2005 Volkswagen Jetta complaints

DRIVING MY DAUGHTER HOME FROM SCHOOL, HOT COOLANT STARTED SPEWING INTO WHERE HER FEET REST ON THE PASSENGER SIDE. *TR

AS EMPHASIS BY OTHER OWNERS OF THIS CAR (HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5457990-CLASS-ACTION-AGAINST-VW-FOR-TIMING-CHAIN-PROBLEM), VOLKSWAGEN DESIGNED A FLAWED SYSTEM WHICH ALLOWS THE TIMING CHAIN TO FAIL PRE-MATURELY. IN FACT, DUE TO THE DESIGN OF THIS MOTOR, A TIMING CHAIN FAILURE WILL DIRECTLY AND IMMEDIATELY LEAD TO OTHER CATASTROPHIC ISSUES SUCH AS A BENT VALVE IN MY SITUATION. UPON REPLACEMENT OF THE MOTOR, I HAD THE EXACT SAME ISSUE HAPPEN LESS THAN 1 MONTH LATER (11/16/11). *TR

THE CAR INTERIOR HAS A CRAYON SMELL MOST NOTICEABLE ON HOT DAYS. I AM CONCERNED THAT I AM BREATHING IN POSSIBLY TOXIC FUMES FROM THE EVAPORATION OF CHEMICALS THAT WERE USED WHEN THE CAR WAS BUILT. AFTER TYPING INTO GOOGLE ONLY THE 2 WORDS "CRAYON SMELL" I GET MANY MANY HITS FOR VW CARS THAT HAVE THE EXACT SAME SMELL AS MINE, SO THIS IS A PROBLEM THAT AFFECTS A LARGE GROUP OF VW VEHICLES. *TR

2005 .5 MODEL YEAR VOLKSWAGEN JETTA TDI (TURBODIESEL) WITH AUTOMATIC (DSG) TRANSMISSION. ON SEVERAL OCCASIONS WHILE DRIVING CAR, THE TRANSMISSION WILL FOR NO REASON SHIFT INTO NEUTRAL, AND ALL TRANSMISSION INDICATOR LIGHTS 'PRNDS' WILL FLASH SIMULTANEOUSLY. SO FAR, IF ENGINE IS SHUT OFF AND THEN RESTARTED, THE TRANSMISSION WILL AGAIN FUNCTION NORMALLY. I BELIEVE THIS HAS HAPPENED 4 OR 5 TIMES NOW. ON ONE OCCASION, THE CAR WAS IN AN INTERSECTION WHEN IT BECAME IMMOVABLE WHICH PRESENTS A SAFETY HAZARD.I CAN SEE THAT THERE IS A MASSIVE AMOUNT OF INFO ON MANY VW INTERNET SITES ABOUT THIS ISSUE, IN FACT IF YOU SIMPLY GOOGLE 'VW DSG FLASHING PRNDS' OR 'VW DSG TRANSMISSION PROBLEMS' ANYONE CAN FIND IT. IT IS A COMMON PROBLEM. I SEE THAT HHTSA HAS BEGUN AN INVESTIGATION BASED ON THIS FOR 2007 THRU 2009 MODEL YEARS, OBVIOUSLY A PROBLEM ON 2005/2006 VW WITH DSG TRANSMISSION AS WELL. VW HAS INITIATED A NEW CUSTOMER SERVICE PROGRAM TO ADDRESS CUSTOMER CONCERNS RELATED TO CERTAIN DSG EQUIPPED MODELS BUT APPARENTLY MINE (AND MANY OTHERS) ARE NOT COVERED THEY SAY BY THIS PROGRAM- NEVERTHELESS A SAFETY ISSUE EXISTS WITH 2005 AND 2006 DSG EQUIPPED VW'S. I CALLED VW CUSTOMER SERVICE (NATIONAL) TODAY 11/3/11 AND REP SAID "I AM NOT AWARE OF THIS ISSUE' FOR THIS YEAR- SO THEY ARE EITHER LYING OR INCREDIBLY UNDERINFORMED. I HAD THE CAR TO VW DEALER FOR DIAGNOSIS, AND THEY STATED THAT A DIAGNOSTIC TEST SHOWED A MALFUNCTION IN A PART THAT CONTROLS TRANSMISSION OPERATION AND WAS CAUSING THE TRANSMISS

TRANSMISSION FAILURE. WON'T SHIFT FROM SECOND TO FIRST. OR FIRST TO SECOND. IF ENGINE IS VERY HOT IT WILL MOST TIMES BUT NOT AT ALL IF COLD OR WARM. *TR

3 OCT 2011: THIS VEHICLE'S FLYWHEEL ASSY FAILED AT APPROXIMATELY 85,000 MILES. FORTUNATELY, THE FAILURE OCCURRED WHILE I WAS AT A VERY LOW RATE OF SPEED IN A NON-CONGESTED AREA. AFTER THE EVENT, I HAVE COME TO REALIZE THAT THIS IS A KNOWN PROBLEM ON DSG TRANSMISSIONS AS INSTALLED ON A VARIETY OF VW MODELS. VW DOES NOT APPEAR TO BE INTERESTED IN DISCUSSING THIS ISSUE FOR MODEL YEARS 2005 / 2006. I AM ONE OF THE LUCKIER ONES AS I REGULARLY MAKE LONG DISTANCE - INTERSTATE TRIPS WITH FAMILY IN-TOW. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE TO ACCEPT FULL FINANCIAL RESPONSIBILITY TO NOT ONLY TAKE CARE OF CUSTOMERS WHO HAVE EXPERIENCED SUCH LOW-TIME FAILURES BUT, ALSO, EXPAND ANY RECALL THAT MAY BE IN-PLACE FOR LATER MODELS SO AS TO PREVENT POTENTIAL LIFE-THREATENING ACCIDENTS WITHIN THE OVERALL DRIVING POPULATION. I HAD BEEN DRIVING A "TIME BOMB" FOR ALMOST 5 YEARS AND, TO DATE, VOLKSWAGEN OF NORTH AMERICA HAS ONLY ISSUED A LIMITED RECALL FOR LATER MODELS, THE 2008-2010, I BELIEVE. THIS EPISODE WILL COST AT LEAST $3000.00 USD AND NONE OF IT IS COVERED BY VOLKSWAGEN. WHAT IS THE ROOT CAUSE OF THIS AND HOW DO I KNOW THAT MY REPLACEMENT DSG TRANSMISSION WILL NOT BE SUSCEPTIBLE TO THIS HAPPENING AGAIN CAUSING POTENTIAL VEHICLE, PROPERTY, AND PERSONAL DAMAGE IN THE FORM OF A VEHICLE "MISHAP".??? *TR

2005.5 VW JETTA, 2.5L 5 CYL ENGINE. CAR HAS BEEN MAINTAINED ACCORDING TO MANUFACTURER GUIDELINES. VEHICLE WAS OPERATING NORMALLY WHEN CHECK ENGINE LIGHT CAME ON. CHECK ENGINE LIGHT WAS LIT STEADY, NOT FLASHING. STARTED TO LOSE POWER AND WAS DIFFICULT TO MAINTAIN SPEED. PULLED OFF ROAD AND IDLE WAS VERY ROUGH. TURNED CAR OFF AND BACK ON AND IDLE WAS WORSE AND CHECK ENGINE LIGHT STILL LIT AND NOT FLASHING. VEHICLE STARTED TO MAKE GRINDING NOISE FROM DRIVER'S SIDE OF THE ENGINE COMPARTMENT. WAS DIFFICULT TO MOVE VEHICLE UNDER ITS OWN POWER AND HAD CAR TOWED TO REPAIR SHOP. REPAIR SHOP FOUND TROUBLE CODE P1340 AND AFTER MORE DIAGNOSTIC THAT TIMING WAS INCORRECT. CAM TIMING WAS VERY FAR OFF AND STRETCHED TIMING CHAIN SUSPECTED. COMPRESSION TEST REVEALED BENT VALVES AS WELL. LOCAL INDY MECHANIC AND LOCAL VW DEALER HAVE BOTH SEEN THIS ISSUE SEVERAL TIMES WITH 2005.5 AND 2006 MODEL JETTA AND RABBIT VEHICLES WITH THE 2.5L ENGINE, AND SEVERAL OTHER SIMILAR FAILURES ARE OUTLINED IN SEVERAL PLACES ONLINE. THE FAILURE OF THE TIMING CHAIN WAS VERY SUDDEN AND COULD HAVE CAUSED AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN NEW JETTA. THE CONTACT WAS DRIVING 60 MPH WHEN THE POWER WINDOWS AND TURN SIGNALS FAILED TO WORK PROPERLY. THE CONTACT ALSO MENTIONED THAT THE EXTERIOR AND INTERIOR LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THAT BOTH A WIRING AND CRASH HARNESS WAS NEEDED TO RESOLVE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED, AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 69,000.

CAMSHAFT FAILURE CAUSING ALL ASSOCIATED/CONNECTING PARTS TO ALSO FAIL. NEVER DEVIATED FROM SPECIFIED MANUFACTURES REQUIRED OIL (505.01). THIS APPEARS TO BE A DESIGN PROBLEM, THAT IS COMMON ON ALL THESE DIESEL ENGINES (BRM), OF WHICH THE MANUFACTURE WILL NOT CORRECT AND THE OWNER IS REQUIRED TO CORRECT AT THEIR OWN EXPENSE AT A COST OF $2000 PLUS. *TR

OWN A 2005 VW JETTA, BROUGHT INTO DEALERSHIP TODAY WITH 106K MILES ON IT AND NOW THEY ARE SAYING THE TIMING CHAIN HAS JUMPED. THIS SOUNDS LIKE IT IS A COMMON PROBLEM, SO WHY ISN'T THERE A RECALL. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THERE WAS A BURNING WAX ODOR EMITTING FROM THE AIR CONDITIONING VENT. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND REPLACED THE CARPET. THE ODOR RETURNED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR DURING SUMMER MONTHS. THE MANUFACTURER WAS CONTACTED AND OFFERED $1500 TOWARD THE PURCHASE OF A NEW VEHICLE. THE VEHICLE WAS NO REPAIRED. THE FAILURE MILEAGE WAS 60,000.

FRONT END CRASH INTO A STOPPED VEHICLE ON COUNTY HIGHWAY. APPROXIMATELY 35 MPH TO 40 MPH. NONE OF THE AIR BAGS DEPLOYED. VEHICLE WAS TOTALED BY INSURANCE PROVIDER. SEAT BELT STRAINING UPON BODY, THAT TOOK FULL FORCE OF STOP NO OTHER ABSORPTION OF IMPACT ENERGY. VEHICLE KEPT ENERGIZED EVEN AT THE SALVAGE STORAGE AREA WHEN KEYS WERE INSERTED NO ELECTRICALLY SAFETY RELAYS DISENGAGED THE VEHICLE ELECTRICAL SYSTEM.

WIRING HARNESS BETWEEN THE BODY AND THE DOORS FLEXES DURING OPENING AND CLOSING OF THE DOOR. THE WIRE COATING BECOMES BRITTLE WITH AGE AND CRACKS CAUSING STRESS POINTS IN THE WIRE LEADING TO BREAKAGE OF 1 OR MORE WIRES IN THE HARNESS LEADING TO INOPERABLE CONTROLS AND ELECTRONICS IN THE DOOR, POSSIBLE ELECTRICAL SHORT, AND POTENTIAL FIRE HAZARD. THIS FAILURE TENDS TO OCCUR AFTER A COUPLE YEARS OF USAGE. THIS PARTICULAR VEHICLE FAILED AT 65,000 MILES. USUALLY THE DRIVER'S DOOR FAILS FIRST AS IT IS USED MOST FREQUENTLY. THIS EQUIPMENT INCLUDES BUT MAY NOT BE LIMITED TO WINDOW CONTROLS, DOOR LOCKS, DOOR OPEN SENSOR, AIR BAG SYSTEM CRASH SENSOR, TRUNK RELEASE SWITCH, FUEL DOOR RELEASE SWITCH, DOOR MIRROR ADJUSTMENT, MIRROR TURN SIGNAL INDICATOR, MIRROR HEATING ELEMENT. WIRING HARNESS MUST BE REPLACED WHICH COSTS APPROXIMATELY $150-$200. HARNESS SHOULD BE REDESIGNED WITH LONGER WIRES TO AVOID STRETCHING OF THE WIRE AND WIRE COATING MATERIAL CHANGED TO AVOID BRITTLENESS WITH AGE AND WORK HARDENING. *TR

CHECK ENGINE LIGHT CAME ON WHILE RETURNING HOME AFTER SHOPPING. CAR WAS TOWED TO THE REPAIR SHOP. DIAGNOSIS WAS CATASTROPHIC FAILURE OF ENGINE DUE TO A TIMING CHAIN JUMP ON A 72K MILE, 2.5 LITER, 2005 VW JETTA TWO MONTHS AFTER PURCHASE. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO STEER. THE CONTACT ADDED POWER STEERING FLUID TO THE VEHICLE BUT CONTINUED TO EXPERIENCE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC STATED THAT THE HIGH PRESSURE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 201,000.

I HAVE A 2005 NEW JETTA AND AT AROUND 60,000 MILES IT SHIFTS HARD FROM 1ST TO 2ND GEAR AND 2ND TO 3RD GEAR. IT ALSO DOWNSHIFTS ABRUPTLY. THE HARD JERKING SCARES ME WHEN DRIVING BECAUSE IT CAN CAUSE AN ACCIDENT. AT SOME POINT VW HAS TO REALIZE THIS IS A SERIOUS SAFETY HAZARD. I GOT THE RECALL LETTER ABOUT THE VALVE BODY AND WHEN I TOOK IT TO A VW DEALER FOR SERVICE I WAS TOLD THAT MY CAR DIDN'T HAVE A VALVE BODY ISSUE. THEY SAID I NEEDED A NEW TRANSMISSION. COST $6,000. I CONTACTED VW BY PHONE AND WAS TOLD THERE WAS NOTHING THEY COULD DO. NOW AT CLOSE TO 70,000 MILES THE JERKING HAS WORSEN AND I HAVE BECOME VERY CONCERNED ABOUT THE SAFETY OF THIS CAR WHILE I'M DRIVING IT. *TR

I PURCHASED A 2005 NEW JETTA AUTOMATIC TRANSMISSION IN JULY OF 2010. IT CURRENTLY HAS 72,000 MILES. 3 ISSUES. ONE, WHEN THE CAR IS FIRST STARTED UP, A CLANGING NOISE OCCURS AND LASTS FOR APPROX 30 SECONDS, THEN IT SOUNDS LIKE A VENT CLOSES AND THE SOUND GOES AWAY. TWO, THE RIGHT FRONT HEADLIGHT WILL NOT TURN OFF SOMETIMES WHEN I PULL ALONG SIDE A CURB. I HAVE TO RESTART THE CAR, BACK THE CAR UP, THEN PULL THE CAR FORWARD TO GET IT TO TURN OFF. THE THIRD ITEM OCCURS INTERMITTENTLY NOT ALWAYS AND INVOLVES SHIFTING OF GEARS. WHEN THE CAR IS GOING APPROXIMATELY 20 TO 30 MILES PER HOUR, IT SEEMS TO BOUNCE BACK AND FORTH BETWEEN 2ND AND 3RD GEAR A LITTLE ROUGH BUT NOT JERKY AND SOMETIMES WHEN COASTING THROUGH AN INTERSECTION THE CAR SEEMS TO HESITATE WHEN I AM READY TO PUSH ON THE GAS. BUT THEN, AFTER A COUPLE SECONDS, ENGAGES INTO GEAR WITH A LUNGE. I RECENTLY TOOK THE CAR TO A TRANSMISSION SHOP FOR ANALYSIS AND THE MAN SAID HE COULD NOT PRODUCE ANY CODES. I TOLD HIM I HAD RECEIVED THE LETTER ABOUT THE TRANSMISSION'S VALVE BODY WARRANTY EXTENSION. HE DROVE THE CAR AND SAID THE CAR DEFINITELY LUNGES AND TOLD ME TO GET IT TO A VW DEALERSHIP FOR A CHECK UP AS HE WAS NOT AN AUTHORIZED VW TECH. I TOOK THE CAR TO THE NEAREST DEALERSHIP WHICH IS 2 HOURS AWAY FROM MY HOME. THEY DROVE THE CAR 3 SEPARATE TIMES TRYING TO PRODUCE THE SCENARIO I DESCRIBED BUT COULD NOT. THE TECH TOLD ME IT SOUNDED LIKE I WAS DESCRIBING THE VALVE BODY ISSUE AND HE WOULD TELL THE SERVICE ADVISOR THAT HE HAD FELT

COILPACK FAILURE CAUSES THE CAR TO DECELERATE AND SPUTTER, ESPECIALLY WHEN IT STARTS TO RAIN. VOLKSWAGEN IS AWARE OF THE PROBLEM SINCE 2001. THE INTERNET IS FULL OF COMMENTS ON THIS DEFECT YET THE PROBLEM CONTINUES. *TR

HARD SHIFTING, IT HARD SHIFTS AND IT KEEPS GETTING WORSE. I WAS TOLD IT WAS THE VALVE BODY BUT VOLKSWAGEN DOES NOT WANT TO PAY FOR IT BECAUSE IT IS A FEW MILES OVER THE 100,000 MILE WARRANTY WHEN I HAVE READ MANY THINGS SAYING THAT VOLKSWAGEN WAS HAVING PROBLEMS WITH THE VALVE BODY. *TR

NOXIOUS ODOR FROM CARPET UNDERLAYMENT. CAUSES HEADACHES AND ODOR TO BE ABSORBED INTO CLOTHING, SKIN, SEATS, ETC. VW WILL NOT ACKNOWLEDGE THE PROBLEM, NOR DISCLOSE THE MATERIAL USED AND IF IT IS OFF-GASSING ANY HAZARDOUS FUMES. *TR

JETTA 2005.5 SEDAN (AUTOMATIC) HARD SHIFTED BETWEEN 2ND & 3TH GEARS, DISPLAYING SHUDDERING AND HESITATION DURING ACCELERATION IN TRAFFIC. SINCE OCTOBER 2010 HARD SHIFTING HAS CONTINUED DAILY AND FREQUENCY OF SHIFTING HESITATION ISSUE HAS WORSENED. HARD SHIFTING WITH HESITATION UP BETWEEN 3TH AND 4TH, AND ALSO HARD SHUDDERING DOWNSHIFT BETWEEN 3RD AND 2ND. DEALER HOOKED VEHICLE TO COMPUTER ON FEB 14, 2011 AND STATED TRANSMISSION HAS NO ERRORS. DEALER WOULD NOT TEST DRIVE FOR LONGER THAN 4 MILES, DEALER STATED HARD SHIFT DID NOT OCCUR IN THAT 4 MILE PERIOD, TEST WAS NOT AT FREEWAY SPEEDS, OWNER WAS NOT IN THE VEHICLE. DEALER STATES VEHICLE IS NOT ELIGIBLE FOR VALVE FIX. VEHICLE SHIFTING FAILURE IS HAZARDOUS AND DANGEROUS HIGHWAY CONDITION.

THE OUTSIDE HANDLES OF THE DRIVER'S DOOR & DRIVER'S SIDE BACK PASSENGER DOOR DO NOT CLOSE PROPERLY. IT APPEARS THAT THE CYLINDER INSIDE THE DOOR DOES NOT LOCK THE HANDLE IN PLACE SO THE DOOR DOES NOT CLOSE. I HAVE TO ROTATE THE CYLINDER WITH MY FINGERS ALONG WITH PUSHING THE DOOR HANDLE INTO PLACE FROM THE OUTSIDE TO RESET THE DEVICE. THERE WAS NO INCIDENT THAT CORRELATES WITH THIS FAILURE. THIS OCCURS DURING EACH USE OF THE DOOR. IN RESEARCHING, I FOUND THAT SOME 2005 VW JETTA MODELS WERE RECALLED FOR THIS SAME PROBLEM. WHEN I SPOKE WITH THE DEALER, HE SAID MY VIN NUMBER DID NOT FALL UNDER THIS RECALL. *TR

VW JETTA 2.5L 2005 OUT OF THE BLUE CHECK ENGINE LIGHT CAME ON AT 81,000 MILES. RANDOM MISFIRE AND VACUUM LEAK CODES. TURN OUT TO BE TIMING CHAIN STRETCHED CAUSING THE PROBLEM COST $2000 TO FIX. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 15 MPH WHEN THE VEHICLE ABNORMALLY LUNGED FORWARD. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR WHENEVER DECELERATING THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE VALVE COVER DIAPHRAGM, COOLANT TEMPERATURE SENSOR AND CRANK SHAFT SENSORS WERE REPLACED BUT TO NO AVAIL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,236.

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT A NOISE COULD BE HEARD FROM THE ENGINE WHILE DECELERATING FROM ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THE VEHICLE NEEDED A NEW TIMING CHAIN. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 79,000. THE VIN WAS UNAVAILABLE.

I HAVE A 2005 VOLKSWAGEN JETTA MY HUSBAND WAS DRIVING THE CAR AND THE BATTERY BLEW UP UNDER THE HOOD. TOOK THE CAR IN AND WAS TOLD IT JUMPED TIMING TOOLS AND PARTS WERE UNAVAILABLE AND THE ENGINE HAD TO BE REPLACED THIS TOOK THREE MONTHS AND NOW THE TRANSMISSION WILL GO INTO NEUTRAL WHILE DRIVING THE VOLKSWAGEN MAINTENANCE DEPARTMENT STATED THERE WAS A RECALL ON THE TRANSMISSION AND IS 8 MILES OVER WARRANTY AND THEY WILL NO FIX THE CAR. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN NEW JETTA. THE CONTACT NOTICED THAT WHEN ATTEMPTING TO TAKE OFF FOR THE FIRST TIME AFTER STARTING THE VEHICLE, IT WOULD STALL INTERMITTENTLY. THE DEALER WAS NOTIFIED WHO INFORMED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY AND PROVIDED NO FURTHER ASSISTANCE. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 50,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 03/24/11*LJ THE CONSUMER ALSO STATED THE VEHICLE HAS A HARD JERKING AND IT ONLY OCCURRED WHEN THE VEHICLE WAS COLD. UPDATED 05.02.11

2005 JETTA GLI - THE TRANSMISSION STOP WORKING BECAUSE OF AN OIL SENSOR IN THE TRANSMISSION. THE TRANSMISSION STOP WORKING COMPLETELY AND WILL STOP WORKING IN THE ROAD AND CAN CAUSE AN ACCIDENT. I REPORTED TO VOLKSWAGEN AND THEY SAID IT WAS TOO BAD YOU NEED TO FIX IT. NEED YOUR HELP ON THIS MATTER PLEASE HELP. *TR

HELLO, I AM WRITING IN HOPES THAT YOU WILL HELP REGARDING A DEFECT IN THIS 2005/2006 JETTA VW MODEL. I HAVE COMPLETED MUCH MY RESEARCH ON LINE AND IT MADE ME ANXIOUS TO SEE MANY OTHERS HAVE HAD THE SAME SITUATION. I AM ASKING THAT YOU HELP IN THIS MATTER. I THOUGHT IT WOULD BE A GOOD IDEA TO CONTACT YOU FIRST. I HAVE ALREADY LOST $200 IN TOWING COST, WHEN MY CAR ABANDONED ME. BASICALLY, I FOUND THAT I COULD NOT TURN THE KEY TO START THE CAR. THE KEY WOULD NOT GO IN. I TRIED TO MOVE THE STEERING WHEEL AT DIFFERENT INTERVALS , BUT NO LUCK AFTER AN HOUR IN A DARK GARAGE. THE KEY JUST WOULDN'T GO IN. I HAD IT TOWED. I STRUGGLED TO GET THE KEY IN ONCE I WAS HOME AND IN A SAFE PLACE. I MANAGED TO PUSH THE KEY IN AFTER 30 MINUTES. A WEEK HAS GONE BY AND IT HAS HAPPENED AGAIN. THE KEY CAN'T GO IN. I HAD TO ABANDON MY CAR AGAIN. I DON'T HAVE AN EXTENDED WARRANTY BUT THAT IS NOT THE ISSUE, THE WARRANTY WOULD NOT COVER IT FROM Y RESEARCH. I FEEL I AM TRAPPED WITH THIS DEFECT THAT IS A COMMON PROBLEM AMONG OTHERS. WARRANTY OR NO WARRANTY, THIS IS A PROBLEM. SEE : HTTP://WWW.CARS-GUIDE.COM/VOLKSWAGEN-FORUM/STEERING-WHEEL-LOCK-AND-IGNITION-SWITCH-PROBLEM-T4673.HTML. I CALLED VW IN AUBURN AND THEY WANT TO CHARGE CLOSE TO $180 TO LOOK AT IT AND ALMOST $500 TO FIX IT. UNACCEPTABLE. IF THIS WAS ISOLATED HERE AND THERE, THEN O.K. BUT THIS IS RAMPANT. *TR

HARD SHIFT FROM 2ND TO 3RD GEAR AND FROM 1ST TO 2ND GEAR. PROBLEM CAUSES CAR TO VIOLENTLY JERK AND POSES A POTENTIAL SAFETY ISSUE WHEN ATTEMPTING TO ACCELERATE OR STOP. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 45 MPH THE BOLTS FROM THE DRIVESHAFT ON THE PASSENGER SIDE WERE LOOSE. THE ENGINE WAS ON BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE MANUFACTURER WAS CALLED AND INFORMED HIM THAT THERE WERE NO RECALLS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000.

THERE IS A LONG RUNNING ISSUE WITH THE 2005 1/2 VW JETTA V TRANSMISSION VALVE BODY THAT IS A SAFETY ISSUE WITH THE TRANSMISSION. WHEN THE TRANS GETS HOT SITTING IN TRAFFIC. THE TRANSMISSION SLIPS IN AND OUT OF GEAR OR SHIFTS VERY HARD OR WILL NOT SHIFT AT ALL AND MAY CAUSE A REAR END ACCIDENT AS THE JETTA DOES NOT SHIFT. VW AMERICA DOES KNOW OF THE PROBLEM AND ISSUED A EXTENDED WARRANTY TO 100,000 MILES OR 7 YEARS. BUT AFTER DOING EXTENSIVE RESEARCH THERE ARE JETTA'S THAT ARE OUT THERE THAT HAVE MILEAGE OVER THE 100,000 MILES. WHEN YOU CALL VW, THEY REFUSE TO HELP AND DO NOT CARE ABOUT THE SAFETY OF THE PEOPLE THAT OWN THEIR PRODUCT. THERE IS ALSO ISSUES WITH PREMATURE BRAKE LIGHT BULBS AND HEAD LIGHT BULBS BURNING OUT. *TR

WE RECENTLY BOUGHT A 2005 VOLKSWAGEN JETTA (THE NEWER DESIGN ALSO COINCIDED 2005.5) FROM A PRIVATE INDIVIDUAL IN MARCH 2010. WE NOTICED THERE WAS A SLIGHT PROBLEM WITH SHIFTING GEARS THAT CONTINUED TO GET WORSE. IN JUNE 2010 WE TOOK THE CAR TO A LOCAL VOLKSWAGEN DEALER AND DISCUSSED THE PROBLEM. THEY TOLD US IT SOUNDED LIKE THE DUAL MASS FLYWHEEL WAS THE PROBLEM. THAT THERE WAS 2 DIFFERENT MANUFACTURERS THAT MAKE THE FLYWHEELS AND THEY NO LONGER USE ONE OF THE MANUFACTURERS DUE TO DEFECTS AND PROBLEMS WITH THE FLYWHEELS THEY MADE. THEY SAID IT WAS A KNOWN PROBLEM THAT THE FLYWHEELS WERE BAD AND WOULD NEED REPLACED WAY BEFORE THEY WERE SUPPOSE TO. EVEN THOUGH THE PROBLEM WAS KNOWN BY VOLKSWAGEN THEY REFUSED TO FIX REPLACE THE DEFECTIVE PART. THEY SAID WE COULD CONTINUE TO DRIVE IT AND BUT WOULD CONTINUE TO GET WORSE AND END UP TEARING UP ALOT OF OTHER STUFF IF IT DID. WE LOOKED ONLINE AND FOUND MANY OTHER PEOPLE HAVING THIS SAME PROBLEM, THOUGH NO RECALL. WE ALSO READ WHERE IF THE FLYWHEEL LOCKED UP/CAME APART WHILE DRIVING IT COULD LOCKUP THE ENTIRE CAR. WE DID COME ACROSS WHERE THE FLYWHEEL HAD BEEN RECALLED IN EUROPE. THE CAR WAS DROVE TILL NOVEMBER 2010 WHEN IT HAD GOTTEN TO THE POINT WHERE IT WOULD DOWNSHIFT ON HILLS AND WHEN YOU WOULD TRY TO GET UP SPEED TO MERGE ONTO THE INTERSTATE IT WOULD NOT SHIFT TO THE NEXT GEAR( BUT THE RPMS WERE NORMAL) AND WAS FORCED TO MERGE ONTO THE INTERSTATE AT A VERY SLOW AND UNSAFE SPEED. THE ENGINE ALSO HAD A VERY LOUD CHATTER NOISE. WE D

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE RIGHT REAR BRAKE LIGHT WAS DEFECTIVE; WHEN HE WOULD TURN THE VEHICLE OFF, IT WOULD STAY ON. THE FAILURE WAS INTERMITTENT. THERE WAS ALSO A RIGHT REAR BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 77,936. THE FAILURE MILEAGE WAS APPROXIMATELY 77,740.

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE WIRING THAT EXTENDED FROM THE ALTERNATOR TO THE POWER DISTRIBUTION CENTER BURNED, CAUSING THE BATTERY'S INABILITY TO HOLD A CHARGE AND THE ENGINE'S INABILITY TO START SUCCESSFULLY. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE WIRES WERE REPLACED. ALSO, THE GAUGES ON THE INSTRUMENT CLUSTER FAILED; WHILE DRIVING, THE CONTACT NOTICED THAT THE GAUGES WERE MOVING AROUND AND NOT STAY STEADY. THE MECHANIC ALSO REPLACED THE INSTRUMENT CLUSTER AND REPROGRAMMED THE COMPUTER. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

2005.5 NEW JETTA 60,000 MILES AND THE TIMING CHAIN HAS SLIPPED TEETH AND THROWN THE ENGINE OUT OF TIME. NEW TIMING CHAIN FROM DEALER IS BETWEEN $4700-$5600. ALL MAINTENANCE AND SERVICE WAS DONE AT THE DEALER. FROM INTERNET SEARCHES IT APPEARS THIS IS A GROWING PROBLEM ON EARLY MODEL YEARS. THE DEALER HAS ALSO ADDED TO THEIR OWNERS MANUAL THAT THE TIMING CHAIN IS NOW A SERVICEABLE ITEM. HOWEVER IT WAS NEVER IN MY MANUALS. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 10 MPH, SHE DEPRESSED THE BRAKES AND THEY FAILED TO ENGAGE. THE VEHICLE PROCEEDED INTO INCOMING TRAFFIC. THE CONTACT WAS ABLE TO AVOID A CRASH. THE CONTACT PROCEEDED TO DRIVE AND WHEN APPROACHING A TRAFFIC LIGHT, THE IDENTICAL FAILURE RECURRED. THE ENGINE WAS SHUT OFF AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT THE BRAKE CYLINDER AND BOOSTER HAD FAILED BUT COULD NOT DETERMINE WHY THEY FAILED. THE BRAKE BOOSTER AND CYLINDERS WERE REPLACED AT A DISCOUNT RATE TO THE CONTACT. THE DEALER STATED THAT THE FAILURE SHOULD NEVER HAVE OCCURRED AND THE MANUFACTURER TOOK THE LIABILITY FOR A PARTIAL REPAIR COST. THE FAILURE AND CURRENT MILEAGES WERE 56,000.

WHEN SITTING IN STOP AND GO TRAFFIC, THE TRANSMISSION SHIFTS VERY HARD IN AND OUT OF THE SHIFTING SEQUENCE. WHEN THAT HAPPENS THE TRANSMISSION WILL TAKE A FEW SECONDS TO SHIFT INTO GEAR AND THUMP VERY HARD. AFTER CALLING A VW DEALERSHIP, I WAS INFORMED THAT THIS IS A VERY COMMON ISSUE WITH THE NEW JETTA'S AND BEETLES. ALSO THERE IS VERY HEAVY CRAZING WITH THE HEAD LAMP FIXTURES AND CANNOT BE REPAIRED AND CAUSES SERIOUS IMPAIRMENT AT NIGHT WHEN THE HEAD LIGHTS ARE ON. *TR

SHORTLY AFTER I BOUGHT CAR I NOTICED A NOISE COMING FROM (SOUNDED LIKE) ENGINE. I ALSO NOTICED CAR NOT CHANGING GEARS SMOOTHLY. FELT AS IF IT WAS HAVING A HARD TIME SHIFTING ESPECIALLY UP HILL, I TOOK THE CAR IN AND WAS TOLD THIS IS JUST HOW A VW SHIFTS AND SOUNDS. I TOLD THEM I DID NOT NOTICE IT WHEN I INITIALLY OWNED THE CAR. THEY RAN A DIAGNOSTIC SINCE NOW THE ENGINE LIGHT IS ON THE WINDSHIELD WIPERS COME ON AT THEIR OWN WILL, THE CLOCK LOOSES TIME CONSTANTLY, AND THE NOISE HAS GOT A LOT WORSE AND SO HAS THE GEAR SHIFTING. THE DIAGNOSTIC THEY SAY SHOWED THE DUAL FANS ARE BOTH BURNED OUT. IF THEY ARE BURNED OUT WHY ARE THEY STILL MAKING A LOUD NOISE SEVERAL SECONDS AFTER I TURN THE CAR OFF? THEY HAVE ALSO TOLD ME NO TRANSMISSION PROBLEM EXISTS BUT ANOTHER DEALER TOLD ME THEY CANNOT KNOW THAT BECAUSE THE DIAGNOSTIC WILL NOT PICK UP ON A BAD TRANSMISSION ONLY A TOTALLY FAILED ONE. WHICH THE CAR WILL BE OUT OF WARRANTY THEN. THESE CARS HAVE OBVIOUS TRANSMISSION PROBLEMS AND ELECTRONIC PROBLEMS THAT ARE BEING IGNORED. AFTER HAVING ALL THIS PROBLEM I LOOKED ON INTERNET AND WAS ASTONISHED AT THE NUMBER OF PEOPLE WITH ALL THE SAME PROBLEMS AS ME. SLOW AND HARD SHIFTS, WIPERS, CAR ACTING AS IF IT IS STALLING, CLOCK LOSING TIME, BATTERY GOING BAD TOO QUICK. BRAKES CONSTANTLY BAD. THIS CAR IS JUST A LEMON. WHY WILL THE GOVERNMENT NOT DO A TOTAL RECALL. THERE IS TOOOOOOO MUCH WRONG WITH TOOOOO MANY OF THEM. *TR

WHEN I AM DRIVING AND COME TO A COMPLETE STOP MY CAR DOES A SUDDEN JERK. WHEN ACCELERATE MY CAR ALSO JERKS WHEN I STEP ON MY GAS PEDAL. *TR

2005 VOLKSWAGEN JETTA TDI SEDAN - ENGINE RAN ROUGH AND NOTICED SLIPPAGE AND HESITATION DURING ACCELERATION FROM FULL STOP. REPEATED RESULTS FROM REPAIR SHOP VISITS FOUND NO PROBLEM, WAS TOLD THIS WAS "NORMAL"... THE FAILURE OCCURRED WHILE DRIVING AT NORMAL HWY SPEED. A LOUD BANG FOLLOWED BY COMPLETE ENGINE FAILURE. VISIT TO DEALER CONFIRMED CATASTROPHIC FAILURE OF DUAL MASS FLYWHEEL, CAUSING COLLATERAL DAMAGE TO ENGINE AND TRANSMISSION. REPAIR ESTIMATE WAS FROM $5K TO $15K. VW AND THE DEALER OFFERED NO ASSISTANCE DUE TO VEHICLE OUTSIDE OF MANF WARRANTY PERIOD, DESPITE CAR BEING WELL MAINTAINED BY THE BOOK. RESEARCH ON OWNERS FORUMS AND WEB SHOWS THIS SAME ISSUE IS PREVALENT IN THE 2005-2009 MODEL YEARS. FOUND OVER 3000+ INSTANCES FROM OWNERS COMPLAINING OF THE SAME ISSUE FROM AS LITTLE AS 15K MILES OF USE....ITS CLEAR THIS IS A MANF DEFECT IN THE DUAL MASS FLYWHEEL AND THAT VW HAS NOT RECOGNIZED THIS... *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT WAS INVOLVED IN A CRASH WHILE TRAVELING APPROXIMATELY 40 MPH. THE CONTACT WAS KNOCKED UNCONSCIOUS WITH THE LEVEL OF IMPACT SUSTAINED DURING THE CRASH. THE ENTIRE AIR BAG SYSTEM FAILED TO DEPLOY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 69,000.

THE ENGINE SEIZED FOR NO APPARENT REASON. NO WARNING LIGHTS, NO ENGINE LIGHTS, NO LOSS OF OIL. THEY COULD NOT EXPLAIN WHY THE ENGINE SEIZED. THEY REMOVED STARTER, REMOVED OIL PAN COULD NOT FIND ANYTHING WRONG. I CAME TO A STOP AND STOPPED THE CAR FOR 5 MINUTES AND IT WOULD NO LONGER RUN. THIS COULD HAVE HAPPENED WHEN I WAS DRIVING. THE ENGINE JUST STOPPED DEAD. THERE WAS NO WARNING THAT THERE WAS ANYTHING WRONG. I WONDER IF THIS IS AN ELECTRICAL PROBLEM. *TR

AIR BAG PROBLEMS ON 2005 VOLKSWAGEN NEW JETTA. DEFECTIVE CONNECTIONS UNDER ALL SEATS WHICH BREAK FROM RANDOM MOVEMENT OF SEATING AREA RESULTING IN A NONFUNCTIONAL AIR BAG FOR THAT PASSENGER. THIS CAUSES A DEFAULT CODE AND BLOCKS ANY AIR BAG FROM FUNCTIONING. ONLY A MATTER OF TIME BEFORE A CRASH RESULTS IN INJURY OR DEATH BECAUSE THE AIR BAG DID NOT DEPLOY AND PROTECT THE PASSENGER. EVERY VISIT TO DEALER TO CORRECT THIS PROBLEM COSTS THE CUSTOMER $300.00 PER SEAT AND FIX WORKS FOR ABOUT 1 MONTH. SEARCH THE WEB AND YOU WILL FIND 1000'S OF CONSUMERS WITH THE SAME PROBLEM. *TR

2005 VOLKSWAGEN NEW JETTA. AIRBAG WARNING LIGHT ON. DEALER DIAGNOSED AS NEEDING A NEW WIRING HARNESS IN PASSENGER SIDE SEAT. NECESSARY TO REPLACE WIRING HARNESS TO INSURE CORRECT OPERATION OF AIRBAGS IN CAR. *TR

TURN SIGNAL SWITCH MALFUNCTION AND FIRE... RIGHT TURN SIGNAL ACTIVATED WITHOUT SWITCH BEING ACTIVATED. AFTER ABOUT 5-10 MINUTES IN THIS CONDITION, SMOKE CAME OUT OF STEERING COLUMN. FIRE/MARKING COULD BE SEEN IN THE SWITCH AREA. EVENTUALLY THE TURN SIGNAL WENT OUT AND THE SMOKE/FIRE STOPPPED. VW SERVICE REPLACED THE SWITCH AND WIRE HARNES. THE PLACTIC ON THE SWITCH AND HARNES WAS MELTED AND CHARRED. *CN

WE HAVE A 2005 JETTA TDI AUTOMATIC. THIS CAR WAS BOUGHT NEW AND HAS BEEN SERVICED AT EVERY INTERVAL BY VW. WE HAVE HAD A COMMON CONCERN ABOUT THE CAR MOVING FORWARD IN DRIVE IN ERRATIC FASHION WHEN COLD AFTER ABOUT 6 MONTHS. WE INFORMED VW ABOUT THIS CONCERN AND THEY SAID NOTHING WAS WRONG. LAST WEEK MY WIFE WAS BACKING OUT OF THE DRIVEWAY AND THE CAR STALLED IN THE MIDDLE OF THE ROAD. WE TRIED EVERYTHING TO GET IT STARTED BUT IT WOULD NOT TURN OVER. WE HAD IT TOWED TO OUR VW DEALER WHO INFORMED US THAT IT WOULD COST $600.00 JUST TO MAKE A DETERMINATION AS TO WHAT THE CAUSE WAS. WE GAVE THEM THE GO AHEAD AND A DAY LATTER THEY INFORMED US THAT THE DUAL MASS FLYWHEEL HAS DISINTEGRATED WHICH IN TURN DESTROYED THE TRANSMISSION. THIS DMF APPEARS TO BE A COMMON PROBLEM WITH VW'S IN GENERAL. IN EUROPE VW WILL FIX THE PROBLEM FREE OF CHARGE, BUT NOT IN THE US. WE ARE WAITING TO HEAR FROM VW ON WHAT IF ANYTHING THEY WILL DO. THE SERVICE MANAGER WAS NO HELP IN THIS MATTER, EXCEPT TO TELL US IT WAS NOT COVERED. STAY TUNED AS WE ENTER THE TWILIGHT ZONE OF DESIGN DEFECTS WITH VW! *TR

ON 11/11/09, I PARKED MY CAR ON MY APARTMENT COMPLEX PARKING LOT. I LEFT MY CAR IN FIRST GEAR AS A SAFETY MEASURE. NEXT MORNING (11/12/09) I TRIED TO START MY CAR, BUT THE CAR WAS LOCKED IN FIRST GEAR EVEN AFTER PRESSING THE PEDAL CLUTCH. THE CAR DID NOT TURN ON BUT STALLED AND MOVE SLIGHTLY FORWARD. FORTUNATELY I HAD THE HAND BREAK ON. IF I DID NOT HAVE THE PARKING BREAK ON, I WOULD HAVE MOVED FORWARD INTO A BUSH IN FRONT OF MY PARKING LOT SPACE. I TURNED OFF THE CAR, SWITCHED TO NEUTRAL GEAR AND TURN THE CAR ON. THE CAR TURNED ON AND I THOUGHT I SOLVED THE PROBLEM. I PUT THE CAR ON REVERSE, TO EXIT MY PARKING LOT SPACE AND AGAIN THE CAR STALLED AND MOVED BACKWARDS. FORTUNATELY THERE WERE NO CAR OR PEOPLE BEHIND ME. AT THAT POINT I REALIZED THAT I COULD NOT ENGAGE THE CAR INTO ANY GEAR AND THAT THE CLUTCH WAS NOT FUNCTIONING. MY CAR IS ONLY 4 YEARS OLD WITH ONLY 46,000 MILES AND THERE IS NO REASON WHY THE CLUTCH WOULD FAIL SO EARLY IN LIFE. I READ IN MANY FORUMS THAT THE 05-06 VW JETTA HAS A DEFECTIVE CLUTCH AND IT COULD BE HAZARDOUS FOR PEOPLE IF THE CLUTCH FAILS WHILE DRIVING. MY CLUTCH DID NOT GIVE ME ANY SIGNAL OF WEAR AND TEAR, NO SOUNDS OR DIFFICULTY WHILE DRIVING, IT WAS WORKING VERY WELL ONE DAY AND NEXT DAY IT BROKE DOWN. WHEN I TOOK THE CAR TO THE DEALER, THE SERVICE MANAGER EXPECTED TO BE A SMALL FIX, SINCE THE CLUTCH WAS NORMALLY OPERATING ON 11/11/09 AND IT SUDDENLY FAILED ON 11/12/09. AFTER A REVIEW, THE DEALER IS CHARGING ME $2200, BECAUSE THEY NEED TO REPLACE

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CAM, ROCKERS, AND THE DUEL MASS FLY WHEEL IN HIS ENGINE FAILED. THE VEHICLE WAS TAKEN TO THE DEALER AND HE WAS ADVISED THAT HE NEEDED TO REPLACE VARIOUS COMPONENTS IN THE ENGINE AT AN EXPENSE OF $6500.00. THE VOLKSWAGEN MANUFACTURER WAS NOTIFIED, AND HE WAS ADVISED THAT BECAUSE HIS WARRANTY EXPIRED HE WAS INELIGIBLE FOR A FREE REMEDY. THE FAILURE MILEAGE WAS 114,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

EPC LIGHT CAME ON AND BRAKE LIGHTS DO NOT TURN OFF EVEN WHEN CAR IS TURNED OFF. NEED TO REPLACE BRAKE SWITCH AND EVERYTHING IS FIXED. *TR