE ELECTRONIC THROTTLE BODY MODULE NEEDED TO BE REPLACED. THEY ALSO SUGGESTED A COMPLETE VEHICLE SOFTWARE UPGRADE. I HAVE AN EXTENDED WARRANTY (SOLD TO ME BY THE DEALER), BUT IT DID NOT COVER THIS REPAIR. *JB

ROUGH ENGINE IDLE, FLUCTUATING IDLE SPEED, UNPREDICTABLE ACCELERATION RATE. *JB

THE VOLVO BEGAN TO SPORADICALLY LOSE POWER AND STALL. I CALLED THE VOLVO DEALER AND MADE AN APPOINTMENT AFTER IT STALLED WHILE CORNERING AND MY WIFE HAD ALMOST LOST CONTROL OF THE VEHICLE. ON 9/23/04 THE VEHICLE WAS TOWED TO VOLVO. THEY CHECKED FOR CODES, BATTERY CABLES, FUEL AND IGNITION AND BATTERY AND FOUND NOTHING WRONG. THEY REPLACED A RELAY. TOTAL COST WAS $173.15. THE PROBLEM WAS STILL PRESENT AND I HAD THE VEHICLE TOWED BACK IN ON 11/16/04. THEY THEN DIAGNOSED THE PROBLEM AS A FAULTY THROTTLE UNIT. THEY REPLACED IT AND PERFORMED A SOFTWARE RELOAD. THE COST OF THAT SERVICE WAS $ 1077.14. THE VEHICLE HAS NOT STALLED SINCE. *NM

VEHICLE SPEED CONTROL. 1ST FAILURE OCCURRED WHEN I WAS DRIVING MY 9 YEAR OLD DAUGHTER AND 6 YEAR OLD NEIGHBOR. TRAFFIC WAS HEAVY AND THE SURGE ALMOST CAUSED ME TO REAR END THE CAR IN FRONT OF ME. LACK OF POWER WITH NORMAL ACCELERATION WHICH LEADS TO MORE PRESSURE TO THE ACCELERATOR LEADING TO AN EVENTUAL DANGEROUS SURGE. VERY NOTICEABLE AT A DEAD START, BUT DOES OCCUR AT DIFFERENT SPEEDS. EXPLAINED BY DEALERSHIP THAT ETM NEEDS REPLACING. REPLACEMENT COST WILL BE $800-$1200. *NM

WHILE DRIVING THE CAR, MY WIFE WOULD EXPERIENCE STALLS WITH OUR CHILDREN IN THE REAR SEATS. WHEN THE CHECK ENGINE LIGHT CAME ON, OUR DEALER DIAGNOSED THE PROBLEM OF A FAULTY ELECTRONIC THROTTLE MODULE ON OUR 1999 V70. *JB

1999 VOLVO V70 WAGON. MASS REGISTRATION 9418PG MY 16 YEAR OLD DAUGHTER DRIVING WITH HER MOTHER IN THE ABOVE DESCRIBED 1999 VOLVO ON RT 3 SOUTHBOUND BETWEEN MILTON & MARSHFIELD MASSACHUSETTS, WHEN THE ETS LIGHT CAME ON AND THE VEHICLE BEGAN TO SHAKE AND STALL. MY WIFE HAVING EXPERIENCED THIS BEFORE INSTRUCTED MY DAUGHTER TO PULL OVER ONTO THE SHOULDER OF THE ROAD AND RESTART THE CAR. MY WIFE & I PAID SOUTH SHORE VOLVO OF NORWELL MASSACHUSETTS $1100 TO REPLACE THIS ETS OR ETM SYSTEM JANUARY OF THIS YEAR. WE HAVE ALSO HAD SPENT $800. ON TWO OXYGEN SENSORS THAT SOUTH SHORE VOLVO INITIALLY DIAGNOSED AS THE PROBLEM. WE HAVE FURTHER SPENT AN ADDITIONAL $125. ON AN IGNITION SWITCH WHICH HAS BEEN CAUSING ALL OF THE DASHBOARD LIGHT TO CONTINUOUSLY LIGHT AND GO OUT, NOW THE SPEEDOMETER AND MILEAGE METER HAVE BEGUN TO FAIL.. SOUTH SHORE VOLVO HAS REFUSED TO CORRECT THE PROBLEMS, THEY WILL NOT EVEN RETURN OUR CALLS. CALIFORNIA HAS FILED A CLASS ACTION LAWSUIT IN AN ATTEMPT TO GET SOME RELIEF FOR IT'S CITIZENS. I AM GOING TO ATTEMPT TO JOIN THEIRS, WOULD PREFER SOME APPRECIATE SOME ASSISTANCE. THANK YOU VINCENT P STANCATO. PS, 20 YEAR VOLVO OWNER, I DRIVE A 1991 VOLVO 245, USED TO LIKE THESE CARS. *NM

DT: THE VEHICLE STALLED. THE DEALER REPLACED THROTTLE BODY 3 TIMES. *AK *JB

ENGINE IDLING IMPROPERLY, READ ABOUT ELECTRONIC THROTTLE FAILURES THROTTLE FAILED, REPLACEMENT REQUIRED. *JB

1999 VOLVO V-70 LOST ALL POWER WENT INTO LIMP HOME MODE APPROX 25 MPH W/O WARNING . THIS OCCURRED ON AN INTERSTATE WITH HEAVY TRAFFIC. EMT CLEANED PROBLEM STILL OCCURRING MAKING FOR A VERY UNSAFE AND DANGEROUS AND CONDITIONS. *JB

ETS LIGHT ON, DEALER REPLACED ETM CUSTOMER PAY. RECEIPTS FAXED TO ODI, THIS VOQ CREATED FROM E-MAIL SENT BY CURRENT OWNER MR. SCOTT. THE CONSUMER STATED THE PART FAILED AND WAS REPLACED BEFORE HE PURCHASED THE VEHICLE, BUT HE IS SURE IT WILL HAVE TO REPLACED AGAIN. *JB

OUR 1999 VOLVO V70 SIMPLY STOPPED WITHOUT WARNING. PORTLAND, ME DEALER "REPROGRAMMED THE COMPUTER" AND "CHECKED." WE DROVE 1500 MILES AND AGAIN IT STOPPED...THIS TIME REPEATEDLY. INDIANAPOLIS DEALER KEPT THE CAR FOR 3 WEEKS AND REPORTED THAT THEY INADVERTANTLY SOLVED WHATEVER THE PROBLEM WAS ($435). IN THE SUBSEQUENT MONTH & 4500 MILES LATER, ALL APPEARS TO BE WELL.

DT: VEHICLE STALLED/DIED, AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK

PROBLEMS WITH MY 1999 VOLVO V70 INCIDENT 5/10/05 1. EVENTS LEADING UP TO THE FAILURE. MY CAR EXPERIENCED A FALTER THEN ROUGH IDLE AND DRASTICALLY REDUCED POWER. IN ADDITION THE CHECK ENGINE LIGHT WENT ON. 2. THE CAR SEEMED TO RECOVER AND I WAS ABLE TO MAKE IT HOME. 3. I TOOK MY CAR INTO MY REPAIR SHOP AND HAD THE PROBLEM DIAGNOSED. I WAS TOLD THE FAULT CODES REGISTERED IN THE CARS COMPUTER INDICATED THERE WAS A FAILING EVAPORATOR PURGE VALVE ALONG WITH BAD ELECTRONIC THROTTLE MODULE (ETM). THE REPAIR COST ME $1,070.00. INCIDENT 5/24/05 1.AFTER A LITTLE OVER 3 MONTHS MY CAR HAS EXPERIENCED THE SAME SYMPTOMS. FALTER THEN ROUGH IDLE AND DRASTICALLY REDUCED POWER. IN ADDITION THE CHECK ENGINE LIGHT WENT ON. 2.I PLAN TO HAVE THE CAR ANALYZED BY THE SAME REPAIR SHOP THAT DID THE PREVIOUS $1,070.00 WORTH OF WORK. 3.RESOLUTION PENDING INVESTIGATION BASED ON THE RESEARCH I HAVE DONE THIS ISSUE SEEMS SIMILAR TO ACTION NUMBER: PE05041 THAT IS CURRENTLY BEING INVESTIGATED BY NHTSA. NHTSA ACTION NUMBER : PE05041 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE : VOLVO MODEL: V70 MANUFACTURER : VOLVO CARS OF N.A. LLC. YEAR : 2001 COMPONENT : VEHICLE SPEED CONTROL DATE INVESTIGATION OPENED : JULY 26, 2005 DATE INVESTIGATION CLOSED : OPEN SUMMARY: THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED ONE HUNDRED AND THIRTY-ONE (131) CONSUMER COMPLAINTS ALLEGING A VARIETY OF CONCERNS RESULTING FROM FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES, INCLUDING A SUDDEN LOS

I HAVE HAD TWO 1999 VOLVO 70-SERIES. ONE A V70 WAGON, AND THE OTHER A S70 SEDAN. BOTH HAD A FAILURE OF THE ELECTRONIC THROTTLE MODULE (ETM). THE ETM ON THE V70 FAILED AT 61,091 MILES. THE S70 FAILED AT 101,312 MILES FOR ME, BUT SINCE WE BOUGHT THE CAR USED AT ABOUT 98,000 MILES, I DO NOT KNOW IF IT FAILED BEFORE. THE V70 WAS EXHIBITING SYMTOMS AND WAS REPLACED UNDER WARRANTY WHEN I BROUGHT IT IN FOR SERVICE. THE S70 HOWEVER FAILED ON THE ROAD IN TRAFFIC WITH MY DAUGHTER DRIVING, WHILE I WAS ALSO IN THE CAR. IT WAS REPLACED BY VOLVO, BUT COST ME AS THERE WAS NO WARRANTY.

ON AUG. 13, 2005, MY WIFE WAS DRIVING ON A PUBLIC ROAD IN SAN FRANCISCO APPROX. 35 MPH WHEN HER 1999 VOLVO V70 (APPROX. 72,500 MILES ON THE ODOMETER) STALLED. I CALLED PUTNAM VOLVO IN BURLINGAME THE FOLLOWING TUESDAY, AND MADE A SERVICE APPOINTMENT FOR THURSDAY, AUG. 18. THAT THURSDAY MORNING, WHEN I STARTED THE CAR, IT BEGAN TO IDLE ROUGHLY, SURGING FROM APPROX. 800 RPM TO 1500 RPM REPEATEDLY. I SHUT THE CAR DOWN, THEN RESTARTED IT; THE CAR THEN RAN FAIRLY NORMALLY. PUTNAM VOLVO DIAGNOSED THE PROBLEM AS A FAULTY THROTTLE CONTROL MODULE, AND CHARGED ME $1225.00 FOR THE REPAIR. IT SEEMS THAT MANY OF THESE THROTTLE CONTROL MODULES ARE FAILING PREMATURELY.

1. EVENTS LEADING TO FAILURE.... ABOUT 3 WEEK PRIOR, EXPERIENCED HESITATION (ALMOST STALLING) WHEN SLOWING FROM HIGHWAY SPEEDS TO LOWER AND STOPPING SPEEDS. *NM 2. FAILURE.... FINALLY, IT HAPPENED. (I HAD JUST READ AN ARTICLE ABOUT THIS IN THE PAPER!) IT STALLING WHEN SLOWING DOWN AND WOULDN'T RESTART UNTIL SOME 2 HOURS LATER. LUCKILY IT WAS DAYTIME AND IN A GOOD NEIGHBORHOOD. 3. WHAT WAS DONE... TOOK IT INTO VOLVO DEALER WITH THE SYMPTOMS AND THEY REPLACED THE ETM. LOTS OF $$$!

WHILE DRIVING AT HIGHWAY SPEED 65-70 MPH CAR SUDDENLY JUMPED FORWARD THEN SLOWED AND STALLED WHILE DRIVING ON HWY. LUCKILY I WAS ABLE TO PULL TO THE SIDE OF THE ROAD WITHOUT A PROBLEM. AFTER A FEW MINUTES THE CAR RESTARTED AND WOULD DRIVE BUT WAS SURGING JUST LIKE BEFORE IT STALLED. I QUICKLY DROVE THE CAR HOME AND PARKED. THE PROBLEM HAS NOT YET BEEN CORRECTED BUT WAS QUOTED $1000 TO REPLACE THE ELECTRONIC THROTTLE MODULE BY DEALER (WILDE VOLVO IN BROOKFIELD, WI). THE SAME DEALER ALSO TOLD ME THAT THEY REPLACE AN AVERAGE OF THREE OF THE ELECTRONIC THROTTLE MODULES EVERY WEEK. THAT SEEMS LIKE A DEFECTIVE PART IF THEY CHANGE 3 A WEEK AT 1,000 EACH AND THE STALLING COULD CAUSE A SERIOUS ACCIDENT. *NM

COMPLAINT: PASSENGER-SIDE FRONT ELECTRIC WINDOW SWITCH INOPERABLE. RESOLUTION: DEALER REMOVED & REPLACED RIGHT FRONT WINDOW SWITCH. THIS IS THE 1ST OF 2 ELECTRIC WINDOW SWITCH FAILURES. I WILL ALSO BE REPORTING THE LATER 2ND FAILURE ON NHTSA'S WEBSITE AS WELL, AS A SEPARATE INCIDENT. *JB

COMPLAINT: NONE OF THE ELECTRIC WINDOW SWITCHES (ALL 4 DOORS) OPERATE; SIDE-VIEW MIRRORS ELECTRIC SWITCH INOPERABLE. RESOLUTION: FAULT TRACED TO INTERNAL FAULT IN WINDOW SWITCH PACK MASTER CONTROL. DEALER REMOVED & REPLACED. THIS IS THE 2ND TIME THIS VEHICLE HAS HAD A PROBLEM WITH INOPERABLE ELECTRIC WINDOW SWITCHES. THE 1ST TIME HAS ALSO BEEN REPORTED TO NHTSA'S WEBSITE (ODI #10133081).*JB

ETM DEFECT , CAR STALL ON HIGHWAY,REPLACE ON DEALER ON MY COST AND BROKEN AGAIN 3 MONTHS LATER, SAME SITUATION LIKE EVERYBODY WITH THIS DEFECTIVE PARTS . VOLVO REPRESENTATIVE SAID THERE NO PROBLEM WITH THESE PARTS !!! SO I HAVE TO PAY FOR THE REPLACEMENT ALL THE LIFE OF THE CAR !! EACH 6 MONTHS ??? 1200.00 $$$ *NM

I WAS DRIVING SOUTH ON I-85 IN DULUTH, GA. THIS STRETCH OF METRO ATLANTA INTERSTATE HAS SIX LANES IN EITHER DIRECTION AND TRAFFIC WAS FLOWING AT SPEEDS OF AROUND 75 MPH. THE ETS LIGHT CAME ON WHEN WE WERE IN THE FAR LEFT (FAST) LANE, THE CAR BEGAN LOSING POWER. I MOVED TO THE RIGHT AS BEST I COULD AND GOT OFF AT THE NEXT EXIT. BY THE TIME I GOT TO THE EXIT RAMP, THE CAR WAS SKIPPING AND MISSING BADLY. MY DAUGHTER LOOKED UP ETS IN THE OWNER'S MANUAL AND, BASED ON WHAT THE MANUAL SAID, I CUT THE CAR OFF AND WAITED A FEW MINUTES FOR IT TO RESET. I CRANKED IT BACK UP AND WE LIMPED THE REST OF THE WAY HOME. SINCE THEN I HAVE ONLY STARTED IT ONCE, BUT IT WAS RUNNING ROUGH SO I DID NOT GO ANYWHERE. CONSIDERING WHAT WE HAVE LEARNED ABOUT ETM FAILURES SINCE THIS HAPPENED AND THE AMOUNT OF TRAFFIC IN ATLANTA, I HAVE BEEN SCARED TO DRIVE IT. HAVING TO CROSS FIVE LANES OF FAST-MOVING TRAFFIC IN A CAR RAPIDLY LOSING POWER IS NOT A SAFE SITUATION. *JB

MALFUNCTIONING OF THE ELECTRONIC THROTTLE SYSTEM (ETS) ON MY 1999 VOLVO V70 STATION WAGON CAUSED ME TO LOSE POWER OR STALL COMPLETELY WHILE DRIVING. IT HAPPENED SEVERAL TIMES PRIOR TO HAVING THE ETS REPLACED. IT OCCURRED FOR ME AT LOW SPEEDS AND IN LIGHT TRAFFIC ALLOWING ME TO GET OFF THE ROAD. I WAS ABLE TO RESTART THE ENGINE AFTER A SHORT TIME INTERVAL. IT COULD HAVE BEEN A MAJOR SAFETY HAZARD IF I HAD THIS FAILURE AT HIGHWAY SPEEDS AND IN TRAFFIC. THIS OCCURRED SEVERAL MONTHS AGO AND HAS BEEN REPAIRED AT MY EXPENSE, BUT ON READING AN ASSOCIATED PRESS ARTICLE TODAY ON AN INVESTIGATION OF THIS PROBLEM BY THE NHTSA, I AM SUBMITTING THIS AS ANOTHER INSTANCE OF THE PROBLEM BEING INVESTIGATED. *NM THE AIR CONDITIONING COMPRESSOR AND POWER WINDOWS HAD TO BE REPLACED. CURRENTLY, THE CHECK ENGINE LIGHT IS ON. *JB

1999 VOLVO V70 DEVELOPED A PROBLEM WITH THE THROTTLE BODY SENSOR RESULTING IN THE VEHICLE STALLING. *MR THE CONSUMER EXPERIENCED NUMEROUS PROBLEMS WITH THE VEHICLE; REPLACEMENT OF DEFECTIVE GEAR SHIFTER LIGHT SOCKET AND THE DRIVER SIDE WINDOW SWITCH, BATTERY LEADS MALFUNCTION CAUSING THE BATTERY TO FAIL, THE REAR WINDOW WASHER PUMP BURNED OUT, AND THE DRIVER DOOR CHECK STRAP HAD BROKEN OFF. *SC

DT: CONSUMER OWNS A 1999 VOLVO V70. VEHICLE STALLED/ DIED AND LOST POWER DUE TO THROTTLE VALVE FAILURE. *AK

DURING NORMAL DRIVING CONDITIONS THE 1999 VOLVO V70 GLT WILL STALL, OR DIE OUT. OTHER INSTANCES THAT OCCUR ALONG WITH OR ALONE, ARE THE GAUGES ALL BEING CUT OFF. MY WIFE SAYS THEY LOOK LIKE THEY WERE UNPLUGGED. WE HAVE BEEN REALLY PUNISHED FOR PURCHASING THIS VEHICLE. VOLVO HAS REPLACED NUMEROUS PARTS AND OTHER MECHANICS HAVE AS WELL (BECAME TO COSTLY @DEALERSHIP-THINK THEY ARE VERY DISREPUTABLE). THIS CAR HAS BEEN DRIVEN PRIMARILY IN THE CITY OF NASHVILLE AND KEPT VERY CLEAN AND SERVICED REGULARLY. WITH 117,000 MILES ON IT, THE DEALERSHIP HAS REPLACED ONE THROTTLE BODY @85000 AND IT NOW NEEDS ANOTHER. THESE AREN'T RELATED I DON'T THINK BUT I CAN EXPLAIN MUCH BETTER OVER THE PHONE. *JB

ENGINE STUTTER / STALL / ENGINE SPEED REDUCED AND NOT DRIVABLE - MULTIPLE OCCURRENCES BEFORE AND AFTER REPAIRS OVER PERIOD OF 5 YEARS. DEALER REPAIR 9/27/00 13941 MILES REPLACED THROTTLE BODY. SECOND INSTANCE RECORDS NOT READILY AVAILABLE - BELIEVE REPLACED MANIFOLD. THIRD INSTANCE 9/16/03 36061 MILES - REPLACED MULTIPLE COMPONENTS UNTIL PROBLEM WENT AWAY. FOURTH INSTANCE JULY 2005 APPROX 75000 MILES TRACS, ABS, CHECK ENGINE LIGHT WITH ERRATIC VEHICLE SPEED - HAD TO KEEP THROTTLE HIGH RPM BUT DIAGNOSIS WAS WHEEL SPEED SENSOR REPAIRED AND PROBLEM WENT AWAY - BUT STARTING TO SHOW SAME STUTTER ON START UP THAT PREDATED FIRST FAILURE - HAS NOT FAILED YET, BUT WIFE REFUSES TO DRIVE AS UNSAFE DUE TO MULTIPLE FAILURES AND LOSS OF POWER / SPEED IN TRAFFIC. I BELIEVE THIS CAR IS AN EXAMPLE OF THE INVESTIGATION IN WORK - REF PE05041. *NM

THE ELECTRONIC THROTTLE MODULE IN MY VOLVO V70 FAILS WITHOUT WARNING. OFTEN AT HIGHWAY SPEEDS, THIS RESULTS IN A SUDDEN LOSS OF SPEED (ALMOST AS IF THE BRAKES WERE SUDDENLY APPLIED). THOUGH VOLVO'S OWNERS MANUAL INDICATES THIS CAN HAPPEN, AND RECOMMENDS RESTARTING THE CAR (UNDER THE SECTION ON THE ETS LIGHT), I AM CONVINCED THE REPEATED FAILURES CONSTITUTE A SAFETY HAZARD. WERE IT TO OCCUR WHEN CHANGING LANES OR MERGING, I FEAR THE SITUATION COULD BE QUITE BAD. ALTHOUGH VOLVO RECOMMENDS REPLACING THE ETM FOR $1000+, I AM RELUCTANT TO DO SO, NOT LEAST BECAUSE OTHERS WITH THE SAME PROBLEM HAVE SPENT THE MONEY TO REPLACE THE MODULE, AND THEN ENDED UP WITH THE SAME PROBLEM AGAIN. RECENTLY, THE INCIDENTS ARE OCCURRING AS OFTEN AS ONCE VERY 15 TO 30 MINUTES.*JB

MY NAME IS [XXX] AND I CURRENTLY OWN A 1999 VOLVO V70. ON AUGUST 1, I HEARD ON THE NEWS THAT NHTSA WAS INVESTIGATING A POTENTIAL ENGINE PROBLEM WITH VOLVOS. THIS WAS THE SAME DAY I WAS TAKING MY CAR TO A LOCAL VOLVO DEALER FOR ITS 150,000 MILES SERVICE AND ONE OF THE PROBLEMS I WAS PLANNING TO REPORT WAS THAT THE CAR STALLS OCCASIONALLY WHEN I AM DRIVING OR JUST LOOSES SPEED. I HAVE REPORTED THIS PROBLEM IN THE PAST TWO YEARS TO AT LEAST THREE VOLVO DEALERS IN THE NEW YORK/NEW JERSEY METROPOLITAN AREA AND I HAVE BEEN TOLD IN ALL OCCASIONS THAT THE PROBLEM COULD NOT BE REPLICATED WHEN CONDUCTING THE SERVICE. THE STALLING PROBLEM BEGAN IN 2003 AND HAS HAPPENED 12 TIMES TO DATE. IN ONE OCCASION I WAS DRIVING AT 50 MILES AN HOUR IN A HIGHWAY WHEN THIS HAPPEN. MY WIFE AND MY CHILD WERE IN THE CAR THEN. WE WERE ALL UNHARMED. WHEN I TOOK MY CAR TO THE VOLVO DEALER ON AUGUST 1, I GOT A CALL FOR THE SERVICE PERSON AND I WAS TOLD THAT THE THROTTLE OF THE CAR HAD AN INTERNAL FAULT AND NEEDED TO BE REPLACED FOR ALMOST $1,000. I WAS ALSO TOLD THAT THIS WAS THE REASON WHY MY CAR WAS STALLING OR LOOSING SPEED. HOWEVER, KNOWING THAT THE CAR MODEL IS CURRENTLY UNDER INVESTIGATION FOR A SIMILAR PROBLEM, I DECIDED NOT TO FIX IT UNTIL THE OUTCOME OF THE INVESTIGATION IS KNOWN. IN MY OPINION, THIS PROBLEM EXISTS WITH THE VOLVO MODELS -- INCLUDING MINE - AND ENCOURAGE THE NHTSA TO PURSUE THE INVESTIGATION . THANK YOU. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.

THE ELECTRONIC THROTTLE MODULE IN MY 1999 VOLVO V70 AS BEGUN TO FAIL WITHOUT WARNING. OFTEN THE PROBLEM WILL FIX ITSELF UPON RESTARTING. HOWEVER, WHEN THE MODULE FAILS (AND THE ETS LIGHT COMES ON IN THE DASH), AN EXTREMELY SUDDEN LOSS OF POWER IS EXPERIENCED---ENOUGH THAT IT COULD EASILY LEAD TO A LOSS OF CONTROL. THE PROBLEM HAS OCCURRED AT LEAST 15 TIMES IN THE PAST 2 DAYS, AND IS A SERIOUS SAFETY HAZARD. VOLVO, IN THE OWNERS MANUAL FOR THE CAR, INDICATES THAT THIS FAILURE MAY SOMETIMES OCCUR (IN THE SECTION DESCRIBING THE ETS LIGHT) AND SUGGEST TRYING TO RESTART THE CAR. WHILE RESTARTING THE CAR DOES OFTEN WORK, I FIND THIS TO BE AN UNACCEPTABLE AND VERY SERIOUS SAFETY HAZARD. VOLVO'S SOLUTION FOR ME IS TO REPLACE THE THROTTLE MODULE AT $1000 OR MORE. MANY HAVE EXPERIENCED THIS SAME PROBLEM, THOUGH, AND THE DEFECT SEEMS TO BE CLEARLY SYSTEMIC. WHAT'S MORE, THERE IS NO EVIDENCE THAT VOLVO'S REPLACEMENTS WON'T EXHIBIT PRECISELY THE SAME PROBLEM. *JB

NO EVENTS LEADING TO FAILURE. ELECTRONIC THROTTLE CONTROL MODULE FAILED WHILED DRIVING ON FREEWAY. FORCED TO MAKE EMERGENCY STOP AND HAVE VEHICLE TOWED TO REPAIR FACILITY TO HAVE THE MODULE REPLACED. *JB

DURING THE MONTH OF MARCH, 2005, I WAS DRIVING MY 1999 VOLVO V70 ON THE INTERSTATE AT 65 MILES PER HOUR WHEN THE CAR JERKED SEVERAL TIMES AND SLOWED TO 10 MILES PER HOUR; NOT ACCELERATING PASS THAT SPEED. I EXITED THE INTERSTATE AND DROVE HOME AT THE SPEED OF 10 MILES PER HOUR OR LESS. TO PREVENT THE CAR FROM STOPPING AT RED LIGHTS, I PLACED THE CAR IN PARK AND PRESSED THE ACCELERATOR TO KEEP THE CAR FROM STOPPING. I HAD THE CAR TOWED TO VOLVO SOUTH ATLANTA AND IT WAS DETERMINED THAT THE THROTTLE BODY HAD TO BE REPLACED AT A COST OF $905.44. THE PARTS WERE DISPOSED OF BUT I HAVE A RECEIPT FOR THE THROTTLE BODY, GASKET AND ETM RELOAD. *NM

"CHECK ENGINE" LIGHT CAME ON 8/3/05. TOOK CAR TO DEALERSHIP FOR DIAGNOSIS. SAID IT WAS MALFUNCTION OF THROTTLE THAT REGULATES AIR GOING INTO ENGINE. NO CONSEQUENCES AS OF YET. *NM

INCIDENCE 2 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER REPORTS; VIBRATION WHEN COMING TO A STOP. SHOP FOREMAN ROAD TESTED WITH CUSTOMER; FELT POOR IDLE AT STOPPING OF CAR. ACCESS DIAGNOSTIC TROUBLE CODE; NONE STORED. R&R THROTTLE BODY. CLEAN AND ADJUST THROTTLE UNIT." THIS INCIDENT WAS THE 2ND OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200. *JB

INCIDENCE 3 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "[THROTTLE & CRUISE] CUSTOMER REPORTS: ETS LIGHT COMES ON INTERMITTENTLY - LIGHT GOES OUT ON RESTART. ACCESS DIAGNOSTIC CODES: ECM 91A7. PERFORM SOFTWARE DOWNLOAD & RESET ADAPTATIONS." THIS INCIDENT WAS THE 3RD OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206. *JB

INCIDENCE 4 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER REPORTS: 1) WHEN SLOWING DOWN TO A STOP TACH DROPS AND THEN PICKS BACK UP WHEN CAR COMES TO A STOP. CLEAN THROTTLE HOUSING. 2) WAS GETTING 20 MILES PER GALLON NOW ABOUT 17 1/2. PERFORM SOFTWARE UPGRADE FOR ECM, TCM AND ETM." THIS INCIDENT WAS THE 4TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207. *JB

INCIDENCE 5 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: CHECK ENGINE LIGHT ON. THERE ARE DRIVE ABILITY CONCERNS. CAR CUTS OUT INTERMITTENT RIGHT AFTER STARTING - WARM OR COLD START. SEE ATTACHED. ACCESS DIAGNOSTIC CODES: ECM 2110 AND ECM 720A. REPLACE IMMOBILIZER ANTENNA RING AND FRONT OXYGEN SENSOR. RESET ADAPTATION." THIS INCIDENT WAS THE 5TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208. *JB

INCIDENCE 6 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: ETS LIGHT CAME ON AFTER DRIVING CAR AT HIGHWAY SPEEDS. WHEN DECELERATING DOWN TO LOCAL (TOWN) SPEED CAR HAS A SEVERE SPUTTERING, HESITATION AS IF IT WAS GOING TO STALL. FAULT TRACED SYSTEM WITH VADIS AND RETRIEVED CODES ECM-532D ECM-9190, ECM-91A7, AND ECM-91F0... REPLACED ELECTRONIC THROTTLE ASSEMBLY, AND DOWNLOADED NEW SOFTWARE TO ADAPT CAR." THIS INCIDENT WAS THE 6TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #1013120.*JB

INCIDENCE 7 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: EVER SINCE THROTTLE WAS DONE A COUPLE OF MONTHS AGO, FEELS LIKE IT IS GOING IN AND OUT OF GEAR WHILE DRIVING- FEELS FOR A MICRO SECOND AT VARIOUS TIMES GOING IN AND OUT OF GEAR. NINO CAN CALL FOR MORE INFO IF NECESSARY. REFER TO RO 435245 09/17/04 78697 MILES - FOUND DEFECT IN THROTTLE UNIT ASSEMBLY REPLACED -- TECHNICIAN FOUND CODES FOR ETM INTERNAL MALFUNCTION. REPLACED ETM AND PERFORMED DOWNLOAD." THIS INCIDENT WAS THE 7TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I HAVE REPORTED ALL THE PREVIOUS INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #10131209 6) ODI #10131213. *JB