Piaggio USA, Inc.: Fuel System, Gasoline › Carburetor System
Piaggio USA, Inc. reported this defect to federal regulators on Jan 30, 2009 and put the number of vehicles at risk at 1,260. The repair is free for as long as the recall stands.
The defect
PIAGGIO IS RECALLING 1,260 MY 2008-2009 APRILIA SCARABEO 200 MOTORCYCLES. THE FLOAT LEVEL IN THE FLOAT BOWL OF THE CARBURETOR WAS NOT SET CORRECTLY IN PRODUCTION, DIRT AND THE VARNISH RESIDUE OF DRIED GASOLINE NOT ALLOWING THE FLOAT NEEDLE TO SEAT CORRECTLY, AND A BLOCKAGE OF THE EVAPORATIVE EMISSION HOSES THAT DID NOT ALLOW THE FLOAT BOWL TO VENT CORRECTLY. THE CARBURETOR WAS NOT ABLE TO MAINTAIN CORRECT OR CONSTANT PRESSURE IN THE FLOAT BOWL. INCONSISTENT PRESSURE IN THE FLOAT BOWL WOULD EITHER PUSH TOO MUCH OR NOT ENOUGH FUEL TO AND THROUGH THE JETS FOR ANY ONE THROTTLE POSITION WHICH DOES NOT ALLOW THE CARBURETOR TO CORRECTLY METER FUEL TO THE ENGINE.
The risk
FUEL FLOODING THE ENGINE, CAUSING DIFFICULT IN STARTING AND POOR PERFORMANCE. IT IS ALSO POSSIBLE FOR FUEL TO LEAK FROM THE CARBURETOR ONTO THE GROUND. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The remedy
DEALERS WILL RE-CONNECT THE HOSES TO ELIMINATE THE CONNECTION OF THE EMISSIONS SYSTEM TO THE CARBURETOR. THIS REMEDY IS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT PIAGGIO AT 1-212-380-4431.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2009 Aprilia Scarabeo 200 | 2 | 2 | 0 | 2 |
| 2008 Aprilia Scarabeo 200 | 0 | 2 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 09V034000.
Full record for the 2009 Aprilia Scarabeo 200 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →