Ez Loader Custom Boat Trailers, Inc.: Trailer Hitches
Ez Loader Custom Boat Trailers, Inc. reported this defect to federal regulators on Apr 27, 2007 and put the number of vehicles at risk at 3,600. The repair is free for as long as the recall stands.
The defect
CERTAIN BOAT TRAILERS UTILIZE A "SWING-TONGUE" ASSEMBLY, IN WHICH THE TONGUE OF THE TRAILER SWINGS ON A PIVOT TO ALLOW THE TRAILER TO BE STORED IN A SMALLER AREA. A FLAT WASHER WAS OMITTIED OR THE FLAT WASHER CAN FAIL, CAUSING THE PIVOT BOLT ASSEMBLY TO FALL THROUGH THE SWING TONGUE ASSEMBLY.
The risk
IF THE PIVOT BOLT ASSEMBLY FAILS, THE TONGUE IS LIKELY TO SWING OPEN AND COLLAPSE. IF THIS OCCURS WHILE THE TRAILER IS UNDERWAY, THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
The remedy
OWNERS WILL BE PROVIDED WITH A HARDWARE KIT AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE REPAIR INVOLVES REPLACING THE FRONT HINGE PIN WITH A REPLACEMENT HINGE PIN HARDWARE KIT FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2007. OWNERS MAY CONTACT EZ LOADER AT 800-553-7855.
36 model years covered
Newest firstWhat this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 07V187000.
Full record for the 2007 Ez Loader Alumacraft → · Recalls carrying a do-not-drive advisory → · Where this data comes from →