Girardin Minibus Inc.: Equipment
Girardin Minibus Inc. reported this defect to federal regulators on Feb 2, 2006 and put the number of vehicles at risk at 13. The repair is free for as long as the recall stands.
The defect
CERTAIN GIRARDIN 2004 AND 2005 MB IV SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN JULY 6, 2004, AND FEBRUARY 10, 2005, EQUIPPED WITH CARRIER COMPRESSOR MOUNT BRACKETS, P/N 86-62400-00. THIS WELD IS USED TO MOUNT THE SECONDARY COMPRESSOR FOR THE SUPPLEMENTAL AIR CONDITIONING SYSTEM ON TO THE ENGINE. IF THE INSTALLER DOES NOT ADEQUATELY TORQUE THE MOUNTING HARDWARE OR THERE IS A POOR QUALITY WELD AT THE WELDMENT'S SUPPORT TAB, THE WELDMENT CAN BREAK OR FALL OFF.
The risk
IF THE WELDMENT BREAKS OR FALLS OFF, THE COMPRESSOR AND VACUUM PUMP COULD SHIFT CAUSING THE MISALIGNMENT AND EVENTUAL LOSS OF THE DRIVE BELT, POSSIBLY RESULTING IN THE LOSS OF OR IMPEDANCE TO THE VEHICLE'S PRIMARY BRAKING SYSTEM, AND COULD POTENTIALLY CAUSE A VEHICLE CRASH.
The remedy
OWNERS ARE BEING INSTRUCTED TO CONTACT CARRIER AT 717-767-3359 OR VISIT THEIR WEBSITE AT WWW.TRANSICOLD.CARRIER.COM FOR FREE REMEDY. THE RECALL BEGAN ON FEBRUARY 15, 2006. OWNERS MAY ALSO CONTACT GIRARDIN MINIBUS SERVICE AND WARRANTY DEPARTMENT AT 819-477-8222.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2005 Girardin MB IV | 0 | 9 | 0 | 0 |
| 2004 Girardin MB IV | 0 | 9 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 06V027000.
Full record for the 2005 Girardin MB IV → · Recalls carrying a do-not-drive advisory → · Where this data comes from →