2006 Volkswagen Jetta complaints

THE CAR LOOSES POWER/ ACCELERATION WHILE IM DRIVING, THE PRNDS LIGHT AND OTHERS START GOING ON AND FLASHING ON DASH. ITS IN THE DEALERSHIP AS OF MARCH 12, 2012 AND THEY ARE CHARGING ME FOR CHANGING THE METATRONIC UNIT IN THE TRANSMISSION. VW HAD A RECALL DONE ON THE 2008-2010 VW'S WITH THE DSG TRANSMISSIONS BUT NOT THE EARLIER ONES LIKE MINE 2006. I AM EXPERIENCING THE SAME THING AS THE OTHERS HAVE AND AM WONDERING WHY IS MY CAR/ YEAR IS NOT INCLUDED IN THE RECALL. I HAVE THE SAME BAD TRANSMISSION IN MY CAR THAT THEY PRODUCED IN THE LATER YEARS. I NEED TO GET MY CAR FIXED, THIS IS A BIG SAFETY ISSUE TO ME AND MY FAMILY. *KB

THE CAR DEVELOPED A RATTLE AROUND 80000 MILES, AFTER SEARCHES ON THE INTERNET I WAS SURE THE DUAL MASS FLYWHEEL (DMF)WAS FAILING. I TOOK THE CAR TO THE DEALER TODAY AND THEY CONFIRMED IT WAS THE DMF. THEY ALSO CONFIRMED THIS IS A COMMON PROBLEM AND VOLKS REFUSES TO DO ANYTHING IF CAR IS OUT OF WARRANTY. OTHER COUNTRIES ARE ALREADY MAKING VOLKS RECALL THESES CARS AND REPLACE THE DMF. THE COST OF THIS REPAIR IS $1800. THIS PROBLEM AFFECTS ABOUT 30% OF CARS AND CAN CAUSE TRANSMISSION FAILURE WHICH WILL LEAD TO ANOTHER $4200 DOLLAR REPAIR. I WOULD REALLY LIKE TO GET HELP IN GETTING VOLKS TO HELP WITH THIS REPAIR. *TR

2006 JETTA TDI SERIOUS CLATTER COMING FROM UNDERNEATH CLOSE TO TRANSMISSION. SOUNDS LIKE TIN CAN CLATTERING WHILE IN PARK OR IDLING. TOOK TO DEALERSHIP WAS TOLD IT WAS A NORMAL DIESEL CLATTER. AFTER RESEARCH AND GETTING MUCH WORSE FOUND IT IS A DEFECTIVE DSG FLYWHEEL HUNDREDS OF COMPLAINTS FOUND ONLINE ABOUT THIS. VW HAS NOW REPLACED THE DEFECTIVE FLYWHEEL WITH A NEW ONE. BUT HAS NOT RECALLED THIS PART! *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, HE NOTICED THAT THE ENGINE WAS VIBRATING ABNORMALLY. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HIM THAT THE FLYWHEEL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPLACED FOR THE FLYWHEEL. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 84,000. THE VIN WAS UNAVAILABLE.

AT INTERSTATE SPEED, I HEARD A BANG AND THE DSG TRANSMISSION DROPPED INTO FIRST GEAR. I WAS ALMOST REAR-ENDED BY OTHER MOTORISTS DUE TO THE SUDDEN DECELERATION, BUT WAS ABLE TO MAKE IT TO THE RIGHT SHOULDER. ALL TRANSMISSION INDICATOR LIGHTS WERE FLASHING ALONG WITH THE CHECK ENGINE ICON . I WAS ABLE TO LIMP HOME WITH ONLY FIRST GEAR AVAILABLE! FAULT CODE ANALYSIS SHOWS A MECHATRONIC MODULE FAILURE INSIDE THE DSG. DEALER SAID THERE WERE MANY DSG UNITS RECALLED LAST SUMMER, BUT MINE WAS NOT ON THE LIST. :( *TR

I OWN A 2006 VOLKSWAGEN JETTA TDI DIESEL (BRM ENGINE CODE). THIS CAR HAS DIED ON ME 4 TIMES NOW, 3 THREE TIMES ON THE EXPRESSWAY. IT ALWAYS HAPPENS WHEN THE ENGINE GETS TO NORMAL OPERATING TEMPERATURE AND WHEN I COME TO A STOP. IT DOES NOT HAPPEN ANY OTHER TIME. BY THE WAY IT ACTS, I ASSUMED IT WAS SOME SORT OF FUEL PROBLEM. DUE TO THE MILD WINTER HERE IN SOUTHERN INDIANA THE FUEL IS NOT GELLING. CODE READER DISPLAYS "NO CODES". I CHANGED THE FUEL FILTER. THEN THE FUEL PUMP RELAY, AND TODAY I INSTALLED A NEW FUEL PUMP. I STARTED THE CAR AND LET IT WARM UP FOR ABOUT 20 MINUTES. I DROVE IT DOWN THE ROAD, SLOWED TO A STOP AND IT DIED. IT WILL START BACK UP AFTER THE ENGINE COOLS DOWN SOME. THIS CAR WAS AT OUR LOCAL VOLKSWAGEN DEALERSHIP FOR 3 DAYS. EVEN AFTER THEY CONSULTED WITH VW TECH'S THEY COULDN'T FIGURE IT OUT. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR UNRELATED REPAIRS WHEN THE MECHANIC ADVISED THE CONTACT THAT THE DUAL MASS FLYWHEEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIR. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

THE HEADLINER BEGAN TO PULL AWAY FROM THE INSIDE ROOF AROUND THE BACK GLASS, THE VANITY LIGHTS IN BOTH THE BACK AND FRONT, AND IS NOW HANGING DOWN OBSTRUCTING THE VIEW FROM THE REAR VIEW MIRROR. VW SERVICE MANAGER CHECKED TO SEE IF VW WOULD COVER COST TO FIX THE PROBLEM, AS THE CAR WAS STILL UNDER THE ORIGINAL WARRANTY WHEN IT BEGAN TO COME DOWN, AND THEY REFUSED. IT IS CLEARLY A MANUFACTURING DEFECT, AS THE SERVICE MANAGER DID SUGGEST I CONTACT VW MYSELF BECAUSE HE HAD SEEN THIS SAME THING IN QUITE A FEW OF THE SAME MODEL CARS. THE DEFECT IS A SAFETY ISSUE DUE TO THE BLOCKING OF THE DRIVER'S VIEW. *TR

I WAS INFORMED BY NIELLO VOLKSWAGEN WHEN I TOOK MY CAR IN TO BE SERVICED FOR 2 RECALLS THAT I HAD A MAJOR OIL LEAK. I THEN BROUGHT MY VEHICLE IN TO SACRAMENTO EUROPEAN ON 2/1/12 FOR AN OIL CHANGE AND TO FIND OUT WHAT WAS THE CAUSE OF MY OIL LEAK. I WAS INFORMED BY THEM THAT I DID NOT HAVE AN OIL LEAK, BUT A TRANSMISSION LEAK. THEY STATED THAT THERE WAS A TECHNICAL SERVICE BULLETIN OUT THAT THIS IS A KNOWN PROBLEM THAT THE SEAL THAT JOINS THE 2 TRANSMISSION COMPONENTS IS LEAKING. CLEARLY SINCE THERE IS A SERVICE BULLETIN OUT THAT THIS IS A KNOWN PROBLEM, THE TRANSMISSIONS THAT THEY HAVE IN THESE VOLKSWAGEN CARS ARE DEFECTIVE AND NEED TO BE REPLACED. MY TRANSMISSION IS SLIPPING WHEN IT SHIFTS INTO SECOND AND THIRD GEARS AND ALSO WHEN I BRAKE. *KB

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHEN THE CONTACT STARTED THE VEHICLE, SHE HEARD A NOISE SIMILAR TO SOMETHING MOVING INSIDE THE ENGINE AFTER THE VEHICLE BEGAN VIOLENTLY SHAKING AND JERKING. WHEN SHE ATTEMPTED TO PLACE THE VEHICLE INTO GEAR, THE ENGINE RPMS WOULD ALSO INCREASE. THE VEHICLE WAS CAREFULLY DRIVEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE DUAL MASS FLY WHEEL HAD A HOLE IN IT WHICH CAUSED THE METAL TO FRACTURE THE BELL HOUSING AND DAMAGE THE TRANSMISSION. THE MECHANIC REPLACED THE FLY WHEEL AND INFORMED HER TO REPLACE THE TRANSMISSION. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 67,000.

WHILE TRAVELING IN RAIN AT 70 MPH WITH CRUISE CONTROL ENGAGED THE SPEEDOMETER DROPPED TO ZERO, THE BRAKE AND ABS/ESP WARNING LIGHT CAME ON AND THERE WHERE THREE CHIMES. A SECOND LATER ALL WENT BACK TO NORMAL. THIS HAPPENED 6 TIMES THAT DAY, AND HAS HAPPENED AT IRREGULAR INTERVALS SINCE AT LEAST 7 TIMES. THERE IS NO CORRELATION ANYMORE BETWEEN WET AND DRY CONDITIONS, CRUISE CONTROL DOES NOT HAVE TO BE ENGAGED, I DO NOT HAVE TO BE TRAVELING AT A CONSTANT SPEED. THERE ARE NO TROUBLE CODES STORED IN THE VEHICLES COMPUTER, AND THE LOCAL DEALERSHIP IS UNABLE TO HELP. *TR

SEAT BELT WILL NOT LONGER RETRACT INTO TENSIONING DEVICE!!!!! *TR

I STARTED TO NOTICE A RATTLING NOISE PRIOR TO A DMF FLYWHEEL FAILURE. THE FAILURE CAUSED TO VEHICLE TO COME TO AN UNCONTROLLED OUT OF CONTROL STOP AT A 68 MPH SPEED. THIS PROBLEM IS KNOWN BY VW AMERICA AND HAS BEEN A UNDER A RECALL ORDER IN THE UK. VW HAS A REPAIR KIT FOR THIS KNOWN PROBLEM WITH A 1,600.00 INSTILLATION COST AND HAS FAILED TO CONTACT OWNERS AND ALERT THEM TO THE LIFE THREATENING RESULT OF THIS KNOWN CATASTROPHIC FAILURE. ALSO, A CATASTROPHIC FAILURE WILL RESULT IS COMPLETE TRANSMISSION REPLACEMENT (+8,000.00) AND POSSIBLY THE INJURY OR DEATH OF THE OCCUPANTS DUE TO AN UNCONTROLLED SLIDE AND DRIFT AND HIGH SPEED. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHIFT OUT OF FIRST GEAR. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THEY WERE IN THE PROCESS OF DIAGNOSING THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 66,783. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE REAR TRUNK WOULD NOT REMAIN LOCKED AND WOULD PERIODICALLY FLY OPEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 60,000.

BOUGHT NEW VW JETTA SEDAN ON 08/17/06. ON 05/13/10 TOOK THE CAR TO THE DEALER BECAUSE OF CAR DECELERATING WHILE DRIVING I.E. DROPPING IN SECONDS FROM 60 MILES TO 20 MILES. IT WAS TAKEN TO THE DEALER MULTIPLE TIMES FOR THE SAME PROBLEM. DEALER ANSWER "UNABLE TO REPLICATE PROBLEM" UNTIL WARRANTY OF FOUR YEARS EXPIRED. THE PROBLEM CONTINUES EVEN AFTER THE CARBON ACCUMULATED ON THE THROTTLE WAS CLEANED AND THE FUEL PUMP WAS REPLACED. DUE TO UNSAFE TO DRIVE, REQUESTED FOR THE DEALER TO BUY THE CAR BACK AS A LEMON. THE DEALER REFUSES BECAUSE THE FOUR YR WARRANTY IS OVER. OTHER PROBLEMS EXPERIENCED WITH THIS VEHICLE DURING THIS PERIOD: AIR BAGS LIGHTS GOING OFF, AIR BAG COVER FALLING OFF, TRUNK OPENING ON ITS OWN WHILE DRIVING, RAIN WATER LEAKING INSIDE THE LINING OF THE CAR, SCREWS COMING OFF A DOOR PANEL, DOORS FALLING OFF THE HINGES, EMERGENCY SWITCH FALLING INSIDE PANEL, FUEL CAP NOT LOCKING, RECALLS. DEALER RECOMMENDING TO REPLACE THE STEERING WHEEL COLUMN FOR 2,340.

WHILE TRAVELING AT A SPEED OF 45MPH AT 5:40PM ON 12/15/11 MY '06 JETTA TDI SUDDENLY STOPPED DRIVING. IT SOUNDED AS THOUGH THE CAR HAD SLIPPED INTO NEUTRAL. THIS HAPPENED ON HWY 83 IN DELAFIELD. HWY 83 IS ONE OF THE BUSIEST HIGHWAYS IN WISCONSIN. WE WERE UNABLE TO PULL OUT OF TRAFFIC AND WERE STRANDED IN THE LEFT OF THE 2 LANES. OUR HAZARDS WERE TURNED ON AS TRAFFIC STARTED TO PULL AROUND US WE WERE CALLING AAA FOR A TOW. WITHIN 5 MINUTES OF THE STALL WE CAUSED A 5 CAR PILE UP. OF THE 5 CARS, 2 WERE TOTALED. 2 OTHER HAD SIGNIFICANT DAMAGE. ONE HAD MINOR. WE SUSTAINED NO DAMAGE AS WE WERE NOT HIT. CAR WAS TOWED TO A TRANSMISSION REPAIR SHOP WHERE THEY FOUND THE DUAL MASS FLYWHEEL TO HAVE CAUSED THE FAILURE. $4,500 - $5,000 ESTIMATED REPAIR FROM THAT SHOP. $5000 "MINIMUM" FROM HALL IMPORTS OF BROOKFIELD. HOW MANY MORE PEOPLE'S LIVES WILL YOU ALLOW TO BE JEOPARDIZED BEFORE YOU DO SOMETHING ABOUT THIS TRANSMISSION PROBLEM? I AM HORRIFIED THAT I CAUSED AN ACCIDENT OF THIS SIZE! VW STOPPED MAKING TDI'S AFTER 2006...WHY? DID THEY REALIZE THERE WAS A PROBLEM? ARE YOU GOING TO WAIT UNTIL SOMEONE IS KILLED BEFORE YOU TAKE ACTION? I AM GOING TO RESEARCH CLASS ACTION LAWSUITS TO SEE IF THIS GROUP OF VW OWNERS HAS A CASE AGAINST VW. AND WHAT IS THE NHTSA'S RESPONSIBILITY TO TAKE THIS FURTHER THAN JUST ACCEPTING COMPLAINTS? *TR

THE TRANSMISSION IS SLIPPING BETWEEN 3 AND 4 GEAR AND BETWEEN 4 AND 5 GEAR. *TR

VEHICLE STOPPED MOVING AFTER STOPPING AT THE TRAFFIC LIGHT. ENGINE STARTS BUT CAR WILL NOT MOVE . SHIFT POSITION INDICATOR FLASHING. VEHICLES TOWED TO THE VOLKSWAGEN GARAGE. NEEDS MECHATRONICS TRANSMISSION MODULE REPLACED . ALMOST $2300 REPAIR . *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE STEERING WHEEL WOULD BECOME INOPERABLE WHILE DRIVING. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 66,000.

DSG TRANSMISSION STUTTERS (JERKS) FROM A STOP OR TO A STOP. IT ALSO OCCURS LESS NOTICEABLY AT HIGHWAY SPEEDS. THE LURCHES FROM A STOP FEELS LIKE IT IS GOING TO LEAVE THE CAR DEAD IN THE MIDDLE OF THE ROAD. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE BRAKE LIGHT WOULD CONSISTENTLY STAY ON EVEN WHEN THE IGNITION WAS TURNED OFF, CAUSING THE BATTERY TO DRAIN. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 104, 000.

AT 64K MILES, THE CHECK ENGINE LIGHT CAME ON AND MY ENGINE STARTED STRUGGLING TO DRIVE EVEN AT A SNAILS PACE. THE TIMING CHAIN WAS THE ISSUE AND WAS REPLACED FOR APPROXIMATELY $2500. APPROXIMATELY 10 MONTHS LATER, THE ENGINE LIGHT CAME ON AGAIN, SAME ISSUE. ONCE AGAIN, IT WAS REPLACED (THIS TIME UNDER WARRANTY). *TT

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THERE WAS A LOUD RATTLING NOISE COMING FROM THE HOOD AREA. THE CONTACT RESEARCHED AND FOUND THAT THE DUAL MASS FLY WHEEL COULD POSSIBLY BE DEFECTIVE. THE DEALER WAS MADE AWARE OF THE DEFECT, BUT DID NOT DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000 AND THE CURRENT MILEAGE WAS 94,000.

ORIGINALLY PURCHASED IN 2007. COMPLAINED ABOUT THE CAR - WHEN SHIFTING IT WOULD EXCEL AND JERK AFTER SHIFTING. THEN AS TIME WENT ON I WOULD BE DRIVING AND THE JETTA WOULD HESITATE AS IF A FUEL WAS NOT GETTING TO THE ENGINE. I TOOK MY CAR IN FOR REGULAR OIL CHANGES AND REGULAR MAINTENANCE. I LIVE IN A RURAL AREA AND DRIVE JUST HIGHWAY MILES AND HAVE APPROX. 121,000 MILES ON IT. I PURCHASED THIS VW AS I ANTICIPATED IT TO LAST A LOT LONGER THAN A REGULAR VEHICLE. WHEN I TOOK IT IN FOR THE LAST OIL CHANGE AND THE INTERMITTENT HESITATION WAS REALLY BAD I WAS TOLD IT WOULD COST ME ANYWHERE FROM $7500 TO $8000 TO FIX. AND I STILL OWED $9000! I ASKED IF IT WAS COVERED UNDER THE WARRANTY. OF COURSE THE WARRANTY EXPIRED IN JULY...BUT NOTHING WAS FOUND ALL THE PREVIOUS TIMES I HAD BROUGHT MY CAR IN FOR SERVICE. AND VW'S REGIONAL REP AND HQ WAS CONTACTED AND BOTH WERE APOLOGETIC THAT VW COULD DO NOTHING ABOUT FIXING MY CAR. LOOKING AT THE INTERNET - I FOUND THAT NATIONWIDE AND UP TO CANADA OTHER INDIVIDUALS WITH LESS MILEAGE HAVE HAD THE SAME ISSUE AND INDIVIDUALS WERE SEEKING ARBITRATION AGAINST VW. I UNDERSTAND VW DOES NOT HAVE A RECALL OR ANYTHING CONSIDERING THIS IS A RECURRING PROBLEM. ALL THEY CAN OFFER IS $1000 TO BUY ANOTHER VW!!! THEIR NERVE! TOTALLY DISHEARTEN WITH VW. *TR

THE WIRING HARNESS THAT RUNS FROM THE ENGINE COMPARTMENT TO THE DRIVES SIDE DOOR HAS CRACKING AND BROKEN WIRES. THE SERVICE DEPARTMENT STATES IT NEEDS TO BE REPLACED. THEY SUGGEST IT IS NOT AN ISOLATED INCIDENT. WIRES WITH BROKEN INSULATION AFTER 6 YEARS IN A DOOR HARNESS THAT IS DESIGNED TO OPEN AND CLOSE MULTIPLE TIMES DAILY SEEMS TO BE A SIGNIFICANT SAFETY ISSUE. ARE THERE OTHER WIRE ISSUES? IS THE WIRE (CAR BUILT IN MEXICO) AN ISSUE OVERALL?

VOLKSWAGEN JETTA 2006 HEADLINER FABRIC FAILURE. SEPARATION OF HEADLINER FABRIC FROM HEADLINER, CREATING A VISIBILITY OBSTRUCTION. POSSIBLY A DANGER TO THE DRIVERS VISIBILITY. CLEAR MANUFACTURES DEFECT DUE TO THE AMOUNT OF RESEARCH DONE ONLINE. A SUBSTANTIAL AMOUNT OF OWNERS HAVE THE SAME COMPLAINT. I HAVE CONTACTED VOLKSWAGEN DIRECTLY. THEY HAVE YET TO INITIATE A MASS RECALL ON 2006 VOLKSWAGEN JETTA HEADLINERS, DESPITE THE NUMEROUS COMPLAINTS BROUGHT TO LIGHT BY OWNERS. *KB

CLUTCH BROKE IN THE CAR IT IS A KNOW DEFECT WITH THE TYPE CLUTCH'S THIS CAR WAS BUILT WITH VOLKSWAGEN IS AWARE OF THE DEFECTS AND ISSUED A TSB IN 2007 1 YEAR AFTER MY CAR WAS BUILT BUT THE SOLD THE CAR AS A CERTIFIED PRE-OWNED VW WITH THE KNOWN DEFECTIVE PARTS. THE PARTS NOW BROKE AND VW IS REFUSING TO REPAIR THE DEFECTIVE PARTS. THERE ARE THOUSAND OF VW JETTAS AFFECTED BY THESE BAD PARTS. *TT

I PURCHASED A 2006 VW JETTA IN LATE 2008, EARLY 2009. THE CAR WAS BRAND NEW AND SAT IN THE SHOWROOM FOR TWO YEARS. AFTER OF DRIVING FOR 1 1/2 YEARS, THE TIRE SIDEWALLS BEGAN TO SEPARATE. CONTINENTAL MADE THE ADJUSTMENT AND I REPLACED THE TIRES THINKING THAT SITTING IN A SHOWROOM FOR THAT MUCH TIME, THEY PROBABLY DRY ROTTED. TODAY, I AM HAVING TO REPLACE ALL FOUR TIRES AGAIN AFTER 13 MONTHS FOR THE SAME REASON, SIDEWALL SEPARATION. READING THE COMPLAINTS ON THIS SITE AND OTHERS, IT APPEARS THERE IS A SERIOUS ISSUE HERE FOR SIDEWALLS ON CONTINENTAL TIRES. THE SIZE IS 225/45R 17. THE TIRES ARE CONTIPRO CONTACT. *TR

THE INSTRUMENT CLUSTER, GEAR INDICATOR, ODOMETER, RADIO, OUTSIDE TEMPERATURE, COMPASS, MPG, SPEED MONITOR AND CONTROLS ALL THE LIGHTING FEATURES ON CAR HAS FAILED. ACCORDING TO THE SERVICE MANAGER I DEAL WITH HE TOLD ME THAT HE HAS SEEN MANY OF THESE CLUSTERS FAIL IN 2005,06 JETTA'S AND PASSAT'S. THE COST TO REPLACE IS $650+ I FEEL THIS IS A KNOWN MANUFACTURING DEFECT THAT VW DOES NOT WANT THE PUBLIC TO KNOW ABOUT. I CAN'T READ MY ODOMETER OR EVEN READ WHAT GEAR I AM IN. IT IS A SAFETY CONCERN. CAN YOU HELP WITH THIS. I FEEL SORRY FOR ALL THE OTHER VW OWNERS THAT HAVE A FAILED INSTRUMENT CLUSTER. *TT

MY WIFE WAS GETTING READY TO GO TO WORK, WHEN SHE OPENED THE DOOR OF OUR JETTA, SMOKE STARTED COMING OUT FROM UNDER THE DRIVERS FRONT SEAT. SHE BENT DOWN TO SEE WHERE IT WAS COMING FROM BUT ALL SHE SAW WAS A RED GLOW COMING FROM UNDER THE SEAT. THIS THING MUST HAVE SET AND SMOLDER ALL NIGHT BECAUSE SHE DIDN'T UNLOCK THE CAR THAT MORNING BECAUSE SHE HAD LEFT THE CAR UNLOCKED DO TO WHERE WE LIVE NO ONE IS AROUND FOR MILES. INSPECTOR SAID THAT IT WAS FAULT OF (VW) THE SEAT, BUT IT WILL COST TO MUCH TO SUE VW. WE ALMOST LOST OUR HOME, GARAGE AND OUR LIVES. WE HAD THE SEAT RECALL REPAIRED BUT I THINK THE REPAIR WAS NEVER MADE, THE VIDEO IS ON YOUTUBE UNDER "JETTA FIRE". ONE OF MY QUESTIONS IS WHY DIDN'T A FUSE BLOW BEFORE THE CAR BURNT TO THE GROUND. *KB

DRIVER FRONT SEAT BELT FAILED, RE-TRACTOR LOCKED, AND THE SEAT BELT WILL NOT PULL OUT OR RETRACT. *KB

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT FAILED TO EXTEND. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

MY CARS TRANSMISSION DID NOT RESPOND TO THE ACCELERATOR INPUT- THE CAR SEEMED TO BE STUCK IN NEUTRAL BUT THE INDICATOR WAS IN THE DRIVE POSITION - THIS HAPPENED WHILE AT SPEED AND I HAD TO MANEUVER OUT OF TRAFFIC TO GET OFF TO THE SIDE OF THE ROAD - I WAS ALMOST HIT AS I COULD NOT ACCELERATE THE CAR BECAUSE OF THIS PROBLEM. THE CAR NEEDED TO BE TOWED AWAY FOR REPAIR. *TR

VEHICLE MANUAL TRANSMISSION FAILURE, PUSHED CLUTCH FOOT PEDAL CLEAR TO FLOOR, WOULD NOT SPRING BACK. ON A BUSY ROAD, ABLE TO PULL OFF THE ROAD. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED WHEN THE ELECTRIC STEERING WHEEL FAILED THE VEHICLE BECAME UNCONTROLLABLE AND STALLED. THE FAILURE OCCURRED ON A DAILY BASIS. THE VEHICLE WAS RENDERED UNDRIVEABLE. A WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THERE WERE NO RELATED RECALLS. THE MANUFACTURER WAS NOTIFIED AND STATED THE WARRANTY EXPIRED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 36,000 AND THE CURRENT MILEAGE WAS 103,000.

THE DUAL MASS FLYWHEEL HAS FAILED ON MY CAR. IF THIS WOULD HAVE HAPPENED AT HIGH SPEED IT COULD CAUSE THE TRANSMISSION AND ENGINE TO SEIZE THUS LOCKING THE FRONT WHEELS AND CAUSING LOSS OF CONTROL/SERIOUS VEHICLE DAMAGE. THERE IS WIDESPREAD INFORMATION ABOUT THIS ON THE INTERNET DOCUMENTING THE FAILURES, SOME OF WHICH HAVE DESTROYED THE VEHICLES TRANSMISSION AND ENGINE IN THE PROCESS. VOLKSWAGEN OF AMERICA IS AWARE OF THIS PROBLEM AND HASN'T ISSUED A RECALL . I AM FORCED TO REPLACE THIS PART MYSELF SINCE VW WILL NOT COVER THIS PART DESPITE THE FACT THAT THEY NOW HAVE AN UPGRADED REPLACEMENT PART AS THEY KNOW THE ORIGINAL IS DEFECTIVE. CST TO REPAIR AT DEALERSHIP $2000. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 5 MPH THE CONTACT HEARD A GRINDING NOISE. THE SOUND COULD BE HEARD AT DIFFERENT SPEEDS INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THE TRANSMISSION HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 09/21/11 *BF THE CONSUMER STATED THE NEW TRANSMISSION ARRIVED IN TWO WEEKS AND WAS REPLACED. UPDATED 10/05/11

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING AT HIGHWAY SPEEDS, THE CLUTCH SUDDENLY FAILED AND DEPRESSED STRAIGHT TO THE FLOOR. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THEY ADVISED THE CONTACT THAT THE CLUTCH NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 63,000. THE VIN WAS UNAVILABLE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA DIESEL. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL PUMP WAS MALFUNCTIONING AND CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO STATED THAT THE FUEL PUMP HAD METAL SHAVINGS INSIDE OF IT THAT WERE CLOGGING THE FUEL INJECTOR. THE MECHANIC ALSO STATED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE CLEANED AND THE HIGH PRESSURE FUEL PUMP AND INJECTORS NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER AND FILED A COMPLAINT. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS, BUT THEY WERE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE STALLING COULD LEAD TO A CRASH. THE FAILURE MILEAGE WAS 55,000.

THE DUAL MASS FLYWHEEL HAS FAILED ON MY CAR. IF THIS WOULD HAVE HAPPENED AT HIGH SPEED IT COULD CAUSE THE TRANSMISSION AND ENGINE TO SEIZE THUS LOCKING THE FRONT WHEELS AND CAUSING LOSS OF CONTROL/SERIOUS VEHICLE DAMAGE. THERE IS WIDESPREAD INFORMATION ABOUT THIS ON THE INTERNET DOCUMENTING THE FAILURES, SOME OF WHICH HAVE DESTROYED THE VEHICLES TRANSMISSION AND ENGINE IN THE PROCESS. VOLKSWAGEN OF AMERICA IS AWARE OF THIS PROBLEM AND HASN'T ISSUED A RECALL . I AM FORCED TO REPLACE THIS PART MYSELF SINCE VW WILL NOT COVER THIS PART DESPITE THE FACT THAT THEY NOW HAVE AN UPGRADED REPLACEMENT PART AS THEY KNOW THE ORIGINAL IS DEFECTIVE. CST TO REPAIR AT DEALERSHIP $1600. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THE WINDOWS AND DOORS FAILED TO UNLOCK, AND THE WINDOWS WOULD NOT ROLL UP OR DOWN. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST THAT INDICATED THE FAILURE WAS CAUSED BY THE DRIVERS DOOR WIRING HARNESS. THE WIRES WERE TO SHORT AND CAUSED THE WIRING RUBBER BOOT, DOOR LOCKS, AND WINDOWS TO FAIL. THE DEALER REPLACED THE DRIVER AND PASSENGER DOOR WIRING HARNESS. THE FAILURE MILEAGE WAS 76,000 AND THE CURRENT MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED AFTER HAVING HER TRANSMISSION FLUSHED BY THE DEALER, THEY NOTIFIED HER THAT THE VEHICLE WOULD NO LONGER SHIFT INTO REVERSE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HER THAT SHE WOULD NEED TO REPLACE THE TRANSMISSION SINCE IT WAS FAULTY. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 90,000.

THE ENGINE IN OUR 2006 TDI DSG BEGAN TO EXHIBIT ROUGH IDLING. AT A CERTAIN POINT IT BECAME EVIDENT SOMETHING WAS WRONG. THE VEHICLE HAS ALWAYS BEEN SERVICED BY A VW DEALERSHIP AT THE SPECIFIED INTERVALS (I CALL THEM THE $400 OIL CHANGES). I COULD HEAR WHAT SOUNDED LIKE AN INTAKE VALVE POPPING AND COULD FEEL A PULSATION IN THE TURBO INTAKE HOSE. I CHECKED ON SOME OF THE FORUMS AND WAS SHOCKED TO LEARN OF THE EARLY CAMSHAFT FAILURE PROBLEM COMMON TO THE PD ENGINES. IT SEEMS THAT VW NARROWED UP THE INTAKE AND EXHAUST CAM LOBES BY ABOUT 30% TO MAKE ROOM FOR THE INJECTOR LOBE, AND TRIED TO COMPENSATE FOR THIS INADEQUATE DESIGN BY MANDATING "SPECIAL" OIL (WHICH I CAN ONLY HOPE OUR DEALER USED EACH TIME THE OIL WAS CHANGED). IT TURNS OUT THOUGH, THAT A CRITICAL CAN WEAR ADDITIVE IN THIS OIL, ZDDP, IN SUFFICIENT QUANTITIES CAN CAUSE EARLY FAILURE OF THE CATALYTIC CONVERTER (AN ITEM WHICH HAS A LONGER WARRANTY PERIOD THAN THE ENGINE). IT SEEMS THAT THE ZDDP ONLY EXISTS IN SUFFICIENT QUANTITY IN VW "SPECIAL" OIL TO GET THROUGH THE ENGINE WARRANTY PERIOD, WHILE AT THE SAME TIME PROTECTING THE CONVERTER FROM WARRANTY FAILURE. I BOUGHT AN AFTER MARKET CAM KIT AND INSTALLED IT MYSELF, SAVING NEARLY $3000 IN THE PROCESS. SINCE THEN WE'VE PUT ANOTHER 60K MILES, USING MOBIL TD TRUCK 5W40 OIL... SO FAR SO GOOD. I THINK THIS WHOLE SITUATION IS DISGRACEFUL AT BEST AND VW SHOULD BE RESPONSIBLE FOR ALL PD CAMSHAFT FAILURES TO A PERIOD SIGNIFICANTLY LONGER THAN THE 80,000 KM WARRANTY. THE PRIMARY R

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY STALL WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WOULD ALSO INTERMITTENTLY HESITATE TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 66,000.

ELECTRICAL HARNESS IN PASSENGER SIDE DOOR LEADS TO INTERMITTENT ELECTRICAL FAILURES THAT CAN LEAD TO SAFETY ISSUES. *TR

I HAVE A 2006.5 JETTA TDI WITH A DSG TRANSMISSION AND 130,000 MILES. MY CAR HAS HAD ALL TRANSMISSION SERVICE COMPLETED AT THE DEALERSHIP. MY INCIDENT BEGAN AT A RED LIGHT. WHEN I WENT TO HIT THE GAS, MY CAR DID NOT MOVE. THE ENGINE REVVED BUT NOTHING. I TURNED THE CAR OFF. ONCE I STARTED IT AGAIN, I WAS ABLE TO GET TO MY DESTINATION. WHEN I WENT TO LEAVE, IT DID IT AGAIN AT A STOP SIGN. I WAS AGAIN ABLE TO TURN OFF MY CAR AND RESTART. IT MOVED APPROXIMATELY 20 FT INTO INTERSECTION, THEN NOTHING. I TURNED IF OFF TWO MORE TIMES AND FINALLY MADE IT THROUGH INTERSECTION (APPROXIMATELY 40 FT THROUGH). WHILE IN DRIVE (GOING APPROX. 20 MPH), THE CAR SHIFTED INTO NEUTRAL, ALL LIGHTS ON INSTRUMENT PANEL WERE BLINKING, JUST AS BEFORE. I SAT FOR A FEW MINUTES, THEN I TRIED TO DRIVE HOME AGAIN IN THE MANUAL GEAR SHIFTING MODE. I MADE IT APPROXIMATELY 1/2 MILE WHEN IT SHIFTED INTO NEUTRAL AGAIN (GOING APPROX. 40 MPH) AND LIGHTS BLINKING. I HAD TO CALL A TOW TRUCK TO TAKE ME TO THE DEALERSHIP. HEAVEN FORBID I HAD BEEN GOING FASTER AND THIS HAPPENED OR SOMEONE HAD HIT ME IN THE INTERSECTION AS I TRIED TO TURN ACROSS TRAFFIC. I UNDERSTAND THERE IS A RECALL FOR 2007-2009 TRANSMISSIONS AND EXTENDED WARRANTY. I SUGGEST EXPANDING THIS TO INCLUDE ALL MODELS WITH DSG TRANSMISSIONS SINCE THEY OBVIOUSLY HAVE DANGEROUS RELIABILITY PROBLEMS. *TR

2006 VOLKSWAGEN JETTA COOLING FAN STOPPED WORKING AT JUST OVER 50K MILES AND 2 MONTHS OUT OF WARRANTY. VW OF AMERICA WILL NOT COVER THIS (AS IT IT OUT OF WARRANTY). IT SEEMS TO BE A COMMON PROBLEM FOR MANY CUSTOMERS. *TR

OUR VW HAS A DSG TRANSMISSION. WE HAVE HEARD A STRANGE SOUND SINCE ABOUT OCTOBER, 2010. IT WAS FINALLY DIAGNOSED AS A DUAL MASS FLYWHEEL FAILURE. THE DEALER REFUSED TO DO ANYTHING. VW FINALLY AGREED TO PAY FOR 1/2 THE REPAIR PARTS AND WE HAD TO PAY ALL OF THE LABOR. WE OBTAINED DATA ON THE INTERNET THAT DUE TO PROBLEMS WITH THIS DSG TRANSMISSION, VW HAD EXTENDED THE WARRANTY ON ALL DSG OR S-TRONIC TRANSMISSIONS FOR 10 YEARS/100K MILES. THE DEALER TOLD US WE WERE WRONG! WE BELIEVE THAT WE HAVE A VW WITH A DEFECTIVE TRANSMISSION AND ASK THAT YOU REQUIRE VW TO MAKE THE REPAIRS UNDER WARRANTY AND THAT YOU, PLEASE, ADD THIS COMPLAINT TO THOSE THAT YOU MAY ALREADY HAVE.

THERE IS A DISTINCT DELAY WHEN TAKING THE CAR FROM PARK TO DRIVE OR REVERSE WHICH CAUSES VERY HARSH ENGAGEMENT. IT MAKES IT A CHALLENGE TO SAFELY MANEUVER THE CAR IN CLOSE QUARTERS. SITTING AT A RED LIGHT THE CAR WILL LURCH FORWARD WHEN LETTING OFF THE BRAKE AND HITTING THE THROTTLE. THIS HAPPENS AT START UP AND AT RUNNING TEMPERATURE. WHEN THIS FIRST BEGAN TO HAPPEN THE PROBLEM WOULD GO AWAY AFTER A TRANSMISSION SERVICE BUT WOULD SOON RETURN. NOW IT IS PRESENT AT ALL TIMES WHETHER THE SERVICE HAS BEEN PERFORMED OR NOT. THE PROBLEM ONLY OCCURS WHEN THE CAR IS AT A STOP AND YOU START TO MOVE THE VEHICLE, FORWARD OR REVERSE. ALL OTHER SHIFTING RESPONSES SEEM TO BE NORMAL. AGAIN THE PROBLEM ONLY EXISTS WHEN STARTING FROM A COMPLETE STOP. FROM WHAT I CAN READ THIS SEEMS TO BE A RECURRING PROBLEM WITH THE DSG TRANSMISSION. *TR