2000 Volvo S70 complaints

I OWNED A VOLVO S70 2000 MODEL WITH A VARIETY OF MAINTENANCE ISSUES RELATED TO STALLING AND SURGING. I HAD TO PAY FOR A NEW THROTTLE MODULE, AIR MASS SENSOR AND THROTTLE CLEANING. I BELIEVE THIS COST OVER $1000 ON PARTS THAT SHOULD HAVE BEEN DESIGNED TO LAST FAR LONGER THAN THEY DID. YOU CAN FIND MORE INFO ON THIS PROBLEM AT HTTP://WWW.VOLVO-FORUMS.COM/LOFIVERSION/INDEX.PHP/T1877.HTML. *JB

MY 2000 VOLVO S70 FAILED ON I-55 IN MS. AND I HAD TO PULL OFF THE ROAD IN HIGH SPEED TRAFFIC. IT WAS VERY DANGEROUS. EACH TIME THE FAILURE WAS IMMEDIATELY PRECEDED BY THE ETS LIGHT COMING ON. *NM

DT: VEHICLE STALLED/DIED, AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK

FAILURE OF ELECTRONIC THROTTLE CONTROL MODULE RESULTED IN SUDDEN AND PERSISTENT LOSS OF SPEED AND STEERING ASSIST WITHOUT WARNING WHEN DRIVING ON HIGHWAY IN TRAFFIC.*JB

RECENTLY MY 2000 S70 VOLVO HAS BEEN EXPERIENCING ACCELERATION PROBLEMS. MY ETS ELECTRONIC THROTTLE SYSTEM)LIGHT WILL ILLUMINATE CAUSING THE CAR TO SHUDDER AND EVENTUALLY STALL IN RUSH HOUR TRAFFIC. AFTER A FEW MOMENTS AND AFTER RE-START , THE VEHICLE WILL FUNCTION AS NORMAL. I TOOK IT TO MY VOLVO SHOP AND WAS INFORMED THAT IT IS THE ELECTRONIC MODULE AND MUST BE REPLACED BY A CERTIFIED VOLVO DEALER. I HAVE RECENTLY SET UP AN APPOINTMENT TO HAVE THIS REPAIR COMPLETED. *JB

2000 VOLVO S70 GLT-SE; ETS LIGHT CAME ON AND VEHICLE LOST POWER ON I-10 IN HEAVY TRAFFIC. LIMPED IN TO A VOLVO DEALER. CAR WAS INSPECTED BY A VOLVO TECH. THE THROTTLE BODY WAS OUT OF FACTORY SPECS. HE REPLACED THE THROTTLE BODY ASSEMBLY AND REPROGRAMMED IT AT A COST OF $985.38. NOT WHAT ONE WOULD EXPECT FROM VOLVO. THIS EVENT NOT ONLY WAS INCONVENIENT BUT PUT MY FAMILY IN DANGER IN HEAVY INTERSTATE TRAFFIC. VOLVO SHOULD MAKE THIS RIGHT!*JB

I OWN A 2000 VOLVO S70. I EXPERIENCED THE FAILURE OF THE ELECTRONIC THROTTLE MODULE SEVERAL TIMES THIS YEAR, 2005. THE CAR WOULD OFTEN RUN ROUGH AND ATTEMPT TO STALL WHILE DRIVING. ON ONE TRIP FROM NEW ALBANY, IN, TO CLEVELAND, OH, IT HAPPENED SO OFTEN THAT I HAD TO LEAVE THE CAR IN CINCINNATI AND RENT A CAR FROM ENTERPRISE CAR RENTAL IN ORDER TO GET TO CLEVELAND. THAT RENTAL COST ME $236.04. I TRIED TO HAVE THE PROBLEM DIAGNOSED AT SEVERAL GARAGES IN SOUTHERN INDIANA, BUT TO NO AVAIL. FINALLY, I TOOK THE CAR TO VOLVO OF LOUISVILLE, KENTUCKY, ON JULY 7, 2005. THEY DIAGNOSED THE PROBLEM AS A FAULTY ELECTRONIC THROTTLE MODULE AND REPLACED THE ENTIRE THROTTLE BODY SYSTEM AT A COST OF $803.73. WHAT PROMPTED MY FILING THIS COMPLAINT WAS AN ARTICLE THAT APPEARED IN THE LOUISVILLE COURIER-JOURNAL ON AUGUST 2, 2005. IT WAS WRITTEN BY ASSOCIATED PRESS REPORTER KEN THOMAS. IT INDICATED THAT THERE HAD BEEN 136 COMPLAINTS REGARDING THE ELECTRONIC THROTTLE MODULE. ONE OF THE MODELS MENTIONED WAS THE 2000 S70 SEDAN, WHICH I OWN. *JB

CAR STALLED WITHOUT WARNING A COUPLE OF TIMES. *JB

FAILURE AND ITS CONSEQUENCES. *JB

WHILE DRIVING FROM CLEVELAND TO ROSWELL, GA, THE ELECTRONIC THROTTLE CONTROL MODULE FAILED IN MY 2000 VOLVO S70. THIS CAUSED THE ENGINE TO LOSE POWER AND THE POWER-STEERING FAILED. I HAD TO PULL INTO A PARKING LOT BESIDE THE ROAD. THE ENGINE COMPLETELY STOPPED. AFTER ABOUT 30 MINUTES, I WAS ABLE TO RESTART IT. THE LOCAL VOLVO DEALER RECOMMENDED REPLACING THE MODULE AT A COST OF OVER $1000. OLD PART WAS NOT RETURNED.*JB

DT: VEHICLE INTERRMITTENTLY STALLED AND DIED . TOOK VEHICLE TO DEALER, WHO SUGGESTED THE PROBLEM WA STHE INTAKE MANIFOLD SYSTEM. *AK

HERE'S WHAT HAPPENED TO US: WE (MY WIFE, THREE YEAR OLD SON AND I) WERE DRIVING OUR 2000 VOLVO S70 SEDAN DOWN INTERSTATE 95 FROM WASHINGTON DC TO NORTH CAROLINA. IN VIRGINIA, THE ELECTRONIC THROTTLE SYSTEM (ETS) SENSOR CAME ON. WE STOPPED, LIKE THE MANUAL SUGGESTED, RESTARTED THE CAR AND THE LIGHT WENT OUT. MIDWAY THROUGH VIRGINIA, THE ETS LIGHT AND CHECK ENGINE LIGHT CAME ON SIMULTANEOUSLY. WE STOPPED AND AGAIN STOPPED THE ENGINE. UPON RESTART, THE ETS LIGHT WENT OFF, BUT NOT THE CHECK ENGINE LIGHT. THIS TOOK PLACE THE WHOLE TRIP DOWN I-95. WE MADE IT HOME, BUT DON'T FEEL COMFORTABLE DRIVING OUR THREE YEAR OLD AROUND. THE VEHICLE STARTED TO LOSE SPEED WHEN THE SENSOR CAME ON. WE STOPPED ALMOST IMMEDIATELY EVERY TIME, WHICH IS NO GREAT THRILL WHEN YOU ARE DRIVING ON AN INTERSTATE. WHEN THE CRUISE CONTROL WAS SET, THE LIGHT CAME ON, KICKED OFF THE CRUISE CONTROL AND BEGAN TO SHAKE AND SHIMMER. WE STOPPED ABOUT TEN TIMES DURING A 150 MILES TRIP. *NM

DT: VEHICLE STALLED AND LOST POWER DUE TO ELECTRONIC THROTTLE FAILURE. I TWOULD COST $1000.00 TO REPLACE IT. *AK

LEADING UP TO THE INCIDENT MY CAR WOULD STALL OR LOSE POWER. WHILE DRIVING ON A VERY BUSY RTE 202 MY CAR LOST POWER IN THE LEFT HAND LANE. IT THE COMPLETELY DIED AND WOULD NOT START. I THEN HAD IT TOWED TO THE CLOSEST MECHANIC (FRANCIS AUTOMOTIVE IN WEST CHESTER, PA). IT WAS DIAGNOSED AS HAVING A BAD VEHICLE SPEED CONTROL WHICH COST IN EXCESS OF $1000 TO FIX. AFTER TALKING TO OTHER VOLVO OWNERS ABOUT THIS I FOUND THAT IT VERY COMMON. IN ADDITION TO THIS I HAVE A PROBLEM WITH THE AIR CONDITION WHICH STOPS WORKING AT INAPPROPRIATE TIMES. AI HAVE ALSO FOUND THAT THIS COMMON WITH 2000 S70'S. I BOUGHT THIS CAR ON VOLVO'S PAST QUALITY REPUTATION. TURNS OUT IT WAS THE BIG MISTAKE I SHOULD HAVE STUCK WITH A NISSAN OR TOYOTA! *NM

FAILED THROTTLE MODULE. *NM

I AM WRITING JUST TO SUPPLY ADDITIONAL INFORMATION REGARDING YOUR ONGOING INVESTIGATION PE05041. DURING THE FIRST FEW YEARS THAT I OWNED MY 2000 VOLVO S70 GLT SE, I EXPERIENCED SEVERAL ELECTRONIC THROTTLE CONTROL FAILURES, WHICH GREW PROGRESSIVELY WORSE. THE VEHICLE WOULD SUDDENLY LOSE SPEED WHEN ACCELERATING AND BE UNRESPONSIVE WHEN THE GAS PEDAL WAS DEPRESSED. THE CAR WAS STILL UNDER WARRANTY WHEN THESE FAILURES OCCURRED, SO VOLVO REPLACED THE ELECTRONIC THROTTLE CONTROL MECHANISM AT NO CHARGE. TO DATE, THE REPLACEMENT MECHANISM HAS NOT FAILED, BUT I WOULD BE INTERESTED IN KNOWING WHAT THE AVERAGE FAILURE AGE OF THE REPLACEMENT PARTS HAS BEEN. I HAVE TWO SMALL CHILDREN WHO ARE FREQUENTLY IN THE CAR WITH ME. *NM

WE PURCHASED THE VOLVO 2000 S70 VEHICLE IN 9/01 WITH 25,000 MILES. A 30,000 MILE CHECK-UP WAS PERFORMED BY SANTA MONICA VOLVO ON 12/26/01. STEVEN AND I BEGAN A 14-MONTH ROAD TRIP AROUND THE US AND HAD THE VEHICLE MAINTAINED AT VOLVO DEALERS THROUGHOUT THE COUNTRY (THE CHECK ENGINE LIGHT PERIODICALLY CAME ON AND WE WOULD ASK THE DEALERS ABOUT IT. WE WERE TOLD NOT TO WORRY ABOUT THE LIGHT.) THE ROAD TRIP ACCOUNTS FOR THE ACCRUED MILES PUT ON THE VEHICLE IN SUCH A SHORT PERIOD OF TIME. RETURNED TO CALIFORNIA 3/04. BROUGHT THE VEHICLE INTO SANTA MONICA VOLVO TO HAVE THE 75,000 MILE CHECK-UP. THEY DID THE CHECK-UP AND WE DROVE AWAY. THE ETS AND CHECK ENGINE LIGHT CAME ON WITHIN ONE MILE, CAR BEGAN TO JERK, CALLED THE DEALER AND IMMEDIATELY RETURNED THE VEHICLE. SM VOLVO DID THE DIAGNOSTICS BUT DID NOT KNOW WHY THE ETS LIGHT CAME ON AS WE DROVE AWAY. THESE THINGS HAPPEN, THEY SAID. SM VOLVO EXPLAINED THAT CERTAIN CODES CAME UP, THEY WOULD RESET THE COMPUTER (CODE EZM#91A7 ON THE THROTTLE UNIT) AND DOWNLOAD A NEW PROGRAM. THEY WOULD BE ABLE TO REPAIR IT BY DOING ADDITIONAL WORK AND DID NOT GUARANTEE THE COMPUTER RESET. WE ASKED IF THE REPAIR WOULD BE GUARANTEED OR COULD WE DRIVE OFF AGAIN AND GET THE SAME RESULTS. THEY COULD NOT GUARANTEE THAT IT WOULD RESOLVE THE ISSUE. THIS LED US TO BELIEVE THAT EVERYTIME WE APPROVED THEM TO REPAIR THE PROBLEM, IT WOULD CONTINUE TO OCCUR. NOT GUARANTEEING THAT THEY CAN RESOLVE THE PROBLEM MADE US CONSIDER MORE RESEARCH AND/OR A SECOND OPINION. WE

MY 2000 VOLVO S70 HAD A MALFUNCTION OF THE ELECTRONIC THROTTLE CONTROL MODULE AND I ALMOST GOT REAR ENDED ON THE HIGHWAY WHEN THE CAR HAVE AN ABRUPT LOSS OF SPEED. I TOOK THE CAR TO A VOLVO DEALER AND WAS CHARGED $1,500 TO REPLACE THE MODULE ABOUT 5 WEEKS AGO BUT IT LOOKS LIKE THE CAR IS STARTING TO MALFUNCTION AGAIN. *JB

2000 VOLVO S-70 CAR STALLED WHILE TRAVELING AT ANY SPEED. I HAD TO SPEND $1200 TO HAVE THE ELECTRONIC MODULE THAT REGULATES THE AIRFLOW AND GAS TO THE ENGINE REPLACED. I DID SOME RESEARCH AND FOUND THIS TO BE A COMMON PROBLEM WITH THIS MODEL. VOLVO IS AWARE OF THE PROBLEM, BUT IS NOT RECALLING OR REIMBURSING CAR OWNERS. *NM

VEHICLE EXHIBITS "HESITATION AND STUTTERING" DURING BOTH ACCELERATION AND MAINTAINING STEADY SPEED. ETS WARNING LIGHT HAS APPEARED AND THEN RESET TWICE. TUNE-UP AND FUEL CHANGES WERE TESTED WITH NO CHANGE IN ISSUE. ETS WARNING LIGHT AND ON-BOARD DIAGNOSTICS INDICATED ELECTRONIC THROTTLE MODULE FAILURE AND REQUIRED REPLACEMENT. I HAVE THE OLD PART AND THE DIAGNOSTIC PRINTOUTS. AFTER RESEARCHING THIS ISSUE, IT APPEARS THAT THIS IS A COMMON AND PREMATURE FAILURE ITEM ON VOLVO CARS FROM 1999 THRU 2001 MODEL YEARS. SINCE THIS IS A CRITICAL SFAETY COMPONENT THAT CAN FAIL WITHOUT NOTICE (AT THE WORST POSSIBLE TIME), IT SHOULD BE AS RELIABLE AS OTHER CRITICAL COMPONEENTS SUCH AS THE ABS OR SRS/AIRBAG SYSTEMS. THIS DOES NOT APPEAR TO BE THE CASE.

2000 VOLVO S70 ELECTRONIC THROTTLE FAILURE.*MR THE CONSUMER STATED THE FAILURE OF THE ELECTRONIC THROTTLE LEAVES THE DRIVER WITH UNEXPECTED LOSS OF THROTTLE CONTROL. *JB

MY 2000 VOLVO S70 IS EXPERIENCING ENGINE TROUBLE OVER THE LAST FEW MONTHS. I HAVE BEEN TOLD BY A REPAIR SHOP THAT IT IS THE ELECTRONIC THROTTLE MODULE CAUSING THE PROBLEM. AFTER NUMEROUS PHONE CALLS TO SEVERAL OTHER SHOPS AND DEALERS, AS WELL AS INVESTIGATIONS OVER THE INTERNET, IT APPEARS THAT THERE IS A DEFECT IN THE MODULE THAT WILL CAUSE THE CAR TO GO INTO A "CRIPPLE MODE" AT ANY GIVEN POINT. THIS HAS HAPPENED TO ME. VOLVO APPARENTLY DOES NOT BELIEVE THAT IT IS A PRODUCT DEFECT, BUT RATHER IT IS A MAINTENANCE ISSUE. I HAVE HAD THE MODULE CLEANED BUT IT HAS NOT HELPED THE PROBLEM. I DO NOT BELIEVE THAT A SITUATION SUCH AS THIS, WHICH WILL COST ABOUT $1,000 TO FIX, CAN BE CONSIDERED A MAINTENANCE ISSUE. THE CAR HAS LESS THAN 60,000 MILES.

ELECTRONIC THROTTLE FAILURE (ETS), CAR STOPPED RESPONDING TO THROTTLE INPUT WHILE DRIVING ON HIGHWAY, CAR NEEDS TO BE FIXED BUT I CAN'T AFFORD THE OUTRAGEOUS COST OF THE REPAIR $1100.

THE CONSUMER EXPERIENCED A PROBLEM WITH THE THROTTLE BODY AND MASS AIRFLOW ON HIS 2000 VOLVO S70. *JB THE POWER STEERING FAILED AND FLUID LEAKED ALL OVER THE DRIVEWAY. THE POWER STEERING PUMP AND RESERVOIR NEEDED TO BE REPLACED. WHY DRIVING, THE AIR DIRECTOR FELL OFF THE BUMPER. *JB *NM

WELL, I'VE ALSO JOINED THE ETS CLUB AT ABOUT 60,000 MILES ON MY S70, 2000, TO THE TUNE OF $860 BUCKS! IT HAPPENED AT THE MOST INOPPORTUNE TIME. WHILE CRUISING SOUTH ON I-95, JUNE 6TH, CAR STARTED TO RUN LIKE IT HAD WATER IN THE GAS. AFTER ABOUT AN HOUR OR SO OF THAT, THE ETS WARNING LIGHT COMES ON, SO I CHECK THE OWNER'S MANUAL, AND IT SAYS TO TURN OFF THE CAR, AND RESTART, AND IF THE LIGHT COMES BACK ON, (YOU'RE IN DEEP DOO-DOO) THEN HEAD FOR A VOLVO DEALER. WELL, IT DID COME BACK ON AND ABOUT AN HOUR LATER, THE CAR GOES INTO THE "LIMP-HOME" MODE OF ABOUT 40 MPH. FORTUNATELY WE WERE ABLE TO "LIMP" INTO WILMINGTON, NC, AND LUCKILY, PARKWAY VOLVO WAS ONLY ABOUT ONE-HALF MILE FROM THE COMFORT INN, WHERE WE CRASHED FOR THE EVENING. PARKWAY VOLVO WAS ABLE TO GET TO MY CAR THE VERY NEXT DAY, REPLACED THE ETS MODULE, AND TO DATE (23 JUN 05) THE CAR RUNS LIKE NEW. THE CUSTOMER SERVICE AND TECHNICAL SKILL OF THE SERVICE MANAGER (BRENT WELLS) ARE SUBERB!!! FORTUNATLEY, I ASKED FOR THE OLD ETS UNIT AND HAVE SINCE LEARNED THAT DON WILSON MIGHT TO HAVE IT. I'M SENDING HIM AN EMAIL ([email protected]) TO SEE IF HE STILL WANTS THEM FOR TESTING). I'M ALSO FILING A COMPLAINT AND WILL SUPPORT A "CLASS ACTION LAWSUIT" ANY WAY POSSIBLE. IT'S UNBELIEVABLE THAT VOLVO WON'T STEP UP TO THE PLATE AND TAKE RESPONSIBILITY FOR THIS "DEFECT"..... DEFECTIVE UNIT HAS THESE MARKINGS: MARELLI, 110541F2A, 00W080201; 9188793; 65CFM2; AH.0082030.K. NOTE: THE BOX THAT THE NEW ONE CAME IS IS MARKED: VOLVO 86

2000 S70 - MULTIPLE REPAIRS AND MULTIPLE RECURRING INCIDENTS OF THIS SAME PROBLEM! CHECK ENGINE LIGHT COMES ON, ENGINE RUNS ROUGH, TACH BOUNCES AND POWER DEMINISHES BECOMING A SEVER HAZARD IN HIGH SPEED TRAFFIC. DEALER FOUND THE PROBLEM TO BE "KNOWN ISSUES" WITH THE ELECTRONIC AIR MASS AND THROTTLE SYSTEMS. REPLACED TWICE WHILE UNDER WARRANTY, EXTENDED WARRANTY DENIED, SHORTLY OUT OF WARRANTY AND PROBLEM RETURNS AGAIN. DEALERSHIP NOR VOLVO WILL TAKE ANY CORRECTIVE ACTION ON >$1000 REPAIR (WHICH ACCORDING TO THE SERVICE TECH IS ALMOST GUARANTEED TO RETURN). THIS IS MY THIRD VOLVO, AND CERTAINLY MY LAST.

2000 VOLVO XL70 HEATER BLOWER FAN NOT WORKING AND STARTED SMOKING.*MR THE HEATER BLOWER MOTOR WAS REPLACED. *NM

INTERMITTENT LOSS OF ALL INTERIOR POWER INCLUDING WINDOWS, DOOR LOCKS, DASHBOARD LIGHTS, HEAT, A/C, WINDSHIELD WIPERS, AIR BAGS, RADIO. CALLED DEALER/SERVICER AND WAS TOLD THEY NEVER HEARD OF THE PROBLEM; CALLED AGAIN A FEW MONTHS LATER AND WAS TOLD TO BRING IT IN; BROUGHT IN FOR SERVICE AND TOLD "NO PROBLEM FOUND." SEVERAL MONTHS LATER LOSS OF ALL INTERIOR POWER MORE FREQUENTLY; BROUGHT IN FOR SERVICE AGAIN AND TOLD THE ENGINE WIRING HARNESS HAD MELTED WIRING AND HAD TO BE REPLACED;WAS ALSO TOLD COULD HAVE RESULTED IN FIRE IF CONTINUED TO OPERATE THE VEHICLE; HAD TO REPLACE ENGINE WIRING HARNESS; COULD NOT OPERATE WINDSHIELD WIPERS IN POURING RAIN; COULD NOT SEE DASHBOARD AT NIGHT;

ELECTRONIC THROTTLE SYSTEM IN MY 2000, VOLVO S70 WENT OUT, AND THE CAR SURGED AND LIMPED HOME. NO ADVERSE CONSEQUENCES OCCURRED THIS TIME, BUT THE POTENTIAL FOR DISASTER BY BEING STRANDED ON A BUSY HIGHWAY OR ELECTRONIC THROTTLE SYSTEM MALFUNCTIONING AS YOU PULL OUT INTO TRAFFIC RAISED MANY SAFETY CONCERNS. THIS SEEMED FROM MY RESEARCH TO BE A COMMON PROBLEM, AND THE ONLY OPTION WAS TO CARRY A CELL PHONE AND MAKE SURE YOUR INSURANCE COVERED TOWING. TO MAKE THINGS WORSE THE REPAIRS COST NEARLY $1000, AND COULD HAPPEN AGAIN DUE TO THE SAME FAULTY PART BEING INSTALLED A SECOND TIME. VOLVO SHOULD OWN UP TO THIS AND RECALL ALL THE VEHICLES WITH THIS FAULTY PART.*AK

1. ETS LIGHT, HESITATION, HAD TO PRESS PEDAL DOWN TO FLOOR TO GET CAR TO MOVE. . DANGER OF STOPPING/STALLING IN TRAFFIC 3. REPLACE THROTTLE BODY $923.00 , 62,492 MILES SERVICED REGULARLY WITH DEALER -- THANKS FORD. *AK

WHILE DRIVING 40 MPH THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT ILLUMINATED ON THE CONSUMER'S 2000 VOLVO V70XC. THE VEHICLE STARTED LOSING POWER THEN CAME TO A STOP. *NM THE MANUFACTURER WAS CONTACTED BUT DIDN'T SEEM TO BE CONCERNED AND REFUSED TO COVER THE COST TO REPAIR THE VEHICLE. *NM

(SAFETY ISSUE) WHILE DRIVING ON THE HIGHWAY, THE PLASTIC SUN ROOF AIR DEFLECTOR SHATTERED AND PIECES OF THE AIR DEFLECTOR ENDED UP ON THE HIGHWAY POSSIBLY HITTING OTHER VEHICLES. THERE ARE NO SIGNS OF THE AIR DEFLECTOR BEING HIT BY ANY TYPE OF OBJECT. IT JUST APPEARED TO CRACK IN THE CENTER AND THE CENTER SECTION CAME OFF. BOTH ENDS OF THE DEFLECTOR WERE STILL ATTACHED TO THE VEHICLE. I DID REPORT THIS INCIDENT TO VOLVO, BUT THEY DID NOT SEEM CONCERNED ABOUT IT AND WOULD NOT LET ME KNOW IF THIS WAS A RECURRING INCIDENT. *NM

THROTTLE BODY WAS DEFECTIVE. VEHICLE WILL NOT ACCELERATE. DEALER STATED THROTTLE NEEDED TO BE CLEANED.*AK THE FAULTY THROTTLE MODULE CAUSED THE VEHICLE TO STALL AND SOMETIMES MADE IT IMPOSSIBLE TO MAINTAIN A CONSTANT SPEED. *NM

AUTOMATIC TRANSMISSION DEVELOPED A PROBLEM: SLIPPING AND SHUDDERING DURING ACCELERATION BETWEEN 16-20 MPH. THE VOLVO DEALER SAID TRANSMISSION WAS DAMAGED AND COULD NOT BE REPAIRED: THEY REPLACED IT WITH A REBUILT VOLVO TRANS. WARRANTY WAS 4 YR, 50,000 MI: TRANS FAILED AT 3 YR, 9 MO, 56839 MI -THE DEALER REFUSED TO HONOR WARRANTY OR TO TRY TO REPAIR EXISTING TRANS: INSISTED UPON REPLACEMENT OF TRANS AT COST OF $3,889.92. *JB THE CONSUMER FELT THAT VOLVO INTENTIONALLY PLACED DEFECTIVE AUTOMATIC TRANSMISSIONS IN THEIR VEHICLES TO FAIL PREMATURELY. *SC *JB

DRIVING ON INTERSTATE HIGHWAY, CAR BEGAN TO HESITATE AND STALL ELECTRONIC THROTTLE CONTROL WAS DEFECTIVE, CAR BECAME INOPERABLE DEALER REPLACED THROTTLE BODY AND ASSOCIATED PARTS. *AK

MY ETS LIGHT KEPT COMING ON. I HAD TO STOP MY CAR IN HIGH SPEED TRAFFIC 10-12 TIMES AND RESTART IT. A WEB SEARCH REVEALS THAT THIS IS A FREQUENT PROBLEM WITH VOLVO S-70. THE CAR SUDDENLY LOSES POWER AND WILL SHUT OFF IF YOU CONTINUE TO DRIVE.*AK

I HAVE A 200 VOLVO S70. A COUPLE OF DAYS AGO, MY SON WAS DRIVING IT AND, SUDDENLY, THE ETS INDICATORLIGHT CAME ON, THE CAR STARTED SHAKING, AND LOST POWER (MY SON SAID IT COULDN'T GO FASTER THAN ABOUT 10 MPH). MY OWNER'S MANUAL INFORMS ME THAT THIS LIGHT INDICATES A FAULT IN THE ETC (ELECTRONIC THROTTLE CONTROL SYSTEM). IN RESEARCHING THIS PROBLEM, I HAVE DISCOVERED THAT IT IS FAIRLY WIDESPREAD. THIS IS POTENTIALLY VERY DANGEROUS. IN FACT, ONE PERSON GAVE A HARROWING ACCOUNT (ON THE INTERNET) OF ALMOST BEING HIT BY ONCOMING TRAFFIC WHILE MAKING A LEFT TURN BECAUSE THIS PROBLEM CAUSED HIS CAR'S SPEED TO DIMINISH TO A CRAWL EVEN AS HE FLOORED THE ACCELERATOR IN A SITUATION WHERE OTHER DRIVERS RIGHTLY EXPECTED HIM TO BE MOVING MUCH MORE QUICKLY. APPARENTLY, THE USUAL REPAIR FOR THIS PROBLEM IS REPLACEMENT OF THE ECM(ELECTRONIC CONTROL MODULE), A JOB WHICH COSTS ABOUT A THOUSAND DOLLARS. CONSIDERING THE SIGNIFICANT EXPENSE OF THIS JOB, MANY VOLVO DRIVERS MIGHT BE UNDERSTANDABLY RELUCTANT TO PART WITH THAT MUCH MONEY; THAT COULD BE DANGEROUS. I HAVE SPOKEN TO SEVERAL PEOPLE AT VOLVO DEALERSHIPS AND WILL SPEAK TO SOMEONE IN THE SERVICE DEPARTMENT OF MY LOCAL VOLVO DEALER TOMORROW. I SHOULD ADD THAT, AFTER LETTING THE CAR SIT WITH THE IGNITION OFF FOR ABOUT A HALF HOUR, IT STARTED RIGHT UP AND HAS BEEN PERFORMING ABSOLUTELY NORMALLY SO FAR. SOME SAY THE PROBLEM WILL PROBABLY HAPPEN AGAIN, AND ONE VOLVO TECHNICIAN SAID THAT MAYBE IT WAS JUST A "HICCUP" THAT WON'T EVER RETURN. I DON'T

ETS LIGHT CAME ON AND CAR THROTTLE SYSTEM WAS AFFECTED. CAR LOST POWER TWICE ON THE HIGHWAY WHEN TRAVELLING AT APPROX 60 MPH. HAD TO PULL OVER TO AVOID POTENTIAL ACCIDENT. REPEATEDLY EXPERIENCED PROBLEMS WHEN IDLING AT TRAFFIC LIGHT. THROTTLE BODY WAS REPLACED AT DEALER FOR OVER $900.00 AND VEHICLE WAS 7,000 MILES OUT OF WARRANTY. COMPLAINED TO VOLVO CUSTOMER SERVICE. NO HELP WAS GIVEN. LOSING A CUSTOMER!!!*AK

DURING NORMAL CRUISING AROUND 55-60 MPH, THE ETS LIGHT WILL COME ON AS THE VEHICLE BEGINS TO STUTTER AND THE ENGINE MODULATES. IT HAS BECOME WORSE OVER THE LAST WEEK AND NOW THE ENGINE "BUCKS" WHEN THE LIGHT IS ON! THIS IS UNPLEASANT AT 55 MPH! EVERY TIME THE ETS LIGHT COMES ON THE CRUISE CONTROL DISENGAGES AND IS NOT ABLE TO BE RESET UNTIL THE LIGHT GOES OFF MANY IGNITION CYCLES (DAYS) LATER. SOME RESEARCH WAS DONE OVER THE WEB AND IT IS AMAZING TO SEE PEOPLE DESCRIBE THE EXACT SAME OR SIMILAR MANIFESTATION HAPPEN ON THEIR S70S. I HAVE AN APPOINTMENT TOMORROW AT THE DEALER IN ANN ARBOR AND EXPECT A > $900 BILL! COME ON VOLVO, HOW CAN YOU NOT HAVE SO MANY COMPLIANTS AND NOT RECALL?*AK

THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT COME ON INTERMITTENLY FOR ABOUT A MONTH, THEN ON APRIL 20, 2004 WHILE I WAS DRIVING ON THE HIGHWAY, THE LIGHT STAYS ON THE CAR WAS SLUGGISH IN ACCELERATING. I HAD TO GET OFF THE HIGHWAY TO TAKE LOCAL STREETS. *AK

THE LEATHER ON THE DOOR INSERTS PULLED AWAY FROM THE MOLDING. IT COST 400.00 PER DOOR FOR THE REPLACEMENT. THE DEALERSHIP SERVICE DEPARTMENT STATES THIS IS KNOWN ISSUE. THIS HAPPENS 100 PERCENT OF THE TIME. MY WARRANTY HAD EXPIRED.*AK

WHEN ACCELERATING CONSUMER HEARD A KNOCKING NOISE, AND VEHICLE LOST ACCELERATION. CONSUMER CONTACTED DEALERSHIP ABOUT THIS ISSUE, AND MECHANIC DETERMINED THAT TRANSMISSION FAILED. *AK

IN EARLY OCTOBER 2003 THE ELECTRONIC THROTTLE SYSTEM (ETS) LIGHT APPEARED ON MY CAR'S PANEL. THIS AFFECTED THE DRIVABILITY OF THE VEHICLE. I PURCHASED AN ADDITIONAL WARRANTY FOR MY VEHICLE WHEN I BOUGHT THE CAR IN MAY 2000. THE DEALER INDICATED THAT MY WARRANTY WOULD NOT COVER THIS PROBLEM AND THAT IT WOULD COST APPROXIMATELY $900 TO REPAIR IT. I DECLINED THE SERVICE. THE LIGHT CONTINUES TO COME ON FREQUENTLY (I.E., EVERY 2ND OR 3RD DAY OF THE WEEK). WHEN THIS HAPPENS, I WILL PULL OVER AND TURN OFF THE CAR FOR A MOMENT. WHEN I START IT UP AGAIN, THE LIGHT DOES NOT APPEAR AND DRIVABILITY IS NORMAL. AS A VOLVO OWNER FOR THE PAST 17 YEARS, I HAVE NOT EXPERIENCED ANY SIMILAR MALFUNCTIONS. I HAVE OWNED A 1982 VOLVO 240, A 1992 VOLVO 240 AND MY CURRENT VOLVO S70. I WOULD APPRECIATE IF YOU WOULD RESEARCH THIS MALFUNCTION TO DETERMINE IF YOU HAVE RECEIVED (OR THE MANUFACTURER) COMPLAINTS FROM OTHER VOLVO OWNERS. THANK YOU FOR YOUR HELP. *NLM

12 VOLT ADAPTER NEEDED TO USE HANDS FREE CELL PHONE AS REQUIRED BY LAW IN NEW YORK & MOST OTHER STATES FAILED DUE TO DESIGN DEFECT. *AK

SPEED CONTROL. HAVE HAD A VARIETY OF SPEED/ENGINE CONTROL PROBLEMS. ENGINE WOULD DIE. ENGINE WOULD CAUSE "BUCKING". ENGINE WOULD NOT ACCELERATE. THROTTLE BODY AND AIR MASS METER REPLACED. THROTTLE BODY COVERED BY WARRANTY BUT I HAD TO PAY FOR AIR MASS METER REPLACEMENT. CURRENT PROBLEM TRAVELING @ 55 TO 60 MPH PRESS ON ACCELERATOR AND CAR WILL NOT ACCELERATE BUT WILL SLOW DOWN WITH RPMS HESITATING AT 5000 AND 4500 WITHOUT ACCELERATING. CAR SLOWS DOWN,LOSES POWER. THIS OCCURS USUALLY UNDER A HILL CLIMBING SITUATION BUT HAS OCCURRED ON FLAT TERRAIN. IN HILL CLIMBING ONCE MORE GRADUAL SLOPE REACHED, CAR ACCELERATES.*AK UPDATED 01/03/06. *JB

THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AND THE AIR BAGS FAILED TO DEPLOY. *AK THE DRIVER SIDE SEAT BELT DID NOT LOCK AND THE CONSUMER HIT THE STEERING WHEEL. VOLVO REFUSED TO SEND THE CONSUMER AN ANALYSIS REPORT. *SCC *JB

THE SEAT BELT (DRIVERS SIDE, SHOULDER) CONTINUES TO 'JAM' OR 'LOCK' IN PLACE AND IS NOT AVAILABLE FOR USE. TO CORRECT, VEHICLE MUST BE TAKEN INTO NEAREST/LOCAL DEALERSHIP FOR ADJUSTMENT AND REPAIR. THUS FAR, THIS HAS OCCURRED APPROXIMATELY SIX TIMES OVER THE PREVIOUS TWELVE MONTHS. ADDITIONALLY, ALL REPAIRS/LABOR HAS BEEN COVERED UNDER VEHICLE WARRANTY, HOWEVER, TECHNICIANS CANNOT SEEM TO DETERMINE THE CAUSE AND MAKE FINAL REPAIRS. *NLM

ON NUMEROUS OCCASIONS THE WIPERS WOULDN'T GO ON. ALWAYS HAPPENS IN THE MORNING. WASHING AND CLEANING DOESN'T HELP. DEALER DOESN'T HAVE A CLUE. PLEASE HELP! *NLM

THE VEHICLE'S TURN SIGNAL, TAIL AND BRAKE LIGHTS ARE CONSTANTLY BLOWING OUT. THE GEAR SHIFT INDICATOR HAS FAILED 3-4 TIMES. PROBLEM HAS OCCURRED AT LEAST 5-6 TIMES. DEALER IS UNABLE TO DETERMINE CAUSE. PH

I WAS IN AN ACCIDENT IN MY 2000 VOLVO S70 IN WHICH THE CAR WAS TOTALED. THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY. THE PASSENGER SIDE AIRBAG DID DEPLOY. ALTHOUGH, I WAS NOT SERIOUSLY INJURED, I WOULD LIKE TO REPORT THAT THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY AT ANY TIME DURING THE ACCIDENT.