Paccar Incorporated: Trailer Hitches › Fifth Wheel Assembly
Paccar Incorporated reported this defect to federal regulators on Apr 25, 2008 and put the number of vehicles at risk at 3,573. The repair is free for as long as the recall stands.
The defect
PACCAR IS RECALLING 3,573 MY 2007 KENWORTH C500, T800, T600, T2000, AND W900 CHASSIS BUILT WITH PHILLIPS QCS II TRAILER CABLE CONNECTION AND TRAILER CABLE MOUNTING BRACKET WITH 'U-SHAPED' CUT OUT. CERTAIN TRAILER CABLE MOUNTING BRACKETS HAVE A 'U-SHAPED' CUT OUT THAT ONLY PARTIALLY SUPPORTS THE TRAILER CABLE CONNECTION. PARTIAL SUPPORT OF THE CABLE CONNECTION MAY ALLOW THE MOLDED BOOT AND ELECTRICAL GROUND PIN TO PARTIALLY OR COMPLETELY PULL AWAY FROM THE 7-WAY SOCKET. PARTIAL OR COMPLETE DETACHMENT OF THE CABLE CONNECTION CAN CAUSE REDUCED WATER RESISTANCE AND POTENTIAL LOSS OF ELECTRICAL GROUND. THERE IS ALSO A POSSIBILITY THE TRAILER LIGHTS MAY FAIL TO ILLUMINATE WITHOUT THE OPERATOR'S KNOWLEDGE.
The risk
IF THIS CONDITION WERE TO OCCUR, OTHER MOTORISTS MAY NOT BE WARNED OF THE TRACTOR/TRAILER MOVEMENTS, INCREASING THE RISK OF A CRASH.
The remedy
DEALERS WILL INSTALL A REINFORCEMENT BRACKET BETWEEN THE FLEXIBLE BACK OF THE QCS II MOLDED BOOT AND THE FRAME BRACKET, AND REATTACH THE SUPPORTING BOLTS. THE RECALL BEGAN ON MAY MAY 30, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440.
5 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2007 Kenworth C500 | 1 | 6 | 0 | 0 |
| 2007 Kenworth T2000 | 12 | 11 | 0 | 0 |
| 2007 Kenworth T600 | 1 | 14 | 0 | 0 |
| 2007 Kenworth T800 | 1 | 21 | 0 | 0 |
| 2007 Kenworth W900 | 2 | 17 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 08V190000.
Full record for the 2007 Kenworth C500 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →