2019 Toyota RAV4 complaints

Took my 2019 RAV4 to Toyota of Orange. Like couple months ago for fuel pump recal but my vehicle stalls when driving on freeway or streets. Looses speed for 4 seconds and its scary reported issues to Toyota of Orange and they don’t fixed anything they only want to sell. They offer me services I don’t need for my vehicle. Got 2021 RAV4 rental from Enterprise and that one work just find no problems had it for about a week. If could get another another dealer that will be great.

Vehicle purchased two years ago developed a failure of the mechanism that opens and supports the rear hatch with no warning. This led to cracking of hinges and brackets, and mis-alignment of the hatch which prevented it from closing and latching. The original estimate for repairs would have made the owner liable for thousands of dollars. After reviewing evidence that this was not due to an accident or other abuse, Toyota agreed to a one-time 'goodwill' financial adjustment that reduced owner financial liability. But as reported in various Toyota owner forums, this is not an isolated incident: hatch opening mechanism failure has been experienced by owners of other Toyota products with various models and model years. A fundamental design flaw requires a remedy, not just repair to return it to its original, flawed, state.

Gas meter is incorrect car is suppose to have 14.5 gallons fuel tank and im only able to out in 9 gallons. gas range meter is incorrect reads wrong range of mileage... need to be recall many people are complaining about this issue toyota should correct it...

A warning notice came on the dashboard stating hybrid system malfunction, see dealer at 49,743 miles. The warning notice stayed on and we called the dealer who instructed us to bring the car in for service and not to drive it until serviced. Toyota service said the hybrid harness wires had rusted which caused the malfunction.

The factory installed bike rack is not sealed properly and leaking water when rains,etc… into the SRS airbag on passenger and driver side

Wipers would not turn on when activated. I checked all fuses were good and still not working. I drove home with no wipers in rain. Then next day I went to recheck fuses and relays, but the wipers came on.

Car hesitates when pulling out from a stop. The natural reaction is to depress accelerator more causing a shift feels like a lower gear and the car pulls out abruptly . This happens very often and I contribute it to lower gas mileage then car is rated at along with accelerated tire wear. I feel it is a safety issue when merging into traffic and causing a possible accident. I've taken my concerns to dealership on numerous occasions with complete disregard of condition calling it a " characteristic" of the vehicle. I feel there needs to be a recall to correct this issue.

Engine stalled on a highway going 65 mph in cruise control. I had 1/4 full fuel tank. just before the engine stopped working I read information on my dashboard I have to stop the car in .5 miles, than .3 miles and engine stalled within seconds. I was able to pull over with dead engine. I shut down the car using key (I have a mechanical key for ignition) and car started with a message 'hybrid system malfunction. output power reduced . visit your dealer." I visited local mechanic who read the codes and instructed its a faulty fuel pump. I filled the car with more gas and drove couple of miles with reduced power. I left the car for 36 hours and it started to run ok by itself. dealer replaced fuel pump and now it works fine. The day of incident I was able to smell gas around engine bay before incident. I was able to smell strong gas smell after incident after I filled more gas in the vehicle most likely from engine bay fresh air intake. My assumption is this is due to bad fuel/air ratio and the result was unburned fuel. The week before the incident engine felt it kicked in roughly on its start up (my car is a hybrid). I had a fuel pump recall performed 4 months before but the fuel pump failed based on codes p319300 p008700 p107a2a . dealer replaced fuel pump (2nd time) and car works well and much smoother than before.

I bought my vehicle new in August 2019, it currently has approximately 30,500 miles. A few months ago I noticed a water stain by the roof, right on the A pillar on the passenger side. I took it to Toyota and they determined it was from the sunroof, according to them one of the drains was clogged with leaves and dirt (prior to this I had NEVER opened/used the sunroof, not sure if leaves are able to get in there without ever opening the roof). They cleaned the water stain and sent me on my way, without checking for water damage. After doing some research online found out this was happening to quite a few frustrated people and seemed to happen in the 2019-2021 RAV4 vehicles, most people were told it was the sunroof but further research revealed the possibility that it was the roof rail that contained bad seals. The water is now pooling on both A pillars right where the airbags are housed. I feel there is a good possibility those airbags will not deploy properly in case of an accident. In addition, multiple customers have complaint of this issues causing electrical problems as well.

The contact owns a 2019 Toyota RAV4. The contact stated that there was an unknown blinking red light on the instrument cluster. The contact received notification of NHTSA campaign number: 20V682000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. Parts distribution disconnect. The approximate failure mileage was 25,000.

The Panoramic Sunroof spontaneously exploded while driving on the freeway. There was no impact point and the glass is bowed outward. When it exploded it was a very load pop and pressure feeling that made everyone's ears ring. About 2 seconds later small glass particles and glass dust fell down on the driver and passenger. This was reported to insurance company and taken to independent service center for estimate and repair. There were no warning lights or prior issues. The sun roof was in perfect working order and the vehicle has less than 25,000 miles on it. Driving context - 10:30 PM, light rain, outside temp was 38degrees, inside car temp set at 72 with heater on, sunshade was back, radio off, very little traffic on freeway with no road disturbances.

The contact owns a 2019 Toyota RAV4. The contact stated while driving approximately 50 MPH, the vehicle inadvertently stalled. The contact stated that an error electrical system warning message was displayed. The contact pulled over and had the vehicle towed to a local dealer where it was awaiting diagnostic testing. The manufacturer was not informed of the failure. The failure mileage was approximately 34,000. The VIN was not available.

The roof rack rails have begun leaking due to failed weather sealants around them. Water is seeping through when it rains, getting water on the airbags, headliner, and moves along the top frame. I’m scared the electrical components will become damaged. Issue began happening right around 45,000 miles when I noticed. I have only owned vehicle for 2.5 years.

The seat belt for the driver's seat often wedges itself between one or another of the levers of the seat-adjustment mechanisms and the side of driver's seat. I am concerned that this may cause the belt to operate less than optimally.

The issue is the stock roof rack that comes with the vehicles. The clips that clip on to the body of the car have gaskets that deteriorate. Water leaks in through those holes and into the headliner of the car. The front SRS airbags are compromised and potentially rendered useless. The wiring that attaches to the airbags is also compromised because the water will eventually corrode it.

Around 2:30 pm on Thursday, December 2, 2021, my wife and I were on our way to the gym for a workout. I was pulling my auto out of my garage. It was in reverse when it stopped half way and did not finish backing out. I put it in drive and then in reverse and I was able to back out. Once out of my driveway, I backed out into the street in reverse. From reverse, I put my car in Drive to start driving on the street. At this point, the car spun out of control and I could not control its movements. The car turned around on the street and drove into my yard. It ran through the yard, spun around through some hedges, onto my driveway and continued back into the yard. At this time it hit a tree in the yard, went back on the road, turned into my driveway before coming to a stop. We got out and inspected the damage. The entire front bumper and the assembly was hanging from the body of the car. The damage was extensive. Thankfully, no one was on the road and the only damage was to my car and my yard. shrubs and tree. This car is a Limited Edition with cameras and braking functions that stop the car if an object comes in its way. The car kept accelerating and did not brake to avoid collision. Note: We bought this 2019 RAV4 in March 2019. It was brand new, full loaded with many safety features. In October of 2019, we heard sounds coming from the front of the car. We took it to Toyota dealership to have it diagnosed. They determined that the Electromagnetic Clutch Assembly needed to be repl

The contact owns a 2019 Toyota Rav4. The contact stated while attempting to park the vehicle, depressing on the brake pedal but the vehicle began to accelerate independently causing the vehicle to crash into a tree trunk. The contact stated no warning light was illuminated. No air bags deployed. The contact stated she had chest and neck pains due to hitting the steering wheel and did go to urgent care but did not seek medical attention. A police report was filed. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 30,000.

After a recall repair order was issued, the repairs were made and now accelerating under load or uphill, the vehicle will accelerate and then bogs down or chokes (the vehicle then loses speed and no longer accelates). The issue has occurred several times while accelerating to freeway speeds on freeway on-ramps (it’s a safety hazard). 1st attempt to repair by the dealer was made on 11/22/2021. 2nd attempt by the same dealership is pending for today 12/08/2021 at 1:30pm.

My sunroof exploded for absolutely no reason.

My roof rack rail assembly is leaking water down my A and C pillars, and into the inside of my vehicle. When it leaks into my car it also leaks down into my side curtain airbags to the point if I were to get into an accident where the side curtain airbags needed to deploy because of my windshield, they would not which could cause me to lose my life. I have asked my dealership about it and they told me they had numerous roof racks replaced because of the leaking but because my vehicle is no longer under warranty, I have to pay to have the roof racks replaced. I have tried to reseal my roof racks but did not work. The Toyota dealership told me that if resealing didn't work, the only other option was to replace. I cannot drive in the rain, even when it is just sprinkling or wash my car because any sort of water will leak into my vehicle. Toyota will not send a recall out for this issue but is known to be a safety issue with the Toyota dealership and numerous people that own a 2019-2021 Toyota Rav4.

The sunroof/moonroof in my 2019 Toyota RAV4 spontaneously exploded while parked overnight in my driveway. There was not any damage on or around that area of my car, nothing above my car. The following morning when I pulled out of my driveway, I noticed a strange sound , retracted my visor and noticed the roof glass was completely shattered in a volcanic like shape. Pieces began to fall as I began to pull back into the driveway.

Was driving on the freeway and heard a loud pop noise. upon pulling over, i noticed a hole in my in my sunroof (punctured from the inside out)

I noticed water pooling on the driver side floor after it rained. I determined water was leaking in the drivers side window and streaming down to the floor and wetting the electrical components. An online search found others with a similar problem. It appears to stem from inadequate gaskets on the roof rails. All of my windows have water seeping in during rain. My concern is the electrical components getting wet. I found one example of corrosion that someone posted online.

Standing water on plastic mat/ passenger-side footwell. Lifted matt up and carpet soaked. Visually and sopping wet to the touch. While driving noise continually of sloshing…. Sounds like water rolling back and forth under passenger seat. Heard Most when slowing or speeding up. Called toyota service departments and currently closed

Roof headliner leak due to poor design and/or water proofing materials on the clips of the roof top bar. This causes concerns about potential damage to the side air bags and electricals.

The contact owns a 2019 Toyota RAV4. The contact stated that whenever it rained, water would enter the cabin of the vehicle. The contact was concerned that it might cause an electrical failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 37,000.

The roof rails allow water to enter the vehicle along the A pillar where the side curtain airbags and connectors reside. Moisture was found inside the connectors, which will lead to corrosion over time and would cause a failure of the airbags to deploy.

My RAV4 has factory roof rails and the seals on the rails for drivers and passengers sides have begun leaking which caused water to get inside the liner of the roof and travel down the a pillars to the side curtain airbags. I had the vehicle inspected at Toyota of Terre Haute Indiana. And they confirmed where the leak was at and stated that they have no reports of this issue happening. However there are a lot of people reporting the same issues online.

The contact owns a 2019 Toyota Rav4. The contact stated that while picking up her husband, upon sitting on the front passenger’s seat, he noticed that the seat was extremely hot. The contact stated that the heated seat feature was in the off position. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer and the vehicle was being diagnosed while filing the complaint. The vehicle was not yet diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 39,000.

The contact owns a 2019 Toyota Rav4. The contact stated while driving 40 MPH, the vehicle was making an abnormal humming and grinding sound. There were no warning lights illuminated. The contact received a recall notification for an unknown recall in regards to a humming sound coming from the transfer case of the vehicle; however, the dealer diagnosed that no issues were found and informed the contact that the recall repair did not need to be completed on the vehicle. The contact stated that the failure had been recurring while driving and he had been hearing abnormal bumping sounds from underneath of the vehicle. The dealer was made aware of the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 3.

Roof rails water sealing failure - causing water to enter the vehicle on each side of the front A pillars of the vehicle and is reaching the airbag electrical connections which can lead to airbag failure during an accident due to corroded electrical connections. Vehicle taken to Toyota of North Charlotte to show dealership the damage to the headliner and request a resolution be completed. Dealership inspected vehicle - stated they believed it to be clogged sunroof drain lines and stated if it continues to notify them. Have reached back out to them as rain storm same night as service 8/15/2021 revealed that leak continues. No warning lights have appeared but symptoms are shown by the amount of water dripping into the cabin from these defective roof rails and running down the A Pillars into the dashboard.

The eco boost made the engine to jump causing the engine Mount to loosing out

Leak at junction of windshield and A-pillar. Potential damage to A-Pillar air bag

Steering suddenly locked up. Car steered to the right went off the road. Turned over several times and landed upside down. Causing serious injuries to myself and the driver. I was in hospital 3 weeks total with broken ribs , broken vertabrae and dislocated shoulder. Cuts on feet from the glass. Driver had cuts on head and dislocated shoulder. Prior to accident, I had reported (twice) to dealer that steering wheel felt loose. The second time, I had him write it down on report when I came in for oil change. So I have proof that I reported it. They checked steering and said they couldn't find anything wrong; but the problem was it didn't do it all the time. Sometimes it would take quite a few seconds before it would react if I would turn it a little left or right. Eventually, it did lock up and caused the horrible accident. The accident occured on November 26, 2020. I typed that date, but somehow this report changed it to Aug 6 and I can't seem to change it.

The roof rails in my 2019 RAV4 are leaking into my car. Toyota dealership is aware of this issue in my hometown as I’m not the only person to come forward with this however stated that being there isn’t a recall there is nothing they can do. This is a dangerous as the roof holds air bags, electrical components amongst the mold that it’s causing. I have a son who is highly allergic to the mold spores. Toyota used the cheapest parts available to put this car together. This needs attention as people are paying 35-40000 for these vehicles for this to take place and they turn their backs . Please take this serious please

Roof leaks in heavy rain or car wash. Water stains noted on the A pillars requiring replacement of the headliner. Concern of water damaging the air bags in the pillars. Now leaking through the front ceiling light with heavy rain.

When filling the fuel tank when full fuel spills out until the pump handle finally shuts off. Estimated spillage is about 1/2 to 1 cup of fuel. This has happened more than 6 times

Unknown component or system While driving on the Interstate during rush hour, traveling 60 miles an hour, another vehicle along side us entered our lane and we had to avoid a collision by aggressive braking and steering. Following this maneuver, our vehicle immediately shut down. An 18 wheel barely missed crashing into our rear. It took us approximately 1 minute to realize we needed to put the car in park, step on the brake, and push the ignition button to restart the vehicle.

Case number started at Toyota Customer service: 210701002045 Requested an unacceptable time to answer of 8 weeks. There was a recall for this vehicle. I wasnt notified and the recall also doesnt show in any website (Not Toyota not in the goverment one). I went on a trip thousands mile aways from home, I was up in the montains, the car got broken in a very bad place where I had to spend almost $2,000 dollars due to Towing, meal and hotel expenses (as the dealer was closed on a weekend). I am trying to solve this with Toyota but they say I have to wait 8 weeks to start looking at my case. It is unacceptable . I need a reimbursement ASAP.

Vehicle will not accelerate when pushing down on the gas pedal. This can occur when leaving a parking place or from a traffic light.

Significant roof leak driver side front. Took it to a dealer. Wants customers to pay for Toyota’s design flaw.

Abnormal bussing noises under the car when driving.

Seat heater turns on automatically and randomly and gets way too hot. I'm afraid it might burn me. I have an appointment with the Toyota dealership however it's my only mode of transportation and I work 3 hours away from home. This puts me at high risk of getting hurt. None of the lights or any indicators came on. There has been no indication that there might be an issue before today. Today is 6-25-2021.

Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, while driving on the interstate the vehicle began vibrating heavily. What component or system failed or malfunctioned, and is it available for inspection upon request? Upon inspection it was noticed that the inner tread of the left rear tire was damaged, worn away and scalloped or cupped. The tire was replaced with a spare, and vehicle driven to the nearest Toyota dealer for service. The damaged tire is available for inspection. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the servicing dealer informed us that the left rear camber was out of manufacturer specification being -1.8 deg. The minimum allowed is -1.7, and the minimum recommended is -1.3. We were informed that to be safe the vehicle required repairs; however, they were unable. We then took the vehicle to the selling dealer who also found the issue and were unable to repair. Two additional service centers also confirmed the rear camber was out of specifications, and posed a safety risk. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the dealer stated that a manufacturer representative from Toyota inspected the vehicle. How was your safety or the safety of others put at risk? Safety was compromised as the damage to the tire was severe and hidden. This damage could have result

Roof rack seals failed, allowing water in above the A-pillar, which damages the headliner and could damage electrical and side airbags, compromising safety. In talking with other 2019 Rav4 owners, many have experienced the same issue as the sealing mechanism is poorly designed.

The sunroof exploded outward/upward. I was doing 75-80mph north bound on I-15 in Montana, south of mile marker 250. Suddenly there was a loud BOOM like a an explosion! (I was startled and almost lost control of the car.) When I reached Cascade, the nearest town, I checked and saw that the sunroof was bulged outward, with a large hole. See pictures. Condition: around 12:45pm. Outside - Cloudy, temp around 30 degree Farenheit with a dusting of snow. Inside cabin was set to 70 degrees. I do not know the elevation above sea level. I was not near any area that rocks could fall on the roof. The only other vehicle was about 1/4 to 1/2 mile behind me at the time of the incidence. The autobody shop guy checked for any signs of rocks or bullets or anything that could have caused it and he could not even guess at the cause, especially since the glass was bulging outward.

The 2019 Rav4 models have an issue with the roof rack rails leaking water into the A pillar as well as the C pillar due to a failure in the materials the manufacturer used. Not only does this cause issues with the headliner of the vehicles but this could also endanger the occupants of the entire vehicle due to the leak affecting the airbags located in the A and C pillars. This leak has a potential to affect electrica as well as the main safety component located in the locations stated above. Not addressing the issue could result in death due to airbag failures and could then lead to class action lawsuits.

MY VEHICLE IS STALLING WHEN AT LOW SPEED AND SOMETIMES HIGH SPEED. IT FAILS TO ACCELERATE. EVERY TIME I CONTACT MY SERVICE PROVIDER THEY PUSH BACK MY SERVICE ANOTHER MONTH.

THERE IS A WATER LEAK THAT HAPPENS IN THE A PILLAR OF THE VEHICLE DUE TO A FAULTY GASKET ON THE ROOF RACK. WATER CAN LEAK INTO THE SIDE CURTAIN AIRBAGS WHICH CAN COMPROMISE THE SAFTEY OF THE VEHCILE. NUMEROUS ACCOUNTS ONLINE FROM OTHER OWNERS AS WELL. PLEASE GOOGLE RAV4 2019 ROOF LEAK. I NOTIVED THE LEAK AS I WAS DRIVING WHEN IT WAS RAINING, IT WAS LEAKING ON THE A PILLAR IN BOTH PASSENGER AND DRIVER SIDE.

ON APRIL 5, 2021 AT 10:40AM ON A HIGHWAY GOING 50 MPH THERE WAS AN EXTREMELY LOUD BANG. LUCKILY WITHOUT CRASHING I PARKED ON THE SIDE AND SAW THAT THE SUNROOF HAD SHATTERED WITH THE APPEARANCE OF COMING FROM WITHIN. THE SHADE HAD BEEN CLOSED THEREFORE THE GLASS WAS PREVENTED FROM SCATTERING ON ME. I HAD TOYOTA CHULA VISTA, CA CHECK IT OUT AND THEY DECLINED TO HONOR THE WARRANTY. THE WEEK AFTERWARDS I SPOKE TO THE MANAGER OF TOYOTA IN YUMA, AZ WHERE I PURCHASED THE AUTOMOBILE WHO ALSO DECLINED TO HONOR THE WARRANTY AND RECOMMENDED TO MAKE A CLAIM WITH MY CAR INSURANCE. I HAVE LEARNED THAT IT IS COMMON FOR SUNROOFS TO EXPLODE IN THIS CAR. THERE WAS A CLASS ACTION SUIT THAT HAS ALREADY BEEN SETTLED. PLEASE INFORM ME OF ANY FUTURE RECALLS. I WILL UPLOAD PHOTOS.