Wabash National Corporation: Service Brakes, Air › Slack Adjusters › Automatic
Wabash National Corporation reported this defect to federal regulators on Mar 21, 2011 and put the number of vehicles at risk at 5,200. The repair is free for as long as the recall stands.
The defect
WABASH IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 VANS MANUFACTURED FROM OCTOBER 15, 2010 THROUGH JANUARY 31, 2011, AND EQUIPPED WITH GUNITE AUTOMATIC SLACK ADJUSTERS. DUE TO AN INCOMPLETE "KNITTING" OF THE IRON AT THE TIME OF CASTING, INADEQUATE STRUCTURAL INTEGRITY OF THE SLACK ADJUSTER HOUSING CAN OCCUR, WHICH COULD CAUSE THE HOUSING TO BREAK AT THE HANDLE UNDER NORMAL OPERATING LOADS.
The risk
SLACK ADJUSTERS WITH THIS FLOW NOTCH COULD CRACK UNDER NORMAL BRAKING CONDITIONS CAUSING LOSS OF BRAKING WHICH COULD RESULT IN A VEHICLE CRASH.
The remedy
WABASH WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE SUBJECT SLACK ADJUSTERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 12, 2011. OWNERS MAY CONTACT GUNITE CUSTOMER SERVICE AT 1-800-677-3786 OR WABASH AT 765-771-5605.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2011 Wabash National Van | 0 | 2 | 0 | 0 |
| 2010 Wabash National Van | 0 | 2 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 11V188000.
Full record for the 2011 Wabash National Van → · Recalls carrying a do-not-drive advisory → · Where this data comes from →