2006 Volkswagen Jetta complaints

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, SHE HEARD A NOISE COMING FROM THE FRONT END OF HER VEHICLE. WHEN THE VEHICLE WAS PARKED AND TURNED OFF, THE VEHICLE WOULD NOT RE-START. THERE WERE NO WARNING LIGHTS PRIOR TO OR AFTER THE FAILURE. A LOCAL MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE DUAL MASK FLY WHEEL (CONNECTED TO THE CRANKSHAFT ON THE ENGINE) HAD A LARGE HOLE (SIZE OF A SILVER DOLLAR) IN IT. SHE CALLED THE MANUFACTURER BUT WAS TOLD THAT THERE WAS NOTHING THEY COULD DO ABOUT THE FAILURE. THE VEHICLE WAS REPAIRED BY THE MECHANIC. THE CURRENT MILEAGE WAS APPROXIMATELY 79,990. THE FAILURE MILEAGE WAS 78,750.

WHENEVER THE OUTSIDE TEMP REACHES 82 OR ABOVE AND I AM STUCK IN TRAFFIC, I LOSE MY POWERSTEERING (ELECTRIC). THIS HAS HAPPENED SINCE DAY 1 WHEN I PURCHASE THE VEHICLE ON 11/1/2006. I HAVE BEEN TO THE DEALER 3 TIMES. EACH TIME THEY ACKNOWLEDGE THAT THE COMPUTER SHOWS THE FAILURE BUT WILL NOT REMEDY THE CONDITION UNLESS THE IDIOT LIGHT IS ON WHEN I ARRIVE. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE DRIVER'S DOOR WHERE THE HINGES WERE LOCATED EXHIBITS DEFECTIVE ENGINEERING WITHIN THE WIRING HARNESS. SEVERAL OF THE WIRES WERE BROKEN BETWEEN THE BODY OF THE VEHICLE AND THE DOOR. THE DRIVER SIDE WINDOW DID NOT OPERATE AND THE POWER DOOR LOCKS DID NOT FUNCTION DUE TO THE BROKEN WIRES. HE TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE WIRING HARNESS NEEDED TO BE REPLACED AND THEY COULD NOT ASSIST WITH REPAIR EXPENSES SINCE THE WARRANTY WAS NO LONGER VALID. THE CONTACT WAS CERTAIN THAT REPLACING THE WIRING HARNESS WOULD NOT REMEDY THE FAILURE SINCE THE WIRING HARNESS WAS BEING DAMAGED BY THE OPENING AND CLOSING OF THE DOOR. HE WROTE THE MANUFACTURER BUT RECEIVED NO ASSISTANCE THERE AS WELL. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 52,500. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000.

VOLKSWAGEN JETTA TDI DUAL MASS FLYWHEEL COMING APART ON DIRECT SHIFT GEARBOX TRANSMISSION. PRIOR TO POSSIBLE LOSS OF POWER ACCIDENT, REPLACED THE DMF. THIS IS A KNOWN PROBLEM IN EUROPE AND AUSTRALIA; THE DMF WAS A RECALL ITEM. *TR

THE AIRBAG LIGHT ON MY 2006 VW JETTA CAME ON DURING 2006. I NEVER RECEIVED NOTIFICATION FROM VW OF A DEFECT BUT WHEN BRINGING MY CAR IN FOR MAINTENANCE, THE DEALER SAID THERE WAS A "NOTICE" OF A DEFECT IN THE UNDERSEAT SENSOR AND/OR WIRING. ON 6/27/06 MY CAR HAD A DRIVER SIDE FRONT IN CRASH. THE AIR BAGS DID NOT GO OFF. THE BODY SHOP SAID THAT THERE WAS PROBABLY NOT ENOUGH DAMAGE TO SET OFF THE AIRBAGS. SHORTLY AFTER GETTING MY CAR OUT OF THE SHOP (2+ MONTHS BECAUSE VW PARTS ARE NOT READILY AVAILABLE) THE AIRBAG LIGHT IS BACK ON. I'VE BROUGHT MY CAR IN FOR MAINTENANCE AT THE VW DEALER BUT THEY HAVE NEVER MENTIONED THE AIRBAG LIGHT WHICH IS PLAIN SIGHT. I WORRY ABOUT THE SAFETY OF MY FAMILY, FRIENDS AND MYSELF. TO ADD INSULT, THE ELECTRONIC SWITCH ON THE TRUNK OPERATES OFF AND ON, THE TRUNK DOES NOT LATCH UNLESS SLAMMED REPEATEDLY, AND WITHIN THE LAST WEEK THE DRIVER'S ELECTRIC WINDOW HAS CEASED TO FUNCTION. *TR

I NOTICED THAT THE SIDE WALLS OF MY CONTINENTAL TIRES ON MY 2006 VW JETTA WERE CRACKED(THERE WERE 25K MILES ON THE TIRES). I REPORTED THIS TO CONTINENTAL -MR. CARL WALKER. I REPLACED THE TIRES WITH BRIDGESTONES. I STILL HAVE THE ORIGINALS. I WAS TOLD TO TAKE THE TIRES TO MERCHANT'S TIRE ON WOODFIED ROAD IN GAITHERSBURG, MD AND HAVE THEM INSPECTED AND THE TREAD DEPTH MEASURED. I DID THIS IMMEDIATELY AFTER SPEAKING TO MR. WALKER. THE SALES REP. AT MERCHANT'S CALLED MR. WALKER AFTER INSPECTION WHILE I WAS PRESENT AND TOLD HIM THAT THE SIDEWALLS WERE INDEED DANGEROUSLY CRACKED ON ALL 4 TIRES AND THAT THE TREAD DEPTH WAS ALMOSTLIKE NEW. I WAS PROMISED 60% COMPENSATION FOR THE CONTINENTAL TIRES BY CONTINENTAL'S REP.CARL WALKER ( CLAIM # 244382) - PHONE #7045834819 -IN OCTOBER BUT HAVE RECEIVED NOTHING. THESE TIRES ARE UNSAFE AND IT IS ONLY LUCK THAT PREVENTED A SERIOUS ACCIDENT DUE TO THEIR FAILURE. VW SAYS THEY HAVE NO JURISDICTION OVER CONTINENTAL EVEN THOUGH THEY SUPPLY TIRES TO THOUSANDS OF VW VEHICLES. IT SEEM THAT VW AND CONTINENTAL WANT TO IGNORE THE PROBLEM FOR ME AND I ASSUME ALL OTHER OWNERS OF THESE TIRES. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA WHICH WAS PURCHASED IN APRIL 2006. HE ALWAYS HEARD A NOISE IN THE ENGINE COMPARTMENT SIMILAR TO ROCKS RATTLING INSIDE THE ENGINE WHILE DRIVING VARIOUS SPEEDS INCLUDING APPROXIMATELY 65 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. THE DEALER ADVISED THAT THE NOISES WERE NORMAL FOR HIS PARTICULAR TYPE OF TRANSMISSION. THE NOISES BECAME WORSE. THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER WHERE THEY VERIFIED THERE WAS AN ISSUE WITH THE TRANSMISSION. UPON FURTHER RESEARCH THEY FOUND THE FLY-WHEEL ASSEMBLY WAS FAULTY. REPAIRS WERE MADE AT THE OWNER'S EXPENSE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGES WERE 80,000. UPDATED 12/22/10 *BF UPDATED 12/30/10*JB

JANUARY 2ND 2010 MY WIFE AND I WERE IN OUR 2006 VW JETTA TDI TRAVELING SOUTH ON THE KANSAS TURNPIKE FROM TOPEKA, KANSAS. THE VEHICLE WAS IN CRUISE AT 70MPH IT WAS 7:30AM CLEAR WITH TEMP OF MINUS 2 DEGREE'S. APPROXIMATELY 35 MILES SOUTH OF TOPEKA, THE VEHICLE SUDDENLY DROPPED DOWN TO 5TH GEAR A SUDDEN AND ABRUPT BANG NOISE WAS HEARD IT SEEMED THAT THE FRONT WHEELS LOCKED FOR A BRIEF MOMENT. MY WIFE HAD JUST UNCLIPPED HER SEAT BELT TO GET SOMETHING FROM THE BACK SEAT WHEN THIS OCCURRED. THIS LOCKING OF THE FRONT WHEELS SLAMMED HER AGAINST THE DASH AND FRONT DOOR POST. I REGAINED CONTROL OF THE VEHICLE AND MANEUVERED IT TO THE SIDE OF THE TURNPIKE. THERE WAS A RATTLING IN THE TRANSMISSION AREA SEVERAL MONTHS BEFORE WHEN I HAD IT AT A DEALERSHIP FOR TRANSMISSION FLUID CHANGE. I HAD ASKED THEM TO CHECK THE RATTLE? WHEN I PICKED UP THE VEHICLE IT WAS STILL RATTLING, I THOUGHT IT TO BE OK. HOWEVER AFTER THIS INCIDENT, I HAVE BEEN INVESTIGATING THE INTERNET AND FOUND SEVERAL DUAL MASS FLYWHEEL FAILURES WITH THIS VEHICLE AND THE DSG TRANSMISSION, HOWEVER VW AMERICA HAS DONE NOTHING ABOUT IT. IF I HAD BEEN IN HEAVY TRAFFIC IT WOULD HAVE CERTAINLY CAUSED A TERRIBLE ACCIDENT, WHEN IT LOCKED UP THE FRONT DRIVE WHEEL, WE WERE LUCKY MY WIFE ONLY HAD A VERY BADLY BRUISED SIDE, ARM AND BACK. WE THEN SPENT TWO HOURS ON THE SIDE OF THE TURNPIKE IN FRIGID TEMPS AWAITING A TOW VEHICLE. WE WERE ENROUTE TO A MEDICAL FACILITY IN TEXAS FOR SURGERY ON BOTH OF MY WIVES EYES WE HAD NO TIME TO DO ANYTHIN

WHILE DRIVING AT 65 MPH ON ROUTE 80 IN ROCKAWAY, NJ, THE CAR APPEARED TO SHIFT INTO NEUTRAL LEAVING ME WITHOUT FORWARD ACCELERATION. MY DASHBOARD TRANSMISSION INDICATOR LIGHTS STARTED FLASHING. I WAS NEARLY MISSED BY HEAVY TRAFFIC WHILE ATTEMPTING TO GET THE CAR TO THE SHOULDER WITHOUT ANY ACCELERATION. I WAITED A FEW MINUTES RESTARTED CAR, IT WENT INTO GEAR AND I PULLED BACK ONTO THE HIGHWAY. IN LESS THAN 500 FEET THE CAR REPEATED THE ABOVE PROCESS AND I ONCE AGAIN HAD TO SAFELY NAVIGATE MY WAY TO THE SHOULDER. AT THIS TIME THE CAR WOULD NOT RE-ENGAGE AND I WAS TOWED TO MY LOCAL VOLKSWAGEN DEALERSHIP. *TR

MY 2006 VW JETTA TDI STOPPED MOVING WHILE DRIVING TO WORK ON JAN 4TH, 2010. THERE WERE NO SIGNS OF ISSUES PRIOR TO THE BREAK DOWN. THE ENGINE WAS RUNNING FINE, THE PRNDS LIGHT ON THE DASH WERE FLASHING AND THE CAR'S TRANSMISSION WOULD NOT RESPOND. AFTER HAVING THE CAR TOWED TO OUR LOCAL VW DEALER WE FOUND THAT THE TRANSMISSION WENT IN TO FAIL SAFE MODE DUE TO A DSG SYSTEM FAILURE. PER OUR SERVICE REP THE MECHATRONIC UNIT FAILED DUE TO OVER HEATING. OUR VEHICLE IS IN-OPERABLE AND THE REPAIR PART NEEDED WILL TAKE 2 WEEKS OR MORE TO RECEIVE AS THERE IS A RECALL ON THE SAME PART FOR THE SAME FAILURE FOR 2007-2009 VW'S AND AUDI'S. OUR VEHICLE IS OUT OF WARRANTY, VW DENIED THAT THIS ISSUE IS APART OF THE RECALL AS OUR VIN DOES NOT FIT THE RECALL LIST. THEY AGREED TO ALLOW THE REPAIR UNDER WARRANTY PRICING AND PAY HALF FOR THE REPAIR; THIS WILL COST ME $1254 TO REPAIR THEIR KNOWN ISSUE. *TR

2006 VOLKSWAGEN JETTA IS EQUIPPED WITH BRAKE LIGHT SWITCH PART NUMBER 3B0 945 511 WHICH WAS THE SUBJECT OF A RECALL (RECALL 07V063000) IN 2003-2005 PASSAT AND PASSAT WAGON. *TR

12-31-09 ODI 2006 VW JETTA TDIDSG MECHATRONICS MALFUNCTION MONDAY, NOVEMBER 2, 2009 VOLKSWAGEN 2006 VW JETTATDI DSG WENT TO SAFE MODE (FELT LIKE NEUTRAL) WHILE ACCELERATING ON STREET (JUST EXITED K-96 IN WICHITA, A 65 MPH 4-LANE AND WAS ACCELERATING FOLLOWING RIGHT TURN FROM COMPLETE STOP). SHIFT INDICATOR LIGHTS FLASHING. WAS ABLE TO TURN OFF ROAD AND MANUALLY DOWNSHIFT TO 1ST GEAR. LIMPED HOME AT 15 MPH. COULD NOT PLACE VEHICLE IN REVERSE UNTIL SYMPTOMS RESET (SHIFT INDICATOR NO LONGER FLASHING). TEST DROVE AFTER RESET. RECURRED AS TURNED AND APPLIED BRAKES TO PARK. LET IT SIT. IT RESET. DROVE BACK HOME. RECURRED WHILE TURNING RIGHT NEAR HOME. QUERIED "JUST ASK." TUESDAY, NOV 3RD CALLED VW LOYALTY CARE, FILED REPORT, AND THEN WITH ENGINE COLD, DROVE TO 4.6 MILES TO AUTOZONE FOR DIAGNOSIS SCAN. AT 3.5 MILES, THE DSG MALFUNCTIONED AGAIN. SAME SYMPTOMS. SCANNED. LET IT SIT. DID NOT RESET. LIMPED 1 MILE TOWARD VW DEALERSHIP. CALLED FOR TOW. UPDATED VW LOYALTY CARE FILE. MILEAGE IN: 85,198 WITH SHIFT INDICATOR LIGHTS FLASHING. MATCHES DESCRIPTION OF DSG TRANS SOFTWARE UPDATE RECALL ('09-'10). ALSO MATCHES THE VW MECHATRONICS UNIT SYMPTOMS FOR SOME 45,000 VW 2007+ MODELS (REPLACED AT NO CHARGE AND WARRANTY EXTENDED ON DSG TO 100,000). PROBLEM AREA: NUMEROUS DSG TEMPERATURE SENSOR MALFUNCTIONS AND THINKS INCORRECTLY THAT THE DSG OIL IS OVERHEATING AND PLACES TRANSMISSION IN SAFE MODE. DIAGNOSIS: REPLACED MECHATRONICS UNIT AT $2,433.48 NOTE: FILED WITH VW LOYALTY CENTER ON NOV 3, T

AN ONGOING PROBLEM WITH A 2006 VOLKSWAGEN JETTA 1.9L TDI AUTOMATIC DSG WITH 87,000 MILES. A VIDEO OF IT IN ACTION: HTTP://WWW.YOUTUBE.COM/WATCH?V=7LSEX_-B_O0 WHILE DRIVING, THE CAR WILL GO INTO NEUTRAL AND ALL THE DASHBOARD LIGHTS WILL COME ON WITH DIFFERENT SOUNDS. CHANGING THE SHIFTER INTO P, N, D, R, S (SPORTMODE) DOES NOTHING. CHANGING INTO THE TIPTRONIC MODE DOES NOTHING. THIS IS ONE INCIDENT OF A SERIES OF INCIDENTS THAT HAVE BEEN HAPPENING SPORADICALLY FOR THE PAST YEAR, BUT THIS HAS BEEN HAPPENING ON AND OFF SINCE BEFORE THANKSGIVING 2009. WE'VE BEEN ON THE PHONE WITH VOLKSWAGEN OF AMERICA AND THEY HAVE NO SOLUTION. THE DEALERSHIP (PARADISE VOLKSWAGEN 760-200-4000) HAS DONE NUMEROUS "REPAIRS" TO THE CAR INCLUDING: MISC DIAGNOSIS 12/28-?? NEW STEERING RACK 12/6-12/22 SENSOR AND ELECTRICAL MODULE 12/1-12/16 MISC DIAGNOSIS ON 11/16-11/20 WE FEEL VERY UNSAFE IN THE CAR - WHAT IF IT HAPPENED ON THE FREEWAY? *TR

MY 2006 JETTA TDI HAS 69K MILES ON IT. I BRING IT TO THE DEALER FOR SERVICE ROUTINELY AND BABY THE CAR. IT SPENDS NEARLY NO TIME IN TRAFFIC AND HAS RUN WELL UNTIL LAST WEEK. LAST WEEK I HEARD A FUNNY SOUND COMING FROM THE ENGINE COMPARTMENT. I BROUGHT IT INTO THE DEALER. LONG STORY SHORT, THE FLYWHEEL HAD CRACKED AND IT WILL BE OVER $2K FOR THE FLYWHEEL. VW KNOWS ABOUT THIS BEING A FAULTY PART AND I'VE HEARD THEY'VE HAD A FULL RECALL IN OTHER COUNTRIES. I CALLED VW OF AMERICA AND THEY REFUSE TO PAY FOR IT BECAUSE THE CAR IS SLIGHTLY OUT OF WARRANTY. IT IS BEING REPAIRED IN THE SHOP BECAUSE I CANNOT AFFORD TO BE WITHOUT A CAR. LUCKILY NO ONE WAS HURT, BECAUSE IF I HADN'T BROUGHT THE CAR IMMEDIATELY IN IT COULD HAVE STALLED THE CAR AT HIGH SPEEDS (FREEWAY) AND RUINED THE ENTIRE DRIVETRAIN, CAUSING AN ACCIDENT. AGAIN, VW KNEW THIS PART HAS BEEN FAULTY. THERE IS A TECHNICAL SERVICE BULLETIN ON IT. *TR

2006.5 VOLKSWAGEN JETTA TDI EXPERIENCING SLOW GEAR CHANGES FROM PARK TO REVERSE OR PARK TO FIRST GEAR TAKING OVER 30 SECONDS TO SELECT GEAR ELECTRONICALLY. SHIFTING FROM LOWER GEAR TO HIGHER GEAR RESULTS IN ENGINE REVVING HIGH BEFORE SHIFT IS ACTUALLY MADE RESULTING IN JERKING VEHICLE MOTION OR A STALLED MOTOR CONDITION. SLOW SPEED MANEUVERING SUCH AS SLOW TURNS AND PARTIAL STOPS RESULTS IN THE VEHICLE LOSING FORWARD POWER FOR SEVERAL SECONDS BEFORE THE ENGINE REVS HIGH AGAIN AND SHIFTS INTO GEAR. AT 30 MPH VEHICLE HAS DROPPED OUT OF GEAR RESULTING IN VEHICLE NEEDING TO BE GUIDED TO THE SHOULDER AND POWERED OFF AND BACK ON BEFORE FORWARD MOTION CAN BE RESUMED. VEHICLE ALSO WILL DISPLAY FLASHING PRNDS DISPLAY ON DASHBOARD ON RESUMING FORWARD MOTION RESULTING IN THE TRANSMISSION TO DISENGAGE AND REQUIRES THE VEHICLE TO BE STOPPED, SHUT OFF, AND THEN POWERED BACK ON. VEHICLE IS EXHIBITING NO MECHANICAL NOISE, SMELL, OR ERROR CODES IN THE COMPUTER. DEALER HAS CONFIRMED THERE IS A MALFUNCTIONING MECHATRONIC UNIT AND VWOA HAS CONFIRMED THEY WILL NOT COVER UNDER THEIR RECALL CAMPAIGN DESPITE THESE SYMPTOMS LEADING TO THE CAMPAIGN IN QUESTION. VOLKSWAGEN CUSTOMER SERVICE HAS DENIED A FURTHER INQUIRY INTO THE MANUFACTURING DATES OF THE MECHATRONICS UNITS AND THEIR TECHNICAL REVISIONS, ONLY GOING OFF VEHICLE MODEL YEARS AND BUILD DATES DESPITE OTHER 2006 OWNERS REPORTING IDENTICAL CIRCUMSTANCES WITH THEIR VEHICLES. TECHNICIANS ADVISED AGAINST FURTHER DRIVING OF THE VEHICLE AS THERE WAS

2006 VOLKSWAGEN JETTA 54000 MILES 5 SPEED MANUAL TRANSMISSION. I WAS DRIVING AND WHILE EXITING A FREEWAY OFFRAMP I DEPRESSED THE CLUTCH TO DISENGAGE THE TRANSMISSION. CLUTCH PEDAL WENT TO THE FLOOR AND WOULD NOT COME BACK UP AND IT DID NOT DISENGAGE THE TRANSMISSION. THE CAR WOULD NOT STOP, AS I COULD NOT PUT THE CAR IN NEUTRAL. VERY DANGEROUS! *TR

2006 VW JETTA TDI TRANSMISSION AND MOTOR FAILURES. *TR

ON MY 2006 VOLKSWAGEN PASSAT THE CAM FOLLOWER HAS WORN THROUGH AND DAMAGED THE CAM SHAFT LOBE THAT DRIVES THE PUMP. THIS IS A KNOWN ISSUE THAT HAS AFFECTED MANY VW PASSATS. IT IS A SAFETY HAZARD AS IT CAN CAUSE THE ENGINE TO STALL THERE FOR IF A PERSON IS IN THE FLOW OF TRAFFIC IT COULD CAUSE A CRASH TO OCCUR. VOLKSWAGEN HAS ISSUED A TSB ON THE ISSUE BUT WILL ONLY PERFORM THIS SERVICE IF THE COMPUTER SHOWS A SPECIFIC CHECK ENGINE LIGHT AND ONLY IF STILL UNDER THE MANUFACTURES WARRANTY. VOLKSWAGEN SHOULD AT THE LEAST BE REQUIRED TO INFORM PEOPLE THAT THE CAM FOLLOWER SHOULD BE CHECKED FOR WEAR AT A REGULAR INTERVALS TO PREVENT A POSSIBLE ACCIDENT. *TR

1ST COMPLAINT ODI #10278262 FILED ON 7/24/09 FOR 2006 JETTA TDI: "PRIOR TO THE EVENT LISTED BELOW, WE NOTICED THAT THE CAR WAS NOT PERFORMING AS IT NORMALLY WOULD. WE WERE STOPPED AT A TRAFFIC SIGNAL IN A CONSTRUCTION ZONE, LIGHT TURNED GREEN PROCEEDED TO ACCELERATE, CAR MOVED 10 FEET, RPM WENT HIGH AND IT WAS AS IF THE CAR WAS IN NEUTRAL. HAD ENOUGH MOMENTUM TO REACH THE SIDE OF THE ROAD. PRND WAS LIT UP AND FLASHING AND THE POWER STEERING SYSTEM SYMBOL HAD ERRATIC FLASHING. TRIED PARK, NEUTRAL, REVERSE NOTHING HAPPENED. PUT THE CAR IN PARK AND SHUT OFF ENGINE. RESTARTED ENGINE AND IT ALLOWED US TO DRIVE OFF. WENT APPROXIMATELY 10 MILES DRIVING AT ABOUT 55 MPH, THOUGHT WE SEEN AN ANIMAL AND LET OFF THE ACCELERATOR. UPON TRYING TO ACCELERATE, INCIDENT DESCRIBED ABOVE HAPPENED AGAIN, THIS TIME A CHECK ENGINE LIGHT APPEARED. BEFORE CALLING THE DEALER WE DID A SEARCH AND CAME ACROSS THIS SITE. OUR VEHICLE HAD A DSG TRANSMISSION SERVICE (FOR A COST OF $286.75) AT 43,703 MILES AND THE CAR NOW HAS 71,491 MILES. THIS VEHICLE ALSO HAS A PROBLEM AT TIMES, THAT WAS REPORTED TO THE DEALER ON JUNE 5, 2007 AND NOTHING WAS DONE ABOUT IT, ON COLD START UP, PUTTING IT IN GEAR AND HAVING A VERY SEVERE JERKING, ALMOST TO THE POINT THAT IT MIGHT STALL THE ENGINE." UPDATE 10-3-09: FOR FEAR OF HAVING ANOTHER OCCURRENCE, THE CAR WAS TOWED (70+ MILES) TO DEALER IN LATE AUGUST, DIAGNOSIS WAS IT NEEDED A NEW MECHATRONICS UNIT. DELIVERY TIME FOR PART WAS OVER A MONTH. TALKED TO MECHANIC AT VW, HE RECO

TRANSMISSION LURCH FORWARD, SOMETIMES SKIP THE SHIFTS,ALSO SHIFTS ARE DELAYED OR ENG REV,TOO HIGH AND DOWNSHIFTHING IT KICKS 2 TO 1AND THERE'S A CLUNKING NOISE. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 75 MPH THE TRANSMISSION SLIPPED INTO NEUTRAL GEAR. A TECHNICIAN CONCLUDED THAT THE TRANSMISSION WAS PERFORMING NORMALLY. HE THEN ADDED THAT DRIVING LONG DISTANCES IN WARMER WEATHER CONDITIONS COULD CAUSE THE FAILURE. THE FAILURE MILEAGE WAS 42,000. THE CURRENT MILEAGE WAS 47,000. UPDATED 10/21/09. *LJ UPDATED 10/20/09*JB

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE GLASS OF THE REAR WINDSHIELD SHATTERED. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN CONCLUDED THAT THE REAR-VIEW MIRROR AND WINDSHIELD NEEDED TO BE REPLACED. HOWEVER HE ADDED THAT NO REPLACEMENTS PARTS WERE AVAILABLE BECAUSE THE COMPONENT WAS REDESIGNED. THE FAILURE MILEAGE WAS 50,200. THE CURRENT MILEAGE WAS 50,230.

CAR WAS ON A TERMINAL ACCESS RAMP AT AN AIRPORT, AT LESS THAN 20MPH WHEN IT SUDDENLY LOST ALL MOTIVE POWER WITH THE ENGINE STILL RUNNING. THE "P-R-N-D-1-2" ON THE INSTRUMENT CLUSTER WAS FLASHING ON AND OFF AND THE TRANSMISSION SEEMED TO BE STUCK IN NEUTRAL REGARDLESS OF WHERE THE AUTOMATIC TRANSMISSION SELECTOR WAS PLACED. CAR HAD TO BE TOWED TO A VW DEALER AND WAS DIAGNOSED WITH A DEFECTIVE/ FAILED "MECHATRONIC UNIT" CAR REMAINED AT DEALERSHIP FOR SIX (6) WEEKS WAITING FOR PARTS. CAR WAS RETURNED ON 09-23-2009 AND APPEARS TO OPERATE NORMALLY. *TR

2006 VW JETTA TDI W/ 14,000 MILES APPROACHING A YIELD, THE CLUTCH WAS DEPRESSED. THE CLUTCH STUCK TO THE FLOOR OF THE VEHICLE CAUSING THE VEHICLE TO LOOSE ALL TRANSMISSION FUNCTION. THE VEHICLE COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE DEALER. IT HAS BEEN IDENTIFIED THAT SOME SACHS CLUTCH COMPONENTS HAVE A DEVELOPMENTAL (FRICTION MATERIAL) FLAW WHICH CAUSE PREMATURE CLUTCH DISC WEAR.THE DEALER DETERMINED THE TRANSMISSION FAILURE WAS DUE TO DRIVER ERROR. FRICTION MATERIAL FLAW ON CLUTCH PLATE OR PRESSURE PLATE WHICH LEADS TO BURNT, SHREDDED, OR MISSING CLUTCH PLATE MATERIAL ON CLUTCH PLATE. THIS SHOULD BE COVERED BY MY WARRANTY. ESPECIALLY SINCE THERE IS ONLY 14,000 MILES. THIS PROBLEM HAS BEEN REPORTED BY HUNDREDS OF 06 TDI OWNERS AND VW CONTINUES TO ACCEPT RESPONSIBILITY FOR THEIR FLAWED EQUIPMENT. *TR

2006 VOLKSWAGEN JETTA, ALL BUTTONS ON THE RADIO ARE DEFECTIVE, THE PLASTIC BUTTONS ARE BUBBLING AND DEFORMING AND PEELING. *TR

2006 JETTA GLI WITH DSG GEARBOX, REPEATED TRANSMISSION CLUNKING (IN AUTOMATIC MODE) WHEN DOWNSHIFTING FROM 2ND TO 1ST, AND HARSH THUNKING IN FIRST GEAR FROM A STOP ENGINE REVS UP BUT CAR WILL NOT MOVE FOR 1 TO TWO SECONDS THEN THUNK AND CAR SURGES FORWARD. ALSO THUNKING WHEN SHIFTING GEAR SELECTOR INTO REVERSE. HAS OCCURRED INTERMITTENTLY AND OFTEN SINCE OCT 2007. POSES DANGEROUS SITUATION AT INTERSECTIONS AND IN STOP AND GO DRIVING WITH POTENTIAL INTERMITTENT LOSS OF FORWARD MOTION AND SUDDEN FORWARD SURGING AFFECTING THE SAFE DRIVEABILITY OF THE VEHICLE COUPLE OF TIMES NARROWLY MISSED RUNNING INTO THE VEHICLE IN FRONT OF ME DUE TO SUDDEN LURCHING OF THE VEHICLE. DEALER REPLACED TRANSMISSION TEMPERATURE SENSOR IN LATE 2008, BUT PROBLEM RECURRED AND PERSISTED AFTERWARDS. AFTER FEW MORE INCIDENTS AND VISITS TO DEALER THROUGH JUN 2009 WAS INFORMED MECHATRONICS UNIT WAS FAULTY AND WOULD BE REPLACED. WAITED 42 DAYS WITH CAR LEFT WITH DEALER FOR NEW PART TO BE DELIVERED FROM FACTORY " DUE TO BACKLOG' , IN MEANTIME CAR WAS RECALLED FOR TRANSMISSION BOLT REPLACEMENT/INSPECTION. FINALLY RECEIVED "FIXED" CAR WITH NEW MECHATRONICS UNIT AND PROBLEM RECURRED THE SAME DAY THREE MILES AWAY FROM THE DEALERSHIP IN STOP AND GO TRAFFIC. WAS TOLD THAT TRANSMISSION 'NEEDED TO RE-LEARN MY DRIVING PATTERN" AND TO DRIVE IT AROUND FOR A WHILE TO SEE IF THE ISSUE WOULD GO AWAY. ISSUE SUBSEQUENTLY RECURRED REPEATEDLY OVER A ONE WEEK PERIOD ESPECIALLY WHEN MOVING FROM A STOP, WITH ENGINE REVVING UP THE

I HAVE A 2006 VOLKSWAGEN JETTA TDI. RECENTLY, I HAVE BEEN EXPERIENCING TRANSMISSION ISSUES. THE VEHICLE LOSSES POWER IN THE TRANSMISSION IN THE UPPER GEARS. CONSEQUENTLY, I LOSE POWER WHILE ON THE INTERSTATE AT HIGHER SPEEDS. THIS HAS CAUSED ME TO HAVE TO TAKE EVASIVE ACTION TO AVOID CAUSING CRASHES FROM CARS BEHIND ME. I HAVE TAKEN THE CAR TO VOLKSWAGEN AS IT IS UNDER WARRANTY. THE WARRANTY COMPANY HAS MADE UNREASONABLE DEMANDS THAT THE DEALERSHIP HAS NOT BEEN ABLE TO FULFILL. AFTER A WEEK, I HAVE NOW TAKEN IT TO AAMCO TO HAVE THE TRANSMISSION SERVICED. I BELIEVE IT IS THE SAME TRANSMISSION THAT HAS BEEN RECALLED ON THE 2009 AND 2010. *TR

2006 VOLKSWAGEN JETTA TDI -- DUAL MASS FLYWHEEL FAILURE. PART HAS BEEN RECALLED IN AUSTRALIA, BUT NOT THE US. VW DEALERS REFUSE TO TAKE CONCERNS SERIOUSLY. *TR

MY 2006 VW JETTA TDI HAS A DSG TRANSMISSION. THIS TRANSMISSION HAS SLIPPED OUT OF GEAR TWICE WHILE TRAVELING ON THE INTERSTATE AT INTERSTATE SPEEDS. THIS IS AN AUTOMATIC TYPE TRANSMISSION AND SHOULD NOT BE SLIPPING OUT OF GEAR. THIS HAS NOT RESULTED IN AN ACCIDENT BUT I WAS REQUIRED TO MOVE ACROSS 3 LANES OF TRAFFIC ONLY UNDER MY CURRENT FORWARD MOMENTUM. LUCKILY I WAS ABLE TO DO SO WITHOUT INCIDENT. *TR

TL*THE CONTACT HAS A 2006 VOLKSWAGEN JETTA. HE STATED THAT THE VEHICLE WAS SURGING FROM SECOND GEAR AND ALSO BECAME HESITANT AND WASN'T SHIFTING GEARS WHEN IT SHOULD HAVE BEEN. WHILE DRIVING 70MPH GOING UP A HILL HE LOST ALL POWER TO THE VEHICLE AND IT FELT AS IF IT WAS IN NEUTRAL. AFTER LOSING POWER IT TOOK ABOUT FIVE SECONDS TO RESET IT SELF. THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL WITH CODES. THE VEHICLE WAS TAKEN TO A DEALER THE CODES WHERE REMOVED. HE WAS INFORMED THAT THE FAILURE OCCURRED FROM THE USG IN THE TRANSMISSION. THE VEHICLE IS CURRENTLY AT THE DEALER BEING WORKED ON. THE FAILURE MILEAGE WAS 68,000 BL

I OWE A 2006 VOLKSWAGEN JETTA THAT I HAVE BEEN BACK AND FORWARD FOR A LICENSED DEALERSHIP REPORTING THAT MY CAR SHUTS OFF COMPLETELY WHILE DRIVING. IIT HAVE BEEN DURING THIS ABOUT JUNE 2007 AND IT HAS BEEN TO DEALERSHIP ABOUT 6 TIMES FOR THIS SAME THING I TOOK IT IN APRIL 2008 AND THEY TOLD ME I NEED A NEW ENGINE AFTER SEVERAL OF MONTHS LETTING THEM DIAGNOSE THE PROBLEM. I AM PAYING CAR NOTE FOR A CAR I CAN NOT DRIVE. I SEEN GOOD MORNING AMERICA AND THEY SAY IT IS ONLY 2009-2010 MODELS WHEN I HAVE A 2006 THEY HAS SHUT OFF ON ME IN TRAFFIC IN BIRMINGHAM, AL , MOBILE, AND MISSISSIPPI. I CALL VOLKSWAGEN THEY TOLD ME THAT THEY COULD NOT HELP ME BECAUSE OF MY MILEAGE THEY CAN ONLY GIVE ME A 1000 DOLLARS TOWARDS ANOTHER VOLKSWAGEN. I TOLD THEM THAT I WILL NOT BUY ANOTHER. AT 1ST THEY TOLD ME THAT I NEED AND O2 SENSOR AND THE NEXT TIME THEY COULD NOT FIND ANYTHING UNTIL THEY REPORTED THAT IT WAS MY ENGINE. I FEEL IT IS NOT FAIR FOR ME TO PAY FOR A ENGINE BECAUSE I HAVE BROUGHT THE CAR TO THEM ON 5 OCCASION AND I CALL TO REPORT THE CAR SHUT OFF IN MONTGOMERY, AL ON MARCH 19, 2008 AND THEY TOLD ME TO HAVE IT TOW TO THE DEALERSHIP IN MISSISSIPPI WHO WAS FAMILIAR WITH CAR. I WAS STARTING IT FOR THE TOW TRUCK TO TAKE TO DEALER AND THE CAR WE HAYWILD. *TR

DRIVING ON I-95 IN JACKSONVILLE, FL, IT WAS RAINING WITH SOME POUNDING (APPROX. 1 INCH OF WATER) ON THE ROADWAY. I WAS MAINTAINING A SPEED OF 35-45 MPH WHEN THE EPC AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE DASHBOARD. AT FIRST THE CAR BEHAVED NORMALLY BUT AFTER ABOUT 5 MINUTES IT LOST POWER AND WOULD NOT ACCELERATE ABOVE 1500 RPM. FORTUNATELY I WAS ABLE TO QUICKLY TAKE AN EXIT RAMP OFF THE FREEWAY AND COAST INTO A GAS STATION, THE CAR CONTINUING TO REFUSE TO ACCELERATE. I TURNED THE CAR OFF AND WAITED FOR ABOUT 5 MINUTES. I STARTED UP AGAIN AND DROVE AROUND THE GAS STATION AND THINGS SEEMED NORMAL AGAIN, ALTHOUGH THE EPC LIGHT WAS STILL ILLUMINATED. STOPPED AGAIN AND WAITED ANOTHER 5 MINUTES. UPON STARTING UP AGAIN, BOTH WARNING LIGHTS WERE GONE AND THE CAR BEHAVED AND ACCELERATED NORMALLY. THIS DEFECT COULD HAVE CAUSED ME TO GET STOPPED IN TRAFFIC ON A BUSY FREEWAY POSSIBLY CAUSING A CRASH AND INJURIES. I WAS VERY LUCKY THAT IT HAPPENED WHERE IT DID AND I WAS ABLE TO PULL OFF TO SAFETY. *TR

THE REAR BRAKE PADS, ON THE VEHICLE SIDE WITH THE EMERGENCY BRAKE CABLE ATTACHED, WEAR VERY PREMATURELY. THE DEALER INDICATED THIS TYPE OF VEHICLE HAS FAULTY BRAKE ADJUSTERS. THEY WOULD NOT REPLACE UNDER WARRANTY. THIS IS A SEVERE SAFETY HAZARD. *TR

VEHICLE AIR CONDITIONING CONDENSATE DRAIN TUBE IS NOT SECURED FROM THE FACTORY. TUBE WILL POP LOOSE AND FILL VEHICLE CARPET WITH STAGNANT AIR CONDITIONING WATER. DEALER REFUSES TO ACKNOWLEDGE OBVIOUS FACTORY DEFECT AS NO FASTENER WAS FOUND TO BE IN THE TUBE FASTENER TAB. DEALER REFUSES TO REPAIR PROBLEM. *TR

VEHICLE TRUNK UNLATCHES WHILE VEHICLE IS STANDING OR IN MOTION, WITH OR WITHOUT THE ENGINE RUNNING. ITEMS IN TRUNK MAY SPILL ONTO HIGHWAY, CAUSING ACCIDENT OR INJURY. *TR

THE VEHICLE EXHAUST GAS RECIRCULATION COOLER LEAKS EXHAUST AFTER 50,000 MILES, EXPOSING THE VEHICLE OCCUPANTS TO EXHAUST GASES. ALTHOUGH THE EGR SYSTEM IS PURELY FOR EMISSIONS CONTROL, THE DEALER REFUSED TO FIX THE PART UNDER THE COVERED EMISSIONS WARRANTY. THIS PROBLEM CAN CAUSE THE DEATH OF THE OCCUPANTS OF THE VEHICLE. *TR

THE CAR AIRBAG LIGHT ILLUMINATES RANDOMLY. DEALER INDICATES SYSTEM MUST BE RESET FOR A CHARGE OF $80 EACH TIME. DEALER REFUSES TO REPAIR PROBLEM UNDER WARRANTY. AIR BAGS MAY NOT DEPLOY IN AN ACCIDENT. *TR

KNOCKING SOUND FROM PASSENGER FRONT, BROUGHT VEHICLE INTO DEALER, THEY SAID THEY DIDN'T HEAR ANY KNOCKING. LESS THAN A MONTH LATER IT GOT EXTREMELY WORSE, I TOOK IT TO ANOTHER SHOP & WAS TOLD IT WAS SOMETHING SERIOUS & NEEDED TO HAVE DEALERSHIP LOOK AT IT. WHEN I RETURNED TO THE DEALERSHIP THEY TOOK 2 DAYS TO TELL ME WHAT THE ISSUE WAS AFTER HAVING TO REMOVE ENGINE, I WAS TOLD IT WAS THE FLYWHEEL & CLUTCH HAD TO BE REPLACED BECAUSE THE FLYWHEEL DAMAGED THE CLUTCH. VERY EXPENSIVE REPAIR & AFTER BEING TOLD ABOUT THIS WEBSITE & SEEING ALL THESE COMPLAINTS I CALLED VW & THEY REFUSED TO ACKNOWLEDGE THIS ISSUE EVEN WITH ALL THESE COMPLAINTS. *TR

SUDDEN TRANSMISSION FAILURE. WHILE DRIVING AT VARIOUS SPEEDS, SEVERAL TIMES THE TRANSMISSION LOST THE GEAR AND WENT TO NEUTRAL. THE CAR LOST POWER AND HAD TO COME TO A COMPLETE STOP. TWO TIMES THIS OCCURRED AT HIGHWAY SPEED WHERE I HAD TO MAKE AGGRESSIVE MANEUVERS TO AVOID A COLLISION. *TR

I NOTICED A NOISE COMING FROM MY ENGINE/DRIVETRAIN ALONG WITH SEVERE ENGINE SHAKING. I IMMEDIATELY TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THERE WERE SEVERAL "TECHNICAL SERVICE BULLETINS" REGARDING THE FLYWHEEL AND CLUTCH IN MY VEHICLE. ALL OF THE BULLETINS ACKNOWLEDGED KNOWN PROBLEMS WITH THE FLYWHEEL AND CLUTCH PARTS. AFTER REMOVING THE TRANSMISSION TO INSPECT THE PROBLEM FURTHER IT WAS DISCOVERED THAT THE FLYWHEEL DISINTEGRATED CAUSING $3800 IN DAMAGE. THE MANUFACTURER WAS CONTACTED BY THE REPAIR FACILITY AND REFUSED TO COVER THE REPAIR CHARGES. *TR

MASS FLYWHEEL AND CLUTCH ASSEMBLY FAILURE. ANOTHER VOLKSWAGEN CLUTCH PROBLEM TO ADD TO THE LIST. WHY IS THE UNITED STATES NOT DOING ANYTHING ABOUT THIS LIKE OTHER COUNTRIES HAVE. ARE WE NOT THE MOST CARING COUNTRY IN THE WORLD, I MEAN LOOK HOW MUCH MONEY THIS GOVERNMENT DISHES OUT TO PEOPLE WHO DON'T DESERVE IT. (CAR MANUFACTURERS WHO CANT EVEN MAKE GOOD ON MANUFACTURER DEFECTS. OTHER COUNTRIES ISSUED VW TO FIX THE PROBLEMS. I EVEN READ A LETTER ON THIS WEBSITE THAT THE PROBLEM DID NOT FIND ITS WAY TO THE US BECAUSE IT WAS ONLY IN THE PASSAT. WELL THE JETTA'S, BEETLE'S, GLI'S AND THE GOLF'S ALL HAVE THE SAME TRANSMISSION THAT THEY ARE REFERRING TO IN THE LETTER. I MEAN THE GOVERNMENT IN CHARGE NOW WANTS US TO BE SUPPORTED BY THE GOVERNMENT SO WHY DOES THE GOVERNMENT NOT DO ANYTHING TO PROTECT US. THEY ARE TO MANY CASES LIKE MINE ALL OVER THIS SITE AND THE INTERNET FOR YA'LL NOT TO DO SOMETHING. TOOK THE CAR IN FOR SERVICE THEN WAS DROPPED WITH THE 3900.00 DOLLAR REPAIR BILL FOR THIS. *TR

HI I BOUGHTMY 06 TDI JETTA 2 YRS AGO IT HAD 39,800 MILES ON IT AND NOW I SEE WHY IT WAS TRADED IN AT 40,000 IT NEEDS A 560.00 SERVICE THAT I WAS NOT TOLD ABOUT. MY FAULT FOR NOT READING THE WHOLE MANUAL . I WAS TOLD BY DEALER THAT THE DSG WOULD NEED TO BE SERVICED AT 100,000 MILES AND IT WOULD BE GOOD. I BROUGHT THE CAR IN FOR CLATTERING NOISE SEVERAL TIMES AND WAS TOLD IT WAS NORMAL THE CAR HESITATED OFTEN AND SHIFTED POORLY BUT SINCE IT WAS AT THE DEALER I FIGURED IT WAS NORMAL. THE CLATTER GOT WORSE AND BY THIS TIME IT WAS ABOUT DUE FOR ITS 100000 MILE SERVICE BUT BEFORE I COULD GET IT IN ONE DAY DRIVING HOME FROM WORK IT SOULDED LIKE A BUCKET OR BOLTS FEEL OUT FROM MY CAR THE CLATTER BECAME SEVERE AND SOON AFTER THE CAR LEFT ME SIT ON THE SIDE OF THE HIGHWAY.I DESCRIBE THE PROBLEM AND CLATTER NOISE TO THE DEALER AND ALL OF A SUDDEN THEY KNEW THE PROBLEM EXACTLY. THEY TELL ME ITS PROBABLY THE CLUTCHES AND IT CAN'T BE REBUILT AND THEN THE SERVICE MANAGER AT YOUNG VW LAUGHING A LITTLE TELLS ME THAT I MISSED TWO SERVICES ON THE TRANNY WHEN I BOUGHT THE CAR WITH 39800 AND THEN THE CAR WAS BROUGHT IN SEVERAL TIMES AND NO ONE EVER TOLD ME THEIR MIGHT BE A PROBLEM UNTIL NOW THE CAR SITS AND I NEED 5000.00 DOLLARS TO FIX IT. THIS TRANSMISSION IS A PIECE OF '!@#$%'. I DON'T KNOW HOW MANY TIMES I ALMOST GOT SIDE SWIPED TRYING TO PULL OUT INTO TRAFFIC QUICKLY FROM A DEAD STOP. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT BOTH OF THE AIR BAG LIGHTS ILLUMINATED ON THE DASHBOARD AND THE MIDDLE CONSOLE. THE DEALER STATED THAT THE PASSENGER OCCUPANCY MODULE PRODUCED A FAULTY CODE, WHICH INDICATED THAT THE SEAT, SENSOR PAD, AND MODULE NEEDED TO BE REMOVED. THROUGH RESEARCH, THE CONTACT DISCOVERED THAT NUMEROUS OTHER CONSUMERS WERE EXPERIENCING THE SAME FAILURE. HE BELIEVES THAT THIS IS A MANUFACTURER DEFECT THAT SHOULD BE RECALLED. THE AIR BAGS WOULD NOT DEPLOY IN THE EVENT OF A CRASH. THE FAILURE MILEAGE WAS 74,000 AND CURRENT MILEAGE WAS 75,000. UPDATED 08/28/09. *LJ THE DEALER TOLD THE CONSUMER THERE WAS A LOW VOLTAGE SIGNAL SENT FROM THE BATTERY THAT CAUSED A MALFUNCTION IN THE PASSENGER AIR BAG MODULE. UPDATED 08/31/09.*JB

AIR BAG DEFAULT- TO MANY TIMES SINCE I PURCHASED MY VEHICLE BACK IN SEPTEMBER OF 2006. I HAVE TAKEN MY CAR IN 6 TIMES ON 11/06, 1/07, 9/08, 10/08, 12/08 AND 7/09. 5 TIMES TO VW OF HAYWARD AND 1 TIME TO MODESTO VW. I FEEL MY LIFE IS ALWAYS AT RISK NOT KNOWING IF MY AIRBAGS WILL WORK IF I AM IN A CAR ACCIDENT.*TR

PRIOR TO THE EVENT LISTED BELOW, WE NOTICED THAT THE CAR WAS NOT PERFORMING AS IT NORMALLY WOULD. WE WERE STOPPED AT A TRAFFIC SIGNAL, LIGHT TURNED GREEN PROCEEDED TO ACCELERATE, CAR MOVED 10 FEET, RPM WENT HIGH AND IT WAS AS IF THE CAR WAS IN NEUTRAL. HAD ENOUGH MOMENTUM TO REACH THE SIDE OF THE ROAD. PRND WAS LIT UP AND FLASHING AND THE POWER STEERING SYSTEM SYMBOL HAD ERRATIC FLASHING. TRIED PARK, NEUTRAL, REVERSE NOTHING HAPPENED. PUT THE CAR IN PARK AND SHUT OFF ENGINE. RESTARTED ENGINE AND IT ALLOWED US TO DRIVE OFF. WENT APPROXIMATELY 10 MILES DRIVING AT ABOUT 55 MPH, THOUGHT WE SEEN AN ANIMAL AND LET OFF THE ACCELERATOR. UPON TRYING TO ACCELERATE, INCIDENT DESCRIBED ABOVE HAPPENED AGAIN, THIS TIME A CHECK ENGINE LIGHT APPEARED. BEFORE CALLING THE DEALER WE DID A SEARCH AND CAME ACROSS THIS SITE. OUR VEHICLE HAD A DSG TRANSMISSION SERVICE (FOR A COST OF $286.75) AT 43,703 MILES AND THE CAR NOW HAS 71,491 MILES. THIS VEHICLE ALSO HAS A PROBLEM AT TIMES, THAT WAS REPORTED TO THE DEALER ON JUNE 5, 2007 AND NOTHING WAS DONE ABOUT IT, ON COLD START UP, PUTTING IT IN GEAR AND HAVING A VERY SEVERE JERKING, ALMOST TO THE POINT THAT IT MIGHT STALL THE ENGINE. THIS IS A 2006 VW JETTA TDI W/DSG TRANSMISSION. THE MODEL SELECTION ON FOLLOWING PAGE ONLY LISTED A GLI FOR SELECTION. *TR

WHEN I BOUGHT MY 2006 VW JETTA TDI THE DSG TRANSMISSION WORKED FINE. AT ABOUT 50,000 MILES THE TRANSMISSION HAS PROGRESSIVELY BECOME ROUGHER AND ROUGHER AND IS NOW BORDERING ON UNSAFE. WHEN I START MOVING FROM A COMPLETE STOP THE CAR JERKS BACK AND FORTH MAKING IT FRIGHTENING TO PULL OUT INTO TRAFFIC. ALSO THE CAR SLAMS INTO THE LOWER GEARS WHEN DOWNSHIFTING. SOMETIMES WHEN I PRESS THE GAS PEDAL FROM A STOP THE CAR HESITATES FOR A FEW SECONDS BEFORE SLAMMING INTO GEAR. WHEN BACKING UP IT IS HARD TO CONTROL BECAUSE OF THE SURGING. UNFORTUNATELY MY CAR IS OUT OF WARRANTY AND I CANNOT AFFORD TO SPEND $3000 TO PAY FOR VW TO FIX THIS KNOW DEFECT IN THE DSG TRANSMISSION. *TR

I HAVE A JETTA TDI 2006 DSG. THE DUAL MASS FLYWHEEL RIPPED APART. THIS TOOK OUT THE TRANSMISSION AND CAUSED THE CAR TO BE INOPERABLE. IT COASTED TO THE SIDE OF THE ROAD. THE WAS NO INDICATION OF A PROBLEM PRIOR TO FAILURE. THE FAILURE WAS SUDDEN AND CATASTROPHIC. VW REPLACED THE DUAL MASS FLYWHEEL AND TRANSMISSION. THEY TOLD ME THE OLD PART WAS GOING BACK TO GERMANY FOR INSPECTION. I HAVE NO IDEA OF WHEN IT WILL FAIL AGAIN, NEXT TIME IT MAY CAUSE A CRASH OR DEATH. I HAVE BEEN READING ABOUT THIS, AND A LOT OF DRIVERS OF THIS TYPE OF VEHICLE HAVE THIS ISSUE OF THE FLYWHEEL RIPPING APART. A FLYWHEEL RIPPING APART UNDER THE STRESS OF THE DRIVE TRAIN SHOULD BE RARE, BUT IN THIS VEHICLE IT IS NOT. IT SEEMS THE HIGH TORQUE OUTPUT OF THE DIESEL ENGINE IS CAUSING ADDITIONAL STRESS ON THE FLYWHEEL, THUS BREAKING IT APART. THERE SHOULD BE A RECALL. ALSO, THE DSG TRANSMISSION IS A HYBRID TRANS, IT OPERATES LIKE AN AUTO TRANSMISSION, BUT MECHANICALLY IS MORE LIKE A MANUAL, BUT IT IS NOT THE MANUAL VERSION WHICH IS ALSO OFFERED IN THE JETTA TDI. *TR

2006 VW JETTA TURBODIESEL WITH DSG TRANSMISSION AT 27K MILES SHIFTING UNPREDICTABLY AT HIGHWAY SPEED. REPAIRED BY DEALERSHIP, MECHANTRONIC FAILURE. FAILED AGAIN AT HIGHWAY SPEED ONE MONTH LATER, CAUSING POTENTIAL INJURY DO TO FAILURE. SIX MONTHS LATER, FLYWHEEL EXPLODES KNOCKING HOLE IN TRANSMISSION AND CAUSING THE VEHICLE LOSE ALL POWER AND THE ENGINE TO DIE. *TR

CLUTCH COMPLETELY FAILED, AS WELL AS FLYWHEEL. NO WARNING, JUST A CATASTROPHIC FAILURE. FORTUNATELY, AT A STOP LIGHT, SO NO ONE WAS INJURED. HOWEVER, IF THIS HAD HAPPENED WHILE DRIVING DOWN THE ROAD, COULD HAVE RESULTED IN DEATH. ALTHOUGH THIS FAILURE IS OCCURRING QUITE FREQUENTLY (IN CARS WITH AS LITTLE AS 400 MILES ON THEM), MANUFACTURER HAS DONE NOTHING TO REMEDY SITUATION, EITHER TO CORRECT IT OR TO COME UP WITH A NEW DESIGN. CURRENTLY AWAITING RESPONSE FROM MANUFACTURER, BUT NO RESOLUTION TO DATE. *TR

DUAL MASS FLYWHEEL FAILURE ON 2006 VW JETTA TDI WITH DSG TRANSMISSION. RESEARCH SHOWS THIS IS NOT AN ISOLATED INCIDENT. RECALLED IN OTHER COUNTRIES. DANGEROUS AND VERY EXPENSIVE SITUATION. WORTHY OF INVESTIGATION AND RECALL. THANKS *TR