2007 Toyota FJ Cruiser complaints

I TOOK MY 2007 TOYOTA FJ CRUISER INTO THE DEALER AROUND THE END OF 2007, IT HAD 12,000 MILES ON IT AT THE TIME. I TOLD THEM THAT MY GAS PEDAL HAD STUCK AND I HAD TO HOLD THE BRAKES DOWN AND TURN OFF THE KEY TO GET IT TO STOP. I THEN HAD TO GET OUT OF THE CAR IN THE MIDDLE OF THE ROAD AND REACH DOWN TO RELEASE IT. THEY TOLD ME THAT IT MUST HAVE STUCK ON THE FLOOR MAT AND TO JUST WATCH IT. IT THEN STUCK AGAIN ABOUT A YEAR LATER AND I WAS ABLE TO RELEASE IT THIS TIME BY KICKING AT IT. I DIDN'T THINK ANYMORE OF IT UNTIL ALL THE RECALLS STARTED COMING OUT ON TOYOTA GAS PEDALS AND I THOUGHT THAT YOU SHOULD KNOW ABOUT THIS BECAUSE IT HAPPENED ON A MODEL THAT IS NOT ON THE RECALL LIST AND THAT THE PROBLEM CAME UP OVER TWO YEARS AGO. THIS INCIDENT IS DOCUMENTED AT THOMPSON TOYOTA IN PLACERVILLE, CA. I BOUGHT THE CAR NEW AT FOLSOM TOYOTA 2/2007. NOTHING HAS BEEN DONE TO FIX THIS YET BUT THE SERVICE DIRECTOR AT THOPSON TOYOTA WAS VERY CONCERNED THIS TIME AND SAID THAT SOMEONE WAS COMING UP FROM THE BAY AREA TO LOOK AT IT SOON. *TR

TOYOTA FJ CRUISER WINDSHIELD CRACKS AND CHIPS EASILY. WE'VE HAD OUR FJ FOR TWO YEARS AND ARE ON OUR 4TH WINDSHIELD. THE SMALLEST BIT OF DEBRIS CREATES A CHIP AND SOMETIMES IT SEEMS TO BEGIN TO CRACK AT THE DRIVERS SIDE FOR NO REASON. DEALER OFFERS NO SOLUTION EXCEPT TO CHARGE $500 A POP TO REPLACE THE WINDSHIELD. THIS SEEMS TO BE A WIDESPREAD PROBLEM AS IT IS MENTIONED ON NUMEROUS WEB BLOGS AND FORUMS. INCIDENT DATE BELOW IS ARBITRARY AS WE'VE BEEN DRIVING WITH A CRACKED WINDSHIELD FOR QUITE A WHILE B/C WE SIMPLY CAN'T AFFORD TO REPLACE YET ANOTHER WINDSHIELD AT THIS TIME.*TR

THERE IS A SMALL POT HOLE ON THE OFF RAMP THAT I USE TO COME HOME FROM WORK. EVERY TIME I HIT IT, MY BRAKES FREAK OUT AND I HAVE TO PUMP THEM TO RECOVER AND GET MY BRAKES BACK. I DRIVE A 2007 TOYOTA FJ CRUISER. (THIS IS MY SECOND FJ CRUISER. MY FIRST ONE DID THE SAME THING ON THIS POT HOLE.) IT HAPPENS EVERY TIME I HIT IT. DIDN'T THINK MUCH ABOUT IT UNTIL I SAW THE RECALL INVESTIGATION ON THE PRIUS BAKES. SOUNDS JUST LIKE WHAT MY FJ DOES. *TR

AFTER ACCELERATING FROM LOW SPEEDS THE STEERING SOMETIMES HAS A LARGE AMOUNT OF MOVEMENT LEFT & RIGHT FROM VERY SMALL STEERING INPUTS. RESULTING IN A "DEATH WOBBLE" SORT OF A FEELING. THIS HAPPENED BEFORE AND AFTER A LIFT KIT AND TIRES WERE INSTALLED. *TR

I WAS DRIVING MY MODEL YEAR 2007 TOYOTA FJ CRUISER TO WORK ON THE MORNING OF 2/9/2010 AT 0730. WHILE BRAKING FOR A RED LIGHT THE PASSENGER SIDE FRONT TIRE WENT OVER A WET STORM SEWER DRAIN GRATE. THE SLICK SURFACE OF THE DRAIN GRATE CAUSED THE TIRE TO SKID. THE ABS SYSTEM ACTIVATED AND THE BRAKES RELEASED, ALLOWING THE VEHICLE TO PROCEED UNIMPEDED TOWARD THE INTERSECTION. I PRESSED THE BRAKE PEDAL HARDER. THE VEHICLE STOPPED JUST INTO THE INTERSECTION. THERE WAS NO COLLISION. I DO NOT KNOW IF PRESSING THE BRAKE PEDAL HARDER HAD ANY EFFECT OR IF THE SYSTEM MANAGED TO APPLY THE BRAKES ITSELF AFTER THE TIRES WERE ON PAVEMENT AGAIN. THIS IS THE FIRST TIME I HAVE EXPERIENCED THIS SITUATION. THE CONSEQUENCE WAS THAT THE VEHICLE PROCEEDED ABOUT 10 FEET INTO THE INTERSECTION, E.G. BEYOND THE "STOP" LINE. IF THE BRAKES HAD NOT RELEASED THE VEHICLE WOULD HAVE STOPPED BEHIND THE WHITE "STOP" LINE. ACCORDING TO THE TOYOTA DEALER THERE IS NOTHING WRONG WITH THE VEHICLE. *TR

SPEED CONTROL SPEEDS UP VEHICLE WHEN APPLYING BRAKES TO DISENGAGE SPEED CONTROL AND SLOW VEHICLE. THIS HAS HAPPENED ON NUMEROUS OCCASIONS WHILE ATTEMPTING TO DISENGAGE THE SPEED CONTROL BY USING THE BRAKE PEDAL. *TR

MOMENTARY LOSS OF BRAKING CAPABILITY WHILE TRAVELING OVER AN UNEVEN ROAD SURFACE, POTHOLE OR BUMP. I ALMOST REAR ENDED THE CAR IN FRONT OF ME YESTERDAY IN THE RAIN. *TR

THE 2007 TOYOTA FJ CRUISER HAS A SIMILAR IF NOT THE SAME BRAKING ISSUE AS THE PRIUS. IF THE VEHICLE HITS A BUMP, POTHOLE ETC WHILE ACTIVELY BRAKING THE BRAKES STOP WORKING UNTIL THE BRAKE PEDAL IS COMPLETELY LET OFF AND REAPPLIED. ALMOST CAUSED SEVERAL ACCIDENTS IN MY CASE. *TR

BRAKES FAIL MOMENTARILY AFTER RIDING OVER A BUMPY ROAD. THIS IS SIMILAR TO THE RECALL ON THE TOYOTA PRIUS. *TR

I BOUGHT MY FJ USED IN MARCH WITH ABOUT 26K ON IT. LOVE THIS TRUCK TO DEATH UNTIL THE BRAKE FAILURE SLIDE!!!. I WAS COMING TO A STOP AT A BUSY INTERSECTION, I LIVE IN A BUSY CITY "NEWARK NJ" (I KNOW I KNOW, HOLD BACK THE JOKE/SARCASM JUST FOR A BIT ;-)). ANYWHO, I WAS ONLY DOING ABOUT 25 OR LESS AND ABOUT 5-10 MILES ON A FLAT SURFACE MY CAR STARTED TO SLIDE, I THOUGHT MAYBE IT WAS OIL ON THE GROUND OR SOMETHING SO DIDN'T PAY IT MUCH MIND. IT WAS A VERY SLOW SLIDE BUT IT STILL SLID A FEW FEET WHERE I HAD TO PUMP THE PEDAL TO STOP. IT DID IT AGAIN WHEN I WAS COMING TO AN OFF RAMP ON RT 22. THIS TIME THE TRUCK SLID SUPER FAR THE BRAKE PEDAL WAS PRESSING JUST AS HARD AGAINST MY FOOT AS I PRESSED DOWN TO STOP IT, LUCKILY THERE WERE NO CARS IN FRONT OF ME. SCARED THE CRAP OUT OF ME!! THIS IS WHEN I FOUND THIS FORUM AND SEARCHED FOR SIMILAR PROBLEMS. I FOUND A FEW POST PRINTED THEM ALL OUT WITH SUGGESTED FIXES AND BROUGHT THEM TO THE DEALER. I SHOWED THE SERVICE TECHS, AND THEY LIKE TOOK A QUICK LOOK AND THROUGH THEM TO THE SIDE. I SAID DON'T YOU WANT TO KEEP THESE. THEY SAID NO WE DON'T NEED THIS STUFF. THEY CHECKED A BUNCH OF STUFF SAID BRAKES AND PADS WERE GOOD, AND SAID THE PROBLEM WAS THE BRAKE FLUID, SO THEY CHANGED IT. ROAD AROUND FOR ABOUT ANOTHER MONTH OR SO AND WITH NO PROBLEMS. UNTIL IT HAPPENED AGAIN THIS TIME WHILE I'M IN STOP AND GO TRAFFIC ON MY WAY TO WORK. AGAIN SLOW PACE BUT I STILL HAD TO DIP AROUND THE CAR IN FRONT OF ME AND ON TO THE SHOULDER TO AVOID HITTING TH

2007 FJ CRUISER: WHEN BRAKING OVER UNEVEN SURFACE THE ABS KICKS IN AND CAUSE MY BRAKES TO GO FROM 100% TO 20%. I HAVE TALKED TO THE DEALERSHIP AND READ COUNTLESS REPORTS ONLINE AND THIS IS A REAL PROBLEM. I BELIEVE THIS IS A SIMILAR ISSUE TO THE ABS PROBLEM WITH THE PRIUS AND IS A SOFTWARE ISSUE WITH THE FJ CRUISERS ABS.

THE BRAKE PEDAL DROPS TO THE FLOOR, AND THE BRAKES STOP WORKING OVER BUMPS WHILE BRAKING. IM ASSUMING THIS IS THE ANTI LOCK BRAKE SYSTEM. BUT IT FEELS VERY DANGEROUS. THE BRAKES COMPLETELY GIVE OUT AND YOU CONTINUE TO ROLL FORWARD WITHOUT STOPPING. ONLY WAY TO MAKE IT GO AWHILE WHEN IT OCCURS IS TO LET YOUR FOOT OFF THE BRAKE AND RE-APPLY. BUT YOU ARE AT RISK AT REAR ENDING SOMEONE SINCE THE VEHICLE STOPS MANY FEET FARTHER THEN YOUR SUPOSSED TO. THIS ALSO HAPPENED ON MY 2007 TOYOTA TACOMA (WHICH I SOLD) IM ASSUMING IT HAD THE SAME BRAKING SYSTEM AS MY CURRENT TOYOTA. I BELIEVE THE ANTI LOCK BRAKE IS DEFECTIVE. *CN

I OWN AN 07 FJ CRUISER AND MY WIFE AN 08, THAT HAS THE EXACT SAME PROBLEM AS THE PRIUS. WHEN EVER I GO OVER A BUMP IN THE ROAD AT LOW SPEED AND BRAKE THE BRAKES FAIL TO WORK IMMEDIATELY WHEN THE CAR IS ON A BUMPY OR SLIPPERY SURFACE, OR WHEN IT DRIVES OVER POTHOLES I GET THAT SAME THING. I HAVE 26K ON THE VEHICLE AND LOVE IT BUT NOW IM CONFUSED ABOUT THAT BRAKE PROBLEM OR IF THERE IS ONE WITH THIS PROBLEM! HELP!!!!!!!!!! *TR

I DRIVE A 2007 TOYOTA FJ CRUISER AND HAVE EXPERIENCED PROBLEMS WITH BRAKING ON AT LEAST THREE OCCASIONS. I HAVE HEARD FROM MANY OTHER FJ CRUISER DRIVERS WHO HAVE ALSO EXPERIENCED THIS PROBLEM: WHEN DRIVING AT RELATIVELY LOW SPEEDS (BELOW 40 MPH) AND ATTEMPTING TO BRAKE, SUCH AS AT A STOPLIGHT, THE BRAKES WILL LOCK UP CAUSING THE VEHICLE TO CONTINUE TO ROLL FORWARD EVEN WHILE THE BRAKE IS BEING PRESSED. IT SEEMS AS THOUGH THE ABS KICKS IN AS YOU CAN FEEL THE "SCRAPING" FEELING THROUGH THE PEDAL. FROM ALL OTHER ACCOUNTS AND BASED ON MINE, IT SEEMS THE COMMON FACTOR IS ROLLING OVER UNEVEN TERRAIN WHILE BRAKING, SUCH AS A POTHOLE, MANHOLE COVER, OR JUST BUMPY ASPHALT. SO FAR I WAS FORTUNATE NOT TO HAVE ANOTHER CAR DIRECTLY IN FRONT OF ME. HOWEVER, I CAM DANGEROUSLY CLOSE TO ROLLING THROUGH A RED LIGHT WHICH COULD HAVE CAUSED A COLLISION WITH THE TRAFFIC WHICH HAD THE GREEN LIGHT. THERE ARE AT LEAST DOZENS OF THESE SAME REPORTS WHICH I'VE READ ON JUST ONE FJ CRUISER OWNER FORUM. ALL ARE CONSISTENT WITH BRAKING OVER UNEVEN TERRAIN WHICH RESULTS IN THE VEHICLE CONTINUING TO ROLL FORWARD. *TR

I OWN A 2007 TOYOTA FJ CRUISER. MY BRAKES DO EXACTLY WHAT IS DESCRIBED WITH THE 2010 PRIUS. ON UNEVEN ROAD SURFACES AND ON SHARP CURVES, THE BRAKES PERIODICALLY AND MOMENTARILY FAIL. BUT A QUICK PUMP ON THE BRAKES WITH THE FOOT OFF OF THE ACCELERATOR USUALLY RESTORES THEM INSTANTLY. I HAVE HAD THE BRAKES CHECKED AND SO FAR IT HAS BEEN REPORTED THAT THEY ARE IN GOOD SHAPE. THE LAST TIME IT HAPPENED IS STATED HEREIN UNDER THE HEADING "APPROXIMATE INCIDENT DATE:". *TR

1. THE 'UNRESPONSIVE' ISSUE - THIS SEEMS TO HAPPEN WHEN BRAKING AT LOW SPEEDS (UNDER 40MPH) AND ONE SIDE OF THE VEHICLE HITS A POTHOLE, UNEVEN PAVEMENT, OR LOOSE GRAVEL. THE RESULT IS THAT THE BRAKES BECOME MOMENTARILY UNRESPONSIVE UNTIL YOU RELEASE AND PUMP THE BRAKE PEDAL AGAIN. IT DEFINITELY FEELS LIKE THE BRAKE ELECTRONICS/SOFTWARE ARE CONFUSED AND GET CAUGHT IN A MOMENTARY GLITCH AS IT FIGURES OUT WHAT TO DO. 2. THE 'OVERRESPONSIVE' ISSUE - THIS SEEMS TO HAPPEN UNDER VERY SIMILAR CONDITIONS TO THE OTHER ISSUE - I.E., LOW SPEED BRAKING OVER UNEVEN OR BROKEN PAVEMENT. THE RESULT IS THAT THE BRAKES BECOME SUPER SENSITIVE TO THE POINT THAT NORMAL BRAKING FLINGS YOU AND YOUR PASSENGERS HARD INTO TO YOUR SEATBELT RESTRAINTS, AS IF YOU ARE SLAMMING ON YOUR BRAKES. THE BRAKE PEDAL GETS A LITTLE MUSHY AND THEN WHAM... THE BRAKES KICK IN BIG TIME. I AM PRETTY SURE THAT THIS CONDITION IS CREATED BY THE BRAKE ASSIST FUNCTION. *TR

WHEN APPLYING MY BRAKES ON SEVERAL OCCASIONS MY BRAKES WOULD FAIL TO ENGAGE AND STOP THE CAR. IT OCCURS WHEN I COME TO A STOP UNDER NORMAL BRAKING AND ONE TIRE HITS A BUMP SUCH AS A MAN HOLE COVER. NO MATTER WHAT I DO THE BRAKES DO NOT ENGAGE AND THE CAR CONTINUES TO ROLL FORWARD. ANTI LOCK DOES NOT ENGAGE WHEN THIS OCCURS IT IS AS IF THE BRAKE PEDAL IS DEAD. ALSO, THE OPPOSITE EXTREME OCCURRED YESTERDAY WHEN APPLIED MY BRAKES WITH NORMAL PRESSURE AND THE VEHICLE BRAKED VERY QUICKLY AND UNEXPECTEDLY HARD. EVERYTHING FLEW FORWARD IN THE VEHICLE. I BELIEVE THESE TWO ISSUES ARE COMMON TO TOYOTA FJ CRUISER OWNERS AND ARE DANGEROUS LIFE SAFETY ISSUES. *TR

WHILE DRIVING IN A STRAIGHT LINE AT ABOUT 35 MPH I EXPERIENCE SUDDEN APPLICATION OF THE RIGHT FRONT BRAKE AND THE SKID INDICATOR LIGHT CAME ON. THE APPLICATION OF THE BRAKE CAUSED ME THE SWERVE TO THE RIGHT. HAD I BEEN AT HIGHWAY SPEED I SUSPECT THAT THE FJ WOULD HAVE ROLLED. *TR

TOYOTA FJ CRUISER CLUTCH PEDAL STICKS WHEN COLD. THE TRUCK BECOMES UNPREDICTABLE OF WHAT ITS GOING TO DO. TOYOTA SAID ITS BEEN WORKING ON A FIX FOR OVER A YEAR NOW AND I HAVEN'T HEARD ANYTHING. IF YOU LOOK AT TOYOTA FORUMS THERE ARE A LOT OF COMPLAINTS. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT HE NOTICED ON TWO OCCASIONS, THE VEHICLE BEGAN TO SUDDENLY ACCELERATE TO ALMOST 90 MPH. WHEN HE INSPECTED THE VEHICLE, HE SAW THAT THE FLOOR MATS SLID UP AND WERE PUSHING AGAINST THE GAS PEDAL. THE FLOOR MATS WERE NOT PROPERLY HOOKED TO PREVENT THE ACCELERATION. HE HAS NOT CONTACTED THE DEALER OR THE MANUFACTURER TO-DATE. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 29,939. THE FAILURE MILEAGE WAS APPROXIMATELY 22,000. UPDATED 03/01/10. *LJ UPDATED 06/11/10

WINDSHIELD CRACKED FROM POSSIBLE COLD WEATHER CONDITION. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE INNER FENDER LINER METAL FRACTURED AT THE CRUMPLE ZONE. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 102,000.

WHILE OPERATING A 2007 TOYOTA FJ (59,956 MILES) ALL THE INSTRUMENT PANEL INDICATOR LIGHTS CAME ON AND THE BRAKE PEDAL FELT AS IF IT WENT TO THE FLOOR. YOU WOULD PRACTICALLY HAVE TO STAND ON THE BRAKE PEDAL TO GET THE BRAKES TO FUNCTION. FOR SOME DRIVERS, IT WOULD BE EASY TO ASSUME THAT THE BRAKES WENT OUT COMPLETELY. THIS LOSS OF BRAKES COULD HAVE LED TO AN ACCIDENT. FORTUNATELY, IT DID NOT. TAKING THE VEHICLE TO THE TOYOTA DEALER FOR SERVICE, IT WAS DETERMINED THAT THE 'ABS HYDRAULIC BOOSTER', PART NUMBER 4705035052, HAD MALFUNCTIONED. OBVIOUSLY, THIS IS A CRITICAL COMPONENT. IT IS ALSO A COSTLY PART AT $2,145.99, PLUS LABOR. *TR

TL*THE CONTACT HAS A 2004 TOYOTA FJ CRUISER. THE CONTACT STATED THAT SPORADICALLY THE PASSENGER SIDE REAR TIRE LOSES TIRE PRESSURE. IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH. HE CONTACTED THE MANUFACTURER AND WAS INFORMED BY A REPRESENTATIVE THAT HIS VIN NUMBER DID NOT FALL UNDER RECALL #06V235000,(TIRES:BEAD), THEREFORE HE WOULD HAVE TO ASSUME RESPONSIBILITY FOR ANY REPAIRS. THE TIRES FAILURE AND CURRENT MILEAGES WERE 10.

I HAVE A 2007 TOYOTA FJ CRUISER AND THE FRONT INNER FENDER ARE BULGING AND TEARING AT THE CRUMPLE ZONE. I'VE CONTACTED RIVERSIDE AUTO WHERE I BOUGHT IT BRAND NEW AND THEY BASICALLY TOLD ME THERE'S NOTHING THEY WILL DO TO FIX THE ISSUE, TOYOTA HAS REDESIGNED THE INNER FENDER 3 TIMES SO THEY KNOW THERE IS A PROBLEM BUT REFUSE TO ACKNOWLEDGE IT. *TR

DEFECTIVE PAINT. EXCESSIVE CHIPPING OF PAINT ON THE VEHICLE. ESPECIALLY AROUND THE FRONT WINDOW AND SIDE PANELS. NOT DUE TO ROCKS. LOOKS LIKE POLKA DOTS ALL OVER. *TR

MY 2007 TOYOTA FJ CRUISER HAS A DESIGN FLAW IN IT'S FRONT FENDERS. THE INNER FENDERS BULGE AND TEAR WHICH CAUSES THE FENDERS TO BIND ON THE DOORS, ETC. THE BULGES AND TEARS ARE IN THE "CRUMPLE' AREAS OF THE INNER FENDERS DESIGNED TO BUCKLE DURING A CRASH. THIS DEFECT WEAKENS AN AREA THAT SHOULD BE INTACT . *TR

MY 2007 TOYOTA FJ CRUISER HAS UNEVEN WEAR ON THE EDGE OF THE TIRES AT 40,000 MILES. THE ORIGINAL COMPLAINT THAT BROUGHT ME TO THE DEALERSHIP WAS A VIBRATION IN THE STEERING WHEEL AT 65MPH. I WAS INFORMED THAT THERE IS A RECALL (CAMPAIGN ID # 06V235000) BUT MY VEHICLE DOES NOT HAVE THE ASSIGNED FOR THE RECALL. IT CERTAINLY SOUNDS LIKE MY VEHICLE IS EXPERIENCING SIMILAR ISSUES. I NOTICED THE VIBRATION APPROXIMATELY 3-4 MONTHS AGO. *TR

MY INNER FENDERWELLS HAVE CRACKED ALL THE WAY THROUGH AT THE CRUMPLE ZONES. I HAVE MENTIONED THIS TO TOYOTA, AND THEY SAY IT IS BECAUSE OF MY AFTERMARKET BUMPER EVEN THOUGH HUNDREDS OF DOCUMENTED CASES HAVE BEEN FOUND ON STOCK FJ CRUISERS OF SAME YEAR AS MINE. I FEEL THIS ISSUE NEGATES THE STRENGTH OF THE FENDERS AND WOULD NOT REACT FAVORABLY IN A CRASH. *TR

PAINT CHIPS ON A 2007 BLUE TOYOTA FJ CRUISER ALL OVER VEHICLE. *TR

2007 FJ CRUISER HAS A CRACK ON THE INNER FENDER, ALSO REFERRED TO AS AN ENGINE BAY BODY RIP. THIS VEHICLE HAS NOT BEEN IN AN ACCIDENT. THE CRACK WAS NOTICED AT AROUND 39,500 MILES, BUT MAY HAVE BEEN THERE EARLIER. NO CORRECTIVE PARTS HAVE BEEN INSTALLED. *TR

2007 TOYOTA FJ CRUISER HAS ISSUES WITH THE TIRE PRESSURE. *NJ THE CONSUMER STATED HER INSURANCE COMPANY MADE HER AWARE OF A RECALL REGARDING THE TIRES ON THE VEHICLE. THE CONSUMER STATED HER HUSBAND HAD TO KEEP PUTTING AIR IN THE TIRES. THE VEHICLE HAS DUNLOP TIRES WHICH WAS RECALLED. THE DEALER INFORMED THE CONSUMER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INVOLVED IN THE RECALL. *JB

VEHICLE: 2007 TOYOTA FJ CRUISER, 4WD AUTOMATIC. 1. EVENTS: ABS SYSTEM FAILURE CAUSED BY UNEVEN ROAD SURFACE (POTHOLE, STEP DOWN, BUMPY ROAD) CAUSING A SINGLE WHEEL TO MOMENTARILY LOSE TRACTION DURING BRAKING. 2. THE ABS SYSTEM ENGAGES (BRAKE PEDAL CANNOT BE FURTHER DEPRESSED, PULSATING / CLICKING NOISE HEARD) TO STABILIZE THE ERRANT WHEEL, BUT DOES NOT PROCEED WITH STOPPING THE VEHICLE AFTERWARDS, NO MATTER HOW HARD THE DRIVER CONTINUES TO PRESS THE BRAKE PEDAL. THE ONLY WORKAROUND IS FOR THE DRIVER TO KNOW TO RELEASE THE BRAKE PEDAL AND RE-APPLY IT. 3. TOYOTA INSISTS THAT THIS IS NORMAL FOR THE ABS SYSTEM DESIGN AND THAT THERE IS NO FIX FOR THE PROBLEM APART FROM APPLYING THE WORKAROUND. I BELIEVE OTHERWISE SINCE I HAVE CONTACTED ONE OTHER FJ CRUISER OWNER WHO HAD THE SAME PROBLEM, AND HAD HIS MASTER CYLINDER / ACTUATOR REPLACED BY TOYOTA UNDER WARRANTY, AND THIS CORRECTED THE PROBLEM, ALTHOUGH AT AN EXPENSE OF ABOUT $2,000 TO THE DEALERSHIP. I FAXED A DESCRIPTION OF THIS COMPLAINT TO RIGHT TOYOTA IN SCOTTSDALE ON JUNE 11, 2009, VISITED THE DEALERSHIP AS MY ODOMETER ROLLED OVER TO 36,000 MILES AN HOUR AFTER SENDING THE FAX, AND REGISTERED A CASE NUMBER WITH TOYOTA CUSTOMER ASSISTANCE CENTER ON JUNE 12, 2009 DESCRIBING THE ISSUE AND HOW THE DEALER EXPLAINED THAT THE PROBLEM COULD NOT BE FIXED. I HAVE EXPERIENCED THIS ISSUE FOUR TIMES IN THE LAST TWO YEARS. THE MOST RECENT OCCURRENCE WAS ON JUNE 6, 2009, WHERE I WAS BRAKING FOR A RED LIGHT, THE VEHICLE ROLLED OVER A 3 INCH STE

I PURCHASE MY BLUE TOYOTA FJ CRUISER IN SEPTEMBER OF 2006. A MONTH AFTER MY PURCHASE I NOTICED THE PAINT CHIPPING IN ODD PLACES THAT I HAVEN'T SEEN ON ANY OF THE OTHER CARS I HAD OWNED. I STARTED TALKING TO OTHER BLUE TOYOTA FJ CRUISER OWNERS AND THEY HAD THE SAME COMPLAINT. I HAVE BEEN TO THE TOYOTA DEALERSHIP AND THEY HAVE PUSHED ME UNDER THE RUG. I HAVE CALLED THE TOYOTA HOTLINE AND THEY HAVEN'T EVEN CONSENTED TO LOOK AT IT. SO HERE I AM. *TR

BEGINNING AT ABOUT 2 MONTHS THE PAINT ON MY VEHICLE STARTED COMING OFF. MY FRIEND HAS THE SAME VEHICLE BUT 2 WEEKS OLDER & HAS THE SAME PROBLEM. THE PAINT HAS GOTTEN PROGRESSIVELY WORSE AND NOW MY CAR IS RUSTING. MY FRIEND ALSO HAS RUST SPOTS ON HIS CAR. *TR

THE WINDSHIELD HAS BEEN CRACKED MULTIPLE TIMES BY NORMAL ROAD DEBRIS. *TR

MY FJ CRUISER HAD BRIDGESTONE DUELER TIRES ON IT WHEN BOUGHT. THE TIRES WERE LOSING AIR PRESSURE AND CAUSING MY CAR TO STOP UNEVENLY. I BROUGHT THE CAR TO TOYOTA TWO TIME AND THEY SAID IT WAS A SUSPENSION PROBLEM, BUT THEY NEVER OFFERED TO FIX THE SUSPENSION. THE DUELER TIRES WORE UNEVENLY AND I WAS FORCED TO CHANGE THE TIRES MYSELF AT ONLY 14K MILES ON THE BRAND NEW CAR. I ASKED FOR REIMBURSEMENT SINCE THERE WAS A TIRE RECALL THAT I ONLY FOUND OUT ABOUT MYSELF ON THE INTERNET. I WAS NEVER TOLD ABOUT THE TIRE RECALL WHEN I BROUGHT MY CAR TO THE DEALER ON TWO OCCASIONS. THEY, TOYOTA, HAS CLAIMED THAT MY PRODUCTION NUMBER AND DATE ON MY CAR DON'T FIT INTO THE RECALL, BUT DON'T ADDRESS THAT THE PRODUCTION OF MY CAR DOESN'T SOLVE THE PROBLEM THAT DEFECTIVE TIRES WERE PUT ON MY CAR. *TR

THE INNER FENDER WALL OF MY FJ CRUISER IS BENDING AND BASED ON OTHERS WITH THIS ISSUE IT WILL SOON CRACK, THE INNER FENDER WALL WILL MOVE AND IMPEDE THE MOVEMENT OF THE DOORS. THIS IS A DESIGN DEFECT AND TOYOTA SHOULD ISSUE A RECALL. *TR

DRIVER SIDE INNER FENDER APRON STARTED BULGING IN THE AREA OF THE CRUMPLE ZONE. THE VEHICLE HAS NOT BEEN IN THE ACCIDENT OR ANYTHING SIMILAR THAT WOULD SEEM TO LEAD TO THE FAILURE. I AM VERY CONCERNED WITH THE SAFETY OF THE VEHICLE NOW SINCE THE CRUMPLE ZONE IS AFFECTED. *TR

METAL TEARS OF THE INNER FENDER APRONS ON BOTH SIDES AT THE CRUMPLE ZONES. *TR

THE PAINT HAS BEEN DRAMATICALLY CHIPPING OFF OF MY 2007 FJ CRUISER. THIS WAS BROUGHT TO THE DEALERSHIPS AND TOYOTA REGIONAL MANAGERS ATTENTION IMMEDIATELY AND IT HAS BEEN OVER A YEAR AND A HALF OF UNRETURNED PHONE CALLS, MISSED APPOINTMENTS AND BEING DISMISSED. *TR

THE INNER FENDER WELLS ON MY 2007 TOYOTA FJ CRUISER ARE BULGING ON BOTH THE DRIVERS SIDE AND PASSENGER SIDE. DEFINITELY SEEMS TO BE A DEFECT IN DESIGN DUE TO POSSIBLE INABILITY OF VEHICLE TO HANDLE THE FLEXING, ETC. IT IS NOW AFFECTING MY DOORS AND BASIC ALIGNMENT OF VEHICLE. GAPS ARE FORMING WHERE THERE SHOULDN'T BE GAPS, ETC. I JUST GOT MY TIRES BALANCED AND ALIGNED AND THE TIRES ARE WEARING FUNNY JUST 2 MONTHS AFTER HAVING WORK DONE ESPECIALLY ON THE DRIVERS SIDE WHERE THE LARGER BULGE IS. THE BULGE IS NOTICEABLY GETTING LARGER WITH TIME AND WILL EVENTUALLY CRACK. I HAVE FRIENDS THAT HAVE THE SAME PROBLEM, STARTED WITH BULGES AND NOW THEIR INNER FENDER WELLS ARE CRACKED. TOYOTA WILL NOT ADMIT TO HAVING KNOWLEDGE OF THIS PROBLEM AND YET EVERY YEAR THE VEHICLE HAS BEEN PUT INTO PRODUCTION THE INNER FENDER WELLS HAVE BEEN IMPROVED AND REINFORCED...BUT EVEN THOSE ARE NOW FAILING AND BULGING. TOYOTA IS AWARE OF THIS AND BLAMING IT ON OFFROAD USE OR AFTERMARKET PARTS....BUT ITS HAPPENING ACROSS THE BOARD ON ALL OR MOST FJ'S. WORK/WARRANTY WORK IS BEING DENIED. WE ARE NOW LEFT WITH A VEHICLE THAT WILL MOST LIKELY FALL APART OR EVEN WORSE...WILL AFFECT US IN AN AUTO ACCIDENT...SINCE ITS RELATED TO THE CRUMPLE ZONE AND IS SHOWING WEAKNESS. PLEASE HELP US AND DO SOMETHING ABOUT IT FOR US. *TR

I WENT ON A TRIP WITH MY TOYOTA FJ CRUISER. PRIOR TO THE TRIP, I NOTED THAT THERE WAS NOTHING WRONG WITH MY VEHICLE. DURING THE TRIP, I LOOKED IN THE ENGINE COMPARTMENT AND OBSERVED THE INNER LEFT FENDER HAD A SLIGHT BULGE AND CRACK. THE VEHICLE WAS NOT INVOLVED IN ANY COLLISION, NOR ANY OTHER TYPE OF EVENT. JUST NORMAL ROAD DRIVING. *TR

TOYOTA FJ CRUISER FENDER FLARE PROBLEM..ENGINE BAY BODY RIPS...BIG PROBLEM SEEN IT ON 6 FJ WOW NEED A SERIOUS LOOK AT THIS PROBLEM BEFORE SOMEONE GETS HURT OR DIES... *TR

I HAVE AN 07 TOYOTA FJ CRUISER & I CHECKED OUT MY INNER FENDER AND SAW 2 CRACKS AFTER READING AN ONLINE FORUM COMPLAINT BOARD ABOUT THIS ISSUE. MY GOOD FRIEND WHO ALSO HAS AN 07 FJ CRUISER HAS THE SAME EXACT PROBLEM AS WELL. THERE ARE CRACKS ON BOTH SIDES OF MY INNER FENDER. MY PASSENGER SIDE HAS A BULGE AROUND THE CRACK AS WELL. MY WIFE DRIVES OUR SMALL CHILDREN (INFANTS) AROUND AND I AM VERY CONCERNED. I READ MANY PLACES THIS IS A DESIGN FLAW BY TOYOTA. PLEASE HELP AS THIS IS A MAJOR SAFETY ISSUE AND SHOULD NEVER CRACK AS IT HAS. *TR

BULGES IN INNER FENDER-UNDER HOOD, FENDER APPEARS TO BE COMPRESSING OR COLLAPSING. *TR

2007 TOYOTA FJ CRUISER: THE INNER FENDER APRON/LINER UNDER THE HOOD IS BULGING. APPEARS TO BE A MANUFACTURER DEFECT. THERE HUNDREDS OF OTHERS WITH THE SAME VEHICLE, SAME PROBLEM. IN MANY CASES THAT I'VE SEEN THE METAL BEGINS TO TEAR. SEE WWW.FJCRUISERFORUMS.COM FOR PICTURES, MORE INFO, ETC.... *TR

I HAVE A 2007 TRD FJ CRUISER WITH THE 100,000 MILE WARRANTY ON IT. AT 12,000 MILES I NOTICED A FENDER BULGE ON THE PASSENGER SIDE OF THE INNER FENDER UNDER THE HOOD. I HAVE NEVER TAKEN THE CAR OFFROADING AND ALREADY, AT 12,000 MILES HAVE A FENDER BULGE. THIS DESIGN FLAW CAN GREATLY AFFECT THE CARS INTEGRITY AND LIFE SPAN. THE LATEST QUOTE ON A FIX FROM A TOYOTA DEALER WAS $4,700. MANY PEOPLE ARE EXPERIENCING THIS TYPE OF BULGE OR CRACK IN THEIR INNER FENDERS AND IT CAN BE A HUGE PROBLEM IF YOU GET INTO A CAR ACCIDENT AND THE CRUNCH ZONE ALREADY HAS A CRACK IN IT. THIS IS A WIDESPREAD PROBLEM THAT NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS HURT. *TR

VEHICLE WAS TRAVELING IN THE SNOW IN 4 WHEEL DRIVE MODE WHEN IT STARTED SHAKING AND VIBRATING AS IF IT HAD A FLAT TIRE. BECAUSE OF THE ROAD CONDITIONS VEHICLE WAS TRAVELING UNDER THE SPEED LIMIT. FAILURE WAS CATASTROPHIC AND DID NOT ALLOWED THE VEHICLE TO COAST TOO LONG AS THE VEHICLE JAMMED, AS IF THE TRANSMISSION HAD BROKEN SEVERAL GEARS AND BINDED. VEHICLE CAME TO A STOP ENGULFED IN SMOKE AND FLAMES WERE COMING FROM THE UNDERCARRIAGE. UPON A QUICK INSPECTION IT WAS NOTED THAT THE FRONT SHAFT HAD BROKEN OFF FROM THE TRANSFER CASE, OIL WAS POURING OUT OF THE CASE AND HEAT FROM THE EXHAUST PIPE, IMMEDIATELY NEXT TO IT, HAD IGNITED THE OIL INTO FLAMES. MUD AND SNOW WAS USED TO PUT OUT THE FLAMES. UNDER FURTHER INVESTIGATION IT WAS NOTICED THAT ONE OF THE TIRES HAD A BLOW OUT, THE REAR DRIVER TIRE. AFTER REPLACING THE FLAT TIRE WITH THE SPARE, AN ATTEMPT TO CARRY ON 2 WHEEL DRIVE MODE WAS MADE BUT RESULTED IN IMMEDIATE RESTART OF THE FLAMES. FLAMES WERE PUT OUT AGAIN USING SAME METHOD AS BEFORE AND VEHICLE WAS TOWED TO A TOYOTA DEALERSHIP. DEALERSHIP UPON CURSORY EVALUATION DECIDED THAT THE TRANSFER CASE HAD "INSUFFICIENT" LUBRICANT. THIS IS RIDICULOUS AS THE TRANSFER CASE LOST ITS OIL WHEN THE SHAFT POPPED OUT WITH THE FRONT PINION GEAR CAUSING THE FIRE. THERE IS NO HEAT SHIELD TO PROTECT OIL FROM IGNITING IN THESE VEHICLES. VEHICLE HAS NOT EVEN BEEN TAKEN APART AS TOYOTA IS NOT AUTHORIZING THE WARRANTY REPAIR. ALL PARTS ARE AVAILABLE FOR REVIEW. *TR

FENDER APRON TEARS AND BULGES IN THE ENGINE BAY OF MY FJ CRUISER. *TR