2004 Volkswagen Beetle

Defect. The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Risk. A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy. Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.

Risk. IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.

Remedy. DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Defect. CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Risk. LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Defect. ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Risk. THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy. DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Defect. ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.

Risk. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.

Remedy. DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Certain subject vehicles, model year (my) 2003 convertible and my 2004 sedan and convertible vehicles are equipped with an advanced dual-stage air bag system.the air bag crash sensors (#1f0 909 606) contain a solder joint on the circuit board that may crack under certain high temperature conditions.if this occurs, the air bag indicator light will illuminate and the control module will enable a fallback algorithm that will ensure that the front air bag always deploys in a frontal crash in which the vehicle's deceleration is high enough to activate the frontal air bags.however, in low-severity …

Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices

Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a …

VW Elsa Newsletter

Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. This function will retrieve all of the MVBs from the transmission which can be attached to a VTA ticket. This selection is available under Guided Functions or GFF when …

Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same time. In some instances the new transmission will require an updated TCM.

09A Transmission -- Replacing Transmission

DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT ANY POWER. DRIVERS PASSING BY ARE STARING. THE SUV BEHIND YOU IS RIGHT ON YOUR BUTT; THEY BEGIN HONKING. THERE'S NOTHING YOU CAN DO. FINALLY, AFTER 20 SECONDS OF COASTING THE CAR ENTERS 3RD GEAR WITH A GIANT LURCH. IT FEELS LIKE IT'S GOING TO EXPLODE! YOU PULL INTO THE GROCERY STORE PARKING LOT, HEART RACING, KNOWING THAT

AIR BAG LIGHT NEVER GOES OFF, STARTED AT 33650 MILES, RIGHT AFTER MY MOM SIGNED OVER THE CAR TO ME.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED FOR TWO MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR WHICH WAS A PART OF THE DRIVER'S FRONTAL SEAT BELT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

AIR BAG LIGHTS ON AND SEEMS THE DEALER CANNOT GET PARTS TO FIX ??

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT A SLOW RATE OF SPEED, THE CONTACT SMELLED BURNING RUBBER AND THE VEHICLE'S RADIO STOPPED WORKING. AS THE CONTACT PROCEEDED DRIVING, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING. THE CONTACT STATED THAT THE VEHICLE SHUT COMPLETELY OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS ABLE TO DIAGNOSE THE VEHICLE AND HAD THE FUSE BOX REPLACED, YET THE FAILURE STILL PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

WHEN DRIVING THE CAR SHUTS OFF IN TRAFFIC IN TOWN AND ON THE HIGHWAY. 2 TIMES NO CHECK ENGINE LIGHT CAME ON. ONE TIME LIGHT CAME ON. MECHANIC IS NOT SURE WHY. I HAVE READ SEVERAL SIMILAR OCCURANCES ONLINE BY OTHER OWNERS. SOUNDS LIKE A RISK FOR FATALITY TO ME. MY DAUGHTER JUST BOUGHT THIS CAR FROM ANOTHER PARTY.

2004 BEETLE WITH 85,000 MILES HARD SHIFTING DOWN - IT JERKS FROM GEAR TO GEAR UNTIL IT COMES TO FULL STOP. . NOW WHILE UPSHIFTING IT COULDN'T MAKE IT OUT OF 3RD GEAR AND HAVE ALMOST BEEN REAR ENDED 3 TIMES. CAR JERKS ,SHUDDERS, LURCHES . TRANSMISSION PROBLEM IS CONSISTENT WITH LOW MILEAGE VW BEETLES

I BOUGHT MY VW BEETLE 2004 USED 3 MONTHS AGO. (EPC LIGHT ON, CHECK ENGINE LIGHT ON) SINCE THEN IVE HAD TO FIX THE TIMING BELT, COOLING, AND HOSES BECAUSE OF BACKFIRE. I GOT NOTIFIED THAT THERE IS A RECALL IN MY CAR, YET WENT TYPING THE VIN # IT SAYS IT NO RECALLS HAVE BEEN FOUND FOR MY CAR. I HAVE DOCUMENTATION TO SHOW THE REPAIRS AND COSTS. I'M WONDERING WHO DO I CONTACT TO DETERMINATE IF MY CAR DOES HAVE A REAL OR NOT.

THE PASSENGER FRONT SEAT HEATER WAS LEFT ON POWER LEVEL 3 WITH A BAG OF CLOTHES IN THE SEAT. AN ODOR WAS DETECTED AND UPON MOVING THE BAG, AN APPROXIMATELY 6' X 10' BURN WAS DISCOVERED ON LOWER PORTION OF THE SEAT BACK.

I BOUGHT THE NEW BEETLE NOT EVEN A MONTH AND I NOTICED A JERKING IN THE TRANSMISSION. I FOUND OUT USING SPECIALIZED WEBSITES FOR ENTHUSIASTS THAT VOLKSWAGEN ISSUE LETTERS TO OWNERS OF NEW BEETLES IN 2010 INFORMING THAT TONS OF OWNERS COMPLAINED ABOUT THE HARD SHIFT THEY WERE EXPERIENCING IN THE AUTOMATIC TRANSMISSION OFTHEIR NEW BEETLE. VOKSWAGEN OFFERED TO EXTEND THE WARRANTY ON THE TRANSMISSION VALVE BODY. THE MODELS AFFECTED SPANS FROM 2003 TO 2008. IN OTHER WORDS, VOLKS SOLD FAULTY CARS WITHING THIS TIME RANGE AND ONLY RECOGNIZED LATER IN 2010 ABOUT THE ISSUE. HOWEVER, THE VALVE BODY FAILURE IN THE TRANSMISSION IS ACROSS THE BOARD AND A RECALL SHOULD HAVE BEEN ISSUED FOR THE RANGE OF 2003-2008. THE COMPONENT WAS DESIGNED TO FAIL BY DESIGN. NOT EVEN THE REPLACEMENT WOULD FIX IT BECAUSE IT WOULD HAPPEN AGAIN. IMAGINE THE DANGER WHEN THERE IS A HARD-SHIFT AND THE CAR STARTS TO JERK AND CHANGING GEARS ERRATICALLY ? IMAGINE THIS HAPPENING ON I95 OR ANY OTHER HIGHWAY. VW JUST EXTENDED THE WARRANTY BUT A RECALL IS NEEDED HERE. I CALLED VW AND THEY ARE REFUSING TO FIX IT SAYING IT IS AN OLD CAR AND WARRANTY IS EXPIRED, BUT THE TRUTH IS SINCE 2003 THE HARD SHIFT CONDITION EXISTED. IT TAKES TIME FOR THE VALVE BODY TO FAIL BUT IT WILL FAIL. I HAVE OTHER CARS, BUT WHEN I NOTICED THE JERK I INVESTIGATED. I ATTACHED THE LETTER THAT I OBTAINED FROM THE NEW BEETLE.ORG SITE AND THERE THERE IS A DETAIL EXPLANATION HOW THE AUTOMATIC TRANSMISSION WILL FAIL DUE TO THE DESIGN

FEUL LEAK, REAR PASSANGER SIDE RIGHT. SAME SIDE THAT THE FUEL FILL IS ON.

THE FUSE BOX IS BURNING BECAUSE SOME CABLES ARE TOO SMALL AND ACCORDING TO THE MECHANICS, IT IS SOMETHING EXTREMELY COMMON BUT ACCORDING TO ME, IT IS NOT SUPPOSED TO HAPPEN.

CONTINUED HEADLAMP FAILURE RE: HEADLAMP COVER GLASS / LEXAN COMES OFF AND FLYS OFF OF CAR. SEVERAL OWNERS REPORT SAME PROBLEM. CREATES HAZERDOUS DEBRIS WHEN IT HAPPENS ON HIGHWAY AND ALSO EXPOSES HEADLAMP LIGHTS DIRECTLY TO WEATHER AND CAUSES FAILURE.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FELT AS IF IT WERE IN NEUTRAL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR SHIFTER IN PARK AND THEN BACK INTO DRIVE, AND WAS ABLE TO RESUME DRIVING. THE CONTACT STATED THAT SHE HAD TO REPEAT THE SAME PROCEDURE FIVE TIMES UNTIL SHE REACHED HER DESTINATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PERRYSBURG AUTO MALL (26875 N DIXIE HWY, PERRYSBURG, OH 43551, PHONE NUMBER: (419) 874-4331) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

VW CHECK ENGINE LIGHT ON, OBD SENSOR PORT NOT READING, BATTERY LIGHT CAME ON, AND ABS LIGHT CAME ON, NOW RADIO IS GOING ON AND OFF. STARTED YESTERDAY MORNING,WHILE DRIVING TO WORK THE ABS STARTED AFTER WORK ON THE WAY HOME.

THE GEARBOX SLIPS, STUTTERS AND JERKS . AND WILL SLIP OUT OF GEAR AND NOT GO BACK IN GEAR UNTIL ENGINE IS RESTARTED. THIS HAPPENS WHEN STARTING TO MOVE FROM A STOP.

WINDOW REGULATORS ARE EASY TO BREAK.

TRANSMISSION LOCKS UP, NOISY UPSHIFT AND DOWNSHIFTS. WHILE DRIVING UNPREDICTABLE GEAR SHIFTS.

AIR BAG LIGHT CAME ON LAST YEAR, RESOLVED. BACK ON, I SEE OLD RECALL? WHAT TO DO?

MY TRANSMISSION WENT OUT ALL AT ONCE MY AIRBAG/SEATBEILT LIGHT ON ALL THE TIME

THE FIRST TIME I ROLLED WINDOWS DOWN IN MY DRIVEWAY SO THAT I COULD TAKE TOP DOWN. THEY WOULD NOT ROLL UP PROPERLY TO MAKE A CONNECTION TO THE TOP CONVERTIBLE OF THE CAR. SO THE CAR WAS NOT WEATHER SAFE.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT ANY SPEED, WHEN THE VEHICLE SLOWED DOWN TO APPROACH A STOP SIGN OR TRAFFIC LIGHT, IT WOULD DOWNSHIFT INDEPENDENTLY. THE VEHICLE BECAME INOPERABLE AND HAD TO BE PULLED OVER, TURNED OFF, AND RESTARTED. THE MECHANIC STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TRANSMISSION SLIPS, JERKS , DOWNSHIFTS , VEHICLE BECOMES DISABLED ON ROADWAY, DANGER TO DRIVER, PEDESTRIANS AND OTHER VEHICLES ON THE ROADWAYS. THERE IS A CLASS ACTION SUIT IN LOUISIANA REGARDING THIS PROBLEM . THIS PROBLEM HAPPENS WHILE VEHICLE IS IN MOTION 10-15 MINUTES AFTER IT IS IN MOTION .

1. AIR BAG: THE AIR BAG INDICATOR LIGHT IS ILLUMINATING. 2. SUNROOF DRAIN SYSTEM CLOGGED: THERE IS LEAKAGE THROUGH THE SUNROOF OF THE PASSENGER SIDE. ALL RAIN WATER IS COMING IN FROM THE PASSENGER DOOR. AFTER ABOUT 2 WEEKS OF THUNDER STORMS THE CAR HAS WATER ALL OVER THE INSIDE AND THE CEILING AND SMELLS BAD. (AS SOON AS I FOUND OUT THE SUNROOF LEAKAGE PROBLEM OF THIS CAR, I FOUND THAT HE U.S. COURT OF APPEALS FOR THE THIRD CIRCUIT HAS APPROVED A $69 MILLION SETTLEMENT STEMMING FROM A CLASS-ACTION LAWSUIT THAT STARTED IN 2007 OVER LEAKING SUNROOFS. HTTP://WWW.CARCOMPLAINTS.COM/NEWS/2014/VOLKSWAGEN-SETTLES-LAWSUIT-LEAKING-SUNROOFS.SHTML)

POWER PASSENGER SIDE REAR WINDOW. STOPPED 3/4 OF WAY UP, HEARD A "CRACK". ROLLED DOWN AND NO LONGER WORKS.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED, FLUID WAS LEAKING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT COOLANT WAS LEAKING AND AN UNKNOWN HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. ON ANOTHER OCCASION, THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, A BURNING ODOR EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN AND THE WATER PUMP KIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, THE CONTACT STATED THAT AFTER THE VEHICLE WAS STARTED AND SWITCHED INTO THE DRIVE POSITION, IT FAILED TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CLUTCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000.

JUST PURCHASED THIS VEHICLE IN NOVEMBER 2015, FEBRUARY 29, 2016 THE VEHICLE WOULDN'T START, HAD MY SONS JUMP IT AND DROVE IT TO WORK, AFTER TURNING VEHICLE OFF TRIED TO START AGAIN RIGHT AWAY, VEHICLE DEAD. MADE AN APPOINTMENT MARCH 4, 2016 WITH VOLKSWAGEN DEALERSHIP, THEY STATED THAT THE ISSUE IS A BURNT ALTERNATOR CABLE AND MELTED FUSE BOX. AFTER READING NUMEROUS ACCOUNTS ONLINE, IT SEEMS THAT IS GOES OUT BETWEEN 70,000 - 80,000 MILES, MY VEHICLE HAD 79,000 MILES WHEN IT HAPPENED. VOLKSWAGEN ISN'T DOING ANYTHING ABOUT IT EVEN THOUGH IT IS A COMMON COMPLAINT I'VE SEEN...WANTING VOLKSWAGEN TO PAY FOR REPAIR...VERY FRUSTRATED, DON'T THINK I WOULD OWN ANOTHER VOLKSWAGEN AGAIN!...IF THIS IS THE WAY THEY TREAT CUSTOMERS. THERE WASN'T A FIRE, BUT IT COULD'VE HAPPENED, ISN'T VOLKSWAGEN CONCERNED ABOUT INDIVIDUALS SAFETY, THINK THEY SHOULD RESOLVE THE ISSUE BY PROVIDING A DIFFERENT SOLUTION TO HOW THE VEHICLE IS DESIGNED PERTAINING TO THE FUSE BOX, ETC.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE ALTERNATOR CABLE MELTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

FOR THE PAST 3-4 YEARS MY BEETLE HAS HAD WORSENING ELECTRICAL ISSUES. SOMETIMES IT JUST TURNS OFF ALL BY ITSELF. EVERYTHING ELECTRICAL GOES OUT. IT HAS EVEN HAPPENED WHILE DRIVING, I WAS IN TRAFFIC AND IT SHUT OFF. I WAS NEARLY KILLED.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE CONVERTIBLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE JERKED AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED BUT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

IN 2008 I TOOK MY VW BEETLE TO THE VW DEALERSHIP SERVICE DEPARTMENT IN MURRIETA, CA ON DATE STREET AND THEY HAVE RECORD THAT THEY FIXED THE AIR BAG LIGHT/ AND REPLACE THE SWITCH WHICH WAS LIT UP ON MY DASH INSTRUMENT PANEL. WELL I TOOK THE SAME CAR 2004 VW BEETLE BACK ON 08/17/2015 AT 8:15 AM SO THEY COULD TAKE CARE OF MY AIRBAG LIGHT WHICH CAME ON AGAIN AT 107,000 MILES. I UNDERSTAND THAT THERE ARE SEVERAL SWITCHES FROM THE SEATBELTS TO THE FRONTEND AND ALSO BEHIND THE CARS DASH THAT CAN CAUSE THE AIRBAG LIGHT TO COME ON BUT, BEING THIS IS A LIFE SAVING PART ON MY CAR I DO NOT FEEL I SHOULD HAVE TO PAY FOR A RECALL SERVICE AND PART ON MY RETURN VISIT. AS I SEE IT THIS IS A DEFECT AND A SAFETY HAZARD AND I SHOULD NOT BE CHARGED A $126.00 TO DIAGNOSE THE ISSUE AND PAY MORE FOR THE PART AND SERVICE TO FIX A DEFECTIVE ITEM. IF I'M INCORRECT PLEASE ADVISE ME SO I CAN UNDERSTAND HOW THIS IS MY FAULT. I THOUGHT IF YOU FIXED THE PROBLEM THEN IT SHOULD BE ON THE COMPANY OR PERSONS WHO REPAIRED THE RECALL ISSUE. THANK YOU VERY MUCH AND I WOULD APPRECIATE A RESPONSE TO MY FRUSTRATION WITH THIS ISSUE. *TR

IT STARTED WITH THE BATTERY LIGHT COMING ON. I MADE IT HOME. I TURNED OFF THE CAR AND WHEN I TRIED TO RESTART, DEAD. I FIRST ASSUMED THE BATTERY NEEDED TO RECHARGE AND DID THAT. IT WOULDN'T HOLD A CHARGE. WHEN I LOOKED AT THE FUSE BLOCK ON TOP THE BATTERY, IT WAS MELTED! ALONG WITH THE WIRE GOING TO THE ALTERNATOR. THIS SEEMS TO BE A VERY COMMON COMPLAINT WITH THESE VEHICLES.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THE BATTERY FUSE BOX WAS HEATED AND POTENTIALLY NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,300.

I WAS DRIVING 25 MPH AND MY FRONT BUMPER HIT A PARKED CAR, AIRBAG DEPLOYED AND RENDERED ME UNCONSCIENCE IT CAUSED $12,000 TO MY TEETH AND POSSIBLE HEAD INJURY AND 18 MONTHS AT A SPECIALIST DENTAL, HAD TO HAVE A BONE GRAPH AND STINT IN MY MOUTH, LIVER AND ABDOMINAL CONTUSION HAD TO PAY AN ATTORNEY $9,000 TO AN ATTORNEY TO REPRESENT ME IN COURT, I LOST MY JOB AND AM NOW ON SSD

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT 40 MPH, THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 03V356000 (AIR BAGS), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 117,600.

APRIL 2014, THE MECHATRONIC UNIT FOR MY 2004 VW NEW BEETLE TDI FAILED. IT WOULD SURGE IN AND OUT GEAR. THIS PART WAS RECALLED OVERSEAS BUT NOT IN THE USA. THIS JANUARY 2015 WHAT I HAD A TURBO FAILURE AND A DUAL MASS CLUTCH FLYWHEEL FAILURE. THIS IS THE DSG 6 SPEED AUTOMATIC TRANSMISSION. THE SPECIAL FLYWHEEL HAS FAILED, IT HAS A HOLE IN THE OUT CASING AND THE INTERNAL SPRINGS INSIDE ARE SLOWING BREAKING UP AND WERE SHOOTING OUT THE ASSEMBLY. THESE PIECES THEN SOMEHOW MANAGED TO MACHINE THE TRANSMISSION BELLHOUSING CREATING AT LEAST 3 HOLES IN THE TRANSMISSION CASE. THE CAR SERIOUSLY VIBRATES AT IDLE BUT WHEN UNDER POWER THE CAR RUNS NORMAL. THERE IS A GRINDING SOUNDS ALSO WHEN AT IDLE. I AM AMAZED THAT THE TRANSMISSION HASN'T CATASTROPHICALLY FAILED YET. THIS WOULD BE A POTENTIAL CRASH IF NOT REPAIRED. ARE THERE ANY OTHER CASES SIMILAR TO THE AFOREMENTIONED PROBLEMS. PLEASE HELP! *TR

TRANSMISSION PROBLEM ONLY WHEN AT USE FOR 20MIN STARTS TO THUMP IN ALL GEARS. BUT MOSTLY NOTICEABLE AT 3 AND 4. SOMETIME LOCKS AT 3 AND HAVE TO TURN OFF AND LET REST TO ENGAGE 1 AGAIN. *TR

ATTEMPTED TO START VEHICLE. VEHICLE ACTED AS IF THE BATTERY WAS DEAD. OPENED HOOD AND FOUND A PARTIALLY MELTED FUSE BOX FUSES, BURN MARKS AND MELTED WIRES. *TR

THE WINDOWS ON THE DRIVER SIDE WILL NOT ROLL UP. THEY HAVE BEEN REPAIRED ON THE PASSENGER SIDE. THIS LEADS ME TO BELIEVE THAT THIS IS A VOLKSWAGEN PROBLEM. I HAVE NOT REPAIRED THE WINDOW SIDE AS OF THIS DATE. IF THERE IS A RECALL, PLEASE ADVISE. I NEED THIS FIXED AS SOON AS POSSIBLE. I WAS TOLD IT WAS THE WINDOW REGULATOR. *TR

THE BACK PASSENGER WINDOW MOTOR WAS REPLACED. TODAY 12/09/14 NOT THE FRONT PASSENGER WINDOW MOTOR NEEDS REPLACED. I THINK THIS IS FAULTY. THIS IS A COMMON OCCURRENCE ACCORDING TO THE LOCAL VW REPAIR DEALERSHIP. *TR

DRIVER'S SIDE SEAT BELT WIRING HAS FAILED THUS ILLUMINATING THE AIR BAG LIGHT. THE SEAT BELT WIRING IS OF MINUTE DIAMETER WITH LITTLE SHIELDING AND POOR CONDUIT. BECAUSE THE SEAT BELT MUST FLEX WHEN MOVING THE SEAT FORWARD, THE STRAIN ON THE WIRING IN THE SEAT BELT RIPS THE WIRING FROM IT'S SOLDERED JOINT. THIS CAUSES THE AIR BAG LIGHT TO ILLUMINATE AND CAUSES THE AIR BAG SYSTEM TO REVERT TO A BACKUP ALGORITHM THAT PUTS THE DRIVER IN A DANGEROUS ENVIRONMENT. THIS "BACKUP" ALGORITHM WILL NOT MONITOR VEHICLE SPEED AND WILL AUTOMATICALLY DEPLOY THE AIRBAG AT A DEFAULT AMOUNT OF FORCE REGARDLESS OF IMPACT FORCE. THIS MEANS THAT A MINOR FENDER BENDER THAT REACHES THE AIRBAG FORCE THRESHOLD COULD DEPLOY THE AIRBAG AT A FORCE TOO GREAT AND CONVERSELY A HIGH SPEED IMPACT MAY DEPLOY THE AIRBAG WITH INSUFFICIENT FORCE. THIS IS AN EXTREMELY COMMON PROBLEM ON THIS MODEL YEAR VEHICLE. A QUICK INTERNET SEARCH WILL ALERT YOU AS TO HOW COMMON THIS PROBLEM IS. AFTER CALLING MY LOCAL DEALERSHIP, THEY TOLD ME "WE REPLACE A TON OF THOSE SEATBELTS." VOLKSWAGEN SHOULD ACKNOWLEDGE THIS EGREGIOUS MANUFACTURING DEFECT AND RECALL THIS DEFECTIVE PART BEFORE FATAL CONSEQUENCES FURTHER PROVE THIS IS A DEADLY AND EXTREMELY COMMON PROBLEM. *TR

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT AFTER ACTIVATING THE TURNING SIGNAL, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING COLUMN. ADDITIONALLY, THE INSTRUMENT PANEL SHORTED AND SMOKE CAME FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN WAS UNABLE TO DETERMINE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000. THE VIN WAS UNAVAILABLE.

EXITING GARDEN STATE PARKWAY SB ENGINE CUT OUT IN THE MIDDLE OF THE EXIT RAMP. HAD TO BE PUSHED OFF AND THEN TOWED. DEALER DIAGNOSED THAT IT WAS THE TIMING BELT TENSIONER. THIS IS NOT COVERED UNDER MY USED CAR WARRANTY HOWEVER THIS IS A KNOWN PROBLEM WITH THE 2.0L TURBO MOTORS. I CONTACTED VW CUSTOMER SERVICE WHO TOLD ME THAT THEY DO NOT HAVE ANY RECALLS OR TECHNICAL BULLETINS FOR THIS PART. I AM AWARE THAT THE PART THAT IS FAULTY ON THE TIMING BELT TENSIONER WAS ONLY CORRECTED IN 2012. I PERSONALLY KNOW SOMEONE WHOSE ENTIRE ENGINE WAS REPLACED UNDER WARRANTY DUE TO THE FAILURE OF THIS PART . THE FAULTY PART BEING REPLACED IS A SPRING. I UNDERSTAND THAT MY VEHICLE IS NOT IN WARRANTY HOWEVER THE PROBLEM IS KNOWN BY VW AND I SHOULD BE EITHER PARTIALLY OR ENTIRELY COVERED FOR THIS REPAIR. IF YOU WANT TO DO YOUR OWN RESEARCH, THIS PROBLEM IS VERY EASY TO FIND ON THE INTERNET. *TR

I HAVE NOTICED A QUARTER SIZE BURN STARTING TO HAPPEN ON THE SEAT SECTION OF THE FRONT PASSENGER SEAT MY SON HAD THE SEAT HEATER ON THIS MORNING WHEN DRIVING TO SCHOOL NO BURN NOTICED ON HIS LEG THE CAR IS A CONVERT ABLE BEETLE 2003 THE SEAT IS IN REASONABLE CONDITION .LEATHER STILL SUPPLE WITH NO VISUAL DEFECTS APART FROM SLIGHT DISCOLORATION AND SOME PERIPHERAL CRACKING ON THE EXTERIOR SEAT SECTION. WILL NOT BE ABLE TO TURN ON HEATED SEAT. *TR

CAR HAS SUDDEN JERKY WHEN SHIFTING ALSO REAR WINDOWS WILL NOT ROLL UP OR DOWN. DEALERSHIP SAID NEEDS NEW TRANSMISSION BUT HAVE ONLY HAD CAR 8 MONTHS. THE WINDOWS QUIT WORKING AFTER OWNING IT FOR ONE WEEK COST 400 JUST TO FIX ONE WINDOW. DEALERSHIP ESTIMATE TO FIX TRANSMITION 6700.00. *JS

ENGINE STALLS WHILE DRIVING. EPC AND CHECK ENGINE LIGHT GOES ON. LOSS OF POWER STEERING. IT IS A VERY DANGEROUS PROBLEM. IT HAS HAPPENED MULTIPLE TIMES. THE LAST TIME WAS 7/8/2014, THE VEHICLE IS IN THE SHOP. I AM AFRAID TO DRIVE IT. REPAIRS HAVE NOT BEEN SUCCESSFUL IN THE PAST. VOLKSWAGEN HAS BEEN CONTACTED THEY SAY NOT RECALLS ARE LISTED. *TR

MY 16 YEAR OLD DAUGHTER DRIVES THIS CAR. INITIALLY THE HEADLIGHT WAS BURNT OUT. ORDERED A NEW HEADLIGHT AND INSTALLED IT AND IT WORKED FINE FOR ABOUT AN HOUR. THEN MY DAUGHTER DROVE THE CAR APPROXIMATELY 10 MILES. WHEN SHE ARRIVED AT HER DESTINATION SHE ATTEMPTED TO TURN THE CAR OFF BUT THE KEY WOULD NOT COME OUT OF THE IGNITION. WHEN I ARRIVED I COULD SMELL SOMETHING BURNING AND THE CAR BATTERY WAS NOW DEAD. I HAD THE BATTERY JUMPED BUT NOW THE HEADLIGHT THAT I JUST REPLACED WAS NOT WORKING AGAIN, AND NOW THE BRAKE LIGHTS AND THE RUNNING LIGHTS WERE NOT WORKING. THE NEXT MORNING THE BATTERY WAS DEAD AGAIN. WHEN WE FINALLY GOT OVER TO THE MECHANIC THE WIRING WAS COMPLETELY MELTED AND THE HEADLAMP MODULATOR WAS BLOWN. THE WINDOW WASHER FLUID RESERVOIR WAS MELTED AND RUINED. AFTER ABOUT $1000 IN REPAIRS THE MECHANIC IS EXPLAINING THIS IS JUST THE ONE SIDE, THE WIRING FOR THE OTHER SIDE IS GOING TO NEED TO BE REPLACED IN NEXT 6 MONTHS OR SO. HE EXPLAINED THIS IS A COMMON OCCCURANCE WITH THESE CARS. I AM HONESTLY AFRAID TO ALLOW MY DAUGHTER TO DRIVE THE CAR AS IT SEEMS IT IS A FIRE HAZARD. *JS

MY ENGINE LIGHT CAME ON AND THE AC STOPPED BLOWING COLD AIR. I ALSO NOTICED A BEEP SOUND THAT WOULD COME ON WHEN I TURNED THE HEADLIGHTS ON BUT THE SOUND WOULD TURN OFF AND ON WHILE I DROVE. THEN THE ALARM STOPPED WORKING AND THE INTERIOR LIGHTS MALFUNCTIONED, THE RADIO ALSO GAVE OUT AND THE VEHICLE SEEMED TO HESITATE WHILE DRIVING IT. I CHECKED THE FUSE BOX ON THE BATTERY AND DISCOVERED THAT THE SLOT WHERE THE FUSE SLIPS INTO ON TOP OF THE VEHICLE BATTERY WAS MELTED AND THERE WAS SOMETHING ON THE DRIVER SIDE HEADLAMP COVER LIKE SOME TYPE OF GAS OR FUMES HAD ESCAPED THE BATTERY AND SPRAYED THE HEADLAMPCOVER. I CHANGED THE FUSES AROUND AND GOT THE AC GOING AGAIN, THEN I CHANGED THEM ALL OUT, AND EVERYTHING WORKED GREAT FOR ABOUT 5 DAYS, THEN THE INTERIOR LIGHTS WENT OUT AGAIN, THE ALARM STOPPED WORKING, RADIO IS OUT, THE BEEPING SOUND IS BACK AND WHEN I CHECKED THE FUSE, IT WAS MELTING AGAIN. I AM AFRAID THAT WHILE IN THE VEHICLE WITH MY CHILDREN I WILL HAVE A MALFUNCTION AND BE INJURED. I JUST PAID OFF THE VEHICLE... WHAT A GIFT FOR PAYING OFF A VEHICLE... SEEMS LIKE EVERYTHING IN AND ON THAT VEHICLE IS A HAZARD AND AN ACCIDENT WAITING TO HAPPEN.. ITS SAD BECAUSE I USE TO LOVE MY NEW BEETLE. *TR

THE BATTERY TO ALTERNATOR WIRE ON THESE CARS OVERHEATS AND CATCHES FIRE. I OWN A CAR DEALERSHIP AND JUST HAD IT HAPPEN TO ME. I WAS LUCKY AND STOPPED ANYTHING HORRIBLE FROM HAPPENING BUT MOST PEOPLE WOULD NOT KNOW ENOUGH TO STOP IT OR THAT IT WAS HAPPENING. THESE CARS ARE A HUGE FIRE HAZARD AND YOU NEED TO ISSUE A RECALL. CHECK THE PICTURES OF BURNED CARS ON GOOGLE. YOU WONT FIND ONE COMPLAINT BUT MANY AND PLENTY OF BURNED CARS. SO I ASK THAT YOU DO YOUR BEST TO FIX THIS ISSUE. THE CAR I OWN HAS A HISTORY OF THE ALTERNATOR BEING SERVICED. OBVIOUSLY A RECALL ISSUE THAT MAYBE VW SHOULD FIGURE OUT HOW TO FIX INSTEAD A BAND AID AND OUT THE DOOR. CHECK CAR FAX ON THIS CAR. IF SOMEONE LET THERE CAR WARM THEY COULD BURN DOWN THERE HOUSE. I AM GOING TO REROUTE THIS WIRE AND REPLACE IT WITH A BETTER GRADE OF WIRE. *TR