1993 Volvo 940

Defect. PLASTIC HOOD INSULATION CLIP(S) WAS(WERE) INADVERTENTLY DROPPED INTO THE HOSE BETWEEN THE CHARGE AIR COOLER AND THE THROTTLE HOUSING WHICH CAN INTERFERE WITH THE THROTTLE OPERATION.

Risk. IF A PLASTIC CLIP MOVES TOWARD THE THROTTLE HOUSING ITCAN BECOME LODGED THERE AND PREVENT THE THROTTLE FROM RETURNING TO IDLE. LOSS OFTHROTTLE CONTROL CAN RESULT IN AN ACCIDENT.

Remedy. CHECK FOR INSULATION CLIPS IN THE HOSE BETWEEN THE CHARGE AIR COOLER AND THE THROTTLE HOUSING, AND REMOVE IF FOUND.

TL*THE CONTACT OWNS A 1993 VOLVO 940. THE VEHICLE HAS DUNLOP TIRES, SIZE P205/60R15. THE CONTACT STATED THAT THE VALVE STEMS ON THREE OUT OF THE FOUR TIRES WERE BAD AND CAUSED THE TIRES TO FLATTEN. HE STATED THAT THE TIRES HAD ONLY BEEN ON THE ROAD FOR SIX MONTHS, WHEN DURING THE COURSE OF ONE WEEK, THE VALVE STEM FAILED ON THREE DIFFERENT TIRES. THE TIRES WERE REPLACED AT THE MANUFACTURER'S EXPENSE. THE CONTACT WAS UNCERTAIN OF THE DOT NUMBER (P072ARO OR CR54606-2). THE VIN, PURCHASE DATE, ENGINE SIZE, AND SPEED WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 128,000.

IN JANUARY 2002 WE PURCHASED A SET OF 4 DUNLOP WINTER SPORT M2 SNOW TIRES 205/55R16 FOR A VOLVO 940 TURBO SEDAN. WE HAVE HAD 3 SIDEWALL FAILURES OF THESE SNOW TIRES RUNNING ONLY 5700 MILES, WITH 2 ACTIVE BLOWOUTS & 1 LARGE SIDEWALL BLISTER. TIRES WERE USED ONLY IN WINTER. THERE IS HARDLY ANY WEAR ON THE TREADS. THE FIRST TIRE FAILED 13APR02 AT 3000 MI (DOT CODE 3400), ITS REPLACEMENT 12JAN04 AFTER 500 MI (DOT CODE 3702), & THE LATEST FAILED 1DEC05 AT 5700 MILES (DOT CODE 3400).. A DUNLOP-GOODYEAR INSPECTOR @ CONDUIT TIRE, BROOKLYN, STATED THIS WAS SIMPLY ROAD HAZARD DAMAGE, WHICH WAS NOT COVERED WITHOUT AN EXTENDED WARRANTY. HE REFUSED ANY DAMAGE RESPONSIBILITY. HE ALSO STATED HE DISLIKES ALL SNOW TIRES & REFUSES TO SELL ANY. A WARRANTY WOULD DO US LITTLE GOOD, AS IT EXPIRES AFTER 3 YEARS, REGARDLESS OF HOW LITTLE USE THE TIRES GOT.. WE DRIVE IN THE NY CITY METRO AREA, A HOME TO POTHOLES. HOWEVER, OVER 35 YEARS OF DRIVING ON THESE SAME ROADS, WE HAVE WORN THROUGH MANY SUMMER & SNOW TIRES, WITH NO SIDEWALL FAILURES, EXCEPT FOR THESE DUNLOP WINTER SPORT M2 TIRES. PREVIOUSLY WE DROVE KLABEAR & BLIZZARD SNOW TIRES WITH NO PROBLEMS, & WE HAVE BEEN VERY PLEASED WITH VARIOUS DUNLOP SPORT SUMMER/ALL WEATHER TIRES THAT PROVIDED EXCELLENT RIDE & WEAR WITH NO FAILURES. OUR SUMMER TIRES ARE DUNLOP SP SPORT 5000 205/55WR16, WITH 3 TIMES THE MILES USED AS THE SNOW TIRES, ON THE SAME ROADS, SAME CAR.. THERE IS NO REASON WHY 3 WINTER SPORT TIRES SHOULD FAIL AFTER A VERY SHORT DISTANCE, WHEN

WHILE PUMPING FUEL INTO VEHICLE, FUEL WOULD SPILL FROM TOP OF FUEL TANK AND PUDDLE UNDER VEHICLE. FUEL TANK AND HOSES/FITTINGS WERE INSPECTED BY AN INDEPENDANT GARAGE. INVESTIGATION REVEALED A 3 INCH SPLIT TO FUEL OVERFLOW HOSE ON MAIN HOSE CONNECTING FUEL FILLER TO FUEL TANK MAIN HOSE REPLACED. DT

INSULATION IS DETERIORATING AND BLOWS THROUGH THE VENTS WHEN IN USE. INSULATION HAS OIL MIXED IN IT AND GETS ON INDIVIDUAL'S HAIR AND CLOTHING IF THEY ARE SITTING IN THE FRONT OF THE VENTS. OWNER HAS CONTACTED DEALERSHIP INFORMED CONSUMER THAT NOTHING CAN BE DONE ABOUT INSULATION. PLEASE DESCRIBE DETAILS. *AK

THE CAR WAS STATIONED IN MY HOUSE DRIVE-WAY AND WAS DESTROYED BY AN SPONTANEOUS COMBUSTION. IT WAS A TOTAL LOSS. *AK

VOLVO DEALER REPRESENTED STATED SRS CRASH SENSOR WAS NOT UNDER ANY WARRANTY. *AK

A GOODYEAR EAGLE GTR4 TIRE (P185 65 R15) EXPERIENCED TREAD SEPARATION, WHEN THE TIRE SEPARATED, DAMAGE WAS CAUSED TO THE VEHICLE. *SLC

CAR STOPPED AT TRAFFIC LIGHT. DEPRESSED GAS PEDAL TO MOVE FORWARD. CAR ACCELERATED AT FULL SPEED WITH GAS PEDAL FULLY DEPRESSED. TURNED OFF ENGINE IGNITION, GAS PEDAL REMAINED FULLY DEPRESSED. CAR TOWED TO VOLVO DEALER FOR DIAGNOSES AND REPAIR.*AK

THE FUEL PUMP ASSEMBLY SHORTED OUT AND THE WIRES COUGHT ON FIRE BURNING THE FUEL PUMP AND BOTH ARE LOCATED INSIDE THE GAS TANK. THANK GOD IT DID NOT BLOW UP. MY MECHANIC WAS SURPRISE IT DIDN'T. I CONTACTED THE MANUFACTURER AND THEY SHOWED NO REAL CONCERN. THEY INVESTIGATED THE SITUATION AND SAID, THEY COULD NOT DETERMINE WHAT CAUSED THE FUEL PUMP ASSEMBLY TO SHORT OUT. THEY ALSO SAID THEY WERE NOT GOING TO EXAMINE IT FURTHER OR RECALL THE PART. PLEASE INVESTIGATE THIS OCCURANCE, THE NEXT PERSON MIGHT NOT BE AS FORTUNATE AS WE WERE. WE ARE AFRAID TO DRIVE THE CAR. I AS THE MANUFACTURER IF THEY WOULD REFIT MY CAR WITH AN EXTERNAL PUMP (LIKE THE NEWER VERSION VOLVOS) THEY SIAD NO. AGAIN THEY SHOWED NO RERAL CONCER FOR ME OR ANY OTHER VOLVO OWNERS. THANK YOU.

DRIVER AIR BAG DEPLOYED BY ITSELF WHILE MY WIFE WAS DRIVING WITHOUT CONTACT WITH ANYTHING.

WHEN ACCELERATING VEHICLE WILL RANDOMLY SHUT DOWN WITHOUT WARNING, CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK

I PURCHASED MY CAR ON APRIL 20, 1993 AT SNELL VOLVO NOW VOLVO OF RICHARDSON. THE NEXT DAY I WAS TRAVELING OUT OF STATE AND NOTICED THAT THE CAR WAS PULLING TO THE SIDE SO I TOOK IT TO A VOLVO DEALERSHIP IN MONROE, LA. AFTER THAT TIME I TOOK THE CAR BACK SEVERAL DIFFERENT TIMES DUE TO THE SAME PROPLEM. THE DEALER COULD NEVER GET IT TO REPEAT THE ACTION. I HAD TO HAVE MY TIRES REPLACED NEARLY AT EVERY 20K MILES. THEY WOULD SIMPLY BLOW OUT. EACH TIME I WAS TOLD THAT I NEEDED AN ALIGNMENT BECAUSE THE CAR WOULD NEVER ALIGN PROPERLY. I MADE SEVERAL COMPLAINTS, BUT TO NO AVAIL. THEN ON SATURDAY, APRIL 18, 1999 I TOOK THE CAR TO A NON VOLVO DEALER TO HAVE IT ALIGNED. IT HAD JUST BEEN TO THE VOLVO SHOP A COUPLE OF WEEK PRIOR FOR A 5K SERVICE CHECK. I WAS TOLD THAT THE CAR COULD NOT BE ALIGNED AND THAT I NEEDED TO TAKE IT TO THE VOLVO DEALERSHIP BECAUSE THE STRUT ROD WAS BENT. I PROCEEDED TO TAKE THE CAR TO THE DEALERSHIP , BUT I COULD NOT STEER THE CAR. THE TAIL RIGOROUSLY MOVED FROM SIDE TO SIDE AND I THOUGHT IT WAS GOING TO CAUSE AN ACCIDENT. I PULLED OFF THE ROAD AND CALL A TOW TRUCK. AFTER THE TRUCK ARRIVED WE COULD CLEARLY SEE THAT A LONG METAL PART WHICH WE THOUGHT WAS THE FRAME WAS CLEANLY BROKEN. I WAS TOLD THAT I PROBABLY WOULD HAVE BEEN KILLED IF I HAD CONTINUED TO DRIVE THAT CAR. I REPORTED THIS TO THE VOLVO HEADQUARTERS AND STATED THAT I HAD ALWAYS HAD PROBLEMS WITH THE CAR NOT BEING ALIGNED AND THAT IT SHOULD HAVE BEEN DETECTED DURING MAINTENANCE CHECKS AND I WAS REFERRED

RECALL 93V074000; VEHICLE HAD OIL CHANGE, AND WHEN LEAVING THE DEALERSHIP WENT UP HILL AT 62MPH BEHIND A TRUCK. CAR SPEEDED ON THE HILL, HIT THE TRUCK, AND FLIPPED OVER. VEHICLE WAS TOTALED. MANUFACTURER AWARE OF THE RECALL, BUT THIS VEHICLE DID NOT COMPLY WITH THE RECALL. THE VEHICLE'S THROTTLE IS STILL OPEN AFTER THE ACCIDENT. *AK

WHEN DRIVING DOWN A STEEP HILL ABOUT 55MPH THE HOOD ON THE VEHICLE JUST POPPED OPEN, AND THE HOOD WENT INTO THE FRONT WINDSHIELD. *AK

NO DEPLOYMENT OF AIRBAGS DURING COLLISION, CAUSING INJURY. (ATTORNEY FOR CLIENT)

AFTER BEING STOPPED AT A TRAFFIC LIGHT 10 OR 15 FT FOWARD, THE VEHICLE STALLED/CUT OFF AND THEN HAD TO RESTART IT. *AK VEHICLE STALLS INTERMITTENTLY AND SO INFREQUENTLY THAT DEALER UNABLE TO DUPLICATE PROBLEM BY TEST DRIVING, STALLING HAPPENS AFTER A FULL STOP WHEN BEGINNING TO ACCELERATE AGAIN, VEHICLE WILL MOVE FOWARD NORMALLY AT LEAST 10 TO 15 FEET THEN ABRUPTLY STALLS, CONSUMER STATES WIRING HARNESS HAS BEEN REPLACED CIRCUIT BOARD HAS BEEN REPLACED TO TRY AN CORRECT PROBLEM BUT NOTHING HAS WORKED.*JB

WINDSHIELD WASHER FLUID DOES NOT ALWAYS COME OUT, CAN HEAR THE PUMP WORKING BUT NOTHING COMES OUT. PLEASE DESCRIBE DETAILS. *AK

VEHICLE REAR-ENDED ANOTHER VEHICLE VERY SLIGHTLY, AIR BAG DEPLOYED AFTER MAKING A LOUD NOISE, VEHICLE THEN FILLED WITH SMOKE. *AK

AUTO-TRAN: SHIFTED FROM DRIVE TO PARK, WITH FOOT STILL ON BRAKE, ENGINE ACCELERATED FORWARD/BACKWARD; UNUSUALLY HIGH ACCELERATION; VEHICLE HIT WALL/OTHER CARS.

EXPERIENCE SUDDEN ACCELERATION, IN REVERSE AND IN PARK, THROTTLE OPEN POSITION IMPACT AT 12:00 AND THEN AT 6:00 POSITION. TT