2020 Subaru Outback complaints

The automatic lifting of the rear trunk opens as it should, but then will start to close on you out of no where without pushing the close button. It is terrifying because it doesn’t sense a body there. The screen in the center console also will become inaccessible and black out making it impossible to use the touch screen. The usb ports/ connecting to iPhone will disconnect making Bluetooth unavailable. Extremely difficult when needing gps or on the freeway

On 2/20, a crack appeared across the drivers side of my windshield while my car was parked. The crack is approximately 15" long extending from the lower side of the windshield, curving up toward the middle of the windshield. The crack is significant enough that it will require replacement.

Rear hatch opens while driving. It will not lock nor will it auto close. The dealer, Pine Belt Subaru, Lakewood, NJ, tried to fix it, but it happened again one week later. A very dangerous situation. A complete replacement of the hatch's lock may solve the problem .

Heated windshield area where the windshield wipers are shorted out and caused the windshield to crack

Starting in September of 2023, my 2020 Subaru Outback began having issues with the battery. After replacing the battery, having the vehicle died, being left stranded in unsafe scenarios, paying for , and associated repairs, I was told the DCM panel was found to be faulty and causing repetitive battery drainage and failures. The DCM is trying to connect to an old network without success causing the battery failure. This occurred twice in September, once in December, and three times in January of 2024.

I have had to replace the battery 2 times. Dealer has replaced once ~1 year of purchase. I replaced the battery ~3.5 years after purchase.

- Driver and Passenger window stuck down (won't close) in extreme cold temperatures - I feel my safety is at risk because I had to drive my car miles in frigid temperatures with my window stuck open. - My dealership acknowledged the problem, but were not able to reproduce it as it was 59 degrees when I took it in. - My vehicle was not inspected by anyone other than the dealer - I had no warning of the problem I have a 2020 Subaru Outback Limited. Since I bought the car, there have been multiple incidents where the driver or passenger window got stuck open after being rolled down on very cold days. Several years ago ,shortly after I bought it, my Subaru dealer explained to me this was happening because Subaru changed the rubber content in the window gaskets to a harder rubber. Then, when there is dirt on the insides of the gasket, the gasket drags on the window and the actuator opens the window because it thinks it detected it was closing on something it was not supposed to close on. The fix to be able to close my window was to take a screwdriver and a T-shirt or thin towel to clean the insides of the gasket that touches the window. Subaru knows about this problem. As this is a safety hazard and dangerous in cold weather, I do not understand why there has not been a recall. I took my car to the dealer today. I was told that it should not happen again if I keep the gaskets clean. As a Subaru is supposed to be made for offroading and extreme weather conditions, I would think tha

I sent a complaint yesterday, I would like to add this to the complaint [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting defective windshield. I’ve had windshield replaced 3 times when just the tiniest pebble tinged. My daughter also has a Subaru Outback and 3 windshields replaced. There must be a defect. Now that we have replaced the windshield several times, State Farm insurance has dropped us because of the number of claims. Most definitely a danger when a tiny people shatters the glass and pieces of the glass hit your face and eyes. If there is another agency I should report this, kindly let me know. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Infotainment center freezes making controls inaccessible. I live in the desert where temps reach 120+ in the car and not being able to turn on the AC is dangerous. - Windows will not roll up once they are rolled down, especially after it has rained or after washing the car. - Driver side Door Sensor Switch broke. This would keep the interior lights and infotainment center from turning off.

I noticed when the weather is wet, closing the front windows is slow. This kept advancing and now it won't close at all. Today, 12/28/2023 it wouldn't even come up more than half an inch then goes back down. Done some online research, and lots of people are reporting this with several Subaru models and dealers only say it needs lubrication.

The windshield is ridiculously susceptible to cracks. I’m on my third windshield in 4 years. I had the windshield last replaced in October and had a new crack within a month. I didn’t even notice anything hitting the windshield with this last crack.

The contact owns a 2020 Subaru Outback Premium. The contact stated that while the vehicle was parked in the garage, the contact noticed the front windshield was fractured. The contact stated that the crack was in the middle of the windshield which was the same area that the previous windshield fracture had occurred. The contact stated that the front windshield had been replaced two times previously due to the same failure and this incident is the third occurrence. The vehicle was taken to the dealer and the contact was informed that the failure was due to the windshield glass being too thin. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 39,000

On 12/6/2023, as I slowly turned right into a parking space, my car suddenly surged forward and accelerated without my input to the gas pedal. The brakes did not work, and there was no resistance from the brake pedal when I repeated to push it. The car continued to accelerate for about 80 ft as I focused on steering to avoid hitting other cars parked in the lot. The car ran over a curb, up a grassy area, and crashed into a row of trees. The airbag did not deploy. I sustained neck muscle strain/whiplash, and bruises to my chest and right knee. My safety was at risk, as well as anyone or anything that was in the car's path since I had no control over the acceleration or the brakes. The car is a 2020 Subaru Outback with about 44000 miles. It is in a body shop and they have not yet determined if it is safe to work on. So far, they have observed the engine race when the car was turned on. There were no warning signs prior to the acceleration. When I called the Subaru dealer service department, I was told that they never heard of this before and it had to have been my fault. They said I could bring it in after the body damage is repaired, and that I can pay for a diagnotic report. However, they expect that the report will not show anything.

A well-known failure of the Thermal Control Valve (TCV) occurred, which disabled many or most of the safety features on the car in addition to crippling the heat output in the cabin. Additionally, depending on which way the valve sticks, it could overheat the car and ruin the engine, or worse. Car is under 4 years old and repair estimate is nearly $1900. There is a technical safety bulletin [XXX] that outlines a redesigned TCV. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Thermo Control Valve assembly has failed resulting in loss of use for the following: Rear Automatic Brake, Eye Sight lane keeping, loss of heat in cabin and failure of coolant to circulate within engine possibly leading to engine failure, loss of cruise control and check engine light coming on. Reference TSB [XXX] . Without cabin heat vehicle is not useable in current cold temperatures (Currently 22 degrees Fahrenheit in Ohio on December 14, 2023). Dealer has confirmed part failure. Issue must be addressed to continue operating vehicle so I paid $1185.87 out of pocket to repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car lurches when put into gear, Transmission make loud chirping noise when place into gear from park, vehicle shudders when turning. Car has had all recalls updated. Symptoms have been reported to two different dealers. Dealer in Traverse City MI indicates this is "normal". Issue has continued since first noticed.

The automatic braking system detection the RB system as it’s identified on the Subaru Dash heater, failure airbag deployment, all disabled repeatedly removal of the battery connections for a period of 30 minutes reset it but failure has repeated

On November 21th, 2023, we were driving on a 30 mph street at 8:00 pm with no traffic and our automatic emergency braking system deployed on our 2020 Outback, we jolted to a stop for no apparent reason. This could have been dangerous if a car was behind us. Just had our oil changed with free inspection at Miller Hill Subaru 1 week prior. First incident. Will have the dealership inspect ASAP. The "Auto Start /Stop No Activity Detected" indicator message light came on afterward.

Automatic Braking system has almost caused a rear-end collision 5 times, because it thinks a shadow is an object. We’ve brought the car to the dealership but they told us twice that they can’t replicate the problem. That doesn’t change the issue. I don’t want to wait until we have a collision and have to go through physical therapy and repairs to address this. Front headlights are blinding other drivers causing them to flash their brights at us regularly on the freeway and local roads which then blinds us and causing us to slow down and break. The dealership say that the lights can be adjusted but this is a serious risk to us and something that happens every night. It’s stressful to drive the car anticipating this all the time. We’ve replace the starter last year and having issues again. The car struggles to start. Last year they said this was a known issue and also replaced the battery. But it’s happening again. This indicates a more complicated issue in the electrical. I don’t want to have to replace the starter every year.

Thermo control valve broken. Leaves no heat to cabin.

Per Subaru there is something wrong with the Cockpit Control Module (CCM) that is causing a constant / parasitic draw on the battery. This results in the battery being dead within 4 hours, leaving us constantly stranded. Because the CCM also controls the electrical system, many of the safety features (auto breaking, lane departure, etc) turn off randomly. This is the diagnosis from our local Subaru dealership: COCKPIT CONTROL MODULE IS DRAWING 2 AMPS. WITH COCKPIT UNPLUGGED THERE IS STILL A 1 AMP DRAW. WILL NEED TO REPLACED CCU THEN FIGURE OUT WHERE THE OTHER 1 AMP DRAW IS. UNABLE TO DIAGNOSE WITH MULTIPLE SYSTEMS DRAWING I have opened a case with Subaru of America, but with no resolution.

Thermal control valve failed leading to temperature problems and loss of safety features such as automatic braking and adaptive cruise control otherwise known as “Eyesight”

Rock hit windshield and cracked Need to be replaced

The factory 2020 Subaru Outback Wagon is built with a Thermo Control Valve that is, essentially, made out of a composite plastic. As this part is part of the engine cooling system, it is placed under both heat and pressure. While it controls the anti-freeze to the heater core in the passenger compartment, it is also attached under cover to metal fittings. While the car now has about 90,000 miles, this control valve cracked and began to leak anti-freeze on top of the engine. Without cooling, the engine would likely be ruined. Thus, the car required immediate service. When a fault like this occurs, by the way, the Subaru Eyesight System shuts down taking with it various safety features. I had the defective part replaced and it's replacement is not made of composite plastic but, rather and more appropriately, metal. It is my belief that the selection of the orignal part was a design defect ignoring the potential for differential expansion of the parts when exposed to such temperatures. Failure was inevitable. It is worth noting this is not an inexpensive repair as numerous parts have to be removed to access this valve. Likewise, the service representative made note that numerous other customers have had to have the same service.

Thermocontrol valve

The contact owns a 2020 Subaru Outback. The contact stated that while driving approximately 60 MPH, there was a cracking sound coming from the windshield. The contact stated that the windshield cracked without impact. The vehicle was taken to the dealer however, the windshield was not replaced. The manufacturer was made aware of the failure and opened a case to assist with the cost of the windshield replacement. The approximate failure mileage was 72,000.

I was driving and car accelerated without warning. Hit partially open garage door, only stopped after hitting and damaging back wall of garage. Significant damage to car, items in the garage and garage wall. There was no warning whatsoever. As of yet the car has not been assessed as to the cause of the malfunction.

The contact owns a 2020 Subaru Outback. The contact stated that the passenger’s side windshield was cracked without impact. The contact took the vehicle to the local dealer, where it was diagnosed with needing the windshield to be replaced. The vehicle was not repaired. The contact took the vehicle to the second local dealer: Stocker Subaru (1454 Dreibelbis St, State College, PA 16801), where it was diagnosed with needing the windshield to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 29,000.

While we were at a speed of about 55 mph on a state highway, I had just selected cruise control when all the lights went on in the dash--including the warning lights for the brake, the check engine light--and power shut down in the vehicle as if we'd run out of gas. We were able to keep a very slow speed of about 20-25mph, but had to activate the 4-way flashers to alert other drivers that we were losing speed. We managed to get over to the shoulder and call for a tow. We feel this was a catastrophic failure of the vehicle, which endangered both of us. At least we still had power steering. At the dealer, the techs advised us that the issue was likely due to a failure of the electronic thermostat control. The car was in the shop for a week, and was repaired at no cost to us. The thermo control valve and all related parts were replaced. If not under warranty, this would have cost over $2K. We had no warning that this component was failing.

When in reverse, the view behind the vehicle when using the rear camera display is poor when there is a shadow behind the vehicle making it difficult to see a person, especially a child. The rear view camera in my 2016 subaru Outback did not have this problem with shadows.

Windshield developed a crack for no apparent reason on the lower passenger side. Car was parked. Only unusual circumstance is that was a hot day.

The contact owns a 2020 Subaru Outback. The contact stated that while in the driveway, the vehicle was started and while driving out of the driveway, the windshield cracked without impact. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 38,000.

I purchased the lease for the vehicle in January 2020. I first notified Subaru in Austin of an obvious "glitch" with the computer operating system in April 2020. The "glitchy" OS challenges came and went, I would notify Subaru and they would remedy the issue with a "patch" update at the service center. On April 29 2022 a clear night and a suitably clean vehicle, the RAB system completely failed to recognize/notify/respond to a mailbox behind me, upon impact the mailbox broke the rear windshield. on June 28 2022 the vehicle fails to start, and is "surging" completely draining a new jumper box, and then promptly burning it out, the box will no longer operate. Put in a new battery(#1), make an appointment for service on the vehicle. The dealership replaces the battery(#2), computer updates are completed. Vehicle goes to the body shop for the rest of the work to be completed. 28 days later, I arrive to pick up my vehicle, all work is complete. However the vehicle will not start (again) Auto body shop replaces the battery(#3).on 9/23/2022 after dark, my Subaru Outback 2020 Limited, stops and puts its Parking break on., all dials spike, then dies, rear hatch signal goes off continuously, regardless of its actual state of open/close. The vehicle refuses to jump with a new jumper box. Outback 2020 is successfully jumped by a newer vehic. New battery installed(#4). 9/29/2022 another appointment at Subaru service center to look at my vehicle, they swap out the battery(#5) and update co

At one year and 7,358 an engine oil leak had to be repaired, and still seepage and monitor is recommended. Then at three years and 28,175 the coolant bypass valve failed and was repaired. Both problems were covered by warrently, but as I live 60 miles from the dealer it was a hassle. I bought the car new in March 2020. I can not recommend Sabaru to people who ask about it and it is highly unlikely I would purchase another Subaru. However it is comfortable and practical and do not plan to sell or trade it for another car at this time. Now at four months after the latest repair it appears to be doing well, and I monitor the oil level.

Car lurches when put into gear, Transmission make loud chirping noise when place into gear from park, transmission shudders when turning. Car has had all recalls updated. Symptoms have been reported to dealer numerous times. Currently vehicle is at Subaru Dealer in Temecula Calif. Dealer states a know transmission problem is being addressed thru a Subaru Engineer. Have been without the vehicle for approx 3 weeks.

The windshield in my 2020 Subaru Outback has cracked spontaneously twice. I had 75K Bumper to Bumper Warranty, which the dealer would not honor the first time the window broke. He said that it was warranted for repair, not replacement. I argued until he gave me a 50% discount. My windshield broke again today. I had just pulled out onto the street and was traveling about 10MPH. No rocks or stone touched the windshield. The sound of the crack startled me. I thought that there had to be an issue. Consequently as I looked online, I have discovered this is a design flaw or something as the problem is widespread. Two cracks in year is not right and it is expensive.

The contact owns a 2020 Subaru Outback. The contact stated that while seated in the parked vehicle in the garage with the vehicle turned off, the contact watched as the passenger’s side windshield cracked without impact. The contact stated that the crack extended approximately two feet. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The contact stated that the front windshield had previously been replaced due to the same failure. The failure mileage was 42,000.

My vehicle stalled abruptly as I came to a stop while driving on a slope. Shortly afterward I determined that this was caused by a loose battery terminal; the battery had been replaced a day earlier. This much was the fault of the mechanic, not the manufacturer. My complaint is with respect to the state which the vehicle failed into: 1. The gear shift was stuck in drive and could not be moved into park. 2. It was not possible to engage the parking break, as it can only be controlled by an electronic switch. 3. The steering wheel column was locked. As a result of this, the only way to prevent the vehicle from rolling backward down the hill was to continuously keep my foot on the brake. It also was not possible, as a result of the locked steering wheel column, to guide the vehicle downhill safely. I was stuck holding the brake and unable to get out of my vehicle until another motorist stopped to give me a jump and enable me to engage the parking brake.

The contact owned a 2020 Subaru Outback. The contact stated that while coming to a complete stop at a red light, an abnormally loud noise was heard coming from the vehicle, and then black smoke came from underneath the driver's side hood. Additionally, a fuel odor was detected while driving. No warning light was illuminated. The contact parked and exited the vehicle with two minor passengers while flames erupted from the engine compartment. No injuries were sustained, and no medical attention was received. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was 44,882.

The contact owns a 2020 Subaru Outback. The contact stated that two months after purchasing the vehicle new, the windshield cracked upon sustaining a light impact. Additionally, the contact stated that the windshield had also cracked from cold air inside the vehicle and the hot air outside the vehicle. The contact also stated that a tiny crack on the windshield would significantly expand within hours. The contact stated that the windshield had been replaced three times by the dealer, and the repair was covered by the insurance; however, the failure kept recurring. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 35,500.

I had a fault/issue with the Electronic Parking Brake on my 2020 Subaru Outback that resulted in a vehicle fire. I had set the electronic parking brake, and received a warning light. I retracted the electronic parking brake and the warning light disappeared. I did this twice. The warning light stayed off. I drove the car and the passenger rear brakes caught on fire, damaging the brakes, the electronic parking brake motor, the brake caliper, the wheel bearing, the ABS sensor and all wiring to that wheel. I had the vehicle towed to the dealer. The dealer had the vehicle for over 2 months. In that time, my insurance inspected the vehicle. The dealer inspected the vehicle. The dealer had a Subaru (Subaru of America) factory tech visit and inspect. Subaru factory sent out a second tech (from quality control) to inspect the vehicle. The dealer tech and both Subaru factory techs could not determine the root cause of the failure. Subaru replaced all components damaged in the fire (at my cost) and sent me on my way without a determination of what caused the issue. Issue was well documented here... https://www.subaruoutback.org/threads/parking-brake-fault-caught-on-fire.551030/ I have attached a scan of the Subaru Dealer repair order.

The contact owns a 2020 Subaru Outback. The contact became aware of a crack on the center of the front windshield. The contact stated that there was no impact to the windshield to cause the crack. The vehicle was not inspected, and the windshield was not replaced. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was 47,900.

I am replacing 3rd windshield since September 2022. This was definitely caused by a rock chip but had been resin repaired. With defroster blowing on a cool morning the windshield cracked across the lower portion. The replacement windshield cracked for no reason other than it was cold during a December night and was replaced in April. That windshield cracked spontaneously while driving in the rain one month after install. A Subaru dealer took photos or I have sent photos to them of all incidents for submission to my Subaru insurance. I have now met the maximum allowed for windshield replacement. All windshields were replaced at an authorized Subaru dealer.

While driving my Subaru Outback, I encounter a problem where the Starlink Multimedia system abruptly goes black. Shortly after, the driver information center also goes black. Although the car continues to run, the cruise control, if engaged, and the EyeSight safety system shuts off as well. Both systems then undergo a reboot.

While driving on the NYS Thruway (I90), I started to pass a Tractor Trailer, I put my blinker on and began moving to the right to pass. There were 2/3 cars in back of me also passing. I was using cruise control and I began to put my foot on the accelerator to finish my passing and move over to the right hand lane to let the other vehicles pass me. However, upon accelerating, my car started to drop power, multiple lights displaying simultaneously indicating a potential problem. (Eyesight Assist, Vehicle Dynamic Control, Brake & Engine Lights), the vehicle started jerking back and forth and I lost all but maybe 5 miles of power. My choice at that time was put my blinker on and try and move to the right - letting the Tractor Trailer pass me on the right and HOPE there was not another vehicle behind so I could move over safely at that crawling speed or go to the left into the gully. This could have been a multiple car collision and maybe fatalities due to the speed and loss of control of my vehicle. After towing to the nearest dealer, they determined it was the Thermo Control Valve. I see now that there is a "service bulletin" and design change of this component and that other Subaru drivers have been affected the same way. This is a very serious situation. I ask, why no recall from Subaru. I have been without my vehicle now for 4 days and may not have it back until next week. I am very fearful of driving that vehicle again.

The contact owns a 2020 Subaru Outback. The contact stated that while attempting to start the vehicle, the battery was completely drained. The contact stated that he was able to jumpstart the vehicle and continued to operate the vehicle. The contact stated no warning light was illuminated. The contact stated that the failure was intermittent but had become more frequent. The contact stated that he had not replaced the battery which was the original OEM battery. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that he needed to drive the vehicle more frequently. The vehicle had not been repaired. The failure reoccurred and the contact took the vehicle back to the same dealer who advised that there were no electrical failures and that he should return after one month to reprogram the computer. The manufacturer had not been informed of the failure. The failure mileage was approximately 8,000.

Over the course of the nearly three years I have owned my vehicle, the windshield has either spontaneously cracked or cracked from a very very small chip three times. Two of these occurred while I was driving, with no debris impact with the vehicle windshield. There have been several suits filed against Subaru for similar cases, including for the 2020 Outback model. This has been three times in about two and a half years, quadruple the amount for my previous vehicle. Not only is this a vision impairment while driving and a financial burden to fix, I also worry about more catastrophic failure should anything significant impact the windshield while driving. I have had the glass repaired twice, and both times the repair technicians could not understand how such a significant crack had occurred.

While driving on I-26, a small rock made an initially small crack in the windshield. Over time, while still driving, we watched the crack expand larger and larger, spreading with multiple new arms across the entire passenger side of the windshield. After parking at home in the garage and scheduling windshield replacement for the next day, we continued to notice the crack continuing to propagate further into the driver side. The incident happened on 5/21/23 and the windshield was replaced on 5/23/23.

-The windshield has cracked in the same place for no apparent reason. -The cracked windshield can affect the use of the safety systems built into the windshield. -I'm not sure how this can be "reproduced" as we are talking about a broken windshield although the windshield has been fixed already once and now, the second break has occurred. -Not inspected but replaced once. It is currently broken and can be inspected again if need be. -The first one appeared in August 2022, the second in May 2023