2020 Toyota RAV4 complaints

Power rear hatch does not always open all the way, sometimes stops after 1" of rise. I must then manually close the rear hatch and try again and again.

We bought a 2020 Toyota Rav4 Limited with Sunroof. When we were driving in freeway, we noticed that a glass shattered somewhere in my car. We realized that the sunroof was completely shattered. There was no accident, just a heavy rain. We didn't know what to do, we didn't know if we have to call police in a matter as it was a potential safety hazard. We have seen a lot of complaint about this and there is no option to completely sealed it off or get rid of sunroof. We are now scared of driving this car in long distance, we will be trading this vehicle soon because of the incident.

Bought the car with 114k on it now with 115k and I brought it in to Toyota because I have a “engine maintenance required” on the dash now they are trying to charge me almost $1000 because my car has over 100k miles on it and they said they won’t cover it.

The contact owns a 2020 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message “Engine Maintenance Required” was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the heater control valve had failed and needed to be replaced. The vehicle was repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 47,000.

Shorted Coolant Bypass Valve, only 14500 miles on my 2020 Rav4, Class action Suit and dealerships want you to pay $800-$1000 to fix problem with a leaky defective plastic poorly designed valve that eventually leaks into the electrical connectors and shorts circuits the valve. There is no recall for this fix and Toyota won't honor the repair. This is a common issue and Toyota Turns a Blind Eye. Error Message: Engine Maintenace Required Call Toyota Dealership. I Did and they give me a song and Dance stating there is no recall for this issue. If i run the heater in the car the message for a few a minutes, then shut off vehicle maintenance warning will reset, once I turn on the AC it will come back on. So, I guess I have to keep the heater on all summer.

The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); for over a year. The contact stated that the vehicle was taken for routine maintenance, and the contact requested information on the possible recall repair and was informed that the manufacturer was working on the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed. The contact had not experienced a failure.

The hinges for the rear door/hatch broke. The door became unaligned and would not close and I had to drive my vehicle to a repair shop with the rear door ajar. This has not been inspected by manufacturer, no police or insurance inspection either. There is no reason these hinges should be worn and literally torn after 5 years.

The contact owns a 2020 Toyota Rav4. The contact stated that during inclement weather, moisture entered the vehicle through the front passenger side and the rear driver side doors. The contact stated that upon opening both the front passenger’s and the rear driver’s side doors, there was a water swishing sound coming from inside the doors. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,000.

Rear seat seat belt warning and chimes comes up even when no one sitting in the back and no stuff is put on the back seat. It start chiming randomly and even when all 3 seat belts are buckled the chime comes up. It is security risk as the sudden sound of warnings can distract drive when driving and can cause accident. This model of Rav 4 does not have option to disable this feature, and cause lot of annoyance when random warning chimes start blaring through the vehicle without any reason and resolution. Toyota is refusing to do anything about it in spite of multiple forums reported this issue with various Toyota models. NHTSA need to take action on Toyota for this safety issue.

Engine coolant bypass valve

Engine maintenance message appeared on my dash. I took it to Big O's Tires and Service a car repair service provider. Upon connecting to the car and inspecting they told me it was a faulty possibly leaking engine coolant valve. The cost to repair is $916. This may cause the engine to overheat and possibly fail due to overheating. This can be very dangerous because it will happen if it does happen while driving which could cause an accident. I have not fixed the issue yet due to a lack of funds but will have to fix it as soon as a get paid because I drive my family in this car and cannot risk catastrophic engine failure. Please have Toyota recall this part as it is a very common failure amongst 2019-2023 Rav4s. A class action lawsuit is underway due to how often this issue arises. Thank you for your time.

The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I cant use my cruise control its not going straight and everytime im turning i can hear a grinding noise its coming from power steering

I was driving the car with no issues on [XXX]- made two 30-minute trips with no issues the same day. During a 15-minute drive, the car was fine until I was at an intersection 12 minutes into the drive [XXX] and [XXX] ). I was stopped at the intersection for maybe a minute, and when the traffic light turned green, I released my brake and went to accelerate when I got the following display message: "Engine Stopped Steering Power Low." The engine turned off, and I couldn't get the car to budge in drive or reverse. When I tried pressing on the gas pedal, it wouldn't budge and felt very stiff. I'm thankful this happened at a smaller intersection on a Sunday evening because my car wouldn't start back up and was stuck in the dead center of this intersection. Cars going East and South all had to drive around me. This put my safety at risk because I had to hop out of my car and redirect people around it until a kind passerby pulled over to help push my car to the right-side turning lane. I was standing in the middle of an intersection on a road with a 35-40 mph speed limit. After pushing the car to the curb and calling a few towing places (maybe 20 minutes later), I tried starting the car again, and it started with no issues whatsoever. I drove it the rest of the way back (for 3 minutes) with no problems, and I made another three 20-25 minute drives on it today. Nothing sounds wrong with the car; it's running with no issues. I would take my car to the dealership for a diagnostic, but

Coolant Bypass Valve failure at 40k miles - 2020 rav4. Replacement at dealership is costing over 800$.

Water by-pass hose failure

Dear NHTSA, My name is [XXX] the owner of the above RAV4. It has been probably if not, six months since that I kept on going to my local dealer for the safety recall on my vehicle however, every time I am going to the dealer, they told me that the recall is not available as a yet. I am very concerned about this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS) However, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The CarPlay disconnects constantly during every drive. It’s is extremely dangerous because when my directions are being displayed the navigation cuts out, and you have to fiddle with your phone to attempt to reestablish the connection.

This recall remedy is overdue and poses a safety risk to passengers. Toyota is currently preparing the remedy for this issue. When the remedy is available, Toyota dealers will inspect the OCS sensors and, if necessary, replace them FREE OF CHARGE. At this time, Toyota estimates the remedy can be available in Quarter 3, 2024, but this is subject to change based on parts availability.

The coolant bypass valuve has failed. There looks to be a class action lawsuit currently underway.

Lift gate will not close properly. Hinges a top of gate are coming undone. Worried gate will open while driving. Had to manually close and hope it closed.

My vehicle Toyota RAV4 Hybrid 2020 began lost power and jerk on highway driving and then following messages appeared: Hybrid System Malfunction, A malfunction in electronic control of engine, throttle or automatic transmission has been detected and check engine light. This happened in September 2024. Toyota dealership replaced the low fuel pressure sensor A after my complaint and vehicle diagnostic, but it did not help. I recently had the same problem while driving on the highway for a long distance.

When attempting to open the rear lift gate wither from the dash or from the key fob rear lift gate partial opens followed by multiple beeps rear lift gift then has to be manually opened or closed

The contact owns a 2020 Toyota RAV4. The contact stated that while driving at 8 MPH to an appointment and making several turns in the parking lot, the vehicle suddenly accelerated and crashed into the building. There were no warning lights illuminated. The top of the vehicle had to be cut off. The driver had a concussion, soft tissue injuries to the neck and back. The passenger sustained a fractured sternum, soft tissue damage, and dementia injuries, The two occupants were provided medical attention. Both of the occupants were wearing seatbelts. The airbags deployed. There was smoke inside the vehicle due to the airbag deployment. There were no reported fire. A police report was filed. The contact mentioned an engine throttle error. The black data was downloaded by her lawyer, which indicated she was not depressing the brakes. The anti-collision feature did not engage. The vehicle was towed to a tow yard. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 37,000.

Failure of the Drivers Side Power Seat.

Coolant Bypass Valve, vehicle is available for inspection. Confirmed by Certified Toyota Dealership. There is a know defect with the Coolant Bypass Valve in 2019-2023 Toyota Rav4. Maintenance Required Light Only Comes on when the Heat is switched to Air Conditioner.

I have a 20202 Rav4 Hybrid and the engine short block has malfunctioned due to no error on my part, in my research there was a recall for this EXACTLY this issues in other cars of this year/make/model - although my vehicle initially did not qualify for this I believe that this in fact related and that Toyota should be responsible for the repair or replacement of the engine. The car is currently with a Toyota Dealership Service Center, Lake City Toyota in Seattle, WA but they have not been helpful. They have given me vague answers and have sent the engine offsite to a machine shop and keep requesting that I pour additional money into fixing an engine that clearly had a manufacturer defect. My car has always been serviced at Toyota dealerships, as suggested by Toyota. My car has never had previous issues until the engine light came on one day, i checked the coolant and it was empty - first replaced the fluid, let it sit overnight, then drove it around the block to circulate the coolant - when the reservoir emptied again I immediately made an appointment to take it in. The Dealership has not given me any paper invoices or written confirmation/notice of what is happening aside form continuing to ask me to pay more money to fix an engine that is clearly related to the national recall issued.

This safety recall relate to airbag on front passenger seat may not deploy due to an accident..im really afraid the risk it have when invole in an accident...i try to call dealer to ask for repair but they say just wait because the remedy is not available...my car is on year 2020 but they still have not the part to get it fix yet...this is the priority safety matter

A Safety Recall 23TA15 had been issued on Dec 20,2023. NHTSA Recall ID: 23V865 Toyota has acknowledged that a defect in the Occupant Classification System (OCS) may result in the passenger airbag failing to deploy in the event of a crash. This directly compromises a core safety feature I relied on when choosing this vehicle. Despite the recall being announced months ago, I was recently informed by Toyota Customer Service that no remedy is currently available and that no rental or loaner program is being offered in the meantime. This situation places me in an unacceptable position: I either drive a vehicle that is not fully safe or absorb the personal financial burden of securing alternative transportation—neither of which is a fair expectation of a customer who acted in good faith. I am requesting the following: 1. A clear timeline for when the necessary repair or replacement parts will become available. 2. Immediate access to a safe and comparable loaner or rental vehicle until the recall is fully resolved. 3. Written confirmation that Toyota acknowledges the safety risk and is currently offering no interim solution.

The flow shut off valve coolant it was recall from Toyota

UNKNOWN

See attached document for complaint.

"Engine maintenance required. Visit your dealer" prompt after turning on Air conditioning. Message of Engine coolant bypass valve circuit short to battery or open upon diagnostic test

Coolant relief valve failure

My Rav4 xle 2020. Starting the engine up it shakes and blows white smokes for 5 seconds and smooths out. This symptoms happens every time when engine is turn on I have to fill coolant once a week.

The manufacturer issued a recall for the air bag deployment system potentially not registering a passenger, thus not deploying, in December 2023. As of April 2025, there is still no remedy to fix this issue, which is a safety concern.

The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Shortly after having vehicle serviced at Toyota the engine maintenance light came on. Imagine my surprise at learning that many other Rav4 owners have the same exact issue right around the 65,000 mile mark. But regardless I toke it to the Toyota dealer to have them diagnose the issue and under the advisement of the technician opt in for the repair so that my car “wouldn’t have more serious problems as a result [of not fixing the coolant bypass valve].” So now I have to pay $1000 for repair when I have had the car just the tiniest bit over 4 years (which is how long the warranty lasted).

The coolant valve is malfunctioning and causing an engine safety light to be on constantly

Coolant bypass valve failure

The wiring harness to the lithium battery is corroded, and it is unregulated. My repair shop said the car is unsafe to drive because of the amount of unregulated electricity in the battery. Also, the cruise control doesn't work. My repair shop says this is happening to other vehicles. Parts and labor total almost $7,000.

After 4 to 5 years vehicle has begun to sporadically upon the first 10 minutes of driving to show a low power steering error message. The error message turns on and turns off within one second many people have been reporting the same issue with even their newer model RAV4’s. This is not acceptable.

Recall has been available with no fix since 2023 They are not providing a repair time I feel unsafe driving the car

Warning light: Engine Maintenance Required Coolant Bypass Valve

Continuous Warning light display : Engine Maintenance Required Visit Your Dealer. The OBD diagnostic scanner lists the faulty system as follows: Code P268115. Engine coolant bypass valve circuit short to battery or open circuit. This appears to be a common fault on certain Toyota RAV4 years.

Liftgate hinges on my 2020 RAV4 hybrid XSE failed, causing misalignment so the liftgate/tailgate does not close properly or completely. Liftgate hinges are made of materials that are not strong enough for consistent and safe operation. Toyota has not issued a recall or provided safety warnings or notifications, nor is the company providing replacement hinges. RAV4 owners are left to pay for the replacement of these hinges when it’s a quality issue that can impact the safe operation of 2020 Toyota RAV4s. Toyota recently settled a lawsuit brought by an individual because of this issue.

The contact owns a 2020 Toyota Rav4. The contact stated that upon starting the vehicle, there was an abnormal amount of white smoke and an abnormal odor coming from the vehicle. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 20V064000 (ENGINE AND ENGINE COOLING) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

The coolant bypass valve has been failed prematurely therefor engine heat up and there is a warning on my dashboard that say "engine maintenance required"