2006 Volkswagen Jetta complaints

I WENT TO STOP AT A LIGHT PUSHED IN MY CLUTCH AND WHEN IT GOT TO THE FLOOR IT CLICKED EVER SO QUIETLY AND WOULDN'T RETURN TO ENGAGED POSITION. I PULLED THE CLUTCH PEDAL BACK UP OFF THE FLOOR AND NOW IT CAN'T BE PUSHED MORE THAN 3/4 OF THE WAY TO THE FLOOR AND IF YOU TRY WHILE THE ENGINE IS RUNNING YOU GET AN AWFUL GRINDING NOISE. CLUTCH PLATE FLEW APART. *JB

CLUTCH FLYWHEEL PROBLEMS WITH MY 2006 JETTA TDI. LEFT ME STRANDED ON HIGHWAY WITH ONLY 41 K MILES ON IT. THE VEHICLE IS IN THE SHOP AND UNDER REVIEW. I'M CONCERNED OVER THE NUMBER OF CLUTCH FAILURES AT SUCH LOW MILEAGE. I AM VERY GENTLE WITH MY CLUTCH. *TR

VEHICLE FAILED TO START ON MULTIPLE OCCASIONS DUE TO INSUFFICIENT BATTERY CHARGE. OWNER OBSERVED BRAKE LIGHTS INCLUDING CHMSL WOULD COME ON INDEPENDENTLY WHILE THE VEHICLE WAS PARKED, SHUT OFF, AND UNOCCUPIED WITH NO BRAKE PEDAL APPLICATION. NO OTHER LIGHTS WERE ON AT THE SAME TIME INTERIOR, HEADLIGHTS, TURN SIGNALS WERE ON. THIS WAS PRESUMABLY THE CAUSE OF THE BATTERY DRAIN ISSUE. ON MULTIPLE OCCASIONS AFTER JUMP STARTING THE VEHICLE OWNER OBSERVED LOSS OF POWER WHILE TRYING TO ACCELERATE. INPUT TO THE ACCELERATOR WAS MOMENTARILY INEFFECTIVE AND HAD TROUBLE MAINTAINING HIGHWAY SPEED. THE ENGINE DID NOT STALL AND NO FAULT CODES WERE GENERATED. POWER WAS RESTORED AFTER A FEW SECONDS, BUT THE SYMPTOMS WOULD OCCUR SEVERAL TIMES DURING A DRIVE. VEHICLE WAS BROUGHT TO A VOLKSWAGEN DEALERSHIP SERVICE FACILITY (LINDSAY VW IN STERLING, VA) ON 7/13/2007. THE OWNER DESCRIBED THE ABOVE SYMPTOMS TO THE SERVICE ADVISOR. THE OWNER WAS CALLED LATER ON THE SAME DATE AND TOLD THAT THE DEALERSHIP COULD NOT VERIFY THE CLAIM AND THAT NO REPAIR WAS PERFORMED. TOOK CAR TO A DIFFERENT DEALER (FAIRFAX VW) WHO CORRECTLY DIAGNOSED THE PROBLEM AS A FAULTY BRAKE LIGHT SWITCH. THE REPAIR PART IS THE SAME PART USED IN THE RECALL. THE CAR WAS FIXED UNDER WARRANTY AND THE REPAIR INVOICE EVEN STATES "RECALL" ON IT BUT THE DEALER SAYS MY CAR IS NOT PART OF THE RECALL AND I NEVER RECEIVED NOTIFICATION.

AT 65 MPH THERE WAS A BRIEF LOCKUP OF THE FRONT WHEELS, STALLING OF THE ENGINE FOLLOWED BY A LOUD MECHANICAL GRINDING NOISE. STOPPED VEHICLE, POPPED HOOD, NOTED ENGINE TO SHAKE VIOLENTLY TO THE EXTENT THAT THE OIL DIPSTICK CAME LOOSE. BROUGHT VEHICLE TO DEALERSHIP. INFORMED BY SERVICE THAT FAILURE IS DUE TO DISINTEGRATION OF THE DUAL MASS FLYWHEEL LOCATED BETWEEN THE ENGINE AND THE AUTOMATIC TRANSMISSION. DEBRIS FROM THE FLYWHEEL LEAD TO DESTRUCTION OF THE TRANSMISSION HOUSING. LATER, WHEN TALKING TO A MECHANIC, FOUND OUT THAT THIS IS THE SECOND JETTA WITH THE DSG AUTOMATIC TRANSMISSION THAT HAD A DMF FAILURE IN ADDITION TO THREE CATASTROPHIC DMF FAILURES ON MANUAL TRANSMISSION JETTAS). AS THIS HAS THE POTENTIAL TO LEAD TO COMPLETE LOCKUP OF THE FRONT WHEELS AT HIGHWAY SPEEDS WITH POTENTIALLY DIRE CONSEQUENCES, I BELIEVE THAT THIS IS A SAFETY RELEVANT ISSUE THAT MIGHT WARRANT BEING ADDRESSED BY NHTSA. *AK

CONTIPRO TIRES. THREE OF THE TIRES ON MY NEW CAR HAVE HAD SIDEWALLS BULGES. THE FIRST I FEEL WAS MY FAULT. I DROVE ON THE TIRE THAT HAD LOW TIRE PRESSURE. BUT THE TWO OTHER TIRES HAVE NOT HAD ANY COMPROMISING SITUATIONS. EACH TIRE HAD LESS THAN 5,000 MILES ON IT. CONTINENTAL TIRE WARRANTY IS A JOKE, THEY HAVE BEEN NO ASSISTANCE. I HAVE NEVER HAD TIRES FAIL ME, I HAVE ALWAYS JUST WORN THEM OUT. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO DECELERATE. SHE SHIFTED INTO NEUTRAL IN ORDER TO SLOW DOWN THE VEHICLE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 14,000 AND FAILURE MILEAGE WAS 12,000.

I HAVE A 2006 VW JETTA TDI WITH AN AUTOMATIC. THE SPEEDOMETER READS 5 MPH FAST AND THEY REFUSE TO FIX IT. I BELIEVE THIS IS A SAFETY ISSUE. *TR

AFTER ABOUT 22,000 MILES THE ENGINE STARTED LOSING POWER, AND THE CLUTCH STARTED MAKING NOISES AND VIBRATIONS UPON ENGAGING/DISENGAGING. THE FIRST TIME IT HAPPENED WE WERE DRIVING ON THE INTERSTATE, SO THE LOSS OF POWER WAS REALLY DANGEROUS. THE DEALERSHIP REPLACED THE WHOLE FLYWHEEL AND CLUTCH ASSEMBLY. *AK

I WAS DRIVING MY 2006 VW JETTA TDI ON FREEWAY DOING ABOUT 60 MPH WHEN I NEEDED TO DOWN SHIFT FROM TRAFFIC AND WHEN DEPRESSING THE CLUTCH IT STUCK TO THE FLOOR MANAGED TO GET TO THE SIDE OF THE ROAD CALLED DEALER I BOUGHT THE CAR FROM. THEN TOLD ME TO TRY TO PULL UP THE CLUTCH PEDAL AND IF SO TRY PUMPING THE CLUTCH AND IF FEELS GOOD THEN GIVE IT A TRY. SO I DID ,THE PEDAL CAM UP, I PUMPED IT FELT OK I JUST STARTED THE CAR , SLOWLY RELEASED THE CLUTCH THE CAR SHOT FORWARD AND DIED WITH A CLUNK. SO I HAD THE CAR TOWED TO THE NEAREST DEALER ( NOT MINE ). TALKING TO THE SERVICE REP HE TOLD ME THEIR HAS BEEN A PROBLEM WITH THESE CLUTCHES AND THEY HAD DONE EIGHT OF THE SAME YEAR AND MODEL UNDER WARRANTY . I CALLED TO SEE IF IT WAS READY THEY TOLD ME IT IS NOT COVERED UNDER WARRANTY AND THAT THE CAR WAS READY TO BE PICKED UP AND I OWED THEM $2700.00 FOR THE REPAIRS IE; NEW CLUTCH, PRESSURE PLATE, FLYWHEEL AND BEARING. I COMPLAINED TO NO AVAIL. MY CAR HAS 20,000 MILES AND OTHER PROBLEMS THEY HAVE NOT FIGURED OUT YET. *TR

AROUND 12-13K MI A LOT OF STRANGE VIBRATION APPEARED ON THE CLUTCH PEDALS, A LOT OF PULSATION DURING TAKE OFFS AND SHIFTS, SLIGHT GRINDING NOICE DURING SHIFTS, VIBRATION FROM THE ENGINE COMPARTMENT AND THE SHIFT LEAVERAGE AT AROUND 2K RPM. MAKES IT EASY TO STALL ESPECIALY DURING HOT DAYS. DEALER IDENTIFY THE PROBLEM AS THE FAILING DMF AND THROW-OUT BEARING AND POSSIBLY A SPRING/PRESSURE PLATE. THE CLUTCH DISK ITSELF WAS NOT SLIPPING.

I WAS DRIVING ON I-80, I MOVED TO THE OFF RAMP , AND WHEN I PUSHED THE CLUTCH, IT WENT ALL THE WAY DOWN TO THE FLOOR. THE 2006 JETTA TDI WITH 26 000 MILES NOW NEEDED A NEW CLUTCH AND FLYWHEEL, $1700 REPAIR BILL. THE NEW CLUTCHA ND FLYWHEEL WERE NOT THE SAME AS THE ORIGINAL. THE REPLACEMENT PARTS HAVE BEEN UPGRADED BY VOLKWAGEN, WHY? MAYBE THE ORIGINAL CLUTCH WAS DEFECTIVE. OR VOLKSWAGEN DID NOT TAKE INTO ACCOUNT THE ADDED TORQUE OF THE NEW PD ENGINE. VERY ANNOYING. *AK

AIRBAG LIGHT KEEPS COMING ON WITH AN INTERMITTENT AIRBAG FAULT. 3RD TIME FOR THE REPAIR. THIS HAS BEEN A CONTINUAL PROBLEM SINCE JULY 2006. ONLY 3 MONTHS AFTER PURCHASE. *AK

GRINDING SOUND WHEN CLUTCH PEDELAL IS DEESSED, SHUDDERING AT TAKE OFF. DEALER AND VW WILL NOT WARRANTY AT 29000 MILES COST OF A NEW CLUTCH $2500. *AK

CLUTCH HAS FAILED TWICE WHILE DRIVING. FIRST TIME MARCH 2007 AT 8,000 MILES. CLUTCH AND FLYWHEEL REPLACED AND FAILED AGAIN MAY 2007 AT 10,000 MILES. *TR

THE CAR JUMPS INTO GEAR AND LURCHES BECAUSE OF A HYDRAULIC BRAKE SWITCH IN THE MASTER CYLINDER THAT APPEARS TO TICK OR BE DELAYED IN TRANSMITTING THE ON /FF SIGNAL TO THE ACCELERATOR CIRCUIT WHICH DURING THE DELAY APPEARS UNRESPONSIVE AS IT IS DESIGNED NOT TO ALOW ACCELLERATING IN GEAR WHILE THE BRAKE IS ON. WHEN THE BRAKE SWITCH TURNS OFF , DELAYED UP TO 5 SECONDS, THE CAR LURCHES FORWARD AS THE DRIVER EXPECTS THAT THE ACCELERATOR IS NOT WORKING AND KEEPS PREASSING ON THE GAS. THIS LURCH IS VERY UNSAGFE AND CAUSED BY A STICKY OR DELAYED BRAKE SWITCH. I HAVE HAD THE SWITCH REPLACED ONCE ALREADY BUT ALL OF THE SWITCHES APPEAR TO BEHAVE IN THE SAME UNSAFE, DELAYED MANNER.*AK TO REPRODUCE THE DELAY, PUT AN AUTOMATIC TRANSMISSION 2006 JETTA TDI INTO DRIVE AND WATCH THE "FOOT ON BRAKE" INDICATOR ON THE DASHBORAD TURN OFF 1-5 SECONDS AFTER THE FOOT IS TAKEN OFF THE BRAKE.

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE FELT THE VEHICLE'S CLUTCH SLIPPING WHILE DRIVING 5 MPH. THE DEALER STATED THAT THE CLUTCH ASSEMBLY NEEDED REPLACING. THE CONTACT STATED THAT SHE EXPERIENCED THE CLUTCH SLIPPING, DIFFICULTY SWITCHING GEARS, AND THE VEHICLE HAS STALLED SINCE THE VEHICLE WAS PURCHASED. THE VIN, PURCHASE DATE, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 33,000 AND FAILURE MILEAGE WAS 31,000.

OUR 2006 VOLKSWAGEN TDI WAS TOWED TO THE DEALER AGAIN YESTERDAY FOR CLUTCH PROBLEMS. AT 2 MONTHS WITH 5,000 MILES THE CLUTCH WOULD INTERMITTENTLY NOT ENGAGE. WAS ABLE TO DRIVE IT TO DEALER , AND DEALER REPLACED MASTER CYLINDER, BLEED SYSTEM AND REASSEMBLED. AT 6 MONTHS, WITH 15,000 MILES THE CLUTCH FAILED, STRANDING US ALONG THE HIGHWAY. HAD IT TOWED TO THE DEALER, WHO REMOVED THE TRANSMISSION, AND INSPECTED DUAL MASS FLYWHEEL. SLIPPED THROW OUT, BEARING CAME APART, THE FORK FOR BEARING SLID INTO PRESSURE PLATE. REPLACED FLYWHEEL, CLUTCH PLATE, PRESSURE THROW OUT BEARING FORK AND SPRING. - AT 9 MONTHS WITH 20,000 MILES TRANSMISSION WHINED IN THIRD GEAR AND HAD A HARSH SHIFT IN ALL GEARS. WHILE DRIVING TO DEALER THE CAR POPPED OUT OF GEAR. DEALER FOUND TRANSMISSION LEAKING FLUID FROM BELL HOUSING. CALLED VOLKSWAGEN, AND WAS TOLD TO CHECK FOR CRACKS IN CASE. REMOVED CASE ,AND INSPECTED FOR CRACKS. HAD HAIRLINE CRACKS. REMOVED AND REPLACED TRANSMISSION, AND REASSEMBLED AND ADDED FLUID." THIS REPAIR TOOK THE LONGEST AS THE DEALER HAS TO WAIT FOR PARTS. THE CAR WAS AT THE DEALER THIS TIME FOR OVER THREE WEEKS. 4- 10 MONTHS WITH 22,000 MILES THREE WEEKS AFTER LAST REPAIR WE WERE AGAIN STRANDED AT THE SIDE OF THE ROAD. AT A STOP SIGN DEPRESSED CLUTCH, PUT CAR IN FIRST, STARTED TO MOVE AND CAR MADE A LOUD NOISE AND CLUTCH WAS DEAD AGAIN. TOWED TO DEALER ,AND WE ARE WAITING TO HEAR AGAIN FROM THEM. BOTH MY HUSBAND AND I HAVE BEEN DRIVING STICK SHIFT FOR OVER 20 YEARS EACH. OUR DEALER

IN JANUARY SOMETHING BROKE OFF FROM THE TRANSMISSION AND KILLED THE ENTIRE ENGINE. IT GOT A NEW ENGINE AND A NEW TRANSMISSION. THAT HAS LED TO A SLEW OF OTHER DIFFERENT PROBLEMS FROM MINOR RATTLES TO DANGEROUS EXHAUST LEAKS AND OIL LEAKS. CORPORATE VW WAS ONLY ABLE TO GIVE ME TWO MONTHS CREDIT ON MY LOAN WHICH FROM READING EVERYWHERE IS JUST THEIR WAY OF GETTING US TO SHUT UP. NOW MY REAR BRAKES ARE METAL TO METAL AND I HAVE A BEARING PROBLEM. I HAVE READ THAT THIS IS A COMMON PROBLEM BUT MY SERVICE DEPARTMENT STATES THAT I CAUSED IT BY HITTING A CURB WHICH IN TURN RUINED THE BEARING. I THINK THE BEARING WAS RUINED WHEN THEY PUT IN THE NEW ENGINE AND SCREWED WITH THE TORQUE. *TR

WIFE STATED THAT WHEN SHE HIT BRAKES IT WAS HARD TO STOP CAR ,DID NOT SLOW, REAR ENDED A SUV AT ABOUT 30 MPH WHICH PUSHED FRONT END UP TO WINDSHIELD ABOVE BUMPER, PUSHED ENGINE INTO FIREWALL. SHE INCURRED MAJOR SEAT BELT BRUISING WITH NO AIR BAG DEPLOYMENT. AFTER INSPECTION THE INSURANCE COMPANY FOUND THAT TWO SENSORS HAD BEEN DISTORTED ALONG WITH CRACKED ENGINE MOUNTS AND BENT CRADLE. THEY TOTALED THE CAR DUE IN PART TO NO AIR BAG DEPLOYMENT,T AND FELT THAT THE CAR WOULD BE UNSAFE AFTER REPAIRS. AFTER CONTACTING VOLKSWAGEN, THEY SAID THAT AIR BAG DEPLOYMENT SHOULD NOT HAVE HAPPENED. BUT WHAT IF MY WIFE HAD JUMPED INTO THE CAR AND FORGOT TO PUT THE SEAT BELT ON SHE WOULD HAVE GONE THROUGH THE WINDSHIELD. I FEEL THAT THIS IS A MAJOR SAFETY DEFECT SINCE MOST ACCIDENTS WOULD OVER RIDE THE BUMPER DUE TO LOW BUMPER HEIGHT. VOLKSWAGEN DOES NOT SEEM TO THINK THIS IS A PROBLEM FROM THE PICTURES I SENT THEM AND OUR TALK ON THE PHONE. *AK

THE MANUFACTURER OF MY VEHICLE AND THE DEALER HAVE INFORMED ME THAT MY VOLKSWAGEN TDI'S WIRING HARNESS WAS CRUSHED DUE TO A FOREIGN OBJECT UNDERNEATH THE SEAT. ALTHOUGH I AM CONTESTING THAT THE OBJECT IS MINE, I DO THINK IT IS OF CONCERN THAT THE WIRING HARNESS IS NOT SECURED OR PROTECTED IN ANY WAY, AND ANY OBJECTS THAT SLIDE UNDERNEATH THE SEAT MAY CRUSH THIS HARNESS AND MAY POSSIBLY RENDER THE AIRBAG SYSTEM USELESS. *JB

TL*- THE CONTACT STATED THAT AFTER DRIVING THE 2006 VOLKSWAGEN TDI DIESEL AND COMING TO A STOP SHE PUT THE VEHICLE IN PARK AND THE VEHICLE CONTINUED TO ROLL ABOUT 4-6 INCHES FURTHER. THE CONTACT STATED THAT THIS WAS A SAFETY PROBLEM, IF SOMEONE WERE IN FRONT OF THE VEHICLE IT COULD HIT HIM/HER. THIS WAS NOTICED AFTER BUYING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED THAT THERE WAS NO ADJUSTMENT TO BE MADE ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO ANOTHER DEALERSHIP CALLED WALLACE VOLKSWAGEN IN TENNESSEE. HE STATED THAT THE SERVICE MANAGER WAS WAITING FOR A VOLKSWAGEN REPRESENTATIVE TO COME IN TO THE DEALERSHIP AND HAVE HIM LOOK AT THE VEHICLE. THE SALES MANAGER INFORMED THE CONTACT THAT THIS WAS A PROBLEM. THE FAILURE MILEAGE WAS 40 MILES AND THE CURRENT MILEAGE WAS 24,800.*AK CONSUMER STATES WHILE GETTING OIL CHANGE THE DEALER WAS NOTIFIED OF THE PROBLEM BY ADJUSTING CABLE ON GEAR SHIFT BUT TO NO AVAIL THE PROBLEM IS STILL YET TO BE FIXED. 4/23/07*TR

THE HIGH BEAM HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI ARE DESIGNED IN A MANNER THAT I FEEL IS EXTREMELY DANGEROUS. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT AND I DO NOT UNDERSTAND HOW THEY ARE EVEN CONSISTENT WITH THE DOT LIGHTING CODE. *JB

CLUTCH FLYWHEEL PROBLEMS WITH MY 2006 JETTA TDI. LEFT ME STRANDED ON HIGHWAY WITH ONLY 37 K MILES ON IT. DEALER SAYS NOT COVERED UNDER WARRANTY AS WEAR AND TEAR, THIS IS THE SECOND TIME IT HAS NEEDED TO BE REPLACED IN 1 YEAR. WE WERE EXITING OFF OF A HIGHWAY AND THE CLUTCH STAYED DEPRESSED STUCK TO THE FLOOR AND THE TRANSMISSION WAS NOT WORKING. *NM

28K MILES... REAR BRAKES WORN DOWN INTO THE METAL, REQUIRING NEW REAR BRAKES AND ROTORS. FRONT HAVE 75% REMAINING. VW AUTHORIZES $150 ASSISTANCE ON LABOR BUT REFUSES TO CALL BRAKES DEFECTIVE. *NM

WHEN STARTING IN DRIVE, AT A STOP LIGHT, CAR DOES NOT ACCELERATE AS IT WOULD NORMALLY WOULD, BUT JUST CREEPS FORWARD FROM 3 TO 10 SECONDS, THEN IT BEGINS TO ACCELERATE NORMALLY. *JB

MY PASSENGER SIDE SEAT BELT IN MY 2006 VW JETTA NEEDED REPLACEMENT. ONCE RETRACTED IT WOULD NOT COME OUT, SO I COULD NOT HAVE A PASSENGER IN THE FRONT OF MY VEHICLE. VW IS REPLACING THE SEAT BELT. *NM

THE HEADLIGHTS ARE DEFECTIVE. WHEN LOW BEAMS ARE PROPERLY ADJUSTED THE HIGH BEAMS ARE TOO HIGH. SO HIGH THAT THERE IS A BLACK LINE BETWEEN THE TOP OF THE LOW BEAN CUT OFF AND THE BOTTOM OF THE HIGH BEAM START. *JB

2006 VW JETTA HAS BRAKE PROBLEM - OFF ROAD AT DEALER>30 DAYS. DEALER TOLD US TO PICK UP THE CAR & THAT THEY WERE "DONE" WITH THE CAR. VW BROUGHT TO TWO OTHER ASE MECHANICS WHO CHECKED THE BRAKES AND FOUND THEM DEFECTIVE. *JB

1) VEHICLE IS A 2006 VW JETTA, PACKAGE 1 MANUAL TRANSMISSION; DRIVING VEHICLE NORMALLY; NO ABNORMAL BRAKING INCIDENTS OR ACCIDENTS WHATSOEVER. 2) REAR BRAKE PADS ON DRIVER'S SIDE WORN DOWN TO RIVETS AT AROUND 11K MILES; THIS RESULTED IN SCORED REAR DRIVER'S SIDE ROTOR; PASSENGER SIDE REAR PADS ALSO WORN DOWN BUT NO DAMAGE TO ROTOR YET; FRONT BRAKE PADS STILL IN EXCELLENT CONDITION FOR BOTH SIDES. APPARENTLY FOR THE 2006 VW JETTA, THE REAR PADS WEAR OUT BEFORE THE FRONT PADS. I CONSIDER THIS A MAJOR DESIGN DEFECT ESPECIALLY SINCE THE REAR BRAKE SYSTEM IS NOT DESIGNED TO BE THE PRIMARY BRAKE LOAD CARRIER, AT LEAST BASED ON THE SIZE AND CONSTRUCTION OF THE ROTORS: A) FRONT ROTORS ARE 25MM VENTILATED B) REAR ROTORS ARE 12MM UNVENTILATED THE REAR BRAKES WEARING OUT BEFORE THE FRONTS FOR THE VW JETTA IS A COMMON PROBLEM AND THIS SHOULD BE LOOKED INTO. SEARCH THE VW FORUMS AND YOU WILL FIND MANY CASES OF THIS. 3) VW WILL BE REPLACING BOTH REAR ROTORS AND PADS UNDER WARRANTY; NOT SURE ABOUT KEEPING THE OLD PARTS SINCE THE WORK WILL BE DONE UNDER VW WARRANTY. THE REPLACEMENT OF THE PARTS IS GOOD BUT I'M NOT SURE IF THIS SOLVES THE ULTIMATE ISSUE OF THE REAR BRAKE BIASING WHICH IS CAUSING THIS PROBLEM IN THE FIRST PLACE. EITHER THE ENTIRE VW JETTA BRAKE SYSTEM AND/OR THE BRAKE PROPORTIONING VALVE NEEDS FURTHER INVESTIGATION. *NM

I NOTICED HIGH BEAMS WERE VERY HIGH RIGHT AFTER I TOOK DELIVERY IN NOV. 2005. BECAUSE, AT THE TIME, I DID VERY LITTLE NIGHT DRIVING, IT DIDN'T BOTHER ME. IT WASN'T UNTIL ABOUT OCTOBER,2006, WHEN I HAD SOME NIGHT LOCAL DRIVING TO DO, THAT I NOTICED HOW THE HIGH-BEAMS SO NICELY LIT UP MY NEIGHBORS SECOND STORY WINDOWS. I QUICKLY LEARNED TO USE 'LOW-BEAMS ONLY" IN OUR DEVELOPMENT!!! I CALLED TON BUSH MOTORS IN JACKSONVILLE TO ASK IF THEY HAD FOUND A CURE FOR THIS PROBLEM. THEY SAID THE SERVICE MGR SAID HE THOUGHT HE COULD TAKE CARE OF IT. AS I HAVE BEEN FOLLOWING THESE COMPLAINTS FOR A WHILE ON THE 'NET, MY FIRST THOUGHT WAS "OH, SURE." ON 12/20/06, I LEFT THE CAR WITH THE SERVICE PEOPLE. WITHIN 30 MINUTES THEY PAGED ME, SAYING THAT IT'S ALL SET. THAT NIGHT, I DROVE THE CAR ALL THRU' THE DEVELOPMENT....... NOT A SINGLE CASE OF SECOND STORY LIGHTING !!! AND THE LOW-BEAMS GIVE ADEQUATE COVERAGE. I DROVE ONTO FLORIDA A1A THE NEXT NIGHT SOUTH TO ST AUGUSTINE, AND HAD GREAT VISIBILITY THE WHOLE WAY. I DON'T KNOW WHAT "TECH 336" DID, BUT MY LIGHTS ARE NOW FINE. *JB

THE SPEEDOMETER ON THE 2006 JETTA, TDI READS 5 MILES PER HOUR LOWER THEN INDICATED SPEED BY GPS AND HIGHWAY RADAR. THE DEALER AND VOLKSWAGEN CUSTOMER SERVICE SITES THE SAE GUIDELINES ALLOWING AN ERROR OF UP TO 6 MILE PER HOUR. WHEN ASKED FOR A COPY OF THE DOCUMENT VOLKSWAGEN WOULD NOT PROVIDE IT. I WAS NOT NOTIFIED AT PURCHASE THAT THE SPEEDOMETER AND ODOMETER WERE IN ERROR ON ALL JETTA CARS. THE ODOMETER AND SPEEDOMETER ERROR WAS NOT DISCLOSED ALTHOUGH THE EXPECTED MILES PER GALLON WERE DISCLOSED BASED ON FAULTY INSTRUMENTATION. *NM

MY 2006 TDI SEEMS TO HAVE HAD A CLUTCH FAILURE AT 8950 MILES. I WAS SITTING IN TRAFFIC AND THE ENGINE STARTED SMOKING AND GIVING OFF A LARGE AMOUNT OF NOXIOUS FUMES AND WOULDN'T ACCELERATE. I WAITED FOR TOWING OUTSIDE ON THE FREEWAY IN SUB-ZERO TEMPERATURE. IT WAS A SATURDAY SO WAITED UNTIL MONDAY FOR IT TO GO TO THE SHOP. THE DEALER SAYS THEY WERE UNABLE TO RE-CREATE THE PROBLEM AND SENT ME OFF WITH THE FAIL-PRONE CAR. I AM VERY UNHAPPY WITH VOLKSWAGEN, IF THIS IS THEIR IDEA OF CUSTOMER SATISFACTION. *JB

1. 2006 VW JETTA TDI 5-SPEED: CLUTCH FILED TO OPERATE AT 18,000 MILES, SLIPPING & BURNING 2. 2006 VW JETTA TDI 5-SPEED: CLUTCH AND DUAL MASS FLYWHEEL FAILED AT 18,000 MILES 3. DEALER REPLACE AT COST OF $2,500. DEALER STATED NOT COVERED UNDER WARRANTY, FILED COMPLAINT WITH VW OF AMERICA. DAMAGED PARTS AVAILABLE FOR INSPECTION. *JB

THE HIGH AND LOW HEADLIGHTS ARE NOT CAPABLE OF BEING ADJUSTED INDEPENDENTLY. THIS IS A SAFETY CONCERN BECAUSE PER MANUFACTURER SPEC, THE LOW BEAMS ARE APPROPRIATELY AIMED, BUT THE HIGH BEAMS ILLUMINATE ONLY TREES. IF THE HEADLIGHTS ARE ADJUSTED SO THAT THE HIGH BEAMS ARE APPROPRIATELY AIMED, THE LOW BEAMS ONLY ILLUMINATE A USELESS DISTANCE IN FRONT OF THE CAR. *NM

2006 VW JETTA TDI AUTOMATIC. STOPPED AT STOP LIGHT. WHEN LIGHT TURNED GREEN THE CAR WOULD GO BUT WOULD NOT SHIFT. PULLED OFF ROAD AND TRIED TO RESTART. AFTER RESTART CAR WOULD NOT MOVE. CAR HAS BEEN IN SHOP FOR 20 CALENDAR DAYS AT THIS POINT. *JB

THE HIGH BEAM HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI CANNOT BE ADJUSTED PROPERLY AND I FEEL THIS CREATES A DANGEROUS SITUATION. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THE DEALER CLAIMS THE HEADLIGHTS ARE ADJUSTED PROPERLY HOWEVER THE FOCUS OF THE HIGH BEAMS IT LITERALLY POINTED UP IN THE TREES. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT. *NM

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS THE HIGH BEAMS WERE OBSERVED TO BE TOO HIGH ALTHOUGH THE ROAD WAS NOT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE ADJUSTMENT COULD ONLY BE MADE TO EITHER FOR THE LOW BEAMS OR THE HIGH BEAM. HOWEVER, IF THE HIGH BEAM WAS ADJUSTED TO THE APPROPRIATE LEVEL, THE LOW BEAM WOULD BECOME TOO LOW WITH THE CONSEQUENCE OF NO ROAD ILLUMINATION. A SECOND DEALERSHIP WAS CONTACTED WHO ALSO WAS UNABLE TO REPAIR THE DEFECT. THE MANUFACTURER WAS CONTACTED AND ACKNOWLEDGED THE PROBLEM AND PROMISED TO CALL BACK HOWEVER THE CALL WAS NEVER RECEIVED.

UNADJUSTABLE AIM OF HEADLIGHTS ON 2006 VW JETTA TDI. RIGHT AND LEFT LIGHTS ARE ADJUSTABLE SIDE-TO-SIDE, BUT I WAS TOLD BY THE DEALER THAT "THE HIGH AND LOW BEAMS ON EACH SIDE ARE ALL ONE UNIT AND CANNOT BE ADJUSTED UP OR DOWN SEPARATELY." I FIND THIS COMPLETELY UNACCEPTABLE, SINCE THE HIGH BEAMS DO NOT ADD ANY DISTANCE OR WIDTH TO THE LIGHT FIELD ON THE ROAD. THEY DO, HOWEVER, LIGHT UP THE TREE-TOPS NICELY. HIGH-BEAMS WHICH ARE USELESS AT HIGHWAY SPEEDS AND CANNOT BE MADE FUNCTIONAL WITHOUT RENDERING THE STANDARD LOW-BEAM FOCUS UNACCEPTABLY SHORT IS A SAFETY HAZARD. CORRECTION SEEMS TO REQUIRE REDESIGNED COMPONENTS. UNACCEPTABLE BRAKE LIGHT REFLECTION IN REAR WINDOW. BRAKE LIGHT HOUSING AT TOP OF REAR WINDOW IS NOT FLUSH TO THE GLASS, BUT APPROXIMATELY 3/8THS OF AN INCH AWAY. THIS CAUSES A LARGE RED GLARE IN THE REAR WINDOW WHEN BRAKES ARE USED IN DARK OR NEAR-DARK SITUATIONS. DEALER SAID " ACCORDING TO DESIGN". I FEEL THIS IS A SAFETY HAZARD DUE TO THE OBSCURING OF VISIBILITY TO THE REAR WHEN BRAKES ARE IN USE. REAR-VIEW MIRROR DIMMING SWITCH DOES NOT ALIGN MIRROR WITH PREVIOUS SETTING. THIS REQUIRES DRIVER TO MOVE THE MIRROR AFTER SWITCHING TO DIM UPCOMING HEADLIGHTS.

THE HIGH BEAM HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI ARE DESIGNED IN A MANNER THAT I FEEL IS EXTREMELY DANGEROUS. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT AND I DO NOT UNDERSTAND HOW THEY ARE EVEN CONSISTENT WITH THE DOT LIGHTING CODE.*JB

THE HIGH BEAM HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI ARE DESIGNED IN A MANNER THAT I FEEL IS EXTREMELY DANGEROUS. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT AND I DO NOT UNDERSTAND HOW THEY ARE EVEN CONSISTENT WITH THE DOT LIGHTING CODE. *NM

REGISTERED PRIOR TO AN ACCIDENT: 2006 VOLKSWAGEN JETTA HEADLIGHT SYSTEM : THE LOW BEAMS AND THE HIGH BEAMS ARE NOT INDEPENDENTLY ADJUSTABLE. WHILE THE LOW BEAMS ARE NORMAL TO GOOD QUALITY WHILE ILLUMINATING THE ROADWAY, THE HIGH BEAMS ARE SET TOO HIGH. THE HIGH BEAMS ARE NOT USABLE FOR NIGHT TIME DRIVING IN ''OPEN RANGE'' COUNTRY. THEY DO NOT ILLUMINATE ANYTHING ON THE ROADWAY AND ARE ESSENTIALLY USELESS. AN ESTIMATE IS AT ABOUT 100 FT DISTANCE IN FRONT OF THE VEHICLE THE CENTER OF THE HIGH BEAM IS ABOUT 10 FT ABOVE THE ROADWAY. TO SEE A PERSON OR ANIMAL ON THE ROADWAY AT A DISTANCE OF 500 FT IS IMPOSSIBLE. THE VW DEALER SAID THERE IS NOTHING THAT CAN BE DONE TO LOWER THE HIGH BEAM AIM POINT. THIS IS THE ONLY VEHICLE IN 50 YEARS OF DRIVING THAT I HAVE HAD THIS PROBLEM WITH. *NM

THE HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI ARE DESIGNED IN A MANNER THAT I FEEL IS EXTREMELY DANGEROUS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT. *NM

CONSUMER COMPLAINT CONCERNING THE 2005-2006 A5 JETTA INACCURATE SPEEDOMETER READING. *TS THE SPEEDOMETERS READS 4-5 MPH HIGHER THAN THE VEHICLE'S ACTUAL SPEED. *NM

THE STANDARD (NON-XENON) HIGHBEAMS ON 2005 AND 2006 JETTAS ARE DEFECTIVE. DUE TO A DESIGN FLAW, THEY DO NOT ADD ANY USEFUL LIGHT TO THE ROAD SURFACE, BUT ONLY ILLUMINATE THE TOPS OF TREES. THERE IS NO SEPARATE ADJUSTMENT FOR THE HIGHBEAM; THE HIGH AND LOW BEAMS MOVE AS A UNIT. IF YOU LOWER THE HIGHBEAM TO MAKE IT USEFUL, THE LOW BEAM BECOMES TOO LOW. *NM

BRAKE LIGHTS REMAIN ON AFTER CAR IS SHUT OFF. *NM

REAR VIEW MIRROR - DAY/NIGHT FUNCTION DEFECTIVE. DRIVER OPERATION BETWEEN POSITIONS DAY OR NIGHT WILL LEAD TO A FALSE VEHICLE ORIENTATION WHICH COULD LEAD TO A COLLISION. *NM

IT HAS COME TO THE NOTICE OF SEVERAL VW 2006 JETTA TDI OWNERS THAT THE REARVIEW MIRROR DOES NOT OPERATE CORRECTLY WHEN FLIPPED FOR NIGHTTIME USE. THE MIRROR OVER ADJUST AND HAS THE POTENTIAL TO OBSCURE THE DRIVERS ABILITY TO SEE OUT THE BACK WINDOW. AN INFORMAL DISCUSSION OF OTHERS NOTICING THIS DESIGN FLAW CAN BE FOUND AT: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=155017. *NM

I LEASED MY 2006 JETTA 2.0 IN JANUARY 2006. CURRENTLY THE CAR HAS STALLED ON ME 4 TIMES AND I HAVE HAD NUMEROUS FAILED STARTS. THE VEHICLE FAILS TO START WHEN I USE THE MAIN KEY AND THE VALET KEY. THIS PROBLEM HAS BECOME PRETTY CONSISTENT NOW THAT I HAVE PUT MORE MILES ON THE VEHICLE. I AM NOW AT 20K AND ITS BEEN A HEADACHE ALL THE WAY. I CAN ONLY BE THANKFUL THAT WHEN THE CAR STALLED ON ME ON NUMEROUS OCCASIONS THAT I WAS NOT IN HEAVY TRAFFIC. THE DEALERSHIP SAYS THAT THEY CAN NOT IDENTIFY THE PROBLEM AND THEREFORE THERE IS NOTHING THAT CAN BE DONE. SUPPOSEDLY, THE CAR STARTS WITHOUT A PROBLEM WHEN IT IS IN THEIR SERVICE BAY. IN ADDITION, WHEN I FIRST GOT THE VEHICLE, MY BACK SEAT LATCHES WERE BROKEN CAUSING THE BACK SEAT TO LUNGE FORWARD DURING HARD STOPS AND TURNS. THIS MADE MY JETTA A TWO PASSENGER VEHICLE! ALSO, THE HAZARD LIGHTS AND SWITCHES WERE MALFUNCTIONING. THE FRONT SUSPENSION OR THE BRAKES MAKE A GRINDING NOISE OR THEY HAVE A LOOSE FEEL, I HAVEN'T BEEN ABLE TO PUT MY FINGER ON IT YET. IM TAKING IT TO THE DEALERSHIP ONCE AGAIN TOMORROW! MY STEERING COLUMN MAKE A FAINT SQUEAKING NOISE DURING TURNS, I HAVE NO IDEA WHAT THAT PROBLEMS IS. IN THE MORNING AFTER I CAN GET THE CAR STARTED THE ENGINE IS LOUD FOR ABOUT TWO MINUTES. THE DEALER FIXED THE LATCH PROBLEMS BUT THE OTHER PROBLEMS GO UNFIXED AND REMAIN A HUGE MYSTERY. *JB

SPEEDOMETER READS 10 TO 15 PERCENT HIGH. AT 65 MPH THE SPEEDOMETER READS 73 MPH. DEALER STATED THIS IS A COMMON PROBLEM WITH JETTA'S AND THEY WERE UNABLE TO CORRECT. *JB

TRAVELING IN STOP AND GO TRAFFIC ON AN UPGRADE TOWARD GEORGE WASHINGTON BRIDGE. I STEPPED ON CLUTCH TO SHIFT BUT COULD NOT. THE CLUTCH PEDAL WAS NAILED TO THE FLOOR. I COASTED INTO A GAS STATION AND TURNED OFF ENGINE. THE SMELL OF CLUTCH BURNING WAS VERY PRONOUNCED. THE VW ROADSIDE ASSISTANCE WOULD NOT TOW ME ANYWHERE BUT TO THE NEAREST DEALER OR ANYWHERE ELSE FOR THAT MATTER UNLESS UNDER 15 MILES. I WOULD HAVE TO PAY FOR ANY TOWING BEYOND THAT. THE CAR WAS ULTIMATELY TOWED TO THE DEALER FROM WHOM THE CAR WAS PURCHASED. VWOA COVERED THE REPLACEMENT CLUTCH ONLY AS A COURTESY ONE TIME. THEY SAID THE CLUTCH WAS NOT COVERED BY THE WARRANTY. I HAD THE CAR FOR ONE WEEK. IT HAD 289 MILES TOTAL! I AM CONCERNED THAT THE VEHICLE IS NOT ACTUALLY FIXED AND THAT VWOA KNOWS THE CLUTCH ASSEMBLY IS INADEQUATE FOR THE CAR. THE OLD PARTS ARE NOT AVAILABLE AS FAR AS I KNOW. I AM NOT SURE AT THIS TIME WHAT PARTS OTHER THAN THE CLUTCH PLATE AND FLYWHEEL WERE REPLACED. *JB