2022 Subaru Outback complaints

The front windshield spontaneously cracked during use of windshield wipers. Resulted in multiple cracks from top center of windshield.

While stopped at a yield sign waiting for traffic to clear so I may proceed with my left turn, I stepped on the accelerator pedal to make my left turn; however, my car did not go because the engine had turned off due to the auto stop feature. Once the engine restarted, I was no longer clear about proceeding with my left turn and had to apply the brakes very hard immediately to stop my vehicle. The auto engine stop is a dangerous feature that should not automatically be applied when starting the car.

My windshield just cracked by itself without hitting anything. This is really frustrating.

Front windshield spontaneously cracked without incident right where the rearview mirror is attached.

Small rocks cause very large cracks across windshield. Windshield seems brittle or fragile.

The front rotor warp excessively causing the brake pedal and the entire car to shake uncontrollably. The entire front brake assemblies were replaced at Subaru of Coconut Creek. Our safety was definitely at risk as it was very hard to brake going downhill with the brake pedal and the car shaking uncontrollably. The dealer confirmed black spots on the front rotors and warped front rotors. There were not warnings prior to, during, or after the shaking. Going downhill was made very uncomfortable. Subaru of Coconut Creek services the vehicle and notified me of the black spots and warped front rotors. There was nauseating burning smell coming from under the hood and we had to wait 15 minutes for it to disssipate.

Sunroof shattered while driving 45mph on a city street. It was not hit by anything we could see, nor was there any debris flying in the air. We pulled over and took a photo. I called the dealership who said to call Subaru USA to start a case, but of course their offices are closed for the weekend.

2022 Subaru Outback with 22, 000 miles. Car had been in my garage overnight. I drove to our local recreation center on the morning of February 18, ambient temperature in mid-30's. I came out 1.5 hours later and discovered a large crack had spontaneously formed in the windshield (passenger side, extends to very edge, no visible causative chip).

My front windshield has cracked twice in the span of 2 years. August 2023 and recently Feb 2025. Bought the car from a legitimate dealer in 2022. Both times there was no hard impact, no obvious damage (initially), the cracks also spread very quickly once the damage is obvious. The repairs each time is not covered, not covered by insurance, $1400+ each time.

2ND time car won't start. First time was 6m ago, pulled battery, tested, bad, replaced battery. Getting ready to charge battery, if bad, will tow to subaru dealership. Last time, subaru tested, said nothing wrong. if your car won't start, how do you function. Went on line and you can't believe how many people suffer with this. Seems like the same drain on the system, from starlink, lights, not shutting down like there supposed too.

Winsdshield cracking and breaking easily. Windshield was replaced in 2023 due to a crack that spread over the whole windshield after being hit with road debris Again this weekend the windshield was hit with road debris and has a size able crack which requires a full windshield replacement. 2 windshields in 3 years of owning the vehicle feels like a defect in the quality and safety of the glass Replacement windshield in 2023 was from the Subaru manufacturer and installed by the dealership

The vehicle’s windshield developed a 8-10 inch crack due to most likely temperature changes. Seems like a known issue for this year/model vehicle.

The contact owns a 2022 Subaru Outback. The contact stated that while starting the vehicle in the morning, she became aware of a 16-inch crack on the windshield. The contact stated that the crack had started close to the passenger’s side A-pillar, approximately 3-inches above the passenger’s side windshield wiper. The contact stated that the vehicle was in the garage when she became aware of the crack. The vehicle had not been taken to a dealer or glass shop. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 41,000.

Front windshield glass developed spontaneous crack. Originating on the drivers side approximately 8 inches up from the bottom drivers side of the glass. Initially the crack was about 5 inches in length horizontal but quickly developed to be 12.5 inches over 24 hours in a garage. Glass is available for inspection. There is no discernible impact point and crack seems to be spontaneous. An appointment at the dealership for assessment was booked and rescheduled pending extended warranty.

I noticed a metal sound when I accelerated then the car jerked forward a few times. Shortly afterwards, ~5 min, the dashboard lights came on:Automatic Transmission Oil Temperature, Blind-Spot Detection, Check Engine, EyeSight System, Reverse Auto Braking and Vehicle Dynamic Control. I was able to drive slowly back home but not sure what is going on with this 3 year old car with 47,000 miles on it.

The Thermo control valve on the vehicle failed. This has been such a consistent problem, that Subaru has extended the warranty for this item to 150K miles. I realize that alone is not a safety problem, but the issue is that when there is a check engine light error, the system shuts down the cruise control, lane departure, collision avoidance (EyeSIGHT), and XMODE (all wheel drive). The safety issue is shutting down these unconnected safety features because of a check engine light. I will say that the dealer promptly fixed the problem at no charge under the extended warranty. my concern was the loss of the 4 wheel drive right as major snow was hitting the Mid Atlantic Area.

The touchscreen shuts down and makes the safety features shut off. This use to happen a few times per quarter, but now is happening a few times per month. Happens always while driving which causes the adaptive cruise to shut off, causing deceleration, the eyesight shuts off, the controls on the keyboard are not available. It takes a minute or two for the screen to reboot and safety features to re-engage, this causes distraction and possible safety hazard. Additionally, the speakers randomly will blast so loud it startles and distracts everyone in the car. This seems to happen randomly, can be at start up, or after sound system has been in use. Additionally, the power windows occasionally will not go back up. Thry reverse partway through raising. Then we have to wait a few seconds and try again. Please make Subaru issue a recall and remedy for-the control screen issue. It is the most dangerous problem we’ve listed here.

In November we used the car for a road trip and returned to our home in Snellville, GA on [XXX] parked the car, unloaded the contents, and put the sunshade in the windshield as we always do. The next day (XXX), I opened the car and removed a few small items used during the trip and walked around the car inspecting the exterior of the car for anything that may have changed due to this trip. At this time, I noticed a crack in the windshield that was not there the evening before. I had driven the car the entire trip and there was no time when something could have struck the windshield and precipitated this crack. I have been in a vehicle when a rock from the road has been kicked up by a vehicle ahead of me and struck the windshield. This type of impact can clearly be heard by passengers in the front seat, as it makes a considerable sound when striking the glass (similar to the sound of a small caliber weapon being fired). These is no indication on the exterior of the glass that this or any other external influence damaged and caused this windshield to crack. As I stated earlier, this windshield was not cracked when we exited the car the evening before. It is plainly visible when sitting in either of the front passenger seats and we would have noticed this. In my view this defect could have only been caused by mechanical stress between the mounting surface and windshield sometime between our arrival home and when this was first noted by us the next day. We have requested a replac

The contact owns a 2022 Subaru Outback. The contact stated that after parking the vehicle on a slightly inclined driveway, the vehicle erroneously rolled backwards. The failure occurred on several occasions and the parking brake was not activated. The vehicle was taken to the local dealer on two separate occasions, but no cause for the failure was found. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 13,927.

I was driving on the interstate, with no cars around me and I heard the windshield crack, the crack went from 3 inches to about 30 inches. There is no reason why this would have happened other than a defective windshield.

The car has been to the dealership five times for electrical/computer issues. First the main dash UI computer screen would occassionally lock up and freeze shutting all safety systems off. (cruise control, lane holding, blind spot warning, etc.) Then the battery failure issues started - basically four times the car when parked and sitting overnight for approximately one week - will not start and the battery is completely dead. This is a know Subaru issue with earlier models and even involved a class action lawsuit. Subaru has not fixed the issue in newer model cars and continues to deny it is an issue. This is gross negligence by continuing to make unsafe cars with the same flaw and nof fixing the issue.

Have second deep crack with light rock impact in less than one year

Windshield has a crack. There is no external force, neither accident happened

DEFECTIVE WINDSHIELDS: COSTLY REPAIR: I purchased this car when it was 9 months old with 7800 miles on it. I now have 30, 080 miles. and I have had to replace the windshield 3 times. I also had one a chip repaired. This means I have replaced the windshield every 7427. miles. Once the crack has started the lane sensing and brake stopping programs are halted. This is a serious safety issue. This is BEYOND RIDICULOUS for a NEW MODEL car. There much be something wrong with the making of these windshields, or the material used to make these windshields. This is a costly repair, being that the windshield needs re-calibrating each time. It's been around $2500.00 each time. The Subaru Dealer I purchased the car from has been made aware, but they have no solutions, no discounts, or no other options. Other than empathy, and tell me many others are having the same problems.

Automatic auto off-on began to fail and car didn't start well. I began to disable the automatic auto on off while driving because it began to sound like it would stall out while stopped at a traffic light . Then I forgot to disable the automatic auto off on and car stalled out while stopped at a traffic light. I took it to dealer, Rafferty Subaru, they couldn't find anything wrong with it. Then a few days later check engine light and other icons started flashing on dashboard. I took it to dealer, they said the gas cap was off. For the next week the automatic auto off on sounded like it would fail so I disabled it, the car didn't start normally every morning, and it began to feel like it didn't shift correctly as I accelerated or slowed down. About one day later it suddenly lurched to almost a stop while driving, check engine light was flashing, other icons on dashboard were flashing, the Park Brake icon started flashing. The engine continued to run but I couldn't go more than 2 mph. I put it in park and it started to smell like something was burning so I turned it off. I had to have it towed to the dealer, Rafferty Subaru.

Front windshield cracked while vehicle was parked after a car wash. Crack started from the center bottom outside, from the base.

Windshield cracked without warning and with no impact. Crack rapidly propagated and sounded like glass was going to break on highway. Took to Wagner Subaru dealer and they said this is typical and is not covered by recall or warranty.

Windshield cracked without any external impact. There was no crack when we parked the car in the evening, but the next morning there was a crack. There was no impact or visible reason that this should have happened.

My subaru outback windshield seems to use low quality glass or have poor windshield mount/frame design. Since purchasing the car new in April 2022, I have had 3 significantly cracked windshields; all of which propagated immediately after getting hit by a pebble mid-drive (not giving any opportunity to fix the chip). I am filing this complaint because I don’t think it should be standard for a windshield to propagate a crack so easily and consistently every time it gets chipped (this seems statistically improbable compared to other cars) - and it’s a legitimate hazard to visibility if I don’t have ample opportunity to get the chip repaired to prevent it from propagating to a crack. Essentially I’m saying that it’s almost guaranteed that getting a chip will result in a foot long crack during the same drive (I say almost because I have been able to repair a chip before it was too late once). Furthermore, the crack will often double in size over night (presumably due to temperature changes) - which leads me to speculate that the windshield glass accumulated internal stresses during install due to poor design. I have only replaced my windshield through official Subaru dealerships with their recommended glass vendor. I’ve attached two photos from my most recent cracked windshield; the first is the crack that propagated immediately after the pebble hit while driving, and the second is after leaving the car overnight stationary. Also note that this is usually at highway speeds; and i

Merging off the interstate at a speed of 75mph onto an off ramp at 7pm with 4 adults in the car and when I started braking the windshield cracked from the passages side a pillar in towards the center of the window approximately 7 inches. There were no other vehicles around us and no signs of a chip or previous damage that could have caused the break in the glass.The crack is halfway up/down the windshield and runs horizontal.

My EyeSight device stopped working correctly when I had the interior cleaned and the front windshield was spray cleaned. "Obstacle Detected" warnings started popping up and slowing down the car. Per the dealership, this was caused by the backsplash from the cleaner and now the entire device has to be replaced at a cost of $3300. Subaru later offered to replace it for $1800. I wish I was told to only spray the cleaner on a cloth or this could happen. Now I have to replace it or it could suddenly stop the car on the highway.

I came out this morning and I have a crack in my windshield that goes from the bottom of the glass up and over to towards the driver side. There does not appear to be any visible signs of impact that caused this crack.

1. The Subaru Outback OEM windshield has cracked and had to be replaced 3 times, so we are currently on our 4th windshield in just 2 years. The car has about 50k miles on it. 2. It is difficult to see through a broken windshield and puts us and others in danger. 3. Yes, the dealer has admitted that Subaru Outback windshields crack frequently and nothing has been done about it. 4. The manufacturer has ignored the issue. 5. No warnings that the windshield would break this frequently.

The windshield cracked from bottom of passenger side to the center of glass for no reasons, while the car was fully stopped, without any external impact. There were no harms caused to passengers, but it is concerning because the windshield could crack anytime without external impact. This didn't get recognized by dealership as a defect, they claim it was due to external impact. Yes, dealership has inspected the vehicle. No warning lamps or messages or other symptoms of the problem prior to the failure.

After doing grocery shopping, I returned to the vehicle, loaded my purchases, and upon getting into the driver's seat, noticed a large "Y" shaped crack in the windshield. The crack wasn't there when I arrived at the store. I've owned the vehicle less than a week, bought it used with less than 14K miles on it.

Was just driving when I noticed my car was sounding louder than usual. Then when I stared it after running some errands it sounds like a bad engine nock. So I took it in for an oil change and they told me it was a cracked exhaust manifold. Also told me it fine to drive and shouldn’t cause further problems. Then I started to smell heavy exhaust smells inside the cab of the car. Now I have to drive it with windows down or risk passing out or dying

I live in New Jersey, I am leasing this vehicle and I have 9 more months to go for the 3 year lease to be over. I am planning to purchase the vehicle after the 3 years. On [XXX] my fiancé and I drove from New Jersey to Ohio and stood at my boyfriend's grandparent's home for 4 days. While being there we had not used the car for 2 days and it was parked at the family members drive way be we were using the grandfather's vehicle since he was showing us around. On [XXX], we were planning to go out and get some ice cream. As we walk to our car the windshield is cracked from the corner of the passenger side to almost the driver's side. We were not sure what to do, we call Subaru and the nearest Subaru was 1 1/2 away from where we were. We decided to go back home with the cracked glass and take it to a nearby dealer 9 hours away. We stood in a hotel half of the way and we didn't drive over 55 miles per hour because we were afraid to go any faster with a cracked windshield. We took our car dealer here in NJ on August 7th, they took at the vehicle, took pictures and they told us, they would probably get approval to replace it under warranty but that it would need approval. They informed us that the vehicle did not have any signs of being in an accidents or that the crack did not show any signs of the windshield being hit to by anything to cause the crack. As of now, August 19, 2024 we are still waiting for approval. I need my vehicle repaired by September, since I work as an elementary

When I sit in the front passenger seat, the airbag sensor icon sometimes says off and sometimes says on--even during the same trip. and even if I have not changed positions. This means I am at risk of bodily injury when the system does not recognize that I am in the seat because the airbag is not operative while I was in the seat. On 7/22/24 the Subaru technician found "no active or stored codes and "recalibrated passenger side front seat. Rechecked to verify air bag warning system is operating as designed." Nevertheless, the sensor does not always recognize that I am in the seat so I am still at risk. I am, by the way, an adult who is over 5 Ft but weighs 90 pounds. I bought the car for safety because Subaru touts safety in advertisements. I find that I am not safe because there is no airbag working much of the time. We have owned the car since mid-June 2024 and this happens multiple times in the car when I am in the passenger seat (I am adding a date for only one date below) but this happens multiple times--the majority of times I am in the passenger seat.

The contact owns a 2022 Subaru Outback. The contact stated that the windshield had cracked after an impact. The vehicle was taken to Safelite Auto Glass, where the windshield was replaced; however, the failure recurred. The vehicle was taken to the dealer, where the windshield was inspected, and the dealer confirmed that the windshield had cracked due to an impact. The vehicle was not repaired. The vehicle was taken back to Safelite Auto Glass, and the windshield replacement was covered by the Insurance provider; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and a case was re-opened. The failure mileage was approximately 16,000.

I had my car parked at my boyfriend's grandfather house in Ohio on Sunday, August 3 and 4 without using the car for 2 days. Today Sunday, August 4 at around 5PM, my boyfriend and I went to our car, because we were planning to go out for ice cream. When we notice a long crack on our windshield. The windshield is cracked and nothing hit it, the cracked extends from the passenger side of the of the corner side all the way to almost the side of the driver side. I read that this has been a problem with many Subarus. I would not have leased this vehicle if I knew this was an issue. It should be identified as a recall. Since I am away from home (New Jersey) and far away from a Subaru dealer, I have to get this windshield repair to get back home. I am going through my insurance to repair it. Please help me in getting to know what to do to get a refund of my deductible. Thank you.

Several months ago Subaru updated the software in the above mentioned systems. Ever since the systems have become overly sensitive to the point of locking breaks up on the highway, at highway speed, for no obstruction. This has taken me from highway speed to a complete stop in the middle of the number 2 lane on several occasions.

I was driving to work and a car kicked up a small rock that struck the lower left portion of my windshield. There was no chip created at the time. Several minutes later, I heard an audible pop and 4 - 6 inch long crack appeared in the same area. Within minutes, the crack traveled across the windshield and extended about one foot further. Within a few days, the crack extended to the middle of the windshield and traveled upwards towards the attachment point for the rear view mirror. It's long enough now where I'm worried about it interfering with Eyesight. When I examined the area where the stone impacted, I can see several very small pits where the rock hit, but each pit is probably no larger than 1/64th of an inch in diameter. Given the behavior of the crack and reports I've heard from others, I suspect that the glass is too thin and under stress the way it's mounted to the car. This fault has been reported over and over on social media and has cost owners many thousands of dollars to correct.

A tiny crack started at the top of the window butnothing impacted. Thenit slowlyintwo weeks crackeddown quickly on the windshield of the driver from passenger side. Again no rockhit itor anything else.It appeared quickly and spread. Our extra warranty shield protection doesnt coveritbutit seems almost like a factory defect.

My car has defective clear coat paint. Subaru recalled some units with defective paint because it resulted in improper windshield installation but not mine.

Second windshield cracked with no impact. This I’d the second time within a year that this has happened to me. Like last time the crack isn’t on the outermost layer, and if you run your finger along the crack it feels completely smooth. This is quite frankly unacceptable with how expensive these windshields are to replace.

I have replaced the windshield for a second time resulting from a (non-impact) stress fracture coming from the passenger side A Pillar. It seems to be exactly the same spot as previous. The crack is large enough to put a credit card in at the start then wanders in varying directions with a finer crack. This time an aftermarket glass was available which I was told is thicker and more durable that the OEM glass. I am told Subaru has extremely thin OEM glass which they are having industry problems with. If it has any significance there is a dent in the passenger door jam B-Pillar which was there from new and painted over. It seems to be a result of manufacturing robotics possibly. I do not know if this is a clue to two windshields stress cracking.

Windshield glass broke spontaneously and randomly with no impact associated with the crack. The crack extends all the way across the windshield.

Went out to driveway and started car. Heard a ping. a few minutes later the windshield started to crack from drivers side bottom corner upward across the field of vision. At first it was about a foot long but spread to about 3 feet. No sign of impact.

This is in response to your boilerplate letter of May 25, 2024. That correspondence stated that my 2022 Subaru Outback’s inspection of May 21, 2024, did not reveal any manufacturing defect that caused the unanticipated acceleration of my vehicle on April 26, 2024. That inspection was conducted by a third-party engineering firm. In amplification of this, the following is provided: • My vehicle on 26 April 2024, at approximately at 0845 AM experienced unanticipated acceleration, in my garage where it had been parked overnight. It was a cool morning. This occurred without any direct body movement from me, whatsoever. The fast forward motion I directly experienced in my vehicle was like if one put their gas pedal to the floor. The vehicle crashed about five feet into a garage shelf with me simultaneously providing braking. This directly caused about $3,000 worth of damage to the vehicle, and I will probably incur higher insurance cost because of this. •Environmental factors have been a contributing factor in unanticipated acceleration in the past. •Time to extract the data from the EDR in my vehicle took almost one month for SOA to complete the inspection (accident occurred on April 26 and the vehicle inspection took place on May 21). •Starlink, Subaru’s automatic collision notification system, did not activate on 26 April 2024, the day of the accident. •“As a rule of thumb, if the crash is sufficient to cause the air bags to deploy the EDR data are usually captured.” From the Na

On may 13, 2024 windshield on the Outback I own sustained a stress crack and the satellite and Subaru retailer confirmed it is a stress crack. Upon my research I noticed I’m not the only one there are hundreds of other people who have faced same safety problem and Subaru Customer Advocate department doesn’t do anything about it.