2022 Toyota Highlander complaints

The contact owns a 2022 Toyota Highlander. The contact received notification of NTHSA Campaign Number: 26V128000 (Seats); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experience a failure.

Known faulty transmission. Ua 80 transmission shifts early causing erratic shifting and excessive wear and tear on the transmission causing premature wear and tear.

System Failed -Transmission makes a high pitch whine, which Toyota has identified as a product manufacturing issue with the 2017-2022 V6 Highlander, but has not done anything to rectify the issue for those of us out of warranty. As this transmission issue usually doesn't start happening until 60,000 miles, unless you bought an extended warranty, you're out another $8K to $10K due to their negligence. Found this on Redit - Toyota knows the UA80F whines—it’s in TSB T-SB-0160-18 , T-SB-0008-21 and CSP ZJC. But unless your VIN’s on their cherry-picked list, they’ll play dumb. Safety Risk - Transmission stops working and car is inoperable. Reproduced - Yes, Toyota is aware that several cars are affected and doesn't care. Symptoms - Identified Symptoms are high pitched whine, rough shifting, transmission slippage, etc.

The contact owns a 2022 Toyota Highlander. The contact stated that while driving 20 MPH with a child seated in the rear passenger’s side seat with the seat back adjusted, while going around a roundabout, the vehicle was cut off by another vehicle, and the contact depressed the brake pedal aggressively to stop the vehicle. There was an abnormal clunking sound coming from the passenger’s side second-row seat, and the seat back moved or readjusted from the previous position. The contact slowed down to approximately 5 MPH to avoid the crash. The child remained secured in the car seat. There was no injury sustained. The vehicle was included in NHTSA Campaign Number: 26V128000 (SEATS). The manufacturer was notified of the failure, but the part was not yet available for the recall repair. The failure mileage was approximately 27,500.

Transmission failure at 38,896 miles

I am having a problem on the transmission as described by the Geras Magazine: "The issue stems from a flawed assembly process involving the counter drive gear support. A locking tab meant to secure a vital retaining nut was not bent properly during factory assembly. This leads to gear movement, internal wear, whining, and eventually failure."

2023 toyota highlander w AU80 transmission whinning noises when accelerating.69000K miles, serviced at Emerson Toyota, scheduled transmission check at 57000K miles, technician stated slight whinning was normal

Nothing happened

The contact owns a 2022 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (Seats); however, the part to do the recall repair was not yet available. The dealer was contacted, and the contact was informed that parts were not yet available for the recall repair. The contact stated that the vehicle was used to transport children, and the unrepaired recall was a safety hazard. The manufacturer was contacted, and a case was filed. The contact had not experienced a failure.

The only door that will lock or unlock using the fab key or the master lock button on the drivers armrest is the drivers side rear door. My vehicle is not able to be locked unless I do it manually and can not be unlocked unless i use the rear drivers side door. This has been reproduced by the dealership. There were no warning lamps or messages and no other symptoms. This has been going on for a month. I am being told by the dealership service department that 3 actuators failed at the same time. My lift gate also malfunctioned this year. Dealership diagnosed it with needing new struts. Not sure if this is related. Lift gate would not open or open only a small amount. This was using the inside button and the outside one as well.

Whining sound, when acceleration

The contact's daughter owns a 2022 Toyota Highlander. The contact stated while driving approximately 65 MPH, the contact noticed an abnormal sound coming from the exterior of the vehicle. The driver pulled to a highway hot shop. Upon inspection, the contact noticed that the upper side of the lower front bumper cover had detached and the cover was hanging and dragging. The contact secured the cover with strings and was able to continue driving. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 23V720000 (Structure); however, the dealer refused to complete the recall repair due to collateral damage caused by the cover dragging. The vehicle was then taken to Toyota of Manhattan (679 11th Ave, New York, NY 10019), where the contact was denied assistance because the previous dealer had already opened a case. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was unknown.

The contact owns a 2022 TOYOTA Highlander. The contact stated that the front upper bumper assembly is separating from the headlight on the passenger side, creating a noticeable gap on the fender portion directly below the headlight. The contact referenced NHTSA campaign number: 23V720000 (STRUCTURE), however, the VIN was not included in the recall repair. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 32,827.

Motorized struts to lift and close the rear lift gate have failed. The struts do work to open the lift gate but they do not work to close it. Manually closing the lift gate is extremely difficult because of the electric motors inside of the struts. A known problem by Toyota as they have issued a TSB. Toyota’s solution is to replace the struts at a cost of $1200. My concern about this being a safety issue: Closing the lift gate after accessing the spare tire is extremely difficult. If my wife would inadvertently open the lift gate, which does work, after leaving the grocery store to put all of the groceries in the back, she would not have the strength to manually close it. Obviously, the vehicle cannot be driven with the open tail gate. This is not any different than if any of the doors could not be closed due to defective hinges. The premature failure of motorized struts is a fairly common problem with Highlanders. ToyotaNation, which is a Toyota sponsored forum for owners to communicate with other owners about issues/problems, contains numerous posts about the failure of motorized struts on the rear lift gate. Your attention to this matter is greatly appreciated. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

PKSB malfunction, LTA system malfunction, SRS system malfunction, Per-Collision system malfunction, Headlight system malfunction and Front camera unavailable.

Headlight system malfunction, Pre-collision system malfunction and LTA malfunction

The power back door struts were not completely operational for about 6 months or more from the date of repair on 2/26/26. Therefore, the back hatch would not close without manipulating it by starting the vehicle and using the inside button to close it. There was also a loud grinding/whining noise each time we opened and closed the hatch. The dealer said it's a common problem and maybe the struts were blown out because we had to open the rear hatch to get a mobility scooter in and out . Since we were concerned that eventually the hatch would be stuck in the upright position permanately, we relented and paid to have the Toyota dealer replace the struts. The dealer said it may become a recall because it's so common.

Goodwill Repair for my 2022 Highlander transmission whine, referencing TSB T-SB-0008-21。”

During very cold tempratures 25 F and below all windows fog up. Defroster is turned on but windows remain fogged. I can turn on rear defroster (electric grid) and clears back window. All windows fog so you cannot see out. With front defroster fan on high it will after a time (starting from the bottm) clear. Side windows on drivers and passenger side will some times clear. Not back passenger windows. Taken to dealer several times. Replaced thermostat. After more complaints dealer said there was no mechanical problem.

The contact owns a 2022 Toyota Highlander. The contact stated that while driving in inclement weather, water was leaking from the overhead console on the driver's side, where the sunglasses holder was located. Additionally, water stains were on the headliner above the driver’s side rear third row seats. The vehicle was taken to the dealer, where it was diagnosed with a fracture to the driver’s side roof rack attachment clip or a sealant interference. The vehicle was repaired with Part Number: 90467-08235. The manufacturer was notified of the failure. The approximate failure mileage was 56,000.

During start up Headlight system malfunction and Pre-Collision system failure lights and waring came on.

During start up LTA malfunction, Pre-Collision system malfunction and Headlight system malfunction lights and warning indicators came on.

During start up SRS airbag system malfunction, front camera unavailable, pre-collision system malfunction and LTA malfunction lights and warnings came on.

To Whom It May Concern, I am submitting this complaint to report a serious mechanical issue involving the transfer case on my 2022 Toyota Highlander. This problem raises concerns regarding the safety, reliability, and overall performance of the vehicle. While driving, I began hearing a grinding noise coming from the vehicle. Concerned, I brought the vehicle to an authorized dealership for a diagnostic inspection. I was informed that there is a transmission-related issue and that the vehicle requires a transfer case replacement. At the time of diagnosis, the vehicle had approximately 77,000 miles and has been primarily driven locally under normal conditions. This type of major drivetrain failure at such mileage is unexpected and concerning, especially given that the vehicle has been properly maintained. The failure of a critical component such as the transfer case can significantly affect vehicle control and drivability, posing a potential safety risk. This raises concerns about a possible defect in the drivetrain system or a broader issue affecting similar vehicles. I respectfully request that this matter be investigated to determine whether this is an isolated incident or part of a wider pattern. If necessary, appropriate corrective actions should be taken to ensure consumer safety. Thank you for your attention to this matter. I am available to provide any additional documentation, including service records and diagnostic reports, upon request.

I am reporting a premature transmission failure on a 2022 Toyota Highlander LE at approximately 85,000 miles. The vehicle began exhibiting a whining noise. When brought into the Toyota Dealership, I was notified that it needs a full transmission replacement. The vehicle was inspected by an authorized Toyota dealership, which determined that the transmission has failed and requires full replacement at an estimated cost of approximately $9,400. There were no warning lamps or messages of the problem prior to the failure. A transmission failing at this mileage creates a significant safety risk, especially when merging into traffic, accelerating from a stop, or maintaining highway speeds. This vehicle has been regularly maintained, with service performed through authorized Toyota dealerships. Despite this, Toyota has declined to provide assistance for the repair. This has caused a massive financial stress and strain. There is a documented pattern of similar transmission failures involving Toyota Highlander vehicles equipped with the 8-speed automatic transmission (UA80 platform) across multiple model years.This appears to be part of a broader pattern of premature transmission failures that may indicate a defect affecting vehicle safety. The consistency of complaints across multiple vehicles and model years suggests this is not an isolated incident. I am requesting that NHTSA investigate this issue for potential safety defects and determine whether further action, including recall

The struts for the tailgate appear to be a problem for these cars. Mine are failing intermittently and so if the technicians don’t witness it, they refuse to cover it under warranty. If I crash and the trunk is the only way out, I willl die. The trunk gets stuck and won’t open or close unless forced. This is a disaster and should be recalled. I see multiple complaints all over the internet about this issue and the dealers are NO help. I have gone 4 separate times and they have wasted my time because there was no resolution.

Rear tailgate won’t open ir close correctly. The keyfob or the button om the tailgate won’t work. Really heavy tailgate to close manually.

The transmission began making a whining noise at about 70,000 miles. It gradually became more noticeable. We had recently completed a thorough service, including transmission fluid exchange at 68,538 miles at a Toyota dealer. In March 2026 we took it to a Toyota dealer at 75,196 miles to report the noise and the dealer said the noise was coming from the transaxle and advised replacing the transaxle, which will require replacing the transmission. This was confirmed by a second Toyota dealer a few weeks later. Upon further research, it is clear that this is a significant safety issue and I will need to expend between $6k - $8k for repair from an independent shop and at a much higher expense if done through a Toyota dealer.

The contact owns a 2022 Toyota Highlander. The contact stated that while driving at various speeds, there was an abnormal sound coming from the engine while the accelerator pedal was depressed. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired out-of-pocket. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.

Noticed a sound coming from the car. I took it to the dealership which they said I would need my transmission replaced. They could only get me a refurbished one, which after parts and labor, it would cost 10,000 dollars. Upon talking with the technician, the transmission my car uses has been known to be faulty and having issues, usually after the warranty. So much so that Toyota did a recall on previous car years to extend the warranty for the transmission. The technician said they are replacing them often, which is why the supply is so low. These transmissions are the ones Toyota has been using since 2016, which have had many defects and causing issues. If this was known for years, why did Toyota continue to use them?

Vehicle: 2022 Toyota Highlander Limited Mileage at failure: ~60,000 miles The driver seat began moving rearward without any driver input while the vehicle was being driven. The movement was intermittent and occurred multiple times over several days. In one incident, the seat moved rearward while my wife was driving, causing her to lose proper reach to the brake pedal and nearly lose control of the vehicle. The seat would sometimes move to the full rear position and continue attempting to move past the mechanical stop. The problem also occurred during vehicle startup and shutdown cycles. This condition creates a significant safety risk because the driver’s seating position can change unexpectedly while driving. In attempting to mitigate the problem, I tried to disable the power seat by removing the fuse. However, the power seat fuses on this vehicle are not clearly labeled and are mounted on the side of the interior junction block under the dash, making them inaccessible to the driver without removing interior panels. As a result, the malfunctioning system could not be quickly disabled. The vehicle required replacement of the driver seat control/track assembly at a cost of approximately $1,600. Uncommanded movement of the driver seat while driving appears to be a safety-related defect and should be investigated for potential recall or service campaign

The contact owns a 2022 Toyota Highlander. The contact stated that while using the rear liftgate with the key fob or the actuator on the liftgate door, the liftgate failed to raise properly and failed to close properly. The contact stated that the liftgate made a beeping sound and then stopped. The contact had taken the vehicle to a local dealer several times and was unable to duplicate the failure. The dealer recommended changing both liftgate pistons. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 48,000.

LIFTGATE MALFUNCTION

Transmission failure of 2022 Toyota Highlander LE at 82,329 miles. Safety compromised due to possible roadside failure.

Component or system that malfunctioned: The braking system on my 2022 Toyota Highlander Hybrid, specifically the transition between regenerative braking and hydraulic friction braking, appears to malfunction intermittently. During braking, the vehicle sometimes lurches or surges forward instead of slowing smoothly, especially at low speeds or when braking downhill. The vehicle is available for inspection upon request. How safety was put at risk: The unexpected forward surge while braking increases stopping distance and creates uncertainty about braking performance, particularly in traffic or parking situations. This creates a risk of rear-end or low-speed collisions and reduces my confidence in the braking system. Problem reproduced or confirmed by dealer or service center: The vehicle was inspected by a Toyota dealership, and a Technical Service Bulletin (TSB) software update intended to address braking behavior was performed at approximately 50,000 miles. However, the braking problem continues unchanged after the repair. I had to pay the dealer to perform this TSB update. The dealer was initially reluctant to apply the TSB and did not associate my braking complaint with the known issue. I had to research the TSB myself and request that it be applied. The invoice notes that the dealer reproduced the issue. Vehicle or component inspected by manufacturer or others: The vehicle has been inspected by a Toyota dealership service department. It has not been inspected by police or

Transmission failed at 63,000 miles, new transmission was installed.

UA80 Transmission failure @ 3.5 yrs old and 89k miles.

Failure of the rear hatch power struts. Door not opening or closing properly.

Parked in sun and the SRS system malfunctioned, after power reset the system reset ok,

Parked in sun and the SRS system malfunctioned, after power reset the system reset ok. Front camera malfunction, RSA malfunction & Pre-collision malfunction.

Parked in sun and the SRS system malfunctioned, after power reset the system reset ok,

Parked in sun and the SRS system malfunctioned, after power reset the system reset ok, LTA malfunction, headlight system malfunction Pre-collision malfunction.

Throttle plate iced up in cold weather, causing computer to put the car in limp mode, creating a dangerous situation. Toyota had a TSB solution for this in 2023, but did not make the software update available until my vehicle failed.

My 2022 Toyota Highlander experienced transmission-related issues that affected the vehicle’s performance, reliability, and overall value. These problems caused inconvenience, safety concerns, and additional stress, and in some cases required diagnostic visits, repairs, or time without use of the vehicle. As a consumer who purchased the vehicle with the reasonable expectation of dependable operation, I believe compensation is warranted for the diminished value, disruption, and potential repair costs resulting from this defect.

The contact owns an Evenflo Car Seat, Model Number: 368124708, Model Type: Revolve 360 Slim, Manufactured Date: July 11, 2024. The car seat was being used in a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 25C010000 (Child Seat). The contact stated that the head rest foam was exposed on the left and right sides of the headrest and that the child was picking out the foam as described in the recall. The manufacturer was contacted and provided pictures of the failure. The contact was advised by a representative from the manufacturer that a repair kit would be sent in the mail to repair the car seat. The contact received the repair kit and found an 8-inch-long by 3/12-inch-wide strip of tape. The contact stated that the repair kit was inadequate to complete the repair on the head rest. The contact had not attempted to call the manufacturer back about the repair kit.

The entire head unit in the center of the front console went crazy and started going blank, glitching out, and basically made it impossible to use any of the features associated with that screen unit. The 2022 Toyota Highlander's head unit controls infotainment (radio, streaming, navigation, phone) and integrates with vehicle settings for climate (auto AC, seat heaters/ventilators), lighting, door locks, and driver-assist features like Road Sign Assist and Parking Support Brake, with over-the-air updates available for connected models. It manages multimedia, Bluetooth, Apple CarPlay, Android Auto, Wi-Fi, and vehicle alerts, offering deep customization for audio, display, and connectivity. We promptly took the car into the Toyota Dealer and they determined it was a bad head unit and I had to pick up the car and they made us drive the car for about 1 1/2 weeks broken, while the part was in transit. After the part arrived, we scheduled visit for that part replacement. They later called and said that it was causing the same issues and had to do a further diagnostic and determined that the integragation control sub assembly computer (the cpu for the head unit?) was actually the bad part. The 2nd part was ordered and installed, and ultimately repaired the issue. We had limited control over the heater and keeping the ice off the windows and other issues with no navigation and other systems during this 1 1/2 week period. This is also the same screen that gives us the backup camera, a

Transmission failed at 75K with no warning lights or prior evidence.

I had been driving my 2022 Toyota Highlander XLE with 46k miles that I just got for about two weeks, so about 10 days out of the 14 i actually drove it from home to work and back home. Within those 10 days driving the SUV, 8 mornings and one afternoon the highlander engine had issues accelerating and shifting gears. Basically when pulling out on to a highway from a side street coming down a hill when pressing the gas to enter the highway and flow of traffic the engine stuttered from zero to 20mph causing the entire SUV to jerk repeatedly and the gears would have issues shifting from first to second. I had to let my foot off the gas pedal then press again repeatedly as the SUV kept jerking trying to accelerate forward stuck no more than 20 mph for 30 seconds then started to even out and climb up after a minute. I have caught this on video twice. This has caused me to hold up traffic on the highway behind me with no where to pull off because my particular side street comes out from a gulch cliff side. No check engine lights came on each time. I took it to an auto shop that did a minor test drive and suggested it go directly to Servco Toyota as it should have powertrain warranty on it still and they believed it was a fuel pump issue. The issue did not happen with this auto shop but I showed them the video. I scheduled an appt at Toyota and it is with them now. They did 2 test drive but could not replicate the issue and could not see any codes coming up. I opted to leave the vehi

Vehicle Issue Description (Rear Liftgate): The rear power liftgate intermittently fails to operate and presents a safety concern. The liftgate often will not open at all. At other times, it opens only partially (approximately one-quarter of the way) and then stops. When this occurs, the liftgate frequently will not close properly and sometimes fails to latch securely. This issue has been ongoing for approximately two years and has progressively worsened. It has now reached the point where the rear liftgate is no longer usable. If the liftgate does not open in an emergency, occupants may be unable to exit the vehicle through the rear, which could be dangerous in the event of an accident. Additionally, when the liftgate fails to latch securely, there is a risk it could open while driving, potentially causing cargo loss, reduced visibility, or allowing exhaust fumes to enter the cabin. Numerous Toyota Highlander owners report the same issue on public forums such as Reddit, indicating this is a widespread and known problem. According to these reports, dealerships are commonly diagnosing the failure as a failed liftgate strut, with quoted repair costs of approximately $1,500. I reported this issue to Toyota directly today and was told that Toyota does not issue recalls and that concerns should be reported to NHTSA. I am frustrated that this appears to be a known issue that has existed for years without corrective action. Component/System Failed: Rear power liftgate system (includi

When turning on the heated steering wheel and about 5-10 minutes, it seems there is smoke coming from the steering wheel leather and it’s very hot that almost burnt my hand and forced me to take my left hand off. I immediately turned the heated steering wheel and stopped. There is a burning spot left on the steering wheel also. The heating option still can be enabled and the same situation repeats (like no fuse was broken)