2009 Spartan Gladiator

Defect. Marion Body Works Inc. (Marion Body Works) is recalling certain 2005-2020 Emergency Response Gladiator and Metrostar vehicles equipped with pneumatically-controlled automatic tire chain systems. The air pressure control lines may not be pressure-protected.

Risk. Without the control line being pressure-protected, in the event the control line is severed, air may suddenly be lost from the service reservoir system, causing the brakes to apply unexpectedly, increasing the risk of a crash.

Remedy. Marion Body Works will notify owners, and dealers will inspect the routing of the control lines, rerouting them into the auxiliary air reservoir as necessary, free of charge. The recall began November 22, 2019. Owners may contact Marion Body Works customer service at 1-715-754-5261 or Spartan customer service at 1-800-543-5008.

Defect. Spartan Motors USA (Spartan) is recalling certain 2004-2020 Emergency Response Gladiator and Spartan vehicles equipped with a pneumatically-controlled automatic tire chain system. The air pressure control lines may not be pressure-protected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Risk. Without the control line being pressure-protected, in the event the control line is severed, air may suddenly be lost from the service reservoir system, causing the brakes to apply unexpectedly, increasing the risk of a crash.

Remedy. Spartan will notify owners, and dealers will inspect the routing of the control lines, rerouting them into the auxiliary air reservoir as necessary, free of charge. The recall began October 4, 2019. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 19017.

Defect. Spartan Motors USA (Spartan) is recalling certain 2004-2016 Emergency Response Gladiator Tractor Drawn Aerial vehicles. Cracks may develop and extend into the vertical portions of the tiller frame, resulting in instability of the aerial device.

Risk. If the aerial device becomes unstable, the device may fall, increasing the risk of an injury.

Remedy. Spartan will notify owners, and dealers will inspect and correct any cracking, and add reinforcements to prevent any possible future cracking, free of charge. The recall began May 13, 2019. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 19007.

Defect. Spartan Motors USA (Spartan) is recalling certain 2001-2019 Spartan MetroStar and Gladiator emergency vehicles. The mounting fasteners for the Emergency Medical Service (EMS) cabinets may not be the correct size, allowing the cabinets to break free from their mountings in the event of a crash.

Risk. If the EMS cabinets become loose during a crash, the cabinets may become projectiles, increasing the risk of injury.

Remedy. Spartan will notify owners, and dealers will replace the incorrect size fasteners with the correct fasteners, free of charge. The recall began November 30, 2018. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 18030.

Defect. Spartan Motors USA (Spartan) is recalling certain 2009-2018 Gladiator and MetroStar emergency vehicles. The fire water pump solenoid may corrode internally, causing a loss of power to the pump control module.

Risk. A loss of power to the pump control module can cause a loss of water pressure for fighting fires, thereby increasing the risk of injury.

Remedy. Spartan will notify owners, and dealers will replace the solenoids, free of charge. The recall began on August 7, 2018. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 18019.

Defect. Spartan Motors USA (Spartan) is recalling certain 2001-2018 Spartan Gladiator, Diamond, MetroStar, and Advantage emergency response vehicles. The affected vehicles may not be equipped with a pressure protection valve installed between the air reservoir and the lubrication control module. If the air line were to become disconnected between the lubrication control module and the air reservoir, a loss of air to the air brake system could occur. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Risk. A loss of air to the air brake system could increase the risk of a crash.

Remedy. Spartan will notify owners, and dealers will inspect the vehicles and install a pressure protection valve, as necessary, free of charge. The recall began on June 26, 2018. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 18017.

Defect. Spartan Motors USA (Spartan) is recalling certain 2008-2017 Gladiator and MetroStar emergency response vehicles equipped with a supplemental park brake system (SPBS). The directions to activate the SPBS incorrectly state to "Pull" the actuation knob, when it should say "Push."

Risk. If the operator follows the incorrect directions and believes that the supplemental front park brake is applied when it is not, the vehicle may unexpectedly roll, increasing the risk of a crash.

Remedy. Spartan will notify owners and supply a new actuator control knob with the correct directions, free of charge. The recall began on May 22, 2017. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 17009.

Defect. Spartan Motors USA (Spartan) certain model year 2004-2010 Emergency Response Gladiator tractor drawn aerial fire apparatus vehicles manufactured November 18, 2004, to July 26, 2010. The tiller frame of the affected vehicles may crack near the outriggers.

Risk. If the tiller frame fully cracks, the vehicle may be unstable, increasing the risk of injury to someone on the ladder.

Remedy. Spartan will notify owners, and dealers will install reinforcements plates, free of charge. The recall began on November 18, 2016. Owners may contact Spartan customer service at 1-800-543-5008.

Defect. Spartan Motors USA (Spartan) is recalling certain model year 2004-2016 Gladiator tractor-drawn aerial emergency vehicles manufactured September 12, 2004, to September 30, 2015. The air brakes on these vehicles may have excessive actuation and release timing, lengthening the distance needed to stop the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Risk. If a longer distance is needed to stop the vehicle there would be an increased risk of a crash.

Remedy. Spartan will notify owners, and dealers will repair the vehicles with a new 3/8" control line, free of charge. The recall began on August 15, 2016. Owners may contact Spartan customer service at 1-800-543-5008. Spartan's number for this recall is 16017.

Defect. Spartan Motors USA (Spartan) is recalling certain model year 2009-2014 ER Gladiator and MetroStar vehicles manufactured January 5, 2010, to January 19, 2015. In the affected vehicles, the power steering fluid may overheat and cause the steering to unexpectedly lock during steering maneuvers.

Risk. If the steering locks, there could be a loss of control of the vehicle, increasing the risk of a crash.

Remedy. Spartan will notify owners, and dealers will install a cooler to prevent the steering fluid from overheating, free of charge. An interim notice was sent to owners on December 17, 2015. The recall began on November 7, 2016. Owners may contact Spartan customer service at 1-800-543-4277.