2001 Toyota Tundra complaints

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE THE VEHICLE WAS STATIONARY, IT BECAME RUSTED AND SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO TNC TOYOTA OF MARIETTA, OHIO WHERE IT WAS TREATED FOR RUST AND CORROSION WITH A SPRAY COATING PER A RECALL. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 08/22/17*LJ THE CONSUMER STATED AFTER THE VEHICLE WAS REPAIRED THE CORROSION WORSENED. THE DEALER STATED SINCE THE CONSUMER SIGNED THE COMPLETED REPAIR ORDER THE WOULD NOT BE ABLE TO ASSIST WITH THE REPAIR. UPDATED 08/28/2017*JS

LOWER DRIVERS SIDE BALL JOINT POPPED OUT GOING DOWN HYWAY. TIRE ENDED UP COLLAPSING IN ON DRIVERS FENDER DOOR AND BROKE CV SHAFT AND TWISTED A ARMS. VERY DANGEROUS. NO PRIOR SIGN OF CLUNKING OR POPPING.

NTSB: 2001 TOYOTA TUNDRA PICKUP HAS RUSTING ON THE UNDER PART OF THE VEHICLE. *BF THE CONSUMER BOUGHT THE VEHICLE USED AND WAS UNAWARE THERE WAS A RECALL FOR THE UNDERBODY RUSTING. THE CONSUMER WAS INFORMED THE RECALL HAD EXPIRED. THE CONSUMER FELT THE MANUFACTURER SHOULD HONOR THE RECALL. *JS

I WAS DRIVING IN A TOYOTA TUNDRA 2001 WITH MY PREGNANT WIFE AND TWO GOATS IN THE BED, WHEN I DROVE OVER A SMALL BUMP BY A LITTLE BRIDGE WHEN I HEARD A NOISE AND LOST CONTROL OFF THE TRUCK ALMOST HITTING A TREE. I WAS WITHIN A HALF MILE FROM MY HOME SO WHEN I GOT HOME I INSPECTED THE TRUCK TO FIND OUT THE LOWER CONTROL ARM BROKE OFF . IF YOU DRIVE THE TRUCK NOW IT WILL PULL THE TRUCK HARD TO THE LEFT AND IT FEELS LIKE ITS ABOUT TO FALL APART. TOYOTA ALSO HAD A SO CALLED RECALL ON THE FRAMES BUT, EVEN STILL THE FRAME IS IN TERRIBLE CONDITION AND THEY REFUSE TO HELP . IM MOST PISSED BECAUSE THIS HAPPENED WHILE MY WIFE WAS IN THE TRUCK AND WE ALREADY LOST ONE CHILD TOGETHER.

TRUCK HAS RUSTED HOLES IN FRAME. REPORTED TO TOYOTA, WAS TOLD IT WAS LOOKED PREVIOUSLY, NO LONGER UNDER RECALL. FOUND OUT LATER WAS DENIED FRAME REPLACEMENT TO PREVIOUS OWNER WHILE STILL UNDER RECALL.

FRAME ON MY VEHICLE IS RUSTED THROUGH. TOOK TO WILDE TOYOTA IN WEST ALLIS, WI. TECHNICIAN INSPECTED FRAME AND CONCLUDED "FRAME RUSTED THRU - NOT SAFE" . NO OTHER ACTION WAS TAKEN BY DEALER.

THE FUEL TANK FELL OUT OF MY TRUCK DUE TO RUST ON THE STRAPS. I WAS TOLD THERE WAS ONCE A RECALL FOR THIS PROBLEM. I TOOK MY TRUCK TO MY LOCAL GARAGE TO GET IT FIXED BECAUSE IT WAS CLOSER. I HAD TIED THE FUEL TANK TO THE TRUCK TO GET THE TRUCK TO THE SHOP. I SUPPLIED TOYOTA WITH THE INFORMATION AND RECEIPTS. THEY ARE REFUSING TO REIMBURSE ME.

THE FRAME WAS PART OF A RECALL, NOW TOYOTA REFUSES TO FIX IT UNLESS I PAY THEM $850 FOR PARTS THEY NEED TO CUT OFF IN ORDER TO REPLACE THE FRAME.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE HAVING THE VEHICLE INSPECTED FOR A MANDATORY ANNUAL STATE INSPECTION, THE VEHICLE FAILED DUE TO CORROSION OF THE SUBFRAME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CORROSION WOULD HAVE TO BE WELDED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE CORROSION PROTECTION COMPOUND WAS NOT AN ADEQUATE PREVENTIVE MEASURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

I CONTACTED TOYOTA ABOUT RUSTING OF MY 2001 TUNDRA WITH 137000 MILES ON IT. THERE ARE HOLES THAT YOU CAN PUT YOUR THUMB THROUGH IN THE FRAME. TOYOTA SAID THERE WAS A LIMITED RECALL AND IT HAS EXPIRED. WHY IS THIS NOT A SAFETY RECALL? IS THERE ANY RECOURSE HERE?

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT OBSERVED THAT THE FRONT PASSENGER SIDE FRAME WAS DETERIORATED AND RUSTED OUT A TWO INCH CIRCUMFERENCE HOLE. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 12V345000 (STRUCTURE:BODY), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. INSTEAD OF THE FRAME BEING REPLACED, THE CONTACT STATED THAT IT WAS SPRAYED PREVIOUSLY WITH A COMPOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000.

I PURCHASED THIS VEHICLE NEW IN 2000 AND HAD THE ENTIRE UNIT UNDERCOATED FOR RUST PROTECTION AND SOUND PROOFING. THE TRUCK HAS BEEN GARAGED SINCE NEW AND SINCE I TRAVEL FOR BUSINESS HAS LOW MILEAGE. THIS IS MY PERSONAL VEHICLE NOT A WORK TRUCK. AS TIME WENT ON I BEGAN NOTICING THE RUST UNDER THE CHASSIS AND THEN I RECEIVED A RECALL NOTICE FOR THE SPARE TIRE BRACKET. I FOUND OUT LATER THAT TOYOTA USED THE SPARE TIRE RECALL TO UNDERSTAND THE MAGNITUDE OF THE CHASSIS RUST PROBLEM. A SHORT TIME LATER I RECEIVED THE RECALL FOR THE CHASSIS EXCHANGE. WHEN I PICKED UP THE TRUCK THERE WAS SOMETHING WRONG WITH THE STEERING, THE WHEEL DID NOT RETURN TO STRAIGHT AFTER A TURN. I COMPLAINED THAT NIGHT AND WAS TOLD IT WAS NORMAL. AFTER A FEW HINDERED MILES THE LINKAGE WAS WORN AND HAD TO BE REPLACED. MY MECHANIC TOLD ME THE CAB WAS NOT ALIGNED TO THE RACK WHEN THEY CHANGED THE CHASSIS. MY COMPLAINT IS WITH THE ROT ISSUE. THE REAR AXLE IS NOW ROTTED TO A POINT WHERE IT IS LEAKING THOUGH THE CASING, NOT THROUGH A SEAL OR FITTING BUT THROUGH THE ROTTED METAL. I DO NOT VIEW A REAR AXLE AS A WEAR/REPLACEMENT PART UNLESS IT IS ABUSED THROUGH THE WORKING OF THE TRUCK. I AM 62 YEARS OLD AND HAVE BEEN DRIVING SINE 16 AND HAVE NEVER EVER HAD TO REPLACE A REAR AXLE FOR ROT. THE FACT THAT TOYOTA ACKNOWLEDGED OWNERSHIP FOR THE CHASSIS RUST TELLS ME THAT THEY SHOULD OWN THE AXLE ROT AS WELL. I HAVE CALLED TOYOTA CORPORATE WITH NO SUCCESS AND AM LOOKING FOR SOME RELIEF ON THIS REPAIR. TOYOTA QUOTED ME APP

THERE WAS A RECALL ON 2000- 2003 TUNDRA FRAMES & BRAKE LINES I CONTACTED TOYOTA THAT FRAME WAS RUSTED & UNSAFE . TOYOTA FIRST ASKED IF I WANTED A BUY BACK OR A REPLACEMENT ON FRAME OF TRUCK . I ASKED FOR FURTHER DETAILS ON BOTH , THEY TAKE ALL MY INFORMATION & OPENED A CASE WITH # [XXX] THEY INFORMED ME A CASE MANAGER WOULD BE IN CONTACT WITH ME . WITHIN 72 HOURS I WAS CONTACTED BY CASE MANAGER [XXX] CAPTAIN WHO INFORMED ME THAT THE FRAME WAS TREATED WITH CORROSION RESISTANT COMPOUND & THERE WAS NOTHING ELSE TOYOTA WOULD DO FOR ME . I DON'T UNDERSTAND HOW THEY CAN SAY THEY TREATED THE FRAME & ITS ROTTED OUT ! THERE IS NO RUST ON ANY OF THE BODY PARTS OF THIS TRUCK . NOW I HAVE A TRUCK WITH A GOOD BODY , MOTOR , & TRANS THAT IS NOT SAFE TO DRIVE CAUSE THE FRAME IS ROTTED OUT . I DID FORGET TO ASK TOYOTA IF THEY WOULD REIMBURSE ME FOR THE BRAKE LINES I PAID TO HAVE REPLACED EVEN THOUGH THEY WERE ON RECALL ALSO . I HOPE WITH THE HELP OF NHTSA THAT TOYOTA WILL HAVE TO HONOR THE RECALL ON MY TRUCK . THANK YOU FOR YOUR HELP IN THIS MATTER . SINCERELY [XXX]EMAIL [XXX] PH # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

SUMMARY: PURCHASED 2001 TOYOTA TUNDRA IN APRIL 2015 FROM FAULKNER BUICK GMC OF WEST CHESTER PA.APRIL 2015 THE DEALER PASSED INSPECTION WHILE ACTIVE RECALLS ON FRAME CORROSION WERE NOT COMPLETE,CORRODED FRAME PRESENT.PER CURRENT INSPECTION FAIL-3-2016-THIS SHOULD NEVER HAVE BEEN PASSED IN 2015 BY DEALER. FAULKNER BUICK GMC OF WEST CHESTER PA, 705 AUTOPARK BLVD,WEST CHESTER, PA 19382 1.THE PRIOR USED CAR DEALER PASSED INSPECTION 2015,SHOULD HAVE FAILED FOR ROTTED FRAME (LEGAL ISSUE);2.PRIOR OWNER,USED CAR DEALER-IGNORED ALL PAST/CURRENT FRAME RECALLS;3.PURCHASED TRUCK 4-2015;4.FAIL INSPECTION-ROTTED FRAME 3-2016;5. TRICOUNTY TOYOTA,LIMERICK, PA,3/15/16 - THEY TOLD MY SON ITS NOT ROTTED ENOUGH, DRIVE A FEW MONTHS AND SEE IF ITS WORSE (EVEN THOUGH THERE IS AN ACTIVE RECALL NOW.;6.WENT TO CONICELLI TOYOTA - CONSHOHOCKEN,PA MARCH17, 2016 - VERY HELPFUL IN TESTING THE CORROSION, THEY AGREE ITS ROTTED THRU, NO WAY TO FIX OTHER THAN COMPLETE REPLACEMENT OF FRAME, SEVERAL TESTS AND PICS GIVEN TO TOYOTA "FIELD REP." ONE MONTH LATER DETERMINES THAT TOYOTA WILL NOT FIX ENTIRE FRAME, ONLY THE SMALL PORTION CURRENTLY UNDER THE ACTIVE RECALL (HOWEVER, THE DEALER SAYS THEY CANT FIX NOR PASS INSPECTION BECAUSE THE REST OF FRAME IS STILL ROTTED - CATCH 22). TOYOTA NOW REFUSES TO FIX THE ENTIRE FRAME - EVEN THOUGH THROUGH PRIOR RECALLS THEY SHOULD HAVE DONE ANYWAY. THEY CANNOT FIX THE PORTION OF FRAME UNDER CURRENT RECALL DUE TO REMAINING CORROSION. I HAVE PASSES ONTO CORPORATE TOYOTA CASE#16041

TAKATA RECALL IS THIS VEHICLE INVOLVED WITH THE LATEST AIRBAG RECALL?

PURCHASED 2001 TOYOTA TUNDRA IN APRIL 2015 FROM FAULKNER BUICK GMC OF WEST CHESTER PA.APRIL 2015 THE DEALER PASSED INSPECTION WHILE ACTIVE RECALLS ON FRAME CORROSION WERE NOT COMPLETE,CORRODED FRAME PRESENT.PER CURRENT INSPECTION FAIL-3-2016-THIS SHOULD NEVER HAVE BEEN PASSED IN 2015 BY DEALER. FAULKNER BUICK GMC OF WEST CHESTER PA, 705 AUTOPARK BLVD,WEST CHESTER, PA 19382 1.THE PRIOR USED CAR DEALER PASSED INSPECTION 2015,SHOULD HAVE FAILED FOR ROTTED FRAME (LEGAL ISSUE);2.PRIOR OWNER,USED CAR DEALER-IGNORED ALL PAST/CURRENT FRAME RECALLS;3.PURCHASED TRUCK 4-2015;4.FAIL INSPECTION-ROTTED FRAME 3-2016;5. TRICOUNTY TOYOTA,LIMERICK, PA,3/15/16 - THEY TOLD MY SON ITS NOT ROTTED ENOUGH, DRIVE A FEW MONTHS AND SEE IF ITS WORSE (EVEN THOUGH THERE IS AN ACTIVE RECALL NOW.;6.WENT TO CONICELLI TOYOTA - CONSHOHOCKEN,PA MARCH17, 2016 - VERY HELPFUL IN TESTING THE CORROSION, THEY AGREE ITS ROTTED THRU, NO WAY TO FIX OTHER THAN COMPLETE REPLACEMENT OF FRAME, SEVERAL TESTS AND PICS GIVEN TO TOYOTA "FIELD REP." ONE MONTH LATER DETERMINES THAT TOYOTA WILL NOT FIX ENTIRE FRAME, ONLY THE SMALL PORTION CURRENTLY UNDER THE ACTIVE RECALL (HOWEVER, THE DEALER SAYS THEY CANT FIX NOR PASS INSPECTION BECAUSE THE REST OF FRAME IS STILL ROTTED - CATCH 22). TOYOTA NOW REFUSES TO FIX THE ENTIRE FRAME - EVEN THOUGH THROUGH PRIOR RECALLS THEY SHOULD HAVE DONE ANYWAY. THEY CANNOT FIX THE PORTION OF FRAME UNDER CURRENT RECALL DUE TO REMAINING CORROSION. I HAVE PASSES ONTO CORPORATE TOYOTA CASE#1604132198, HO

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS RUSTED OUT WITHOUT WARNING. THE DEALER REPAIRED THE VEHICLE FOUR YEARS AGO AND STATED THAT NOTHING COULD BE DONE FOR THE RECENT FAILURE. THE MANUFACTURER STATED THAT THE FRAME WAS ALREADY SPRAYED, SO NOTHING COULD BE DONE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING 65 MPH, THE DRIVER SIDE WHEEL DETACHED FROM THE VEHICLE. IN ADDITION, THE VEHICLE SLID 100 FEET INTO THE MEDIAN AFTER THE FAILURE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER SIDE UPPER BALL JOINT FRACTURED, WHICH RESULTED IN THE DRIVER SIDE WHEEL DETACHING. THE A ARM, RIM, TIRE, CALIPERS, AND UPPER BALL JOINT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V22500 (SUSPENSION), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 268,000.

IN 2010 TOYOTA HAD A RECALL ON THE FRAME AND SPARE TIRE HOLDER RESULTING IN THE SPARE TIRE COMING OFF AND CAUSING ACCIDENTS. I WAS NOTIFIED BY MAIL TO GET THE FRAME/CROSS MEMBER CHECKED BY THE CLOSEST DEALER POSSIBLE. SO I SET UP AN APPOINTMENT WITH JOHNSON CITY TOYOTA IN TENNESSEE AND WHEN THE PART WOULD ARRIVE THEY WOULD CALL ME. I NEVER GOT THE PHONE CALL SO AFTER TWO MONTHS OF WAITING I CALLED THE DEALERSHIP AND THEY HAD TOLD ME THE RECALL HAS EXPIRED AND I'M OUT OF LUCK. I HAD BOUGHT THE 2001 TUNDRA IN JULY 11, 2011 SO I REALLY DIDN'T HAVE MUCH TIME FROM THE GET GO AND WASN'T TOLD ABOUT THE RECALL WHEN I BOUGHT THE TRUCK FROM AN INDIVIDUAL SELLER,"MIGHT FAULT" FOR NOT GOING OVER THE WHOLE THING ANYWAY, BUT MY PROBLEM IS THAT THE FRAME AND THE SPARE TIRE HOLDER IS AN ACCIDENT WAITING TO HAPPEN. SO I HAD CALLED CORPORATE IN 2012, AND TODAY WITH A VERY DISAPPOINTING ANSWER TWICE THAT THE RECALL IS NO LONGER AVAILABLE AND THAT THEY CAN NOT HELP ME. MY CASE NUMBER WITH TOYOTA CORPORATE IS 1601253399 FROM TODAY BUT I DO NOT HAVE THE CASE NUMBER FROM THE 2012 CALL. ALSO I HAVE A FRIEND THAT HAS A 2002 TACOMA THAT WAS ALSO RECALLED FOR THE SAME REASON AND HIS FRAME HAD GOTTEN REPLACED IN JULY 2013 AT JIM BARKLEY TOYOTA IN ASHEVILLE,NORTH CAROLINA WHICH GOES COMPLETELY AGAINST WHAT I'M BEING TOLD. I HOPE THAT THIS IS THE INFO THAT YOU NEED BUT PLEASE CONTACT ME IF PICTURES ARE NEEDED OR WITH ANY DETAILS. I HOPE YOUR THE RIGHT PEOPLE THAT CAN HELP ME, IF NOT CAN YOU SEND ME TO THE

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING LESS THAN 5 MPH, THERE WAS AN ABNORMAL NOISE HEARD ON THE FRONT DRIVER SIDE OF THE VEHICLE. THE FRONT DRIVER SIDE LOWER BALL JOINT FRACTURED WITHOUT WARNING AND CAUSED THE CONTACT TO COAST THE VEHICLE OFF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V225000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 304,000.

THE L/F LOWER BALL JOINT BROKE WHILE VEHICLE WAS BEING DRIVEN, CAUSING A GREAT DEAL OF COLLATERAL DAMAGE TO THE FOLLOWING COMPONENTS WHICH NEED TO BE REPAIRED AND REPLACED: L/F LOWER BALL JOINT; L/F KNUCKLE POPPED OUT FROM UPPER BALL JOINT; RACK PINION ASSEMBLY BIND AND TWISTED WHEN LEFT FRONT COLLAPSED; L/F AXLE SHAFT POPPED OUT AND GREASE OUT; L/F CALIPER HOSE BROKEN; ALIGNMENT NEEDED AS PART OF REPAIR. DUE TO FAILURE OF L/F BALL JOINT, SERVICE TECH RECOMMENDS REPLACING R/F LOWER BALL JOINT TO AVOID ANOTHER CATASTROPHIC FAILURE AND DANGER OF INJURY DUE TO AUTO CRASH. FORTUNATELY, THE BALL JOINT AND ALL OTHER DAMAGE DID NOT OCCUR UNTIL DRIVER HAD EXITED INTERSTATE AND WAS JUST PULLING INTO A PARKING LOT, OTHERWISE, A SERIOUS CRASH COULD HAVE ENSUED WITH INJURY TO DRIVER. THERE WAS NO WARNING WITH THIS BALL JOINT FAILURE, TRUCK HANDLED NORMALLY UNTIL ABRUPT FAILURE IN PARKING LOT. EXPENSE TO REPAIR NEARLY $5000.

ADDENDUM TO REFERENCE NUMBER 10785255 ON 1/7/16, CHRIS ADAMOS [OPERATIONS MANAGER] CALLED FROM TOYOTA HEADQUARTERS DUE TO MY ONGOING CONCERNS OFT RUST PERFORATION COMPROMISING MY FRAME, MAKING IT UNSAFE. I EXPLAINED THAT I AM CONCERNED THAT 1) THE CRC INTERVENTION [PROPOSED BY TOYOTA] DID NOT REMEDY A PROBLEM [THAT HAD BEEN IDENTIFIED BY TOYOTA], 2) THUS THE PROBLEM REMAINS UNRESOLVED, AND 3) SAFETY ISSUES CONTINUE TO EXIST AND THAT THE FRAME IS ACTUALLY WORSE THAN IT HAD BEEN WHEN INSPECTED IN 2012. CHRIS STATED, 'THE CRC WAS NOT MEANT TO REMEDY THE PROBLEM, IT WAS MEANT TO MITIGATE THE PROBLEM.' HE EXPLAINED THAT, WHEN THE 2012 RECALL INSPECTIONS OCCURRED, 'IF A FRAME WAS PERFORATED, IT WAS REPLACED. IF THERE WAS NO PERFORATION, THE CRC WOULD BE APPLIED AND THAT MAY HELP FOR 6 MONTHS, A YEAR, OR 3 YEARS IN YOUR CASE, BUT IT WAS APPLIED WITH THE THOUGHT THAT IT WOULD EVENTUALLY FAIL.' I EXPLAINED THAT WAS NOT MY UNDERSTANDING OF THE CRC'S ROLE WHEN THE DEALER DISCUSSED THE PLAN IN 2012. I HAD BEEN MADE TO BELIEVE THAT THE CRC WAS TO PREVENT ANY FURTHER CORROSION WHICH WOULD COMPROMISE THE FRAME'S INTEGRITY. I EXPLAINED THAT HAD I KNOWN THE CRC WAS ONLY 'BAND-AIDING' THE PROBLEM, I WOULD HAVE SOLD THE TRUCK IN 2012. NOW, THE VEHICLE CANNOT PASS AN INSPECTION WHICH IS NEEDED TO BE SOLD, NOR WOULD I WANT TO SELL THE VEHICLE TO OTHERS BECAUSE IT IS UNSAFE. CHRIS ACKNOWLEDGED THAT OWNERS WHO RECEIVED FRAME REPLACEMENTS HAD THE PROBLEM RESOLVED. HE ALSO ACKNOWLEDGED TOYOTA WAS AWA

THE FRAME ON MY 2001 TOYOTA TUNDRA WAS COATED WITH A CORROSIVE RESISTANT COMPOUND [CRC] PER BILL KIDD TOYOTA DEALER IN 2012 DUE TO "SAFETY RECALL BOD & 90M & SERVICE CAMPAIGN AOF." IN 2015, PRIORITY TOYOTA [VA] STATED MY FRAME HAD RUST PERFORATIONS & NEEDED A FULL FRAME REPLACEMENT. PRIORITY TOLD ME TO CONTACT TOYOTA HEADQUARTERS ASAP TO EXPLAIN THE DANGEROUSNESS OF THE VEHICLE'S COMPROMISED STRUCTURE. MY CASE MANAGER AT HEADQUARTERS, AUTUMN, & ANOTHER REPRESENTATIVE [ERICA] INFORMED ME THAT TOYOTA WON'T OFFER AN OUT OF WARRANTY ASSISTANCE NOR A "GOOD WILL GESTURE." BOTH EXPLAINED THAT HEADQUARTERS HAS APPROVED FRAME REPLACEMENTS AFTER THE SERVICE CAMPAIGN'S EXPIRATION BASED ON THE FOLLOWING: REPAIR COSTS [I WAS TOLD REPAIRS ON MY TUNDRA WERE CONSIDERED 'EXTENSIVE,'] AGE/MILEAGE, CUSTOMER LOYALTY AND SERVICE RECORDS. I WAS DENIED A FULL FRAME REPLACEMENT; HOWEVER, I'M IN CONTACT WITH ANOTHER TOY CONSUMER WHO EXPERIENCED A SIMILAR ISSUE WITH A 2001 TUNDRA WITH APPROX THE SAME MILEAGE WHO HAD THE FRAME REPLACED THIS YEAR. WHEN I SHARED THESE CONCERNS WITH HEADQUARTER'S SUPERVISOR, JESSIE HAYWOOD, HE STATED: "THE CRC HAS NOT BEEN EFFECTIVE AND SOMETHING SHOULD BE DONE ABOUT IT" AS HE IS AWARE OF HUNDREDS OF TUNDRA, SEQUOIA, AND TACOMA CUSTOMERS WHO HAVE EXPERIENCED RUST PERFORATION ON THE FRAMES DESPITE THE CRC APPLICATION. MR. HAYWOOD RECOMMENDED THAT I CONTACT THE NHTSA RE MY SAFETY CONCERNS AS WELL AS MY REPORT THAT TOYOTA HAS OFFERED "SECRET WARRANTIES" TO SOME CONSUMERS BUT

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE AND DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFUSED TO PROVIDE ANY ASSISTANCE OR APPROVE THE FRAME REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000. UPDATED 02/10/16*LJ ...UPDATED 02/19/16 *BF CONSUMER TOOK THE VEHICLE TO DEALER (4/19/12) UPDATED 05/18/18*JB

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING AT AN UNKNOWN SPEED, AN ABNORMAL BANGING NOISE EMITTED FROM THE REAR OF THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE REAR CROSS MEMBER WAS COMPLETELY CORRODED AND THE REAR SHOCK WAS FRACTURED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED UNDER AN UNKNOWN MANUFACTURER CUSTOMER SATISFACTION CAMPAIGN IN WHICH THE VEHICLE WAS TREATED FOR RUST. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 164,000.

TOOK MY 2001 TUNDRA IN FOR THE FRAME RECALLS. I HAD 52616 MILES ON A GARAGE KEPT TRUCK. THEY SAID MY FRAME WOULD BE FINE AND WOULD HAVE A CRC COMPOUND APPLIED APR 2012. AFTER A FEW WEEKS I TOOK IT BACK IN SINCE THE COMPOUND WAS FALLING OFF, MAY 2012. THEY REAPPLIED THE CRC. I TOLD THEM I HAD CONCERNS OVER SPRAYING OVER RUST, BUT SAID THEY WERE SURE TOYOTA WOULD STAND BEHIND IT. FEB 2014 THE TECHNICIAN MADE A COMMENT ABOUT THE RUST AND LACK OF COMPOUND VISIBLE. FEB 2015 THE TECHNICIAN AGAIN SAID IT WAS CLEAR THAT THE CRC WAS ALMOST GONE. HE MADE A NOTE OF IT ON THE SERVICE REPORT. I ASKED THEM TO CONTACT THE CORP OFFICE ABOUT IT. A FEW WEEKS LATER THE DEALERSHIP SAID THAT CORP WOULDN'T SPRAY IT AGAIN, BUT THAT THE DEALERSHIP WOULD SPRAY IT. 27 JUNE 2015 DRIVING HOME FROM WORK ON INTERSTATE 41, THE FRONT STRAP HOLDING THE GAS TANK BROKE, MILEAGE 58325. I GOT THE TRUCK TO THE DEALERSHIP AND HAD NEW STRAPS INSTALLED. THE TECHNICIAN SAID THEY ACTUALLY HAD TO DRILL AND TAP AND MOUNT THE FRONT STRAP IN A DIFFERENT LOCATION DUE TO SEVERE ROTTING OF THE FRAME. AFTERWARDS I FOUND OUT THAT THE STRAPS SHOULD HAVE BEEN REPLACED DURING PHASE 2 OF SSC 90. I CALLED TOYOTA CORP CASE# 1507131315. THE FIRST CASE MANAGER GEORGE SAID RIGHT AWAY TOYOTA WOULD DO NOTHING FOR ME. THEN I TOOK MY TRUCK TO THE GAS STATION TO FILL IT UP FOR THE FIRST TIME. GAS STARTED POURING OUT ONTO THE GROUND. I BASICALLY CALLED EVERY DAY TILL I GOT JEFFERY MOORE AS MANAGER. HE GOT MY STRAPS AND TANKS REPLACED BUT SAI

TOOK CAR TO DEALER FOR FRAME RECALL. THEY SAID FRAME WAS FINE AND JUST NEEDED A REAR CROSS MEMBER. THEY ALSO SAID THEY WILL CLEAN ALL RUST OFF FRAME AND PUT PROTECTIVE COATING ON IT. INDEED THEY DID BUT DID NOT CLEAN ANY RUST OFF. AND THAT MEANS THIS UNDERCOATING WILL BE OFF IN LESS THEN 6 MONTHS. WHERE THERE WAS HEAVY RUST SCALING AND ALL OTHER RUST. THEY JUST SPRAYED OVER THE TOP OF THE RUST AND MISSED MANY SPOTS. WHEN I GOT HOME AND INSPECTED. THERE ARE HOLES IN THE FRAME I CAN STICK MY HAND IN. I AM DUMB FOUNDED HOW THIS WAS MISSED. OR MAYBE IT WAS MENT TO BE MISSED BECAUSE THEY DID NOT WANT TO REPLACE THE FRAME. FRAME NEEDS TO BE REPLACED UNDER RECALL PLANE AND SIMPLE. THE PICTURES TELL THE WHOLE STORY. THE FRAME IS 100% CLEARLY WITHOUT A DOUBT ROTTED THROUGH. THE BODY ON THE TRUCK IS NEAR MINT WITH NO ROT OR RUST. AND JUST A FEW LITTLE DINGS. TOYOTA NEEDS TO FOLLOW THROUGH ON THE RECALL IN PLACE. VERY DISAPPOINTED IN METRO TOYOTA OF CLEVELAND.

AFTER HAVING TIRES PLACED ON 2001 TUNDRA, THE MECHANIC & HIS SUPERVISOR ADVISED ME TO GO TO NEARBY TOYOTA DEALER DUE TO CONCERNS OF RUST COMPROMISING FRAME. [IN APRIL 2012, THE FRAME RECEIVED A CORROSIVE RESISTANT COMPOUND DUE TO SAFETY RECALL 90M AS TOYOTA DID NOT FEEL THE FRAME QUALIFIED FOR A FULL FRAME REPLACEMENT. I WAS INFORMED THAT CRC WOULD PREVENT THE RUSTING THAT INITIATED THE RECALL]. UPON ARRIVING AT THE TOY DEALER, THE STAFF IMMEDIATELY REQUESTED AN INSPECTION AS THEY HAD SEVERAL INCIDENCES OF OWNERS COMPLAINING OF CRC'S FAILURE TO PREVENT RUSTING. THE INSPECTOR LOCATED A HOLE ON THE FRAME'S FRONT PASSENGER SIDE. I WAS ADVISED TO CONTACT TOY HEADQUARTERS ASAP AS THE FRAME COULD FOLD UP UPON MYSELF & PASSENGERS IN A COLLISION. I CONTACTED TOY HEADQUARTERS ON 8/12/15 AND SPOKE WITH SHAE AND THEN ADRINA, WHO ULTIMATELY ASSIGNED ME TO CASE MANAGER, AUTUMN. WHEN AUTUMN CONTACTED ME 2 DAYS LATER, SHE INFORMED ME THAT I "HAD PARTICIPATED IN THE CAMPAIGN IN APRIL 2012 AND THIS CAMPAIGN EXPIRED IN DECEMBER 2012." SHE EXPLAINED THAT "ONCE THE CAMPAIGN HAS EXPIRED, THE FRAME IS NOT COVERED." SHE EXPLAINED TOYOTA WOULD DO NOTHING TO ASSIST FURTHER. I EXPLAINED THAT TOY'S CRC "REMEDY" HAD FAILED TO STOP THE RUST ISSUE WHICH INITIATED THE ODI INVESTIGATION AND SUBSEQUENT RECALL. THE CRC HAD ONLY MANAGED TO MASK THE PROBLEM UNTIL THE "CAMPAIGN" EXPIRED AND TOYOTA WAS NO LONGER LEGALLY OBLIGATED TO ADDRESS THE STILL-EXISTING PROBLEM. RESEARCH INFORMED ME THAT MYSELF AND HUNDREDS

THE TOYOTA SAFETY RECALL WORK DONE IN 2012 TO TREATED MY VEHICLES FRAME TO PREVENT RUST PERFORATION HAS FAILED. DURING NH STATE INSPECTION AREAS WHERE THE FRAME HAD RUSTED THROUGH WERE IDENTIFIED. THESE AREAS HAD BEEN TREATED UNDER TOYOTA'S GUIDANCE AND AT THEIR EXPENSE. DUE TO FRAME RUST PERFORATION, AND RUST ISSUES IDENTIFIED BELOW MY VEHICLE WOULD NOT PASS INSPECTION. TOYOTA OF PORTSMOUTH, WHERE THE INITIAL RECALL WORK WAS INITIATED, AND TOYOTA MOTOR SALES HAVE BOTH DENIED TO REMEDY THIS SITUATION. MANY OTHER 2001 TOYOTA TUNDRA OWNERS WERE PROVIDED COMPLETE FRAME REPLACEMENTS. I WAS PROVIDED WITH A RUST TREATMENT THAT HAS FAILED TO CORRECT THIS SAFETY ISSUE. THE STATE INSPECTION WAS REQUESTED BY ME PRIOR TO SPENDING $2,776 (AND UP TO $5,000 OR MORE IF INTERNAL PARTS WERE DAMAGED) TO REPLACE A RUSTED THROUGH AND LEAKING REAR DIFFERENTIAL CASE THAT COULD HAVE SEIZED UP AT HIGHWAY SPEEDS IF I HAD NOT NOTICED THE LEAK. THIS INSPECTION ALSO IDENTIFIED FOR THE SECOND TIME A RUSTED THROUGH AND LEAKING EXHAUST MANIFOLDS (THE LEFT MANIFOLD WAS "STARTING" TO LEAK ON 09/16/2014 WHEN THE TRUCK LAST PASSED INSPECTION. I HEARD THE TICKING SOUND, CHARACTERISTIC OF THIS LEAK, SINCE THE VEHICLE WAS UNDER WARRANTY AND TOLD IT WAS NORMAL. THE BODY AND BED OF MY TRUCK WAS DETERMINED BY A LOCAL BODY SHOP TO BE IN GOOD CONDITION WITH MINIMAL RUST. THIS WAS DETERMINED BY VISUAL INSPECTION AND THE CONDITION OF THE LOWER PORTIONS OF THE DOORS WHICH ARE FREQUENTLY A TROUBLE SPOT IN STATES WHERE ROA

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE SECONDARY HOOD RELEASE-LEVER FRACTURED DUE TO CORROSION, WHICH MADE IT DIFFICULT TO OPEN THE HOOD. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS ADVISED THAT THE PART NEEDED WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 102,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE REAR DRIVER SIDE SUBFRAME PERFORATED DUE TO EXCESSIVE CORROSION. IN 2012, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (SUSPENSION); HOWEVER, THE FAILURE RECURRED. THE REMEDY CONSISTED OF SPRAYING A CORROSION PROTECTOR ONTO THE ENTIRE FRAME, WHICH FAILED TO PREVENT THE SUBFRAME CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 370,000.

TL* THE CONTACT OWNED A 2001 TOYOTA TUNDRA. WHILE AT A COMPLETE STOP, THE CONTACT'S VEHICLE WAS STRUCK BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 45 MPH. THE FRONTAL AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS DESTROYED. BOTH DRIVERS WERE TRANSPORTED TO THE HOSPITAL BY AMBULANCE. A POLICE REPORT WAS FILED. THE CONTACT HAD TO STAY IN THE HOSPITAL FOR THREE DAYS. THE CONTACT RECEIVED CARDIAC IMPACT WITH THE STEERING WHEEL BECAUSE THE AIR BAG DID NOT DEPLOY. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 11/12/15*LJ UPDATED 1/4/2015 *JS

I LEFT MY DRIVEWAY TO DO SOME ERRANDS AND WHEN I RETURNED I THOUGHT SOMEONE HAD THROWN AN OLD TIRE ON MY PROPERTY. TO MY DISMAY I QUICKLY REALIZED IT WAS MY SPARE TIRE WITH THE ROTTED HOIST STILL FROZEN TO THE INSIDE OF THE RIM. I HAD ALREADY TAKEN MY TRUCK TO A DEALER FOR UNDER CARRIAGE ROTTING RECALL. THANK GOD THIS DIDN'T HAPPEN AT ANY OTHER TIME, IT COULD HAVE KILLED PEOPLE. I DO A LOT OF HIGHWAY DRIVING.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 5 MPH, THE FRONT PASSENGER SIDE WHEEL DETACHED FROM THE AXLE AND CAUSED THE VEHICLE TO COME TO AN ABRUPT STOP WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE LOWER BALL JOINT ON THE FRONT PASSENGER SIDE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V225000 (SUSPENSION). THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

ON APRIL 11 2013 I PURCHASED A 2001 TOYOTA TUNDRA. MONTHS LATER WHILE CHECKING THE TIRE PRESSURES AT A GAS STATION, I WAS SHOCKED TO NOTICE THAT THERE WAS A HOLE IN THE FRAME ABOUT TWO INCHES ACROSS. I CALLED MY NEAREST TOYOTA DEALER, WOBURN FOREIGN MOTORS, AND SPOKE WITH NICOLE WHO RAN THE VIN NUMBER AND TOLD ME THAT JAFFARIAN TOYOTA IN HAVERHILL HAD INSPECTED THE TRUCK ON 20 APRIL 2012. THEREFORE, THEY WOULD NOT LOOK AT MY TRUCK. NEXT, I CALLED JAFFARIAN AND EXPLAINED THAT THE FRAME LOOKED TO ME AS IF IT COULD SNAP IN HALF, AND THAT I COULD NOT SEE HOW THAT MUCH RUST COULD OCCUR FROM WHEN THEY INSPECTED IT. THE SERVICE TECHNICIAN THEN SAID THAT IF THEY HAD INSPECTED AND PASSED THE TRUCK THEN THEY WOULD HAVE APPLIED A PRESERVATIVE UNDERCOATING TO THE FRAME. I POINTED OUT THERE WAS NO SUCH PAINT OR UNDERCOATING ANYWHERE TO BE SEEN ON THE FRAME. HE TRIED TO GET ME BACK ON THE RECALL LIST, BUT FOUND OUT THAT HE COULD NOT. BEING MY ONLY VEHICLE FOR USE TO MAKE A LIVING, I CONTINUED TO DRIVE THE TRUCK UNTIL 11 APRIL 2015, WHEN THE FRAME SNAPPED IN HALF AS I WAS ENTERING MY DRIVEWAY. I HAD BEEN ON INTERSTATE 95 AT 65 MPH ONLY MINUTES EARLIER, WHEN I EXPECT THE VEHICLE WOULD HAVE LOST CONTROL AND PROBABLY ROLLED OVER HAD THE FRAME SNAPPED THEN. IF THE VEHICLE WAS INDEED INSPECTED, THEN IT SEEMS EVIDENT THAT THE INSPECTOR WAS NEGLIGENT IN HIS DUTIES AND PASSED THE VEHICLE KNOWING THAT IT HAD SEVERE AND DANGEROUS CORROSION TO ITS CHASSIS. UNDER THESE CIRCUMSTANCES, I HAVE CONTACTED T

I PURCHASED THE VEHICLE IN OCTOBER 2014 AND WAS INFORMED ABOUT A FRAME CORROSION ISSUE CAUSING FAILURES AND FAILURE TO PASS VT STATE INSPECTIONS BY A FAMILY FRIEND IN JANUARY. I CONTACTED TOYOTA AND PROVIDED [XXX], THE CUSTOMER SERVICE REPRESENTATIVE WITH ALL VIN INFORMATION. HE LOOKED UP SERVICE RECORDS AND INFORMED ME THAT THE VEHICLE HAD A CORROSION APPLICATION APPLIED IN 2010 UNDER THE PREVIOUS OWNER AND THERE WAS NOTHING FURTHER REQUIRED. UNDER THE RECALL ACTION THAT WAS ALL REQUIRED BASED I MY VIN NUMBER. I DID ASK IF IT HAD ISSUES DISCOVERED WHAT WAS I TO DO, [XXX] TOLD ME TO CONTACT TOYOTA AGAIN IF THAT OCCURRED. I TOOK THE VEHICLE TO BE INSPECTED ON 27 MARCH, 2015 AT GROTON GARAGE, IN GROTON VT AND THE OWNER [XXX]. CONTACTED ME TO INFORM ME THAT IT COULD NOT BE INSPECTED DUE TO MULTIPLE FRAME CORROSION ISSUES THAT ARE FAILURES. HE ALSO KNEW OF THE RECALL ISSUE FOR FRAME CORROSION AND FAILURE AND TOLD ME TO CONTACT TOYOTA AGAIN. ON 30 MARCH I SPOKE WITH [XXX] WHO TOOK THE INFORMATION UPDATE THE DATA UNDER CASE # 1503303884 AND TOLD ME A SPECIALIST DEALING WITH THIS HIGH PROFILE ISSUE WOULD CONTACT ME WITHIN 1 BUSINESS DAY. I WAS CONTACTED THE NEXT DAY BY THORN WHO PULLED UP MY INFORMATION AND INFORMED ME THAT TOYOTA HAD COMPLETED THE FRAME APPLICATION IN 2010 AND THAT IS ALL THAT IS REQUIRED BY TOYOTA TO BE COMPLETED BY RECALL ACTION B0D. I INFORMED HIM THAT THE VEHICLE COULD NOT BE INSPECTED AFTER JUST PURCHASING DUE TO THE FRAME BEING CORRODED AND HE STATED TOYOTA R

TL*THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE) AND THE DEALER SPRAYED THE CROSS MEMBER WITH A CORROSION PROTECTION COMPOUND. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY REFUSED TO REPAIR THE VEHICLE UNDER THE RECALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS REPAIRED. THE DETAILS OF THE REPAIRS WERE UNAVAILABLE. THE FAILURE MILEAGE WAS 180,000.

SPARE TIRE HOLDER RUSTED & SPARE TIRE FLEW OFF INTO TRAFFIC. THIS IS A SAFETY ISSUE. *TR

THE FRAME IS THE FIRST MENTIONED IN RECALL WITH SUPPLEMENTAL CONDITIONS..... MY VEHICLE WAS DIAGNOST WITH PERFORATION IN SAID FRAME BUT WAS TOLD IT DIDNT ME SUPPLEMENTAL CONDITIONS. *TR

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE CROSS MEMBER WAS SPRAYED WITH A CORROSION PROTECTION COMPOUND ACCORDING TO NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE); HOWEVER, THE COATING WAS DETERIORATING. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000. UPDATED 3/30/15*CN THE CONSUMER STATED THE CROSSMEMBER WAS REPLACED AND THE FRAME WAS SPRAYED. UPDATED 7/8/2015 *JS

YOU MIGHT BE CURIOUS TO KNOW THAT THE FRAME RECALL THAT TOYOTA HAD AND THAT ENDED IN 2012 IS RECURRING ON THE TOYOTAS AGAIN. I HAD MINE CHECKED IN 2012 AND WAS TOLD IT WAS FINE BUT THEY WERE GOING TO UNDER COAT IT IN ORDER TO PREVENT IT FROM HAPPENING IN THE FUTURE. I WENT TO HAVE IT INSPECTED LAST WEEK FOR THEM TO TELL ME THAT THE FRAME IS SOFT AND RUSTED THROUGH WITH A HOLE, IN THE EXACT SPOT THE RECALL WAS REFERRING TO. I BROUGHT IT TO THE TOYOTA DEALERSHIP WHO DID THE UNDER COATING TO BEGIN WITH JUST FOR THEM TO CONFIRM THAT THE HOLE WAS THERE, THE RUST WAS OCCURRING BUT THE RECALL HAD ENDED IN 2012 AND THEY CAN NO LONGER HELP US. IN TURN THEY TOLD US TO CONTACT TOYOTA CORPORATION, WHICH WE DID, AND THEY TOLD US THEY CAN NOT HELP US EITHER BECAUSE THE RECALL HAD ENDED. THE REPRESENTATIVE ON THE PHONE AGREED WITH US BUT SAID THE CORPORATION WOULDN'T ALLOW HIM TO DO ANYTHING. SO, END RESULT IS WE ARE STUCK WITH A TRUCK THAT HAD A FRAME "FIXED" BUT IS NOW DOING THE SAME THING IT DID BEFORE BUT THE TOYOTA DEALERSHIP WON'T HONOR IT, NOR WILL THE CORPORATION. I SHOULD ADD WHEN I CONTACTED THE DEALERSHIP IN REGARDS TO THIS ONE OF THE FIRST THINGS THE TECHNICIAN SAID TO ME WAS THAT I WASN'T THE FIRST ONE TO COME BACK WITH A RUSTED FRAME. VERY SHADY AND UNRELIABLE. I WOULD HOPE THAT TOYOTA WOULD HONOR THEIR RECALLS THAT WERE PREVIOUSLY FIXED BUT APPARENTLY THAT'S NOT THE CASE. *TR

BOTH LOW BEAM HEADLIGHTS WENT OUT SIMULTANEOUSLY. SAFETY DRIVING LIGHTS ALSO DID NOT WORK. HIGH BEAM HEADLIGHTS DID WORK. TROUBLESHOOTING REVEALED THAT BOTH SYLVANIA SILVERSTAR 9033/HB2 H4 LIGHT BULBS BURNED OUT SIMULTANEOUSLY. THE HEADLIGHT BULBS ARE DANGEROUS AND SHOULD BE RECALLED ASAP. HAVING BOTH HEADLIGHTS BURN OUT AT THE SAME TIME IN INEXCUSABLE! IT NEARLY CAUSED ME TO CRASH AT HIGH SPEED. HAD TO DRIVE HOME USING MY HIGH BEAMS AND FOG LIGHTS. *TR

ON 11//18/0/01IRC'D A RECALL FOR EXCESSIVE CORROSION OF THE REAR CROSS MEMBER. IN 10/2012,I WAS INFORMED THAT THE TRUCK FRAME PASSED INSPECTION AND WAS GOOD.THEY DID REPLACE TWO GAS TANK STRAPS AND TOLD ME THE UNDERCOATING THAT SHOULD BE SPRAYED ON IT AS PART OF THE RECALL WAS NOT AVAILABLE.I NEVER RECEIVED ANY ADDITION CORRESPONDENCE REGARDING THE UNDERCOATING.ON 12/23,14 I TOOK MY TRUCK TO TJ TOYOTA FOR A TRAILER LIGHT WHIP REPAIR. AT THAT TIME, THE MECHANIC HAD ME LOOK AT THE FRAME RAIL.IT IS RUSTED SO BAD I COULD SEE RIGHT THROUGH THE RAIL.THE CONNECTION OF THIS RAIL TO THE FRAME HAS EXCESSIVE SCALING.THE TRUCK WAS DUE FOR AN INSPECTION AT THE END OF THE MONTH, AND I WAS TOLD THEY WOULD NOT DO AN INSPECTION.THE MECHANIC CONTINUED TO TELL ME HE FELT THE TRUCK WAS "JUNK" UNSUITABLE FOR TOWING ANYTHING.I CALLED 1-800-331-4331 AT TOYOTA AND SPOKE WITH [XXX], [XXX] AND [XXX]. [XXX] PROCESSED A CONFERENCE CALL WITH HERSELF, [XXX] AT TJ TOYOTA AND ME. [XXX] TOLD ME TO TAKE THE TRUCK BACK TO TJ TOYOTA TO REDO THE FRAME INSPECTION AND IF IT FAILED, TOYOTA WOULD REPLACE THE FRAME. HOWEVER, [XXX], FROM TJ TOYOTA STATED IT IS NOT CORRODED ON THE FRAME BUT IT IS ON THE RAIL CONNECTING TO THE FRAME. I ASKED WHAT THEY WOULD FOR ME AND HE STATED, SPRAY IT WITH UNDERCOATING. I ASKED WHAT THAT WOULD DO FOR THE TRUCK AND [XXX] STATED NOTHING?. NNYROADS ARE SALTED HEAVILY.IF THIS VEHICLE WAS NEVER UNDERCOATED OR PROTECTED FOR RUST, THE FACT THAT THE RAILS ARE RUSTED IS DUE TO NOT BEING PREPA

MY POWER STEERING STARTED MAKING A NOISE AND THE STEERING BECAME DIFFICULT. UPON CHECKING MY POWER STEERING FLUID AND ADDING SOME THERE WAS IMPROVEMENT, BUT I NOTICED I WAS LEAKING POWER STEERING FLUID. I TOOK THE TRUCK TO A LOCAL MECHANIC AND FOUND OUT THAT THE RUST ON THE UNDERNEATH OF THE TRUCK WAS SO SIGNIFICANT AND THAT A HOLE HAD ACTUALLY RUSTED THROUGH CAUSING THE LEAKAGE OF POWER STEERING FLUID. I HAD TO HAVE THE ENTIRE RACK AND PINION REPLACED. THE MECHANIC NOTIFIED ME AND ACTUALLY SHOWED ME ALL OF THE RUST CONCERNS. THERE IS SIGNIFICANT RUST ON THE FRAME AND OTHER HARDWARE PARTS ON THE UNDERNEATH OF THE TRUCK. TOYOTA NOTIFIED ME OF 2011 THAT THERE WERE SOME CONCERNS AND REQUEST I GO TO THE DEALERSHIP TO HAVE A COMPOUND PLACED ON THE FRAME TO PREVENT FURTHER RUSTING. I DID COMPLETE THIS AS REQUESTED, HOWEVER THE MECHANIC SHOWED ME THAT THE COMPOUND LOOKED LIKE IT WAS SPORADICALLY PLACED AND THAT IT BASICALLY DID NO GOOD. THE RUST ISSUE IS SIGNIFICANT. I CONTACTED TOYOTA ONCE I KNEW THE ISSUE WAS RUST RELATED AND AFTER TALKING WITH A COUPLE OF PEOPLE I SPOKE WITH SOMEONE AT HEADQUARTERS. HE BASICALLY TOLD ME THAT HE COULD NOT DO ANYTHING FOR ME UNLESS TOYOTA ISSUED ANOTHER FRAME RECALL. HE SAID THE COMPANY WAS CONSIDERING IT, BUT NO ISSUE HAS CAME OUT. I THEN STATED THAT IT SOUNDS LIKE TOYOTA KNOWS THAT THERE IS AN ISSUE, BUT IS NOT SURE IF THEY WANT TO OWN UP TO IT AND ADDRESS IT. THIS WAS NOT DENIED BY THE REPRESENTATIVE I WAS SPEAKING WITH. IN ADDITION TO THE FRAME

THE GEAR SHIFT LEVER HOUSING BROKE WHILE SHIFTING FROM DRIVE TO PARK. FORTUNATELY I WAS IN A PARKING LOT AND NOT SOMEPLACE WHERE I WOULD CAUSE A SAFETY ISSUE. I WAS UNABLE TO SHIFT UNTIL I TOOK APART THE PLASTIC COVERS AND FIGURED OUT HOW TO WORK THE SHIFT LINKAGE MANUALLY. THE SHIFTER HOUSING PIECE APPEARS TO BE A FAIRLY THIN PIECE OF CAST ALUMINUM AND BROKE IN SEVERAL SPOTS. A SEARCH ON THE INTERNET SHOWS THAT THIS IS A FAIRLY COMMON OCCURRENCE. *TR

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT IN JANUARY 2012 THE VEHICLE WAS TAKEN TO THE DEALER TO BE INSPECTED FOR FRAME CORROSION. AFTER INSPECTING THE VEHICLE THE MECHANIC DETERMINED THAT THE FRAME DID NOT NEED TO BE REPAIRED OR REPLACED AND SPRAYED THE FRAME WITH AN ANTI CORROSION SUBSTANCE CRC. IN OCTOBER 2014 THE VEHICLE FAILED AN INSPECTION DUE TO A PERFORATED SUB FRAME CAUSED BY CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN NUMBER WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 187,000.

I PURCHASED A 2001 TOYOTA TUNDRA EXTENDED CAB PICK UP TRUCK NEW IN FEB. 2001. THE VEHICLE WAS SERVICED AT A TOYOTA DEALERSHIP FOR YEARS. ON DEC. 11, 2011 I RECEIVED A RECALL NOTICE FROM TOYOTA (SSC 90M) REGARDING SEVERE CORROSION OF THE REAR CROSS-MEMBER. ON FEB. 18, 2012 THE TRUCK WAS SERVICED AT KOONS TOYOTA IN WESTMINSTER, MD. AT THAT TIME AN INSPECTION WAS COMPLETED AND THE PAPER WORK I WAS GIVEN INDICATED THE FOLLOWING; "INSPECT, REMOVE RUST & CLEAN FRAME, NO RUST EX SPEC, APPLY CRC. THE TRUCK WAS BACK AT THE SAME DEALERSHIP IN 2013 FOR A ROUTINE OIL CHANGE AND NO MENTION OF RUST WAS MADE BY THE SERVICE DEPARTMENT. IN OCT. 2014 THE VEHICLE WAS SERVICED AT A CERTIFIED AUTOMOBILE REPAIR STATION. AT THIS TIME I WAS INFORMED THE MECHANIC THAT MY FRAME WAS BADLY RUSTED. I HAVE CONTACTED TOYOTA AND THEY WILL ONLY SAY THE "CAMPAIGN" ON MY VEHICLE IS OVER. ALTHOUGH I REALIZE RECALL SSC 90M ENDED IN 2012 I BELIEVE THAT MY FRAME WAS RUSTED IN FEB. 2012 WHEN THE VEHICLE WAS AT A TOYOTA DEALERSHIP AND SHOULD HAVE BEEN FIXED AT THAT TIME. I BASE THIS ON THE OPINION OF 2 CERTIFIED AUTO MECHANICS AND 1 CERTIFIED AUTO BODY REPAIRMAN. ALL 3 INSPECTED MY VEHICLE AND OUR OF THE OPINION THAT THE AMOUNT OF RUST ON THE FRAME COULD NOT HAVE OCCURRED FROM 2012 TO 2014. THEY ADVISE THE FRAME WOULD HAVE HAD TO HAVE BEEN RUSTING IN FEB. 2012, BEFORE THE RECALL ENDED. *TR

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS CORRODED AND CAUSED THE PROTECTIVE COATING TO CHIP OFF. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 122,000. UPDATED 01/07/14*LJ THE CONSUMER STTED THE VEHICLE WAS TAKEN TO A MECHANIC HWO ADVISED THE FAILURE WAS DUE TO RUST JACKING. THE MACHANIC SUGGESTED THE VEHICLE BE TAKEN TO THE DEALER. THE DEALER STATED THERE WERE NO RUST HOLES. UPDATED 6/8/2015 *JS

WAS HIT HEAD ON AND AIR BAGS DID NOT DEPLOY. *TR

I HAD JUST PICKED UP THE TRUCK FROM KINGS TOYOTA, AFTER THEY HAD PUT A NEW FRAME ON THE TUNDRA; WAS DRIVING APPROXIMATELY 6 MILES WHEN I HAD TO USE FORCE TO STEER VEHICLE. I PULLED INTO MY DRIVEWAY AND LOOKED UNDER MY TRUCK. MY RACK WAS SO CORRODED. THERE WERE HOLES WITH LEAKS THROUGHOUT, BUT ONE HOLE ABOUT THE SIZE OF A PENCIL. TOOK TRUCK BACK TO DEALER (VERY ANGRY), WHERE THEY SAID I NEEDED A NEW RACK. IT WAS BEYOND REPAIR. *TR