2014 Triumph Rocket Iii Roadster

Defect. Triumph Motorcycles America, LTD (Triumph) is recalling certain model year 2014-2015 Triumph Thunderbird, Thunderbird ABS, Tiger 800,Tiger 800 ABS, Thruxton, and Bonneville motorcycles manufactured February 6, 2014, to August 7, 2014. The engine control unit may improperly activate the fuel injectors.

Risk. Improper signalling to, and activation of, the fuel injectors could cause the engine to unexpectedly lose power, increasing the risk of a vehicle crash.

Remedy. Triumph will notify owners, and dealers will modify the internal ECU hardware, free of charge. The recall began December 4, 2014. Owners may contact Triumph customer service at 1-678-854-2010. Triumph's number for this recall is SB519.

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

CHANGING GEARS FROM 4TH INTO 5TH THE TRANSMISSION LOCKED UP CAUSING THE REAR WHEEL TO LOCK UP AND SLIDE. I IMMEDIATELY PULLED THE CLUTCH LEVER AND THE REAR WHEEL RELEASED. I MOVED TO THE SIDE OF THE ROAD AND SHIFTED INTO 1ST GEAR, WHEN RELEASING THE CLUTCH THE TRANSMISSION WAS STILL LOCKED UP. THIS WAS EXTREMELY UNSAFE AS I WAS TRAVELING AT OVER 65 MPH ON A BUSY INTERSTATE.