Blue Bird Body Company: Structure › Body
Blue Bird Body Company reported this defect to federal regulators on Dec 17, 2009 and put the number of vehicles at risk at 223. The repair is free for as long as the recall stands.
The defect
BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2010 ALL AMERICAN D3 FRONT ENGINE MODEL SCHOOL BUSES MANUFACTURED FROM AUGUST 13, 2009 THROUGH OCTOBER 24, 2009. ADHESIVE FOR THE INSIDE PANELS ADJACENT TO THE REAR CENTER EMERGENCY DOOR WAS OMITTED FROM THE JOINTS. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH."
The risk
WITHOUT THE REQUIRED ADHESIVE, THERE IS AN INCREASED RISK OF INJURY TO THE BUS OCCUPANTS IN THE EVENT OF A CRASH.
The remedy
BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 12, 2010. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.
1 model year covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2010 Blue Bird All American D3 | 1 | 3 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 09V481000.
Full record for the 2010 Blue Bird All American D3 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →