2003 Volvo S60 complaints

1) ELECTRIC READING OF DASHBOARD GOES COMPLETELY DARK. UNABLE TO DETERMINE SPEED, FUEL, ENGINE TEMPERATURE, ECT. URGENT AIR BAG WARNING LIGHT WENT ON PRIOR TO IT GOING DARK. CAR SKIPS GEARS AND REVS WHEN GAS PEDAL IS PRESSED. 2) RADIATOR COOLING FAN KEEPS RUNNING WHEN CONNECTED EVEN WHEN VEHICLE IS TURNED OFF. IT NEVER TURNS OFF UNTIL BATTERY IS DRAINED. REPLACED ENTIRE UNIT AS WELL AS BATTERY AND STILL HAS THE SAME PROBLEM. VOLVO REPAIR STATED THEY NEVER HAD AN ISSUE LIKE THIS AND ISSUE MAYBE CONNECTED TO FAILED ELECTRICAL SYSTEM. *TR

CAR EXPERIENCES LOSS OF POWER, STALLING, SPUTTERING AND HESITATION WHEN GAS PEDAL IS PRESSED DOWN. SAN LUIS OBISPO SMITH VOLVO AUTHORIZED DEALER COULD NOT FIND ANY CODES TO EXPLAIN THIS. CHECKED TIMING SENSORS, FUEL PRESSURE, RPM CAM SIGNALS, ETH SYSTEM, AIR FLOW METER, MAP SENSOR. ALL CHECKED OUT OK, DEALER SAID ALL SIGNS POINT TO ETA FAILING. CAR STALLS AND LOSES POWER ABRUPTLY, I DO NOT FEEL SAFE DRIVING IT ANYMORE. THERE IS A RECALL FOR MODELS UP TO 2002, THIS 2003 S60 NON TURBO MANUAL SEEMS TO EXHIBIT THE FLAWS OF ELECTRONIC THROTTLE FAILURE. *TR

I AM THE OWNER OF A 2003 VOLVO S60, THIS VEHICLE HAS BEEN A HEADACHE FOR SOME TIME NOW. THE FIRST ISSUE STARTED WITH THE HEADLIGHTS BLOWING OUT. I HAVE HAD THE CAR SINCE 2008 AND THE LIGHTS HAVE BLOWN OUT ATLEAST 10X'S. THE 2ND MAJOR ISSUE I'M HAVING WITH THE VEHICLE IS THE CAR COMPLETELY SHUTS DOWN WITHOUT WARNING WHEN MAKING A TURN OR SOMETIMES SITTING IDLE AT A RED LIGHT. OF COURSE WHEN THE CAR IS HOOKED UP TO A DIAGNOSTIC MACHINE THERE ARE NO ERROR CODES AND SINCE THIS ISSUE HAPPENS WITHOUT WARNING IT NEVER HAPPENS WHEN A SERVICE TECH IS WITH ME. LASTLY, TWO DAYS AGO I STARTED MY VEHICLE AND THE ENTIRE DASH COMPLETELY BLACKED OUT. NONE OF THE GAUGES ARE OPERABLE. I CANNOT SEE WHETHER I HAVE FUEL OR NOT IN IT. I FEEL THAT THE MANUFACTURER OF THIS VEHICLE SHOULD BE HELP RESPONSIBLE FOR THESE ISSUES. I HAVE READ MANY COMPLAINTS, AND THERE WERE MANY VOLVO OWNERS WHO HAVE HAD THE SAME EXACT PROBLEMS I HAVE BEEN EXPERIENCING. THERE NEEDS TO BE A RE-CALL SO THAT THE CONSUMERS WHO HAVE PAID SEVERAL DIAGNOSTIC FEES AND REPAIRS FEES GET REIMBURSED FOR THE FAULTY PRODUCTS OR PARTS BEING USED TO BUILD THESE VEHICLES. *TR

MY INSTRUMENT CLUSTER HAS BEEN MALFUNCTIONING UNTIL IT WENT COMPLETELY BLANK, OCCASIONALLY IT WILL LIGHT UP, THIS IS A SAFETY CONCERN SINCE UNABLE TO SEE SPEEDOMETER OR VEHICLE FAULT LIGHTS. *KB

STARTED THE CAR ON A VERY COLD MORNING (AROUND 0 F) STARTED TO DRIVE AND NOTICED A HOT BURNING SMELL BUT COULDN'T SEE ANYTHING BURNING. NEXT DAY A LITTLE WARMER STARTED THE CAR AND NOTICED THE SAME SMELL AND THE LOOKING AT THE SEAT NOTICED A SMALL BURN HOLE ON THE SIDE OF THE SEAT. SEAT HEATERS WERE ON BOTH DAYS. IMMEDIATELY TURNED THEM OFF AND THE SMELL WENT AWAY. NOW I AM AFRAID TO USE THE SEAT HEATERS FOR FEAR OF FIRE. ONE OF THE TURNS OF THE CAR WAS THE SEAT WARMERS AS I LIVE IN A FAIRLY COLD CLIMATE. AND I ALSO HAVE AN UNSIGHTLY BURN ON THE LEATHER SEATS. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED WITH HIS FOOT ON THE BRAKE PEDAL, THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD INTERMITTENTLY HESITATE TO ACCELERATE FROM A STOPPED POSITION. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 20,000. UPDATED 01/04/12 *BF UPDATED 01/09/12

2003 VOLVO S60 AW DASHBOARD FAILURE. I UNDERSTAND FROM TALKING WITH AUTO MECHANICS THIS IS A COMMON PROBLEM AND IS ALSO RECOGNIZED BY AUTO ELECTRICAL REPAIR SITES. THIS EXTREMELY DANGEROUS WITH THIS LOSS OF EQUIPMENT. *TR

COMPLIANT 1: I HAVE A 2003 S60 VOLVO. THE INSTRUMENT PANEL GOES DARK AND ALL INSTRUMENTS STOP WORKING. THIS INCLUDES ALL GAUGES, SPEEDOMETER, RPM, FUEL, TEMP AND BLINKERS. THEY ALL GO TO ZERO AND PANEL TURNS BLACK AND COMPLETELY OFF. THE EXTERIOR BLINKERS DO STILL WORK. WHEN THE PANEL IS WORKING I RECEIVE VARIOUS MESSAGES SUCH AS SRS AIRBAG SERVICE URGENT, BRAKE FAILURE, AND STOP IMMEDIATELY NO OIL PRESSURE. I TOOK THE CAR TO MY MECHANIC AND HE SAID IT'S THE DRIVER INFORMATION MODULE WHICH COSTS $1300 TO REPLACE. MY MECHANIC ALSO STATED THAT THIS IS A REOCCURING PROBLEM IN THIS CAR. I HAVE DONE RESEARCH ON THE INTERNET AND HAVE FOUND THAT THERE ARE MANY VOLVO'S OF THE SAME MAKE AND MODEL IN WHICH THE SAME EXACT PROBLEMS ARE OCCURING. I FEEL THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR FIXING THIS PROBLEM. IT'S OBVIOUS THAT IT'S A RECURRING PROBLEM. COMPLIANT 2: I'M ALSO EXPERIENCING AN ENGINE STALL PROBLEM. THIS IS VERY DANGEROUS. THE CAR WILL STALL AT LEAST 50% OF THE TIME WHEN MAKING A TURN. I'VE RESEARCHED THIS AS WELL AND FOUND THAT IT'S A REOCCURRING PROBLEM AS WELL. APPARENTLY THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT AN INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. THIS CAUSES ENGINE MISFIRES AND CAUSES THE ENGINE TO SHUT DOWN COMPLETELY WHEN IN MIDDLE OF INTERSECTIONS. I HAVE COME CLOSE TO MANY DANGEROUS SITUATIONS BECAUSE OF THIS ENGINE FAILURE.

FOR SEVERAL WEEKS I HAVE INTERMITTENT ISSUES WITH ODD CODES SHOWING UP ON THE DASH BOARD AND THEN THE CAR NOT STARTING. I TOOK IT IN AND NO ONE COULD FIND ANYTHING WRONG. THIS WEEK DRIVING HOME FROM WORK ON THE HIGHWAY THE CAR WENT INTO FULL SHUT DOWN. (EXTREMELY DANGEROUS !!!!) I MANAGED TO GET THE CAR TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART A FEW MINUTES LATER AND DROVE THE CAR HOME WITH THE FLASHERS ON AND REMAINING IN THE RIGHT LANE IN CASE OF A REPEAT. I WAS IN THE FAR LEFT LANE KEEPING UP WITH RUSH HOUR TRAFFIC WHEN THE CAR DIED INITIALLY. IT APPEARS THAT THIS IS A COMMON PROBLEM WITH VOLVOS AND I AM HOPING THAT SOMETHING WILL BE DONE AS THIS IS VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL FAILED, INCLUDING ALL GAUGES AND WARNING LIGHTS. IN ADDITION, THE CONTACT STATED THAT THE BRAKES WERE AFFECTED BY THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE FAILURE WAS DIAGNOSED AS THE INSTRUMENT PANEL CONTROL MODULE. THE MANUFACTURER WAS CONTACT AND ADVISED THAT THE VEHICLE WAS OUT OF WARRANTY THEREFORE, THEY WERE NOT ABLE TO ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 89,000.

I HAVE A 2003 S600 AND THE INSTRUMENT PANEL GOES DARK AND ALL THE INSTRUMENTS STOP WORKING (SPEEDOMETER, RPM, FUEL, TEMP -- ALL GO TO ZERO) . THIS OCCURS INTERMITTENTLY, WHILE DRIVING, THE ENGINE WAS RUNNING FINE AND NO WARNING LIGHTS CAME ON. I AM ALSO EXPERIENCING PROBLEMS WITH INDICATOR LIGHTS ON THE DASHBOARD. AS AN EXAMPLE, THE BLINKER LIGHTS ON THE DASHBOARD ONLY WORK ABOUT 20% OF THE TIME. THE ACTUAL DIRECTIONALS ON THE EXTERIOR OF THE CAR ARE STILL WORKING ALL OF THE TIME. THE CONDITION SEEMS TO BE GETTING PROGRESSIVELY WORSE. IN ADDITION VARIOUS MESSAGES HAVE APPEARED -- SUCH AS SRS AIRBAG SERVICE URGENT, BRAKE FAILURE - STOP SAFELY. BROUGHT IT TO MY MECHANIC AND HE HAD TO REPLACE THE DRIVER INFORMATION MODULE (DIM) $1,300. HE STATED THAT HE HAS REPLACED 4 DIM'S WITHIN THE PAST MONTH. APPEARS TO BE A COMMON FAILURE WITH 2003 S60 MODEL. MY MECHANIC ALSO COMMENTED THAT IN THE PAST VOLVO DEALER WOULD ONLY HAVE 1 DIM IN STOCK -- THEY NOW HAVE 6 TO 8 IN STOCK. I THINK THIS SHOULD BE A MANUFACTURER EXPENSE -- NO MATTER WHAT THE MILEAGE IS ON THE CAR. *TR UPDATED 08/04/11 *BF

2003 VOLVO S60 PASSENGER FRONT DOOR HANDLE DOES NOT OPEN FROM INSIDE. OPENS FROM OUTSIDE FINE. *TR

THE INSIDE DOOR HANDLES ON MY VEHICLE BROKE. I WAS ABLE TO GET A NEW HANDLE ASSEMBLY FOR THE PASSENGER SIDE, BUT THE MANUFACTURER HAS NOT BEEN ABLE TO PROVIDE A NEW HANDLE ASSEMBLY FOR THE DRIVER'S SIDE DOOR. THE DOOR CANNOT BE OPENED FROM INSIDE THE VEHICLE. I'VE WAITED TWO MONTHS, BUT APPARENTLY THE NEW PART IS NOT AVAILABLE. *TR

MY 2003 VOLVO S60 HAS A SEATBELT WARNING MESSAGE. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY DRIVER INFORMATION MODULE WHICH WOULD COST 1400 PLUS TAX TO REPAIR. THE CAR IS VALUED AT APPROXIMATELY 4000 AS A TRADE. THERE ARE MANY COMPLAINTS OF FAILURE OF THIS PART EVEN IN MUCH NEWER VOLVOS. *TR

I HAD A SIMILAR ISSUE ABOUT TWO YEARS AGO AND REPLACED THE CATALYTIC CONVERTER. JUST TODAY (9/25/10), MY 2003 VOLVO S60 BEGAN TO IRREGULARLY STALL WHILE DRIVING. WHILE I'M SLOWING DOWN, IT DOWNSHIFTS BY IT SELF, AND JUST DIES, AND WHILE I'M SLOWING DOWN, THE WARNING INDICATORS ON THE DASH ARE NOT LIT, AS IF NOTHING IS WRONG, BUT WHEN COME TO A COMPLETE STOP ALL THE LIGHTS ON THE DASH ARE LIT. THE CHECK ENGINE LIGHT THEN COMES ON, IT WASN'T ON BEFORE THIS HAPPENED. THIS CAN BE VERY DANGEROUS WHEN YOU ARE SLOWING DOWN TO TURN AT AN INTERSECTION. THE CAR STALL, YOU HAVE NO POWER STEERING AND YOU ARE DEAD IN THE MIDDLE OF TRAFFIC. THIS HAPPENED NO LESS THAN 10 TIME WHILE I WAS DRIVING TODAY. *TR

I HAVE A 2003 S60 VOLVO. WHILE DRIVING 55 MPH THE CAR WOULD GO INTO LIMP MODE AND THE SPEED WOULD QUICKLY DROP TO 10 MPH AND THE MESSAGE REDUCED ENGINE PERFORMANCE WOULD BE DISPLAYED. THE CAR WILL NOT ACCELERATE PAST THAT SPEED. THIS IS VERY SERIOUS SAFETY CONCERN BECAUSE THE QUICK DROP IN SPEED MAY LEAD TO AN ACCIDENT. I TOOK THE CAR TO A VOLVO DEALERSHIP AND WAS INFORMED THE CAR NEEDS THE ELECTRONIC THROTTLE SYSTEM REPLACED. THIS WAS A COMMON PROBLEM WITH OLDER MODELS AND A RECALL WAS ISSUED AFTER A CLASS ACTION LAWSUIT. MY MODEL IS NOT INCLUDED IN THIS RECALL, HOWEVER; IT IS EXHIBITING THE EXACT SAME PROBLEM THAT USUALLY OCCURS WHEN THE CAR REACHES 100,000 MILES. *TR

FRONT PASSENGER SIDE DOOR, WILL NOT OPEN FROM THE INSIDE AND WINDOW WILL NOT ROLL DOWN. WINDOW LOCKED IN PLACE AND THE MOTOR STRUGGLES IN ITS ATTEMPT TO ROLL IT DOWN. ALONG WITH THIS A WEEK LATER MY SUN ROOF DECIDED NOT TO OPEN, IN AN ATTEMPT TO OPEN THE SUN ROOF- ALL YOU HEAR IS A LOUD CLICKING SOUND. EVEN THEN IT BARELY CRACKS OPEN. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY REPLACED THE ELECTRONIC THROTTLE ASSEMBLY AT THE CONTACTS EXPENSE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

2003 VOLVO S60 EXPERIENCED "DEATH" OF DRIVER INFORMATION MODULE (DIM), WHICH MONITORS ALL GAUGES ON THE VEHICLE. DEALERSHIP IS ABLE TO REPLACE THE PART FOR $1500! IT NOT AVAILABLE "AFTER MARKET" BY ANOTHER MANUFACTURER. RESEARCH ONLINE SHOWS THIS IS A VERY COMMON PROBLEM AMONG 2001-2003 MODELS. THIS MAJOR SAFETY CONCERN SHOULD BE INVESTIGATED, AS NUMEROUS PEOPLE ARE DRIVING WITHOUT DASH PANEL INFORMATION DUE TO THE EXORBITANT COST. THE PROBLEM BEGAN APPROXIMATELY TWO WEEKS AGO AND CANNOT BE REMEDIED WITHOUT BUYING THE DIM. *TR

THE PASSENGER SIDE FRONT DOOR WILL NOT OPEN FROM THE INSIDE. THE CAR WAS BROUGHT TO GARDEN STATE VOLVO IN WALL, NJ IN MARCH FOR THIS TO BE FIXED. THE MECHANIC "FIXED" THE INSIDE CABLE WITH DUCT TAPE AND CHARGED US $175 FOR THE REPAIR. WITHIN A WEEK THE DOOR WAS BROKEN AGAIN. I CALLED GARDEN STATE VOLVO AND ASKED FOR THE PART TO REPAIR THIS PROBLEM TO BE ORDERED. I HAVE CALLED SEVERAL TIMES AND I HAVE BEEN TOLD THAT THE PART IS BACK-ORDERED AND IS COMING FROM SWEDEN. THIS IS A VERY DANGEROUS SITUATION, IN CASE OF AN ACCIDENT THE DRIVER CAN NOT GET OUT. *TR

2003 VOLVO S60 SEDAN. CONSUMER STATES RECEIPT OF LETTER FROM VOLVO REGARDING EXTENDED WARRANTY NOTICE INFORMING HER THAT THE VEHICLE HAS BEEN FITTED WITH A FAULTY FUEL PUMP *TGW THE CONSUMER STATED INSTEAD OF A RECALL, VOLVO SUGGESTED THAT THE CONSUMER ONLY TAKE THE VEHICLE IN FOR REPAIRS IF SHE SMELLED GAS OR HAD A GAS LEAK. THE CONSUMER STATED VOLVO WAS WILLING TO PUT HER LIFE AT RISK RATHER THAN FIXING THE PROBLEM UP FRONT. *JB

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHEN THE CONTACT ATTEMPTED TO EXIT A PARKING SPACE THE VEHICLE SUDDENLY SURGED FORWARD WITHOUT WARNING. AFTER EXAMINING THE VEHICLE THE CONTACT NOTICED THAT THE DRIVER SIDE FLOOR MAT BECAME STUCK UNDER THE ACCELERATOR PEDAL. THERE WERE NO PRIOR WARNINGS AND THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

BRAKE BOOSTER STARTS LEAKING AIR FROM VACUUM PRESSURE. READ ONLINE THAT THIS IS QUITE OFTEN FROM OTHER VOLVO OWNERS AROUND THE TIME WHEN THE MILEAGE GETS TO BETWEEN 95,000 AND 100,000. REDUCED BRAKING POWER AS A RESULT OF DEFECT. *TW

WE TO HAVE A 2003 S60 WITH A VERY BAD FUEL SMELL. WE BOUGHT IT USED IN 2006 FROM A VOLVO DEALER IN CARY, NC. OF COURSE, WHEN I CALLED VOLVO AND GAVE THEM THE VIN #, THEY SAID THAT WE WERE NOT COVERED. OUR CERTIFIED PRE OWNED STATUS EXPIRED IN FEB. OF THIS YEAR. I REALLY DON'T WANT TO SPEND $700+ TO GET SOMETHING FIXED THAT HAS BEEN A RECURRING PROBLEM FOR VOLVO. *TR

AT APPROXIMATELY 85,000 MILES ON MY 2003 VOLVO S60, THE PASSENGER FRONT DOOR FAILED TO OPEN. THE DEALER SAID A PLASTIC PART HAD BROKEN INSIDE THE DOOR PANEL AND TO CORRECTLY FIX, IT WOULD BE $845 AND THAT THE ENTIRE DOOR PANEL WOULD NEED TO BE REPLACED. THEY THEN SAID THAT IF WE WANTED TO ACCEPT THE RISK, THEY COULD GO IN AND GLUE THE PIECE AND TIE IT FOR $162. VOLVO SAID THEY WOULDN'T BE RESPONSIBLE ALTHOUGH THE PART FAILURE TRAPS A PERSON IN THE CAR NOT ALLOWING THE PASSENGER TO OPEN THEIR DOOR FROM WITHIN. I WENT WITH THE RISKY $162 OPTION AND IT FAILED TO WORK A MONTH LATER. THE FRONT PASSENGER DOOR IS INOPERABLE FROM THE INSIDE OF THE CAR. IT WILL OPEN FROM THE LATCH ON THE OUTSIDE OF THE CAR. *TR

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING LOW SPEEDS, THE VEHICLE WOULD ACCELERATE ABNORMALLY. THE CONTACT EXPERIENCED DIFFICULTY ACCELERATING AS IF THE VEHICLE WERE IN LIMP MODE. IN ADDITION, THE VEHICLE STALLS WITHOUT WARNING. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THEY COULD NOT DUPLICATE THE FAILURE AND PROVIDE A REMEDY. THE 2003 S60 WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06V441000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 74,000.

WHILE OPERATING THE VEHICLE A LOUD "BANG" WAS HEARD FROM THE REAR OF THE VEHICLE CAUSING A MOMENTARY MOVING DISTURBANCE (SHIMMY). UPON STOPPING THE VEHICLE TO INSPECT, I NOTICED THERE WAS NO LONGER ANY TENSION ON THE PARKING BRAKE. CONTINUING TO DRIVE INDICATED THAT THE BRAKE WAS SEIZED ON ONE WHEEL AND LOOSE/RATTLING PARTS FROM SOMEWHERE NEAR THE REAR WHEEL. FURTHER INVESTIGATION HAS SO FAR REVEALED THAT THIS MAY NOT BE AN UNCOMMON PROBLEM FOR S60 VOLVOS WITH REPEATED COMPLAINTS APPEARING ON ENTHUSIASTS SITES INCLUDING INCIDENTS OF BOTH REAR WHEELS SEIZING WHILE THE VEHICLE IS IN OPERATION. CONSULTATION WITH THE TWO NEAREST VOLVO DEALERSHIPS INDICATES NO ACKNOWLEDGMENT FROM VOLVO OF THE DEFECT. IT APPEARS THE PROBLEM MAY BE WITH THE INTERNAL PARTS ASSOCIATED WITH THE RETURN MECHANISMS IN THE PARKING BRAKE ASSEMBLY. AS THIS IS POTENTIALLY A SERIOUS SAFETY ITEM I BELIEVE IT WOULD BE BENEFICIAL TO HAVE THE NHTSA REVIEW THIS PROBLEM AS MANY S60 VOLVOS WILL HAVE REACHED SIMILAR SERVICE LIVES. *TR

ON 12 DEC, 2008, MY 2003 VOLVO S60 STALLED WITH NO WARNING WHILE TRAVELING ON A BUSY HIGHWAY AT 60 MPH. I PULLED TO SAFETY (VEHICLE WAS IN "LIMP HOME" MODE) AND HAD THE VEHICLE TOWED TO THE DEALERSHIP (PARK PLACE VOLVO). SINCE THE VEHICLE STARTED RIGHT BACK UP AND PRESENTED NO CODES, I WAS TOLD THERE WAS NOTHING WRONG AND GIVEN A BILL FOR $418 (FOR TOW AND DIAGNOSTIC CHECK). APPROX. 1 MONTH LATER, VEHICLE PRESENTED SAME PROBLEM; IT STALLED, WITHOUT WARNING, WHILE DRIVING... CREATING A GREAT SAFETY RISK FOR THE SECOND TIME. I HAD VEHICLE TOWED AGAIN TO SAME DEALERSHIP, AND SINCE VEHICLE STARTED RIGHT BACK UP WITH NO CODES, I WAS TOLD THERE WAS NOTHING WRONG. DEALERSHIP COULD NOT GET VEHICLE TO DUPLICATE PROBLEM ON EITHER OCCASION. HOWEVER, TO APPEASE ME, DEALERSHIP DID REPLACE ACCELERATOR PEDAL...VEHICLE STILL PRESENTS SAME STALLING ISSUE, AND INTERMITTENTLY GOES INTO "LIMP HOME" MODE FOR NO APPARENT REASON. THIS WILL UNDOUBTEDLY CAUSE A SERIOUS ACCIDENT, AS IT IS OBVIOUS, FROM THE NUMEROUS COMPLAINTS ON THIS ISSUE, THAT THIS IS A MASS DEFECT. *TR

THE SEAT BELT CAN NOT BE PULLED OUT AND THEREFORE DOES NOT WORK. *TR

THE TURN SIGNAL LEVER BROKE WITHOUT MUCH FORCE BEING PLACED ON IT. THE PLASTIC USED TO CONSTRUCT IT MAY NOT HAVE BEEN OF GOOD QUALITY. THE PART ITSELF IS COSTING ME $100 FOR THE LEVER AND ANOTHER $100 FOR LABOR. THIS SHOULD NOT BE AN ISSUE WITH CARS. I'VE NEVER HAD ANYTHING LIKE THAT HAPPEN TO ME BEFORE. THE TURN SIGNAL LEVER HAS A STEEL REINFORCEMENT BAR GOING UP PART OF IT. WHERE THE BAR STOPS IS WHERE THE PIECE BROKE OFF. IT DIDN'T EVEN SNAP. THE PLASTIC JUST SORT OF PEELED AWAY. NOT WHAT I EXPECT OUT OF ANY CAR, ESPECIALLY A VOLVO. *TR

THE OEM JACK THAT CAME WITH MY VOLVO FAILED MISERABLY WHEN I HAD A FLAT TIRE. THE JACK WAS NEVER USED BEFORE THIS INCIDENT. WHILE THE JACK WAS PLACED ON A LEVEL SURFACE AND WAS COMPLETELY VERTICAL, THE FORCE NECESSARY TO SPIN THE JACK HANDLE CAUSED THE JACK TO VERY SLOWLY SLIDE SIDEWAYS IN AN INCREASINGLY PRECARIOUS POSITION. I STOPPED AND STARTED OVER SEVERAL TIMES ONLY TO RENDER THE SAME RESULT. AFTER SEVERAL ATTEMPTS, I WAS ABLE RAISE THE CAR HIGH ENOUGH TO ATTEMPT REMOVAL OF THE FLAT TIRE. THE JACK HOWEVER WAS VERY UNSTABLE. WHILE ATTEMPTING TO REMOVE THE TIRE, THE JACK FAILED AND THE CAR FELL TO THE GROUND. LUCKILY, THE FLAT TIRE WAS STILL ON THE CAR. SINCE I WAS IN MY PAVED DRIVEWAY, I WAS ABLE TO USE ANOTHER JACK. SINCE IT WASN'T A VOLVO JACK, I WAS ABLE TO USE WOODEN BLOCKS TO CRIB OR SECURE THE CAR BY STACKING WOOD UNDER THE CAR AS THE JACK RAISED THE CAR SO IT WOULDN'T FALL OFF THE JACK. THE VOLVO JACK IS BENT AND UNSAFE TO USE AGAIN, EVEN THOUGH IT WASN'T SAFE TO USE THE FIRST TIME. I AM REPORTING IT AS I HAVE FOUND MANY OTHER VOLVO OWNERS ON THE WEB WHO HAD THE SAME EXPERIENCE WITH THEIR VOLVOS. *TR

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING 35 MPH, THE ENTIRE VEHICLE BEGAN TO SHAKE, THE SERVICE ENGINE LIGHT ILLUMINATED, AND THE VEHICLE SHUT OFF. THE WEATHER CONDITIONS WERE RAINY AT THE TIME OF FAILURE. THE FAILURE OCCURRED IN THE MIDDLE OF THE ROAD. THE CONTACT PULLED OFF THE HIGHWAY AND THE VEHICLE RESTARTED AFTER 2-3 MINUTES. THE DEALER REPLACED THE FUEL PRESSURE SENSOR, BUT THE FAILURE PERSISTS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 63,000.

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING 10 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE HAS OCCURRED ON THREE OCCASIONS AND THE MECHANIC HAS BEEN UNABLE TO DIAGNOSE THE FAILURE EACH TIME. THE MANUFACTURER STATED THAT HER VIN WAS NOT INCLUDED IN RECALL NUMBER 07V226000 (ENGINE AND ENGINE COOLING). THE CURRENT MILEAGE WAS 60,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 02-01-08 *BF UPDATED 02/01/08 *TR

I OWN A VOLVO S60 AND IT HAS STALLED THREE TIMES IN THE LAST TWO WEEKS, I TOOK IT IN TO BE LOOKED AT AND THEY FOUND NOTHING WRONG WITH THE ENGINE TO FIX MY PROBLEM. *JB

THE CAR STALLED REPEATEDLY WHILE THE ENGINE WAS IDLING. ALL POWER WAS LOST MAKING THE CAR VERY DIFFICULT TO STEER AND BRAKE. I NEARLY GOT INTO SEVERAL ACCIDENTS THE ENGINE STALLED WHILE: 1) STOPPED AT A RED LIGHT 2) WHILE SHIFTING GEARS ON THE HIGHWAY 3) WHILE SHIFTING GEARS IN HEAVY TRAFFIC I TOOK THE CAR TO THE DEALERSHIP 4 TIMES BEFORE THE PROBLEM CORRECTLY FIXED. THE FOLLOWING ITEMS WERE REPLACED BUT DID NOT FIX THE PROBLEM: 1) FUEL PUMP 2) MAP SENSOR (REPLACED 2 TIMES) NEITHER OF THESE FIXES WORKED. THE PROBLEM WAS CORRECTED AFTER MODIFYING THE SOFTWARE ON THE COMPUTER BOARD. *JB

THE VEHICLE IS A 2003 VOLVO MODEL S-60 T-5, PURCHASED MAY 6, 2006. AT THE TIME OF PURCHASE, THE VEHICLE WAS UNDER THE WARRANTY OF 50,000 MILES AND WAS SERVICED FOR WARRANTY ITEMS BY RICKENBAUGH VOLVO. THE VEHICLE CURRENTLY HAS 60,500 MILES. UPON USING THE SEAT WARMERS FOR THE FIRST TIME DECEMBER 27, 2006, A SMALL HOLE BURNED IN THE DRIVER'S SEAT FROM THE SEAT HEATING ELEMENT. SMOKE WAS COMING OUT OF THE HOLE WHEN I DISCOVERED THE ISSUE AND I IMMEDIATELY TURNED OFF THE SEAT WARMER. I TOOK THE VEHICLE IMMEDIATELY (DECEMBER 27, 2006) TO VOLVO PARTS, INC. FOR INSPECTION. THERE IS A SHORT IN THE HEATING ELEMENT THAT MAKES THIS VEHICLE UNSAFE TO DRIVE. I CALLED THE VOLVO CORPORATION CUSTOMER SERVICE THAT SAME DAY AND WAS TOLD THAT THE VEHICLE WOULD NOT BE REPAIRED BY THE VOLVO CORPORATION BECAUSE IT WAS NO LONGER UNDER WARRANTY. I PHONED RICKENBAUGH VOLVO THAT SAME DAY AND WAS TOLD THE HEATING ELEMENT AND PAD WOULD NEED TO BE REPLACED AT A COST OF APPROXIMATELY $630.00. I AM CONCERNED THAT THE HEATING ELEMENT WAS IMPROPERLY INSTALLED CAUSING A SHORT, OR THE ELEMENT IS DEFECTIVE. IN ANY CASE, THE PRODUCT WAS DEFECTIVE WHEN IT WAS STILL UNDER A WARRANTY OR IMPROPERLY INSTALLED AT THE TIME OF MANUFACTURE, BUT INSTEAD OF ADDRESSING THE SAFETY ISSUE, THE VOLVO CORPORATION IS FOLLOWING ITS STANDARD PROCEDURE OF HIDING BEHIND ITS WARRANTY TERMS. THIS IS WHAT CONCERNS ME THE MOST. THERE WAS NO INJURY TO A PERSON, HOWEVER, THE LEATHER SEAT NOW HAS A HOLE FROM THE SMALL FIRE CAUSED BY THE HE

WHILE DRIVING ON I-290 THE ENGINE OF MY 2003 VOLVO S60 SUDDENLY LOST ALL POWER. I NARROWLY ESCAPED SEVERAL SERIOUS ACCIDENTS ON A BUSY CHICAGO HIGHWAY. WHEN THE CAR LOSES POWER THERE IS ABSOLUTELY NOTHING THE OPERATOR CAN DO TO MOVE OVER TO THE SIDE. I WAS DRIVING APPROX. 60 MPH WHEN THIS HAPPENED. THE VEHICLE COMPLETELY STALLED, AND I WAS ABLE TO RESTART THE VEHICLE AFTER APPROX. 30-60 SECONDS. THE PROBLEMS EXHIBITED BY THE CAR ARE EXACTLY THE SAME AS THE RECENT RECALL THAT VOLVO HAS ANNOUNCED FOR VOLVO VEHICLES. MY CAR IS NOT INCLUDED IN THIS RECALL. THE CAR IS NOW STALLING RANDOMLY AT LOWER SPEEDS. *NM

I HAVE A 2003 VOLVO S 60 THAT HAS BEGUN STALLING OUT WHILE DRIVING. I BELIEVE THAT THIS IS SIMILAR TO OTHER CAR PROBLEMS THAT HAVE BEEN REPORTED RECENTLY. THE CAR DIES AFTER IT HAS REACHED OPERATING TEMPERATURES. IT JUST STOPS ON THE INTERSTATE OR AT A STOP LIGHT, IN INTERSECTIONS, ETC. IT TAKES BETWEEN 10 AND 30 SECONDS BEFORE IT CAN BE RESTARTED. MY CONCERN IS THAT THIS COULD BE AN RECURRING UNREPORTED PROBLEM WITH THIS VEHICLE. *NM

THE TRANSMISSION OF MY S60 INADVERTENTLY MIS-SHIFTS AT A VARIETY OF SPEEDS. THE PROBLEM HAPPENS AT LOW SPEEDS WHEN BACKING OFF BETWEEN GEARS AND FEELS LIKE IT UP SHIFTS AT AN INAPPROPRIATE TIME AND SPEEDS UP. OTHER TIMES THE TRANSMISSION WILL MIS-SHIFT UPON ACCELERATION CAUSING HIGH REVS, WITH NO POWER. TALKED WITH VOLVO SEVERAL TIMES AND FIRST SERVICE VISIT PAID $100 FOR A SOFTWARE UPGRADE THAT DID NOTHING. NEXT TIME TO SERVICE THEY CHECKED THE SERVOS AND STATED THEY WERE OK. LAST TRIP TO SERVICE ADDRESSED ISSUE W/ SERVICE REP AND REQUESTED TO HAVE IT DOCUMENTED. SERVICE REP STATED CAR HAD A 100K GUARANTEE DISMISSED REQUEST. CAR HAS 80K ON IT AND PROBLEM SEEMS TO BE INCREASING. AFRAID IT IS A SAFETY ISSUE DUE TO LACK OF CONTROL. *JB

MY 03 VOLVO STALLS AT HIGHWAY SPEEDS RESULTING IN A LOSS OF POWER STEERING. THIS HAPPENS SEVERAL TIMES PER TRIP, POSING A VERY VERY DANGEROUS SITUATION. THE VEHICLE STALLS WHEN LETTING OFF THE GAS PEDAL AND OCCASIONALLY WHEN COMING TO A STOP. *NM

ON 12/22 I WAS DRIVING MY 2003 VOLVO S 60 AWD. I WAS VERY SLOWLY AND CAREFULLY PULLING INTO A FRONT IN PARKING SPOT. I WAS PARTICULARLY CAREFUL BECAUSE THERE WAS A DRIVER SITTING IN THE CAR PARKED TO MY RIGHT, AND I DID NOT WANT TO GET TOO CLOSE TO HIS CAR. WITH MY FOOT ON THE BRAKE I WAS SLOWLY MOVING INTO THE SPOT. MY FRONT FENDER TAPPED THE SHORT CONCRETE BARRIER AT THE FRONT OF THE PARKING SPOT. THE NEXT THING I NEW, THE CAR WAS RAPIDLY ACCELERATING FORWARD. I WAS WORRIED THAT I WOULD GO OVER THE BARRIER AND STRIKE A BRICK WALL IN FRONT OF ME. I BELIEVE THAT THE ENGINE BLOCK MUST HAVE HIT THE SHORT CONCRETE BARRIER AND THAT IS WHAT ULTIMATELY STOPPED THE CAR. DESPITE THE FACT THAT I WAS INCHING INTO THE SPOT AT THE SLOWEST POSSIBLE SPEED. THE FORCE OF THE ACCELERATION WAS ENOUGH TO CRUMPLE THE WHOLE FRONT OF MY CAR, CRACK THE WINDSHIELD, AND CAUSE THE PASSENGER FRONT AIR BAG TO RELEASE. I FEEL VERY CERTAIN THAT THIS REPRESENTED UNINTENDED ACCELERATION. I DO NOT THINK THERE WAS ANY CHANCE THAT I STEPPED ON THE GAS INSTEAD OF THE BRAKE. I AM A VERY CAREFUL, CAUTIOUS DRIVER, AND WAS VERY AWARE OF WHAT I WAS DOING AT THE TIME WITHOUT ANY DISTRACTIONS. I REPORTED THIS TO VOLVO CUSTOMER SERVICE, WHO CLAIMS THAT AFTER INSPECTING THE CAR, THEY FOUND NO SAFETY CONCERNS. I AM CONCERNED THAT HAVING VOLVO DO THEIR OWN INSPECTION REPRESENTS A CONFLICT OF INTEREST. *NM

HAD PROBLEMS WITH CAR STALLING AT SLOW SPEEDS, BUT ALL OF A SUDDEN WHILE DRIVING ON A MAJOR HIGHWAY AT 65 MPH AND CAR LOST POWER. WE WERE ABLE TO GLIDE TO SHOULDER WHERE CAR STALLED. IT RESTARTED IMMEDIATELY, BUT ABOUT EVERY 5 MI. THE CAR WOULD STALL AGAIN. THE SERVICE DEPT. AT STAMFORD VOLVO TOLD ME I HAD BAD GAS AND THEY REPLACE A SENOR IN THE FUEL SYSTEM. AS SOON AS I LEFT THE DEALERSHIP AND GOT ON THE HIGHWAY THE CAR STALLED AGAIN. I BROUGHT IT BACK TO THE DEALER. THEY SERVICED THE CAR AGAIN AND TOLD ME THE WATER IN THE GAS RUSTED SOME SCREEN IN THE FUEL SYSTEM. THEY REPLACED IT AND THUS FAR THE CAR HASN'T' STALLED BUT THERE IS STILL SOME HESITATION WHILE DRIVING AT HIGH SPEEDS. *NM

RECENTLY WHILE DRIVING AT SPEEDS AROUND 40 MPH MY CAR EXPERIENCED A LOSS OF SPEED AND THEN STALLED. EACH EXPERIENCE HAS BEEN PRECEDED BY A BRIEF LOSS AND THEN BY A MORE PROLONGED LOSS AND FINALLY A COMPLETE ENGINE FAILURE WHICH LOCKS UP STEERING. IN EACH INSTANCE THE CAR HAS RESTARTED. THE MECHANIC SAID IT WAS MOST LIKELY A FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM). STEPS ARE CURRENTLY BEING TAKEN TO REPLACE THE ETM. *NM

DT: 2003 VOLVO S60. VEHICLE STALLED/LOST POWER DUE TO THROTTLE BODY FAILURE. *AK THE VEHICLE STALLED A TOTAL OF SIX TIMES WHILE THE CONSUMER WAS ON A ROAD TRIP. THE VEHICLE WAS TAKEN TO A REPAIR FACILITY BUT THEY DIDN'T HAVE THE PART TO REPAIR THE PROBLEM. *NM

DT: 2003 VOLVO S60. VEHICLE STALLED AT LEAST 6 OR 7 TIMES AT VARIOUS SPEEDS. TRANSMISSION WAS REPLACED DUE TO STALLING. *AK

DT: THE CONTACT S BROUGHT CAR TO DEALER 3 TIMES BECAUSE IT WILL NOT START AFTER SITTING FOR AWHILE. . SHE OWNS A 2003 VOLVO MODEL S60 2.4T. THE FIRST TIME IT HAPPENED WAS ON 8-12-05. THE LAST TIME IT HAPPENED ON 8-27-05. ONCE IT TOOK OVER AN HOUR FOR IT TO START UP. EVERY TIME SHE FIXED IT, THE PROBLEM RECURRED. IT WILL INTERMITTENTLY NOT START. SHE WAS THE ORIGINAL OWNER. SHE DID NOT THINK SHE HAD THE ELECTRONIC THROTTLE MODULE (ETM) REPLACED. VEHICLE HAS NOT STALLED WHILE SHE WAS DRIVING, BUT AT TIMES IT SURGED FORWARD. *AK

DT: THE CONSUMER STATES THAT 2003 VOLVO S60 HAS AN INABILITY TO STOP IN REVERSE . THE BRAKES FAILED AND THE CAR ACCELERATED IN REVERSE. THIS OCCURRED AFTER THE CAR STARTED AND SPUTTERED. THE CONSUMER TOOK THE CAR TO THE DEALER, AND THEY SAID IT WAS A SOFTWARE PROBLEM, THE SOFTWARE WAS UPDATED. BUT THE CAR WAS STILL DOING THIS. THE CONSUMER HAS NOT CALLED THE MANUFACTURER. THE SOFTWARE WAS THE ONLY THING MENTIONED AS BEING THE PROBLEM WITH THE CAR. THE CAR HAS BEEN DOING THIS FOR ABOUT 2 YEARS. LATELY, THE CAR HAS BEEN DOING THIS MORE FREQUENTLY. *AK

BETWEEN 12/2004-6/2005 MY 2003 VOLVO S60 LOST POWER/ POWER DECREASES AT VARYING SPEEDS. THE MOST SIGNIFICANT WAS ON THE HWY GOING 65 MPH. I HAD JUST ACCELERATED TO GET ONTO THE HWY IN FRONT OF A SEMI TRUCK. MY CAR REACHED 65-70 MPH AND BEGAN TO DROP SPEEDS - 65 TO 55 TO 50 TO 40 WITH IN SECONDS. THE SEMI ALMOST RAN OVER ME BECAUSE THE SPEEDS DROPPED SO FAST. I CAUSED 2 OTHER CARS ON THE HWY TO GO ONTO THE SIDE RAMP OTHERWISE IT WOULD HAVE BEEN A HORRIBLE CRASH WITH THE SEMI. I HAVE TAKEN THE VEHICLE TO THE DEALER 3 TIMES COMPLAINING OF THE SAME PROBLEM. THE FINAL TIME STATING NOT TO GIVE THE CAR BACK UNTIL IT WAS FIXED. THE DEALER SAID THEY DOWNLOADED NEW SOFTWARE TO THE CAR? IF IT HAPPENS AGAIN THEY CAN INSTALL A BLACK BOX TO RECORD WHAT IS GOING ON. WHAT IF THE NEXT TIME THE SEMI DOES CRASH INTO ME? THE FIRST TIME THEY HAD THE CAR THE LABELED AS PEDAL POSITION SENSOR INSTALL/REPLACE? THE SECOND TIME THE INVOICE READS PRESSURE SENSOR INTAKE AIR REPLACED? ULTIMATELY, I SAW THE REPORT IN THE NEWS AND RECOGNIZED THE ISSUE TO EXACTLY WHAT HAPPENS TO MY CAR. I NOTICED THAT YOU DID NOT INCLUDE 2003 S60'S IN YOUR REPORT. I KNOW THESE SHOULD BE LOOKED AT AS WELL. I LOVE MY VOLVO I JUST DON'T FEEL VERY SAFE IN IT. PLEASE CONTACT ME FOR ANY QUESTIONS. *NM

I WAS TRAVELING ON I-65 FROM LOUISVILLE, KY TO CHICAGO, ILLINOIS AND ENCOUNTERED SUDDEN LOSS OF POWER AFTER DRIVING 205 MILES AT STEADY FREEWAY SPEEDS. THE CAR (VOLVO S60, 2003 MODEL) SUDDENLY LOST POWER AND SPEED FROM 70 MPH. I PULLED OVER TO THE SHOULDER AT A SPEED OF 40 MPH AND TURNED OFF THE ENGINE. I WAITED 10 MINUTES AND THEN STARTED THE ENGINE AND REENTERED THE HIGHWAY AND WAS ABLE TO ACCELERATE TO 70 MPH. AFTER ABOUT 3-5 MINUTES THE SAME LOSS OF POWER OCCURRED AND THE ENGINE TURNED OFF AND THE OIL LIGHT REMAINED ON. I ONCE AGAIN PULLED OFF TO THE SHOULDER, TURNED OFF THE VEHICLE AND CALLED FOR TOW ASSISTANCE. THE CAR WAS TOWED TO A VOLVO DEALER IN , INDIANA (NAPLETON AUTO) AND LEFT FOR 24 HRS. DEALER REPORTED NO DIAGNOSTIC EVIDENCE OF PROBLEM AND WAS UNABLE TO REPLICATE THE PROBLEM ON NON-HIGHWAY DRIVE TESTS. I SUBSEQUENTLY DROVE THE CAR ON A RETURN TRIP TO LOUISVILLE, KY ( 350 MI.) BUT WITH SEVERAL STOPS ALONG THE WAY TO REST THE ENGINE. THIS LOSS OF POWER CREATED A VERY SERIOUS SAFETY RISK. WHEN THE LOSS OF POWER OCCURRED I HAD A FAST MOVING TRUCK BEHIND ME AND AVOIDED AN ACCIDENT BY QUICKLY MOVING TO THE SHOULDER. I WAS VERY DISTRESSED BY THIS EXPERIENCE. *NM

DT: CONTACT STATDS 2003 VOLVO CUT OFF WHILEGOING 60 MPH. CAR COMPLETELY LOST POWER IN THE MIDDLE LANE. IT WAS TOWED ,AND THEY KEPT IT FOR 3 DAYS. CONSUMER PICKED IT UP ON 7-16-05. THE DEALER REPLACED THE BATTERY. NINE DAYS LATER ON 7-24-05 THE CAR COMPLETELY QUIT AGAIN. THEY CALLED HECONSUME R AT HOME AND TOLD HER THEY THOUGHT IT WAS A FUEL PRESSURE ISSUE. HER CAR HAS BEEN IN THE SHOP 2 TIMES PREVIOUSLY FOR HESITATION AND DELAYS, AND THEY KEPT TELLING HER IT WAS CHIP RELATED .THE LAST TWO INCIDENTS OCCURRED AT RELATIVE HIGHER SPEEDS THAN THE FIRST TIME. CAR HAS BEEN IN THE SHOP FOR ONE WEEK, AND SHE DID HEAR FROM THE SERVICE DEALERSHIP LAST NIGHT. HE TOLD HER HE THOUGHT IT WAS A FUEL PRESSURE ISSUE AND HE WAS GOING TO CALL IN A SPECIALIST. *AK