Daimler Trucks North America: Equipment › Other › Labels
Daimler Trucks North America reported this defect to federal regulators on Mar 30, 2011 and put the number of vehicles at risk at 526. The repair is free for as long as the recall stands.
The defect
CERTAIN MODEL YEAR 2000-2003, 2005 AND 2006 THOMAS BUILT MINOTOUR SCHOOL BUSES BUILT ON FORD AND GM CHASSIS FROM APRIL 17, 2000, THROUGH AUGUST 29, 2008. THESE BUSES WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
The risk
INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
The remedy
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL BEGAN ON MAY 24, 2011.
9 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2008 Thomas Built Buses Minotour | 0 | 20 | 0 | 0 |
| 2007 Thomas Built Buses Minotour | 0 | 23 | 0 | 0 |
| 2006 Thomas Built Buses Minotour | 0 | 22 | 0 | 0 |
| 2005 Thomas Built Buses Minotour | 1 | 14 | 0 | 0 |
| 2004 Thomas Built Buses Minotour | 0 | 12 | 0 | 0 |
| 2003 Thomas Built Buses Minotour | 0 | 9 | 0 | 0 |
| 2002 Thomas Built Buses Minotour | 0 | 7 | 0 | 0 |
| 2001 Thomas Built Buses Minotour | 0 | 3 | 0 | 0 |
| 2000 Thomas Built Buses Minotour | 0 | 4 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 11V204000.
Full record for the 2008 Thomas Built Buses Minotour → · Recalls carrying a do-not-drive advisory → · Where this data comes from →