Ford Motor Company: Engine and Engine Cooling › Engine › Diesel
Ford Motor Company reported this defect to federal regulators on Dec 12, 2006 and put the number of vehicles at risk at 5,028. The repair is free for as long as the recall stands.
The defect
ON CERTAIN LOW CAB FORWARD CHASSIS TRUCKS, THE UNSEALED INJECTION PRESSURE REGULATOR CONNECTOR IS EXPOSED TO THE OUTSIDE ENVIRONMENT DUE TO ITS LOCATION ON THE BACK OF THE ENGINE AND THE ENGINE'S LOCATION IN THE VEHICLE. THE CONNECTOR HAS A HEAT INSULATION SLEEVE THAT MAY RETAIN WATER AROUND THE CONNECTOR.
The risk
OVER TIME, THE COLLECTED WATER MAY POTENTIALLY CORRODE THE CONNECTOR LEADS RESULTING IN VARIOUS ENGINE PERFORMANCE CONCERNS INCLUDING; RUNNING ROUGH, DIFFICULT OR UNABLE TO BE STARTED, OR ENGINE STALL INCREASING THE RISK OF A CRASH.
The remedy
DEALERS WILL REPLACE THE INJECTION PRESSURE REGULATOR CONNECTOR, INSPECT FOR CORROSION, AND REPLACE THE HEAT INSULATION. IF CORROSION IS PRESENT, THE CONNECTOR WILL BE REPLACED. IF CORROSION IS NOT PRESENT, DIELECTRIC GREASE WILL BE APPLIED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 13, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1 model year covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2006 Ford LCF | 2 | 3 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 06V471000.
Full record for the 2006 Ford LCF → · Recalls carrying a do-not-drive advisory → · Where this data comes from →